2013 HYUNDAI VELOSTER Electrical System Problems

On or about May 1, 2025, I was operating my 2013 Hyundai Veloster when flames were observed emanating from under the hood. I immediately pulled into the median and, upon opening the hood, observed an active fire beneath the plastic engine cover. I contacted 911. Before the fire department arrived, a passerby extinguished the flames with a fire extinguisher. Firefighters from a nearby station arrived shortly thereafter and fully doused the engine compartment. The vehicle was subsequently towed to a Hyundai dealership. At that time, I was aware of an active recall related to potential brake line issues that could result in an engine compartment fire. After the vehicle remained at the dealership for an extended period, I was informed that Hyundai Motor America (“HMA”) would send an inspector. Approximately 30 days later, I was contacted by HMA’s corporate office and asked to provide documentation, including a copy of the title and insurance information. During this call, I was advised that while repair or replacement of the vehicle was unlikely, HMA would “make me whole.” Shortly thereafter, I received written correspondence from HMA stating that, following its review of the inspection results, documents, and other information, no product defect was identified as the cause of the incident. The letter concluded that HMA would not accept responsibility and denied my request for assistance or compensation.

Smoke, burning smell came from ac control unit. Ac wiring unit, knob completely burned/melted. Reported to Hyundai local and corporate office no resolution other then I just have to replace the unit. Please note this happened in 2022 (40,000 miles today vehicle had 58,000miles) and I paid in full for the replacement the 1st time.

The knob for the A/C can not handle the amperage when in the 4 position, it gets too hot, melts, and shuts off the system. It is available for inspection. Hyundai is acutely aware of this problem and recalled it in other years, the same as their junk engines, but once again the owners of the 2013 are left out in the dark. This is a fire hazard that the manufacturer is trying to sweep under the rug, there are service bulletins out on it for other years.

See attached document for complaint.

Car started smoking on cabin while driving. Risk of hazard dueto bad A/C control switch. Wiring harness and plug melted too. Several Hyundai Veloster are suffering same issue. Started to think blower wiring is to small for load too. Pleaae see attached pictures. Time and miles provided is an approximate. Do not remember when exactly happened but was reported previously. In the pictures you are going to be able to see the faulty part P/N for your review.

The air conditioner knob doesn't work when I put it at 4. Took it apart and the wires are burn including the pigtail that holds the wires into the knob.

On October 17, 2024, owner was leaving Denver, CO on the highway and had to stop for traffic and vehicle wouldn't move. Was in drive but vehicle would not drive and pulled to side of road. Had insurance tow to nearest Hyundai dealership. Check engine light was on and dealership checked vehicle and needed to have the crankshaft position sensor replaced. Fixed the problem thank God and I was on my road shortly there after. My Veloster is 2013 with 47,000 miles at time of incident.

Vehicle is burning through oil without having oil light engaged. Vehicle is going through two quart + of oil every 3 weeks. Just added 2 quarts of oil 3 weeks ago when the car would not accelerate past 5mph and rough idled (this turned out to be caused by a different issue still being diagnosed), I added the oil as dip stick showed no oil on the stick. Light did not come on. Took to independent mechanic this week who stated I had no oil in the vehicle. Can not go 3 month/3000 miles for an oil change or the engine would be damaged. Have taken the vehicle several times to Valvoline who indicate no oil with no oil pressure light on, each time. This has been constant for 2 years. Each mechanic shop states the GDI engines are burning through oil. No oil leaks have been detected. This issue could result in serious engine damage.

First the turbo stopped working n smoking. Took it to the dealer n they had it for a month.. Get it back one day later had to have it towed . Vehicle was there for another 2 weeks got it back and it started to smoke. I pressed on the gas pedal n the car wouldn’t move! The first time the turbo was supposed to be replaced I believe ever since it was sent there to be replaced it was never the same. I still have the car and it will not start. The turbo n engine are filled with oils .

The Plug that connects to the AC control Unit is burned and damaged. In fact, When I replaced it its smells like smoke. It is the third time since 2018 that I changed the unit. I decided to officially make a complaint because I saw that this vehicles and exact models from 2014-2016 where included but My year not ( 2013). I called the Hyundai and they told me that I needed to buy the unit and go fix it in a dealer. I found it unfair because is a defect of the car not something People can make to the car. The campaing nunber is: 16-01-070 from december 2016 ( and my car where not included) The problem is not the unit is the plug that cames from the car that connects to the unit that melts and gets burned.( but the unit is damaged due to this)

The contact owns a 2013 Hyundai Veloster. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle was consuming 3 quarts of oil every 3,500 miles. Additionally, the contact stated that while driving at an undisclosed speed, she heard an abnormal sound and pulled to the side of the road. The contact stated that upon inspecting the engine oil level, there was no oil on the dipstick. The contact stated that the low oil pressure warning light failed to illuminate. The contact then pulled into the nearest gas station, where oil was added to the engine. The contact stated that the low oil pressure warning light had failed to illuminate while the engine oil level was low on several occasions. The dealer was notified of the failure and advised the contact that the low oil pressure warning was designed to illuminate when the oil level was 2 quarts low; however, the contact stated that the warning light had failed to illuminate. The manufacturer was notified of the failure and advised the contact to take the vehicle to the dealer for an oil consumption test. The vehicle was not repaired. The failure mileage was approximately 80,000.

Mileage: 80,000

The blower fan only blows slightly and the knob does not work. This was a known issue with the 2014, but not the 2013. This causes a significant safety concern to someone living in extreme heat, especially children and the elderly.

This complaint is regarding safety recall #23V651000 related to my 2013 Hyundai Veloster. In September of 2023, a potential problem with the ABS module was identified which could cause an engine compartment fire while driving or parked. It is now February, 2024, 5 months later and there is still no resolution. This is unacceptable. I am driving a vehicle which could result in personal property damage and/or personal injury or death. Being told to park the vehicle outdoors and away from structures is not a long term solution until the recall remedy is completed. How much longer am I, and others going to have to wait for a resolution to this issue?

I am concerned with the notice of a recall which I received June 2023 concerning a possible electrical fault in the ABS module which could cause a fire in the engine compartment. There is NO fix available . I called my local Hyundai garage and the Hyundai corp office and they both told me the same thing and that is they do not have a fix and do not know when one will be available' I find this unacceptable and stalling by the Hyundai Company I am told that I should park the car away from the house as it might catch fire wether the car is running or not. After 8 months i can only suppose the Hyundai Company is ignoring the problem because it will cost them money I would be most grateful if you could light a fire under Hyundai, so to speak, so that they will solve this problem [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2013 Hyundai Veloster. The contact stated that the HVAC system was inoperable. The vehicle was taken to the dealer to be diagnosed. The contact was informed that the wiring to the HVAC control switch was burned. The contact was informed that the vehicle was not included in NHTSA Campaign Number: 20V393000 (Equipment). The vehicle was diagnosed but was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 84,358.

Mileage: 84,358

Climate control switch melted and caused a small fire. I had to pull my dash apart very quicky to put it out. The Hyundai dealership would not help me even though a 2014 Elantra and Veloster has had technical service bulletins regarding this issue. They charged me 200$ dollars to tell me the switch melted even though I had already pulled it apart and showed them the issue. I spoke to Hyundai USA about it and they did not help me either. I bought the part and replaced it myself after the dealer tried to tell me it was almost 700$ for the repair. My son was in a panic because the cab of the car was filling with smoke as we were driving. No warnings or anything.

The contact owns a 2013 Hyundai Veloster. The contact stated that while starting the vehicle and shifting into reverse (R), the vehicle failed to respond. The contact then shifted into drive (D), but the vehicle failed to respond. There was no warning light illuminated. The contact stated that he shifted into park (P), turned off, and restarted the vehicle, and the vehicle responded as needed. The contact stated that the failure had been recurring. The vehicle was taken to an independent mechanic several times, but the failure could not be duplicated. The contact related the failure to NHTSA Campaign Number: 23V132000 (Electrical System); however, the VIN was not included. The dealer was notified of the failure and advised the contact to schedule an appointment for a diagnostic test. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure, and a case was opened. The manufacturer then referred the contact to the dealer for assistance. The failure mileage was approximately 45,000.

Mileage: 45,000

Ac controls started melting and almost caused a fire.

A wire from the ac fan controller gets extremely hot and the fan controller melts. Could possibly be a fire hazard under the right circumstances.

Then wiring for the temperature control knob is faulty. When taken apart to see the problem it has very obviously melted from extreme overheating causing the plastic to deform and render the knob and a/c power button unusable. God only know what other electrical shorts and melted components are under the hood. They had a recall for other year models just not mine. Clearly it’s a universal issue and should be fixed accordingly.

