2008 JEEP WRANGLER 2-DR 4X4 Fuel System, Gasoline Problems

WHEN FILLING THE FUEL TANK GAS ALWAYS COMES SPILLING OUT OF THE FILLER HOLE. IT DOES NOT MATTER IF YOU ARE HOLDING THE PUMP HANDLE WITH YOUR HAND OR LETTING THE PUMP SHUT OFF AUTOMATICALLY. THERE SEEMS TO BE SOME STRANGE BUBBLE EFFECT AND THE GASOLINE BURPS BACK OUT OF THE FILLER HOLE AND SPRAYS ALL OVER THE GROUND, THE SIDE OF THE VEHICLE AND ANYONE STANDING CLOSE TO THE VEHICLE WHILE IT'S BEING FUELED. I FILED A COMPLAINT THREE MONTHS AGO AND RECEIVED NO RESPONSE. THIS IS A VERY SERIOUS ISSUE.. COULD RESULT IN FIRE, LOSS OF PROPERTY OR DEATH. *TR

Mileage: 74,000

WHEN EVER I FILL UP WITH GAS, FUEL SPITS BACK OUT AT ME. *TR

Mileage: 30,000

I HAVE OWNED THIS JEEP SINCE EARLY MAY OF 2013. WHENEVER I GO TO THE GAS STATION AND FILL THE TANK GAS ALWAYS OVERFLOWS FROM THE FILLING NECK. WHEN PUMPING GAS WHEN THE TANK REACHES FULL THERE IS A BUBBLE EFFECT AND YOU CAN EFFECTIVELY HEAR THE FILLER NECK BURP THEN IT SPEWS FUEL ALL OVER THE GROUND, SIDE OF THE VEHICLE AND ANYONE STANDING CLOSE TO THE FUEL DOOR. *TR

Mileage: 80,123

WHEN FILLING UP THE VEHICLE AT ANY AND ALL GAS STATIONS, WHEN THE FUEL PUMP HANDLE CLICKS OFF AUTOMATICALLY, A FAIRLY LARGE SPLASH-BACK OF GASOLINE EXITS THE FILLER PORT AND FLOWS ONTO THE VEHICLE, MY HAND, AND THE GROUND. *TR

Mileage: 24,000

STARTING MONTHS AGO WHENVER I FILL MY TANK AT THE GAS STATION, FUEL OVERFILLS WHEN FULL. IT HAPPENS AT EVERY STATION NOW EVERYTIME. I CAN PUT THE FILL LEVER AT A LOWER FILL RATE AND IT STILL HAPPENS. I HAVE THE FILL NOZZLE IN ALL THE WAY OR OUT HALF WAY OR IN BETWEEN AND IT DOES NOT MATTER. IT LEAKS OUT ABOUT 6 - 12 OZ DOWN THE VEHICLE. THE ENTIRE VEHICLE SMELLS LIKE GAS EVERYTIME. *TR

WHEN PUTTING FUEL IN THE VEHICLE, IT SPITS THE FUEL BACK OUT...TAKES ABOUT 20 MINUTES TO FILL UP AND BEING VERY CAREFUL. *TR

Mileage: 27,000

GAS OVERFLOWS AND SPILLS OUT OF GAS TANK EVERYTIME I FUEL UP. SAW NO RECALL BUT JUST STARTED READING OTHER PEOPLE HAVING THE SAME PROBLEM. THERE IS A TSB ON IT I READ BUT ONLY FOR ONES BUILT BETWEEN MARCH 2007 AND MARCH 2008 BUT MINE WAS ON APRIL 2008. THERE SHOULD BE A RECALL ON THIS. IT IS NOT SAFE. THANK YOU *TR

I CURRENTLY DO NOT HAVE THE CORRECT DATE OF THE FIRST OCCURANCE, BUT SINCE I HAVE BOUGHT THIS JEEP I HAVE HAD IT IN THE SHOP MORE THAN 10 TIMES FOR A WATER LEAK ( THE MAJOR ISSUE ). THEN RIGHT AFTER I BOUGHT IT I WAS COMING OFF OF THE BAY BRIDGE IN MARYLAND, AND THE STREERING STRUT BROKE CAUSING DIFFICULTY STEERING. THE PRESSURE PLATE IN THE TRANSMISSION WENT BAD, THE GAS TANK HAD TO BE REPLACED, MY SEAT BROKE TWICE, THE BOOT AROUND THE GEAR SHIFT HAD TO BE REPLACED. THE LIST GOES ON AND ON. IT WAS JUST IN THE SHOP ON FRIDAY TO HAVE THE WATER LEAK IN THE DOOR AND ROOF REPAIRED AGAIN. I TRIED TO FILE FOR THE LEMON LAW WHEN THIS FIRST STARTED AND THEY TOLD ME MY VEHICLE DID NOT QUALIFY. I HAVE BEEN IN TOUCH WITH CHRYSLER TO MAKE THEM AWARE OF ALL I HAVE BEEN THROUGH AND THEY GET ME AN APPOINTMENT AT THE DEALER ( BIG DEAL ) THEY ACT LIKE THEY COULD CARE LESS. I WAS TOLD BY THE MANAGER AT THE DEALERSHIP THAT HE HAD GONE TO A MEETING THE OTHER DAY AND THAT CHRYSLER HAD "BIG PROBLEMS", APPARENTLY THEY HAVE DISCOVERED THE WINDSHIELDS ARE OFF BY 1/8 OF AN INCH CAUSING ALL THESE VEHICLES TO LEAK! SHOULDNT THAT BE A RECALL. I HAVE LOST MORE TIME FROM WORK AND MORE HEADACHES WITHOUT A CAR THAN ENOUGH. THEY SHOULD BUY THIS VEHICLE BACK FROM ME AT THE PRICE I SCREWED BUYING IT! *TR

WHEN FILLING WITH GAS, BEFORE THE TANK APPROACHES FULL, GASOLINE SPEWS OUT AROUND THE FILLER NOZZLE ALL OVER THE SIDE OF THE JEEP. NOW THAT THIS PROBLEM HAS STARTED, IT OCCURS EVERY TIME I FILL UP. I HAVE HAD THE JEEP FOR ABOUT A YEAR AND IT WAS FINE UNTIL RECENTLY. CHRYSLER HAS EXTENDED THE WARRANTY FOR JEEPS WITH THIS PROBLEM FOR JEEPS MADE BETWEEN MARCH 2007 AND MARCH 2008. MY JEEP WAS MADE IN MAY OF 2008 SO IT IS NOT COVERED. I HAVE READ ON THE NET THAT MANY PEOPLE WITH THIS ISSUE HAVE HAD THE GAS TANK REPLACED AND IT HAS SOLVED THIS PROBLEM. THIS IS A DANGEROUS SITUATION AND I AM NOT SURE WHAT TO DO ABOUT IT. *TR

