2007 LEXUS LS Service Brakes Problems

My vehicle brake, ABS, lights are on the dashboard, Lexus has deemed the vehicle unsafe to drive due to the brake actuator being faulty causing internal damage to the ABS, junction box this is a $5000 repair, upon my research I find that service bulletin were issued years ago about this from Lexus and they reimbursed or repaired these issues during a good will campagne they initiated, was advised by a Lexus member of corporate that the letter came out for my vehicle but I was not the owner at the time, they are now saying its expired and nothing they can do. This does not waive their responsibility of this defect, which is not a wear and tear item. I have tried to allow Lexus to remedy this situation only to be hit with resistance. Please see attached

Brake actuator along with various other messages displayed

The brake actuator is a well known failure component with these cars and yet no recall has been issued. It's almost $4,000 to repair this defective component.

Brake actuator along with other safety brake codes .

Brake system broke brake actuator and fuse panel associated with brake relay

Brakes aren’t working at all. Have already replaced actuator and other braking components. Sparks Toyota is saying it’s the brake actuator and accumulator very expensive fix. Car slides when trying to apply brakes. Several complaints filed

Lexus whom parent company is Toyota manufactured the 2007 Lexus LS 460. This Lexus was manufactured with a dangerous part which is the Brake Actuator. This part fails leaving the vehicle unable to move. Which is very dangerous to consumers as this can happen anywhere at anytime. Lexus acknowledges this mistake and fixed some vehicles when in fact a recall should have been placed to fix them all. This was unfair as many consumers are purchasing these vehicles not knowing of this issue (even when Lexus Toyota did).

LEXUS HAD RECEIVED NUMEROUS REPORTS WHERE VARIOUS BRAKE SYSTEM RELATED WARNING LAMPS ILLUMINATE DUE TO INTERNAL MALFUNCTIONS OF THE BRAKE ACTUATOR ASSEMBLY. WHILE MY 2007 LS 460'S BRAKE ACTUATOR ASSEMBLY WAS REPLACED UNDER THIS RECALL/WARRANTY AND WAS REPLACED 3 YEARS AGO, MY VEHICLE CONTINUES TO HAVE THE SAME ISSUE. THE LEXUS'S RECALL LETTER DATED APRIL 19, 2016 TO ME STATED THAT THE PRIMARY COVERAGE OFFERS WARRANTY ENHANCEMENT UNTIL DECEMBER 31, 2017, REGARDLESS OF MILEAGE AFTER THE PRIMARY COVERAGE END, THE SECONDARY COVERAGE IS APPLICABLE FOR 10 YEARS FROM THE DATE OF FIRST USE, OR 150,000 MILES, WHICHEVER OCCURS FIRST. LEXUS IS REFUSING TO REPLACE THE FAULTY BRAKE ACTUATOR. THIS CONTINUES TO BE AN ISSUE FOR MOST OF THE LS 460 VEHICLES THAT HAD THE BRAKE ACTUATORS REPLACED.

