2012 MAZDA CX-9 Engine Problems

After hearing low rumbling sound and smelling burnt oil, car was taken to dealer for check up. They informed me of known issue, front PTU leaking oil due to design flaw that put the PTU so close to the exhaust. I am seeing that other owners of this model are also reporting fires due this same exact problem, apparently unbeknownst to me Mazda has provided extended warranty up to 90k miles but not actually informed the owners of this as a potential catastrophic problem. my personal review has informed me that fire seem to be most common between 110,000 and 130,000 mile ranges.

CAR IDELS UP AT STOP SIGNS

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED. ADDITIONALLY, THE BRAKES FAILED TO ENGAGE WHEN THE BRAKE PEDAL WAS DEPRESSED. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE MASTER CYLINDER AND BRAKE BOOSTER NEEDED TO BE REPLACED. THE CONTACT WAS ADVISED TO REACH OUT TO THE DEALERSHIP ELDORADO CHEVROLET(233 N CENTRAL EXPWY, MCKINNEY, TX 75070). THE CONTACT WANTED A SECOND OPINION AND THE VEHICLE WAS TAKEN TO ELDORADO CHEVROLET (2300 N CENTRAL EXPY, MCKINNEY, TX 75070) WHERE IT WAS ALSO DIAGNOSED WITH THE MASTER CYLINDER AND BRAKE BOOSTER NEEDING TO BE REPLACED. THE SVC MGR INFORMED CONSUMER HE WOULDNT ADVISED ANYONE TO DRIVE THE VEHICLE UNTIL REPAIRS WERE MADE. DUE TO INCORRECT TITLE WORK THE DEALER REFUNDED SOME MONEY AND TOOK POSESSION OF THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000. THE CONSUMER STATED THE VEHICLE WAS PUT BACK ON THE LOT FOR RESALE. THE CONSUMER CONTACTED A LAWYER AND VEHICLE WAS TAKEN OFF THE LOT BUT CARFAX WAS NOT UPDATED WITH CORRECT INFORMATION.

Mileage: 110,000

MY WIFE WAS DRIVING DOWN A CITY STREET WHEN THE CAR COMPLETELY SHUT DOWN AND LOST ALL POWER. LUCKILY, SHE WAS ABLE TO STOP WITHOUT CAUSING AN ACCIDENT. WE HAD CAR TOWED TO AN INDEPENDENT MECHANIC. AFTER INSPECTION WE WERE TOLD THE WATER PUMP HAD FAILED CAUSING COOLANT TO LEAK INTO THE ENGINE AND CAUSED COMPLETE ENGINE FAILURE. WE WERE QUOTED $8K-$10K TO REPLACE THE ENGINE. THE 2012 MAZDA CX-9 ONLY HAD 99K MILES, BUT UNFORTUNATELY OUR EXTENDED WARRANTY EXPIRED A FEW YEARS AGO, SO MAZDA WAS OF NO HELP. WE WERE LEFT TO JUNK OUR CAR FOR A FRACTION OF WHAT IT'S VALUE SHOULD HAVE BEEN. APPARENTLY THIS IS A KNOWN ISSUE AND WE WILL BE JOINING THE CURRENT CLASS ACTION LAWSUIT AGAINST MAZDA.

Mileage: 99,000

IN OCT. 2019 MY CX9 STOPPED WHILE BEING DRIVEN. FOUND OUT THE WATER PUMP (WHICH IS INSIDE THE ENGINE) HAD GONE OUT AND DESTROYED MY ENGINE. THIS IS A KNOWN PROBLEM OF WHICH MAZDA HAS FAILED TO MAKE THEIR CONSUMERS AWARE. I PURCHASED THIS CARE NEW AND ALL OF MY SERVICES HAD BEEN HANDLED BY MAZDA. NO-ONE TOLD ME ABOUT THIS PROBLEM AND I STILL HAD TO PAY JUST OVER 4K TO GET A NEW ENGINE OF THE SAME STUPID DESIGN PUT IN MY CAR. THIS IS VERY DANGEROUS PROBLEM. HOW MANY MAZDA DRIVERS HAVE BEEN INJURED OR KILLED IN CRASHES BECAUSE THE WATER PUMP DESTROYED THE ENGINE ON A FREEWAY AND THE CAR CEASING TO MOVE WAS THE CAUSE OF AN ACCIDENT THAT TOTALED THE CAR AND AS A RESULT WENT UNDETECTED? THE ENGINES NEED TO BE RECALLED.

