Problem Breakdown
Compare to Other Years
CAM CHAIN ADJUSTER OTHERWISE KNOW AS A DOOHICKEY. IF IT FAILS IT MAY CAUSE THE ENGINE TO SEIZE UP WITHOUT WARNING, I CHANGE MINE AFTER IT BROKE BUT DID NOT CAUSE MASSIVE INTERNAL DAMAGE I WAS UNAWARE THAT MINE HAD FAILED I DID THE CHANGE AS PREVENTATIVE MAINTENANCE THIS PROBLEM HAS BEEN KNOWN TO T...
CAM CHAIN ADJUSTER OTHERWISE KNOW AS A DOOHICKEY. IF IT FAILS IT MAY CAUSE THE ENGINE TO SEIZE UP WITHOUT WARNING, I CHANGE MINE AFTER IT BROKE BUT DID NOT CAUSE MASSIVE INTERNAL DAMAGE I WAS UNAWARE THAT MINE HAD FAILED I DID THE CHANGE AS PREVENTATIVE MAINTENANCE THIS PROBLEM HAS BEEN KNOWN TO T...
THE IDLER SHAFT LEVER (AKA "DOOHICKEY") BROKE IN HALF AND THE PIECES OF IT WERE FLOATING AROUND IN THE CRANK CASED. THIS IS VERY DANGEROUS BECAUSE IF A PIECE OF THE IDLER SHAFT LEVER GETS CAUGHT IN THE COUNTERBALANCE CHAIN OR CAUSES A CRANK BEARING FAILURE THE ENGINE COULD LOCK UP AT SPEED CAUSING ...
THE IDLER SHAFT LEVER (AKA "DOOHICKEY") BROKE IN HALF AND THE PIECES OF IT WERE FLOATING AROUND IN THE CRANK CASED. THIS IS VERY DANGEROUS BECAUSE IF A PIECE OF THE IDLER SHAFT LEVER GETS CAUGHT IN THE COUNTERBALANCE CHAIN OR CAUSES A CRANK BEARING FAILURE THE ENGINE COULD LOCK UP AT SPEED CAUSING ...
THE IDLE SHAFT LEVER IN MY 2001 KAWASAKI KLR650 HAD COMPLETELY BROKEN INTO 2 PIECES. I DISCOVERED THIS WHEN UPGRADING THE PART. IT COULD HAVE CAUSED CATASTROPHIC ENGINE FAILURE. *TR
THE IDLE SHAFT LEVER IN MY 2001 KAWASAKI KLR650 HAD COMPLETELY BROKEN INTO 2 PIECES. I DISCOVERED THIS WHEN UPGRADING THE PART. IT COULD HAVE CAUSED CATASTROPHIC ENGINE FAILURE. *TR
AFTER 14,000 MILES OF USE I AM THE SECOND OWNER OF THE MOTORCYCLE THE IDLE SHAFT LEVER FAILED. WITH THE FREQUENCY OF THIS FAILURE BEING REPORTED, THERE SHOULD BE A TSB ISSUED. *TR
AFTER 14,000 MILES OF USE I AM THE SECOND OWNER OF THE MOTORCYCLE THE IDLE SHAFT LEVER FAILED. WITH THE FREQUENCY OF THIS FAILURE BEING REPORTED, THERE SHOULD BE A TSB ISSUED. *TR
WHEN I TORE INTO MY 2001 KLR 650 TO INSPECT AND REPLACE THE FAULTY "DOOHICKEY". I FOUND THE FACTORY ONE BROKE. BOTH THE SPRING AND BALANCER WERE BROKE AND I DID NOT FIND EITHER PART IN THE MOTOR. THEY ARE STILL FLOATING AROUND IN THE MOTOR SOMEWHERE. THERE WAS SCARING ON THE PARTS INSIDE THE MOTOR W...