Mileage: 119,890

THERE IS A SAFETY RELATED DEFECT IN MY VEHICLE WHICH CAN CAUSE THE BRAKING SYSTEM TO FAIL COMPLETELY. I DO LOT OF HIGHWAY DRIVING AND SOME LIGHTS LIKE ABS , TRACTION , BRAKE AND WARNING TURN ON AND MY BRAKE SYSTEM STARTS BEHAVING BAD. AFTER SOME RESEARCH AND TALKING TO LEXUS DEALERSHIP I FOUND OUT THAT THIS MODEL HAS A DESIGN DEFECT AND THE BRAKE ACTUATOR GO BAD. THIS IS A SAFETY ISSUE AND IT SHOULD BE A RECALL BUT LEXUS INSTEAD EXTENDED THE WARRANTY ON THIS ITEM AND HAVE REPLACED THIS DEVICE FOR FREE ON THESE MODELS BUT WHEN I CALLED THEY SAID WARRANTY IS NOT GOING TO COVER IT AND I HAVE TO PAY OUT OF MY POCKET. IT COSTS ROUGHLY $3000 PARTS AND LABOR. I DO NOT WANT TO SELL MY CAR IN THIS CONDITION AS I DO NOT WANT THE BUYER TO DIE FROM IT. LOT OF PEOPLE ARE BUYING THESE CARS WITHOUT KNOWING THAT THERE IS A BIG RISK AND THEY MAY LOOSE THEIR LIVES. I REQUEST SAFETY ADMINISTRATION TO COME FORWARD AND LOOK INTO THIS ISSUE AND SAVE 100S OF LIVES. JUST IMAGINE YOU ARE DRIVING ON HIGHWAY HAVE BRAND NEW BRAKE PADS NEW TIRES AND ALL OF A SUDDEN YOUR BRAKING SYSTEM FAILS AND YOU LOOSE YOUR LIFE. PLEASE TAKE ACTION.

THE BRAKE ACTUATOR ON THIS VEHICLE FAILS AND DISABLES THE ABS SYSTEM. THIS IS A COSTLY FIX FOR COMSUMERS.

Mileage: 151,000

I HAVE FILED A COMPLAINT WITH CORPORATE LEXUS ABOUT THE NOTORIOUS 'BRAKE ACTUATOR ' ISSUE. THERE WAS A RECALL CAMPAIGN 150K MILES OR 10 YEARS FROM MANUFACTURE BUILD DATE. WHAT I AM HAVING IS NOISE COMING FROM THE BRAKE ACTUATOR WHEN THE PEDAL IS DEPRESSED. THIS ISSUE WILL ONLY LEAD UP TO THE BRAKE ACTUATOR FAILING AND CAUSING A CATASROPHIC ACCIDENT. MY VEHICLE ONLY HAS 88K MILES. DEALERSHIP AND CORPORATE KNOWS OF THE ISSUE AND WILL NOT HONOR THE WARRANTY ENHANCEMENT. THERE IS A REASON WHY THEY HAD THIS EXTENDED CAMPAIGN BECAUSE THEY KNOW THAT THE BRAKE ACTUATORS IN THESE VEHICLES ARE FAULTY. NOT ONLY ON THIS MODEL BUT OTHER MODELS AND MOST RECENTLY NEWER VEHICLES MADE BY LEXUS ARE HAVING THIS ISSUE AND ARE BEING CALLED IN TO HAVE THE BRAKE ACTUATOR FIXED. THE CONTROL ARMS ON THIS VEHICLE IS ALSO ANOTHER ISSUE BUT I DONT MIND FORKING THE BILL ON THAT BECAUSE IT IS A WEAR AND TEAR ITEM. THE NOISE OF MY BRAKE ACTUATOR WILL GRUNT ON THE HIGHWAY STREETS AND WHILE PARKED. AS A LIFE LONG LEXUS CONSUMER I AM EXTREMLY BOTHERED THAT THEY DO NOT CARE ABOUT THEIR CUSTOMERS SAFETY. MIND YOU THE REPAIR IS ROUGHLY $5000 REDICULOUS THAT CUSTOMERS HAVE TO FORK OUT THE MONEY ON A VEHICLE THEY CALL THEIR FLAGSHIP. IT IS NOT A MATTER OF 'IF' IT WILL FAIL BUT 'WHEN'. CONAIDERING THE AMOUNT OF VEHICLES AFFECTED BY THIS I AM VERY SURPRISED THERES NO ACTUAL 'RECALL' FOR THIS SPECIFIC VEHICLE. THE NUMBER IS IN THE THOUSANDS. HIGHLY DISSAPOINTED IN LEXUS AS THEY ARE WILLING TO SACRAFICE THE SAFETY OF THEIR CUSTOMERS OVER A FAULTY PART THE CAR WAS MANUFACTURED WITH. ALSO SUPPOSEDLY THEY SENT OUT LETTERS FOR THE WARRANTY ENHANCEMENT BUT I NEVER RECEIVED ONE OR A PHONE CALL STATING THAT OWNERS WERE ABLE TO BRING IN THEIR VEHICLE TO HAVE THIS REPAIRED. I HAD THIS ISSUE BEFORE THE WARRANTY ENHANCEMENT WAS OVER AND THEY SAID IF THERE IS NO LIGHT THEY WONT HONOR IT.

