1999 JEEP WRANGLER Structure Problems

The contact owns a 1999 Jeep Wrangler. The contact stated that while driving at an undisclosed speed, the rear subframe fractured near the axle. The vehicle was taken to an independent mechanic who diagnosed that the subframe was corroded and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 145,000.

Mileage: 145,000

I STARTED HEARING A BANGING/CLANGING NOISE UNDER THE REAR OF THIS VEHICLE UPON STARTING/STOPPING OR REVERSING. THE NOISE IS BEST DESCRIBED AS A SHARP METALLIC CLANG. UNDERCAR INSPECTION REVEALED THE FRAME HAS CORRODED TO THE POINT THE UPPER CONTROL ARM MOUNTS HAVE PULLED AWAY FROM THE FRAME AND THE TRACK BAR THAT LOCATES THE AXLE SIDE-TO-SIDE HAS SEPARATED FROM THE REAR AXLE HOUSING ALONG WITH THE UPPER CONTROL ARM MOUNT SEPARATING FROM THE AXLE HOUSING. REPAIR OF THIS VEHICLE REQUIRES REPLACEMENT OF THE FRAME ALONG WITH REPLACEMENT OF THE COMPLETE REAR SUSPENSION AND AXLE HOUSING. THIS SAME VEHICLE WAS REPORTED TO YOU 03 NOVEMBER 2016 FOR THE SAME ISSUE INVOLVING THE CENTER SECTION OF THE FRAME RUSTING THROUGH CAUSING THE TRANSFER CASE MOUNT/SKID PLATE TO DROP. SAFETY CAPS WERE INSTALLED ON THE FRAME AT THIS TIME AND THE VEHICLE WAS PLACED BACK INTO SERVICE.

Mileage: 197,000

FRAME ROTTED FROM RUST WHERE THE REAR SUSPENSION ATTACHES TO THE FRAME. TOO MUCH RUST TO REPAIR. REMAINING VEHICLE IS IN GOOD SHAPE CONSIDERING ONLY 107K MILES. SUSPENSION BROKE FREE FROM THE FRAME DURING NORMAL ROAD OPERATION. I AM TOLD THAT THE PROBLEM IS EPIDEMIC WITH JEEP TJ FRAMES. APPARENTLY SO BECAUSE THERE IS NOTING AVAILABLE ON THE USED PARTS MARKET. LOTS OF TJ BODIES AND PARTS AVAILABLE BUT NO FRAMES TO GO ALONG WITH THEM.

Mileage: 107,000

JEEP IS A 5 SPEED TRANSMISSION. COULDN'T SHIFT CORRECTLY, HEARD A RATTLE. ENGINE HAD FALLEN DUE TO RUSTING FRAME. FRAME SO RUSTED, ENGINE FELL. ONLY 90,000 MILES ON VEHICLE. NOT DRIVEN DAILY. WAS IN MOTION.

Mileage: 90,000

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE CHANGING THE REAR DRIVER SIDE TIRE, IT WAS DISCOVERED THAT THE SPARE TIRE HUB WAS EXTREMELY CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN ANY OPEN RECALLS. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 25,001.

Mileage: 25,001

JEEP WRANGLER (TJ BODY) 1999 FRAME RUST I WAS DRIVING THE VEHICLE AT INTERSTATE (68-72MPH) SPEEDS WHEN A SEVERE VIBRATION STARTED SUDDENLY AND THE MANUAL TRANSMISSION SHIFT LEVER DROPPED TO A LOWER THAN NORMAL POSITION. I PULLED OFF IN A SAFE AREA AND INSPECTED FIRST FOR A FLAT TIRE AND THEN LOOKED UNDER THE VEHICLE. I NOTED THE RIGHT FRAME RAIL HAD RUSTED THROUGH FROM THE INSIDE AND THE TRANSMISSION-TRANSFER CASE MOUNT/SKID PLATE ASS'Y HAD SEPARATED FROM THE RIGHT (PASSENGER SIDE FRAME RAIL AND DROPPED APPROX. 2-3 INCHES. THIS CAUSED SEVERE DRIVELINE VIBRATION AND ERRATIC VEHICLE CONTROL. *TR

