2002 KIA SPORTAGE Service Brakes, Hydraulic Problems

TL* THE CONTACT OWNS A 2002 KIA SPORTAGE. THE CONTACT STATED THAT WHEN DRIVING AT VARIOUS SPEEDS AND DEPRESSING THE BRAKES, THE LINING FRACTURED ON THE REAR PASSENGER SIDE. THE VEHICLE WAS TOWED HOME WHERE THE OWNER REPLACED THE BRAKE SHOES AND CYLINDERS ON THE REAR DRIVER AND PASSENGER SIDES. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 4,290.

Mileage: 4,290

DT*: THE CONTACT STATED WHILE TRAVELING 35 MPH UPHILL ON ICY ROAD CONDITIONS WITH THE 4WD ENGAGED, THE VEHICLE BEGAN TO SLIDE. THE VEHICLE WAS TAKEN TO THE DEALER, WHO DETERMINED THAT THE BRAKE BOOSTER CABLE, VACUUM HOSE, WHEEL BEARINGS HAD FAILED. EACH COMPONENT WAS REPLACED ON SEPARATE OCCASIONS. THE 4WD WAS REPLACED 3 TIMES, BUT THE PROBLEM PERSISTED. THE SERVICE DEALER EXPRESSED TO THE CONTACT THAT THERE WERE MANY VEHICLES OF THE SAME MAKE AND MODEL WITH 4WD PROBLEMS.*AK

Mileage: 55,000

BRAKES NEED REPLACING TWICE IN UNDER 18000 MILES. WIVES CAR NEED WHOLE BRAKE SYSTEM FROM MASTER CYLINDER ON DOWN UNDER40,00 MILES. *NM

Mileage: 8,000

2002 KIA SPORTAGE PISTON SEIZED DAMAGING BRAKE PADS AND ROTORS. *TS *JB

Mileage: 39,329

THE LEFT FRONT ROTORS WERE DEFECTIVE. THIS WAS DISCOVERED DURING VEHICLE INSPECTION. THE VEHICLE WAS SERVICED AT LEAST TWENTY TIMES FOR OTHER DEFECTS. NO SERVICE FOR THE BRAKES. *AK THERE WAS A SHORT IN THE WIRING IN THE SHOCK ARMS, A PROBLEM WITH THE CATALYTIC CONVERTER, RATTLING IN THE EXHAUST SYSTEM, LICENSE PLATE LIGHTS WERE INOPERATIVE DUE TO ROTTED SOCKETS, WHEEL BEARINGS WERE EXTREMELY LOOSE, PULLING TO THE RIGHT, THE RIGHT REAR POWER WINDOW WAS INOPERATIVE, CHECK ENGINE LIGHT HAD COME ON POSSIBLY DUE TO A SMALL LEAK OR A LOOSE GAS CAP, TRANSMISSION HANG UP WHEN COLD, BAD FRONT BRAKES, CRACK IN DASH, CUP HOLDER WAS BROKEN, TAILPIPE RUSTED AND FELL OFF, WHEN THE HEATER AND DEFROST WAS ON THE A/C WOULD COME ON, THE CONSUMER WOULD GET SHOCK WHEN EXITING THE VEHICLE, INTERMITTENTLY BOTH REAR WINDOW WOULD NOT GO UP OR DOWN, AND THE LEFT REAR WINDOW WAS TOTALLY INOPERATIVE. (THERE WAS NO POWER WHEN GOING UP HILL) *SC *JB

Mileage: 34,000

BRAKE ROTORS WERE REPLACED FOUR TIMES DUE TO WARPING. CONSUMER HAS TO HAVE THEM REPLACED EVERY THREE MONTHS. *AK

Mileage: 22,000

VEHICLE DEVELOPED A SQUEAK IN FRONT BRAKES. VEHICLE WAS TAKEN TO THE DEALER, AND THEY PUSHED BACK THE CALIPER PISTON. HOWEVER, PROBLEM RECURRED. LATER, DEALER STATED THAT THERE WAS NOTHING ELSE FOUND.*AK ROTORS HAVE HOT SPOTS AND LIGHT GROOVES CAUSING HEAVY BRAKING *TS

Mileage: 11,744

SEVERAL MONTHS AFTER THE PURCHASE OF MY 2002 KIA SPORTAGE MY BRAKES STARTED TO PULSATE, I TOOK IT TO THE DEALER THEY SAID MY BRAKES WERE WARPED AND NEEDED REPLACING. ROTORS AND PADS IN FRONT HAVE BEEN REPLACED NOW 4 TIMES IN 16 MONTHS!*AK

THE VEHICLE'S ROTORS AND BRAKES FAILED PREMATURELY. THE CAUSE HAS NOT BEEN DETERMINED. THE PART HAS BEEN REPLACED THREE TIMES, HOWEVER PROBLEM STILL EXIST. *NM