The contact owns a 2013 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 23V132000 (Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while parking on a city street at approximately 3 MPH, the contact engaged the Reverse Park Aid Sensor (RPAS). The contact had to activate the "shift lock release" in order to park the vehicle. The contact stated that the turn signals were inoperable, the headlamps were not functioning normally, and the proximity rear sensor alarm had stopped functioning. The manufacturer was made aware of the issue. The failure mileage was approximately 149,000. VIN showed no open recall.

Mileage: 149,000

UNKNOWN I'm not sure, I'm only scared what happens if this recalls isn't fixed sooner than expected so I can avoid unexpected issues or expensive repairs...

unknown

The blower for the AC and heater stopped working. It evidently caught fire because there is a burnt smell. When I searched the problem, I noticed that you already did a recall for this but left out the 2013 models. This is extremely dangerous as it could catch fire while driving. Please add the 2013s to the recall.

I was driving and the blower control switch stopped working and I had smoke coming out of my dash. Later my husband took it apart and the back of the switch and the part that plugged into the switch was burned. Without a blower, I don't have any defrost, fan, or ac option which could be dangerous in the winter if things ice over. We called Hyundai and they are very well aware of this issue and they said that we could replace it and the same thing could happen in 2 months and they aren't doing anything about it. This part was replaced once by the dealer while my car was under warranty. The only indication that there was a problem is when it stopped working along with the smoke issue.

The manual heater control unit, theinternal switch for the blower (fan) speed control become inoperative- the wire gets too hot and burns which makes this not work and could catch fire.

The contact owns a 2013 Hyundai Veloster. The contact works as a certified mechanic. The contact stated that upon servicing the vehicle, he noticed that the heater control wiring harness was extremely hot. The contact cleaned the wiring harness with on contact cleaner; however, the contact stated that the vehicle began to overheat while idling. The contact diagnosed that the heater control wiring harness connector had melted. The vehicle was not repaired. The dealer and the manufacturer were not notified of the failure. The failure mileage was approximately 66,000.

Mileage: 66,000

The contact owns a 2013 Hyundai Veloster. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power without warning. The contact stated that the spark plugs had melted and made a hole in the piston. The vehicle was taken to the local dealer but the vehicle was not diagnosed or repaired. The manufacturer was contacted but no additional assistance was provided. The contact had related the failure to NHTSA Campaign Number: 19V204000 (Electrical System, Engine). The failure mileage was approximately 145,000. The VIN was not available.

Mileage: 145,000

A few months ago, my ABS and Traction Control lights began to come on and off randomly. Then, new lights would pop up, such as Check Engine and the Brake light. These lights would come on, and then go off very sporadically. In the last week, it had gotten much worse. My tire pressure light and EPS light had came on as well, totaling about 6 or 7 lights that are on and won't go off. Then, my steering wheel became increasingly hard to turn, I' m guessing because the EPS was off. Then, my speedometer completely stopped working, and my gas gauge was jumping up and down after I had filled it to a full tank. I pulled the code, and got code for a wheel speed sensor. I replaced the wheel speed sensor, and no lights went off. I then inspected the fuses, noticed that the ABS fuse was blown, and decided to replace it. I replaced it, and the ABS module (or pump) started to smoke badly. The car had a heavy electrical smoke smell and I didn't think it was safe to drive for a while. Hyundais have had recalls for ABS modules smoking before, but never for a 2013 Hyundai Veloster, and I believe that is something that should be investigated because I believe I could have been injured.

The contact owns a 2013 Hyundai Veloster. The contact received notification of NHTSA Campaign Number: 19V204000 (Electrical System, Engine). The contact took the vehicle to the local dealer and had recall repair completed. The contact stated on 6/26/2022 while driving 60 MPH, the check engine warning light illuminated. The contact continued driving to AutoZone and was informed that cylinder #4 had an unknown error code. The vehicle was not repaired. The contact took the vehicle to back to the local dealer, where it was diagnosed with needing all four fuel injectors replaced. The vehicle was not repaired. The manufacturer had not been informed of the failure. The failure mileage was approximately 84,150.

Mileage: 84,150

So the vehicle wants to hesitate and buck violently to the point of nearly stalling out while accelerating and prevents the car from being able to merge into highway traffic in a safe manner and the surrounding years make and model are all on a recall due to a E.C.U. required update for a necessary reflashing for the ability to be use the automobile in the way it's designer/designers can make make want h. The severity and frequency of the problems are embarrassing and frustrating to be scared of risking my life being injured in a stalled/stalling vehicle without a power supply to navigate

I bought the 2013 Base Version Veloster w/ 80,000 miles on it back in 2021, beginning of January having no problems with the vehicle. Halfway through the month my Veloster started having on and off transmission problems, then at the end of the month, not even a month into owning the vehicle , my car won’t go into gear and my gear light is blinking on my dashboard. I do my research and see ALOT of Velosters have this problem, but don’t know the reason for it. So I proceed to take it to a trusted mechanic that does a diagnoses and determines I need a new TMC module, and also determined nothing else was wrong with the car. I had to wait 8 months to get the part from the Hyundai dealership and finally when they get it fixed, they tell me to take it to the Hyundai dealership to get it reprogram, because the car was put into limp mode after the new module was put in. After I picked up my vehicle, I took it to the dealership. I left them with all the information and insist that I only want to reprogram my TCM Module. They proceed to do a diagnosis on my car and call me the same day, saying They have a recall on the rode bearings and also that I need a new transmission, and will replace it for 7,100$. I was mortified. The vehicle is only 80,000, and I already have to replace the transmission after buying the vehicle, I feel scammed. If I see that thousands of people are having this same problem, I believe it needs to be address.

Driving on the interstate back from work going 60+ mph. The Vehicle TURNS OFF AND I LOST POWER, my RPMS DROPPED TO 0 and it was no longer accelerating. It’s AS IF IT WAS IN NEUTRAL. I had to cruise my way off to the side and get my car towed to a shop. THIS COULD HAVE KILLED ME

The contact owns a 2013 Hyundai Veloster. The contact received a recall notification for NHTSA Campaign Number: 19V204000 (Electrical System, Engine) however, the dealer informed the contact that they would be able to facilitate the repair in 34 weeks. The contact stated that he contacted a second dealer; Hiley Hyundai of Fort Worth (9000 West Fwy, Fort Worth, TX 7610) and was informed that they could not complete the recall repair. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. Parts distribution disconnect.

The contact owns a 2013 Hyundai Veloster. The contact stated that while driving at various speeds, the vehicle stalled due to the engine overheating. There was no warning light illuminated. The contact had taken the vehicle to a dealer for an inspection and was informed that the vehicle had been making an abnormal sound and needed to be diagnosed. The contact declined. The contact linked the failure to NHTSA campaign number: 19V204000 (Electrical System, Engine) however, the VIN was not included in the recall. The manufacturer was also notified of the failure and a complaint was filed. The vehicle was not repaired and remained at the dealer. The failure mileage was approximately 120,000.

Mileage: 120,000

faulty HVAC module and wiring catching on fire

Air condition control switch located in cabin below infotainment unit. The setting of 1-4, the one most used will stop working requiring use of another number. After removing the part (twice replaced by dealership previously) found the contact points of switch melted. The wiring harness plugged into control until also melting.

Electrical issues & engine issues. 2013 Hyundai Veloster. - purchased brand new and September 2013. CENTEREACH HYUNDAI DEALERSHIP. Since day one I’ve had many issues. So I’m having multiple repairs and replacement of AC /Heat blower,switches, Resistors,-Blower head unit, radio,Control head ( Internally shorting.Recall #948 ( canister cracked).report to dealer sells of exhaust coming in car. Also had replaced Right rear door actuator. July 2018 complained of transmission slipping not going into gear pulling back etc. Dealer claims no trouble calls. Once again I am having the same issues. This time driver side window goes down by itself and will not stay up, I have to manually open passenger side door lock and once again the blower does not work. Lights on my dash all lit oil light had been flickering, tire pressure light stays on and airbag light is lit. Just recently I have been driving in the car and had thought in the middle of driving that the transmission had went the car mediately pulled back and did not move I was lucky enough to have guided it over to the side of the road. NHTSA # 19V204000 ( Hyundai recall #182) 2013 Hyundai Veloster - although it states four”TURBO ENGINE” only I am having the same exact problems. Let’s not wait until the engine goes on fire or causes a serious accident ! I am more than concerned and worried about this for I have no other transportation. I have contacted Hyundai customer care service. Both emailed and called. Hyundai Consumer Affairs # 18383206. I had also been advised over the phone(which I am was not aware of) another recall #966 - Involving a Hyundai Veloster’s 2012 -2017, as per rep. She set up an appointment with the dealership in which I go to, and also purchased the car, I asked her to please forward me a copy of the email and what she sent to the dealership, in which I am still waiting. I’m hoping the dealership Will take this more seriously coming from the manufacture. I Will advise outcome. Thank you

Ac control knob, electrical wiring started smoking and would have caught fire if i had not turned off ac the cat could have possibly caught fire, not yet it is scheduled to be inspected 06/19/2021, no warning signals were presented the ac would only blow on lower settings at the onset of thw problem. The problem first appeared on 6/16/2021.

