2010 KIA FORTE Engine Problems

Knocking in engine, loss of power, rod bearings needs replacing

I got a car from coparts and they told me nothing was wrong! I recently bought the car

Known engine problem with bottom end knocking sounds. Potential risk of fire or wreck caused by engine failure. Engine condition is an ongoing issue. Dealerships and manufacture refuse to honor recall because last recall hasn't been addressed and the title is rebuilt.

Unknown. Vehicle serviced since 2010. Oil changes based on recommend miles. Only 80,000 miles. Wife [XXX] only uses it mostly for store runs. Since recently inspection and oil change motor has a loud knocking at start up and gets quiet shortly after but while idling you can here a ticking noise. We have all paper work to maintenance. Fear if my wife is stranded or worse and thought I would report this. I will take it in to see what is said. Doesn't seem normal for only 80,000 and well maintained INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Was driving at slow rate of speed <30 MPH, the car started having a really loud knocking sound coming from the engine and then lost all power. Had car towed to local garage and was informed that the rod bearing had been broken and the engine needed to be replaced.

The contact owns a 2010 Kia Forte. The contact stated while driving 30 MPH, there was an abnormal sound coming from the hood of the vehicle. The contact pulled over on the side of the road. There were no warning lights illuminated. The vehicle was driven to the local dealer where it was diagnosed and determined that the rod bearing was damaged and needed to be replaced. The vehicle was not repaired due to the warranty being expired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 110,000.

Mileage: 110,000

On January 20, th 2024 my Connecting (Rod Bearings In cylinder # 1 failed ! My 2010 Kia Forte Started making a loud rattling noise from inside the Engine! I immediately parked my car. On February 13th, Kia Of Carson ca. Excepted my Kia for service check ! They tried to charge me $235.00 (see service check receipt! Then they later retracted the bill ! Today is February 25th and my Vehicle in still at the dealership unrepaired ! My complaint is that the Kia Dealership and cooperation has tried to Mislead me in every aspect of the rules and regulations of a recall , in order to not repair this (significant Vehical Safety issue! They even tried to get me to pick up the vehicle sand drive it away in the condition it's in ! My insurance company said they will not be liable if something happens to me while operating this vehicle while it's under Recall ! Kia is alleging that my vehical is not under (Warrenty any more! (1).If the recall was not a significant issue why would they recall the 2010 Thru 2013 Kia Forte ! It's Clear " that a 14 year old model would not still be under warranty! However...the rules of recall states that if the conditions are found to exist in any vehical subject to recall it Must be repaired!

Engine knocks really bad

kia already has a recall on the 2.0 litre Theta engines due to rod bearing failures due to improper machining of the engine blocks, resulting in metal filings blocking oil passages in the bottom end of the engine resulting in the significant risk of a fire or catastrophic engine failure usually at highway speed which can cause accidents. They also have a recall for possible engine fires and instruct owners to park their vehicles outside, with a significant risk of burning occupants. YouTube mechanics have been complaining of all these Kia engines' early failures such as: Scotty Kilmer Exotic Car Play Place The Car Wizard Calls to Kia Motors USA have resulted in their refusal to replace these 2.0 non-direct injection engines.

179000 miles owner was driving and heard a knocking sound. He is an independent mechanic and put it in the shop to diagnose. While inspecting oil was within normal operating range and not yet due for an oil change. Low end rod knock. Changed oil to inspect for debris and found light flakes of bearing material. Diagnosed as rod knock and needs bearing replaced.

The contact owns a 2010 Kia Forte. The contact stated that while driving or while idling, he heard a loud knocking sound coming from the hood of the vehicle. No warning lights were illuminated. The vehicle was taken to an independent mechanic where it was diagnosed that the rod bearings were faulty. The dealer was not notified of the failure. The vehicle was not repaired. The contact was concerned for his safety while operating the vehicle. The manufacturer was notified of the failure and the contact was informed that the VIN was not included in a recall. The failure mileage was approximately 70,000.

Mileage: 70,000

Car repeatedly has leaks and knocking engine sound, 5 repairs no resolve. Told different solutions paid for repairs. Engine noise still continues. Took in at 149,000. Why isnt there a recall on the engine?

The contact owns a 2010 Kia Forte. The contact stated while driving at approximately 45 MPH, the vehicle stalled. On two other occasions, the vehicle shut off and the driver was able to steer the vehicle off the roadway. There were no warning lights illuminated. The vehicle was taken to an independent mechanic, where it was diagnosed that there was no oil in the engine. The independent mechanic informed the contact to check the oil level while refueling. The vehicle was consuming an excessive amount of engine oil. There was an abnormal rattling sound detected. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 130,000.

Mileage: 130,000

There is an ongoing issue with the MAP sensor that triggers a check engine light as well as the RPMS to fluctuate. This can happen when disconnecting the battery and/or replacing the MAP sensor. I replaced the MAP sensor and still get this ongoing issue. This is a safety concern because due to the RPMs constantly fluctuating, the car jolts forward when driving which could possibly result to the car hitting another vehicle in front of it. But the only way to get it to stop / get the check engine light to turn off, is to drive it for x amount of miles until it fixes itself. This problem has been inspected by Kia themselves and they did not give any information to me about the issue. This issue seems to happen any time I get the vehicle serviced.