Mileage: 24,755

ON SEPTEMBER 10, 2008 I PURCHASED A NEW 2008 JEEP WRANGLER FROM MY LOCAL DEALER. IT HAS HAD MODEST USE UNDER NORMAL DRIVING CONDITIONS AND HAS BEEN PROPERLY MAINTAINED. IT HAS APPROXIMATELY 18,500 MILES ON IT. I HAVE HAD NO PROBLEMS WITH THE VEHICLE, EXCEPT A MONTH AGO I STARTED EXPERIENCING PROBLEMS WITH THE GAS SHOOTING OUT OF THE TANK NEAR THE END OF FILLING UP. I COULD AVOID THE PROBLEM ONLY IF I SHUT OFF THE GAS AS IT NEARED THE TOP (BEFORE THE POINT WHEN IT IS SHUT OFF BY THE NOZZLE??S OWN MECHANISM). HOWEVER IF I FILLED THE TANK ON THE JEEP AS I DO ON OUR OTHER CAR (AND AS I DID ON THE JEEP PRIOR TO LAST MONTH), THE GAS WOULD SHOOT OUT OF THE TANK, SPILLING ON THE SIDE AND ON MY FINGERS, AND ON ONE OCCASION, ON MY PANT LEG. I CONSIDER THIS PROBLEM OF GAS SPILLING OUTSIDE THE CAR A VERY DANGEROUS CONDITION WHICH NEEDS TO BE REMEDIED. I HAD NOT RECEIVED ANY RECALL OR SERVICE ACTION NOTICES FROM THE MANUFACTURER ABOUT THIS PROBLEM. SO I DID AN INTERNET SEARCH AND DISCOVERED THAT THERE HAD BEEN A NUMBER OF OTHER PEOPLE EXPERIENCING THE SAME PROBLEM AND THAT THE MANUFACTURER HAD ISSUED A RECALL FOR 2007 AND 2008 WRANGLERS MANUFACTURED BETWEEN MARCH 2007-MARCH 2008. I CHECKED MY VEHICLE AND DETERMINED IT WAS MANUFACTURED IN MAY 2008. HOWEVER THE PROBLEM WAS THE IDENTICAL PROBLEM COMPLAINED ABOUT AND WHICH WAS THE SUBJECT OF THE RECALL. I THEREFORE CONTACTED MY DEALER AND WAS EVENTUALLY ADVISED THAT THEY WOULD REPLACE THE FUEL TANK AS AN EMISSION PROBLEM COVERED BY A LIFETIME WARRANTY. I WOULD CERTAINLY THINK IT ADVISABLE FOR THE MANUFACTURER BE REQUIRED TO NOTIFY ITS OWNERS OF THIS PROBLEM AND/OR ISSUE A RECALL OF THE AFFECTED VEHICLES. PLEASE NOTE THAT ISSUES RELATING TO VEHICLE DEFECTS AND RECALLS IS NOT PART OF MY PROFESSIONAL PRACTICE AND I HAVE NO INTEREST IN THIS MATTER OTHER THAN BEING A SINGLE JEEP OWNER. *TR

Mileage: 18,500

JUST PURCHASED A 2008 RUBICON AND WHEN I GO TO FILL UP THE GAS TANK, THERE IS ALWAYS OVERFLOW AFTER THE PUMP SHUTS OFF DUE TO BEING FULL. THE GAS SPLASHED OUT ALL OVER MY PANTS LEG THE FIRST TIME AND STILL OVERFLOWS ONTO THE SIDE OF THE CAR AND PAVEMENT. *TR

WHEN YOU FILL THE JEEP UP IT ALWAYS SPITS FUEL ON THE GROUND AND YOU IF YOUR STANDING TOO CLOSE. NOT A LITTLE A LOT. *TR

FUEL DOES NOT SHUT-OFF AT FUEL PUMP AND GAS SPILLS OUT EVERY TIME I RE-FUEL. THE DEALERSHIP DIDN'T FIX THIS WHEN I RECENTLY HAD THE VEHICLE SERVICED BECAUSE IT WASN'T A RE-CALL. I HAVE SINCE COMPLAINED AND IT WILL BE FIXED UNDER WARRANTY DURING MY NEXT VISIT. *TT

Mileage: 22,000

THE VEHICLE WHEN FILLING WITH GASOLINE OVERFLOWS EACH AND EVERY TIME REGARDLESS OF FILLING STATION USED. THIS IS A KNOWN JEEP WRANGLER PROBLEM FOR 2007-2008 MODELS BUT CHRYSLER IS NOT CORRECTING THE PROBLEM FOR VEHICLES BUILT AFTER MARCH 31,2008. MY BUILD DATE IS 06-08. I DON'T KNOW WHAT CHANGED AFTER 3/31/08 BUT THE PROBLEM EXISTS FOR JEEPS BUILT AFTER THAT DATE. THIS IS AN EXTREMELY DANGEROUS CONDITION BOTH PUBLIC SAFETY AND ENVIRONMENTAL. DEALER WANTS $100 TO DIAGNOSE PROBLEM. CHRYSLER NEEDS TO STEP UP AND FIX THIS KNOWN SAFETY DEFECT. *TT

Mileage: 40,000

2008 JEEP JK GAS FILLER TUBE OVERFLOWS WHEN AUTOMATIC GAS SHUTOFF OCCURS DURING REFUELING EVERYTIME. IT HAS OCCURRED AT MANY DIFFERENT GAS STATIONS AND PUMPS. GAS COMES OUT AND COATS THE VEHICLE AND GROUND. *TR

Mileage: 100

GAS OVERFLOW AT TIME OF VEHICLE FILLUP. *TR

Mileage: 40,000

UPON FILLING THE VEHICLE WITH FUEL, GAS OVERFLOWS FROM THE FUELING NECK ONTO THE GROUND, VEHICLE, AND PERSON FUELING. ALSO, MANUAL TRANSMISSION GEAR WILL POP OUT OF FIRST GEAR ON ITS OWN. *TR

2008 JEEP WRANGLER MANUAL TRANS CAUGHT ON FIRE WHILE I WAS DRIVING. *TR

Mileage: 39,000

FUEL SPILL BACK DURING REFUELING. GASOLINE SPLASHES OUT AFTER TANK IS FULL, SOAKING VEHICLE AND ANYONE STANDING NEAR. TSB#14-001-011 COVERS PROBLEM BUT MY VEHICLE'S BUILT DATE IS ONE DAY OFF. PROBLEM STILL EXIST FOR MY VEHICLE. *TR

I HAVE A 2008 JEEP WRANGLER, I GET GAS SPILLAGE EACH TIME I FILL UP THE TANK. CHRYSLER HAS ISSUED AN EXTENDED WARRANTY FOR CERTAIN 2007 & 2008 WRANGLERS BUT MINE IS NOT INCLUDED. CHRYSLER NEEDS TO MAKE GOOD ON ALL VEHICLES THAT ARE HAVING THIS PROBLEM AND NOT JUST PICK A FEW TO FIX. PLEASE HEAR MY PLEA AS I AM RETIRED AND LIVING ON A FIXED INCOME AND IT IS VERY DIFFICULT TO MAKE REPAIRS ESPECIALLY WHEN IT IS A FAR REACHING PROBLEM. *TR

Mileage: 42,000

2008 JEEP JK GAS FILLER TUBE OVERFLOWS WHEN AUTOMATIC GAS SHUTOFF OCCURS DURING REFUELING EVERYTIME. IT HAS OCCURRED AT MANY DIFFERENT GAS STATIONS AND PUMPS. GAS COMES OUT AND COATS THE VEHICLE AND GROUND. *TR

Mileage: 12,000

2008 JEEP WRANGLER JK FUEL SPILLS OUT OF FILLER NECK AT THE END OF FUELING PROCESS. HAPPENS ON EVERY FILL-UP. *TR

Mileage: 11,000

WHEN I FUEL UP AFTER IT STOPS IT WILL SHOOT OUT THE FILLER NECK. *TR

Mileage: 18,000

MY 2008 JEEP WRANGLER JK 2 DOOR SAHARA OVERFLOWS WHILE FILLING UP WITH GAS. IT HAPPENED SPORADICALLY OVER THE LAST 2.5 YEARS, BUT IN THE LAST 6 MONTHS IT HAS HAPPENED EVERY OTHER FILL-UP. THE LAST 5 FILL-UPS ALL OVERFLOWED SPILLING GAS ON THE SIDE OF MY VEHICLE AND ON THE GROUND. I CONTACTED MY DEALER AND THEY ORDERED A NEW GAS TANK AND A "TUBE"... WAITING TO SEE IF THAT RECTIFIES THE PROBLEM. SEVERAL OTHER JEEP OWNERS, SPECIFICALLY ON JK FORUMS HAVE NOTED THE SAME ISSUE AND DIRECTED ME TO THIS WEBSITE TO FILE A CONCERN. *TR