Replaced the manual climate control on my 2013 hyundai veloster. The connector to the unit is melted.

SHORTLY AFTER I PURCHASED THE VEHICLE, USED FROM CARMAX, THE LIGHTING ON THE STEERING WHEEL STOPPED TURNING ON AND WOULD RANDOMLY COME ON WHILE DRIVING, USUALLY AFTER ABOUT 10-15 MINUTES AND WHILE TURNING. . IT NO LONGER COMES ON AT ALL AND NONE OF THE STEERING WHEEL BUTTONS WORK ANYMORE EITHER, NOR DOES MY HORN.

Mileage: 30,000

THE CLIMATE CONTROL SWITCH HAS BEEN REPLACED MULTIPLE TIMES. THE MAIN HARNESS WHERE CLIPS IN IS BURNT AN IS MELTING MY SWITCH OUT AFTER BEING CHANGED AN USED FOR FEW HOURS IT THEN BURNS OUT. THE CAR SMELLS LIKE IT'S MELTING THREW THE VENT OF PLASTIC.

MY SECOND HVAC CONTROL UNIT HAS MELTED. THE PLUG IS BURNT. THUS IS A RIDICULOUSLY NORMAL ISSUE, YOU KNOW WHEN IT FAIL BECAUSE YOU SMELL THE BURNING PLASTIC BEFORE THE HEAT SHUTS OFF.

IVE REPLACED THE ENGINE THREE TIME DUE TO FAILURE. THE FAILURE OF THE GDI MOTORS IS IMMINENT. ON A DIFFERENT NOTE, THE CLIMATE CONTROL KNOB HEATS UP AND BURNS OUT THE METAL STRIP BEHIND THE KNOB WHICH CAUSES THE KNOB TO EVENTUALLY BECOME USELESS.

Mileage: 100,000

FAN SPEEDS FOR HEAT AND A/C NO LONGER WORK WHEN THE DIAL IS PLACED ON THE NUMBER FOR THE SPEED OF THE FAN. TO GET SPEED #2 TO BLOW, THE DIAL IS ACTUALLY SOMEWHERE AROUND POSITION 2.5. TO GET SPEED #3 TO BLOW, THE DIAL NEEDS TO BE AT ABOUT 3.5, WILL NOT WORK WITH DIAL PLACED ON THE NUMBER 3 LIKE IT SHOULD. SAME ISSUE WITH FAN SPEED #4. AFTER REMOVING DASH PANELS TO INSPECT, WIRES AND ELECTRICAL CONNECTIONS ARE GETTING SO HOT TO THE POINT THAT THEY MELT. THIS IS A FIRE HAZARD.

Mileage: 71,000

SMELLED A BURNING PLASTIC SMELL AND LATER REALIZED THAT SETTING #4 ON HVAC FAN NO LONGER WORKED. VEHICLE WAS IN MOTION ON A HIGHWAY AT THE TIME.

Mileage: 63,000

MOST OF NOT ALL OWNERS OF HYUNDAI/KIA VEHICLES EXPERIENCE A SHORT IN THE CLIMATE CONTROL UNIT. THIS FAULT NOT ONLY CREATES A VISIBILITY ISSUE WHILE DRIVING THE CAR IN ADVERSE WEATHER. BUT MAY ALSO CAUSE SPARK FIRE ASSOCIATED WITH THE CLIMATE CONTROL KNOB.

THE HEAD LIGHT BULBS HAVE BEEN REPLACED 6 TIMES, AND THE 'BRAIN' OF THE CAR HAS BEEN REPLACED 2 TIMES (WITH A REFURBISHED ONES, (NOT NEW). I UNDERSTAND THERE WAS A RECALL FOR MAKE AND YEAR OF MY CAR FOR THE SOFTWARE REPLACEMENT BECAUSE OF ELECTRICAL ISSUES. I DON'T UNDERSTAND WHY MY PARTICULAR CAR WAS NOT LISTED. MY CAR IS HAVING ELECTRICAL ISSUES!!!

THE AC CONTROLLER QUIT WORKING SO I LOOKED AND THE WIRES HAD BURNED BEHIND THE DASH ALSO MELTED THE SWITCH SEEN ONLINE IT SEEMS TO BE A VERY COMMON ISSUE WITH THISCAR

Mileage: 83,305

AC CONTROL SWITCH REPLACED 4 TIMES AND THE CRUZE SWITCH HAS WIRE PROBLEM

I BOUGHT A 2013HYUNDAI VELOSTER IN APRIL OF 2019 WITH IN THE FIRST 2 DAYS OF HAVING CAR IT STOPPING ACCELERATING AN LEFT ME ON THE SIDE OF ROAD. I HAD TO CAR TOWED BACK TO THE DEALER WHERE THE CAR WAS BOUGHT . AFTER THEM LOOKING IN TO THE PROBLEM THEY ENDED UP REPLACING THE CATALYTIC CONVERTER. THE CAR RAN FINE FOR ABOUT ANOTHER 5 TO 6 MONTHS. THEN ONE DAY BAD ROUGH IDEL RPMS DROPPING WHEN UNDER ACCELERATION AFTER PUTTING ON CODE READER IT TURNED OUT TO BE A MISFIRE I THEN REPLACE COIL PACK AND SPARK PLUGS. THE VELOSTER RAN FINE FOR ABOUT 3 TO 4 MONTHS THIS TIME. NOW WE ARE BACK TO THE CAR HAVING ISSUES TODAY 7/11/20 LOSS OF POWER UNDER ACCELERATION,ROUGH IDEL,KNOCKING SOUND COMING FROM ENGINE. I HAVE CONTACTED HYUNDAI IN THE PAST ON THE 2013 ECU RECALL THEY DID NOT WANT TO HONOR THERE RECALL SAYING IN ORDER TO LOOK IN TO THE PROBLEM I'D NEED TO GET IT DIAGNOSED THROUGH THE DEALER WHEN I CAN SIMPLY USE MY OWE CODE READER. IT HAS BEEN NOTHING BUT ISSUES WITH THIS VEHICLE I BOUGHT WITH ONLY 63000 MILES THIS IS FRUSTRATING IS THERE ANYTHING THAT CAN BE DONE FOR HYUNDAI TO HONOR THERE RECALL THANK YOU .

Mileage: 93,000

THE AC/ CLIMATE CONTROL KNOB HAS PARTS IN IT THAT KEEP MELTING, RENDERING THE HEAT AND AIR CONDITIONING UNABLE TO TURN ON.

Mileage: 30,000

MY CAR STALLED AT A RED LIGHT. EVEN THOUGH THE ENGINE WAS RUNNING AND THERE WERE NO MECHANICAL LIGHTS ON, THE CAR WOULDN'T GO WHEN I PRESSED THE GAS. AFTER TURNING THE CAR OFF AND ON SEVERAL TIMES, IT WOULDN'T MOVE. IT HAD TO BE PUSHED OUT OF THE STREET AND AFTER 20 MINUTES OF RESTING, IT WORKED AGAIN. *TR

Mileage: 89,000

THE AIR/FUEL MIXTURE IN THE ENGINE CAUSED THE OIL TO BURN THROUGH FASTER THAN IT SHOULD, INCREASED PRESSURE AND CAUSED THE CYLINDER TO DAMAGE THE ENGINE. THIS RESULTED IN ME HAVING TO REPLACE THE ENGINE. THE ELECTRICAL SYSTEM CAUSED THE VEHICLE TO IDLE ROUGH AT LOW RPM, AND EVENTUALLY STALLED AT AN INTERSECTION ON A BUSY HIGHWAY. *TR