Mileage: 170,000

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO KENNEDY MAZDA LOCATED AT 1411 RIDGE PIKE, CONSHOHOCKEN, PA 19428, (610)272-0700, TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE WAS DAMAGED DUE TO A WATER PUMP FAILURE. THE VEHICLE WAS TOWED BACK TO THE HOME AND LATER REPAIRED BY AN INDEPENDENT MECHANIC HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 109,000. THE VIN WAS NOT AVAILABLE.

Mileage: 109,000

DRIVING ON RTE 3 N IN BRAINTREE. CAR WAS DECELERATING WHILE I HAD MY FOOT ON GAS. LOST STEERING AND BARELY MADE IT TO BRAKE DOWN LANE. THIS CAR HAS 72K MILES ON IT. NEEDS NEW ENGINE.

Mileage: 72,000

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. WHILE ATTEMPTING TO ACCELERATE FROM A TRAFFIC LIGHT, THE ACCELERATOR PEDAL WAS DEPRESSED; HOWEVER, THE VEHICLE FAILED TO RESPOND. THE CONTACT STATED THAT THERE WERE NO WARNING INDICATORS BEFORE OR AFTER THE FAILURE. THE BRAKE PEDAL ALSO BECAME EXTREMELY DIFFICULT TO DEPRESS. THE VEHICLE WAS TOWED TO CONTINENTAL MAZDA (LOCATED AT 2363 AURORA AVE, NAPERVILLE, IL 60540, (630) 352-5900) WHERE IT WAS DIAGNOSED THAT COOLANT ENTERED THE ENGINE OIL AND CAUSED THE ENGINE TO FAIL. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND PROVIDED CASE NUMBER: 1-2189354066. THE APPROXIMATE FAILURE MILEAGE WAS 52,000.

Mileage: 52,000

VEHICLE STALLED WHILE EXITING THE HIGHWAY, ENGINE LIGHT ON, NOISE FROM TIMING CHAIN AREA, VEHICLE OVERHEATS, WATER PUMP FAILURE PUSHES ANTIFREEZE INTO THE OIL COMPARTMENT CAUSING THE ENGINE TO GET DAMAGED WITHIN MINUTES WHITEOUT A WARNING. THIS IS OBVIOUSLY A MAJOR VERY EXPENSIVE SAFETY ISSUE.

Mileage: 128,000

I OWN A 2012 MAZDA CX9, WHICH I PURCHASED NEW. ON MONDAY MORNING (NOVEMBER 12, 2018) MY (CHECK ENGINE LIGHT CAME ON) AND SO I TOOK IT IMMEDIATELY TO THE DEALERSHIP FOR DIAGNOSIS. MY CAR WAS RUNNING BEAUTIFULLY, SO I JUST ASSUMED WITH THE WEATHER CHANGE, PERHAPS THE GAS CAP WASN'T TIGHTENED, AND THEY JUST NEEDED TO CLEAR THE CODES. IT TURNS OUT THE WATER PUMP FAILED AND APPARENTLY DESTROYED THE ENTIRE ENGINE. WHICH BECAME APPARENT AS I DROVE IT TO THE DEALERSHIP FOR DIAGNOSIS, PER THEIR RECOMMENDATION. MY CAR IS WELL MAINTAINED BASED ON THE DEALER RECOMMENDATIONS AND IS CONSISTENTLY SERVICED AT THE MAZDA DEALERSHIP. THE CAR IS IN FANTASTIC CONDITION WITH ONLY 90,000. AS AN OWNER, I DID EVERYTHING BY THE BOOK IN TERMS OF MAINTENANCE FOR MY CAR. I AM LETTING YOU KNOW, MAZDA HAS A SERIOUS PROBLEM AND IT'S A SAFETY ISSUE, AS WELL. IF A WATER PUMP CAN JUST FAIL WITHOUT WARNING AND COMPLETELY SHUT DOWN AN ENGINE, THAT'S NOT GOOD. I THINK THIS IS FAR MORE DANGEROUS THAN THE AIR BAG RECALL, WHICH IS ONLY A CONCERN IF YOU GET IN AN ACCIDENT. THERE IS NO WARNING ON THE WATER PUMP FAILING, AS IT'S SELF-CONTAINED WITHIN THE POWER TRAIN AND THE ONLY WAY TO CHECK THIS PART IS BY REMOVING THE ENTIRE ENGINE, WHICH LEADS ME TO BELIEVE THIS PART WAS NOT DESIGNED TO BE A WEAR PART. IT'S AN ENGINEERING DESIGN FLAW, THAT CAN CAUSE BODILY HARM IF IT FAILS, BECAUSE IT TAKES OUT THE ENTIRE ENGINE AND YOU LOSE CONTROL OVER THE VEHICLE.

