This Problem Across All Years
Check engine light came on. Error code 0302 and 0316 on ODB at dealer. Was advised that engine needed to be replaced due to coolant intrusion into cylinder 2 which cause the vehicle to overheat. Engine has 3200 miles on it. Safety hazard due to engine seizing at high speed and causing an accident due to loss of power. Also possible engine fire due to loss of coolant/overheating.
Check engine light came on. Error code 0302 and 0316 on ODB at dealer. Was advised that engine needed to be replaced due to coolant intrusion into cylinder 2 which cause the vehicle to overheat. Engine has 3200 miles on it. Safety hazard due to engine seizing at high speed and causing an accident due to loss of power. Also possible engine fire due to loss of coolant/overheating.
Coolant Intrusion of Cylinder 3, car has less than 50,000 miles total and has been very well taken care of. Has had over a gallon of coolant added within the month of Aug
Coolant Intrusion of Cylinder 3, car has less than 50,000 miles total and has been very well taken care of. Has had over a gallon of coolant added within the month of Aug
My 2018 Lincoln MKZ with the 2.0 Ecoboost Engine incurred premature engine failure at ONLY 40k miles. My safety as well as other drivers' safety at risk due to EcoBoost Engine in certain model year 2013-2019 Ford and Lincoln vehicles have an inherent design defect which makes them predisposed to leak coolant, including allowing the coolant to seep into the engine cylinder, which causes overheating and cylinder head cracking, and can cause the engine to misfire, suddenly stall, or even catch fire while driving. In April the car began to "shake" at start up. The shaking was intermittent. After a few days of this, the check engine light came on. I took it to the mechanic (T&H) to have it looked at. They said the "shaking" is the car misfiring at start up. They were not able to locate any leaks or identify the cause of the misfire. They code on the check engine light was Code P0301-Cylinder #1. During April and May the misfires have continued and got worse. I was going back and forth to T&H trying to diagnose the issue. On May 12th, while taking the kids to school, I went to pull out into traffic and the car would not accelerate. The dashboard lights said the engine was overheating. The car would not go above 10mph. Luckily my mechanic is down the street. They were concerned about excessive use of coolant and not seeing a leak anywhere. They filled the coolant, and I made a follow up appt in one week to do a borescope inspection. On May 19th, T&H did a Borescope inspection and visually confirmed coolant in cylinder #1. They provided me a copy of a TSB 22-2229 that states the engine block needs to be replaced. The cost of the engine block replacement was estimated at $8k. Engine failure at 40k miles is unacceptable. An engine block replacement due to a manufacturing/design flaw should be covered by Lincoln Motor Co as a goodwill repair regardless of warranty status.
My 2018 Lincoln MKZ with the 2.0 Ecoboost Engine incurred premature engine failure at ONLY 40k miles. My safety as well as other drivers' safety at risk due to EcoBoost Engine in certain model year 2013-2019 Ford and Lincoln vehicles have an inherent design defect which makes them predisposed to leak coolant, including allowing the coolant to seep into the engine cylinder, which causes overheating and cylinder head cracking, and can cause the engine to misfire, suddenly stall, or even catch fire while driving. In April the car began to "shake" at start up. The shaking was intermittent. After a few days of this, the check engine light came on. I took it to the mechanic (T&H) to have it looked at. They said the "shaking" is the car misfiring at start up. They were not able to locate any leaks or identify the cause of the misfire. They code on the check engine light was Code P0301-Cylinder #1. During April and May the misfires have continued and got worse. I was going back and forth to T&H trying to diagnose the issue. On May 12th, while taking the kids to school, I went to pull out into traffic and the car would not accelerate. The dashboard lights said the engine was overheating. The car would not go above 10mph. Luckily my mechanic is down the street. They were concerned about excessive use of coolant and not seeing a leak anywhere. They filled the coolant, and I made a follow up appt in one week to do a borescope inspection. On May 19th, T&H did a Borescope inspection and visually confirmed coolant in cylinder #1. They provided me a copy of a TSB 22-2229 that states the engine block needs to be replaced. The cost of the engine block replacement was estimated at $8k. Engine failure at 40k miles is unacceptable. An engine block replacement due to a manufacturing/design flaw should be covered by Lincoln Motor Co as a goodwill repair regardless of warranty status.
I own a 2018 Lincoln MKZ. The vehicle Engine overheating warnings came up, and I took the car to the dealership. They informed that the Lincoln MKZ vehicle had a frequent problem with coolant leaking into the engine due to faulty power train assembly. The dealer has seen and repaired hundreds of vehicles with this problem. Lincoln company denies responsibility for this manufacturing defect. The vehicle is only 7 years 3 months and 30 days old with 67914 miles used by single owner. A reputed company like Lincoln should be held responsible for manufacturing and marketing vehicles where the power train and engine fails on a fairly new vehicle.
I own a 2018 Lincoln MKZ. The vehicle Engine overheating warnings came up, and I took the car to the dealership. They informed that the Lincoln MKZ vehicle had a frequent problem with coolant leaking into the engine due to faulty power train assembly. The dealer has seen and repaired hundreds of vehicles with this problem. Lincoln company denies responsibility for this manufacturing defect. The vehicle is only 7 years 3 months and 30 days old with 67914 miles used by single owner. A reputed company like Lincoln should be held responsible for manufacturing and marketing vehicles where the power train and engine fails on a fairly new vehicle.