I had oil changed on my 2010 Kia forte 2.0 motor and afterwards the oil light came on on the way home from the shop and it died and engine started making a loud noise they have an engine recall on these motors for going bad I need them to replace my engine I can't afford to put new motor in my car when it's not my fault it has a defect in the motor

Engine failure on 2010.kia forte due to faulty oil pump causing car to come to a stop while in trafficc could cause safety problem for everyone on roadway

Premature engine failure in 2010 kia forte ex in April 2020 resulted in a vehicle that was unsafe to drive. The problem was confirmed by a mechanic and later the dealership. No warning messages or lamps were displayed. The problem was identified after I spoke with my mechanic about a ticking noise that I was hearing upon starting my vehicle. The noises first appeared a few weeks before my cars engine was diagnosed as failing.

In March 2023, my 2010 kia forte ex began to make a ticking noise, similar to the noise it had made before its first engine had failed. I had just had my car inspected the week prior and had my oil changed. I took my car back to the mechanic, where they confirmed there was an issue with my "new" engine. The engine was "knocking." I took my kia to the dealership where I had gotten the first engine replaced to see if my warranty still covered the new engine as it was not even 3 years old, but was told it was not under warranty. I took my car to another mechanic to get a second opinion after being quoted over $3000 for a new engine. The mechanic said that there were metal shavings in my oil, which was only a week or two old at that time. He said the issue was likely the rod baring's. I learned kia had several lawsuits going on about premature engine failure in kia fortes, but was told by kia that my car was not going to be part of that lawsuit. No warning messages showed up prior to the failure. The only symptom of the failure that was noticeable to me was the knocking, and would not be as noticable to someone who doesnt know much about cars. Driving my car for the last time, I noticed a burning smell when I turned on the ac. I shut it off and looked for signs of a fire, knowing kias have been catching fire recently. These cars arent safe on the roads and Kia should be held accountable before more people get hurt.

Engine piston knock getting ready to fail and lock up which could cause a crash and loss of control of car.

My Engine died at 114,000 miles. It developed engine knock. I now have to replace the engine. Kia refuses to help with this and is asking for 8,000 to replace the engine.

As I am driving my car losses speed slows to almost stop. I keep my foot on the gas pedal very lightly pressing acceleration to keep it going.

Unknown, 2010 Kia Forte engines have an active and open recall in Canada for a ticking noise that leads to vehicle fires and cause death it is not being addressed here in the United States even though the problems are exactly the same there's a smell of gas burning there are ticking and knocking noises coming from an engine and Kia is refusing to replace it here in the United States but they are actively replacing it in Canada

Very loud knocking noise coming from engine. No check engine light or oil light has come on at all. It's been doing this for over a year now.. Ive taken it to several place and no one can figure it out. The knocking gets so bad it makes my steering wheel shake.

hi, i have a standing issue with my 2010 kia forte sx 2.4l the engine developed this knock that has totally incapacitated the car so it cannot be driven. every mechanic ive been to says that the engine is done and needs to be replaced. ive checked for recalls and i found hundreds of consumers with the same exact problem where these 2.4l engines developed a crippling knock. Has this establishment recieved any complaints and if so what is being done to relieve the consumer who has no where to turn and is stuck with a car they cant use and is being ignored by KIA COORPORATION and every one else. Any suggestions would be greatly appreciated, Thank You

I have 2 Kia Forte I was a 4dr my current is a 2 dr Koup . The engine makes noises the motor actually blew on my way to work with the 4dr then purchased a 2dr it’s doing the same the guy says it’s a cylinder but why do I feel like I’m getting ripped off by Kia bc this is an ongoing issue

Engine and air bag

Engine is knocking very loudly. Concerned it is going to fail while driving it and cause an accident. I have noticed many other people have this issue with this 2.0 engine Kia has.

While the vehicle was operating the engine had a noticeable amount of power reduction and there were multiple knocking sounds occurring simultaneously. The vehicle was being operated in the right-most furthest lane of a busy freeway in the middle of traffic and at freeway speeds of approximately 65 mph. The issue seemed to originate from the engine causing engine malfunction without engine light indication. There was no engine light prior, during, or post-incident. The vehicle has been professionally inspected, but not thoroughly diagnosed. Altogether, the motor has had a major unidentifiable malfunction and now I have no transportation from the once-reliable vehicle I was using.

Randomly the car refused to accelerate, rpms would not go past 3k. It happened it different time points of a drive. There was never any check engine light. Mechanic drove the vehicle and ran a check on it and said with out a warning light there isn’t much I can do. Suggested replace crank shaft sensor. There was no change to the point the entire car died while driving up hill with no shoulder and a very large truck behind. My children would be dead right now if there had been another vehicle in the lane next to me I was able to barely to get the cat into. The car started back up after 30 mins. Was looked at again, informed it could have something to do with the engine tick, still no warning lights. The car stalls, jerks like a misfire and had refused to keep a stable speed while on the interstate

The contact owns a 2010 Kia Forte. The contact stated while driving 10 mph and approaching a stop sign, the vehicle lost motive power. The check engine and battery warning lights were illuminated. The vehicle was restarted without further failure. The vehicle was not diagnosed nor repaired. The manufacturer was not notified of the failure. The failure mileage 111,407.