Mileage: 20,000

WHILE FUELING MY VEHICLE, IT OVERFLOWS GASOLINE AS THE TANK APPROACHES FULL AND THE NOZZLE SHUTS OFF. *TR

Mileage: 44,000

FUEL SPIT-BACK. *TR

Mileage: 3,000

GAS TANK OVERFLOW AND SPRAY WHEN FILLING UP. *TR

Mileage: 58,300

EVERY TIME I FILL UP MY 2008 JEEP WRANGLER, FUEL SPILLS OUT OF THE FILLER NECK. I TOOK THE JEEP TO THE DEALER WHO TOLD ME THAT THE VENT VALVE IN THE FUEL TANK IS STICKING AND THAT I NEEDED TO REPLACE THE ENTIRE TANK TO CORRECT THE PROBLEM. *LN

Mileage: 30,000

AT APPROXIMATELY 30,000 MILES A PROBLEM STARTED WHERE I CAN NO LONGER "FILL" MY GAS TANK BECAUSE NO GAS PUMPS WILL STOP ON THEIR OWN. ONCE THE TANK IS FULL GAS WILL CONTINUE TO PUMP UNTIL I PHYSICALLY STOP THE PUMP. THIS DID NOT HAPPEN FOR THE FIRST 30,000 MILES AND JUST STARTED TO HAPPEN FOR NO APPARENT REASON. I NOW JUDGE HOW MUCH GAS I THINK I NEED AND STOP THE PUMP PREMATURELY. *TR

Mileage: 30,000

EVERYTIME WHEN FILLING UP AT A GAS STATION THE NOZZLE CLICKS OFF AND THEN GAS SPEWS OUT OF THE FILLER NECK APPROX 2 CUPS. *TR

Mileage: 21,000

FUEL OVERFLOW WHEN FILLING UP WITH GAS. THE PUMP DOESN'T SHUT OFF UNTIL AFTER IT HAS SPILLED ALL OVER THE GROUND AND SIDE OF THE VEHICLE. HAPPENS ON A REGULAR BASIS. *LN

STARTING AT 35K MILES ON MY 2008 JEEP WRANGLER...EACH FILL UP AT THE GAS STATION, GAS WOULD SPEW OUT AFTER THE GAS PUMP WOULD CLICK OFF. THIS IS A VERY HAZARDOUS CONDITION. THE ONLY WAY NOT TO HAVE THE GAS SPILL OUT IS TO NOT FILL THE TANK UP. A DEFINITE FLAW IN DESIGN AS I'VE BEEN READING ITS HAPPENING TO LOTS OF JEEP OWNERS FROM 2007-2010. *TR

Mileage: 35,000

EVERY TIME I FILL THE TANK ON MY 2008 JEEP WRANGLER A SIGNIFICANT AMOUNT OF FUEL OVERFLOWS OUT OF THE TANK. THIS IS A SERIOUS HEALTH AND SAFETY ISSUE. THIS PROBLEM OCCURS WHEN I FILL THE TANK MYSELF OR WHEN AN ATTENDANT FILLS IT. I HAVE BEEN TOLD BY THE ATTENDANT AT MY LOCAL STATION THAT THIS IS COMMON TO THIS MAKE AND MODEL. *TR

IF I FILL UP MY 2008 JEEP WRANGLER THE GAS OVERFLOWS AND SHOOTS BACK OUT OF THE TANK AT THE END. *TR

Mileage: 10,000

EVERY TIME I FILL UP WITH GAS, MY 08 JEEP WRANGLER 2DOOR WILL OVERFILL. IT DOESN'T MATTER WHAT STATION I AM AT, OR HOW MUCH GAS WAS IN THE TANK PREVIOUSLY. IT WILL ALWAYS SPEW ABOUT A CUP OF GAS ON THE SIDE OF THE VEHICLE AND PAVEMENT UPON FILLING. HTTP://WWW.YOUTUBE.COM/WATCH?V=V6W487ONKSO THE LINK IS TO A VIDEO I FOUND OF A PERSON THAT HAS A SIMILAR PROBLEM, ALSO WITH A WRANGLER. *TR

Mileage: 32,000

JEEP WRANGLER 2008, GAS TANK OVERFLOWS UPON EVERY FILL UP, SHOOTS GASOLINE ONTO THE HANDS, ARM AND POTENTIALLY THE FACE. THE OCCURS EVERY TIME I FILL UP MY JEEP, AND IS A POTENTIAL FIRE HAZARD. *TR

Mileage: 36,000

EVERY TIME I FILL MY JEEP WRANGLER MY GAS TANK WILL OVERFLOW. THE GAS PUMP WILL STOP, RECOGNIZING THAT THE TANK IS FULL, BUT THE TANK WILL OVERFLOW WITH ABOUT 1-2 CUPS OF GASOLINE. THIS IS HAPPENED AT EVERY GAS STATION I GO TO. I FEEL THAT THIS IS A FIRE AND ENVIRONMENTAL HAZARD. THIS PROBLEM HAS BEEN OCCURRING FOR THE PAST 6 MONTHS. *TR

FUEL SPILLS FROM THE FUEL FILLER DURING FUELING. WHEN THE NOZZLE CLICKS OFF, FUEL OVERFLOWS AND SPLASHES AND SPILLS OUT THE FILLER AND ALL OVER THE VEHICLE. *TR

Mileage: 32,000

GAS TANK OVERFLOWS WHEN I FILL UP ON MY 08 WRANGLER. *TR

Mileage: 20,000

GAS SHOOTS BACK OUT OF THE FILLER NECK ONTO ME, THE JEEP, & THE GROUND BEFORE THE PUMP CUTS OFF EVERY TIME I FILL IT UP. THIS JUST STARTED A FEW MONTHS AGO. I BOUGHT THE JEEP FROM A FRIEND WHO PURCHASED IT NEW, & SHE SAID THAT IT HAD JUST STARTED DOING IT A FEW WEEKS BEFORE I GOT IT FROM THEM. IT NEVER HAPPENED UNTIL THE JEEP GOT ABOUT 40,000 MILES ON IT. *TR

Mileage: 40,000

GASOLINE OVERFLOWS FROM FILLER NECK EVERYTIME WE FILL UP THE JEEP. CAUSING GASOLINE TO SHOOT OUT ALL OVER THE PERSON FILLING UP THE SIDE OF THE JEEP AND ONTO THE GROUND. THIS HAPPENS EVERYTIME. *TR

Mileage: 25,000

WHEN FILLING UP THE GASOLINE TANK ON MY 2008 JEEP WRANGLER X 2-DR, THE GAS PUMP DOES NOT AUTOMATICALLY STOP AND THE GAS POURS BACK OUT OF THE FILLER HOLE AND RUNS DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND. THIS NEVER HAPPENED FOR THE FIRST FEW MONTH OF OWNING THE JEEP BRAND NEW FROM THE DEALER, OVER TIME IT HAS GOTTEN SIGNIFICANTLY WORSE. *TR