Initially when buying the vehicle in 2021, it had 30k miles. Car continued to give me a "cylinder 2 misfire code" after numerous trips to different garages and then the car beginning to start up rough and anti freeze missing i came across a "service bulletin" regarding it being a faulty ring in the engine. I took the vehicle to Ford and they replaced the engine. My car just hit 100k miles All of the sudden one day when trying to stop at a red light the car was shaking . There was no codes and only happened while in drive and at a red light or stop sigh:( complete stop) I took the card to Ford, who diagnosed it and open up my tranny and found out there was no fluid ,was burnt and had metal in it. There is still no code on my dash board and i need to pay 7k to replace a transmission. The fluid is housed internally , there was no leaks, and no codes was thrown on the dash. How was i to know transmission fluid was leaking and wher was it going?
Initially when buying the vehicle in 2021, it had 30k miles. Car continued to give me a "cylinder 2 misfire code" after numerous trips to different garages and then the car beginning to start up rough and anti freeze missing i came across a "service bulletin" regarding it being a faulty ring in the engine. I took the vehicle to Ford and they replaced the engine. My car just hit 100k miles All of the sudden one day when trying to stop at a red light the car was shaking . There was no codes and only happened while in drive and at a red light or stop sigh:( complete stop) I took the card to Ford, who diagnosed it and open up my tranny and found out there was no fluid ,was burnt and had metal in it. There is still no code on my dash board and i need to pay 7k to replace a transmission. The fluid is housed internally , there was no leaks, and no codes was thrown on the dash. How was i to know transmission fluid was leaking and wher was it going?
I have been told by a ford mechanic on 7.11.2024, 6 weeks before buying the car that there is coolant intrusion in cylinder 2 and the only fix to this would be to replace the long block that cost a little over 8k, some how some way this vehicle dont have any recalls about this well known issue. This in no way should be on the customer due to a defect by Ford engine in there vehicles.
I have been told by a ford mechanic on 7.11.2024, 6 weeks before buying the car that there is coolant intrusion in cylinder 2 and the only fix to this would be to replace the long block that cost a little over 8k, some how some way this vehicle dont have any recalls about this well known issue. This in no way should be on the customer due to a defect by Ford engine in there vehicles.
I own a 2018 Lincoln MKZ. Starting the second week in January I started to notice a strange smell in the cabin of my car and outside of my car. I told my husband that I was smelling something strange, and he noticed that the exhaust was a billowy white smoke. My husband noticed that this was not a good sign. We also noticed that my Lincoln app was saying there was a misfire in cylinder 2. My husband checked my coolant and saw that my coolant reservoir was completely empty. My husband added coolant and informed me that we would need to take the car to the shop. By the following week ([XXX]) my husband checked my coolant again and saw that my reservoir was empty again and my app was saying cylinder 2 was misfiring again. On Tuesday [XXX], we took the car to the Suburban Ford of Waterford to have my car looked at. On Wednesday [XXX], the dealership called my husband and informed him that I would need a new engine in my car because the coolant is leaking into cylinder and mixing with the oil which is causing the misfire in cylinder 2. The dealership informed us that this was a problem that Ford and Lincoln had with the 2.0 and 1.5 engines for the MKZ and Fusion. The 2018 MKZ was affected by this problem. The dealership informed us that Ford/Lincoln replaced the engines after they noticed the problem, but they said my car must have had the older engine that had the problem. As you can imagine I was very upset to hear that my car, which is only six years old, would need a new engine. Not only was I upset to hear this, but I am also upset about possibly shouldering the financial burden of a new engine when this is a manufacturing problem that is no fault of my own. Also, since Ford/Lincoln knew about this issue why did they not send out a recall notice about this issue? I have found out that the oil mixing with the coolant causes corrosion in the cylinders. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
I own a 2018 Lincoln MKZ. Starting the second week in January I started to notice a strange smell in the cabin of my car and outside of my car. I told my husband that I was smelling something strange, and he noticed that the exhaust was a billowy white smoke. My husband noticed that this was not a good sign. We also noticed that my Lincoln app was saying there was a misfire in cylinder 2. My husband checked my coolant and saw that my coolant reservoir was completely empty. My husband added coolant and informed me that we would need to take the car to the shop. By the following week ([XXX]) my husband checked my coolant again and saw that my reservoir was empty again and my app was saying cylinder 2 was misfiring again. On Tuesday [XXX], we took the car to the Suburban Ford of Waterford to have my car looked at. On Wednesday [XXX], the dealership called my husband and informed him that I would need a new engine in my car because the coolant is leaking into cylinder and mixing with the oil which is causing the misfire in cylinder 2. The dealership informed us that this was a problem that Ford and Lincoln had with the 2.0 and 1.5 engines for the MKZ and Fusion. The 2018 MKZ was affected by this problem. The dealership informed us that Ford/Lincoln replaced the engines after they noticed the problem, but they said my car must have had the older engine that had the problem. As you can imagine I was very upset to hear that my car, which is only six years old, would need a new engine. Not only was I upset to hear this, but I am also upset about possibly shouldering the financial burden of a new engine when this is a manufacturing problem that is no fault of my own. Also, since Ford/Lincoln knew about this issue why did they not send out a recall notice about this issue? I have found out that the oil mixing with the coolant causes corrosion in the cylinders. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)