Mileage: 111,407

VEHICLE HAS BEEN KNOCKING SINCE THE DAY I TOOK THE VEHICLE OVER. WAS TOLD THAT KIA ALWAYS SAID ITS NORMAL BUT ITS CLEAR THAT IT IS A ROD KNOCK AND THAT THADA ENGINES HAD THIS PROBLEM. IM AFRAID IF THE ROD LETS LOOSE IT COULD CAUSE A FIRE.

MY KIA WAS JUS FINE DRIVING DOWN TO MY DAUGHTERS HOUSE WHICH IS AN HOUR N HALF WHERE I LIVE. WHERE ALL OF A SUDDEN ENGINE LIGHT CAME ON AND A KNOCKING SOUND CAME ON SLIGHT NOISE. I KEPT AN EYE ON THE NOISE AND VEHICLE. WHEN WE STOPPED I CHECKED ALL THE LIQUIDS AND EVERYTHING WAS FINE. WE HAD TO TAKE CARE OF SOME THINGS THEN ON OUR WAY HOME IT WAS SOUNDING HORRIBLE AND ALL OF A SUDDEN THE CHECK ENGINE LIGHT WAS ON, OIL LIGHT AND BATTERY LIGHT. SO I PULLED OVER AND CALLED TO HAVE MY CAR TOWED HOME. I DID NOT WANT TO RISK ANYTHING WORSE, BUT HONESTLY I THINK IT IS THE WORSE FOR ABSOLUTELY NO REASON FOR WHEN THERE IS NO LEAKS AND ALL FLUIDS ARE FULL.

Mileage: 145,000

THE CAR HAS LESS THAN 88,000 MILES ON IT. THE CAR STARTED MAKING TICKING NOISE. THE REPAIR SHOP SAID IT IS THE ENGINE AND IT NEEDS REPLACED. THEY ALSO SAID THIS WAS A VERY COMMON ISSUE ON THESE ENGINES. SAID IT WASN'T WORTH THE COST TO REPLACE. I'M SO ANGRY CAUSE THE CAR STILL SHOULD HAVE ALOT OF LIFE LEFT IN IT. THE CAR HAS BEEN TAKEN CARE OF AND THIS IS A FAULTY BECAUSE OF KIA!!

JUST AFTER PURCHASING THE CAR USED WITH 73,349 MILES ON THE ODOMETER ON 7/31/2014 THERE WAS A SLIGHT KNOCK IN THE ENGINE, WHICH SOUNDS LIKE THE PROBLEM THAT LED TO RECALLS ON LATER YEARS MODELS WITH 4 CYLINDER ENGINES, SO I THINK THE PROBLEM STARTED EARLIER. SINCE THERE WAS NO WARRANTY (SOLD AS IS) ON A USED CAR THE DEALER TOLD US REPAIRS WOULD COST MORE THAN JUST REPLACING THE ENGINE, SO I HAD TO PAY $3,000 TO REPLACE THE ENGINE. I COMPLAINED TO BOTH THE DEALER (FAIRFAX KIA) AND THE MANUFACTURER WITH NO RESOLUTION.

Mileage: 78,000

MY CAR WAS BOUGHT BRAND NEW FROM KIA OF CLARKSVILLE. IT HAS ALWAYS HAD A TICK I WAS TOLD IT WAS NORMAL. AT 88,000 MILES MY CAR LOCKED UP. JUST DRIVING UP A SMALL HILL IT STARTED KNOCKING LOUD AND LOST POWER. TOOK IT TO KIA THEY WANT 6000.00 TO REPAIR IT WITH A JUNK YARD MOTOR. HOW DO THEY SELL FAULTY ENGINES AND GET AWAY WITH IT. I TOOK GOOD CARE OF MY CAR AND OIL CHANGES WHEN DUE. I'M SO UPSET THAT AS A CONSUMER WE HAVE NO PROTECTION AGAINST THIS.

Mileage: 88,000

THE ENGINE STARTED MAKING KNOCKING SOUNDS. I'M AFRAID IT MIGHT CATCH FIRE.

Mileage: 170,000

TOOK CARE OF THE CAR AND MY MOTOR HAS RECENTLY GONE OUT. LOST POWER GOING UP HILL AND HAD A BAD TICKING NOISE I PULLED OFF AN EXIT AND IT SOUNDED LIKE SOMETHING BROKE IN THE MOTOR. VERY DISAPPOINTED.

Mileage: 180,000

THIS ENGINE HAS A WIDESPREAD PROBLEM OF TICKING COMING FROM THE TOP PART OF THE ENGINE, AND ISSUES WITH OIL INCLUDING BURNING OIL. I PERSONALLY HAVE EXPERIENCED BOTH DESPITE MANY EFFORTS TO TRY TO REMEDY THE PROBLEM. MANY OTHER DRIVERS OF THE SAME CAR HAVE HAD THESE SAME ISSUES WHICH HAVE LED TO SCORING IN THE CYLINDERS AND COMPLETE ENGINE FAILURE. I MYSELF AM ALSO VERY CLOSE TO ENGINE FAILURE. MANY PEOPLE INCLUDING MYSELF BELIEVE THAT THERE IS AN UNDERLYING ISSUE(S) CAUSING THESE PROBLEMS IN THE THETA II ENGINES. MANY PEOPLE IN CANADA HAVE HAD THEIR ENGINE REPLACED FOR THE SAME PROBLEMS.

