2023 JEEP WRANGLER Fuel/propulsion System Problems

"Vehicle is subject to Recall 68C (Fire Risk). Manufacturer states remedy is 'Not Yet Available.' I am instructed not to charge the battery and to park away from structures. I cannot safely park the vehicle at my home or use the electric propulsion I am paying for. The vehicle presents an immediate fire hazard while parked."

What component or system failed or malfunctioned, and is it available for inspection upon request? My 2023 Jeep Wrangler Rubicon 4xe (VIN [XXX] ) has experienced repeated failures in the high-voltage hybrid electrical system, including “Service Hybrid System” warnings, failure to hold charge, and loss of EV function. It has also experienced a dangerous front steering damper failure at highway speed. All components remain available for inspection upon request, and the vehicle is still in my possession. How was your safety or the safety of others put at risk? The hybrid system failures have caused repeated drivability issues, unpredictable power delivery, and warnings advising me not to operate or charge the vehicle due to potential battery-related safety risks. More critically, the steering damper failed abruptly at approximately 75 mph, causing severe front-end instability, vibration, and momentary difficulty maintaining directional control. This failure created an immediate risk of a loss-of-control crash on the highway. Being instructed not to charge the vehicle for months due to safety recalls also indicates a high-voltage battery safety risk that could endanger me, my passengers, and others. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes. Multiple dealerships have documented hybrid-system faults, charging restrictions, and recall-related battery concerns. The “Service Hybrid System” fault has been observed and documented by authorized Jeep/Chrysler service centers. The steering damper failure was documented during service shortly after the highway incident, and the dealer confirmed the part had failed unexpectedly despite passing inspection less than 1,000 miles earlier. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives, or others? The defects have been repeatedly inspected and documented by Jeep/Stellantis dealerships. Stellantis has been notified directly INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

Last week the cat went in for the open recalls. However the electrical and propulsion problems are still going on so I think it’s more than software. The car jerks and come close to stalling almost like a standard transmission with the clutch not catching properly. Additionally, and this is separate and does not occur with the problem described above. The dashboard lights randomly go off. It has no correlation to anything just randomly shut off then come back on.

I just left my house and i was getting on the highway and the service 4 wheel drive light came on then all a sudden the car slowed down then it accelerated really fast so i pulled over and put it in park then when i tried to continue driving i put it in drive and it would not move. The engine ran but it would not move so i had to get it towed to the dealership

My leased 2023 Jeep Wrangler 4xe is included in Recall #68C (NHTSA #25V741000) for a battery fire risk when parked. Jeep and NHTSA have both advised owners not to charge or park the vehicle near structures due to a potential fire hazard. This makes the vehicle unsafe and unusable under normal lease conditions. I contacted my leasing company, Chrysler Capital, to request assistance because the vehicle cannot be safely used or parked. Their representatives repeatedly refused to escalate or document my case and stated that they “can’t do anything,” including refusing to provide a supervisor’s ID or written confirmation. I feel unsafe keeping or driving the vehicle, and I believe I should not be charged lease fees or penalties while it is under this recall. I am requesting that this issue be investigated and that Jeep and Chrysler Capital provide appropriate lease termination or safety accommodations.

Recall for electric battery packs in the electric Wrangler Manufacture requires that we don't park the vehicle in our garage and we don't charge or use the electric battery This pretty much makes my vehicle unusable as I drive the electric motor and my only free parking space is inside my garage

On October 25th, 2025 my husband and I were driving home on the freeway. All of a sudden, without any warning notice or check engine light, my hybrid 2023 Jeep caught on fire as we were in it driving down the freeway. The fire started under the hood and under us. Flames were coming up the sides of the Jeep as we drove and were getting bigger then coming in the vents and under the hood. My husband pulled the Jeep over to the shoulder and we quickly got out and away from the Jeep and called 911 for help. Cars were still driving down the freeway as the Jeep was engulfed in flames. Our safety was put at high risk since we were driving on the freeway at highway speeds and the Jeep caught on fire without any warning and my husband and I were sitting inside the Jeep traveling while it was actively on fire and getting worse. We were located right by the fire as we were driving. It was under us, in front of us and growing around us. Others were put at risk because there was a large fire on the side of the freeway as other vehicles were driving by. A semi truck almost hit the median in the freeway when it probably noticed what was going on. Further, vehicles were driving in the right hand lane right beside the active fire. My Jeep was sparking, throwing flames and some things exploded. Jeep hybrids have had problems and my Jeep has had many recalls and problems. Stellantis was involved with the last few dealership service visits. The Jeep was not charging so a new charging system was put in it at the dealership. The Jeep had a red turtle come on as I was driving and it drastically slowed my speed down suddenly. I pulled over and then my Jeep turned off and would not start again for hours. The dealership, with Stellantis involved, put in a new rechargeable battery. These were some of the things done recently prior to my Jeep catching on fire en route in addition to many recalls/updates. There were no warning signs at all prior to his Jeep fire.

