2006 JEEP WRANGLER Fuel/propulsion System Problems

Vehicle’s inlet check valve for gas tank does not work properly when tank is filled at fueling stations. Does not trigger gas pumps to stop causing overflow and spilling on person / clothing / vehicle and gas station property. This is a known issue for 2005-2006 Jeep Wranglers. The issue was repaired by manufacturer for newer Jeep Wranglers. Currently no manufacturer ownership on remediation issue and/or recall for 2005-2006 model year Jeep Wranglers.

WHEN FILLING UP THE GAS TANK WITH FUEL, THE FUEL SPLASHES OUT GOING OVER ME, MY FENDERS, SIDE OF JEEP AND THE GROUND. I BELIEVE THIS IS A MAJOR SAFETY ISSUE.AND JEEP SHOULD BE LIABLE. GOD FORBID IF THIS CAUSED A FATALITY.

Mileage: 75,000

FUEL OVERFLOWS WHEN THE TANK IS FILLED. THE AUTO-SHUTOFF DOESN'T WORK. IT HAPPENS EVERY TIME I FILL THE TANK, NO MATTER WHAT GAS STATION. THIS IS A SAFETY AND ENVIRONMENTAL HAZARD.

Mileage: 91,000

EVERY TIME I FILL THE JEEP UP WITH GAS, LARGE AMOUNT OF FUEL SPILLS OUT BEFORE THE FILL GUN CAN STOP IT. I HAVE BEEN TO MANY DIFFERENT GAS STATION AND IT HAPPENS AT ALL OF THEM. THIS IS A VERY DANGEROUS, MANY OTHERS WITH MY YEAR JEEP HAVE FILLED COMPLAINTS AND GOT THE ISSUE FIX.

EVERY TIME I FILL UP MY FUEL TANK, 1/2 A SECOND AFTER THE PUMP SHUTS OFF, A SIGNIFICANT OF FUEL COMES RUSHING OUT ON TO THE GROUND.

Mileage: 37,000

WHEN FILLING THE WRANGLER WITH FUEL, THE TANK CONSISTENTLY AND REGULARLY OVERFILLS AND SPITS FUEL OUT OF THE TOP OF THE FUEL TANK TOWARDS THE GAS PUMP NOZZLE, THE PERSON FILLING THE WRANGLER, THE EXTERIOR OF THE WRANGLER, AND ONTO THE FLOOR NEXT TO THE WRANGLER. THERE IS A TSB FOR REPAIR OF THIS ISSUE, BUT MY YEAR IS NOT AUTOMATICALLY COVERED BY THAT TSB. PLEASE HELP.

Mileage: 117,000

WHEN FILLING UP THE FUEL TANK, IT WILL EITHER CLICK-OFF EVERY 2 TENTHS OF A GALLON OR SPILL FUEL OUT WHEN ATTEMPTING TO FILL AT THE SLOWEST RATE. THERE ARE NO KINKS OR ETC IN THE FILLER PIPE OR VENT PIPE.

Mileage: 2,500

DURING PUMPING OF GASOLINE INTO THE TANK WHEN THE TANKS FILLS, GAS SPEWS FROM THE TANK EVERYTIME. THIS DOES NOT HAPPEN WITH EITHER OF THE OTHER 3 JEEPS THAT I OWN. THIS CAUSES A POTENTIAL FOR FIRE AND/OR INJURY DUE TO GASOLINE SPLASHING ON HANDS, ARMS AND CLOTHES.

Mileage: 68,000

WHEN I FILL UP WITH GAS AT A STATION, AFTER THE PUMP CLICKS, ABOUT A PINT OF GAS SPLASHES OUT OF THE FILLER AND DOWN THE BODY ONTO THE GROUND.

Mileage: 50,000

JEEP WRANGLER 2005 AND 2006. WHEN FILLING THE GAS TANK AT THE GAS STATION, GASOLINE WILL OVERFLOW MOMENTARILY, SPILLING GASOLINE ON THE GROUND FROM THE GAS TANK FILLER TUBE WHEN THE GAS PUMP FUEL NOZZLE SHUTS OFF. THIS HAS HAPPENED ON THE 2005 AND 2006 MODEL YEAR WRANGLERS I HAVE OWN(ED). REVIEWING COMMENTS ON THE INTERNET THIS IS A COMMON PROBLEM WITH THESE MODEL YEARS. AN ADDITIONAL PROBLEM IS THE INTERNAL STICKING (DUE TO INTERNAL VALVE PLUG EXPANSION) CHECK VALVE THAT CAUSES SPILLAGE ALSO MAY NOT PERMIT PROPER FUEL FILLING.

Mileage: 113,820

GAS TANK BLOWS OUT A LARGE AMOUNT OF GAS AFTER FILLING UP.

Mileage: 64,000

WHEN FILLING THE FUEL TANK TO FULL GASOLINE WILL SHOOT OUT OF THE FILLER HOLE AND OVER THE SIDE OF THE VEHICLE. THE PROBLEM IS CONSISTENT (I CAN ONLY RECALL 4 TIMES WHEN IT DID NOT OCCUR SINCE I PURCHASED THE VEHICLE IN 2015 WITH 82,000 MILES ON IT. IN ALL CASES THE VEHICLE WAS STATIONARY, ENGINE WAS OFF, PARKED NEXT TO THE GASOLINE PUMP.

Mileage: 123,900

JEEP WRANGLER X 2006 AUTOMATIC. STHALL WHILE RUNNING IN HIGHWAY .THEN WOULD NOT START ,NO CRANK. NO FUEL PUMP START , NO PANEL INDICATORS WORKING. SHOWS A 06- 02 CODE ERROR IN PANEL. MEAN FUELING CALIBRATION ERROR. 3 OR 4 DAYS LATER IT START LIKE NEW.

Mileage: 120,000

WHEN REFUELING THE VEHICLE, GASOLINE WITH SHOOT OUT OF THE FUEL FILL WHEN THE TANK IS NEARLY FULL. FROM SPEAKING WITH OTHER JEEP WRANGLER UNLIMITED OWNERS (2005 & 2006 MODELS ONLY), THIS ISSUE IS COMMONPLACE AND UNADDRESSED BY JEEP. IT IS REPORTEDLY DUE TO A DESIGN FLAW IN THE OVERFLOW VALUE IN THE FILLER TUBE. EACH TIME THIS HAPPENS, APPROXIMATELY 1/4 OF GASOLINE WILL FLOW OUT OF THE TANK BEFORE THE GAS PUMP CLICKS OFF. THIS HAS EXPOSED ME TO GASOLINE ON MY SKIN, AS WELL AS SPILLED FUEL ON THE GROUND. THERE IS RISK DUE TO EXPOSURE TO ETHANOL AND OTHER CHEMICALS, ENVIRONMENTAL EXPOSURE WITH GASOLINE ON THE GROUND, AND FIRE RISK.

Mileage: 142,212

EVERY TIME I FILL MY JEEP, IT OVERFLOWS AND SPILLS FUEL ALL OVER THE SIDE OF MY JEEP AND THE GROUND BEFORE THE RULE PUMP SHUTS OFF. I HAVE THIS ISSUE WITH EVERY FILL UP AT ANY FUEL STATION I USE. IT WILL SOMETIMES OVERFILL AND SPILL ENOUGH OUT AS TO NECESSITATE THE USE OF A FUEL SPILL CLEANUP KIT AND I'VE HAD SEVERAL SHOES AND PANTS RUINED FROM SPOUTING FUEL. I HAVE HAD SEVERAL OTHER JEEP WRANGLER OWNERS OF THE SAME YEAR AND MODEL COMPLAIN OF THIS EXACT PROBLEM. I FEEL THIS IS NOT ONLY AN ENVIRONMENTAL PROBLEM, BUT A FIRE SAFETY PROBLEM AS WELL. IT CANNOT BE SAFE TO HAVE A SYSTEM THAT OVERFILLS AND SPILLS GASOLINE EVERY SINGLE TIME YOU FILL YOUR VEHICLE CREATING A SIGNIFICANT RISK OF FIRE.

Mileage: 70,700

2006 TJ FUEL OVERFLOW WHEN FILLING TANK. FUEL SPITS OUT OF GAS TANK ON TO PERSON HOLDING THE GAS HANDLE PUMP WHEN FILLING. AUTO IS OFF AND STATIONARY. IT HAPPENS EVERY TIME.

Mileage: 45,000

I HAVE A 2006 JEEP WRANGLER TJ I BOUGHT USED HAVE HAD IT GOING ON 6 MONTHS AND EVERYTIME I GO TO THE GAS STATION AND FILL UP WHEN THE PUMP KICKS OFF THE GAS SPEWS OUT ALL DOWN THE SIDE OF MY JEEP FLARES AND THE JEEP ITSELF AND DOWN ONTO THE GROUND WHEN I FILLED IT UP THE FIRST TIME IT WAS ALL OVER MY HAND MY LEG AND RUINED MY SHOES!! I GOT ON A JEPP FORUM AND WAS TOLD TO GET A GMC FILLER HOSE WITH A CHECK VALVE AND I DID AND PAID TO HAVE IT INSTALLED AND I STILL HAVE THE SAME ISSUE. I HAVE DONE A LOT OF RESEARCH ON THE INTERNET AND I AM NOT ALONE HERE THIS IS A HUGE ISSUE AND IT IS GOING TO LEAD TO SOMEONE GETTING HURT OR WORSE KILLED!! IS THIS WHAT IT'S GOING TO TAKE FOR YOU TO FIX THIS PROBLEM WITH THE WRANGLERS? I SURE HOPE NOT!! THIS IS BEYOND RIDICULOUS AND NEEDS ADDRESSED AND FIXED ASAP.....