Mileage: 176,000

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE UNDERCARRIAGE AND FRAME WERE CORRODED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

Mileage: 110,000

THE FRAME ON MY 1999 JEEP WRANGLER TJ IS ROTTING THROUGH IN SEVERAL PLACES. A VEHICLE ONLY 15 YEARS OLD NORMALLY HAS PROBLEMS, BUT IT SHOULD NOT BE A FRAME RUSTING THOUGH. I AM ASKING YOU TO URGE CHRYSLER TO DO THE RIGHT THING FOR ME AND MANY JEEP OWNERS WHO ARE ALSO EXPERIENCING THIS PROBLEM AND RECALL AND REPLACE THE FRAMES. OTHER AUTOMOBILE MANUFACTURERS HAVE DONE THIS AS IT IS A SAFETY ISSUE AND THE RIGHT THING TO DO. THANK YOU. *TR

Mileage: 115,750

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE TEMPERATURE CONTROL LEVER MELTED WITHOUT WARNING. THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE CONTACT ATTEMPTED TO REMEDY THE FAILURE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

Mileage: 115,000

TL ' THE CONTACT OWNS A 1999 JEEP WRANGLER. WHILE THE VEHICLE WAS BEING SERVICED FOR AN UNRELATED REPAIR, THE MECHANIC NOTICED THAT THE FRONT PASSENGER'S SIDE FRAME WAS SEVERELY RUSTED. THE FRONT DRIVER'S SIDE FRAME CONTAINED A HOLE AND A CRACK. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 68,000. JCC

Mileage: 68,000

TL* THE CONTACT OWNS A 1999 JEEP WRANGLER. THE CONTACT STATED THAT THE INSTRUMENTAL PANEL AND GAUGE FAILED TO ILLUMINATE DUE TO THE LOOSE SCREWS THAT ARE LOCATED ON THE BOTTOM OF THE INSTRUMENT STRUCTURE. THE CONTACT WAS UNABLE TO READ THE GAUGE ON THE INSTRUMENT PANEL AND THE ELECTRICAL BLOWER MOTOR FAILED. THE MANUFACTURER STATED THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 99V117000 (UNKNOWN OR OTHER). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 30,000 AND THE CURRENT MILEAGE WAS 191,000.

Mileage: 30,000

1999 JEEP WRANGLER HAD MULTIPLE REAR DIFFERENTIAL FAILURES BEFORE 70K MILES. *TS *** NO ANSWER REQUIRED*** THE ORIGINAL DRIVE TRAIN WAS REBUILT USING ORIGINAL MOPAR PARTS. THE DRIVE TRAIN FAILED FOR THE SECOND TIME AT 69000 MILE AFTER ONLY 11000 MILES OF USE. THIS TIME THE DEALER REFUSES TO PROVIDE ANY FINANCIAL ASSISTANCE. THE VEHICLE HAD OTHER FAILURES WHICH INCLUDE WATER LEAKS, DRIVE TRAIN SEALS FAILURE, ELECTRICAL FAILURES, MULTIPLE ABS FAILURES, AIR BAG AND SEAT BELT PROBLEMS, AND THE PAINT WAS PEELING OFF THE VEHICLE. *NM

Mileage: 69,500

SAME ELECTRICAL CUT OFF PROBLEMS. CONSTANT BURNING WIRE SMELL. DEFROST KNOBS, AND HIGH MED LOW KNOB STAYS ON LOW OR HIGH, OR NOTHING. KNOBS AND MOTORS HAVE BEEN REPLACED 1 TIME. DIFFERENT DEALERS IN CHICAGOLAND AND CENTRAL IL SAY THERE IS NOTHING WRONG NOR ANY RECALLS THAT HAVE TO DO WITH THIS. TIRED OF SPENDING MONEY. TOP OF VEHICLE IS VERY WORN, SEAMS ARE BUSTING OUT AND TOP IS BECOMING UNSAFE. DRIVERSIDE WINDOW ZIPPED FELL OFF. JEEP IS GARAGED DAILY AND TAKEN CARE OF BUT IS FALLING APART.

