2010 JEEP PATRIOT Fuel/propulsion System Problems

Fuel System. When I fill the gas tank completely the car will stall within a minute or two. I lose power steering, break booster. I can restart and the car will operate correctly. This has been happening for some time.

Cannot fill gas tank correctly. 30 seconds at a time due to gas tank roll over vale failure according to everything we have found on this issue with other owners. This is a serious problem that needs to be recalled. It cost around 800.00 to replace gas tank.. Please investigate issue and respond to [XXX]. I am doing this for my daughter she needs help with this issue it is a ongoing issue that started about 1 year ago thank you [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Every time I fill my gas tank it takes 20 minutes to fill it just keeps shutting gas off at handle. I have checked a Jeep forum it says it is a roll over valve in gas tank and entire tank has to be replaced at a cost of around 800.00 to 1000.00 dollars. It also caused engine to run rough and shut off a lot. This is something Jeep should have to repair at their cost not consumers. It has been going on for about 6-8 months and it scare me each time it happens Thank you

After filling fuel tank to full, cranking the ignition, shifting into drive, and beginning propulsion, the engine will occasionally stall. This requires me to stop, shift into park, and restart and rev the engine to prevent it from happening again, which it sometimes does. This malfunction often takes place in high-traffic areas such as intersections or onramps to the freeway.

Every time gas is filled to only the first click to stop or no click at all the car will stall after the fill. THE CAR STALLS EVERY TIME NOT ONCE IN AWHILE BUT EVERY TIME AFTER A FILL START IT UP THEN RUNS REAL RUFF AND STALLS AGAIN. Every time it is filled up. The car stalls while getting on the freeway or street. Dealer state it is the fuel roll over sensor built in the fuel tank. Jeep knows this is a problem they are passing the buck on to the car owners. This is a safety issue when the car stalls. I need to pull over every time this happens and it is every time. They have to fix and recall this safety issue.

Premature shutoff during fueling at gas pump (every two- to three-tenths of a gallon), causing long delays at each fill-up. Previous owners have reported diagnoses by certified mechanics of stuck rollover valves, which have been recalled in other Fiat-Chryslet products but not yet for the Jeep Patriot model.

SINCE I BOUGHT MY KEEP IN JULY 2020 .. EVERYTIME I'VE FILLED MY GAS TANK ALL THE WAY .. AT FIRST MY JEEP WOULD DO A LITTLE JUMPING ON REGULAR STREE AS I DRIVE TOWARDS FREEWAY BUT AFTER A LITTLE BIT IT WOULD GO AWAY .. BUT AS I CONTINUE TO DRIVE FOR ABOUT 15 MIN ON FREEWAY MY JEEP BEGINS TO MAKE THIS WHINING SOUND AND THEN MY JEEP WOULD ACCELERATE ABOVE 5 ON ITS OWN (SCARY) THEN WOULD GO BACK TO NORMAL THIS USUALLY WAS WHILE GOING UP A HILL ON FREEWAY .. WHINING CONT. AND ACCELERATING MAY HAPPEN ONCE MORE WHILE GOING UP THE HILL .. THEN MY TRANSMISSION TEMP LIGHT WILL COME ON . I USUALLY PULL OVER TO LET MY CAR REST BECAUSE I'M SCARED TO DRIVE IT AFTER IT HAD A MIND OF IT'S OWN. THIS HAS ONLY HAPPENED AFTER I FILL MY TANK TO THE FULL .PLEASE FIX THIS I'M AFRAID IT WILL BLOW MY ENGINE WHILE ON FREEWAY ! THREE TIMES THIS HAS HAPPENED AFTER A FULL TANK HAS BEEN APPLIED . SO STEP BY STEP I FILL TANK TO FULL AS I DRIVE ON STREET TOWARDS FREEWAY IT WILL JUMP A LITTLE BUT WILL GO AWAY BY TIME I GET ON FREEWAY ONCE ON FREEWAY CAR SEEMS FINE FOR ABOUT 10 -15 MIN THEN I START TO HEAR A WHINING SOUND ALMOST AS IF IT'S STUCK IN A GEAR .. AS I'M DRIVING UP A HILL ON FREEWAY THE WHINING GETS WORSE AND MY RPMS DON'T SEEM TO GO ABOVE 50 THEN MY MY ENGINE WILL JUST ACCELERATE ON ITS OWN ALL THE WAY PASSED 5 .. THEN RETURN TO NORMAL QUICKLY AFTER .. WHINING NOISE CONT. AS I'M STILL DRIVING ABOUT 10 MIN LATER MY TRANSMISSION TEMP LIGHT WILL COME ON . THAT'S WHEN I GET OFF FREEWAY AND PULL OVER TO LET MY CAR REST FOR A LITTLE BIT .. ONCE I GET BACK ON FREEWAY AFTER 10 MIN REST EVERYTHING IS BACK TO NORMAL NO MOR WHINING AND TEMP LIGHT IS GONE .. THIS IS AN ISSUE AFTER FILLING UP MY TANK TO THE FULL!