Mileage: 12,500

MY 2008 JEEP WRANGLER SAHARA HAS FUEL OVERFLOW EVERY TIME THAT I FILL THE TANK. IT SPILLS ALL OVER THE SIDE OF THE CAR, ON THE GROUND, AND ON MYSELF IF I AM IN FRONT OF THE NOZZLE. I TOOK IT IN 2 YEARS AGO, AND WAS TOLD THAT EVERYTHING WAS FINE. I HAVE TRIED FILLING IT DIFFERENTLY, BUT IT STILL SPILLS A LITTLE WHEN IT IS ALMOST FULL. IT MAKES MY HANDS STINK, AND MY GARAGE. I AM AFRAID IT WILL CORRODE THE PAINT ON MY CAR. I HAVE HEARD OF OTHER WRANGLERS WITH THE SAME PROBLEM, AND MY WIFE HAS A 2009 WRANGLER THAT HAS THE EXACT SAME PROBLEM. *TR

Mileage: 20,000

WHILE PUMPING GAS, FUEL OVERFLOWS AND SPILLS OUT ONTO THE GROUND. *TR

Mileage: 18,000

I WAS IN THE PROCESS OF FILLING GAS TANK OF 2008 JEEP WRANGLER. AS TANK FILLED TO CAPACITY, PUMP SHUT OFF, COULD HEAR CLICK IN HANDLE, BUT GAS OVERFLOWED BACK OUT OF TANK ONTO JEEP, MY SHOES AND PANTS LEG. *TR

Mileage: 38,612

FUEL GUSHES OUT OF FILLER ALL OVER THE SIDE OF THE VEHICLE AND ALL OVER THE GROUND. PUMP CLICKS OFF AND 1/2 SECOND LATER COMES OUT OF FILLER. HAPPENS AT EVERY GAS PUMP NO MATTER BRAND. ALL DO IT. PROBLEM WITH ANGLE? PUMP DOESNT FIT PROPERLY INTO FILLER. *TR

Mileage: 24,000

WE HAVE A 2008 JEEP WRANGLER, 2 DOOR. 4X4 .WHENEVER WE FILL THE GAS TANK WITH THE AUTOMATIC SHUTOFF ATT HE PUMP ENGAGED, GAS OVERFLOWS OUT OF THE CAR BEFORE AUTOMATICALLY SHUTTING OFF. THIS HAPPENS ALL THE TIME AND VARIOUS GAS STATIONS THROUGHOUT THE YEAR. NOW WE HAVE TO MANUALLY LISTEN TO THE GAS FLOWING IN AND STOP IT FROM FILLING UP ENTIRELY. THIS IS A PROBLEM AT FULL SERVICE STATIONS, LIKE GETTY, OR WHEN WE ARE IN NEW JERSEY (FULL SERVICE IS MANDATORY IN NJ).THIS IS NOT ONLY A MAJOR INCONVENIENCE BUT THIS HAS TO BE A SAFETY HAZARD. DOES SOMEONE HAVE TO DIE BEFORE CHRYSLER/JEEP RECOGNIZES THIS AS A DEFECT. *TR

JEEP WRANGLER 2008 WHEN FILLING UP WITH THE GAS SPITS OUT ALL OVER EVERYTIME I FILL MY TANK UP. *TR

Mileage: 36,000

WHILE REFUELING MY 2008 JEEP WRANGLER THE FUEL FILL WOULD OVERFLOW WHEN FULL RATHER THAN CAUSE THE GAS PUMP TO TRIP. THIS HAPPENED EVERY TIME I WOULD REFUEL. I TOOK THE VEHICLE TO THE DEALER AND THEY REPLACED THE GAS TANK AND THE EVAP CANISTER. *TR

Mileage: 15,000

FUEL OVERFLOW FROM FILLER TUBE AND SPRAYS ONTO PERSON PUMPING FUEL, VEHICLE AND SURROUNDING ENVIRONMENT. THIS HAPPEN EVERY TIME WE FUEL JEEP. WE HAVE HAD THE JEEP SINCE 2008 AND PROBLEM STARTED IN DECEMBER 2010. THIS JEEP LOOKS BRAND NEW AND GARAGE KEPT AND NEVER BEEN OFF ROAD. *TR

Mileage: 37,500

FILLING UP AT THE GAS STATION THE GASOLINE OVERFLOWS OUT OF THE TANK, IT HAPPENS ALMOST EVERY TIME I FILL UP MY 2008 JEEP WRANGLER. *TR

Mileage: 35,000

EVERY TIME I FILL UP MY 2008 JEEP WRANGLER. GAS SHOOTS BACK OUT OF THE VEHICLE AND DOWN THE SIDE OF THE VEHICLE AND ON YOUR HAND AND ARM. *TR

Mileage: 27,450

WHEN I FILL UP MY 2008 JEEP WRANGLER. GAS SHOOTS BACK OUT OF THE VEHICLE. ENOUGH TO RUN DOWN THE BUMPER TO THE GROUND. IF YOU ARE NOT PAYING ATTENTION THE GAS CAN GET ON YOU. *TR

Mileage: 35,000

2008 JEEP WRANGLER JK (2 DOOR). GAS LEAKS OUT OF TOP OF THE FILLER NECK WHEN FILLING THE JEEP UP WITH GAS. THE AUTO SHUTOFF ON THE GAS PUMP CLICKS AND THEN THERE IS PROB 1/4 TO 1/2 GALLON OF GAS SPILLING DOWN THE SIDE OF THE CAR. INTERMITTENT PROBLEM AND ITS NOT BECAUSE IM TOPPING THE TANK OFF. THERE SEEMS LIKE THERE IS SOMETHING WRONG WITH THE CAR BECAUSE IT HAPPENS AT ALL DIFFERENT GAS STATIONS WITH OR WITHOUT THE RUBBER COVER ON THE GASOLINE PUMP FILLER NECK. *TR

Mileage: 40,000

WHEN FILLING THE FUEL TANK ON MY '08 JEEP WRANGLER, THE TANK OVERFLOWS AND SPILLS GAS ALL OVER THE SIDE OF THE VEHICLE. I LOCK THE TAB ON THE FUEL NOZZLE TO AUTO FILL THE TANK, AND EVERYTHING WORKS AS NORMAL UNTIL THE PUMP SHUTS OFF. WHEN THE PUMP SHUTS ITSELF OFF, IT IS QUICKLY FOLLOWED BY GAS GUSHING BACK OUT OF THE FILLER PORT. THE FIRST TIME IT HAPPENED, IT SPRAYED GAS ALL OVER MY PANTS, SHOES, GLOVES, ALL OVER THE BACK CORNER OF MY JEEP, AND LEFT A 3FT DIAMETER PUDDLE OF FUEL ON THE GROUND. I HAVE HAD THE JEEP SINCE NEW (BOUGHT IN FEB '09) AND IT JUST TURNED 40K MILES. THE FIRST INSTANCE HAPPENED ABOUT 2 WEEKS AGO, AND IT HAS HAPPENED THREE MORE TIMES SINCE THEN. *TR

Mileage: 40,000

WHEN FUELING MY 2008 JEEP WRANGLER FAST, THE AUTOMATIC SHUTOFF WILL CLICK OFF WHEN THE TANK IS FULL. THEN THE TANK SPITS GASOLINE BACK OUT OF THE FILLER NECK AND DOWN THE SIDE OF THE JEEP. A COUPLE TIMES I TRIED FILLING THE TANK AT THE SLOWEST AUTOMATIC RATE AND THE VALVE DIDN'T SHUT OFF WHEN THE TANK WAS FULL. THIS STARTED IN EARLY 2010, BUT IT WASN'T ON EVERY TANK FILL. NOW, IT HAPPENS EVERY TIME I TRY TO COMPLETELY FILL THE TANK. AS OF TODAY I HAVE UNDER 29,000 MILES ON THE JEEP. *TR