Mileage: 60,000

TL* THE CONTACT OWNS A 2007 LEXUS LS460. THE CONTACT STATED THAT THE BRAKE LIGHTS REMAINED ILLUMINATED WHILE DRIVING. THE BRAKE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO JIM HUDSON LEXUS OF COLUMBIA DEALER, (328 KILLIAN RD, COLUMBIA, SC 29203) AND WAS DIAGNOSED THAT THE BRAKE ACTUATOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE BUT DID NOT ASSIST. THE FAILURE MILEAGE WAS APPROXIMATELY 52,800.

Mileage: 52,800

THE ABS ACTUATOR ASSEMBLY HAS BEEN DEEMED FAULTY IN SEVERAL TOYOTA/LEXUS VEHICLES. INSTEAD OF THE A RECALL BEING ISSUED A WARRANTY ENHANCEMENT WAS PUT IN PLACE TO ADDRESS THIS ISSUE FOR ANYONE WHO TOOK THE CAR TO THE SHOP. HOWEVER WITH OUT A RECALL MOST PEOPLE WHO WERE OWNERS OF THESE VEHICLES WAS NOT AWARE TO HAVE THE PART CHECKED AND THIS IS A SAFETY ISSUE, A VERY EXPENSIVE PART THAT SHOULD NOT NORMALLY FAIL AND WITH OUT A RECALL OR A LETTER FROM LEXUS/TOYOTA A LOT OF PEOPLE WAS PUT AT A DISADVANTAGE WITH BEING ABLE TO ADDRESS THIS ISSUE BEFORE THE WARRANTY ENHANCEMENT EXPIRED. WHILE IN MOTION I RECEIVED ALL KIND OF ERROR LIGHTS AND A MESSAGE TO PULL MY VEHICLE OVER AS SOON AS POSSIBLE AND NOTIFY THE DEALER. AT THIS TIME MY ABS SYSTEM IS COMPROMISED AND I HAVE NO TRACTION CONTROL AND MY ABS ACTUATOR CONTINUES TO VIBRATE EVEN WHEN I TURN THE CAR OFF WHICH IS USING THE BATTERY EVEN MORE. IT PULSATES THE ENTIRE TIME THE CAR IS RUNNING ALSO. I FEEL WITH LEXUS KNOW THIS IS A FAULTY PART IT ON SEVERAL OF THEIR VEHICLES CUSTOMERS THAT WAS NOT MADE AWARE OF THIS ISSUE OR THE WARRANTY ENHANCEMENT SHOULD NOT BE HELD LABILE WITH THE REPAIR COST WHICH IS 1800 FOR THE PART AND 300-400 FOR LABOR. THIS SHOULD BE A RECALL OR THE WARRANTY ENHANCEMENT SHOULD BE EXTENDED AND ALL OWNERS OF THESE VEHICLES SHOULD BE NOTIFIED AND LEXUS/TOYOTA SHOULD COMPENSATE WITH A REPLACEMENT PART ALL THE OWNERS OF VEHICLES WHICH WAS EFFECTED. THIS TOOK PLACE WHILE MY VEHICLE WAS IN MOTION ON THE INTERSTATE. MY BRAKES ARE VERY HARD TO USE.

