2003 LINCOLN LS Power Train Problems

TL* THE CONTACT OWNS A 2003 LINCOLN LS. WHILE DRIVING VARIOUS SPEEDS, THE GEAR SHIFTER BECAME DIFFICULT TO MANEUVER. THE VEHICLE WAS TAKEN TO AUTOFARM FORD LINCOLN (221 MALL RD, LOGANSPORT, IN 46947, 574-753-6294) WHERE IT WAS DIAGNOSED THAT THE CYCLOID PATCH FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 170,000.

Mileage: 170,000

TL* THE CONTACT OWNS A 2003 LINCOLN LS. WHILE DRIVING VARIOUS SPEEDS, THE TRANSMISSION MALFUNCTIONED. THE CONTACT STATED THAT THE TRANSMISSION HARDSHIFTED, WHICH CAUSED THE VEHICLE TO LUNGE FORWARD ON MORE THAN ONE OCCASION. JACKSON FORD IN DECATUR, ILLINOIS WAS MADE AWARE OF THE FAILURE, BUT THE SOURCE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 100,000.

Mileage: 100,000

TL* THE CONTACT OWNS A 2003 LINCOLN LS. WHILE DRIVING UNKNOWN SPEEDS, THE VEHICLE FAILED TO ENGAGE INTO OVERDRIVE AND THE CHECK TRANSMISSION INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE CONTACT CALLED A LOCAL DEALER (CASEY JACKSON FORD, 1435 E MAIN ST, ROYSTON, GA 30662) AND WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE FAILURE MILEAGE WAS 78,000. *TT *TR

Mileage: 78,000

CAR GOES INTO FAIL SAFE EACH AND EVERY TIME IT IS DRIVEN. IT DID SO 19 TIMES TODAY. I CONNECTED A CODE READER WHICH IDENTIFIED THE PROBLEMS AS BEING RELATED TO THE THROTTLE CONTROL AND THE THROTTLE BODY. I PURCHASED THE CAR 1 1/2 MONTHS AGO. PRIOR OWNER HAD THE THROTTLE BODY REPLACED WITH A NEW MOPAR UNIT 4 MONTHS AGO/ 2000.MILES AGO. DON'T WANT TO REPLACE IT AGAIN SINCE THIS IS LIKELY NOT THE PROBLEM.

Mileage: 75,100

THE TRANSMISSION HAS PROBLEMS SHIFTING WHILE DRIVING AND MAKES IT DANGEROUS TO OTHER CARS AROUND ME

Mileage: 122,000

TOOK TRANSMISSION FOR REPAIR. TRANSMISSION SHOP COULD NOT LOAD NEW LINCOLN SOFTWARE ON NEW COMPUTER MODULE. IT HAS BEEN TWO WEEKS AT ROWLETT TRANSMISSION SHOP AND NOW THE "ENGINE SIDE" OF THE NEW COMPUTER INSTALLED WILL NOT CLEAR. SAYS THERE IN AN ENGINE ISSUE NOW. THERE WAS NO ENGINE ISSUE BEFORE I TOOK IT TO GET THE TRANSMISSION FIXED.

Mileage: 80,000

CEL CAME ON, CODE INDICATED TRANSMISSION ISSUE. "E" APPEARED IN THE GEAR INDICATOR, RATHER THAN THE GEAR THE TRANSMISSION WAS IN. TRANS WOULD NOT SHIFT INTO 2ND AND 5TH OF GEARS. HAD THE CAR TOWED TO TRANSMISSION SHOP, WHO TOLD ME THE PROBLEM WAS A BAD TRANSMISSION CASE THAT HAD BEEN DESTROYED AS THE RESULT OF SERVO IMPACT OVER TIME. A BUSHING COULD HAVE RESOLVED THE PROBLEM, HAD LINCOLN INSTALLED ONE AT MANUFACTURE. TECH TOLD ME THIS WAS A KNOWN PROBLEM WITH THE LINCOLN 5R55 TRANSMISSION. SHOP INSTALLED NEW TRANSMISSION, WITH BUSHING, FOR $3700. NO WAY A MODERN TRANS SHOULD FAIL AT 113K MILES, ESP. FROM SOMETHING LIKE THIS, SO EASILY PREVENTABLE. LINCOLN PURCHASERS, WHO PAY A PREMIUM FOR THE ADVERTISED QUALITY OF A LINCOLN, EXPECT AND DESERVE BETTER, ESPECIALLY SINCE A SUBSTANTIAL NUMBER OF LINCOLN PURCHASERS HAVE EXPERIENCED THE EXACT SAME PROBLEM, AND HAVE HAD TO BEAR THE COST OF THE TRANSMISSION REPLACEMENT NECESSITATED BY LINCOLN'S MANUFACTURE AND PLACEMENT IN THE STREAM OF COMMERCE OF A PROVEN DEFECTIVE PRODUCT. LINCOLN SHOULD BEAR SOME OF THE COST, BUT HAS REFUSED TO DO SO. *TR