Mileage: 45,000

RECALL 99V117000 CONCERNING INSTRUMENT PANEL SCREWS. ALL THE INSTRUMENT GAUGES ARE FAILING TO OPERATE. VEHICLE HAD BEEN TO DEALER FOR INSPECTION. DEALER INFORMED CONSUMER THAT THIS VEHICLE WAS NOT COVERED UNDER THE RECALL.*AK

Mileage: 60,000

WATER WAS LEAKING INTO THE FRONT PASSENGER COMPARTMENT OF MY 1999 WRANGLER SAHARA. CHRYSLER SAID THIS WAS A KNOWN PROBLEM IN THE JEEP WRANGLERS BUT IS UNWILLING TO CONSCIDER THIS WORTH LOOKING TO REPAIR. *AK

Mileage: 115,000

HEAD OF THE BOLTS WHICH HOLD THE HINGES HAS BROKEN OFF, CAUSING DOOR TO DISCONNECT FROM VEHICLE. DEALER AND MANUFACTURER WERE NOTIFIED. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

DURING RAIN AND TRAVELING AT NORMAL SPEEDS, VEHICLE STARTS TO TAK IN WATER THROUGH BODY WELDS FROM FLOOR BOARD AND BOLTS FOR PASSENGER SEAT/ FIREWALL LEAK WAS REPAIRED BY DEALER, BUT BODY CONTINUES TO LEAK UNCONTROLLABLY/ NEW VEHICLE HAVE SAME PROBLEM. REVIEW JEP FORUMS FOR PROOF.*AK

IT SEEM LIKE ALL OF THE EXTERIOR COMPONENTS PAINTED BLACK ARE NOW CHIPPING. MAINLY ON THE PASSENGER SIDE MIRROR AND ON THE BRACKETS WHICH HOLD THE WINDOW IN THE HARD TOP.*AK

A BODY SEAL ON THE PASSENGER SIDE ALLOWS WATER TO ENTER THE PASSENGER SIDE COMPARTMENT (FRONT AND REAR) CAUSING INCHES OF WATER TO ACCUMULATE RUINING THE INTERIOR CARPET. NLM

MY 99' JEEP HAS LEAKED WATER UNDER THE SEATS FROM THE DAY I BOUGHT THE CAR. I HAD 4 REPAIR ATTEMPTS WHERE THEY REPLACED THE DOOR SEALS X 2, SANDED THE DOOR FRAME, RESEALED THE WINDSHIELD, SEALED THE SEAMS UNDER THE WHEELS AND REPLACED THE CARPET 3 TIMES. THE CAR STILL LEAKED. I HAVE SENT A LETTER OF DEFECT TO THE MANUFACTURE AND AFTER THE 5 AND FINIAL REPAIR ATTEMPT THE JEEP STILL LEAKED WATER UNDER THE SEATS. CHRYSLER EVEN HAD AN ENGINEER FLY DOWN TO THE SERVICE SHOP AND LOOK AT THE JEEP. HE TOLD ME THE LEAK WAS FIXED. YESTERDAY IT RAINED AND AFTER DRIVING THROUGH SOME PUDDLES WATER STILL LEAKED UNDER THE SEATS. *AK

THE FLOOR LEAKED FROM THE TIME OF PURCHASE, THE CARPET WAS RUINED, THE DEALERSHIP HAS REPLACED THE CARPET AND "FIXED" THE LEAK TWICE, I STILL DO NOT KNOW IF IT HAS BEEN PROPERLY REPAIRED AS FOR IT HAS NOT RAINED SINCE THE LAST REPAIR WAS COMPLETED. THE DEALERSHIP ALSO CONFIRMED THAT THEY HAVE SEEN SEVERAL JEEPS WITH THE SAME PROBLEM RETURNED FOR REPAIR. IF THE DEALERSHIP IS AWARE OF THIS PROBLEM THEN WHY HAS THERE NOT BEEN A RECALL ISSUED BY CHRYSLER ???