Mileage: 109,000

I BOUGHT MY CAR MAY 2016 IT HAD AN ODD SMELL ONCE I STARTED USING MY AC UNIT BUT COULDN'T FIGURE IT OUT. IN AUGUST I LOST LEVEL 1 AND 2 ON MY BLOWER KNOB, AND IN OCTOBER 2018 I LOST ALL HEAT AND THE BLOWER KNOB NO LONGER WORKED. I OREDER AN OEM DASH CONTROL UNIT AND HAD A CO-WORKER INSTALL IT FOR ME. SEPT. 2019 I AGAIN LOST LEVEL 1 AND 2 OF THE FAN BLOWER. I CONTACTED THE SUPPLIER AND WAS TOLD THIS IS ONLY UNDER WARRANTY IF IT WAS INSTALLED AT A CERTIFIED SHOP AND ONLY IF I PUT ON 12K MILES AND UNDER 1 YEAR. I WASN'T ABLE TO USE MY WARRANTY DUE TO I HAD MY CO-WORKER IN STALL. FEB 14TH 2020 REMOTE STARTED MY CAR AS IT IS VERY COLD IN WI. WHEN I GOT TO MY CAR I THOUGHT IT WAS ON FIRE DUE TO THE SMELL INSIDE MY CAR. I SAW NO SMOKE OR FLAMES. I DROVE HOME FROM WORK AND THE SMELL WAS HORRIBLE I HAD TO CRACK THE WINDOW IT WAS SO STRONG AND DROVE IN THE SLOW LANE IN CASE MY CAR BURST IN TO FLAMES SO I COULD GET OUT. FEB. 16TH MY WHILE DRIVING MY CAR THE SMELL OF BURNING PLASTIC WAS OVERWHELMING AND THEN SUDDENLY I LOST TOTAL HEAT AND THE KNOB FOR THE BLOWER NO LONGER WORKED. FEB. 17TH I BOUGHT ANOTHER HEATER FROM THE SAME OEM ONLINE STORE. I BROUGHT IT TO WORK WHEN IT ARRIVED ON THE 20TH. THE SAME C-WORKER WENT TO INSTALL IT AND HE SAID HE WOULDN'T INSTALL IT BECAUSE HE DIDN'T WANT ME TO DIE FROM MY CAR STARTING ON FIRE AS THE CABLE HARNESS CONNECTOR IS MELTED. I LAUNCHED A COMPLAINT WITH HYUNDAI THE SAME DAY. I WAS GIVEN A CASE NUMBER AND TOLD TO WAIT TO HEAR BACK WITHIN 24 HOURS DUE TO THE FIRE ISSUE/SAFETY CONCERN. I DID HEAR FROM ROBERTA FROM CORPORATE AND I WENT OVER THE DETAILS, SHE SAID THEY WOULD PAY FOR TOWING AND CAR RENTAL. I TOOK MY CAR IN TO A HYUNDAI DEALERSHIP AND AM BEING TOLD THAT I HAVE TO PAY $136 BECAUSE THEY NEED TO RULE OUT THAT IT'S NOT MY REMOTE STARTER CAUSING THE ISSUE THAT I HAD INSTALLED AT BEST BUY. THIS IS A KNOWN ISSUE OF THAT COMPONENT MELTING

Mileage: 110,000

TL* THE CONTACT OWNS A 2013 HYUNDAI VELOSTER. WHILE DRIVING 55-65 MPH THE VEHICLE BACKFIRED AND STALLED. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THERE WAS SMOKE DETECTED FROM UNDERNEATH THE HOOD. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED HENDERSON HYUNDAI (460 N BOULDER HWY, HENDERSON, NV 89015 (702) 800-6127) BUT WAS NOT DIAGNOSED OR REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS AT THE DEALER SEVERAL TIMES FOR ABNORMAL KNOCKING NOISE IN THE ENGINE. THE CONTACT STATED THAT HE WAS NOT INFORMED OF HIS VIN BEING INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V204000 (ELECTRICAL SYSTEM, ENGINE). THE MANUFACTURER WAS CONTACTED BUT DID NOT ASSIST. THE FAILURE MILEAGE WAS 120,000.

Mileage: 120,000

WHILE DRIVING IN THE HIGHWAY I HAD A BURN WIRE SMELL WHEN MY AIR CONDITIONER WAS SET AT BLOWER SPEED 4 AND IT STOP WORKING AT THAT SETTING. I WAS DOING DOME RESEARCH AND FOUND THE CONTROLLER HAS A TENDENCY TO GET BURN INDIDE DUE TO BE UNABLE TO HOLD THE BLOWER ELECTRICAL LOAD. I THINK THIS CAN TURN INTO A FIRE HAZARD. FOUND INFO IN FORUMS, YOUTUBE VIDEOS ETC. LOT OF PEOPLE IS DEALING WITH THIS TO THE POINT THEY REPLACE THE PART WITH AN ORIGINAL ONE AND THE NEW ONE GETS BURN AGAIN. THE CONTROLLER PN: 97250-2V010-BPD

Mileage: 39,500

THE KNOB ON TO THE AC AND HEAT IN THE VEHICLE BURNED OUT AND DOESNT WORK. ACCORDING TO MAIN WEBSITES, THIS ISSUE HAPPENS ALOT AND CONTINUES TO BE AN ISSUE FOR MANY EVEN AFTER IT'S BEEN REPLACED.

Mileage: 92,000

THE FAN SWITCH FOR THE HVAC QUIT WORKING, SO I TOOK THE CLIMATE CONTROL MODULE OFF TO SEE WHAT THE PROBLEM WAS AND NOTICED THE SWITCH ITSELF WAS MELTED AND BURNED, AS IF THERE WAS A FIRE AND/OR THE VOLTAGE IS TOO HIGH. THIS IS A SEVERE FIRE HAZARD AND SHOULD BE LOOKED INTO IMMEDIATELY. I AM NOT THE ONLY PERSON HAVING THIS ISSUE.

Mileage: 65,000

STEERING WHEEL MAKING CLUNKING NOISES WHEN IT IS TURNED AND MESSED UP CLOCKS RING CAUSING THE VEHICLES AIRBAG LIGHT TO TURN ON

THE HEATING CONTROL UNIT KNOB DOES NOT SET ON THE VARIOUS SETTINGS (1-4) AND DOES NOT BLOW HEAT OR AIR CORRECTLY. MANY PEOPLE HAVE HAD THIS ISSUE AND END UP HAVING TO REPLACE THE UNIT THEMSELVES. THE ISSUE IS THE CONTACTS GET BURNED OUT AND NO LONGER WORK. THIS IS A SERIOUS FIRE HAZARD AND I DONT KNOW WHY A RECALL HASNT BEEN ISSUED. IF YOU SEARCH ONLINE YOU WILL SEE NUMEROUS EXAMPLES OF WHAT I AM REFERRING TO. IF I REPLACE THIS MYSELF I HAVE TO RISK DAMAGING MY CAR OR ELECTROCUTING MYSELF AND PAYING FOR AN EXPENSIVE PART. THE OTHER OPTION IS HAVE A MECHANIC DO IT AND END UP SPENDING OVER 500$ FOR SOMETHING THAT SHOULD NOT BE MALFUNCTIONING. PLEASE INVESTIGATE THIS SERIOUS ISSUE AND DO THE RIGHT THING.

Mileage: 68,000

THE TEMPERATURE CONTROL KEEPS MELTING I HAVE READ THEY ARE A LOT OF COMPLIMENTS ABOUT THIS FIRE HAZARD I HAVE REPLACED IT 3 TIMES BUT THE WORDING HARNESS IS BURNT

Mileage: 100,000

FAN BLOWER SWITCH NO LONGER FUNCTIONS ON SETTING 1 OR 2. SETTING 3 AND 4 WORK FOR NOW. A FAINT ELECTRICAL SMELL WAS DETECTED SHORTLY AFTER I CHANGED THE FAN SPEED.

Mileage: 78,000

THE CLIMATE CONTROL/FAN SPEED SELECTOR KNOB MELTS AND BURNS OUT, CAUSING A POTENTIAL FIRE HAZARD. VOLTAGE IS TOO HIGH FOR THE MATERIAL THEY ARE USING AND THUS CAUSES IT TO MELT AND BURN OUT.

