High Severity Issue
This component has been associated with crashes, fires, or deaths.
This Problem Across All Years
AS AT 11/07/2023 KIA AMERICA KNEW OF HCV/HYDRAULIC CLUTCH ACTUATOR -HEV/HYBRID ELECTRIC VEHICLE CAUSED TRANMSISSION PROBLEM IN KIA NIRO HYBRID 2020 AND KIA AMERICA REFUSED TO REPAIR IT. RECALL COMPLETED 5/27/2025 AFTER POWER TRAIN WARRANTY EXPIRED.
AS AT 11/07/2023 KIA AMERICA KNEW OF HCV/HYDRAULIC CLUTCH ACTUATOR -HEV/HYBRID ELECTRIC VEHICLE CAUSED TRANMSISSION PROBLEM IN KIA NIRO HYBRID 2020 AND KIA AMERICA REFUSED TO REPAIR IT. RECALL COMPLETED 5/27/2025 AFTER POWER TRAIN WARRANTY EXPIRED.
What component or system failed or malfunctioned, and is it available for inspection upon request? The component that failed was the Hydraulic Clutch Actuator, which is part of the hybrid transmission system. This component was already replaced in May 2024 under recall SC276, but it failed again. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The failure significantly affects the vehicle’s drivability. The most noticeable issue is a loud, explosive-like sound during operation and a slipping sensation, especially when braking at low speeds on city streets. The vehicle feels unstable and difficult to control during these episodes. This creates a serious safety risk for me and for others on the road. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, it was inspected by a Kia dealership authorized by the manufacturer as part of recall SC276 in Colorado. It was later inspected again in February by Kia Serramonte in California for the same issue, but the problem still persists. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there are currently no warning lights illuminated. However, the vehicle shows abnormal behavior such as jerking, loss of power, and a noise similar to an explosion. These symptoms first appeared before the recall in 2024, and then reappeared in August 2024, just a few months after the repair until now. Due to financial limitations, I was only able to take the vehicle in for service in November 2024, and finally left it at the dealership in February 2025. The so-called “repair” lasted two months, but the dealership refused to take responsibility. I had to pay $3,188 out of pocket, and even after that, nothing was fixed — the vehicle remains defective.
What component or system failed or malfunctioned, and is it available for inspection upon request? The component that failed was the Hydraulic Clutch Actuator, which is part of the hybrid transmission system. This component was already replaced in May 2024 under recall SC276, but it failed again. The vehicle is available for inspection upon request. How was your safety or the safety of others put at risk? The failure significantly affects the vehicle’s drivability. The most noticeable issue is a loud, explosive-like sound during operation and a slipping sensation, especially when braking at low speeds on city streets. The vehicle feels unstable and difficult to control during these episodes. This creates a serious safety risk for me and for others on the road. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, it was inspected by a Kia dealership authorized by the manufacturer as part of recall SC276 in Colorado. It was later inspected again in February by Kia Serramonte in California for the same issue, but the problem still persists. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No, there are currently no warning lights illuminated. However, the vehicle shows abnormal behavior such as jerking, loss of power, and a noise similar to an explosion. These symptoms first appeared before the recall in 2024, and then reappeared in August 2024, just a few months after the repair until now. Due to financial limitations, I was only able to take the vehicle in for service in November 2024, and finally left it at the dealership in February 2025. The so-called “repair” lasted two months, but the dealership refused to take responsibility. I had to pay $3,188 out of pocket, and even after that, nothing was fixed — the vehicle remains defective.
2020 Kia Niro was driving fine until one day while driving down the highway at highway speeds (65-70 mph), the car began to lose power and as we switched lanes to get to the side of the highway, the car began to smoke and caught on fire. Our safety was at risk due to the car catching on fire. The problem is unable to be reproduced as the car is a total loss. Vehicle was inspected by police at the scene. There were no warning lights, and the vehicle had been in working condition prior to the incident. The vehicle had a recall that was fixed at our local Kia dealership as soon as a solution was indicated, and the part was located.
2020 Kia Niro was driving fine until one day while driving down the highway at highway speeds (65-70 mph), the car began to lose power and as we switched lanes to get to the side of the highway, the car began to smoke and caught on fire. Our safety was at risk due to the car catching on fire. The problem is unable to be reproduced as the car is a total loss. Vehicle was inspected by police at the scene. There were no warning lights, and the vehicle had been in working condition prior to the incident. The vehicle had a recall that was fixed at our local Kia dealership as soon as a solution was indicated, and the part was located.