Mileage: 106,000

EVERY TIME I FILL MY JEEP WITH GASOLINE, WHEN IT REACHES IT'S CAPACITY, GAS SPEWS OUT OF THE FILLER TUBE AND ONTO THE REAR FENDER FLARE AND SUBSEQUENTLY ONTO THE GROUND. THIS IS NOT A NEW ISSUE WITH THESE JEEPS AND IT IS A FIX THAT SHOULD BE DONE BY THE MANUFACTURER DUE TO THE OBVIOUS SAFETY CONCERNS. THIS IS A FIRE HAZARD AND COULD CAUSE SERIOUS INJURY IF NOT CORRECTED. THIS HAPPENS EVERY TIME I FILL THE VEHICLE UP WITH GAS AND IT'S RIDICULOUS.

GAS SPILLS OUT WHEN FILLING TANK INSTEAD OF CLICK GAS PUMP OFF AUTOMATICALLY

MY JEEP WRANGLER SPEWS GAS ON EVERY FILL UP. RUINED PANTS, SHOES. FEAR GAS IS GOING TO IGNITE FROM HOT EXHAUST. DOES EVERY EVERY TIME. SOMEONE GOING TO GET HURT SERIOUSLY. EVERYONE IS PURCHASING GM FILLER TUBE WITH FLAPPER TO REPLACE JEEP FILLER. DONE SO FREQUENTLY CAN'T GET PART. JEEP COULD FIX EASILY INSTALLING 20 DOLLAR FILLER TUBE OR PUTTING NEW VALVE IN TANK. THIS IS SERIOUS.

Mileage: 67,000

WHEN YOU FILL UP THE GAS TANK THE AUTOMATIC STOP DOESN'T WORK AND THE GAS SPILLS OUT ALL OVER THE PLACE. I BOUGHT THE JEEP USED ON JULY 11, 2014, AND I JUST HAVE NEVER DONE ANYTHING ABOUT IT. WHEN I BOUGHT IT, IT HAD 35,000 MILES, NOW I HAVE 70,666 MILES. I WENT ONLINE AND ON THE JEEP FORUM AND YOUTUBE SOME PEOPLE HAD FIXES BY BUYING A GM NEW FUEL FILLER HOSE PART #15131046 AND REPLACING IT AND IT SEEMS TO HAVE WORKED. ACCORDING TO WHAT I'VE READ THE WARRENTIES WERE EXTENDED FOR 2007 AND OVER BUT NOT THE 2006'S.

FUEL TANK FILLER NECK SPILLS GASOLINE FORCEFULLY OVER THE SIDE, FENDER FLARE AND GROUND, WHICH REQUIRES A SPILL KIT TO BE USED TO CLEANUP THE PUDDLE CREATED BY THIS SPILL. THIS PROBLEM HAS OCCURRED BEFORE AND WAS FIXED USING THE SAME FAULTY PARTS WHICH AT THAT TIME WAS UNDER WARRANTY. APPROXIMATELY 4000 MILES LATER THE SAME SPILLING OF GASOLINE OCCURRED BUT DEALERSHIP SAID THE VEHICLE WAS OUTSIDE THE WARRANTY PERIOD AND THAT IT WOULD COST ME $1000 TO REPAIR. I BELIEVE THIS IS AN EXTREME FIRE HAZARD AS WELL AS A POSSIBLY SEVERE INJURY TO MYSELF AS THE GASOLINE COULD FLY INTO MY EYES OR UNTO MY CLOTHES. I DEMAND A COMPLETE NEW FUEL TANK CONFIGURATION AND FUEL FILLER NECK PARTS. TWO EXACT PROBLEMS MEANS FAULTY EQUIPMENT PARTS AND SHOULD BE REPAIRED WITH UPDATED PARTS. THE FIRST TIME IT WAS FIXED IS LISTED BELOW.

Mileage: 34,000

GAS TANK OVERFLOWS WITH FUEL WHEN FILLING GAS TANK AND SPRAYS BACK ON YOU AND TO GROUND. I ATTACHED A LINK TO A YOUTUBE VIDEO. THIS IS NOT MY CAR BUT I HAVE THE EXACT SAME PROBLEM. HTTPS://WWW.YOUTUBE.COM/WATCH?V=ZOUVOKEOLO8

Mileage: 30,000

WHEN FUELING THE VEHICLE, THE FUEL SPLASHES BACK AT NEAR FULL. THE FUEL LEAKS DOWN THE PLASTIC FUEL DOOR AREA AND ONTO THE PAINTED FINISH ON THE BODY. I HAVE HAD IT SPLASH BACK ONTO MYSELF, ALSO. THERE IS SUPPOSEDLY A FAULTY FLAPPER VALVE INSIDE THE FILLER HOSE BEFORE THE FUEL ENTERS THAT TANK. THIS IS A KNOWN ISSUE ON THE 97-06 WRANGLERS.

Mileage: 63,000

WHEN SITTING STILL WITH THE ENGINE OFF AND PUTTING GAS IN MY 06 JEEP WRANGLER, THE GAS PUMP DOES NOT KICK OFF QUICK ENOUGH WHEN THE TANK IS FULL AND SPILLS GAS DOWN THE SIDE OF THE JEEP AND ONTO THE GROUND CREATING A VERY DANGEROUS FIRE HAZARD - IF YOU ARE NOT STANDING BACK, IT WILL SPLASH GAS ONTO YOUR CLOTHES WHICH COULD BE A DANGEROUS PERSONAL HAZARD WITH THE POTENTIAL OF BURNS TO A PERSONS BODY. GETTING IN AND OUT OF A VEHICLE PRODUCES STATIC ELECTRICITY AND COULD BE ENOUGH TO START A FIRE WITH THE JEEP AND POTENTIAL DANGER TO PEOPLE AND PROPERTY. THE JEEP WILL "BURP" GAS EVERYTIME THAT YOU FILL IT - THIS HAS HAPPENED ON NUMEROUS OCCASIONS. I DO NOT EVEN FILL THE TANK AND LET THE PUMP KICK OFF ANYMORE FOR THIS REASON - IT IS A DANGEROUS SITUATION IF YOU WAIT FOR THE PUMP TO KICK OFF.

Mileage: 32,000

THE JEEP HAS WHAT HAS BEEN TERMED THE JEEP DEATH WOBBLE. THE JEEP IS ALL STOCK, NOT LIFTED AT ALL. I HAVE FIRED THE PARTS CANNON AT THE JEEP...ALL THE WORK HAS BEEN PERFORMED BY FACTORY TRAINED TECHNICIANS USING OE PARTS. I HAVE CHANGED THE TIRES TWICE IN 20,000 MILES. THE JEEP GETS A TERRIBLE WOBBLE ON THE HIGHWAY AT 55MPH (SPEED LIMIT ON 465 IN INDIANAPOLIS) AND CAN ONLY BE BROUGHT UNDER CONTROL BY STOPPING THE VEHICLE. EVEN THOUGH I HAVE NEVER BEEN IN AN ACCIDENT CAUSED BY THE EXCESSIVE WOBBLE, IT IS DEFINITELY NOT SAFE TO COME TO A COMPLETE STOP ON THE HIGHWAY. IT'S NOT ALWAYS EASY TO PULL OVER TO THE SIDE OF THE ROAD ON A BUSY INTERSTATE HIGHWAY. THE FUEL FILLER NECK OFTEN OVERFLOWS WHEN FILLING THE FUEL TANK ALSO. THERE WAS A RECALL ON SOME JEEPS FOR THIS SAME PROBLEM. HOWEVER, THE JEEP DEALERSHIP SAID MY SPECIFIC JEEP DOESN'T QUALIFY FOR THE FIXING OF THE ISSUE. IT IS DEFINITELY NOT SAFE TO HAVE A FUEL FILLER NECK THAT DOESN'T STOP THE FUEL NOZZLE FROM FLOWING.

Mileage: 59,000

WHEN FILLING THE FUEL TANK THE FUEL FILLER HOSE FAILS TO STOP THE FLOW OF FUEL COMING BACK OUT OF THE TANK. THIS RESULTS IN FUEL SPILLING ON THE GROUND AND DOWN THE SIDE OF THE VEHICLE.

Mileage: 68,000

FUEL PUMP DOES NOT SHUT OFF WHEN FULL CAUSING ABOUT 10 OUNCES OF FUEL TO SPRAY ON ME AND ON THE GROUND. IT ALSO DRIPS DOWN THE PAINT WHICH CAN CAUSE ISSUES DOWN THE ROAD OVER TIME

Mileage: 11,301

WHILE FUELING AND BEFORE THE PUMP AUTOMATICALLY SHUTS OFF, FUEL SPRAYS OUT OF THE FILLER NECK, RUNS DOWN THE FENDER AND ONTO THE GROUND. THIS IS NOT JUST RANDOMLY IT HAPPENS AT EVERY FILL UP.