Mileage: 108,000

MY BRAKE LIGHTS DON'T WORK. ENGINE LIGHT KEEPS COMING ON. AIRBAG CONTROL UNIT DOESN'T WORK/ASIC IS DAMAGED. TRANSMISSION COOLER HOSE KEEPS LEAKING FLUID THE VEHICLE STOPPED ON THE FREEWAY CAUSING A CRASH.

Mileage: 212,435

I HAD A MILD ENGINE KNOCKING NOISE FOR A SEVERAL WEEKS, BUT JUST HAD AN OIL CHANGE A FEW DAYS PRIOR TO THE INCIDENT. I WAS DRIVING DOWN THE ROAD AND THE CAR SEEMED TO BE STRUGGLING TO SHIFT GEARS AND GO. I PULLED OVER AND HEARD TERRIBLE ROD KNOCKING AND ENGINE CLANKING NOISES. I TURNED THE CAR OFF TO CALL MY FATHER AND ASK IF HE THOUGHT I COULD MAKE IT HOME, AND I AGREED TO ATTEMPT IT. WHEN I TURNED THE CAR BACK ON THE ROD KNOCKING WAS WORSE THAN BEFORE, IT MADE A VERY LOUD CLICKING NOISE WHEN I ACCELERATED, AND THE OIL LIGHT CAME ON. I GOT BACK ON THE ROAD AND THE ENGINE STALLED WITHIN MINUTES, IN THE MIDDLE OF A BUSY INTERSECTION.

Mileage: 135,090

MOTOR HAS BEEN MAKING PECKING SOUND FOR PERIOD OF TIME. AS GOING DOWN THE ROAD TODAY IT DIED IN THE ROAD. FINALLY GOT IT TO CRANK ENOUGH TO GET OUT OF THE ROAD BUT IT'S MAKING A LOUDER KNOCKING SOUND.

Mileage: 20

SUDDEN ENGINE FAILURE WHILE DRIVING

Mileage: 168,000

ENGINE BURNED IN FRONT YARD HUSBAND DROVE CAR TO POST OFFICE RETURNED WITH CAR AND ENGINE WAS ON FIRE, FIRE DEPARTMENT HAD TO PUT FIRE OUT. HUSBAND MADE IT HOME AND PARKED THE VEHICLE AT FRONT DOOR HUSBAND THOUGHT CAR WAS STEAMING BUT CAR WAS ON FIRE

Mileage: 100,000

TL* THE CONTACT OWNS A 2010 KIA FORTE EX. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, A TICKING NOISE EMERGING FROM THE ENGINE COMPARTMENT STARTED. NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS DRIVEN TO THE DEALER HOLLY KIA, 13175 S DUPONT HWY, FELTON, DE 19943, THEY DETERMINED THAT THE VEHICLE NEEDED A NEW ENGINE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 88,000.

Mileage: 88,000

AFTER AN OIL CHANGE MY ENGINE BEGAN TO KNOCK. OIL CHANGE WAS NOT OVERDUE BY MORE THAN A HUNDRED MILES. OIL LIGHT CAME ON. TOOK IT TO BE CHANGED THE NEXT DAY. AS I WAS DRIVING HOME, OIL LIGHT BEGAN TO FLICKER AND BY THE TIME I GOT HOME (10 MILES) IT WAS STEADY. I TOOK IT BACK TO THE OIL PLACE. THEY INFORMED ME MY OIL WAS OVERLY SLUDGY AND WERE WORRIED IT MIGHT BE AN ENGINE ISSUE. THEY ALSO FOUND METAL SHAVINGS IN THE PAN. THIS IS THE EXACT SAME ISSUE HAPPENING WITH THE 2011 RECALLS. MY MECHANIC TOLD ME MY CAR IS DANGEROUS TO DRIVE AND I NEED AN ENGINE REPLACEMENT. KIA TOLD ME IT WOULD BE ALMOST 6000 OUT OF POCKET. THIS ENGINE NEEDS TO BE INSPECTED. I HAVE NEVER HAD ANY OTHER ISSUE WITH THIS CAR.