WHEN FILLING MY 2008 JEEP WRANGLER (2 DOOR) WITH GAS AND THE PUMP AUTOMATICALLY SHUTS OFF ABOUT 0.5 GAL OF GAS WILL SPILL OUT OF THE FILL TUBE ON ME, MY CAR, AND THE GROUND. GOT A NICE GAS BURN ON MY FOOT THE FIRST TIME THIS HAPPENED. THE SECOND TIME I STOOD AWAY FROM THE CAR NOT KNOWING IF THE PROBLEM WAS WITH THE GAS PUMP OR MY CAR. AFTER HAVING GAS SPILL FROM MY CAR TWICE I DON'T FILL THE TANK ANY MORE AND EVERY TIME I DO PUT GAS IN I AM AFRAID I WILL HAVE ANOTHER SPILL AS I AM NOT SURE HOW FULL I CAN GET IT BEFORE I HAVE PROBLEMS AGAIN. *TR

Mileage: 56,000

GAS TANK OVERFLOWS - AT 13,500 MY FUEL TANK BEGAN OVERFLOWING BADLY AT EVERY FILLUP. I KNOW THIS IS AN EXTREMELY COMMON PROBLEM ON 2007+ JEEP WRANGLER JKS. MANY TIMES THE FUEL ENDS UP ON THE PANTS AND SHOES OF THE PERSON FILLING UP THE TANK. CHRYSLER NEEDS TO MAKE THIS AN OFFICIAL RECALL BEFORE SOMEONE GETS HURT. *TR

Mileage: 13,538

FUEL OVERFLOWS WHEN FILLING AT THE GAS STATION. PUMP APPEARS NOT TO AUTOMATICALLY SHUT OFF IN TIME AS THE TANK APPROACHES THE FULL MARK AND GAS OVERFLOWS FROM THE FILLER TUBE. THIS IS A RECENT PROBLEM. *TR

Mileage: 60,000

GAS SPITS OUT OF FILLER WHEN NEARING FULL, SPILLS DOWN SIDE OF VEHICLE, SPRAYS WHOEVER/WHATEVER IS NEARBY. *TR

Mileage: 30,000

I OWN A 2008 JEEP WRANGLER RUBICON 2 DR. WHEN FILLING THE GAS TANK THE GAS WILL GUSH OUT WHEN IT'S FULL AND THE PUMP SHUTS OFF. I HAVE BEEN SPLASHED WITH GAS AS WELL AS GAS FLOWS OUT ON ONTO THE GROUND. *TR

I HAVE A 2008 JEEP WRANGLER SAHARA. STARTING IN NOVEMBER 2010, EVERY TIME I FILL MY TANK UP COMPLETELY THE GAS PUMP SHUTS OFF AT FULL AND THEN GAS POURS OUT OF THE FILL NECK. IT OVERFLOWS DOWN THE SIDE OF THE JEEP AND ONTO THE GAS STATION FLOOR. IT HAS HAPPENED 4 TIMES IN A ROW AND AT DIFFERENT GAS STATIONS. *TR

Mileage: 24,000

I HAVE A 2008 JEEP WRANGLER X AND DURING REFUELING, OFTEN TIMES IT BEGINS TO OVERFLOW BEFORE THE PUMP WILL SHUT OFF. I HAD TO STOP TRYING TO ACTUALLY FILL UP, IT WOULD DO THIS WITHOUT EVEN TRYING TO TOP OFF THE TANK. IT WOULD NOT CLICK OFF LIKE IT HAD WITH OTHER CARS I HAVE OWNED. *TR

Mileage: 34,200

MY 2008 JEEP WRANGLER X'S GAS TANK OVERFLOWS UPON THE LAST BIT OF FILLING THE TANK. IT STARTED AT ABOUT 20,000 MI. THE GAS PUMP SHUTS OFF, AND THEN WAIT A FEW SECONDS TO HEAR IT COMING UP THE THROAT OF THE TANK AND IT SPILLS A GOOD AMOUNT OF GAS EVERYWHERE, NOT JUST A FEW DROPS. THERE WERE NO PARTICULAR EVENTS LEADING UP TO THE FAILURE, AND IT OCCURS 9/10 TIMES THAT I GET GAS. IT DOES NOT MATTER WHICH GAS STATION I GO TO, OR WHAT PUMP IS BEING USED. CHRYSLER TOLD ME WHEN I BROUGHT THE JEEP INTO THE JEEP SERVICE DEPARTMENT THAT "THEY HAVE NO SOLUTION FOR THE PROBLEM". *TR

Mileage: 20,000

THE LAST 5 OR 6 TIMES I FILLED UP ON GAS, THE GAS OVERFLOWED AND SPILLED ONTO THE SIDE OF THE WRANGLER AND ONTO THE GROUND. HAVE MAKE AN APPOINTMENT WITH THE DEALER I BOUGHT IT FROM TO LOOK AT IT AND TRY TO DETERMINE WHAT THE PROBLEM AND SOLUTION IS. *TR

Mileage: 31,000

GAS TANK OVERFLOWS WHEN BEING FILLED. THIS IS A SCARY SITUATION WHEN OTHERS AT THE STATION MIGHT BE SMOKING, USING A CELL PHONE, ETC. THIS HAPPENS MOST EVERY TIME YOU FILL THE TANK. I NOW TRY TO GUESS AND KEEP THE TANK AT 3/4'S. *TR

Mileage: 23,000

I HAVE A 2008 JEEP WRANGLER JK THAT SPILLS ABOUT 1/2 GALLON OF GAS ON ME, THE SIDE OF THE VEHICLE AND THE GROUND WHEN IT IS FILLED WITH GAS. THE DEALER TELLS ME IT IS A DEFECTIVE ROLL OVER VALVE IN THE GAS TANK AND THAT I HAVE TO REPLACE THE GAS TANK. I HAVE BEEN TOLD YOU HAVE STARTED AN INVESTIGATION INTO THIS #PE10032. I WOULD LIKE TO ADD ANOTHER COMPLAINT TO THIS. THANK YOU *TR

Mileage: 62,000

FUEL SPILL WHILE REFUELING. AFTER NOZZLE AUTOMATICALLY CLICKS OFF, FUEL IS SOMETIMES EJECTED BACK OUT FROM THE FILLER NECK. FUEL IS SPILLED ON THE VEHICLE, THE GROUND, AND IN SOME CASES THE PERSON REFUELING. PROBLEM OCCURS ABOUT 75% OF TRIPS TO THE GAS STATION. UPDATED 02/07/11 *TR

I OWN A 2008 JEEP WRANGLER JK AND FOR ABOUT A MONTH WHEN I FILLUP AT THE GAS STATION IT OVERFLOWS ABOUT A HALF OF QUART OF GAS ONTO THE GROUND. I HAVE BROUGHT THE JEEP TO STORM'S MOTORS IN SOUTHAMPTON NY WHERE I PURCHASED SAME AND AGREED TO REPLACE TANK. I HAVE TO PAY THE $100 DEDUCTIBLE. I FEEL THIS SHOULD BE A SAFETY RECALL AND NOT JUST A WARRANTY ISSUE. *TR

Mileage: 25,000

I HAVE A 2008 JEEP WRANGLER, 2 DOOR. AT AROUND 30,000 MILES, I STARTED TO EXPERIENCE GAS OVERFLOW WHEN FILLING UP. WHEN THE PUMP IS LEFT TO AUTOMATICALLY SHUT OFF, IT WILL AND THEN GAS WILL FLOW OUT OF THE FILL UP TUBE. IT HAS BEEN ANYWHERE FROM SHOOTING OUT TO JUST RUNNING DOWN THE SIDE OF THE JEEP. I WOULD GUESS AT LEAST A CUP OF GAS. THIS HAPPENS AT VARIOUS FUEL PUMPS AND DIFFERENT STATIONS. I CONTACTED THE DEALER AND THEY SAID THEY HAVE NEVER HEARD OF SUCH A THING AND MAYBE IT WAS THE PUMP. I TOLD THEM IT HAD HAPPENED AT SEVERAL DIFFERENT PUMPS, BUT THEY WOULD DO NOTHING. I NOW HAVE TO GUESS WHEN THE TANK IS ABOUT FILLED AND GO THE LOWEST FLOW SETTING ON THE PUMP HANDLE. IF I GET THIS RIGHT, I DON'T GET GAS ON ME OR ALL OVER THE SIDE OF MY JEEP. NEVER HAD THIS PROBLEM WHEN IT WAS NEW AND I THINK THIS IS A SAFETY HAZARD THAT SHOULD BE FIXED. *TR