Mileage: 121,000

EVERYTIME I FILL UP GAS TO FULL, THE ENGINE STALLS ON THE ROAD FOR COUPLE TIMES.

Mileage: 1

EVERY TIME I FEEL MY GAS TANK UP AND DRIVE AWAY, MY VEHICLE BUCKS AND THEN STEERING FREEZES UP AND MY JEEP STALLS. THIS IS VERY SCARY AND HAS GOTTEN WORSE. ESPECIALLY GETTING GAS OFF THE FREEWAY AND GOING ON THE FREEWAY! THIS HAS BEEN HAPPENING FOR ABOUT A YEAR AND HAS GOTTEN WORSE!!! *TR

Mileage: 55,000

THE VEHICLE WILL CONTINUOUSLY STALL AND BUCK WHILE IDLING FOR ABOUT ONE MINUTE AFTER FILLING UP WITH FUEL. THIS HAS OCCASIONALLY HAPPENED ON THE ROAD WHILE THE VEHICLE IS IN MOTION IMMEDIATELY AFTER LEAVING THE GAS STATION. IN THESE CASES, THE DRIVER IS PUT IN A VERY DANGEROUS SITUATIONS, AS THE STEERING WHEEL LOCKS-UP WHEN THE CAR STALLS. THE CAR IS NEVER "TOPPED-OFF" BUT FILLED UNTIL THE FIRST PUMP CLICK. AFTER ABOUT A MINUTE, THE PROBLEM WILL RESOLVE AND THE VEHICLE WILL RUN FINE UNTIL THE NEXT FUELING. THE EXACT CAUSE IS UNKNOWN, BUT THE EVAP SYSTEM OR FUEL TANK ROLLOVER-VALVE IS SUSPECTED AS THE CULPRIT. THIS IS AN EXTREMELY DANGEROUS PROBLEM THAT MANY OTHER JEEP PATRIOT OWNERS EXPERIENCE AND NEEDS TO BE DEALT WITH. *TR

Mileage: 116,000

AFTER FUELING THE CAR, THE ENGINE STALLS AND THE CAR STOPS FREQUENTLY. IN TRAFFIC AND CAUSING A SERIOUS HAZARD TO ME, MY PASSENGERS AND THE OTHER DRIVERS IN THE AREA. THE CAR WOULD SPUTTER AND STALL AT STOP SIGNS AND LIGHTS, WHEN STOPPED, WHEN SLOWING (UNDER 40 MPH) AND WHEN ACCELERATING FROM A SLOW DOWN OR STOP.

Mileage: 70,000

VEHICLE STALLS ON IDLE AFTER FILLING UP THE TANK. DOESN'T STALL WHEN IN MOTION. THE PROBLEM USUALLY OCCURS A FEW MILES AFTER FILLING UP THE TANK; ON A STOP LIGHT, STOP SIGN, ETC. IT IS INTERMITTENT AND MOSTLY HAPPENS AFTER REFUELING.

Mileage: 85,237

STUCK ROLLOVER VALVE. 86,000 MILES. ROLLOVER VALVE IS INSIDE GAS TANK, CASUING REPLACEMENT OF ENTIRE TANK. MANY OTHERS ONLINE NOTE SAME PROBLEM FOR THE PATRIOT. JEEP RECALLED OTHER MODELS FOR THE SAME PROBLEM BUT NOT THE PATRIOT.

Mileage: 86,000

GAS TANK CANNOT BE FILLED UP ALL THE WAY AS THE CAR STALLS AND TURNS OFF IN LESS THEN A MILE. THE CAR HAS NO ACCELERATION MORE THEN 20MHP AND TAKES A LONG TIME IN GAINING SPEED WHEN TRYING TO TAKE OFF AFTER A STOP AND WHEN CHANGING LANES. CAR LACKS POWER WHEN DRIVING ON HIGHWAYS, CREATING TRAFFIC AND PANIC IN THE DRIVER. CAR IS A HAZARD ON THE ROAD AND MECHANICS ARE AWARE BUT NO ONE SEEMS TO FIND THE ISSUE AND CORRECT.