Mileage: 63,000

THE DRIVERS SIDE WINDOW DOES NOT COME BACK UP THE MOTOR ENGAGES AND WINDOW STUCK IN OPEN ALSO OCCURED ON THE PASSENGER REAR WINDOW

Mileage: 41,234

THE AC FAN CONTROL SWITCH ON THE DASH MELTS ON THE BACK OF IT AND CAUSES THE SWITCH TO ONLY WORK ON SPEED 1 AND IN SOME CASES NOT AT ALL. NOW IVE RESEARCHED THIS MULTIPLE TIMES AND MANY MANY PEOPLE HAVE HAD THE SAME ISSUE THAT IM HAVING AND SOME HAVE EVEN HAD THEIR WHILE CAR CATCH FIRE. SO TO BETTER EXPLAIN IM ADDING A YOUTUBE LINK THAT EXPLAINS WHAT HAS HAPPENED. HTTPS://WWW.YOUTUBE.COM/WATCH?V=1CKRHIB7XNU&FEATURE=SHARE

Mileage: 75,584

TL* THE CONTACT OWNS A 2013 HYUNDAI VELOSTER. THE CONTACT STATED THAT THE CLIMATE CONTROL FAN SWITCH MELTED, WHICH AFFECTED THE FAN SPEED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT CALLED DUELL'S EVANSVILLE HYUNDAI (LOCATED AT 4400 E DIVISION ST, EVANSVILLE, IN 47715, (812) 473-4400) WHERE IT WAS DIAGNOSED THAT THE CONTROL FAN SWITCH NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 116,618.

Mileage: 116,618

TAKARA RECALL. AC SWITCH AND WIRES ARE BURNT, POSSIBLE ELECTRICAL FIRE.

Mileage: 89,705

THE AC/HEATER BLOWER SWITCH WAS REPLACED 2 YEARS AGO AND AS OF TODAY I REMOVED THE SWITCH FOR NOT WORKING AGAIN AND FOUND THE SWITCH AND BOX HAD MELTED AND CAUGHT FIRE. THIS IS A MAJOR FIRE HAZARD THAT HAS OCCURRED TO MULTIPLE PEOPLE.

Mileage: 91,000

I AM ON MY THIRD CONTROL HEATER ASSEMBLY (PART NUMBER: 972502V010BLH) - AFTER SEVERAL MONTHS THE FAN SPEED CONTROL BREAKS. IT TOTALLY FALLS APART INTERNALLY AND NOW I SEE WHY - APPEARS TO BE A HEAT ISSUE. I DO NOT FEEL SAFE IN THIS VEHICLE AS I COULD SEE AN ELECTRICAL FIRE STARTING, I HAVE ATTACHED A PHOTO OF THE CONNECTOR.

Mileage: 100,000

TL* THE CONTACT OWNS A 2013 HYUNDAI VELOSTER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V204000 (ELECTRICAL SYSTEM, ENGINE). WHILE DRIVING 70 MPH, THE CONTACT HEARD AN ABNORMAL POPPING AND CLUNKING NOISE AND THE VEHICLE STALLED. SMOKE EMERGED FROM THE VEHICLE AND OIL WAS IN THE ENGINE COMPARTMENT. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT CALLED LEE HYUNDAI OF GOLDSBORO (304 N OAK FOREST RD, GOLDSBORO, NC 27534, (866) 789-1488), BUT THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 15836168, BUT NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 121,000.

Mileage: 121,000

WE TOOK THE CAR TO HONDAI BEFORE THIS RECALL ABOUT 3 MONTH AGO LEFT IT THERE FOR 3 DAYS THEY DID A DEEP CHECK UP ON THE ELECTRICITY SINCE THE CAR WON'T DRIVE NO RESULTS WERE FOUND AND THE CAR STILL NOT WORKING.

Mileage: 50,000

MY CAR BEGAN MAKING A WHISTLING SOUND AND STOPPED IN TRAFFIC. NO POWER JUST STOPPED.- I WAS DRIVING ON A FEEDER ROAD AT ABOUT 35MPH.

Mileage: 58,000

I HAVE A HYUNDAI VELOSTER 2013. ON THE HWY HOME FROM WORK MY CAR SUDDENLY LOST POWER, I WAS ABLE TO MAKE IT TO THE SIDE OF THE ROAD WHERE IT COMPLETELY DIED. UPON INITIAL INSPECTION IT SEEMED TO BE IN PART DUE TO THE BATTERY. WE REPLACED THE BATTERY AND . SWITCHED OUT THE ALTERNATOR TO TEST IT AND TOOK IT IN TO THE DEALERSHIP WHERE THEY CHARGED US 150 TO SUGGEST FACTORY PARTS IN ORDER TO DIAGNOSE IT. I REFUSED AND PUT THE OLD ALTERNATOR BACK ON AFTER IT TESTED CLEAR AND HECKED THE FUSES. THE MULTI FUSE FOR THE ALTERNATOR HAD BLOWN SO WE REPLACED THAT (MAKING IT DRIVEABLE) AND BROUGHT IT IN TO A DIFFERENT HYUNDAI SERVICE DEPT. THEY DIDNT CHARGE ME TO TELL ME THAT IT HAD BLOWN A ROD AND I NEEDED A NEW ENGINE. HYUNDAI IS REFUSING TO DO ANYTHING HOWEVER DID CALL THE SEXIST JERKS FROM THE ORIGINALLY HYUNDAI DEALERSHIP AND USED THAT INTERACTON AS BASIS TO SAY MY CAR IS FINE...

Mileage: 67,000

I PURCHASED MY 2013 HYUNDAI VELOSTER IN FALL OF 2015 AS SECOND OWNER FROM WORLD HYUNDAI IN MATTESON, IL. IT HAD ROUGHLY 32,000 ON THE ODOMETER. AFTER TWO DECENT YEARS OF RELATIVELY TROUBLE FREE OWNERSHIP THE "ELECTRICAL GREMLINS" ATTACKED THE TRUNK RELEASE, THEN THE REVERSE CAMERA, THEN THE CLIMATE CONTROL KNOB. I WAS RELUCTANT TO TAKE THE CAR IN AGAIN BECAUSE I HAD SPENT MORE MONEY ON DIAGNOSTIC CHARGES THAN I HAD ON ITEMS THAT WERE COVERED. I LIKED THE VEHICLE AND METICULOUSLY MAINTAINED IT TO SPEC AS WELL. ON ONE OF THE COLDEST DAYS IN WINTER OF 2019, I WENT OUT TO START UP MY VELOSTER AND WAS TERRIFIED BY A LOUD METAL TICKING FOLLOWED BY RATTLING IN THE MOTOR. I IMMEDIATELY SHUT DOWN THE CAR. I WAITED A BIT THEN TRIED TO START IT AGAIN. IT WAS VERY BAD. I TOOK THE CAR TO THE CLOSEST HYUNDAI DEALERSHIP IN WHICH I DESCRIBED ALL THE ISSUES WITH THE CAR. AT THIS POINT THE VEHICLE HAS ROUGHLY 92000 MILES ON THE ODOMETER AND OF COURSE THE TELL ME THERE IS NOTHING THEY CAN DO BUT, REPLACE THE MOTOR FOR AROUND $4500 , SELL ME A NEW ONE, OR BUY IT IN TRADE. ONCE AGAIN I PAID OVER $430 IN DIAGNOSTIC FEES WITH NO COVERAGE OR HELP. LOOKED AROUND ON LINE AND FOUND THAT THESE VEHICLES HAS HAD ALL OF THE ABOVE ISSUES AND NO CLEAR SOLUTIONS TO ANY. I'VE ALSO NOTICED THAT ALL OF THE ISSUES I HAVE HAD WITH MY VEHICLE MANY OTHERS HAVE POSTED ON YOUTUBE, GOOGLE ETC., BUT NOT MANY HAVE FILED OFFICIAL COMPLAINT. COME ON PEOPLE! GET ON BOARD!