Mileage: 88,657

WHEN FILLING UP TANK, FUEL COMES POURING OUT WHEN TANK IS DONE BEING FILLED

Mileage: 82,000

2006 WRANGLER UNLIMITED (RUBICON) OVERFILLS WITH GASOLINE BEFORE THE PUMP STOPS. ABOUT A CUP OF FUEL, DOES NOT MATTER WHICH GAS STATION OR HOW FAST THE TANK IS FILLED. IT HAS BEEN DOING THIS SINCE I PURCHASED IT FROM JEEP DEALER IN 2013.

Mileage: 59,000

WHILE FUELING MY 2006 JEEP WRANGLER, THE FUEL FAILED TO STOP DISPENSING WHEN THE TANK WAS FULL. THIS RESULTED IN FUEL SPEWING OUT FROM THE TANK. THE FUEL GOT ON ME AS WELL AS THE JEEP AND THE IMMEDIATE SURROUNDING AREAS. I HAVE FUELED THE JEEP AT MULTIPLE GAS STATIONS WITH THE SAME RESULT. FUEL SPILLING OUT FROM THE TANK IS A SERIOUS FIRE, ENVIRONMENTAL, AND HEALTH HAZARD. AFTER REVIEWING THE NHTSA'S WEBSITE AS WELL AS OTHER REPUTABLE SOURCES, THIS SEEMS TO BE A VERY COMMON PROBLEM/COMPLAINT. I'M AWARE THAT THE 2007 AND NEWER JEEPS HAVE A RECALL TO FIX THIS PROBLEM. I FAILED TO REALIZE HOW SUCH A COMMON AND SERIOUS PROBLEM CAN BE IGNORED IN THE 2006 JEEPS.

Mileage: 99,000

JUST PURCHASED THIS JEEP FROM A DEALERSHIP AND WHEN I FILL UP THE TANK WITH GAS IT OVERFLOWS EVERY TIME SPILLING GAS ALL OVER THE GROUND AND OVER THE DRIVERS REAR QUARTER PANEL. IT IS HARD TO STOP THE OVERFLOW DUE TO THE GAS COMING OUT, DANGER OF FUEL GETTING ON MY CLOTHES WHICH THEN MAKES ME FLAMMABLE AND SMELL LIKE FUEL. THERE IS ALWAYS THE DANGER OF FUEL GETTING IN MY EYES AS WELL, I DO NOT FEEL SAFE WITH THIS FLAW. I DON'T BELIEVE THAT ALL OF THE 2005 AND 2006 JEEP OWNERS SHOULD HAVE TO DISH OUT $900 FOR A NEW FUEL TANK THAT WILL FAIL AGAIN ANYWAY BECAUSE THE ICV VALVE WILL JUST FAIL AGAIN. THIS IS A STATIONARY ISSUE WHEN FILLING THE GAS TANK. CAN'T BELIEVE THAT SPILLING GAS ON THE GROUND EVERY TIME IS THAT GOOD FOR THE ENVIRONMENT.

Mileage: 63,500

FUEL SPILLS OUT OF THE FILLER PORT DUE TO INCORRECT ENGAGEMENT OF THE STOP ON FUEL PUMP NOZZLES. THIS IS DUE TO A MALFUNCTIONING ICV. THE JEEP HAS BEEN DOING THIS SINCE I HAVE OWNED IT AND THE PREVIOUS OWNER STATED IT DID THE SAME THING SINCE HE AND HIS WIFE BOUGHT IT IN 2008 -WHEN THE VEHICLE WAS ONLY TWO YEARS OLD.

Mileage: 53,000

I BOUGHT MY 2006 JEEP WRANGLER RUBICON NEW FROM A DEALERSHIP. AFTER FEW YEARS I STARTED HAVING ISSUES WITH FUEL SPITTING OUT OF THE GAS FILLER WHEN FILLING UP AT A GAS STATION. ABOUT 1/4 TO 1/2 CUP AT A TIME. DOESN'T MATTER WHICH STAION OR WHICH PUMP I USE. THE PUMP I USE WOULD CLICK OFF,BUT ALWAYS A SECOND TOO LATE. THIS IS A VERY DANGEROUS PROBLEM IN THAT NOT ONLY IS IT DAMAGING MY PAINT AND WHEEL WELL FLARES BUT ALSO SPILLING GAS ON THE GROUND CREATING AN ENVIRONMENTAL HAZARD AS DEFINED AND REGULATED BY THE ENVIRONMENTAL PROTECTION AGENCY, AS WELL AS SPLASHING ONTO THE PERSON FILLING THE JEEP COVERING THEM IN FLAMMABLE CHEMICALS AND EXPOSING THEM TO LONG-TERM HEALTH ISSUES THROUGH INHALATION AND SKIN ABSORPTION AS ADDRESSED BY THE NATIONAL INSTITUTES OF HEALTH. NOT TO MENTION WITH THE FUEL SPILLING OUT LIKE THAT, IT ALSO CREATES A LOT OF FUEL VAPORS. WITH JUS A STATIC SPARK, IT COULD VERY WELL INGNITE THE FUEL. I CONSIDER THAT A VERY DANGEROUS SITUATION.

Mileage: 20,000

WHEN FUELING THE VEHICLE, WHEN THE TANK IS FULL AND THE GASOLINE NOZZLE SHUTS OFF, APPROXIMATELY ONE CUP OF GASOLINE COMES OUT OF THE VEHICLE FILLER TUBE AND SPRAYS THE AREA AROUND THE FILLER INLET AND DOWN THE SIDE OF THE VEHICLE. THIS EVENT OCCURS REGARDLESS OF THE RATE OF FUEL FLOW. THIS EVENT OCCURS WHEN THE FILLER NOZZLE TURNS OFF AUTOMATICALLY OR WHEN THE USER MANUALLY CONTROLS THE RATE OF FUEL. THIS PROBLEM HAS BEEN DIAGNOSED BY FCA AS A DEFECT IN A PLASTIC VALVE LOCATED IN THE VEHICLE'S FUEL TANK THAT REACTS NEGATIVELY WITH GASOLINE ADDITIVES, SPECIFICALLY ETHANOL. FCA DOES NOT CONSIDER THIS TO BE A SAFETY ISSUE. AS THE VEHICLE OWNER, I CONSIDER THE FACT THAT THE VEHICLE SPEWS GASOLINE OUT AT ME WHILE REFUELING TO BE A SAFETY ISSUE AND REQUEST THAT THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION TAKES STEPS TO REQUIRE FCA TO RESOLVE THIS ISSUE BEFORE SOMEONE IS BURNED. THANK YOU. *TR UPDATED 9/15/15*CW *CN

Mileage: 30,000

I BOUGHT MY 2006 JEEP WRANGLER RUBICON NEW FROM A DEALERSHIP. AFTER ABOUT TWO YEARS I STARTED HAVING ISSUES WITH FUEL SPITTING PUT OF THE GAS FILLER WHEN FILLING UP AT A GAS STATION. THIS IS MY WIFE'S VEHICLE AND SHE COMPENSATED BY NOT FILLING IT FULL BY SHUTTING THE FUEL PUMP OFF BEFORE THE HANDLE WOULD CLICK. OVER THE YEARS I HAVE MENTIONED IT TO DEALERSHIPS AND REPAIR SHOPS AND NO ONE EVER HEARD OF IT. IT IS AT A DEALERSHIP NOW FOR ANOTHER ISSUE AND AGAIN I MENTIONED THE GAS SPITTING OUT OF THE GAS NECK AND RUNNING DOWN THE JEEP SIDE AND GETTING ME WET. THEY SAID THEY KNOW ABOUT THE ISSUE AND THAT JEEP AND NHTSA HAD ADDRESSED THE ISSUE IN A COMPROMISE BY JEEP OFFERING AN EXTENDED WARRANTY ON 2007 AND 2008 MODELS AND JEEP SENT OUT COMMUNICATIONS TO THAT EFFECT. SINCE I HAVE A 2006, I NEVER RECEIVED ANY NOTIFICATION ABOUT THE FUEL OVERFLOW PROBLEM, UNTIL NOW. I CONTACTED JEEP AND THEY ACKNOWLEDGED THE ISSUE BUT REFUSED TO ADDRESS IT. THIS IS A VERY DANGEROUS PROBLEM IN THAT NOT ONLY IS IT DAMAGING MY PAINT AND WHEEL WELL FLARES BUT ALSO SPILLING GAS ON THE GROUND CREATING AN ENVIRONMENTAL HAZARD AS DEFINED AND REGULATED BY THE ENVIRONMENTAL PROTECTION AGENCY, AS WELL AS SPLASHING ONTO THE PERSON FILLING THE JEEP COVERING THEM IN FLAMMABLE CHEMICALS AND EXPOSING THEM TO LONG-TERM HEALTH ISSUES THROUGH INHALATION AND SKIN ABSORPTION AS ADDRESSED BY THE NATIONAL INSTITUTES OF HEALTH.