Mileage: 90,000

WHILE DRIVING MY MAZDA CAR, IT SUDDENLY STARTED BUCKING AND CHECK ENGINE LIGHT CAME ON. CAR WAS TOWED TO THE DEALERSHIP. PER MAZDA MECHANIC, WATER PUMP MALFUNCTIONED FORCING COOLANT INTO THE ENGINE. FEEL THIS POSES A SIGNIFICANT SAFETY ISSUE AS THERE WAS VERY LITTLE WARNING POSING RISK OF ACCIDENT, ENGINE OVERHEATING AND POTENTIAL FIRE. THIS APPEARS TO BE A COMMON ISSUE AS MULTIPLE OTHER POSTS REPORTED

Mileage: 92,000

FUEL PUMP FAILURE CAUSING ENGINE FAILURE AND TO DIE IN MOTION ON A RURAL HIGHWAY. VEHICLE HAD TO BE PUSHED OFF THE ROAD.

Mileage: 180,000

THE TRANSFER CASE IS LEAKING AND GOING TO GO COMPLETELY OUT ON MY 2012 MAZDA CX-9, I NOTICED THE SAME GEAR SHIFTING PROBLEM IN MY 2004 MAZDA 6 WAGON. THE CAR FEELS LIKE DRIVING A STICK, IT JOLTS WHEN SHIFTING TO DRIVE AND WHILE MOVING IT FEELS LIKE IT IS SHIFTING EARLY. THIS IS A KNOWN PROBLEM WITH MAZDA BUT A RECALL IS YET TO SURFACE FOR THIS ISSUE.

Mileage: 58,000

WHILE DRIVING MY VEHICLE ON THE HIGHWAY MY CAR WOULD NOT ACCELERATE WHEN I PRESSED ON THE GAS. MY RPM'S WENT UP TO 4 AND WOULD DROP DOWN WHEN I LET OFF THE GAS. WITHIN MINUTES MY STEERING WHEEL LOCKED UP AND THE CAR BASICALLY SHUT DOWN. I HAD TO TRY AND DRIFT TO THE SHOULDER IN HIGH SPEED TRAFFIC. WHEN I GOT TO THE SHOULDER THE CAR STARTED SMOKING. I HAD THE CAR TOWED TO MAZDA DEALERSHIP. THEY TOLD ME MY WATER PUMP WENT AND LEAKED FLUID THROUGHOUT THE ENGINE, RESULTING IN ME NEEDING A NEW $8,000 ENGINE. THEY TOLD ME THAT MAZDA DESIGNED THE CX9 WHERE THE WATER PUMP IS IN THE ENGINE BLOCK BEHIND THE TIMING BELT AND IT IS NOT SOMETHING THEY CAN EASILY INSPECT WHEN I BRING MY CAR IN FOR SERVICE. SO WHEN A WATER PUMP GOES ON THESE MAZDA CX-9'S IT RESULTS IN THE CONSUMER NEEDING A WHOLE NEW ENGINE. THEY ALSO STATED THAT THERE ARE NO INDICATORS THAT WILL NOTIFY YOU IF THERE IS A PROBLEM WITH THE WATER PUMP TO AVOID THIS FROM HAPPENING. THE SAFETY ISSUE IS THAT MY CAR WAS ON THE HIGHWAY AT THE TIME THIS OCCURRED WITH VEHICLES GOING AT HIGH SPEEDS. MY CAR BASICALLY SLOWED DOWN SIGNIFICANTLY AND EVENTUALLY STOPPED AND I COULD NOT TURN THE STEERING WHEEL TO BETTER ASSIST ME GETTING OUT OF THE WAY OF THE HIGH SPEED TRAFFIC.

Mileage: 126,100

THE MAZDA CX 9 CUTS OFF WITHOUT WARNING AT TRAFFIC LIGHTS. IT ALSO HAS CUT OFF AT LOW SPEED TURNS. IT RESTART SOME TIMES. SOMETIME IT WILL NOT FOR A FEW MINUTES. BEEN LEFT IN THE MIDDLE LANE OF US 27 SOUTH OF SEBRING FLORIDA AT A TRAFFIC LIGHT STALLED. THE RPM FLUXUATES AT TIMES AND THE VEHICLE SURGES. DANGEROUS SITUATION WHEN IN THE CENTER LANE AND IT JUST CUTS OFF WITH NO WARNING. NO ENGINE CHECK LIGHT OR WARNING PRIOR TO CUTTING OFF.