Mileage: 92,000

THE TRUNK LATCH HAD BEEN FAILING INTERMITTENTLY. I STOPPED AT A DEALERSHIP WHO OPENED THE DRIVER'S DOOR, AND BEGAN LOCKING AND UNLOCKING THE ELECTRIC DOOR LOCKS. THIS SOLVED THE PROBLEM AT THE TIME. I ASKED HOW PLAYING WITH THE LOCKS WOULD FIX THE TRUNK ISSUE. THE QUESTION WAS NOT ANSWERED. THIS SOLVED THE PROBLEM FOR A COUPLE OF YEARS. HOWEVER, THE TRUNK LATCH FINALLY FAILED PERMANENTLY. I COULD NOT OPEN THE TRUNK VIA THE EMERGENCY LATCH FROM THE IN SIDE. I WAS TOLD BY THE DEALERSHIP THAT THE ISSUE WAS AN ELECTRICAL ISSUE. HENCE, THE DOOR LOCK REMIDEY. MULTIPLE VELOSTER OWNERS HAVE REPORTED THE SAME WITH SOME YEARS BEING RECALLED. THE 2013 HAS NOT BEEN RECALLED AND THE DEALERSHIP QUOTED 400.00 TO REPAIR THIS DEFECT. I BOUGHT THE CAR NEW AND IT NOW HAS 50,000 MILES. I HAVE HAD MULTIPLE SAFETY ISSUES WITH THIS VEHICLE THAT HAVE BEEN RESOLVED BUT FYI-ISSUE WITH ABS KICKING IN DURING EVERY SINGLE BRAKE, EVEN IF AT A RED LIGHT. I BROUGHT THE CAR TO THE DEALERSHIP MULTIPLE TIMES FOR THIS ISSUE AND WAS TOLD IT WAS NORMAL. I WENT TO ANOTHER DEALERSHIP AND TEST-DROVE ANOTHER 2013 HYUNDAI VELOSTER. THE ABS ONLY KICKED IN WHEN APPROPRIATE NOT WITH EVERY SINGLE BREAK. WHILE PURCHASING TIRES AFTER A 3RD BLOWOUT ( 30, 000 MILES) THE TIRE COMPANY NOTICED SOMETHING WRONG WITH THE SENSORS TO THE ABS. THIS WAS RESOLVED BY THE TIRE COMPANY. IT'S CONCERNING THAT HUYNDAI WOULD NOT ACKNOWLEDGE THE ABS ISSUE. IN FACT, THEY DON'T ACKNOWLEDGE ANYTHING-- MY GPS NEVER WORKED CORRECTLY WHICH WAS REPORTED TO HYUNDAI AT LEAST 10 TIMES OVER A THREE-YEAR PERIOD. I FINALLY MADE A VIDEO OF THE MALFUNCTION- AS SOON AS I SUBMITTED THE VIDEO THE GPS WAS REPLACED IMMEDIATELY. PROBLEM BEING THE NEW GPS WAS THE SAME MODEL AS THE FIRST AND DOES NOT WORK EITHER. I NOW HAVE A VEHICLE WITHOUT A GPS AND WITHOUT A TRUNK THAT OPENS.

Mileage: 50,000

MY WIFE HAS A 2013 HYUNDAI VELOSTER TURBO AND THE HVAC SYSTEM HAS STOPPED FUNCTIONING. AFTER INVESTIGATING THE MATTER I DISCOVERED A MANUFACTURER DEFECT WITH THE VEHICLE. THE POWER WIRE LEADING TO THE CLIMATE CONTROL MODULE OVERHEATED AND MELTED THE PLASTIC CONNECTOR AND DESTROYED THE CLIMATE CONTROL MODULE. THIS COULD HAVE STARTED A FIRE. I CONTACTED HYUNDAI CONSUMER AFFAIRS AND HYUNDAI CUSTOMER CARE IMMEDIATELY TO NOTIFY THEM OF THE ISSUE AND SO THAT THEY WOULD COVER THE REPAIR COSTS FULLY. I ALSO INFORMED THEM OF TWO OTHER ISSUES, ONE, THE STEERING WHEEL CONTROLS ARE MALFUNCTIONING AND TWO, ONE OF THE LED LIGHTS IN THE PASSENGER TAIL LIGHT IS OUT. I RECEIVED A CASE NUMBER FROM THEM, #15272744. I MADE AN APPOINTMENT AT LANCASTER HYUNDAI LOCATED ON MAIN STREET IN EAST PETERSBURG PA AND DROPPED THE CAR OFF. I ALSO INFORMED THEM OF ALL THE ISSUES AND MY FINDINGS (THIS WAS YESTERDAY 1/18/19). THIS MORNING (1/19/19) I RECEIVED A CALL BACK FROM SERVICE ADVISOR DAVID COREY WHO LEFT ME A VOICEMAIL STATING THAT HYUNDAI HAS DECLINED TO COVER THE REPAIRS AND TELLING ME TO COME PICK UP THE CAR. SINCE THEN I HAVE CONTACTED HYUNDAI CONSUMER AFFAIRS AND HYUNDAI CUSTOMER CARE TO NO AVAIL. THIS ISSUE WITH THE CLIMATE CONTROL MODULE IS WELL DOCUMENTED ONLINE AND THERE HAS EVEN BEEN A RECALL FOR IT ISSUED BY HYUNDAI BUT FOR SOME REASON MY WIFE'S VEHICLE IS NOT INCLUDED IN THE RECALL. I HAVE UPLOADED PHOTOS OF THE DAMAGED CONNECTOR AND WIRING HARNESS AS WELL AS A PHOTO FROM ANOTHER HYUNDAI VELOSTER OWNER WHICH SHOWS THE RECALL FOR THE CLIMATE CONTROL MODULE. I AM THANKFUL TO GOD THAT THE VEHICLE DID NOT CATCH FIRE SINCE MY WIFE AND TWO YEAR OLD SON TRAVEL IN IT EVERY DAY. I JUST WANT HYUNDAI TO DO THE RIGHT THING AND COVER THE COSTS TO REPAIR THIS FACTORY DEFECT.

Mileage: 85,000

THE LATCH ON THE VELOSTER SEEMS TO GO OUT IT STILLL CAN HERE THE MOTOR WORKING BUT WILL NOT OPEN NO OTHER WAY TO OPEN THE HATCH FROM INSIDE MANY PEOPLE HAVE COMPLAIN ONLINE DON'T KNOW EXACTLY WHAT IS THE ISSUE CAUSING THE PROBLEM

MY CLIMATE CINTRIL KNOB STOPPED WORKING ST DIFFERENT SETTINGS. SOMETIME I GET LEVEK 4 FIRCE OF AIR WHEN THE SELECTIIN IS ON 1. OR OTHER TIMES I GET AIR FORCE OF 2 WHEN THE SELECTION IS ON 4. MY AC ALSO WON'T WORK ONCE THE KNOB STARTED ACTUNG UP. MY SECOND ISSUE IS MY CHECK ENGINE LIGHT GIES ON AND OFF. I GOT A READING OF DTC P0087 BUT I AM TOLD THERE IS NO RECALL EVEN THOU THERE IS A TSB OUT THERE.

Mileage: 74,000

INCIDENT HAPPENED ON JULY 21ST 2017 AT 1:45PM AT 9701 DESSAU ROAD, AUSTIN TEXAS. I WAS COMING AROUND THE CORNER AT DESSAU AND RUNDBERG HEADING NORTH AND I FELT THE CAR SKIP A LITTLE AND HAD SOME LOSS OF POWER. I PULLED INTO THE PARKING LOT AT 9701 DESSAU AND THE CAR WAS SMOKING AND THE BRAKES WENT OUT. I PULLED THE EMERGENCY BRAKE AND THEN OPENED THE HOOD, THERE WAS FIRE AND BLACK SMOKE COMING OUT AND I RAN INSIDE TO GET A FIRE EXTINGUISHER. IT LOOKED LIKE THE ALTERNATOR FAILED AND CAUGHT ON FIRE. THE FIRE SPREAD UNDER THE MOTOR COVER AND BURNED SOME OF THE HOOD, BUT I GOT TO IT QUICKLY AND MINIMAL DAMAGE WAS DONE. I COULD HAVE CRASHED AND DIED.

Mileage: 45,000

ONE AFTERNOON DURING RUSH HOUR IN THE BRONX MY GEAR STICK WOULD NOT SHIFT FROM P TO D SO I HAD TO USE THE OVERRIDE SHIFTIER FUNCTION JUST TO GET MY CAR TO MOVE. ALONG WITH THE GEAR SHIFT NOT WORKING NONE OF THE ELECTRICAL COMPONENTS IN THE CAR WORKED NOT MY INDICATORS/HAZARDS, MY WINDOWS WONT WIND DOWN SO I COULD AT LEAST SIGNAL MY INTENTION, MY WIND SHIELD WIPERS WERE NON OPERABLE AND MY SEAT BELT SENSOR DOES NOT WORK. IT WAS POURING OUT THIS DAY AND I HAD NO VISIBILITY BECAUSE MY WIPERS WOULD NOT WORK AND COULD NOT SIGNAL TO OTHER DRIVERS MY INTENTIONS. THE NEXT DAY I TOOK MY CAR TO THE DEALERSHIP AND THEY CONCLUDED THAT THE ISSUE WAS RELATED TO THE AFTERMARKET AUTO START THE PREVIOUS OWNER HAD INSTALLED. SO I HAD THE AUTO START REMOVED BUT THE ISSUE STILL OCCURS, HYUNDAI IS UNSURE OF WHAT IS CAUSING THE PROBLEM. HYUNDAI IS SUGGESTING A COMPLETE REWIRING BECAUSE THEY ARE UNSURE EXACTLY WHAT IS CAUSING THE ISSUE AND CLAIM IT WILL NOT BE COVERED UNDER WARRANTY BECAUSE IT SEEMS TO BE AN ELECTRICAL ISSUE, WHICH ARE NOT COVERED UNDER WARRANTY. THIS WILL COST ME UPWARD OF 7000$. I AM SURE THIS IS A DEFECT THERE IS NO WAY A CAR WITH LESS THAN 30,000 MILES SHOULD BE HAVING SUCH MAJOR ISSUES. THIS VEHICLE IS VERY UNSAFE FOR ME TO DRIVE WITHOUT ANY INDICATORS OR MY GEAR SHIFTIER WORKING. WHEN MAKING A U-TURN OR PULLING INTO PARKING SPOTS IT TAKES ME TWICE AS LONG BECAUSE I NEED TO HAVE SOMETHING SHARP HANDY TO PUSH INTO THE GEAR SHIFT RELEASE BUTTON.