Mileage: 23,000

WHEN FILLING THE GAS TANK, IT WILL OVERFLOW, SPILLING GAS ON THE SIDE OF THE JEEP WRANGLER, THE TIRE AND THE GROUND. IT SEEMS LIKE THE FLAPPER VALVE IN THE FILLER NECK ISN'T PREVENTING SPILLS. IT HAPPENS EVERYTIME I'VE FILLED UP, SO I TRY NOT TO FILL THE TANK ANYMORE. I BELIEVE IT'S A SERIOUS SAFETY AND FIRE HAZARD. ONE SPILL WAS SO BIG, THE GAS STATION EMPLOYEES HAD TO USE KITTY LITTER TO SOAK IT ALL UP

Mileage: 72,500

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE REFUELING, THE FUEL PUMP FAILED TO SHUT OFF AND CAUSED FUEL TO SPEW OUT WITH FORCE AND SPILL ONTO THE GROUND. THE CONTACT STATED THAT THIS WAS A RECURRING FAILURE. THE VEHICLE WAS NOT TAKEN IN FOR DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 50,000. UPDATED 10/19/15 *BF

Mileage: 50,000

WHEN REFILLING MY GAS TANK THE GAS PUMP DOES NOT SHUT OFF AND GAS SPILLS OUT WITH FORCE CAUSING GAS TO SPILL ALL OVER THE PLACE (MYSELF, JEEP & THE GROUND). THIS IS A VERY COMMON PROBLEM WITH 2006 WRANGLERS (TJ & LJ) & JEEP FINALLY NEEDS TO DO SOMETHING ABOUT THIS FOR THESE MODELS AS WELL. THESE WERE THE WRANGLERS THAT TESTED SOME OF THE NEW PARTS FOR THEIR JK MODELS THAT CAME OUT IN 2007 TO PRESENT. A RECALL HAS BEEN ISSUED FOR THE 2007 & NEWER MODELS FOR THIS SAME PROBLEM. HOW ABOUT FIXING WHERE THE PROBLEM STARTED AT ORIGINALLY. THANK YOU, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB

Mileage: 41,000

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE PUMPING FUEL INTO THE VEHICLE, THE FUEL WOULD OVERFLOW REGARDLESS OF THE AMOUNT WITHIN THE VEHICLE. THE FAILURE RECURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 5,000.

Mileage: 5,000

WHEN FILLING GAS TANK, FUEL GUSHES (NOT A DROP, NOT A TRICKLE, RATHER A VIOLENT EXPULSION OF FUEL) FROM THE FILL NECK. MANY JEEP WRANGLER OWNERS REPORT THE SAME PROBLEM. THIS IS A SERIOUS SAFETY ISSUE.

Mileage: 36,000

I PURCHASED THIS JEEP USED AND THE VERY FIRST TIME I FILLED THE FUEL TANK, GAS SPEWED PROFUSELY FROM THE TANK OPENING WITHOUT TRIGGERING THE NOZZLE TO STOP AS THE TANK WAS APPROACHING FULL. THIS CAUSES GASOLINE TO SPRAY ALL OVER THE VEHICLE, THE PUMP, THE OPERATOR, AND TO PUDDLE ON THE GROUND. THIS SAME SCENARIO HAS PLAYED OUT AT EVERY GAS STATION I HAVE VISITED SINCE. THE ONLY SOLUTION IS TO TRY TO GUESS WHEN THE TANK IS CLOSE TO FULL AND STOP THE PUMP PREMATURELY. THIS IS A SERIOUS SAFETY AND ENVIRONMENTAL ISSUE THAT WARRANTS IMMEDIATE CORRECTION FROM THE MANUFACTURER. I CONTACTED THE PREVIOUS OWNER OF THE VEHICLE AND SHE STATED THAT THE SAME FUEL OVERFLOW PROBLEM WAS PRESENT THE ENTIRE TIME SHE OWNED THE VEHICLE. IN SPEAKING WITH OTHER JEEP OWNERS, THIS IS A VERY COMMON PROBLEM WITH 2005-2006 JEEP WRANGLER MODELS AND HAS EVEN RESULTED IN AT LEAST ONE CLASS ACTION LAW SUIT. PLEASE HELP PREVENT A FUTURE CATASTROPHE AND TAKE ACTION ON BEHALF OF THE CONSUMER ASAP.

Mileage: 49,000

THE FILLER NECK DOESN'T CLOSE FAST ENOUGH WHEN FILLING THE GAS TANK, THUS RESULTING IN GAS SPEWING OUT ONTO THE JEEP (CONSEQUENTLY FADING ANY FENDER YOU HAVE INSTALLED) AND ONTO YOUR PERSON. AS PER SEVERAL CAR MECHANICS' CONSULTATIONS, THE ETHANOL IN GAS IS/HAS ERODED THE FILLER NECK AND IT CAN'T CLOSE IN TIME. APPARENTLY THE ISSUE WAS ADDRESSED IN LATER MODELS OF THE JEEP WRANGLER. IT IS A NEARLY $600 FIX (INCLUDING LABOR). TEMPORARY SOLUTION: ONLY PUT ABOUT $25 IN THE GAS TANK AT A TIME (WHICH IS INCONVENIENT IS YOU ARE CONSTANTLY TRAVELING).

Mileage: 63,000

WHEN FILLING THE FUEL TANK IT ALWAYS OVERFLOWS. IT DOES NOT MATTER THE STATION OR HOW THE PUMP IS IN THE TANK. IT ALWAYS SHOOTS GAS OUT BEFORE IT KICKS OFF. I THINK THIS IS A SERIOUS FIRE HAZARD AND I ALSO CAN SPRAY FUEL ON THE PERSON FILLING. IT SOUNDS LIKE THIS IS AN ONGOING ISSUE WITH THIS MODEL AND NOTHING HAS BEEN DONE???

Mileage: 98,000

EVERY TIME THE GAS IS FILLED, FUEL OVERFLOWS AND POURS ONTO THE VEHICLE, GROUND AND WHOMEVER IS STANDING NEAR IT. *TR

Mileage: 30,500

TANK OVERFLOWS WHEN FILLING UP WITH FUEL. PUMP AUTO SHUT OFF DOES NOT WORK ON THIS VEHICLE AT ANY STATION. ALWAYS GET FUEL OVERFLOW. *TR

Mileage: 36,002

2006 JEEP WRANGLER UNLIMITED AFTER GETTING FUEL FILLED I PULL OUT OF STATION AND IT STARTS HESITATING AND THEN STALLS IN MIDDLE OF STREET. IT NEARLY CAUSED AN ACCIDENT FROM CAR BEHIND ME I HAD TO RESTART AND IT WOULD STALL AND BOG FEW MORE TIMES THEN RUN OK. TODAY I FUELED UP AND PULLED OUT OF STATION AT A 6 LANE DIVIDED ROAD WITH AN INTERSTATE WITH ON AND OFF RAMPS BOTH SIDES SO I HAD ONLY 100 FEET TO CROSS THREE LANES TO GET INTO LEFT TURN LANE FOR INTERSTATE AS THIS LANE GOES UNDER AND AT LIGHT TURNS LEFT TO ON RAMP, JUST TO GIVE YOU INSIGHT ON SITUATION, I FUEL UP PULL OUT AND IT SHUTS OFF CARS HAVE TO STOP I AM IN MIDDLE OF THREE LANE DEAD IN THE WATER IT STARTS BACK UP AND I PULL UP THANK GOD A SAFE DISTANCE TO CAR IN FRONT OF ME AND IT BOGS DOWN AND THE SURGES MAKING THE JEEP THRUST FORWARD HAD TO BRAKE HARD NO ACCIDENT WAS CAUSED BUT GOD FORBID IT COULD HAVE PLEASE RESEARCH THIS. *TR

Mileage: 104,230

WHEN REFUELING FUEL TANK ON THIS VEHICLE THE FUEL PUMP WILL NOT SHUT OFF WHEN FUEL ENTERS FILLING TUBE OF VEHICLE THUS CAUSING FUEL TO BE SPILLED OUT OF THE FILLING TUBE AND ONTO EXTERIOR OF VEHICLE, DRIVING SURFACE AND FUEL FILLING SYSTEM INCLUDING THE HOSES AND PUMP(S). THE FUEL FLOW HAS SUCH FORCE THAT THE PERSON OPERATING FILLING PUMP WILL ALSO BE SPRAYED WITH FUEL ON THEIR PERSON AND CLOTHES AS WELL AS AREAS MENTIONED PREVIOUSLY. THIS CAUSES A SEVERE EXPLOSIVE ENVIRONMENT IN THE PROXIMITY OF STATIC ENERGY. I HAVE NEVER REFUELED MY VEHICLE WITHOUT THE OVERFLOW HAPPENING UNLESS I ONLY PARTIALLY FILLED MY FUEL TANK, WHY HAVE A 19 GALLON TANK IF YOU CAN ONLY USE 2/3 OF IT? THERE IS A SEVER DANGER OF FIRE/EXPLOSION DUE TO THE AMOUNT OF FUEL THAT IS SPILLED BEFORE THE PUMP IS STOPPED. *TR