Mileage: 113,000

SHIFTS HARD, WHEN IN 20-30 MPH, IN GEAR 2 AND 3. AFTER DIAGNOSTIC, DEALER SAID IT MAY BE TRANSMISSION, BUT THEY HAVE TO TEAR IT APART. IF BANDS, TORQUE CONVERTER, OR SOLENOID PACK THEY HAVE TO TEAR DOWN AND REBUILD. HE DID SAY THAT ONE OF THE SOLENOIDS WENT OUTER IF BANDS WERE BENT, THEY WOULD HAVE TO REBUILD THE TRANSMISSION FOR A COST OF $2500 - $3500. I HAVE READ ALL OVER THE INTERNET WHERE PEOPLE ARE COMPLAINING ABOUT HARD SHIFTING AND TRANSMISSION PROBLEMS. IT SEEMS THAT THE PART WAS DEFECTIVE BY DESIGN. ONE PERSON SAID THAT THEY BOUGHT A KIT THAT FIXES THE DESIGN FLAW - 5RW MASTER SERVO BORE REPAIR KIT (FORD 5R55W/S/N). IT IS NOT MADE BY FORD, IT SEEMS THEY ARE TOO CHEAP TO FIX THE REAL PROBLEM. THEY SHOULD LISTEN TO PEOPLES CONCERNS. I AM ALSO GOING TO CALL THE 800 NUMBER FOR FORD LINCOLN AND SEND THEM A LETTER. WOULD USE WITH ANY TRANNY REBUILD. THE FINAL COST OF THE REPAIR IS NOW AT $4000.00. YIKES. *TR

Mileage: 3

THE TRANSMISSION FAILED AND HAS TO BE REPLACED PER GRAPEVINE FORD IN TEXAS. THESE FORDS HAVE HAD TRANSMISSIONS FAILING FOR YEARS AND YOU LAZY PEOPLE WON'T MAKE THEM RECALL THEM. EXACTLY HAS DOES ONE GET TO OWN A GOVERNMENT AGENCY?? *TR

Mileage: 85,000

I BOUGHT A 2003 LINCOLN LS AND IT HAS BEEN IN THE SHOP MOST OF THE TIME I HAVE OWNED IT. 11,000 DOLLARS WORTH OF REPAIRS. NOW THE TRANSMISSION SHIFT ERRATICALLY AND THE DEALER SAYS IT CAN BE FIXED AND HAS TO HA A NEW ONE. 3800 DOLLARS MORE CMON THE IS NOW ONLY A 3000 DOLLAR CAR. *TR

Mileage: 78,000

MY 2003 LINCOLN LS START SHIFTING WHILE DRIVING AND THE CHECK TRANSMISSION LIGHT CAME ON THEN THE E IN THE GEAR BOX CAME ON. *TR

Mileage: 120,000

TL* THE CONTACT OWNS A 2003 LINCOLN LS. WHILE DRIVING AT 20 MPH, THE ECT ENGINE WARNING LIGHT ILLUMINATED AS THE VEHICLE BEGAN SHAKING EXCESSIVELY. THE CONTACT MOVED THE VEHICLE FROM THE ROADWAY AND SHUT OFF THE ENGINE. WHEN RESTARTING, THE VEHICLE RESUMED NORMAL OPERATION. THE CONTACT STATED THE FAILURE WOULD OCCUR INTERMITTENTLY. THE DEALER ADVISED THERE WAS A FULL THROTTLE FAILURE. THE VEHICLE WAS NOT REPAIRED. IN ADDITION, THE TRANSMISSION WARNING LIGHT WOULD INTERMITTENTLY ILLUMINATE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING OF THE TRANSMISSION AND THERE WERE NO REPAIRS. THE FAILURE MILEAGE WAS 52,000 AND THE CURRENT MILEAGE WAS 82,000.