Mileage: 26,088

OUR 2013 MODEL HYUNDAI VELOSTER CLOSED SUNROOF EXPLODED ON FEBRUARY 27, 2016 WHILE DRIVING DOWN FREEWAY AT 65MPH IN FAST LANE. IT SOUNDED LIKE A GUN GOING OFF WHEN THE ROOF EXPLODED INTO PIECES ON THE BACKS OF ME AND MY HUSBAND. WE WHERE IS UTTER SHOCK, TRYING TO GET OFF THE FREEWAY SAFELY WHILE GLASS FALLING ON US. WHEN LOOKING AT THE ROOF, IT WAS CLEAR THAT IT EXPLODED BURSTING FROM INSIDE OUT; LEAVING THE FRAME BENT LIKE IT WAS FORCED OPEN FROM INSIDE OUT. THIS WAS NOT A PRESSURE ISSUE (BEFORE GETTING ON FREEWAY, THE SUNROOF WAS OPEN). IT WAS NOT A HOT OR COLD ISSUES EITHER AS IT WAS A NICE 72 DEGREES. THOUGH THERE IS A RECALL FOR THE 2012 VELOSTER MODELS AND UNFORTUNATELY THERE HAS NOT BEEN ENOUGH PEOPLE TO REPORT ISSUES FOR 2013 MODELS AS OF YET. WHEN CONTACTING HYUNDAI DEALERSHIP, I WANTED TO FILE COMPLAINT (THEY GAVE ME AN 1800 NUMBER) THEN I ASKED IF THERE WERE ANY ISSUES, THEY DENIED EVER HEARING ABOUT SOMETHING LIKE THIS. AS MY HUSBAND AND I ARE COMMUTERS, WE HAVE ALREADY RUN OUT OF WARRANTY AND WOULD NEED TO PAY OUT OF POCKET. I WILL BE FIGHTING FOR REIMBURSEMENT OF THE $1,490.00 ($500 DEDUCTIBLE) THAT IT COST TO FIX THE SUNROOF AND FRAME THAT NEEDED REPLACED. MY ARGUMENT IS THAT I PURCHASED MY 2013 VEHICLE IN OCT. 2012, THEREFORE MY CAR WAS MANUFACTURED IN 2012 AND THEY WERE STILL USING THE 2012 DEFECTED ROOF FOR THE EARLY 2013 MODELS AND THAT SHOULD BE HONORED TO THE 2012 RECALL.

Mileage: 128,224

STEREO SPEAKER SYSTEM KEEPS COMING LOOSE FROM, HARNESS, REPAIRED, BROKEN AGAIN. WAS TOLD BY DEALER RECALL ISSUE. BOTH HEADLIGHTS AND FACTORY INSTALLED FOG LIGHTS HAVE REPEATEDLY GONE OUT, COSTING SEVERAL HUNDRED DOLLARS TO REPAIR. PAINT IS CHIPPING OFF VEHICLE IN SEVERAL PLACES, HAS BEEN SINCE APPROX 6 MONTHS AFTER BUYING CAR AND TOLD BY DEALER THERE IS NOTHING WRONG WITH PAINT, ALTHOUGH CHIPPING IN STRAIGHT LINE

Mileage: 6,000

HELLO, THIS REPORT IS NOT FOR A PARTICULAR INCIDENT, HOWEVER IT IS WIDESPREAD AND SHOULD BE ADDRESSED. I HIGHLY ENCOURAGE YOU TO READ THIS ARTICLE: HTTP://WWW.NETWORKWORLD.COM/ARTICLE/2871485/MICROSOFT-SUBNET/HACKERS-COULD-EXPLOIT-SECURITY-HOLES-IN-PROGRESSIVE-INSURANCE-SNAPSHOT-DEVICES.HTML THIS TELLS OF HOW THE PROGRESSIVE SNAPSHOT VULNERABLE TO HACKERS AND TRANSMITS THE DATA IT COLLECTS UNENCRYPTED. SINCE THE PROGRESSIVE SNAPSHOT IS PLUGGED DIRECTLY INTO THE OBD-II PORT, IT HAS ACCESS TO THE VEHICLE'S COMPUTER, WHICH COULD ALLOW A HACKER TO CONTROL THE CAR. AFTER READING THIS, I HAVE OPTED-OUT OF THE SNAPSHOT PROGRAM AND THEREFORE, MY CHANCE TO GET A DISCOUNT. THIS NEEDS TO BE ADDRESSED BECAUSE IT PUTS MILLIONS OF PEOPLE AT RISK. THANK YOU *TR

I WAS DRIVING DOWN THE HIGHWAY DURING THE WINTER LAST YEAR APPROX. JANUARY AND HAD HALF THE MILES LISTED ABOVE. MY INTERIOR HEAT CONTROL WAS ON FULL BLAST AND IT CUT OUT. I TRIED TO ADJUST AND IT WOULD TURN ON IF THE KNOB WAS PERFECTLY ALIGNED....SLIGHT ELECTRICAL BURNING SMELL WAS PRESENT. TOOK INTO DEALER AND THEY REPLACED THE INTERIOR BLOWER SWITCH, THE CONNECTION HAD SCORTCH MARKS ON IT SO THEY REPLACED THE WIRES AND CONNECTORS ALONG WITH THE SWITCH/CONTROL KNOB. 6 MONTHS LATER THE PROBLEM WAS RECURRING EXCEPT THIS TIME I WAS RUNNING AIR CONDITIONING AS THE TEMP OUTSIDE WAS 36 DEGREES CELSIUS OUTSIDE.... THIS TIME MUCH WORSE. IT SMELT LIKE AN ELECTRICAL FIRE. ,,,I TOOK THE COVER PLATE OFF THAT HELD THE HEATER CONTROLS IN PLACE AND THE CONNECTIONS ON IT LITERALLY MELTED OFF INTO MY HAND. THIS IS NOT AN ISOLATED INCIDENT, MANY OTHER HAVE THE SAME ISSUE WITH THIS CAR, AND THIS IS THE SECOND TIME FOR ME. HERE ARE LINKS TO OTHER PEOPLE HAVING SIMILAR ISSUES ---------------------- HTTP://WWW.VELOSTER.ORG/FORUM/37-HYUNDAI-VELOSTER-ISSUES-TSBS-RECALLS/8177-HVAC-FAN-SPEED-SWITCH-ISSUE.HTML ---------------------- HTTP://WWW.VELOSTER.ORG/FORUM/8-HYUNDAI-VELOSTER-GENERAL-DISCUSSION/7729-WEIRD-PROBLEM-AC-SHUTS-DOWN-WHEN-FAN-SETTING-MOVED-4-HIGHEST.HTML ---------------------- PICTURE OF SAID ISSUE/MELTING --------------------- HTTP://INSTAGRAM.COM/P/QH-QUCIF2K/ *JS

Mileage: 48,000

4 TIMES I HAVE HIT A POTHOLE OR A BUMP ON THE ROAD AND HAVE HAD A "LOUD BANG", THE CAR JERKS VIOLENTLY AND THEN THE WIPERS CAME ON - ONE TIME I HAD THE "LOUD BANG" THE CAR JERKED VIOLENTLY THE WIPERS CAME ON AND THE CAR WENT INTO NEUTRAL. THE COMBINATION OF THE SUSPENSION, TIRES AND RIMS MAKE THIS CAR VERY DANGEROUS ON ROADS THAT HAVE ANY KIND OF POTHOLES OR BUMPS. PLEASE HELP. *JS