Mileage: 200

EVERY TIME I FILL THE TANK FULLY, SINCE NEW, THIS VEHICLE HAS OVERFILLED AND SPILLED APPROXIMATELY 0.3 GALLONS OF FUEL. I HAVE TWO FRIENDS WITH 05-06 JEEP WRANGLERS WITH THE SAME FUEL FILLER NECK, BOTH HAVE THE SAME PROBLEM. CHRYSLER IS UNWILLING TO REPAIR AT A REASONABLE COST, BUT IT IS A DESIGN FLAW THAT IS DANGEROUS TO THE OWNER OF THE VEHICLE AND THE ENVIRONMENT. *TR

Mileage: 200

DURING THE REFUELING PROCESS FUEL WILL SPRAY OUT OF THE NOZZLE SPAYING ME AND THE VEHICLE. THIS HAPPENS WITHOUT WARNING AND WILL TAKE YOU BY SURPRISE IF YOU ARE NOT CAREFUL.THIS HAPPENS EVERY TIME I HAVE BEEN READING ABOUT THIS PROBLEM WITH THIS YEAR OF JEEP AND IT SEEMS AS IF THERE ARE A LOT OF VEHICLES INVOLVED WITH THIS PROBLEM FOR THE YEAR I OWN. GOOGLE "GAS SPILL PROBLEMS JEEP 2006" AND YOU WILL SEE. *TR

Mileage: 82,000

WHEN FILLING THE TANK, RATHER THAN SHUTTING OFF THE GAS, IT BURPS AND OVERFLOWS. THIS HAPPENS EVERY TIME I FILL IT. *TR

Mileage: 47,903

WHEN REFUELING THE GASOLINE TANK WILL OVERFLOW SPILLING UPWARDS OF A QUART OF GASOLINE ON THE OPERATOR,(IN EYES AND ON CLOTHS) THE VEHICLE AND THE GROUND. GASOLINE IS HIGHLY FLAMABLE! THIS IS A VERY COMMON PROBLEM WITH JEEP WRANGLERS OF THE 2005 AND 2006 MODELS HAPPENING TO EVERY SINGLE OWNER I HAVE TALKED TO.IN OREGON WE DO NOT PUMP OUR OWN GAS AND THE STATION EMPLOYEES SAYS "IT HAPPENS WITH ALL THESE JEEPS" WHEN I GO OUT OF STATE AND PUMP MY OWN GAS IT ALLWAYS SPLASHES OUT GETTING GAS EVERYWHERE. THIS IS A WIDELY COMMEN PROBLEM WITH THESE VEHICLES AND I CANT BELIVE IT HAS BEEN ALLOWED TO GO ON THIS LONG WITH OUT BEING ADDRESS AS IT IS VERY DANGEROUS WHEN FUELING YOUR CAR AND GETTING SPILLED GAS EVERYWHERE. *JS

Mileage: 10,000

FILLING GAS GOT SPRAYED WITH GAS ON FACE HANDS AND ARMS MY SKIN BURNED I SMELLED LIKE GAS FOR A LONG TIME THIS IS A MAJOR SAFTY.. GAS ON GROUND ON VEHICLE HAD 3 JEEP WRANGLERS ALL HAD SAME PROBLEMS .DO I HAVE TO DIE.. PLUS GAS CAUSES CANCER. FILLING GAS EVERY 3 DAYS GETING SPAYED WITH GAS.. BREATHING POISON GAS FUMES. DEATH WOBBLE FRONT END .PLUS FIRE RISK. WE NEED.HELP. NOW. IF THERE IS CLASS ACTION LAWSUIT LOOK ME UP. SAFTY FIRST. HELP US. *JS

Mileage: 28,100

GAS TANK OVERFLOWS AT THE GAS PUMP, SPITING FUEL EVERYWHERE. ALSO WHILE FILLING, THE PUMP CONSTANTLY SHUTS OFF AS IF THE FILL NECK OF THE JEEP IS OVERFLOWING. I HAVE TO BARELY HOLD THE PUMP IN THE ON POSITION IN ORDER TO FILL AND IT STILL OVERFLOWS. THIS PROBLEM IS DANGEROUS AND NEEDS TO BE ADDRESSED. *TR

Mileage: 100,000

WHEN FUELING THE FUEL OVERFLOWS EVERY TIME. THIS CAN NOT BE SAFE. *TR

Mileage: 79,000

WHEN FILLING THE FUEL TANK, THE FUEL OVERFLOWS AND SPILLS GAS ON THE GROUND. THIS IS A DEFECT IN THE OVERFLOW VALVE IN THE GAS TANK THAT CAUSES PRESSURE TO BUILD WHEN THE TANK IS NEAR COMPLETELY FULL DURING A FILL-UP. MANY OTHER JEEP OWNERS HAVE HAD THE SAME PROBLEM ACCORDING TO THE ONLINE JEEPFORUM.COM, WRANGLERFORUM.COM AND OTHERS. A RECALL IS NECESSARY TO PREVENT POSSIBLE FIRES AND EXPLOSIONS. MANY OTHER JEEP OWNERS HAVE EXPERIENCED THIS PROBLEM WITH BOTH TJ AND JK WRANGLERS. SOME HAVE REPLACED THE FUEL OVERFLOW VALVE AND SOLVED THE PROBLEM. *TR

Mileage: 53,100

THE GAS TANK OVERFLOWS WHEN IT IS BEING FILLED. THIS IS A SERIOUS FIRE HAZARD TO BOTH THE VEHICLE OWNER AND THE GENERAL PUBLIC AS A LARGE QUANTITY OF GAS OVERFLOWS OUT OF THE TANK. *TR

Mileage: 40,000

WHEN I FILL UP WITH FUEL AFTER PUMP SHUTS OFF FUEL GUSHES OUT ON SIDE OF JEEP AND ONTO GROUND. *TR

Mileage: 50,000

I BOUGHT A USED RHD 2006 WRANGLER SPORT IN NOV. 2013 FOR $18,500.00.........AND YOU GUYS WILL NOT FIX THE GAS TANK THAT BLOWS GAS OUT WHILE YOU ARE FILLING IT, I LOSE AT LEAST A HALF A GALLON OF GAS EACH TIME I FILL IT UP, AND IT LEAVES A HUGE PUDDLE ON THE GROUND AND ONE TIME SOMEONE IS GOING TO THROW A LIT CIGARETTE IN IT OR IGNITE IT IS SOME WAY AND PEOPLE ARE GOING TO GET HURT........... I AM SOOOOOOOOOOOOOOOOO UPSET OVER THIS, AND THE REASON YOU WON'T FIX IT IS BECAUSE IT IS A RHD FLEET VEHICLE.......IT IS MY REGULAR CAR, AND I DRIVE IT EVERYWHERE, AND IF ANYTHING HAPPENS I WILL SUE YOU UNTIL THERE IS NO TOMORROW. *TR

Mileage: 53,858

SEVERE FUEL SPIT BACK WHEN FILLING UP MY JEEP WRANGLER. GAS SPILLED ALL OVER THE VEHICLE AND GROUND! *TR

OVERFLOW OF GAS WHEN FILLING 100% OF TIME. *TR

Mileage: 50,000

EVERY TIME I FUEL UP UNLESS I LISTEN VERY CAREFULLY TO THE CHANGE IN THE SOUND OF THE GASOLINE FROM THE PUMP INTO THE TANK THE FUEL FILLER FAILS TO AUTOMATICALLY CUT OFF WITHOUT OVERFLOWING. EVERY WRANGLE UNLIMITED OWNER I HAVE ASKED EXPERIENCES THE SAME PROBLEM, YET CHRYSLER FAILS TO ACKNOWLEDGE THE ISSUE. I AM PERSONALLY UNAWARE OF ANY FIRES RESULTING FROM THIS PROBLEM, BUT THE POTENTIAL DEFINITELY EXISTS. *JS

Mileage: 20,000

FUEL PUMP WILL NOT SHUT OFF WHEN THE TANK IS FULL RESULTING IN GASOLINE SPILLED ON THE VEHICLE AND ALL OVER THE GROUND. *TR

Mileage: 104,000

OBVIOUSLY THERE ARE MANY COMPLAINTS YET YOU GUYS ARE IGNORING THEM. YOU FILL UP WITH GAS AND AT TOP OFF IT SPITS GAS OUT THAT GETS ALL OVER THE PERSON FILLING CLOTHES. THIS IS A MAJOR PROBLEM THAT YOU NEED TO GET OFF YOUR ASSES AND GET THIS PROBLEM RESOLVED BEFORE SOMEONE GETS HURT. I PURCHASED THIS VEHICLE RECENTLY AND FILLED UP 5 TIMES AND THIS OCCURRED EVERYTIME. FIX IT! *TR

Mileage: 53,000

WHEN FILLING THE FUEL TANK THE PUMP CUTS OFF TO LATE AND CREATES SPLASH BACK AND POURS GASOLINE ON THE GROUND AND ALL OVER WHOEVER IS NEAR BY. *TR

GAS PUMPS WILL NOT FILL VEHICLE PROPERLY. GASOLINE SPILLS FROM FILLER NECK ACROSS BACK END OF VEHICLE WHENEVER I FILL VEHICLE WITH FUEL. *TR

Mileage: 125,000

WHEN VEHICLE IS BEING FUELED UP, GAS LEAKS OUT OF TANK AND SPILLS. SEEMS THE CHECK VALVE IS STUCK OF BROKEN. I MUST MAKE SURE I STOP FILLING BEFORE IT GETS FULL SO IT DOESN'T SPILL. *TR

Mileage: 20,000

GAS SPURTS OUT OF TANK WHEN I FILL IT UP AND DRIPS ALL OVER GAS STATION FLOOR. THE GAS PUMP DOES NOT STOP ONCE ITS FULL LIKE OTHER CARS AND IM WORRIED SPILLED FUEL COULD IGNITE. ALSO BAD FOR ENVIRONMENT. *TR

Mileage: 40,000

OVER FILLS AT THE FUEL PUMP ALL THE TIME.