Mileage: 52,000

WHILE DRIVING SUDDENLY THE ABS LIGHT, TRACTION CONTROL LIGHT AND THE PARKING BRAKE LIGHT CAME ON. I IMMEDIATELY EXITED THE FREEWAY AND PULLED INTO A PARKING AREA AND TURNED THE CAR OFF. AFTER CALMING MY 87 YEAR OLD MOTHER DOWN I RESTARTED THE CAR AND NONE OF THE LIGHTS CAME ON. I PROCEEDED TO START DRIVING MY CAR HOME AND AGAIN ALL THE LIGHTS CAME ON. I CONTACTED THE DEALER WHERE I PURCHASED MY CAR AND SPOKE TO THE SERVICE MANAGER WHO INFORMED ME THAT THEY KNEW OF THIS PROBLEM WITH THE LINCOLNS AND THAT I SHOULD BRING IT IN WHICH I DID. I WAS INFORMED THAT IT WOULD COST APPROX. $2,000.00 TO FIX THIS PROBLEM BECAUSE LINCOLN ONLY COVERS AUTOMOBILES THAT ARE LESS THAN 10 YEARS OLD OR HAVE LESS THAN 100K MILES. MY CAR HAS 109K BUT I FEEL THAT LINCOLN SHOULD COVER THIS SINCE THEY HAVE KNOWN ABOUT IT LONG BEFORE MY CAR HAD 100K MILES AND THIS IS A VERY BIG SAFETY HAZARD. I HAVE TAKEN EXCELLENT CARE OF MY CAR GETTING EVERY OIL CHANGE ON TIME AND EACH OF THE SERVICES THAT HAVE BEEN SUGGESTED. LINCOLN HAS SAID THEY CAN'T HELP ME AND THE DEALER SAYS HIS HANDS ARE TIED, WHAT RECOURSE DO I HAVE? ALSO I HAVE ALREADY HAD TO HAVE A NEW TRANSMISSION PUT IN MY CAR. *TR

Mileage: 109,300

REPEATED FAILURE OF LEFT REAR WHEEL BEARING AND LEFT DIFFERENTIAL SEAL. DEALERSHIP HAS REPLACED WHEEL BEARING AND SEAL 2X, SECOND TIME REPLACED LEFT AXLE SHAFT ALSO. FIRST INDICATION OF PROBLEM IS ODOR OF GEAR OIL LEAKING FROM DIFFERENTIAL, PARTICULARLY AFTER HIGHWAY DRIVING. NOTICED IT AGAIN TODAY, (3/15/08) WILL BE RETURNING TO DEALER ASAP. *TR

Mileage: 66,400

REPEATED FAILURE OF LEFT REAR WHEEL BEARING AND LEFT DIFFERENTIAL SEAL. DEALERSHIP HAS REPLACED WHEEL BEARING AND SEAL 2X, SECOND TIME REPLACED LEFT AXLE SHAFT ALSO. FIRST INDICATION OF PROBLEM IS ODOR OF GEAR OIL LEAKING FROM DIFFERENTIAL, PARTICULARLY AFTER HIGHWAY DRIVING. NOTICED IT AGAIN TODAY, (3/15/08) WILL BE RETURNING TO DEALER ASAP. *TR

Mileage: 66,400

CAR HAS CONSISTENTLY JUST SHUT OFF WHILE DRIVING (ROUGHLY 30 TIMES IN THE LAST YEAR). BEEN INTO THE DEALER NO LESS THAN 10 TIMES. HAD THOUSANDS OF DOLLARS OF VALVE COVERS, COILS, PLUGS GASKETS, WINDSHIELD WIPER COMPONENTS REPLACED. NO CHANGE. CAR WILL STILL DIE WHENEVER IT FEELS LIKE IT. LINCOLN/FORD COULD CARE LESS, AND THE DEALER AND FIELD ENGINEERS SEEM TIRED OF SEEING MY CAR. CONSTANT MOVEMENT OF BRAKE PEDAL IN RHYTHM WITH WINDSHIELD WIPERS. DEALER HAS TRIED TO FIX NUMEROUS TIMES AND THE PROBLEM IS WORSE NOW THEN WHEN THEY STARTED. FRONT BRAKE PADS RATTLE. DEALER SAYS IT IS A KNOWN ISSUE AND I SHOULD JUST DEAL WITH IT. FRONT SEAT BACKS FALL DOWN. DEALER AND FORD BLAME MY KIDS BEING IN CAR SEATS. NEVER HAD A PROBLEM BEFORE THEY TOOK SEATS APART TO REPLACE FAULTY SEAT HEATER. THE TRANSMISSION IS AWFUL. BEEN REPROGRAMMED 3 TIMES AND NEW SERVOS INSTALLED. STILL DOES NOT SHIFT SMOOTHLY, AND VERY ERRATIC. SHIFTS WHEN IT SHOULDN'T AND DOES NOT SHIFT WHEN IT SHOULD. CAR STALLED AND ACTIVATED THE ALARM HORN HONKING, LIGHTS BLINKING IN THE MIDDLE OF AN INTERSECTION. CAR RESTARTED. NEXT DAY CAR HAD DEAD BATTERY AND WOULD NOT START. COULD NOT EVEN JUMP IT AS THERE WAS NO POWER TO OPEN TRUNK AND LOCK CYLINDER WAS FROZEN DUE TO LACK OF USE. BATERY IN TRUNK!! WHEELS HAD TO BE BALANCED 3 TIMES THEN FORCE BALANCED TO REMOVE EXCESSIVE VIBRATION. ALL AT MY EXPENSE HAD LEAKY REVERSE LIGHT REPLACED BY DEALER NOW HAVE SOME PIECE OF A FASTENER FLOATING AROUND INSIDE THE DECK LID RATTLING. CLIPS FOR E BRAKE ARE ALWAYS BROKEN AND APPARENTLY 180 BUCKS TO FIX.