Mileage: 7,000

TUESDAY THE 22ND, MY STEREO STOPPED COMING ON START-UP. SATURDAY THE 26TH CAR WOULD NOT START. AFTER CAR WAS JUMP STARTED, STEREO CAME ON, BUT CAR WOULD NOT SHIFT. HAD TO MANUALLY OVERRIDE SHIFTER TO DRIVE CAR, AT WHICH POINT I DISCOVERED ALL ELECTRICAL PARTS HAD STOPPED FUNCTIONING, INCLUDING TAIL LIGHTS, TURN SIGNALS, POWER WINDOWS, ETC. DEALERSHIP REPLACED BATTERY AND ENTIRE JUNCTION BOX, BUT ISSUE REAPPEARED 1 MONTH LATER. *TR

Mileage: 650

WHEN I WASH MY CAR I LIKE TO WIPE DOWN THE ENGINE AND THE INNER PART OF THE FRONT HOOD. ABOUT A WEEK AGO I WENT TO WASH MY CAR OPEN THE HOOD ONLY TO DISCOVER A WHITE SUBSTANCE (ALMOST LIKE WHITE BATTERY CORROSION) RUNNING ALL DOWN MY FIRE WALL COVER. I MADE AN APPOINTMENT WITH THE SERVICE DEPARTMENT TOLD THEM NOT TO DO ANYTHING TO THE CAR UNTIL THEY CAN EXPLAIN TO ME HOW IT HAPPEN AND HOW ARE THEY GOING TO FIX IT. ABOUT 20 MINUTES LATER THE SERVICE MANAGER CALLS ME OVER AND EXPLAINS TO ME THAT THE WHITE SUBSTANCE ON MY FIREWALL WAS WHEN THE DETAIL PEOPLE FROM WHERE I PURCHASE MY CAR LEFT IT THERE. I EXPLAIN TO HIM THAT WOULD BE IMPOSSIBLE SINCE I ALWAYS LOOK AT MY HOOD AND THIS WAS THE FIRST TIME I SAW IT. THE SERVICE MANAGER THEN TURNS TO THE TWO DECALS ON THE TOP OF THE HOOD AND STATED THEY MAY BE WATER SEEKING IN BUT BECAUSE HE DID NOT FIND THE FIREWALL WET HE JUST WIPED OFF THE WHITE SUBSTANCE AND TOLD ME THERE IS NOTHING HE CAN DO IT'S JUST THE DESIGNEE OF THE DECALS. I'M NOT EVEN SURE IT IS THE TWO DECALS; BUT ONE THING FOR SURE SOMETHING IS ALLOWING WATER TO SEEK INTO MY FIREWALL AND HYUNDAI IS NOT TAKING CARE OF THEIR CUSTOMERS NHTSA PLEASE HELP. *TR

Mileage: 1,789

THE SPEEDOMETER AND TACHOMETER DASHBOARD INSTRUMENTS ARE ALMOST UNREADABLE BY PERSONS WITH RED-GREEN COLOR BLINDNESS. APPROXIMATELY 5% TO 10% OF THE MALE POPULATION IS RED-GREEN COLOR BLIND (0.5% TO 1% FOR FEMALES). THE SPEEDOMETER AND TACHOMETER DIALS ARE BLACK WITH WHITE LETTERING AND DEEP RED NEEDLES TO POINT AT THE LETTERING. THAT DEEP RED ON A BLACK BACKGROUND IS ALMOST INVISIBLE. IF I SPEND TIME SEARCHING, I CAN FIND THE NEEDLE, BUT IT IS VERY UNSAFE TO TAKE ONE'S EYES OFF THE ROAD FOR THE LENGTH OF TIME IT TAKES TO FIND THE ALMOST INVISIBLE NEEDLE. AN ARGUMENT OF, "IF YOU CAN'T READ THE INSTRUMENTS, GET A DIFFERENT CAR," IS NOT REASONABLE BECAUSE THE CAR ONE IS DRIVING IS NOT ALWAYS ONE'S OWN CAR, SUCH AS IT MAY BE AN EMPLOYER'S CAR OR (THE WAY I DISCOVERED THIS PROBLEM) IT MAY BE A RENTAL CAR, AND THERE ARE MANY OTHER SCENARIOS WHERE ONE DID NOT CHOOSE THE CAR ONE HAS TO DRIVE. SINCE 5% TO 10% OF THE MALE POPULATION HAS THIS COLOR VISION DEFICIENCY, I CANNOT BELIEVE THAT HYUNDAI NEVER DISCOVERED THE PROBLEM, BUT CHOSE STYLING OVER SAFETY. I ALSO SUSPECT THIS PROBLEM IS NOT LIMITED TO HYUNDAI. *TR

THIS VEHICLE HAD A SERIOUS SAFETY ISSUE OCCUR AROUND 5:00 AM ON JULY 10TH; AS I WAS DRIVING OUT OF MY DRIVEWAY (CAR IN DRIVE AND IN MOTION) ALL POWER FAILED. NO LIGHTS, ACCELERATION, POWER STEERING OR BRAKES, ETC. WHICH WAS A SERIOUS HAZARD ESPECIALLY GIVEN THE DARKNESS AT THAT TIME OF DAY. THIS SAFETY ISSUE FOLLOWED MULTIPLE OCCASIONS WHERE ALL THE POWER FAILED WHEN TRYING TO ENTER THE VEHICLE USING THE PROVIDED KEY FOBS. THESE SITUATIONS COULD ALSO HAVE BEEN DANGEROUS AS ON ONE OCCASION THIS HAPPENED WHILE MY CAR WAS IN AN URBAN PARKING GARAGE IN THE EVENING. IT TOOK APPROXIMATELY 45 MINUTES- 1 HOUR BEFORE THE POWER RESTORED AND I COULD START THE VEHICLE. I BROUGHT IT TO THE DEALERSHIP ON JULY 5TH TO REMEDY THE POWER ISSUE AND THE TECHNICIAN COULD FIND NO ISSUE - THEY SWITCHED OUT THE CAR BATTERY AS A PRECAUTION IN THE EVENT THERE WAS A HAIRLINE CRACK CAUSING THE INTERMITTENT POWER FAILURES. AS OF AUGUST 27TH, THE VEHICLE WAS STILL NOT REPAIRED FROM THE JULY 10TH INCIDENT. DEALERSHIP NOTIFIED ME IT WAS REPLACING THE ENTIRE FUSE BOX AND ENGINE WIRING HARNESS AS THE DIAGNOSED CAUSE OF THE FAILURE. *JB

Mileage: 4,300

IT STARTED AS SOME SMALL SHOCKS FROM DOOR AND STEERING WHEEL. THE VEHICLE NOW SHOCKS YOU FROM JUST ABOUT ANYWHERE YOU STAND. I DID BRING IT TO THE DEALER AND AFTER HAVING FOR OVER 3 DAYS ONLY A OIL CHANGE HAD BEEN DONE. I ASKED TO PICK UP FOR A APPT. I HAD ON SUNDAY AND ALL THREE PAGES OF WHAT WAS TO BE LOOKED AT STATED WORK NOT DONE.I TOLD SERVICE ADVISOR I NEEDED TO GET CAR FIXED BEFORE I DROVE ACROSS COUNTRY, I ASKED TO BRING IT BACK AND HE SAID I THOUGHT YOU WERE LEAVING WHICH I AM BUT VERY CONCERNED ABOUT DRIVING ANY LENGTH BECAUSE IT GETS PAINFUL IF I HAVE TO TURN ON LIGHTS. *TR

Mileage: 4,000

WHILE TRAVELING DOWN THE ROAD AT APPROXIMATELY 50 MPH THE CRANK PULLEY FELL OFF THE MOTOR. THIS PREVENTS THE ALTERNATOR, WATER PUMP AND AC COMPRESSOR FROM FUNCTIONING AS THEY ARE BELT DRIVEN. WITH THE ALTERNATOR NOT FUNCTIONING THE BATTER WILL BE DRAINED TO THE POINT OF DEAD (DEPENDING ON WHAT ACCESSORIES ARE ON) AND WITH THE WATER PUMP NOT FUNCTIONING THE CAR WILL ALMOST IMMEDIATELY OVERHEAT LEAVING THE VEHICLE STRANDED. *TR

Mileage: 313

VEHICLE IN PARK, DRIVERS SIDE WINDOW AND PASSENGER REAR DOES NOT ENGAGE TO BRING DOWN WINDOW. ALSO 2ND INCIDENT ON 10/6/2012, PASSENGER DOOR AND WINDOW DOES NOT UNLOCK TO OPEN FROM INSIDE WHEN VEHICLE PLACED IN PARK. HAVE TAKEN INTO THE DEALER TWO TIMES TO HAVE VEHICLE INSPECTED FOR FAULT. TECHNICIANS HAVE NOT BEEN ABLE TO REPLICATE MIS-FUNCTION. UNSURE IF VEHICLE HAS A DEFECT. *TR

Mileage: 1,756