Mileage: 38,000

AT EVERY FILL UP FUEL SPILLS ALL OVER MYSELF ,MY CAR AND THE FLOOR. VERY UNSAFE! AUTOMATIC SHUT OFF NEVER KICKS IN WHEN FULL. HOW MANY COMPLAINTS DO YOU NEED AND FOR HOW MANY YEARS! DOES ANYBODY ACTUALLY READ THEM BESIDES THE CONSUMER? THERE ARE OVER 500 COMPLAINTS OF THIS ON THIS WEBSITE ALONE. WHAT DOES IT TAKE TO GET A RECALL? *TR

Mileage: 47,000

FUELING THE VEHICLE ALWAYS RESULTS IN FUEL SPRAY FROM THE VENT ON THE FILLER NECK. THIS SPRAY HAPPENS 100% OF FUELINGS. THE TANK IS OFTEN LESS THAN 90% FULL AFTER THIS AND REQUIRES TOPPING AND ADDITIONAL FUEL SPRAY. I HAVE HAD TO REPORT TO NAVY MEDICAL TO HAVE MY EYES FLUSHED AND CHECKED AFTER BEING SHOT DIRECTLY IN THE EYES WHILE LISTENING FOR THE DISTINCT SOUND OF FUEL BUBBLES RISING TO THE TOP OF THE FUEL FILLER NECK. THIS CAUSES ON AVERAGE 1/8 GALLON OF FUEL TO BE SPILLED PER FILL UP. OVER 40K MILES AT AN AVERAGE OF 14MPG THAT IS 22 GALLONS OF FUEL SPILLED AND MORE EVAPORATED. IF FILLING STATIONS REQUIRE SHUT OFF VALVES, AND ALL NEW VEHICLES REQUIRE EVAPORATIVE EMISSIONS SYSTEMS TO CONTROL ENVIRONMENTAL AIR QUALITY, TO THE GREAT DETRIMENT OF GAS MILEAGE, WHY HAS THIS ISSUE NOT BEEN INVESTIGATED BY THE FEDERAL GOVERNMENT? WHY DO WE HAVE TO USE SHODDY GAS CANS WITH CARB COMPLIANT NOZZLES WHICH CAUSE MORE FUEL SPILLS THAN NORMAL FUEL CONTAINERS IF THE GOVERNMENT IS PREPARED TO IGNORE THIS? I'VE BEGUN USING SURPLUS NATO JERRY CANS TO FILL MY TRUCK AND AVOID BEING SOAKED IN DANGEROUSLY FLAMMABLE AND CANCER CAUSING FUEL. *TR

Mileage: 43,000

WHEN PUTTING GAS IN MY JEEP USING A FUEL PUMP GAS RUNS OUT ALL DOWN THE SIDE OF MY VEHICLE AND MAKES A PUDDLE ON THE GROUND BEFORE THE PUMP CLICKS OFF. THIS HAS BEEN HAPPENING FOR OVER A YEAR NOW. IT HAPPENS EVERY TIME I FILL UP MY CAR UNLESS I HAPPEN TO HEAR HOW CLOSE THE GAS LEVEL IS GETTING AND SHUT THE PUMP OFF ON MY OWN. *TR

WHILE FILLING THE GAS TANK THE PUMP NEVER SHUT OFF CAUSING GAS TO SPILL EVERYWHERE. FAULTY CHECK VALVE IN FUEL TANK. SHOULD BE RECALLED. *TR

Mileage: 75,500

GAS TANK HAS SPLASH BACK EVERY TIME YOU FUEL IT SPILLING GAS OUT ONTO FENDER AND GROUND. *TR

Mileage: 8,000

WHILE FUELING UP MY 2006 JEEP UNLIMITED TJ, THE GAS SPILLS OUT ALL OVER THE SIDE OF THE JEEP ONCE IT'S FULL INSTEAD OF TURNING OFF THE PUMP. THIS HAS BEEN AN ISSUE SINCE DAY ONE, WHICH MEANS THERE SHOULD BE A RECALL AS MANY OTHER 05 & 06 JEEPS HAVE THE SAME EXACT ISSUE. *TR

Mileage: 1,000

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT FUEL SPILLED TO THE GROUND WHEN THE FUEL TANK WAS FILLED. THE VEHICLE WAS TAKEN TO THE DEALER TO HAVE A DIAGNOSTIC PERFORMED WHICH LOCATED THE FAILURE AT THE FUEL TANK VALVE. THE DEALER ADVISED THAT THE FUEL TANK NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 80,000 AND THE APPROXIMATE CURRENT MILEAGE WAS 85,000.

Mileage: 80,000

WHEN FILLING UP THE GAS TANK, GAS WILL POUR OUT WHEN IT'S FULL/OVERFULL AND SOMETIMES SPRAY GAS EVERYWHERE. *TR

Mileage: 48,000

FUELING THIS VEHICLE IS EXTREMELY DIFFICULT AND DANGEROUS DUE TO THE FACT THAT NO MATER HOW SLOW YOU TRY TO PUMP FUEL INTO IT SHOOTS BACK UP THE TANKS FUEL PIPE AND ONTO THE GROUND AND ON YOU IF YOU ARE NOT CAREFUL. THIS FUEL SYSTEM HAS AN OBVIOUS FLAW. NO VEHICLE SHOULD BE THIS DIFFICULT TO FUEL. IN 40 YEARS OF DRIVING I HAVE NEVER HAD ANYTHING LIKE THIS WITH ANY OTHER VEHICLE. I WON'T LET ANYONE ELSE PUT FUEL IN THIS 2006 JEEP WRANGLER BECAUSE I'M AFRAID A SERIOUS ACCIDENT COULD TO EASILY OCCUR. *TR

Mileage: 45,000

FUEL SPILLS EVERY TIME I FILL THE TANK. THE THING THAT IS SUPPOSED TO SHUT OFF THE NOZZLE DOES NOT WORK. *TR

Mileage: 15,000

WHEN FUELING MY 2006 JEEP LJ GAS SPRAYS OUT ALL OVER THE SIDE OF THE JEEP AND ANYONE STANDING NEAR THE BACK OF THE JEEP WHEN THE TANK IS FULL AND THE PUMP TRIPS OFF. *TR

Mileage: 36,500

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. THE CONTACT STATED THAT AFTER ADDING FUEL TO THE VEHICLE, THE FUEL PUMP AUTOMATICALLY SHUT OFF AND FUEL SPRAYED OUT OF THE FILLER NECK. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE MECHANIC STATED THE FUEL PURGE VALVE HAD TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 36,000.

Mileage: 36,000

WHEN FILLING THE FUEL TANK, REGARDLESS OF FAST OR SLOW, GAS SPEWS OUT OF THE FILL PORT WHEN THE TANK IF FULL. FAST, IT SPEWS GAS ABOUT 2 FEET OUT FROM THE VEHICLE, SLOW, IT JUST RUNS OUT THE FILLER SPOUT WITHOUT SHUTTING THE PUMP OFF. THIS IS VERY DANGEROUS AS I USUALLY LOOSE A COUPLE CUPS OF FUEL ON THE GROUND EVERY TIME I FILL UP. *TR

Mileage: 95,086

FUEL SYSTEM SPEWS FUEL ALL OVER VEHICLE AND OPERATOR WHEN FILLING. WILL NOT SHUT OFF ON ITS OWN. *TR

Mileage: 39,554

CHECK VALVE FAILS CAUSING FUEL TO SPILL OR "SPIT BACK" ONTO THE GROUND OR THE PERSON REFUELING THE VEHICLE. *TR

FUEL SPRAYS OVER ONTO THE GROUND, JEEP AND OWNER WHEN REFUELING. *TR

Mileage: 69,000

WHEN FILLING THE FUEL TANK AT A GAS STATION, THE PUMP HANDLE CLICKS OFF, AND FUEL POURS DOWN THE SIDE OF THE VEHICLE. *TR

Mileage: 32,000

WHEN FUELING, IT ALWAYS OVERFLOWS AND SPILLS FUEL OUT FROM THE GAS TANK. IT SEEMS TO BE A BIT BETTER IF I MANUALLY HOLD THE FUEL PUMP AND PUMP THE GAS AT AN EXTREMELY SLOW RATE. I AM NOT ABLE TO LET THE PUMP AUTOMATICALLY FILL OTHERWISE FUEL SPILLS. THIS HAPPENS EVERY TIME I FUEL THE JEEP. *TR