Mileage: 11,000

2002 KIA SPORTAGE.*MR (NAR) FIRST OIL CHANGE, FILTER REPLACEMENT, LUBE, RATTLING NOISE UNDER STEERING WHEEL, SLUGGISH TRANSMISSION SHIFTING AND EXCESSIVE BRAKE RESIDUE ON RIGHT FRONT WHEEL. *CB

Mileage: 2,380

PROBLEMS WITH BRAKES STICKING, WINDOWS LOCKED UP, CALIPERS CRACKED.*MR TWO MONTHS AFTER PURCHASE, MECHANIC WAS INFORMED THAT THE BRAKES FELT LIKE THEY WERE STICKING OR PULLING WHEN AT A STOP OR LIGHT. THE CD PLAYER WAS INOPERABLE. CONSUMER WAS TOLD A NEW AGENT THAT WAS BEING USED ON HER VEHICLE MADE THE NOISE AND IT WOULD GO AWAY IN A COUPLE OF MONTHS. JUNE 3, 2003, WINDOWS LOCKED UP, COULDN'T ROLL UP, MOTOR BURNED OUT. JUNE 7,2003, VEHICLE SUDDENLY JERKED. THERE WAS A NOISE FOLLOWED BY SPARKS ND CLANKING METAL SOUNDS. CONSUMER REALIZED SHE HAD NO BRAKES AND HAD TO PULL THE EMERGENCY BRAKE TO STOP. VEHICLE WAS TOWED TO THE DEALERSHIP. THE CALIPER HAD CRACKED AND BROKEN CAUSING THE PADS TO SHATTER ALONG WITH THE ROTORS TO FALL OUT OF THE BOTTOM OF THE VEHICLE. THEY CLAIMED THIS FAILURE WAS DUE TO HER NEGLIGENCE. CONSUMER QUESTIONED THAT IF ON A REPAIR BILL IT STATED "30% BRAKES REMAINING," WHY WOULD THEY NOT REPLACE THEM. CONSUMER WAS BILLED $175. FOR THE RENTAL CAR, $700. FOR SERVICE AND TOW, $875. TOTAL. CONSUMER WAS INFORMED IF THE MATTER WAS TAKEN TO COURT THE DISCOUNT OF 30% WOULD BE DROPPED AND THE TOTAL TO BE PAID WOULD BE $1200. CONSUMER ASKED FOR COMPENSATION FOR TIME AND TROUBLE, LOAN CAUGHT UP, VEHICLE REPAIRED AT NO COST TO HER AND RENTAL CHARGES DROPPED. *PH

FRONT END OF VEHICLE SHAKES WHEN BRAKES ARE APPLIED. *MR THE FRONT ROTORS CONTINUED TO WARP. THERE HAVE BEEN THREE REPAIR ATTEMPTS. *SCC *JB

BRAKES WARPED SINCE CONSUMER OWNED VEHICLE. AFTER REPAIR THE BRAKES WOULD WARP AGAIN. THIS PATTERN CONTINUED UNTIL THE DEALERSHIP DECIDED TO KEEP THE TRUCK FOR FURTHER REPAIRS.*AK

Mileage: 900

BRAKES WARPED SINCE CONSUMER OWNED VEHICLE. AFTER REPAIR THE BRAKES WOULD WARP AGAIN. THIS PATTERN CONTINUED UNTIL THE DEALERSHIP DECIDED TO KEEP THE TRUCK FOR FURTHER REPAIRS.*AK

Mileage: 900

WHEN THE BRAKE PEDAL IS DEPRESSED, THEY FAIL TO STOP THE VEHICLE DUE TO THE ROTORS WARPING. THIS RESULTS IN EXTENDED STOPPING DISTANCE. ALSO, THE 5 SPEED STANDARD TRANSMISSION WOULD NOT GO INTO SECOND GEAR AND NEEDED REPLACEMENT. THE REAR END ALSO MAKES A POPPING/CLUCKING NOISE AND THE VEHICLE WILL JERK FORWARD HARD WHEN THE NOISE OCCURS. THE CAUSE OF THE FAILURES IS UNDETERMINED. *PH

Mileage: 3,000

CONSUMER STATES THAT SINCE BUYING THE VEHICLE IN JANUARY OF 2003 ROTORS HAVE BEEN REPLACED TWICE IN THAT TIME. THE FAULTY ROTORS CAUSED VIBRATION WHILE BRAKING. THE ROTORS WERE REPLACED ONCE AT 5699 MILES AND AGAIN AT 8694 MILES. WHEN THE ENGINE WAS STARTED ALL THE DOORS LOCKED, BUT WHEN IT WAS DAMP OUTSIDE THE LOCKS WORKED INTERMITTENTLY. THE DRIVER'S SIDE WIPER WASHER WAS NOT WORKING AS WELL AS THE PASSENGER SIDE. THE DEALER READJUSTED IT. THERE WAS A RATTLING IN THE DASH ON THE DRIVERS SIDE BELOW THE AIR VENT. *AK *PH *NLM