I have a hybrid jeep 4xe, 2023. Allegedly unaffected by the software issue over the weekend that caused countless issues for 2024 and 2025 jeeps. My 2023 jeep wrangler 4xe stopped suddenly while driving. Unfortunately, I panicked in the moment, so I do not remember if it completely powered off or if it just lost propulsion, but it stopped. I had to turn the car off and then back on to get it to go the next day. My check engine light came on for about 24 hours and went off again.

The vehicle has been under recall since September 2024. They have been unable to repair it. I requested a refund or replacement since it has been nearly a year now without repair. The company offered me $9,000 and $9,000 to the lawyer I had contact them. This is not acceptable since they cannot repair the vehicle they need to refund my money or give me a new car.

There is a problem with my electrical system. I have brought it in to jeep several times, and they have brushed it off. In July 2024 I was driving and the car shut off in the middle of traffic. I was able to come to a stop in a turning lane, but it was a dangerous, scary situation. When I took it to the dealership, they said they could not replicate it and sent me on my way. In March 2024 I was stranded at night at a dog park when my car wouldn't start. There was a message stating that the electrical system needed to be serviced. I had it towed to the dealership and they said it was just the engine battery and an issue with a sensor that was put in upside down. In October 2024 I received a notice not to charge my battery or park it in or near buildings. There was no fix. Then, they had software update that was supposed to fix internal problems with the batteries. I asked for a new battery without the issues, and they said no. The scariest, and biggest problem I'm having, though, is that intermittently I lose power when trying to accelerate into traffic. This has led to many scary incidents of other drivers nearly hitting me and being very upset. The most recent incident was on Wednesday, February 12. I was driving on highway 12 in the morning on my way to work and a car pulled in front of me. To avoid a collision, I swerved to the left lane and tried to accelerate to get out of the way of the car behind me and my car would not accelerate. I had to take my foot off the gas, then push again to get it to go. It was terrifying and dangerous. The car behind me nearly hit me, and they honked and were very upset. This situation happens probably once or twice a month. I had my car in the shop to address these issues and I had a rental car and Jeep said they would work with the dealer to repair. They never did. Never called me back, and now they are refusing my rental reimbursement. I don't have anymore money to pay for another so I'm stuck

2023 vehicle no problems until 95B safety recall was performed. Warning light low air next day. Two wks after recall serv. and less than 4-6 months after reg. Maint. & oil change the check engine light came on upon start. Checked and the black coolant reservoir the caps dip stick was void of fluid I was told. Called dealer to advise. Visited dealership the head mechanic dx that the gas cap seal is bad.the check engine light off and not the low to empty coolant. Complaint is the warning light panel. The electrical wires exposed hanging broken small panel on the passengers side of the rearview mirror. Noticed after pickup from dealership. This was addressed with service depart. These panel, coolant, panel broke handing wires, gas cap seal are all issues after recall services. I believe it is unlikely just electrical issues that occurred when it was recently in for the battery recall requiring overnight parking. It was left overnight as they needed to know if it would catch fire. I was not informed if it was necessary as I’ve read to test drive it on electric before it was returned to me. The advisor was in days off happened to be in and was pleasant but I felt rushed. I was given the paper to sign and just told all is well, period. Broken panel part with electrical wires hanging out of rearview mirror. Gas cap seal that is now faulty setting of warning check engine light but not the LOW coolant? No explanation for damaged panel part and reason for messing with the wires. Concerns are engine, electrical and panel failure. Engine should not have issue with coolant. It never should’ve gotten to that point. The fact that there was low to no coolant as the dip stick didn’t register any. It’s a solid black reservoir not able to visibly check for coolant.I find it’s a safety issue, a mechanical issue. The head mechanic is saying that we would’ve never known about coolant needed had it not been for the only 2 yr old gas cap that leaves engine warning light on.