Mileage: 135,000

TL* THE CONTACT OWNS A 2007 LEXUS LS. WHILE DRIVING APPROXIMATELY 30 MPH, THE CONTACT DEPRESSED THE BRAKE PEDAL AND FOUND IT HARDER TO DEPRESS THAN NORMAL. THE CONTACT HAD TO USE AN EXCESSIVE AMOUNT OF PRESSURE TO APPLY THE BRAKES AND THE VEHICLE HESITATED BEFORE COMING TO A STOP. IN ADDITION, SEVERAL UNKNOWN WARNING INDICATORS ILLUMINATED ON THE INSTRUMENT PANEL AND THERE WAS A CONTINUOUS BEEPING NOISE COMING FROM THE DASHBOARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER AND DEALER WERE NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 73,000.

Mileage: 73,000

LEXUS DIAGNOSED THE FRONT BRAKE ACTUATOR IS FAILING. APPARENTLY THIS WAS A KNOWN ISSUE AND THERE WAS A CUSTOMER SUPPORT PROGRAM THAT EXTENDED THE WARRANTY ON THIS PART TO DECEMBER 31, 2017 OR 150,000 MILES. THIS ISSUE APPEARED AT ABOUT 100,000 MILES ON MY VEHICLE, BUT BEYOND THE EXPIRATION DATE OF THE CUSTOMER SUPPORT PROGRAM AND LEXUS HAS REFUSED TO REPAIR IT AT NO COST OR CONSIDER AN EXTENSION. I CONSIDER THIS ISSUE A SAFETY RISK AS IT CONCERNS THE BRAKING SYSTEM. GIVEN THAT LEXUS PREVIOUSLY ACKNOWLEDGED THE ISSUE ON THESE VEHICLES AND THERE IS A SAFETY CONCERN, I BELIEVE A RECALL CAMPAIGN SHOULD BE FORMALLY ANNOUNCED.

Mileage: 102,683

AT RANDOM TIMES WHEN DRIVING OUR CAR, THE ABS, VSC AND BRAKE WARNING LIGHTS COME ON ON THE DASHBOARD. WHEN THIS HAPPENS THE ABS SYSTEM BECOMES INOPERATIVE, AND THE FRONT BRAKES CAN EASILY LOCK UP DURING MODERATELY HEAVY BRAKING. WE BELIEVE TOYOTA HAS PURPOSELY DESIGNED THE SYSTEM TO DISABLE THE ABS FUNCTIONALITY WHEN THERE IS A POSSIBLE PROBLEM DETECTED IN THE ABS ACCUMULATOR. THAT DOES NOT SEEM LIKE A GOOD IDEA. THE WARNING LIGHTS SOMETIMES GO OFF FOR A WHILE (A FEW DAYS SOMETIMES) AND THEN RETURN AT RANDOM TIMES AND DURING VARIOUS DRIVING CONDITIONS. THE WARNING LIGHTS USUALLY COME ON WHEN DRIVING AT MODERATE SPEED, AND WHEN NOT TOUCHING THE BRAKE PEDAL. FROM OUR RESEARCH IT SEEMS LIKE THIS ISSUE IS WELL KNOWN AND DOCUMENTED, AND TOYOTA SOMETIMES REPAIRS THE BRAKE SYSTEM AT NO COST, HOWEVER IT SEEMS LIKE THIS SHOULD BE A REQUIRED RECALL. OUR CAR HAS LOW MILES FOR THE YEAR, ONLY 86K. WE HAVE ASKED FOR HELP FROM LEXUS HOWEVER HAVE NOT GOTTEN ANY RESPONSE SO FAR.

Mileage: 86,000

MY 2007 LS460 LEXUS WITH 100K MILES HAS A FAILED BRAKE ACTUATOR ASSEMBLY ASCERTAINED BY A LEXUS AND TOYOTA DEALER. THIS WAS A CONFRONTED PROBLEM BY TOYOTA FOR FAILURE OF THE O RINGS WITHIN THE ASSEMBLY. THE ACTUATOR ABRUPTLY WENT OUT WHILE ON THE HIGHWAY AT 70MPH CAUSING BRAKE FLUID TO NOT GO TO THE RIGHT CALIPERS. THERE IS A RECALL FOR 150 K MI OR 10 YEARS, WHICHEVER OCCURS FIRST. HOWEVER. MY LEXUS WAS OUT OF WARRANTY IN MAY, 2018 AND THEY WILL NOT OFFER ANY HELP WHATSOEVER BECAUSE MY WARRANTY EXPIRED APROX. 1 YEAR AGO.