Mileage: 192,000

CAR DID NOT STOP WHEN PLACED IN PARK , SHIFTERS GETS STUCK. WHEN PLACING THE CAR IN REVERSE PARK , THE CAR MOVED FORWARD INSTEAD OF REVERSE , NOT STOPING ,HAD TO PUSH THE BRAKE PEDAL AND THE EMERGENCY BRAKE AS THE CAR WAS MOVING FORWARD ( WHILE ON REVERSE) KEPT MOVING FWD AT APPROXIMATELY 5 MILES WITHOUT PRESSING THE FAS PEDAL . HAD TO STOP BY USING EMERGENCY BRAKE. TURNED OFF THE CAR TOOK IT TO THE DEALER. WHEN PLACING THE CAR IN REVERSE THE CAR KEPT MOVING DANGEROUSLY FORWARD

Mileage: 93,000

UPDATE TO CLAIM 11277949 KIA DEALER CLAIMS SHIFTER BUSHING AND THE TRANSMISSION SWITCH. STRANGE THAT SUCH A DANGEROUS WAS TREATED WITH MORE CONCERN. 5 MORE SECONDS OF THAT MALFUNCTION AND I WOULD HAVE WOUNDED OR KILLED A INNOCENT PEDESTRIAN

Mileage: 94,000

TL* THE CONTACT OWNS A 2010 KIA FORTE. WHILE DRIVING AT LOW SPEEDS, A NOISE WAS DETECTED COMING FROM THE ENGINE AND THE CHECK ENGINE INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE CONTACT WAS INFORMED THAT ONE OF THE ENGINE LIFTERS WAS THE CAUSE OF THE ABNORMAL TAPPING NOISE AND THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 137,000.

Mileage: 137,000

&#128663; CAR CAUGHT ON &#128293; FIRE WHILE DRIVING ON I 285..

Mileage: 227,376

MY ENGINE HAD 85,000 MILES ON IT AND I REGULARLY DID OIL CHANGES AND THE ENGINE BLEW RANDOMLY AND COSTS OVER $5,000 TO REPLACE. THE VEHICLE WAS OPERATING FINE WHEN I PARKED IT ON MY LUNCH AND WHEN I CAME OUT TO LEAVE WORK IT WOULD NO LONGER START.

Mileage: 85,000

MY AIRBAG HAS BEEN ON FOR OVR A YR. TOOK IT TO A DEALER TO GET REPAIRED. THE LIGHT WAS OFF FOR 4 DAYS AND CANE BACK ON AND STAYS ON. BACK AGAIN. AND STILL HAD TO PAY ANOTHER DIAG. FEE. BUT THEY SAID IT WAS FIXED. NOW MY CAR SOUNDS REALLY LOUD...KNOCKING THATS ANNOYING. EVERYTIME I START MY CAR AND DRIVE IT MAKES THAT NOISE. JUST FOUND OUT. ITS AN AIRBAG MODULE THAT WASNT COVERED IN THE RECALL. WHY CLDNT THEY FIND THAT AT 1ST. SMH. VERY DISAPPOINTED IN KIA. GOING TO A DIFFERENT MFG...LIKE TOYOTA

Mileage: 100,000

KNOCKING IN ENGINE NOTICED WHITE STARTING AND DRIVING. CHECK ENGINE LIGHT ILLUMINATED LEAVING OIL CHANGE AT 86K MILES (12/27/2018). MOMENTS LATER, VEHICLE WOULDN'T GO ABOVE 60MPH ENTERING HIGHWAY. ALL LIGHTS ILLUMINATED ON THE DASH, PULLED OVER ON RAMP AND TURN VEHICLE OFF. VEHICLE WOULDN'T START AND WAS TOWED TO MECHANIC. MECHANIC GOT VEHICLE TO START AND HEARD KNOCKING. IDENTIFIED COMING FROM THE ENGINE AND VEHICLE WAS TURNED OFF. MECHANIC ADVISED VEHICLE TO BE TOWED TO DEALER DUE TO RECENT ENGINE RECALLS. VEHICLE WAS TOWED TO THE DEALER AND IS PENDING DIAGNOSTIC. I AM NOT THE ORIGINAL OWNER AND THE "10 YEAR/100,000 MILE" WARRANTY DOES NOT APPLY TO ME. HOPEFULLY THEY ARE HONEST AND HONOR THE REPAIR/REPLACEMENT.

Mileage: 86,000

SINCE IVE BOUGHT MY CAR ITS HAD A TICKING/KNOCKING NOISE COMING FROM THE ENGINE. REALLY LOUD IN THE MORNING AND IT USED TO GO AWAY AFTER DRIVING NOW ITS CONSISTENTLY MAKING NOISE. IVE BEEN TO NUMEROUS MECHANICS AND ALL SAY THAT ITS NORMAL FOR THESE ENGINES. THE NOISE KEEPS GETTING LOUDER AND I ONLY HAVE 118,200 MILES ON THIS CAR. THE CAR IS IN EXCELLENT SHAPE AND I BABY IT. BESIDES SOME MINOR SCRATCHES IT LOOKS AND RUNS BRAND NEW BESIDES THE [XXX] KNOCKING SOUND. PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TL* THE CONTACT OWNS A 2010 KIA FORTE. WHILE THE VEHICLE WAS BEING DRIVEN, THE CONTACT HEARD AN ABNORMAL TICKING SOUND COMING FROM THE ENGINE. THE VEHICLE WAS TAKEN TO EVERGREEN KIA (LOCATED AT 9205 S WESTERN AVE, CHICAGO, IL 60643, (800) 671-8069) WHERE IT WAS DIAGNOSED THAT THERE WERE SIGNS OF PISTON SLAP AND CYLINDER WALL DAMAGE. THERE WERE ALSO METAL SHAVINGS IN THE ENGINE OIL. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE APPROXIMATE FAILURE MILEAGE WAS 51,173.