Mileage: 65,000

FUEL SPILL ON EVERY FILL UP. *TR

Mileage: 85,000

WHEN FILLING FUEL TANK GAS PUMP SHUTS OFF TOO LATE, RESULTS IN FUEL SPILLAGE EVERY TIME VEHICLE IS FILLED UNLESS THE TANK IS NOT FILLED COMPLETELY. GAS BLOWS BACK ONTO HAND OF PERSON FILLING VEHICLE CAUSING PERSONAL INJURY HAZARD, AND ALSO SPILLS ONTO GROUND AND VEHICLE CAUSING FIRE HAZARD. THE SHUT-OFF WORKS, BUT COMES TOO LATE TO BE EFFECTIVE - USUALLY PUMP SHUTS OFF THEN MOMENTARILY LATER GAS FLIES OUT OF FILLER NECK. *TR

Mileage: 50,000

CONSISTENTLY, WHILE REFUELING THE VEHICLE, REGARDLESS OF FILL RATE, IF THE NOZZLE IS NOT STOPPED MANUALLY, GASOLINE ERUPTS FROM THE FILLER NECK WHEN THE TANK IS FULL. IT IS USUALLY ENOUGH TO LEAVE GAS DRIPPING DOWN THE VEHICLE AND A SMALL PUDDLE UNDERNEATH. THIS HAPPENS EACH AND EVERY TIME IT IS FILLED. *TR

Mileage: 98,000

I WAS FILLING UP THE JEEP AND THE GAS SPILL OUT FORM THE NOZZLE. I HAVE READ ONLINE AND IT SEEMS TO BE A CONSTANT ISSUE. THIS IS NOT THE FIRST TIME IT HAPPENED TO ME AND I HAVE BEEN TO SEVERAL DIFFERENT GAS STATIONS. *TR

Mileage: 42,300

FUEL SPLASH-BACK UPON FILLING VEHICLE WITH FUEL. FUEL COVERS OUT SIDE CORNER OF VEHICLE AND GROUND CREATING HAZARDOUS CONDITIONS AS WELL AS POLLUTING GROUND WATER. *TR

Mileage: 35,000

WHEN FILLING THE GAS TANK THERE DOESN'T APPEAR TO BE ANY SHUT-OFF WHEN THE TANK IS FULL. I'VE OWNED THE JEEP FOR 2 MONTHS NOW AND THIS HAS HAPPENED 3 TIMES. WHEN THE GAS TANK GETS FULL IT SPITS OUT THE GASOLINE INSTEAD OF SHUTTING OFF THE PUMP HANDLE LIKE IT IS SUPPOSED TO. I HAVE SEARCHED THE INTERNET AND HAVE NOT FOUND ANY MENTION OF A RECALL FOR THIS PROBLEM. PLEASE ADVISE IF THERE IS A FIX FOR THIS. *TR

Mileage: 56,000

EVER SINCE I BOUGHT MY 2006 JEEP WRANGLER UNLIMITED RUBICON, I HAVE PROBLEMS WHEN REFUELING THE CAR. I BOUGHT MY CAR SECOND-HAND. IF I LEAVE THE GAS NOZZLE ON 'AUTO', THE AUTO-SHUTOFF OF THE PUMP SHUTS OFF TOO LATE, RESULTING IN A GUSH OF GASOLINE SQUIRTING OUT OF THE TANK. THE ONLY WAY TO PREVENT ANY SPILLING OF GAS DURING FUELLING IS TO LISTEN TO THE NOISE THAT THE ESCAPING AIR OUT OF THE TANK MAKES, OR GUESSTIMATING ROUGHLY HOW MUCH GAS THE CAR NEEDS, THEN MANUALLY VERY SLOWLY CONTINUE TO FILL UP. *TR

EACH TIME I REFILL THE FUEL TANK, THERE IS A LARGE AMOUNT OF SPLASH BACK OF FUEL OUT OF THE FILLER AFTER THE GAS PUMP SHUTS OFF WHEN IT DETECTS THAT THE TANK IS FULL. IT STARTED HAPPENING AROUND 30000 MILES ON THE ODOMETER AND HAPPENS EVERY TIME I REFUEL THE JEEP. *TR

Mileage: 30,000

ADDING GASOLINE TO GAS TANK AT A FILLING STATION WITH A STANDARD PUMP NOZZLE, WILL ALWAYS RESULT IN AN EXPULSION OF GASOLINE FROM THE VEHICLE FILLER OPENING WHEN THE TANK IS FULL. THE PUMP NOZZLE DOES SHUT OFF THE DELIVERY OF FUEL, BUT A SUSPECTED DESIGN FLAW PERMITS GASOLINE TO ERUPT OUT OF THE FILLER OPENING, WHICH WILL SPLASH ONTO AN UNSUSPECTING PERSON DOING THE REFILLING, ONTO HIS SHOES, AND RUN DOWN THE OUTSIDE OF VEHICLE, CREATING AN UNNECESSARY HEALTH AND SAFETY HAZARD. VIDEO DOCUMENTATION CAN BE EASILY FOUND WITH A QUICK SEARCH ON YOUTUBE. *TR

Mileage: 40,915

I OWN A 2006 JEEP TJ RUBICON & AM HAVING A REFUELING ISSUE AT THE GAS PUMP. AT FIRST IT OVERFLOWED MAYBE TWICE. NOW I CAN'T REFUEL WITHOUT THE SHUT -OFF (ON THE GAS PUMP) SHUTTING OFF. THE ONLY WAY I CAN REFUEL IS BY HOLDING THE PUMP LEVER GENTLY WHICH DOES RESULTS IN AN OVER FLOW. I TALKED TO CHRYSLER CUSTOMER SERVICE & THEY SAID THIS IS THE FIRST TIME THEY HAVE HEARD OF THIS PROBLEM & MADE AN APPOINTMENT FOR ME FOR DIAGNOSTICS A MY LOCAL DEALERSHIP WHICH WILL COST ME $120.00 FOR A PROBLEM THAT OTHER TJ OWNERS ARE TALKING ABOUT ON THE INTERNET. THIS HAS BEEN A REFUELING PROBLEM FOR THE LAST 6 MONTHS. *TR

Mileage: 70,000

WHEN FUELING MY JEEP WRANGLER AND ALL GAS STATIONS, THE GAS TANK OVERFLOWS WHEN BEFORE THE FUEL CUTOFF SWITCH ON THE GAS PUMPS KICKS OFF. EVERY SINGLE TIME THIS HAPPENS. THERE IS A PROBLEM WITH THE FILLER HOSE SOMEHOW FROM THE FACTORY. NOT ONLY DOES IT LEAK OUT THE TOP OF SPOUT BUT IT SPRAYS EVERYWHERE, ON CLOTHES AND ANYTHING NEARBY WITHIN 3 FEET. PROBABLY HALF A CUP OF GAS GIVE OR TAKE AT EVERY FUEL STOP IN MY ESTIMATION. *TR

Mileage: 43,000

WHILE PUMPING GAS AT MULTIPLE DIFFERENT GAS STATIONS, THE PUMP FAILED TO SHUT OFF WHEN THE FUEL TANK BECAME FUEL. AS A RESULT OF THE PUMP NOT SHUTTING OFF, FUEL SPILLED OUT OF THE TANK AS IT BECAME OVERFILLED. I DID NOT LEAVE THE PUMP NOR DID I SET THE LOCK ON THE PUMP SO I WOULD NOT HAVE TO HOLD THE PUMP HANDLE DURING ANY OF THE TIMES I HAVE PUMPED GAS INTO THE VEHICLE TO AVOID SPILLING FUEL THE BEST I CAN. THIS HAPPENS AT MANY DIFFERENT STATIONS THAT I FILL MY FUEL TANK UP AT, THE ONLY COMMON DENOMINATOR IN MY SITUATION IS THE VEHICLE ITSELF. THE VEHICLE HAS NOT BEEN MODIFIED IN ANY WAY THAT WOULD INTERFERE WITH NORMAL FUEL PUMPING PROCEDURE. *TR

I BOUGHT THIS VEHICLE USED AND THE FIRST TIME I WENT TO FILL UP WITH GAS, I PUT THE NOZZLE IN THE FILLER OPENING AND SQUEEZED THE HANDLE ALL THE WAY. I LOCKED THE HANDLE SO THE GASOLINE WOULD CONTINUE TO FLOW AND LET GO OF THE NOZZLE. AROUND THE 16 GALLON MARK, GASOLINE SHOT OUT OF THE FILLER OPENING AND THEN POURED DOWN THE SIDE OF THE JEEP. ENOUGH CAME OUT THAT IT CREATED A SMALL PUDDLE ON THE GROUND. GASOLINE GOT ALL OVER THE SIDE OF THE JEEP AND THE FENDER. IT ALSO SPRAYED MY HAND AS I WAS STANDING NEAR IT. I HAD TO WIPE DOWN THE FENDER AND SIDE OF JEEP BECAUSE I DIDN'T WANT TO CAUSE ANY DAMAGE TO PAINT OR PLASTIC. I FOUND THIS SAME PROBLEM EACH AND EVERY TIME I'VE FILLED THE TANK SINCE THAT TIME. I'VE TRIED DIFFERENT GAS STATIONS AND NOZZLES BUT IT DOESN'T SEEM TO MATTER. THIS IS COMPLETELY UNACCEPTABLE IN MY OPINION AND FORCES ME TO BARELY TRICKLE THE GAS INTO THE TANK BY ONLY SQUEEZING THE HANDLE PART WAY. IF I DON'T DO THIS, I SPILL GAS ONTO THE GROUND AND THE SIDE OF MY JEEP WITH EACH FILL. AFTER RESEARCHING THIS PROBLEM, I'VE FOUND IT IS VERY COMMON IN MY MODEL YEAR AND THE YEARS SURROUNDING. WHY WON'T CHRYSLER JUST FIX THIS?! *TR