Mileage: 75,000

WHEN I FILL THE GAS TANK ALL THE WAY, THE JEEP STALLS SHORTLY AFTERWARD. THAT TURNS OFF THE POWER STEERING. IT'S VERY DANGEROUS. POTENTIALLY DEADLY IF IT HAPPENS WHILE CORNERING AT HIGHER SPEEDS. FORUMS ONLINE ARE SAYING THAT IT'S A MANUFACTURER FLAW IN THE ROLLOVER VALVE INSIDE THE GAS TANK, AND THAT THE ONLY WAY TO FIX IT, IS TO REPLACE THE TANK. THAT IS A VERY EXPENSIVE REPAIR. THE FORUMS INDICATE THAT IT IS BECOMING A VERY COMMON PROBLEM. I FEEL THAT JEEP SHOULD ISSUE A RECALL ON THIS DANGEROUS FACTORY FLAW AND PAY FOR THE REPAIRS.

Mileage: 92,000

TL* THE CONTACT OWNS A 2010 JEEP PATRIOT. AFTER THE CONTACT REFILLED THE FUEL TANK, THE VEHICLE SUDDENLY SHUT OFF WHILE ACCELERATING. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER AND MANUFACTURER WERE NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 74,000.

Mileage: 74,000

TL* THE CONTACT OWNS A 2010 JEEP PATRIOT. AFTER FILLING THE FUEL TANK, THE VEHICLE SUDDENLY SHUT OFF. THE VEHICLE WAS TAKEN TO TAYLOR AUTOMOTIVE (11989 HWY 22, MARTIN, TN) WHERE THEY REPLACED THE FUEL CAP AND PARTS RELATED TO THE FUEL SYSTEM, BUT THE FAILURE CONTINUED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES, BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 110,000. THE VIN WAS INVALID.

Mileage: 110,000

EVERY TIME THAT I FILL THE FUEL TANK, MY JEEP STALLS ONE TO THREE TIMES WITHIN THE FIRST COUPLE MILES. THIS CAN HAPPEN AT A STOP LIGHT, DRIVING OUT OF A PARKING LOT, OR WHILE MAKING A LOW SPEED TURN. I HAVEN'T BEEN INVOLVED IN AN ACCIDENT DUE TO THIS ISSUE YET, BUT THERE HAVE BEEN CLOSE CALLS TO DATE. I TOOK MY VEHICLE TO A MECHANIC TO GET THE ISSUE DIAGNOSED AND I WAS INFORMED THAT IT IS DUE TO A FAULTY ROLL OVER VALVE LOCATED ON TOP OF THE FUEL TANK. THE ONLY WAY TO CORRECT THE ISSUE IS TO REPLACE THE FUEL TANK WHICH IS VERY COSTLY.

Mileage: 94,376

AFTER FILLING UP WITH GAS CAR STUMBLES AND DIES AT STOPS FOR ABOUT FIVE MINUTES MINUTES AFTERWARDS. THIS PROCEDURE GOES ON FOR ABOUT TEN MILES ALL I READ SAYS IT IS A SAFETY VALVE ON TOP OFF GAS TANK. ONLY WAY TO FIX IS RELACE THE WHOLE GAS TANK. THIS HAPPENS WHEN VEHICLE IS IN MOTION OR JUST SETTING IDLELING. RPM STARTS TO DECREACE AND SMOTHERS PLUM OUT. I PURCHASED THIS VEHICLE USED IT HAS DONE THIS EVER SINCE IVE OWNED IT.

Mileage: 145,000

THE CAR STALLS AFTER FILLING UP THE TANK. HAS HAPPENED SEVERAL TIMES.

Mileage: 65,000

MY JEEP STALLS AFTER FILLING TANK WITH GAS AND I BELIEVE IT IS A FAULTY VALVE INSIDE THE TANK ITSELF WHICH REQUIRES REPLACEMENT OF THE ENTIRE TANK AND SHOULD BE A RECALL--THIS IS A SAFETY ISSUE AS IT CAUSES THE VEHICLE TO STALL WHILE DRIVING AWAY FROM GAS STATION. SAW THIS ALERT FOR 2012 MODELS BUT IT IS THE SAME ISSUE HTTPS://AUTOWEEK.COM/ARTICLE/CAR-NEWS/2012-JEEP-COMPASS-AND-PATRIOT-BE-RECALLED-FUEL-TANK-PROBLEM#IXZZ5SDMM78OJ