Mileage: 51,173

THE ENGINE IS FAILING. JUST OVER 100,000 MILES AND HAS BEARING FAILURE WITH ROD KNOCK. I HAVE READ STORY AFTER STORY ABOUT THESE ENGINES FAILING. A 2010 NEEDS TO BE RECALLED AND REPAIRED THE SAME AS 2011. SAME ENGINE ,SAME PROCEDURES. THE CAR IS USELESS NOW. CAN'T SELL,TRADE,OR DRIVE.

Mileage: 110,000

2010 KIA FORTE; 113,000 MILES. CHECK ENGINE LIGHT CAME ON. CODE READ '3RD ENGINE BANK SENSORS.' DEALERSHIP DIAGNOSED THE PROBLEM AS 'KNOCKING RODS COMING APART INSIDE THE ENGINE.' THE DEALERSHIP CURRENTLY HAS TWO KIA FORTES IN THE SHOP WITH THE SAME MILEAGE AND PROBLEM. SEEMS LIKE A PATTERN.

Mileage: 113,000

MY ENGINE STARTED MAKING A LOUD CLICKING SOUND WHEN I STARTED THE CAR AND CONTINUED AS I DROVE, THEN THE CHECK ENGINE LIGHT CAME ON. WE TOOK IT TO A MECHANIC THAT SAME DAY. I SPOKE WITH 3 MECHANICS, ALL SAID IT'S A COMMON ENGINE PROBLEM WITH KIA'S AND THEY SAID IT WAS SPUN CRANK ON THE ROD BEARINGS AND IT'S A COMMON ISSUE WITH KIA'S. I HAVE HAD THE CAR SINCE 2010 AND ONLY HAVE 50K MILES ON IT. THEY REFUSE TO HONOR THEIR 100,000 MILES 10 YEAR WARRANTY.

Mileage: 50,000

TL* THE CONTACT OWNED A 2010 KIA FORTE. WHILE DRIVING APPROXIMATELY 50 MPH, SMOKE WAS PRESENT COMING FROM THE VEHICLE. AFTER STOPPING THE VEHICLE, IT WAS DISCOVERED THAT FLAMES AND SMOKE WERE COMING FROM UNDER THE FRONT OF THE VEHICLE. THE FIRE DEPARTMENT WAS CALLED TO THE SCENE AND EXTINGUISHED THE FLAMES. THE VEHICLE WAS DESTROYED AND TOWED. A FIRE REPORT WAS FILED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 137,000.

Mileage: 137,000

WHILE DRIVING CAR STARTED TO MAKE KNOCKING NOISES COMING FROM ENGINE. LAST WEEK THURSDAY. ( MAY 31, 2018) MILEAGE AT 65K. THEN SUDDENLY ENGINE OFF' ON ITS OWN. DID NOT WANT TO START. STARTER AND BATTERY WAS FINE BASED ON TOWING COMPANY STAFF WHO HELPED WITH TOW. NEXT DAY HAD A MECHANIC DIAGNOSE THE PROBLEM ENGINE, HE INDICATED THE ENGINE HAS LOCKED, OIL LEVEL WAS GOOD BUT WAS SLUDGY. HAD AN ANNUAL OIL CHANGE MID FEB 2018. I NORMALLY DRIVE TO AND FROM WORK IT TAKES ABOUT 15MINS. WITH TRAFFIC 20MINS. I STAY IN GUAM, ISLAND IS QUITE SMALL 18 MILES WIDE AND 31 MILES LONG. CALLED DEALER ASKED ABOUT RECALL FOR THIS PARTICULAR PROBLEM TO BE TOLD NO RECALLS HAVE BEEN FILED BY KIA BASED ON MY VEHICLES VIN NUMBER. SEARCHED THE WEB FOUND MANY COMPLAINTS ABOUT THIS SIMILAR OR SAME PROBLEM. A CLASS ACTION SUIT HAS BEEN FILED IN QUEBEC CANADA ON THIS MATTER FOR KIA FORTE 2010 ENGINE PROBLEMS/LOCKING. HOPEFULLY I AM NOT THE ONLY PERSON SUFFERING FROM THIS PROBLEM. PLEASE HELP.

Mileage: 65,576

TOOK MY KIA FORTE IN TO THE AUTO REPAIR SHOP BECAUSE THE ENGINE STARTED MAKING A KNOCKING NOISE. I HAVE THE OIL CHANGED REGULARLY JUST AS IT IS SUPPOSED TO BE DONE, AND JUST HAD IT CHANGED LESS THAN 2 WEEKS AGO. THE SHOP SAID THE ENGINE HAS MAJOR ENGINE FAILURE AND THAT THERE WAS NOTHING I CAN DO ABOUT IT. THEY SAID I WILL HAVE TO REPLACE THE ENGINE. I CALLED THE KIA DEALERSHIP TO FIND OUT ABOUT THE RECALLS ON KIA MOTORS AND THEY SAID THAT MY ENGINE IS NOT ON THE RECALL LIST BUT THAT THERE ARE MANY OF THE SAME MOTORS THAT ARE FAILING AND I WOULD HAVE TO CALL KIA CONSUMER AFFAIRS TO FIND OUT IF MAYBE THEY WILL ADD MY ENGINE. I SEE NOTHING BUT WHERE OTHER KIA OWNERS ARE HAVING THE SAME ISSUE WITH BOTH THE 2L & 2.4L ENGINE AND KIA IS BEING NASTY ABOUT REPLACING THEM. I AM VERY UPSET AS MY CAR IS NOT PART OF THEIR RECALL AND KNOW THAT IT SHOULD BE.