Mileage: 30,000

FUEL ALWAYS SPILLS FROM FILLER WHEN ALLOWING PUMP TO AUTOMATICALLY TURN OFF. *TR

EVERY FEW TIMES I FILL MY GAS TANK, IT OVERFLOWS. THIS CAUSES THE GAS TO SPLASH BACK AT ME, SPILL ON THE CAR, AND POOL ON THE FLOOR. THIS PROBLEM BEGAN WHEN I HAD ABOUT 30,000 MILES ON MY VEHICLE. IT IS PROGRESSIVELY GETTING WORSE AND NOW OCCURS MORE FREQUENTLY. TO REMEDY THIS PROBLEM, I HAVE NOT BEEN TOPPING OFF MY TANK. *TR

Mileage: 30,000

GAS SPILLAGE WHEN FILLING GAS TANK ON 2008 JEEP WRANGLER 2 DOOR SAHARA. *TR

Mileage: 15,000

I OWN A 2008 JEEP WRANGLER WHERE FUEL SPILLS OUT OF THE FILLER PORT DURING THE REFUELING PROCESS. THIS CONDITION OCCURS WHEN THE FUEL TANK IS FILLED TO THE FULL OR NEARLY FULL LEVEL AND THE GAS PUMP AUTOMATICALLY SHUTS OR CLICKS OFF. THIS OCCURS EVERY TIME I FILL UP WITH GAS, AND EVERY TIME IT HAPPENS, A SIGNIFICANT AMOUNT OF GASOLINE IS SPLASHED ALL OVER THE DRIVER SIDE REAR CORNER OF THE VEHICLE, THE GROUND, AND SOMETIMES THE PERSON FILLING THE TANK. IT FIRST HAPPENED ROUGHLY 600 MILES AFTER THE BUMPER TO BUMPER WARRANTY EXPIRED, SO THE DEALERSHIP CURRENTLY WILL NOT COVER THE REPAIR. *TR

Mileage: 52,400

WHEN FUELING MY 2008 JEEP WRANGLER (JK), AND ALLOWING THE FUEL PUMP TO AUTOMATICALLY TURN OFF WHEN THE GAS TANK REACHES THE FULL LEVEL, FUEL WILL OFTEN OVERFLOW OUT OF THE FILL PORT. MY ASSUMPTION IS THAT THE PUMP IS NOT TURNED OFF SOON ENOUGH, LEADING TO AN OVERFLOW SITUATION. *TR

Mileage: 17,000

I HAVE A 2008 JEEP WRANGLER X, WHILE FILLING THIS VEHICLE UP WITH GAS UPON FULL OR NEAR FULL WHEN THE PUMP NOZZLE CLICKS OFF FUEL SPILLS OUT OF THE FILL PORT SPLASHING ON THE CAR MYSELF AND THE GROUND. *TR

FUEL SPILLS OUT OF THE FILLER PORT DURING THE REFUELING PROCESS. THIS HAS HAPPENED MORE FREQUENTLY WHEN THE JEEP IS RUNNING ON EMPTY AND I FILL IT UP COMPLETELY. I HAVE A 2008 JEEP WRANGLER JK 2DR SPORT 4X4. *TR

Mileage: 18,000

2008 JEEP WRANGLER X. GAS OVERFLOW. PURCHASED THE VEHICLE IN MARCH 2010. SO THIS PROBLEM COULD HAVE BEEN HAPPENING FOR THE FIRST 36,000 MILES PRIOR TO OUR PURCHASE. *TR

Mileage: 1

EVERY TIME I FILL UP MY 2008 JEEP WRANGLER RUBICON, THE GAS TANK OVERFLOWS. DOESN'T MATTER IF I AM HOLDING THE NOZZLE AND LISTENING FOR THE TANK TO FILL, IT STILL OVERFLOWS. THIS HAS BEEN HAPPENING CONSISTENTLY FOR THE LAST SIX MONTHS. *TR

Mileage: 5,000

I HAVE A 2008 JEEP WRANGLER. EACH TIME I REFUEL THE GAS TANK IT SPEWS GASOLINE ON ME AS WELL AS THE VEHICLE AND THE GROUND. THIS IS A FAIRLY LARGE AMOUNT AND MUST BE A FIRE SAFETY AS WELL AS A HEALTH HAZARD FROM DIRECT SKIN CONTACT. I PURCHASED THIS VEHICLE FROM THE DEALERSHIP USED AND UNDER WARRANTY APPROXIMATELY 8 MONTHS AGO. THIS PROBLEM STARTED ABOUT 2 1/2 MONTHS AGO AFTER WARRANTY EXPIRED. I AM TAKING VEHICLE BACK TO DEALERSHIP ALONG WITH A PRINTOUT OF THE COMPLAINTS ALREADY VOICED OF THE SAME NATURE SINCE THIS APPEARS TO BE A ONGOING PROBLEM WITH THESE VEHICLES. *TR

Mileage: 41,000

WHEN REFUELING, MY 2008 JEEP WRANGLER DOES NOT STOP THE GAS FLOW BEFORE THE TANK IS FULL. ABOUT 20-30 OUNCES OF GASOLINE USUALLY BUBBLES OUT OF THE GAS INLET AFTER THE PUMP STOPS, LEAVING A PUDDLE OF GAS ON THE GROUND EVERY TIME. CURRENTLY THE PROBLEM HAS NOT BEEN RESOLVED. *TR

Mileage: 18,000

FUEL SPILLS WHEN GAS PUMP DOES NOT SHUT OFF. *TR

Mileage: 50,000

I HAVE A 2008 JEEP WRANGLER AND EVERY TIME I GO TO FILL UP MY GAS TANK, THE TANK WILL NOT AUTOMATICALLY CUT OFF THE GAS PUMP WHEN THE TANK IS FULL. THIS HAS BEEN OCCURRING FOR APPROX THE LAST 15,000 MILES AND I CURRENTLY HAVE 27,000 MILES ON THE JEEP. THE VEHICLE WAS BRAND NEW WHEN I PURCHASED IT. I HAVE THIS PROBLEM AT EVERY GAS STATION I HAVE TRIED SO I DO NOT BELIEVE IT IS A GAS PUMP FAILURE. I HAVE ALSO FILLED OTHER CARS AT THE SAME GAS STATIONS WITH NO PROBLEMS. *TR

Mileage: 12,000

JEEP JK WRANGLER 2008 - GAS TANK OVERFLOWS AT EVERY FILL UP SPLASHING GASOLINE ONTO PUMP, PERSON, VEHICLE AND GROUND. RISK OF FIRE AND OR EXPLOSION. PROBLEM STARTED ABOUT TWO YEARS INTO VEHICLE AND HAS NOT GONE AWAY. DEALER NOT REPAIRING PROBLEM SINCE VEHICLE WARRANTY EXPIRED DUE TO MILEAGE; NOT YEARS. *TR