Mileage: 80,000

I HAVE A 2010 JEEP PATRIOT AND IT HAS BEEN HAVING RANDOM ISSUES THAT IT TURNS OUT ARE RELATED TO A FAILED TIPM WHICH CHRYSLER KNOWS ABOUT AND IS NOT ADDRESSING. MY HORN RANDOMLY HONKS, THE AIRBAGS DID NOT DEPLOY IN A RECENT SMALL ACCIDENT, AND NOW THE CAR WON'T START. ALL OF THESE ITEMS ARE NOTED AS RELATED TO A FAILING TIPM AND ALL CAN BE FOUND ALL OVER THE INTERNET WHEN SEARCHING FOR "2010 JEEP PATRIOT WON'T START". BASED ON THE MOST RECENT PROBLEM (NO STARTING), I REPLACED THE BATTERY AND THE STARTER WITH NO FIX. JEEP SHOULD HAVE TO FIX THIS IF THEY HAVE KNOWN ABOUT IT AND THE POTENTIALLY DANGEROUS IMPLICATIONS. RIGHT NOW THE CAR IS PARKED IN MY DRIVEWAY BECAUSE I HAD TO GET IT TOWED HOME.

Mileage: 144,000

SINCE FEBRUARY 5TH, 2018, MY 2010 PATRIOT HAS BEEN IN THE SHOP 3 TIMES FOR STALLING ISSUES, ALL SEEMINGLY AFTER FILLING MY GAS TANK. THE STALLING HAPPENS WITHIN MOMENTS AFTER DRIVING AWAY FROM THE GAS PUMP, AND MY VEHICLE NEEDS TO BE TOWED EACH TIME, COSTING ME EVERY TIME. VARIOUS 'FIXES' HAVE BEEN MADE, INCLUDING NEW SPARK PLUGS, TRANSMISSION FUEL CHANGE AND MOST RECENTLY, A ESIM AND DETECTOR. THE LATEST MECHANIC AT THE JEEP DEALER THAT REPAIRS MY VEHICLE SAID THE ISSUE WAS FROM GASOLINE GETTING INTO THE ESIM AND CAUSING A SAFETY STALL. FROM OTHERS I HAVE READ FROM, THIS ISSUE IS VERY COMMON AND NEEDS TO BE FIXED PERMANENTLY AND CORRECT FOR OWNERS, IN PREVENTION OF INJURY OR DEATH. SOME I HAVE READ FROM MENTION THE ROLLOVER VALVE IN THE GAS TANK NEEDS REPLACEMENT, WHICH WOULD THEREFOR REQUIRE THE ENTIRE GAS TANK TO NEED REPLACEMENT, A HEFTY PRICE FOR SOMETHING THAT SEEMS TO BE THE ERROR ON CHRYSLERS' BEHALF. I NO LONGER FEEL SAFE TO GO ON LONG TRIPS WITH MY VEHICLE, WHICH I PURCHASED PRE OWNED JUST LAST YEAR. PLEASE TAKE ACTION ON THIS ISSUE AS I KNOW MANY OWNERS ARE SUFFERING FROM THE SAME ISSUE THAT CAN BE DANGEROUS.

Mileage: 105,500

EVERY TIME I FILLUP MY JEEP I GET WITHIN 1 MILE OF GAS STATION IT BEGINS TO STALL. THIS HAPPENED EVERYTIME I FILL UP FOR THE PAST 5 YEARS. THE JEEP WILL JUST SHUTOFF AND THE POWER STEERING STOPS WORKING BEING THAT IT STALLED. THIS HAS ALMOST CAUSED ME TO CRASH MANY TIMES AND TO GET THE PROBLEM FIXED JEEP DEALERSHIP SAID I WOULD HAVE TO REPLACE THE ENTIRE GAS TANK. DOING SOME RESEARCH LOTS OF PEOPLE ARE COMPLAINING ABOUT THIS HAPPENING TO THEM AND BEING VERY COSTLY TO FIX. THE ITEM THAT NEEDS TO BE FIXED IS THE (FUEL TANK ROLLOVER VALVE) JEEP DOESN'T MAKE A REPLACEMENT PART FOR THIS AND THAT IS WHY YOU HAVE TO REPLACE THE ENTIRE FUEL TANK. BELOW IS A WEBSITE ABOUT THE PROBLEM HTTPS://WWW.CARGURUS.COM/CARS/DISCUSSION-T29898_DS631498 HTTP://WWW.JEEPFORUM.COM/FORUM/F11/GAS-FILL-PUMP-PUMP-SHUTTING-OFF-WHILE-FILLING-1447396/

Mileage: 75,000

WHEN TRYING TO FILL THE GAS TANK IN A STOPPED POSITION WITH THE VEHICLE TURNED OFF, THE HOSE CONTINUALLY SHUTS OFF AS IF THE TANK IS FULL WHEN IT IS NOT. PRIOR TO THIS ISSUE, THE CAR WOULD SOMETIMES SHUTTER AND FEEL LIKE IT WAS GOING TO STALL OUT AFTER FILLING THE TANK.