Mileage: 39,000

TL*THE CONTACT OWNS A 2003 LINCOLN LS. THE CONTACT STATED THAT THE ENGINE GOES INTO THE FAIL SAFE MODE WITHOUT WARNING. THE FAILURE HAS OCCURRED THREE TIMES WITHIN THE PAST MONTH WHILE DRIVING 40-45 MPH. THE DEALER HAS NOT BEEN ABLE TO CORRECT THE FAILURE. FORD MOTOR COMPANY HAS YET TO RESPOND. THE FAILURE MILEAGE WAS 44,000 AND CURRENT MILEAGE WAS 45,000. UPDATED 01-10-08. *KB THE CONSUMER ALSO STATED WHILE DRIVING, THE TRANSMISSION WOULD SHIFT ERRATICALLY. THE SHIFTER COVER WAS CRACKING ON THE RIGHT SIDE. UPDATED 01/10/08. *JB

Mileage: 44,000

WITH APPROX. 2300 MILES, TRANSMISSION WENT. TOOK 31 DAYS TO REPAIR. LESS THAN 50 MILES UPON IT'S RETURN, IT WENT AGAIN. AFTER 11 DAYS, VEHICLE WAS RETURNED, SO FAR (800 MILES), IT APPEARS TO BE WORKING WELL.

Mileage: 2,300

THE CONSUMER STATED IT WAS DIFFICULT TO SHIFT GEARS. *JB

Mileage: 20,360

SPARK KNOCK UNDER LOAD (PASSING OR FROM 0) OCCURS WITH LOW RPM AND HIGH RPM UNDER LOADS CURRENTLY TOLD TO WAIT UNTIL LINCOLN FINDS A FIX SINCE THEY HAVE NEVER HEARD OR DEALT WITH THIS PROBLEM BEFORE. TRANSMISSION HAS HAD REPAIRS DONE ALSO. SHIFTING HAS GOTTEN BETTER SINCE REPROGRAMMING OF COMPUTOR. SINCE THIS IS A UNIQUE PROBLEM TO THIS VEHICLE COMPLAINTS ARE NOT TAKEN TOO SERIOUSLY BY LINCOLN OF CANADA.

JUST PURCHASED 03 LINCOLN LS V-8 SPORT THREE WEEKS AGO, ALREADY INTO SERVICE. THE TRANNY IS SLOW ON UP AND DOWN SHIFTS. THE SERVICE DEPT. ( NEIL LINCOLN MERCURY @ 1900 RT 112 MEDFORD NY) SAID THIS WAS A KNOWN PROBLEM ON MY INITIAL CALL, JUST BRING IT IN AND THEY WILL REPROGRAM THE TRANNY SHOULD SOLVE THE PROBLEM. MY SECOND COMPLAINT IS I NOTICED AN EXCESSIVE AMOUNT OF UNCOMFORTALBE HEAT UNDERNEATH THE DRIVER SIDE DASH WHILE DRIVING, I SUSPECT THIS IS DUE TO THE LACK OF AN INSULATED COVER. THIS COVER I COME TO FIND OUT WAS IN THE 2000, 2001, 2002, MODEL YEARS. UNFORTUNATELY SOME GENUIS DECIDED TO FORGET IT. THAT'S A PROBLEM, AS IT IS NOT JUST A LITTLE WARM, BUT REALLY HOT, I CAN'T IMAGINE MY COMPLAINT WAS THE FIRST FOR THIS, AS NONE OF THE 03'S ARE EQUIPED WITH THIS PROTECTIVE COVER. THE LINCOLN SUPPORT CUSTOMER SERVICE HAS ADVISED ME I MUST TALK WITH SERVICE, AS THIS IS NOT A PART ON THE 03, AND SERVICE TELLS ME TO SPEAK TO LINCOLN, AS THIS IS A VALID COMPLAINT. WHAT THE HECK AM I SUPPOSE TO DO? OH AND BACK TO THE TRANNY WHAT IF IT DECIDES TO JUST GO TO MUSH WHILE I'M CROSSING AN INTERSECTION. TO LATE TO SAY SORRY THEN! I'VE HEARD THAT THE 30,000 MILE TRANNY TUNE UP WILL OFTEN SOLVE THIS TRANNY ISSUE, CAN I MAKE THEM SERVICE IT NOW I'VE GOT 1,500 LOGGED TO DATE. THANK YOU FOR THE ASSISTANCE, IT IS VERY MUCH APPRECIATED, SORRY FOR THE LONG MESSAGE. BRIAN

Mileage: 100