Mileage: 45,000

EVERYTIME I FILL MY 2008 WRANGLER WITH FUEL, IT SPILLS ALL OVER INCLUDING ME. THIS IS A FIRE HAZARD AS FUEL SPILLS ALL OVER MYSELF AND THE JEEP. I HAVE TRIED DIFFERENT STATIONS AND STILL THE SAME RESULT. CHRYSLER SAYS THERE IS NOTHING WRONG BUT I FEEL THIS IS AN ACCIDENT WAITING TO HAPPEN. EXPOSED FUEL IN HOT TEMP WITH THE POSSIBILITY OF SPARKS BY OTHER SOURCES WHILE FUELING. IT STARTED DOING THIS LAST JULY 2009 AND CONTINUES TO THIS DAY. *TR

Mileage: 42,000

THE FUEL TANK IN MY 2008, 2 DOOR, JEEP WRANGLER JETTISONS FUEL AT EACH FILL-UP. I'M TOLD THE ROLL-OVER VALVE HAS FAILED AND THAT THIS IS COMMON FOR JEEP WRANGLER JKS. IF THE ROLL-OVER VALVE IN THE GAS TANKS IN MOST MODELS OF A VEHICLE ARE DEFECTIVE, SEEMS LIKE THE MANUFACTURER SHOULD RECALL THE VEHICLES FOR PROPER SAFETY REPAIR. *TR

Mileage: 56,236

I WAS FUELING MY 2008 2D JEEP RUBICON, THE AUTO-FILL LEVER ON THE GAS PUMP CLICK TO STOP FILLING, THEN GAS OVERFLOWED THE TANK. ABOUT 1 CUP OF GAS WENT ALL OVER BUMPER, SIDE OF JEEP AND MY SHOES. THIS HAS SINCE HAPPENED AT EVERY FUEL STATION EVERYTIME. *TR

Mileage: 25,400

I PURCHASED A 2008 JEEP WRANGLER AND EVERY TIME I FILL UP WITH GAS THE PUMP DOES NOT SHUT OFF AND IT SPILLS OVER. THIS HAPPENS WEEKLY, EVERY TIME I'M AT THE PUMP. CHRYSLER/JEEP WILL NOT CORRECT THE PROBLEM. *TR

GAS OVERFLOWS ON FILLING GAS TANK. *TR

Mileage: 35,000

EVERY TIME I FILL MY VEHICLE UP WITH FUEL, AT THE END OF THE FILL UP, FUEL COMES GUSHING OUT OF THE FUEL TANK NECK, AFTER THE PUMP HAS PERFORMED ITS AUTO SHUTOFF. AT LEAST 1 - 2 CUPS OF FUEL IS SPILLED ON THE GROUND EVERY TIME THIS OCCURS. THE DEALER SAID THAT I SHOULD IDLE AT THE PUMP FOR 60-90 SECONDS BEFORE PERFORMING A FILL UP. I HAVE ATTEMPTED THIS AND IT HAS NO EFFECT ON THE FLUE GUSHING OUT OF THE TANK. *TR

Mileage: 22,000

FUEL OVERFLOWS DURING FILLUP CAUSES SPILLED GASOLINE ON THE VEHICLE AND ALSO ON THE GROUND. THIS HAPPENS AT MULTIPLE FUEL STATIONS RULING OUT GAS PUMP AS DEFECTIVE. THE FUEL SYSTEM APPEARS TO NOT SIGNAL THE PUMP TO STOP PUMPING GAS WHEN FULL. *TR

Mileage: 49,256

1. EVERY TIME I GET GAS MY GAS TANK ON MY 08 JEEP WRANGLER OVERFLOWS. 2. IT OCCURS EVERY TIME I GET GAS. IT CAUSES ME TO SPILL GAS DOWN THE SIDE OF MY JEEP AND ON THE GROUND. 3. THE DEALERSHIP WILL NOT DO ANYTHING SINCE I AM 10K PAST MY WARRANTY. *TR

Mileage: 40,000

2008 JK WRANGLER BOUGHT NEW, NO ACCIDENTS 45,000 MILES. EVERY TIME I FILL UP WITH GAS, GAS SPEWS OUT ALL OVER THE JEEP AND GROUND SEEMS I CANNOT FILL IT SLOW ENOUGH TO STOP THIS. IT HAPPENS 90% OF FILL UPS AT MULTIPLE PUMPS SERIOUS FIRE HAZARD. GASCAP LIGHT IS ON EVEN WITH THE CAP TIGHT. *TR

Mileage: 45,000

MY 2008 JEEP JK RUBICON SPEWS GAS AND EJECTS THE GAS PUMP WHEN IT REACHES CAPACITY. IT DOESN'T HAPPEN EVERYTIME, BUT EVERY THIRD TIME. I NOW HAVE TO "GAUGE" HOW MUCH GAS IS IN THE TANK AND STOP IT BEFORE IT FILLS UP. WHEN IT OVERFLOWS, NEARLY A PINT TO TWO PINTS SPEW OUT ALL OVER MY JEEP, GAS STATION FLOOR AND SEVERAL TIMES OVER MYSELF. THIS IS A SERIOUS HEALTH AND ENVIRONMENTAL HAZARD. IMAGINE SOMEONE LIGHTING A CIGARETTE AFTER A FUEL UP FORGETTING HE JUST GOT GASOLINE ON HIM. *TR

Mileage: 10,000

2008 JEEP WRANGLER X. LATELY WHEN I FILL UP THE GAS TANK IT OVERFLOWS. I'VE HAD THE JEEP SINCE SEPTEMBER 2007. THE LAST 4 FILLUPS THIS HAS BEEN AN ISSUE AT MULTIPLE STATIONS. IT OVERFLOWS IF I HOLD IT MANUALLY, OR USE THE LOCKING MECHANISM ON THE FUEL GUN. IT OVERFILLS EVEN WHEN IT "CLICKS" OFF. THIS HAS TO BE DANGEROUS. I AM NOW IN THE HABIT OF PUTTING IN LESS GAS SO AS NOT TO DEAL WITH GASOLINE SPILLING OUT OF MY TANK AND ALL DOWN MY FENDERS AND BUMPERS. THIS IS NOT SAFE. THERE ARE MANY COMPLAINTS OUT THERE. CHRYSLER SHOULD ISSUE A RECALL FOR THIS PROBLEM. GASOLINE FUMES AND CARS ARE NOT SOMETHING THAT SHOULD BE TAKEN LIGHTLY. *TR

I HAVE A 2008 JEEP WRANGLER THAT OVERFLOWS FUEL EVERYTIME I FILL IT UP. WITHIN A HALF SECOND OF THE PUMP SHUTTING OFF FUEL SPRAYS OUT OF THE FILL TUBE. ALL OVER THE JEEP, ALL OVER ME, ALL OVER THE GROUND. EVEN IF I DECREASE THE FLOW TO A TRICKLE IT STILL OVERFLOWS. *TR

Mileage: 28,000

WHEN FUELING MY 2008 JEEP WRANGLER X (2DR) AND SETTING THE PUMP TO AUTO FILL THE FUEL OVERFLOWS ONCE THE TANK WAS FILLED COMPLETELY. THE PUMP CLICKED OFF AND THE FUEL TANK THEN "VOMITED" A LOT OF FUEL OUT. *TR

Mileage: 18,000

2008 WRANGLER 2 DOOR. AT ABOUT 25,000 MILES, STARTED OVERFLOWING WHEN I FILLED UP GAS TANK. I DIDN'T WORRY ABOUT IT TOO MUCH UNTIL I HAD ANOTHER ISSUE AND WENT IN FOR SERVICE AT THE DEALER. THAT IS WHEN I COMPLAINED ABOUT IT. THEY SAID THE SHUT-OFF VALVE INSIDE THE TANK WAS STUCK AND REPLACED THE GAS TANK. 100 MILES LATER, THE ENGINE LIGHT CAME ON. DEALER INSPECTED IT AND SAID THERE WAS A FAULTY EMISSIONS VALVE ON THE GAS TANK AND WOULD HAVE TO REPLACE IT AGAIN. *TR