Mileage: 66,000

ADDING FUEL TO VEHICLE TANK RESULTS IN FUEL GUSHING OUT OF FUEL FILLER PIPE. IT APPEARS THE FUEL TANK CANNOT VENT THE AIR IN THE TANK AS NEW FUEL IS ADDED AND THIS FORCES NEWLY ADDED FUEL BACK OUT OF THE FILLER PIPE. THIS IS A VERY DANGEROUS AND COMMON PROBLEM REGARDING FAULTY ROLLOVER VALVES ON THE FUEL TANK ON SEVERAL JEEP MODELS/YEARS ACCORDING TO ONLINE FORUMS .

Mileage: 148,000

CAN NOT PUT FUEL INTO THE GAS TANK. THE PUMP SHUTS OFF EVERY FEW SECONDS DUE TO BACK PRESSURE. A MECHANIC CHECKED THE SYSTEM AND SAID THE PROBLEM WAS A STUCK ROLL OVER VALVE INSIDE THE FUEL TANK AND THE ENTIRE GAS TANK WOULD HAVE TO BE REPLACED AT A COST OF $1400. WHEN THIS HAPPENS, GAS SPLASHES OUT ONTO CAR AND ANYONE TRYING TO FILL THE TANK. SPILLING GASOLINE ON THE OUTSIDE OF THE CAR AN MYSELF IS A SAFETY HAZARD!

Mileage: 82,000

FUEL SPEWS OUT EVERY TIME I TRY TO PUT GAS IN THE VEHICLE. I AM ONLY ABLE TO PUT 20 OR 30 CENTS IN AT A TIME. THIS STARTED ON 11/01/16 TO PRESENT TIME AND HAPPENS EVERY TIME I TRY TO PUT FUEL IN TANK.

Mileage: 70,000

GAS TANK ROLL OVER VALVE: THERE SEEMS TO BE A DEFECTIVE COMPONENT AT THE TOP OF THE GAS TANK WHICH IS CAUSING THE VEHICLE TO STALL AT LEAST ONCE AFTER FILLING UP THE GAS TANK. THIS IS A SAFETY ISSUE AND SHOULD BE RECALLED AS IT AFFECTS A LOT OF VEHICLES BASED ON MY SEARCHES.

Mileage: 75,000

DRIVING ON THE INTERSTATE AND AUTO SUDDENLY LOST POWER ALTHOUGH ENGINE WAS STILL RUNNING IT WOULD JUST IDLE, EVEN WITH THE GAS PEDAL ALL THE WAY TO THE FLOOR, TURNED AUTO OFF AND LET IT SET FOR A FEW MINUTES AND WHEN IT RESTARTED IT APPEARED TO BE OK, WOULD TAKE GAS, THEN ON 3-19-2015 THIS HAPPENED 3 DIFFERENT TIMES WITHIN A 150 MILES ON THE INTERSTATE,WOULD HAVE TO UNHOOK THE BATTERY AND RECONNECT IT BEFORE THE PROBLEM WOULD CLEAR UP, THEN DRIVE IT JUST A BIT MORE AND IT WOULD HAPPEN AGAIN. *TR

Mileage: 75,000

MY 2010 PATRIOT LIMITED STALLS ALL THE TIME. IT GETS WORSE WHILE SITTING AT A RED LIGHT. I HAVE TO PUT THE CAR IN NEUTRAL, REV UP THE ENGINE SO IT DOES NOT GO DEAD. IT SEEMS TO GET WORSE IF THE GAS TANK IS BELOW 1/2 TANK. ALSO I REALLY THOUGHT SOMEONE WAS STEALING MY GAS BECAUSE THE GAUGE GOES UP AND DOWN. ALL THE INFO I HAVE LOOKED UP IT'S ALL JEEP PRODUCTS 2010 2011 2012 2013 ALL HAVE THE SAME PROBLEMS. *TR

Mileage: 49,000