WHEN I TORE INTO MY 2001 KLR 650 TO INSPECT AND REPLACE THE FAULTY "DOOHICKEY". I FOUND THE FACTORY ONE BROKE. BOTH THE SPRING AND BALANCER WERE BROKE AND I DID NOT FIND EITHER PART IN THE MOTOR. THEY ARE STILL FLOATING AROUND IN THE MOTOR SOMEWHERE. THERE WAS SCARING ON THE PARTS INSIDE THE MOTOR W...
DOOHICKEY AND SPRING ON THE COUNTER BALANCER OF THE ENGINE WITH 14000 MILES WAS BROKEN DURING MOTORCYCLE USAGE. THIS IS A SUGGEST REPLACEMENT PART THAT IS RECOGNIZED BY OWNERS OF KAWASAKI KLR 650 , SO WHEN I TOOK MIND APART TO REPLACE IT, IT WAS BROKEN AND THE SPRING WAS ALSO MISSING INTO THE ENGI...
DOOHICKEY AND SPRING ON THE COUNTER BALANCER OF THE ENGINE WITH 14000 MILES WAS BROKEN DURING MOTORCYCLE USAGE. THIS IS A SUGGEST REPLACEMENT PART THAT IS RECOGNIZED BY OWNERS OF KAWASAKI KLR 650 , SO WHEN I TOOK MIND APART TO REPLACE IT, IT WAS BROKEN AND THE SPRING WAS ALSO MISSING INTO THE ENGI...
VEHICLE WAS A 2001 KAWASAKI KLR 650 MOTORCYCLE. DISMANTLED ENGINE CASE AND FOUND BALANCER CHAIN TENSIONER BROKEN INTO THREE PIECES. HAD TO RUMMAGE THROUGH THE CRANKCASE TO FIND TWO OF THE PIECES. THE TENSIONER SPRING WAS ALSO BROKEN. PIECE OF SPRING NOT FOUND. *NM
VEHICLE WAS A 2001 KAWASAKI KLR 650 MOTORCYCLE. DISMANTLED ENGINE CASE AND FOUND BALANCER CHAIN TENSIONER BROKEN INTO THREE PIECES. HAD TO RUMMAGE THROUGH THE CRANKCASE TO FIND TWO OF THE PIECES. THE TENSIONER SPRING WAS ALSO BROKEN. PIECE OF SPRING NOT FOUND. *NM
1)POOR PERFORAMANCE SEEMED LIKE CARBURATER PROBLEM. 2)SUDDEN LOUD KNOCK AND ENGINE STALLED AT 40MPH. UPON INTERNAL INSPECTION, BALANCER SHAFT ADJUSTER FAILED (BROKE INTO 4 PIECES) CIRCULATED PIECES THROUGHOUT CRANKCASE AND SNAPPED BALANCER CHAIN. MAY BE ADDITIONAL DAMAGE TO INTERNAL ENGINE PARTS...
1)POOR PERFORAMANCE SEEMED LIKE CARBURATER PROBLEM. 2)SUDDEN LOUD KNOCK AND ENGINE STALLED AT 40MPH. UPON INTERNAL INSPECTION, BALANCER SHAFT ADJUSTER FAILED (BROKE INTO 4 PIECES) CIRCULATED PIECES THROUGHOUT CRANKCASE AND SNAPPED BALANCER CHAIN. MAY BE ADDITIONAL DAMAGE TO INTERNAL ENGINE PARTS...