Mileage: 100,000

MY KIDS AND I WAS TRAVELING IN VEHICLE WHEN I TRIED TO APPLY THE BRAKES AND NOTICED MY CAR WOULD NOT STOP. I WAS TRAVELING APPROX. 25 MPH ON CITY STREET AND HAD TO PULL OVER AND LATER GET MY CAR TOWED TO DEALERSHIP. THE DEALERSHIP EXPLAINED MY ACTUATOR NEEDS REPLACING AND LEXUS WILL COVER THE COST, HOWEVER THE ACTUATOR CAUSED MY BRAKE PUMP TO GO OUT. LEXUS HAVE NOT ISSUED A RECALL BUT HAVE PUT AN "EXTENDED WARRANTY" IN PLACE UNTIL 12/2017, MY FAMILY LIVES WAS ENDANGERED DUE TO THIS FAILURE AND NOW LEXUS WANT TO CHARGE ME $2K TO REPLACE THE BRAKE BOOSTER PUMP ASSEMBLY. THIS PART IS DIRECTLY RELATED TO THE ABS SYSTEM. LEXUS REPRESENTATIVE MIKE STATED "WE WILL PAY FOR ACTUATOR ($2K) AND YOU WILL PAY FOR THE PUMP). MY HUSBAND CONTACTED LEXUS CORPORATE AND SPOKE WITH KATHRINA BOYLES AND DENIED OUR CASE AND REINTERATED LEXUS WILL ONLY COVER THE ACTUATOR-SHE ALSO SENT US A DENIAL LETTER. HOW IS THIS POSSIBLE? LEXUS DO NOT WANT TO ISSUE A RECALL ON THE ACTUATOR BECAUSE THAT WOULD BE THEM TAKING BLAME SO THEY COWARDLY ISSUED AN "EXTENDED WARRANTY". MY ACTUATOR MALFUNCTIONING PUT MY FAMILY LIFE IN EXTREME DANGER AND CAUSED MY PUMP TO MALFUNCTION AND YET LEXUS WANT ME TO PAY THE BILL. DO LEXUS CARE THAT MY FAMILY LIFE WAS PUT IN DANGER? SHOULD I CONTACT A LAWYER OR LOCAL NEWS STATION AND TELL MY DANGEROUS STORY. MY GOD I COULDN'T STOP THE CAR IMMEDIATELY AND SWERVED ALL OVER THE PLACE UNTIL I WAS ABLE GET CAR TO SLOW DOWN.

BRAKE MALFUNCTION ERROR WAS SHOWN ON THE SPEEDOMETER SCREEN WITH FIVE LIGHTS (ABS, VSC, BRAKE, TRACTION CONTROL LIGHT, AND WARNING LIGHT). THE BRAKE PEDAL BECAME VERY SOFT AND THE VEHICLE CAME TO ABRUPT STOPS. ON OTHER OCCASIONS THE BRAKE PEDAL BECAME HARD AS A ROCK AND ALSO MADE THE VEHICLE COME TO A JERKING STOP. PULSATION AND NOISE WERE ALSO NOTED. DEALER ADVISED THAT THE BRAKE ACTUATOR PART (44050-50110) WAS THE CAUSE OF THE MALFUNCTION AND NOISE. LEXUS TECH AND ADVISOR NOTED THAT THIS IS A A VERY COMMON ISSUE ON THIS PARTICULAR MODEL - 2007 LS460.

Mileage: 49,303