Sorry for my bad English, I am from Quebec, in Canada. On [XXX], our jeep wrangler 2023 burned. The 95B recall was process on December 19th 2024. The battery burned, no flames were visible, only chemical fire. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

What component or system failed or malfunctioned, and is it available for inspection upon request? Jeep 4xe: after coming to a complete stop or just slowing down and entering a lower gear, has a 1-2 second delay in the accelerator. Has caused tires to squeal when accelerator started to respond. Have almost caused accidents when becoming unresponsive as the vehicle will move forward but lose accelerator power. This happens infrequently and spontaneously which makes it impossible to plan for/ drive defensively against, cannot replicate or force it to happen. Vehicle can be inspected upon request. How was your safety or the safety of others put at risk? Vehicle will move forward after stopping, such as an intersection, and suddenly does not increase for 1-2 seconds making me a hazard to traffic. This happens maybe 1-3x a week and is impossible to replicate. Have been almost rear ended many times as no brake lights appear when this happens. Have almost been t-boned by oncoming traffic because of the delay. Has the problem been reproduced or confirmed by a dealer or independent service center? No. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Vehicle has had engine repaired and inspected by dealership. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.

My vehicle is waiting for a fix for Recall 24V720000 / 95B – It is totally unacceptable that Jeep has no time frame for a solution for this horrific safety issue however my vehicle is having another even more dangerous issue that Jeep refuses to acknowledge and I know I am not the only one with this serious defect. My vehicle (2023 4Xe with 5000 miles) losses acceleration power… This has happened at least 10x over the past 5 months. The check engine light often flashes on and off or stays on steady during this. When engaging the gas pedal at various speeds (30-65MPH) the gas fails to respond or output any power causing the vehicle to slowdown dramatically. SIGNIFICANT risk of being crashed into. It takes flooring the gas pedal and anywhere from it 10-25 seconds for the power to kick back in / engage and accelerate. I have been trying to get this fixed since August. One Jeep dealership (had my vehicle for 36 days) replicated the issue but got ‘no code’ therefore they could not fix. Since the 24V720000 / 95B was announced 2 months ago no Jeep dealership (I have contacted over 18) will even attempt to investigate or fix this issue as they claim its related to the battery recall 24V720000 / 95B. I urge you to investigate this loss of power before something catastrophic occurs.

Second time we have had an issue with the battery. Unable to plug it is because of an unresolved battery recall, this time for over a month. We purchased the vehicle specifically for the battery and now we have to buy fuel.

Recall 95B. I have been given the runaround for months on the status of this recall from the FCA recall center and Jeep. I purchased a hybrid Jeep 4xE with the main purpose of being able to run both electric and gas. However, jeep is telling me not to charge the vehicle, do not park it in the garage, and to make sure that it’s not parked near any structures because of explosion/fire hazard! This is completely unacceptable to not have a resolution for such a major concern in a timely manner.

The safety of this vehicle is a ticking time bomb. We are instructed not to park in or near a structure, near other vehicles, or charge it. Even if I don’t not charge it how am I supposed to park at my own home? How am I supposed to park at work? You are putting several lives at risk not to mention others vehicles, houses, businesses. I do search and rescue and have my k9 with me pretty much at all times. I am told it can ignite at anytime but it’s ok to leave my dog in? Where is the safety and concern over my highly trained k9 let alone family pet. I will never feel safe with this car again. I asked if they even replaced the battery if they could tell me it wouldn’t happen with the new battery and I could park back in my garage and they said no they couldn’t say it wouldn’t happen again.

Loss of power pulling into traffic 6/6/24, nearly causing an accident, hybrid battery stopped working. CEL and service charging system light. Called dealer and not able to get service appointment until 6/26/24. Used vehicle unsafely until 6/26 without battery. Dropped off at dealer 6/26 and just received the vehicle with repair today, 7/24/24 28 days later.

jeep just shut down while heading down interstate 81 about 70 mph in far 3fd left lane not much time to exit the highway had to sit on the left side of the highway and put in Park and restart it did start up after the complete shutdown

The 2023 jeep wrangler 4ex shutdown on highway at speed 75 mile/h!!!!! And cannot restart, gear only in P position. Only towing

While driving on highway/freeway at approx 70 mph 2023 Jeep wrangler 4xe suddenly lost power/engine shut down. I coasted safely and pulled over from the fast lane to the right lane of the freeway to the shoulder. Vehicle was able to be restarted and able to be driven. Now at the dealership.