CHANGED OIL AND DISCOVERED PIECES OF METAL IN CRANKCASE. HAD A BROKEN IDLER SHAFT LEVER THAT SPLIT IN TWO. LUCKILY IT DID NOT GIVE WAY WHILE I WAS RUNNING AND SEIZE THE ENGINE. DESIGN FLAW IN THE IDLER SHAFT LEVER WELD RESULTED IN FAILURE. *NM
CHANGED OIL AND DISCOVERED PIECES OF METAL IN CRANKCASE. HAD A BROKEN IDLER SHAFT LEVER THAT SPLIT IN TWO. LUCKILY IT DID NOT GIVE WAY WHILE I WAS RUNNING AND SEIZE THE ENGINE. DESIGN FLAW IN THE IDLER SHAFT LEVER WELD RESULTED IN FAILURE. *NM
BALANCER SHAFT FAILURE ON A 2001 KAWASAKI KLR 650 MOTORCYCLE. *AK
BALANCER SHAFT FAILURE ON A 2001 KAWASAKI KLR 650 MOTORCYCLE. *AK
IDLER SHAFT LEVER RETAINER CAME APART INSIDE ENGINE, CAUSED SPRING TO FAIL EARLY WHICH ALSO CAME APART INSIDE ENGINE. THIS IS A KNOWN PROBLEM WITH THESE MACHINES SO I DID A CHECK TO SEE AND DISCOVERED THIS. I FOUND ALL THE LITTLE PIECES READY TO BE SUCKED UP INTO THE OIL PUMP WHICH WOULD HAVE CAUSED...
IDLER SHAFT LEVER RETAINER CAME APART INSIDE ENGINE, CAUSED SPRING TO FAIL EARLY WHICH ALSO CAME APART INSIDE ENGINE. THIS IS A KNOWN PROBLEM WITH THESE MACHINES SO I DID A CHECK TO SEE AND DISCOVERED THIS. I FOUND ALL THE LITTLE PIECES READY TO BE SUCKED UP INTO THE OIL PUMP WHICH WOULD HAVE CAUSED...
I HAVE NOTICED RATTLE IN ENGINE ALMOST SINCE NEW. AT 21000 MILES I OPENED UP THE L SIDE ENGINE CASE. THERE WAS A BROKEN ENGINE BALANCER CHAIN ADJUSTER AND MANY CHUNKS OF METAL IN CRANKCASE. I CHECKED THE INTERNET AND APPARENTLY THIS IS VERY COMMON. I BELIEVE THIS FAILURE COULD CAUSE A REAL WHEE...
I HAVE NOTICED RATTLE IN ENGINE ALMOST SINCE NEW. AT 21000 MILES I OPENED UP THE L SIDE ENGINE CASE. THERE WAS A BROKEN ENGINE BALANCER CHAIN ADJUSTER AND MANY CHUNKS OF METAL IN CRANKCASE. I CHECKED THE INTERNET AND APPARENTLY THIS IS VERY COMMON. I BELIEVE THIS FAILURE COULD CAUSE A REAL WHEE...
COUNTER BALANCER ADJUSTER FAILURE. *NLM
COUNTER BALANCER ADJUSTER FAILURE. *NLM
BROKEN BALANCER CHAIN TENSIONER ON A 2001 KAWASAKI KLR650 MOTORCYCLE.
BROKEN BALANCER CHAIN TENSIONER ON A 2001 KAWASAKI KLR650 MOTORCYCLE.
FAILURE OF COUNTERBALANCE ADJUSTER. PART SHATTERED INTO THREE PIECES. ONE PIECE LOST IN CRANKCASE, REQUIRING FURTHER DIASSAMBLY OF ENGINE TO RECOVER
FAILURE OF COUNTERBALANCE ADJUSTER. PART SHATTERED INTO THREE PIECES. ONE PIECE LOST IN CRANKCASE, REQUIRING FURTHER DIASSAMBLY OF ENGINE TO RECOVER
BALANCER IDLER SHAFT, TENSIONER LEVER FAILURE ON A 2001 KAWASAKI KLR 650 MOTORCYCLE, RESULTING IN PIECES OF STEEL ENTERING OIL SUMP, CRANKCASE AND TRANSMISSION OF ENGINE.
BALANCER IDLER SHAFT, TENSIONER LEVER FAILURE ON A 2001 KAWASAKI KLR 650 MOTORCYCLE, RESULTING IN PIECES OF STEEL ENTERING OIL SUMP, CRANKCASE AND TRANSMISSION OF ENGINE.