Mileage: 25,000

MY 2008 JEEP WRANGLER SPEWS GAS AFTER THE AUTOMATIC SHUT-OFF. I DO NOT TOP OFF AND HAVE TRIED SEVERAL GAS STATIONS. THE GAS PUMPS CLICKS OFF AND 3 SECONDS LATER I HEAR A GURGLE AND ABOUT 2 CUPS OF FUEL VOMITS OUT, RUNS DOWN MY PAINT, PLASTIC BUMPER AND ON THE GROUND. THIS SEEMS TO BE A VERY SERIOUS AND DANGEROUS THING. I HAVE TAKEN MY JEEP BACK TO THE DEALER WHO REPLACED THE GAS TANK. THE FIRST FILL UP WITH THE NEW TANK HAD NO ISSUES, FROM THE SECOND FILL UP ON IT SPEWS. *TR

Mileage: 17,000

WHEN GASSING UP VEHICLE- FUEL WILL REGURGITATE OUT FUEL NECK ONTO PERSON FUELING AND ALL OVER VEHICLE AND GROUND. HAPPENS EVERY TIME I FUEL REGARDLESS OF HOW SLOW I FUEL VEHICLE. EXTREMELY DANGEROUS! *TR

Mileage: 15,000

WHEN FUELING MY 2008 JEEP WRANGLER GAS ALWAYS SPILLS OUT. I HAVE HAD IT FOR OVER A YEAR AND IT JUST STARTED ABOUT TWO MONTHS AGO. I PUT THE GAS NOZZLE IN THE FILL TUBE AND CLICK IT ON AUTO FILL. THE NOZZLE WILL CLICK OFF THEN A SECOND LATER GAS COMES SHOOTING OUT. I'VE READ ON A FORUM THIS IS A COMMON PROBLEM AND BELIEVE JEEP SHOULD ISSUE A RECALL AND FIX THE PROBLEM. I ALSO THINK I SHOULD BE REIMBURSED FOR THE $120 DOLLARS I PAID TO HAVE IT CHECKED AND NOT FIXED. *TR

Mileage: 26,542

I HAVE A 2008 JEEP WRANGLER 2DR HARDTOP WITH 30,000 MILES. EVERYTIME I FILL UP AT THE GAS STATION, THE GAS NOZZLE INSTEAD OF SHUTTING OFF PROPERLY, IT SPEWS GAS FROM THE TANK ALL OVER THE GROUND. THE GAS RUNS ALL DOWN MY PAINT AND ONTO THE GROUND. *TR

Mileage: 30,000

MY 2008 JEEP WRANGLER WILL SPILL GAS OUT ALMOST EVERY TIME I FILL THE TANK IF I HOLD THE NOZZLE ON ANYTHING ABOVE ABOUT A QUARTER OPEN. AS IT NEARS FULL, THE PUMP CLICKS OFF AND THEN WHOOSH, OUT COMES ABOUT A QUART OF GAS, SPILLING DOWN THE SIDE AND ONTO THE PARKING LOT. IT DID NOT DO THIS WHEN I FIRST BOUGHT IT. IT STARTED DOING THIS ABOUT 6 MONTHS AGO. I NEVER CONTACTED THE DEALER AS MY WARRANTY IS UP. I REALLY DIDN'T GIVE THIS MUCH THOUGHT AS I HAVE LEARNED IF I JUST TRICKLE THE LAST FEW GALLONS IN, IT ONLY HAPPENS TO ME ABOUT 25% OF THE TIME. HOWEVER, AFTER STUMBLING ACROSS A JEEP FORUM ON THE INTERNET AND FINDING OUT THAT THERE ARE MANY PEOPLE OUT THERE WITH THIS EXACT SAME PROBLEM, I REALIZE THAT SOMEBODY IS GOING TO GET KILLED BY AN EXPLOSION OR FIRE EVENTUALLY. *TR

Mileage: 20,000

GAS PUMP FREQUENTLY DOES NOT DISENGAGE AFTER TANK IS FULL CAUSING GASOLINE TO SPRAY OVER VEHICLE AND ON TO GROUND. *TR

Mileage: 37,000

EVERYTIME I FILL UP THE VEHICLE GAS SPILLS OUT OF THE FILLER NECK AFTER THE FUEL NOZZLE SHUTS OFF. *TR

Mileage: 20,000

2008 JEEP WRANGLER OVERFLOWS DURING EACH GAS FILL UP. SHUTS OFF ONLY AFTER GAS IS OVER FLOWING FROM GAS FILL PIPE. *TR

Mileage: 25,000

FUEL TANK OVERFLOW. WHEN REFILLING FROM EMPTY, THE TANK WILL SPRAY FUEL OUT THE FILLER SPOUT AFTER THE PUMP SHOTS OFF AUTOMATICALLY. DEALER HAS REPLACED THE EVAP CANISTER AND ESSIM VALVE AND RESULTS ARE THE SAME. IT STILL "BURPS" FUEL OUT AND MAKES A MESS. *TR

Mileage: 25,000

GAS SPILLS OUT OF TANK AT EVERY FILL-UP. NO TOPPING OFF, WILL SPILL OUT EVEN IF UNDERFILLED. KNOWN ISSUE BEING REPORTED FOR JEEP JK AT JK-FORUM.COM. *TR

Mileage: 25,000

I HAVE A 2008 JEEP WRANGLER, 2 DOOR, 4X4. THE PAST 4-5 TIMES I HAVE FILLED UP WITH GAS, THE GAS HANDLE STOPS WHEN FULL, THEN GAS STARTS GUSHING BACK OUT GETTING ALL OVER THE SIDE OF THE VEHICLE AND GROUND, MY ESTIMATE WOULD BE 1/4-1/2 A GALLON EACH TIME, MINIMUM. *TR

Mileage: 13,500

WHEN FILLING UP MY 2008 JEEP WRANGLER WITH GAS, GAS WILL SPRAY OUT OF THE FILLER TUBE AFTER THE PUMP SHUTS OFF. GAS WILL GET ON MY CLOTHES AND ALL OVER THE SIDE OF THE JEEP. THIS IS A VERY DANGEROUS SITUATION, AND AN ENVIRONMENTALLY SENSITIVE ONE AS WELL. *TR

Mileage: 13,450

2008 JEEP WRANGLER JK SPILLS GASOLINE OUT OF FILLER NECK WHENEVER FILLING UP TANK. *TR

Mileage: 32,000

2008 JEEP WRANGLER -- GAS OVERSPILLS WHEN FILLING UP. HAPPENS AT DIFFERENT GAS STATIONS NUMEROUS TIMES. *TR

Mileage: 36,768

WHEN FILLING THE FUEL TANK GAS COMES RUSHING OUT OF THE FILLER NECK A COUPLE OF SECONDS AFTER THE TANK REACHES FULL AND THE AUTO-SHUT OFF ON THE FUEL STATIONS FILL PUMP SHUTS OFF. THIS CAUSES FUEL TO SPILL DOWN THE SIDE OF THE JEEP WRANGLER AND PUDDLES ON THE GROUND. THIS HAPPENS AT EVERY FILL-UP AT DIFFERENT FUEL STATIONS. *TR

Mileage: 42,130

GASOLINE OVERFLOW'S OUT OF GAS TANK WHEN TRYING TO FILL CAR. *TR UPDATE: TANK WAS FULL AND ABOUT A HALF GALLON OF FUEL CAME OUT.

Mileage: 31,653