This is the second time this jeep stalls out on us. This most recent time we were traveling on the freeway going about 70mph when all the sudden the jeep’s motor shuts off and is unresponsive. We are literally coasting in the middle of nowhere hoping the vehicle has enough momentum to get out of the way. Something was blinking on the dash but i couldnt pay attention to that as I was trying to pull over safely. Jeep did not start back up until 2 hours of of waiting on freeway. There are a ton of recalls for this vehicle and as it sits right now the plug in for EV port is not working at all. It makes a ton a strange noises. And to top it off this is a rental car that shouldnt be on the streets earning revenue. This jeep needs to be appropriately recalled before someone gets injured.

My gas gauge read 37 miles till empty and then died in the middle of a main rd. Had to get it towed $320 for the tow and $200 diagnostic fee. Just to find out that the gas gauge is incorrect and not to trust it.

Lost total power in the fast lane on the freeway! Lots of flashing indicators: "Service Charging System", "Brake and Push Button to Start", Transmission Gear "D" flashing with the gear it was in "D and little 8", telling me to put it in Park while I was driving on the freeway trying to get over to the side...how is that even possible?, further it was coming to a stop quickly like a heavy regenerative braking was one making it even more dangerous as we would about to come to a total stop on the freeway! (I read someone in a Tesla died this way). This was dangerous for us and the cars around us. I have read they have a recall for this very issues in Dec 2022, but MY CAR IS NOT INCLUDED in the recall so there is a much bigger issue going on! All my recalls are up to date per the dealership. So need NHTSA to step in/up! I attached pictures of what was on the dash after we got over the side of the freeway (was not able to record while it occur for safety reasons, of course).

Brand new 2023 wrangler with 600 miles on it that I’ve had for 4 days and the engine completely cut off on the busy highway with my whole family in the car. Message appeared on the screen stating “performance limited, service charging system”. We were eventually able to get the engine on again by turning the car off and on which was incredibly dangerous in the middle of a very busy highway. We are very very lucky that this did not all result in a serious accident

Car just died while driving about 30mph in all electric mode. Charge fault error came on. Loss of steering and brakes. Able to coast to stop. Placed car in e save mode to start engine, was able to get home.

Driving on the freeway my JEEP stalled. It was flashing red tk plug it in. I was driving hybrid on a full tank of gas. A truck almost hit me in this process.

I received a recall notice on my Jeep Wrangler Sahara 4xe that the vehicle could suddenly shut down while in motion and needed a repair to prevent this from happening. I took it into the dealer to get the repair. At this point the vehicle had about 1200 miles on it. About a week AFTER getting the recall repair, the vehicle shut down without warning while I was driving it in all electric mode. I had to pull off the road, coast to a stop, and restart. I took it back to the dealer and they said that they had never heard of this happening AFTER getting the recall fixed. They said they didn’t know what to do to address it and would be reporting it to Jeep/Stellantis HQ in Detroit. The dealer is Jeff D’Ambrosio in Downingtown, PA. They said they would be back in touch once they heard from Detroit. This is extremely concerning and should be investigated.

This vehicle was sold unlawfully to me, with an open recall on it. I purchased the brand-new vehicle from Sterling Heights Dodge, Chrysler Jeep New car dealership on 3/23/23. I got at open of business 9am left shortly after 11am with the new car.3/24 The vehicle engine lights came on, RPM's were revved high, engine was making loud noises. I called the dealership to make an appointment with service, I was told I can't bring my car there for service it had to go to Toledo Service Dept Grogan the closest to me. I was told to drive it as is it would be fine. On 3/26 my vehiicle abruptly stopped in heavy traffic with my 5 year old grandson in the backseat. Nothing worked, all power was dead. I have videos of this. I had to get out and motion for traffic to go around us, several time we were almost hit. The car was towed to Grogan they got it in for service 3/28. It was discovered by the service manager on 3/23 when I purchased my new car that New car had an open recall on it launched 3/14/23, and the dealership entered 3/23/23 as the repair date to bypass the system because you can't sell a brand new car with an open recall. The car is dangerous, it has been sitting in service since 3/28 until present date totally disabled without ability to be fixed by Grogan experts. The car was unlawfully sold, it was not disclosed there was a open recall or I would have opted to buy a different car. The car is a lemon they will not take the car back although it was sold unlawfully New Cars are forbidden to be sold with open recalls, and open recalls are to be disclosed prior to selling consumers cars. It is going to cause a very serious accident with injuries and potentially even fatality.