Mileage: 130,000

IVE BEEN EXPERIENCING WHAT OTHER PEOPLE ON KIA FORUMS HAS LABELED AS HARD SHIFTING SINCE NOVEMBER OF 2017. WHEN I START DRIVING THE CAR JERKS REALLY HARD IN BETWEEN 1-2 RPM OR WHEN IT'S SHIFTING. IT'S NOT THE TRANSMISSION FLUID AND IT MAY BE THE HEAT TEMP SENSOR BUT I DON'T KNOW.

Mileage: 120,000

HELLO, I AM CURRENTLY HAVING ISSUES WITH MY 2010 KIA FORTE. THE VEHICLE HAS BEEN STRUGGLING TO ACCELERATE AND SOON EVENTUALLY BEGAN TO FEEL AS IF IT WERE GOING TO STALL OUT ALL TOGETHER EVERY TIME I STEPPED ON THE GAS. THE CHECK ENGINE LIGHT CAME ON AND AFTER DIAGNOSING THE CODE, IT READ P0336 (CRANKSHAFT POSITION SENSOR A CIRCUIT RANGE/PERFORMANCE). AFTER SOME RESEARCH I FOUND THAT APPARENTLY THERE IS A RECALL ON THESE ENGINES FOR WHAT APPEARS TO BE THE SAME ISSUE I AM CURRENTLY HAVING. I LOOKED UP MY VEHICLES VIN ON THIS WEBSITE AND WAS NOTIFIED THAT THERE IS NOT CURRENTLY AN OPEN RECALL EVEN THOUGH I HAD JUST READ THAT HUNDREDS OF THOUSANDS OF VEHICLES OF THE SAME MAKE AND ENGINE TYPE (THETA 2) WERE BEING RECALLED FOR CRANKSHAFT ISSUES. WOULD LIKE TO HAVE MY CAR CHECKED OUT VIA RECALL MEASURES. THE SAFETY OF MY FAMILY IS IN QUESTION DUE TO THESE KNOWN ISSUES.

Mileage: 105,000

AS I WAS EXITING THE HIGHWAY I HEARD A RATTLING NOISE COMING FROM UNDER MY HOOD. THEN ALL OF A SUDDEN SMOKE START TO COME FRO M UNDER HOOD AND OUT THE BACK OF THE CAR. AS THAT WAS HAPPENING I HEARD A LOUD BANG THEN MY ENGINE SHUT OFF BEFORE I COULD PULL OVER. AFTER I WAS TOWED TO A LOCAL DEALERSHIP AND AFTER MY CAR WENT THROUGH A DIAGNOSTIC CHECK I WAS TOLD BY THE MECHANIC THAT MY ENGINE FAILED EVEN THOUGH IT WAS IN GREAT CONDITION AND WE'LL MAINTAINED.

Mileage: 63,001

AT A STOP LIGHT OR STOP SIGN. IT WILL QUIT FOR NO REASON. I HAVE TO PUT IT IN PARK OR NEUTRAL TO START AND CONTINUE. PLUS, DRIVING ALONG THE TRANSMISSION WILL KICK OUT GEAR FOR A SECOND AND THEN GO AGAIN.

Mileage: 101,008

I HAVE A 2010 KIA FORTE KOUP. IT RUNS AND DRIVES ALRIGHT BESIDES IT MAKES SUCH A KNOCK. I HAVE HEARD IT COULD BE A ROD KNOCK OR A SPUD BEARING ETC. NEED TO KNO IF I'M UNDER MANUFACTURER WARRENTY AS I'M NOT THE ORIGINAL OWNER. CAR ONLY HAS 88,000 MILES ON IT TOO. ALSO THE PLACE I TOOK IT TO SEE WHAT WAS WRONG SAID IT WOULD BE 2 GRAND TO FIX IT. HOW DO YOU EXPECT ME TO DO THAT AS I'M MAKING PAYMENTS ON THE CAR AND ONLY HAD IT SINCE APRIL OF THIS YEAR.

I HAVE KIA FORTE WHICH WAS RUNNING FINE. UNTIL I CHANGE THE STARTER THEN THE OIL WAS PUMPING TO THE ENGINE IT WOULD KNOCK LOUDLY & IF I WOULD ANY LONGER IT WOULD BLOW THE ENGINE.