KAWASAKI KLR650 BALANCER TENSIONER AND CAM SPRING ON MOTORCYCLE LESS THAN ONE YEAR OLD WITH LOW MILEAGE. AFTER READING OF SIMILAR FAILURES IN OTHER MOTORCYCLES SOME OF WHICH REPORTEDLY RESULTED IN INJURY, I DECIDED TO OPEN THE ENGINE HOUSING TO INVESTIGATE. BOTH COMPONENTS HAD SHATTERED RESULTING IN...
KAWASAKI KLR650 BALANCER TENSIONER AND CAM SPRING ON MOTORCYCLE LESS THAN ONE YEAR OLD WITH LOW MILEAGE. AFTER READING OF SIMILAR FAILURES IN OTHER MOTORCYCLES SOME OF WHICH REPORTEDLY RESULTED IN INJURY, I DECIDED TO OPEN THE ENGINE HOUSING TO INVESTIGATE. BOTH COMPONENTS HAD SHATTERED RESULTING IN...
CONSUMER HAD NOTICED THE SWING ARM BOLTS HAD BEEN COMING APART FROM MOTORCYCLE FRAME, WHICH WAS ATTACHED TO SUSPENSION, AND COULD CAUSE DRIVER TO LOSE CONTROL OF MOTORCYCLE. DEALER HAD BEEN CONTACTED. *AK CONSUMER STATED THAT THE PIVOT SHAFT BOLTS WITH COTTER PINS HAVE BEEN REFITTED SO THEY WILL ...
CONSUMER HAD NOTICED THE SWING ARM BOLTS HAD BEEN COMING APART FROM MOTORCYCLE FRAME, WHICH WAS ATTACHED TO SUSPENSION, AND COULD CAUSE DRIVER TO LOSE CONTROL OF MOTORCYCLE. DEALER HAD BEEN CONTACTED. *AK CONSUMER STATED THAT THE PIVOT SHAFT BOLTS WITH COTTER PINS HAVE BEEN REFITTED SO THEY WILL ...
WHILE DRIVING AND WHEN HOLDING CLUTCH IT SUDDENLY ENGAGED, CAUSING UNWANTED AND UNEXPECTED ACCELERATION WHICH COULD HAVE CAUSED A CRASH. ALSO, CLUTCH PLATE MAY HAVE BEEN INSTALLED INCORRECTLY. CONSUMER HAS CONTACTED DEALER, DEALER HAS YET TO DETERMINE CAUSE. *AK THE DEFECT WAS DETERMINED T...
WHILE DRIVING AND WHEN HOLDING CLUTCH IT SUDDENLY ENGAGED, CAUSING UNWANTED AND UNEXPECTED ACCELERATION WHICH COULD HAVE CAUSED A CRASH. ALSO, CLUTCH PLATE MAY HAVE BEEN INSTALLED INCORRECTLY. CONSUMER HAS CONTACTED DEALER, DEALER HAS YET TO DETERMINE CAUSE. *AK THE DEFECT WAS DETERMINED T...
WHILE DRIVING AND WHEN HOLDING CLUTCH IT SUDDENLY ENGAGED, CAUSING UNWANTED AND UNEXPECTED ACCELERATION WHICH COULD HAVE CAUSED A CRASH. ALSO, CLUTCH PLATE MAY HAVE BEEN INSTALLED INCORRECTLY. CONSUMER HAS CONTACTED DEALER, DEALER HAS YET TO DETERMINE CAUSE. *AK THE DEFECT WAS DETERMINED T...
WHILE DRIVING AND WHEN HOLDING CLUTCH IT SUDDENLY ENGAGED, CAUSING UNWANTED AND UNEXPECTED ACCELERATION WHICH COULD HAVE CAUSED A CRASH. ALSO, CLUTCH PLATE MAY HAVE BEEN INSTALLED INCORRECTLY. CONSUMER HAS CONTACTED DEALER, DEALER HAS YET TO DETERMINE CAUSE. *AK THE DEFECT WAS DETERMINED T...