Mileage: 19,800

WHEN FILLING UP THE GAS TANK, FUEL SLOSHES OUT OF THE FILLER SPOUT JUST BEFORE THE PUMP CLICKS OFF. THE BACK-SPLASH VOLUME IS LARGE ENOUGH TO SPLASH ONTO CLOTHES, RUN DOWN THE SIDE OF THE VEHICLE, AND LEAVE A SMALL PUDDLE OF GASOLINE ON THE PAVEMENT. *TR

Mileage: 29,657

WHEN FILLING UP GAS TANK, FUEL SPILLS FROM THE FILLING PORT ALL OVER ONCE IT IS FULL. THIS HAPPENS EVERY TIME I FILL UP AND HAS DONE SINCE I PURCHASED THE CAR IN FEBRUARY 2011. *TR

Mileage: 46,000

EVERY TIME I FILL UP WITH FUEL, THE FUEL OVERFLOWS OUT OF THE VEHICLE AND DUMPS GASOLINE ONTO ME AND THE GROUND. THIS HAS A LONG TERM HEALTH EFFECT ON PERSONS FILLING THE VEHICLE. IT HAS AN IMMEDIATE EFFECT ON THE ENVIRONMENT, AND I WILL BE NOTIFYING THE EPA OF THIS ISSUE AS WELL. I SEE FROM VARIOUS JEEP WEBSITES THAT THIS IS A LONG STANDING ISSUE THAT HAS NOT BEEN ADDRESSED. *TR

Mileage: 76,250

EVERY TIME I REFUEL MY 2006 JEEP THE GAS SPRAYS OUT OF THE FILLER TUBE UNTIL I REMOVE THE GAS PUMP MANUALLY. THIS IS A KNOWN JEEP ISSUE THAT REQUIRES A REPLACEMENT GAS TANK. OUR ENVIRONMENT AND MY BODY/CLOTHES SHOULD NOT GET COVERED IN GASOLINE EVERY TIME I REFUEL! PLEASE MAKE CHRYSLER FIX ALL JEEP MODELS WITH THIS ISSUE. *TR

Mileage: 92,543

REGARDLESS OF HOW FUEL NOZZLE IS PLACED, FUEL TANK OVER FILLS APPROX 1/8TH-1/3TH GALLON OF FUEL. I FEAR THIS COULD CAUSE A FIRE IN THE EVENT FUEL SPLASHED ONTO BRAKE ROTOR OR OTHER HOT COMPONENTS, NOT TO MENTION THE ENVIRONMENTAL AND FINANCIAL IMPACT OF THIS ISSUE DIRECTLY RELATED TO POOR DESIGN. *TR

Mileage: 49,000

TL* THE CONTACT OWNS A 2006 JEEP WRANGLER. WHILE REFUELING THE VEHICLE, THE CONTACT NOTICED THAT FUEL BEGAN TO SPILL OUT OF THE FILLER NECK. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

Mileage: 40,000

I WAS FILLING UP MY 06 JEEP WRANGLER AND I GOT SPRAYED WITH FUEL ON MY BODY, JEEP AND GROUND. THE PROBLEM HAS HAPPENED EVERY TIME I TRY TO FILL MY TANK UP TO FULL. IM CONCERNED THAT STATIC ELECTRICITY MIGHT IGNITE THIS, MYSELF OR ANOTHER HUMAN BEING. JEEP/ CHRYSLER REFUSES TO FIX THIS ON MY JEEP. THE SAME EXACT SAME THING WAS HAPPENING TO MY WIFE'S 07 CHRYSLER ASPEN AND IT WAS RECALLED AND FIXED. WE BOUGHT BOTH VEHICLES NEW AND THEY HAVE NEVER BEEN WRECKED. JEEP/ CHRYSLER ARE RISKING PEOPLES LIVES WITH THIS ISSUE. *TR

Mileage: 23,000

EVERY JEEP OWNER I HAVE TALKED TO HAS A FILLING SPLASH-BACK PROBLEM WHEN FILLING THEIR GAS TANK. WHY HASN'T THERE BEEN A RECALL ON ALL THE JEEPS AND OTHER MODELS WITH THIS SAME PROBLEM.. GET GOING ON THIS IT IS NOT AN ISOLATED PROBLEM. ALL JEEPS,,,,, CAN YOU READ ? ALL ARE HAVING THIS PROBLEM... BIG SAFETY AND HEALTH ISSUE. NOT ONE PLACE BUT HERE DID I FIND TO LIST THE PROBLEM AS A SAFETY ISSUE. TOO MANY SITTING ON THEIR BACKSIDES AND DOING NOTHING ON THIS SAFETY ISSUE. READ BETWEEN THE LINES AND GET GOING. A VERY DISGRUNTLED TAX PAYER AND OWNER OF A FAULTY PRODUCT THAT IS UN-SAFE AND UN-HEALTHY WITH NOTHING BEING DONE ABOUT IT. GET MY DRIFT?..... *TR

Mileage: 11,000

EVERY TIME I FILL UP MY WRANGLER, IT BURPS OUT FUEL. THIS HAPPENS REGARDLESS OF THE SPEED OF FLOW THE GAS( I HAVE HAD THIS ISSUE WHEN SLOWLY FILLING UP AS WELL AS WHEN THE PUMP IS ENGAGED AND "LOCKED" ON TOO. IT IS RIDICULOUS THAT FUEL SPILLS EVERY TIME I HAVE TO GET SOME. *TR

Mileage: 33,000

EVERY TIME I FILL UP THE TANK, FUEL IS EJECTED FROM THE FILLER HOSE AND GOES ALL OVER THE SIDE OF THE JEEP AND THE GROUND AND USUALLY MYSELF. THE AUTO-SHUT OFF WORKS ON THE PUMPS BUT FUEL STILL COMES OUT. I'VE TRIED USING "HALF THROTTLE" ON THE PUMP BUT STILL HAVE THE SAME PROBLEM. I'VE LOOKED THROUGH MANY JEEP FORUMS AND IT APPEARS THERE IS A FAIRLY LARGE RANGE OF WRANGLERS THROUGHOUT DIFFERENT MODEL YEARS THAT HAVE THIS ISSUE. HOW HAS THIS NOT BEEN A RECALL? THIS CAN'T BE SAFE TO HAVE FUEL SHOOTING OUT EVERY TIME YOU FILL UP. *TR

GAS SPILL OUT WHEN FUELING TO NOW WILL NOT TAKE GAS AT ALL WITHOUT MAJOR SPILLAGE. *TR

Mileage: 20,075

WHEN REFUELING THE VEHICLE, THE GAS TANK OVERFLOWS AND SPILLS A LOT OF GAS. INITIALLY THOUGHT IT WAS THE PUMP, HOWEVER, IT HAPPENS AT EVERY GAS STATION. THIS SEEMS TO BE A SIGNIFICANT SAFETY HAZARD AND SOMEONE COULD GET HURT. *TT

Mileage: 44,000

MORE THAN HALF OF THE TIMES I FILL THE FUEL TANK, THE FILLER NOZZLE DOES NOT SHUT OFF, SPRAYING FUEL OUTSIDE THE VEHICLE. *TT

Mileage: 1,000

WHEN I FILL UP FUEL TANK, AS I GET CLOSE TO FULL, GAS SPITS OUT OF TANK, ALSO HAPPENS IF I RELAEASE FUEL PUMP HANDLE. HAVE HAD TANK REPLACED. WORK OK FOR ABOUT A YEAR, NOW IT SPITS GAS AGAIN. *TT

Mileage: 1,001

SINCE NEW EVERY GAS FILL BURBS GAS BACK OUT OF THE FILLER HOSE ON TO REAR FENDER AND GROUND.

Mileage: 1,006

WHEN FUELING VEHICLE, AT ABOUT 7/8 FULL POINT, GAS SPRAYED OUT OF FUEL NECK ONTO ME. THEN CUT OFF ON THE PUMP NEVER ENGAGED. HAS HAPPENED NUMEROUS TIMES. *JS

Mileage: 67,588

DURING REFUELING GASOLINE SPITS BACK OUT OF THE FUEL FILLER TUBE NECK AT THE END OF THE FILL ONTO THE GROUND AND THE PERSON REFUELING THE JEEP IF HOLDING THE NOZZLE. THE PERSONAL INFORMATION SECTION OF THIS FORM WILL NOT ACCEPT AS VALID MY PHONE NUMBER IN GERMANY [XXX]. THE NUMBER I PLACED IN THE PHONE FIELDS IS NOT VALID. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Mileage: 48,000