Mileage: 5,699

HAVE HAD BRAKES WORKED ON 5 TIMES IN PAST YEAR, AIR CONDITIONER SMELLS MUSTY EVERY TIME YOU TURN IT ON, GAS WARNING LIGHT DOESN'T WORK, RIGHT REAR WINDOW DIDN'T WORK FOR OVER A YEAR. *AK

CONSUMER STATED THAT WHEN APPLYING THE BRAKES THE BRAKES WOULD MAKE A LOUD NOISE. DEALER NOTIFIED. *AK

WHILE DRIVING THE CONSUMER APPLIED THE BRAKES BUT THEY DID NOT RESPOND. *AK *NLM

Mileage: 15,000

I BOUGHT A KIA SPORTAGE IN APRIL 2002. SINCE THEN, THE CAR HAS BEEN BROUGHT BACK TO THE KIA SERVICE CENTER ON FOUR SEPARATE OCCASIONS FOR THE SAME PROBLEM. THE ENGINE WILL SPUTTER, THE CAR SHAKES, THE RPMS GO TO 0 AND THE HEADER PIPE GLOWS RED HOT (LITERALLY), AND ALL OF A SUDDEN THE CAR WILL LOSE 75% OF ITS POWER. THIS IS DANGEROUS. THIS CAR HAS MAYBE 10,000 MILES ON IT AND IT WAS BOUGHT BRAND NEW. THIS IS RIDICULOUS AND NOT ACCEPTABLE. THE SERVICE CENTER HAS REPLACED THE ROTORS (KEEP IN MIND THIS IS ON 10,000 MILES), THE CATALYTIC CONVERTER, HEAD PIPE, MUFFLER AND THE REST OF THE ENTIRE EXHAUST SYSTEM, AND SPARK PLUGS. UP TO THIS DATE, THEY HAVE NOT FOUND THE PROBLEM AND EVEN AS I TYPE THIS, THE CAR IS SITTING IN THE SERVICE CENTER THE FOURTH TIME. I WAS GIVEN A RENTAL VEHICLE THE THIRD TIME. BUT THIS TIME, THEY HAVE NOT GIVEN ME A RENTAL OR REPLACEMENT VEHICLE BECAUSE TWO ARE OUT OF COMMISSION DUE TO ACCIDENTS AND ONE IS CURRENTLY BEING USED. THEY SAY THAT THEY HAVE TO HOOK THE CAR UP TO A COMPUTER AND DRIVE IT NUMEROUS MILE TO RECORD DATA. I JUST WANT A CAR THAT WORKS. *JB

I WAS WONDERING IF YOU WOULD KNOW WHERE I CAN GET MY VEHICLE TESTED FOR HEALTH ISSUES. I PURCHASED A 2002 KIA SPORTAGE AT THE END OF JANUARY 2002. I HAVE A COMPLAINT ABOUT MY VEHICLE THAT THE DEALERSHIP DOES NOT SEEM TO BE ABLE TO FIX. IT HAS A VERY STRONG ODOR THAT IS COMING INTO THE VEHICLE THROUGH THE AIR VENTS. THE DEALERSHIP HAS REPLACED THE CATALYTIC CONVERTER BUT IT HAS NOT HELPED AT ALL. THE DEALERSHIP DOES NOT KNOW WHAT THE PROBLEM IS. I FINALLY GOT THEM TO GO FOR A TEST DRIVE WITH ME AND HAD THEM SMELL THE ODOR JUST LAST WEEK. I HAD BEEN TRYING TO GET THEM TO GO FOR A TEST DRIVE WITH ME SINCE MAY 2002. MY VEHICLE HAS 15000 MILES ON IT SO IT IS TO LATE FOR ME TO GET THE MANUFACTURER TO PURCHASE THE VEHICLE BACK UNDER THE OREGON LEMON LAW. I TRIED TO GO THROUGH THE ARBITRATION PROCESS BEFORE I HIT 12,000 MILES BUT THE PERSON I SPOKE TO SAID I DID NOT HAVE A CASE BECAUSE I ONLY HAD SERVICE ORDERS FOR 2 OF THE 4 TIMES I TOOK THE VEHICLE IN FOR THE ODOR. THE DEALERSHIP DID NOT WRITE UP A SERVICE ORDER FOR THE SMELL UNTIL THE 3RD TIME I TOOK THE CAR TO THEM. I AM HOPING THAT YOU OR SOMEONE YOU KNOW MIGHT BE ABLE TO HELP ME WITH THIS PROBLEM. I DO NOT THINK THAT THE SMELL IS VERY SAFE FOR MY CHILDREN AND MYSELF TO BE SMELLING. IT HAPPENS EVERY TIME I DRIVE MY VEHICLE. THE BRAKES BUILD UP A BLACK DUST THAT IS VERY EXCESSIVE AROUND THE RIM OF MY FRONT TIRES WITHIN 6 MONTHS THEY WERE 30 PERCENT WARN. DT

BRAKE ROTORS WERE WARPED EXCESSIVELY AND HAD TO BE REPLACED AT 5000 MILES.*AK