My vehicle was the victim of attempted theft and reported to City of Cincinnati police 8/11/23. It then underwent repairs and delays before it was returned to me on 9/22/23. The left side rear door is basically detached from the system, causing the alarm to go off or not even work. The back seat lock is completely malfunctional, and there is glass remaining inside the car. I was informed by two separate Kia locations that they would contact me about repairs. On 9/29, notice attached here, I was informed that when a remedy is available, they will repair and cover the costs. No one has contacted me, and I have called multiple times over the last several months, including leaving voicemails, asking for any updates. I have phone logs I can provide as well. NOTE: The "Upload Files" button is not working below. Each time I click it, it just vanishes. This makes it impossible to attach anything.
My vehicle was the victim of attempted theft and reported to City of Cincinnati police 8/11/23. It then underwent repairs and delays before it was returned to me on 9/22/23. The left side rear door is basically detached from the system, causing the alarm to go off or not even work. The back seat lock is completely malfunctional, and there is glass remaining inside the car. I was informed by two separate Kia locations that they would contact me about repairs. On 9/29, notice attached here, I was informed that when a remedy is available, they will repair and cover the costs. No one has contacted me, and I have called multiple times over the last several months, including leaving voicemails, asking for any updates. I have phone logs I can provide as well. NOTE: The "Upload Files" button is not working below. Each time I click it, it just vanishes. This makes it impossible to attach anything.
My Niro has been having issues with sputtering, jerking, chugging, and feeling like it’s about to stall. Sometimes it happens right when I start the car and sometimes it happens while I am driving. The check engine light just started coming on yesterday. I believe the transmission is faulty and have spoken to or taken it to the dealer with this same issue multiple times as it is covered under warranty. They keep telling me that’s just how the car drives but in the 8 cars I’ve owned in my life, I have never had a car that behaves this way before. An internet search of “Kia niro transmission problems” proves that this is a common and known issue with this car that Kia is doing nothing to resolve. I have a daily 20 mile commute to work and feel incredibly unsafe driving my car and letting my teenage daughter drive it.
My Niro has been having issues with sputtering, jerking, chugging, and feeling like it’s about to stall. Sometimes it happens right when I start the car and sometimes it happens while I am driving. The check engine light just started coming on yesterday. I believe the transmission is faulty and have spoken to or taken it to the dealer with this same issue multiple times as it is covered under warranty. They keep telling me that’s just how the car drives but in the 8 cars I’ve owned in my life, I have never had a car that behaves this way before. An internet search of “Kia niro transmission problems” proves that this is a common and known issue with this car that Kia is doing nothing to resolve. I have a daily 20 mile commute to work and feel incredibly unsafe driving my car and letting my teenage daughter drive it.
THE SERVICE ENGINE VALVE WITH "CHECK ACTIVE AIR FLAP SYSTEM" ERROR MESSAGE IS DISPLAYED. THE DIAGNOSTIC ERROR THAT COMES UP IS AAF - P059F. ACCORDING TO THE DEALER AIR COMPRESSION TEST WERE COMPLETED AND PROPERLY FUNCTIONING. I HAVE SUBMITTED 3 PICTURES WITH THE SAME ERROR MESSAGE CODE TO THE DEALER AND THEY STATE NOT ALL SAVED IN THE CAR'S ECM. THE LIGHTS CAME ON WHEN STARTING AS WELL AS WHILE DRIVING. NOTICED THAT THE CAR TAKES LONGER TO CHANGE GEARS OR GO INTO EV MODE.
THE SERVICE ENGINE VALVE WITH "CHECK ACTIVE AIR FLAP SYSTEM" ERROR MESSAGE IS DISPLAYED. THE DIAGNOSTIC ERROR THAT COMES UP IS AAF - P059F. ACCORDING TO THE DEALER AIR COMPRESSION TEST WERE COMPLETED AND PROPERLY FUNCTIONING. I HAVE SUBMITTED 3 PICTURES WITH THE SAME ERROR MESSAGE CODE TO THE DEALER AND THEY STATE NOT ALL SAVED IN THE CAR'S ECM. THE LIGHTS CAME ON WHEN STARTING AS WELL AS WHILE DRIVING. NOTICED THAT THE CAR TAKES LONGER TO CHANGE GEARS OR GO INTO EV MODE.