Mileage: 95,000

WHEN AT STOPPED POSITION I STEP ON FOOTFEED AND RPMS DO NOT INCREASE AND THEN ALL OF A SUDDEN THE VEHICLE SURGES FORWARD. THE RPMS AS SHOWN ON THE GAUGE SHOW THAT IT IS IN THE IDLE STATE UNTIL THE SUDDEN SURGE. THIS MOSTLY HAPPENS WHEN TRYING TO ADVANCE SLOWLY. THIS HAPPENS INFREQUENTLY BUT PRESENTS A SAFETY CONCERN WHEN IT HAPPENS IN CLOSE FACILITY OR WHEN IN TRAFFIC. THE DELAY IN VEHICLE MOVEMENT MAY BE AS LONG AS 10 SECONDS AND THEN IT JUST JUMPS TO CURRENT DEMAND FROM THE FOOTFEED. THIS HAPPENS RARELY BUT WHEN IT HAPPENS IT REALLY ALARMS THE DRIVER. *TR

Mileage: 10

TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE ENGINE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE BUT THE PROBLEM RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, WHO COULD NOT DUPLICATE THE FAILURE. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 43,000.

Mileage: 43,000

I WAS DRIVING THROUGH A REDUCED SPEED ZONE OF 35 MPH AND WENT TO SET MY CRUISE CONTROL, ABOUT 3-5 SECONDS LATER I FELT THE CAR GO DEAD. I LOST POWER STEERING AND ALL ELECTRICAL SYSTEMS. MY INDICATOR LIGHTS WERE ON AND FLICKERING AND I HAD NO CONTROL OVER THE VEHICLE OTHER THAN WANING OFF TO THE SIDE OF THE ROAD TO GET OUT OF THE WAY OF TRAFFIC. ONCE MY CAR CAME TO A STOP I PROCEEDED TO TURN OFF THE IGNITION. I TRIED STARTING IT AND THE ENGINE TURNED A COUPLE OF TIMES BUT WENT DEAD SO I TURNED IT OFF. I TRIED ONE MORE TIME TO START THE IGNITION AND WAS ONLY BARELY ABLE TO GET THE ENGINE TO START AND MAINTAIN. I WENT OFF ON MY WAY AND LATER ON MY WAY HOME I STOPPED TO GET FOOD AND WHEN I GOT BACK IN MY CAR I TRIED STARTING IT AND IT STRUGGLED TO START. I HAVE ONLY HAD MY CAR FOR 1.5 YEARS AND ONLY IN THE PAST COUPLE MONTHS EXPERIENCED PROBLEMS WITH MY CRUISE CONTROL NOT ACTIVATING AND SETTING TO MY CURRENT SPEED. *TR

Mileage: 70,000

TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT THERE WAS A LOAD KNOCKING IN THE ENGINE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DIAGNOSED THAT THE VEHICLE EXHIBITED A ROD KNOCK AND RECOMMENDED HAVING THE ENGINE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 47,000.

Mileage: 47,000

OUR 2010 KIA FORTE EX LOST 90% OF POWER REPEATEDLY (RPMS DROP TO IDLE, REGARDLESS OF THROTTLE POSITION) AT SPEEDS FROM 0-35MPH. THIS IS NOT THE FIRST OCCURRENCE, BUT I THINK IT IS THE SAME PROBLEM. THIS IS VERY DANGEROUS IF YOU ARE MAKING A LEFT TURN AND YOU LOSE ACCELERATION, YOU CAN BE IN THE WAY OF ONCOMING TRAFFIC BY LOSING POWER. ABOUT 2 YEARS AGO (25,000 MILES OR SO) THE TPS (THROTTLE POSITION SENSOR) WENT OUT. KIA COULD NOT DIAGNOSE IT UNTIL IT THREW A CODE (LAME). NOW WE GET THE SAME ISSUE, THE VEHICLE IS STALLING, OR "STUMBLING" WHEN THE SPEED SHOULD BE CONSTANT OR ACCELERATING, BUT THERE IS NO ENGINE CODE FOR THE CODE READER TO PICKUP YET, SO THE MECHANICS CAN'T FIGURE OUT WHAT TO DO. APPARENTLY THIS IS A PROBLEM ON MANY MODELS OF KIA/HYUNDAI AND THE MECHANICS DON'T RECOGNIZE IT SO THEY CAN'T FIX IT, AND YOU ARE STUCK WITH A DANGEROUS CONDITION. I THINK THERE SHOULD BE A RECALL OF THESE FAULTY TPS SENSORS. KIA/HYUNDAI SHOULD AT LEAST ISSUE A SAFETY TSB (TECHNICAL SERVICE BULLETIN) TO CLUE IN THEIR MECHANICS AS TO WHAT THE PROBLEM IS. HERE'S A GREAT ARTICLE SHOWING THE PROBLEM: HTTP://WWW.KIA-FORUMS.COM/KIA-CARNIVAL-SEDONA-2006/80251-TPS-SENSOR-SYMPTOMS-TPS-FAILURE-CEL.HTML THANKS FOR YOUR ATTENTION TO THIS MATTER. *TR

Mileage: 47,100

TL* THE CONTACT OWNS A 2010 KIA FORTE. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT RESTARTED THE VEHICLE AND IT FUNCTIONED PROPERLY. THE CONTACT VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 10,000. THE VIN WAS NOT AVAILABLE.

Mileage: 10,000