Mileage: 77,900

MULTIPLE TRIPS TO THE DEALERSHIP AND AN INDEPENDENT MECHANIC AND THE CHECK ENGINE LIGHT (CEL) COMES ON WITH A DIAGNOSIS OF EVAPORATING SYSTEM / LOOSE GAS CAP. MULTIPLE DIAGNOSTICS FEES, A GAS TANK PRESSURE TEST AND 3 GAS CAPS LATER AND THE PROBLEM HAS NOT BEEN FIXED. I NOTICED A FEW ONLINE FORUMS WITH SEVERAL OTHERS COMPLAINING OF THE SAME ISSUE ACROSS A WIDE RAGE OF YEARS AND MAZDA MODELS. THERE IS A DESIGN PROBLEM WITH MAZADA EVAPORATING, FUEL AND EMISSIONS SYSTEMS. THE DEALER CANNOT IDENTIFY THE PROBLEM. BEYOND REPLACING THE GAS CAP AND COLLECTING A DIAGNOSTIC FEE.

Mileage: 40,000

PURCHASED THE VEHICLE NEW FROM DAVIS MOORE MAZDA- WICHITA, KS. FOR THE PAST 4 YEARS WE HAVE EXPERIENCED MULTIPLE ENGINE STALLS AS WELL AS COMPLETE ENGINE STOPPING WHILE DRIVING, CITY, HIGHWAY, TURNING ETC. HAVE HAD THE CAR INTO THEIR SERVICE DEPT. MANY TIMES AND THEY KEEP SAYING IT IS FINE ( THE LAST TIME THEY SAID IT MIGHT BE CAUSED BY HAVING 8 OZ TOO MUCH ENGINE OIL IN IT). WE HAVE LESS THAN 12,000 MILES ON IT TO DATE BECAUSE WE ARE AFRAID TO DRIVE IT. I BELIEVE THIS IS A VERY REAL SAFETY ISSUE. WE HAVE ALL THE PAPERWORK FOR EACH SERVICE DEPT. VISIT. LAST TWO VISITS WE WERE TREATED LIKE WE WERE MAKING THIS STUFF UP. THIS HAS BEEN HAPPENING EVERY YEAR SINCE PURCHASING.

Mileage: 500

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. WHILE DRIVING 20 MPH, THERE WAS A LOUD METAL TO METAL NOISE COMING FROM THE REAR OF THE VEHICLE. IN ADDITION, THE GEARS FAILED TO SHIFT CORRECTLY AND THE OIL AND ENGINE INDICATORS ILLUMINATED. THE DEALER DIAGNOSED THAT THE BRAKES NEEDED TO BE CHANGED. THE BRAKES WERE REPLACED, BUT THE FAILURE RECURRED AND WORSENED. THE CONTACT ALSO SMELLED FUEL COMING FROM THE VEHICLE AND THE VEHICLE HAD TROUBLE ACCELERATING. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 33,000.

Mileage: 33,000

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. THE CONTACT STATED THAT WHILE TRAVELING 15 MPH, THE VEHICLE EXHIBITED DIFFICULTY IN DECELERATING. THE CONTACT HAD TO PUMP THE BREAK PEDAL EXTREMELY HARD IN ORDER TO SLOW THE VEHICLE. THERE WAS A HISSING NOISE THAT SOUNDED THROUGHOUT THE VEHICLE. THE VEHICLE DID NOT DECELERATE UNTIL APPROACHING AN INCLINE. THE CONTACT WAS ABLE TO STOP AT A LOCAL MECHANIC SHOP WHERE THE MECHANIC DIAGNOSED THE THAT THE BRAKE VACUUM BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 55,000.

Mileage: 55,000

I HAVE AN ISSUE WITH THE BRAKE PEDAL MAKING A HISSING SOUND WHEN DEPRESSED, IT FILLS SOFT AND EXTREMELY HARD, WHICH MAKES IT DIFFICULT TO STOP. IF I RELEASE THE BRAKE PEDAL THE ENGINE REVS UP AND DOWN AT LEAST THREE TIMES MAKING THE CAR HESITATE WITH ENGINE CLUNKING AND A FEELING LIKE SOMEONE HITTING YOU FROM BEHIND. IT HAPPENS VERY SUDDEN AND UNSAFE MANNER. I HAD TWO OCCASIONS WHEN A HAD TO PRESS EXTREMELY HARD ON THE BRAKE TO STOP THE CAR. I THINK THAT THERE IS A SERIOUS MECHANICAL DEFECT WITH THE BRAKE SYSTEM AND SHOULD BE IMMEDIATELY ADDRESSED BY MAZDA. I HAD RESEARCHED ON LINE AND THERE ARE NUMBER OF MAZDA CX9 OWNERS WITH SIMILAR COMPLAIN. PLEASE FEEL FREE TO CONTACT ME FOR FURTHER ASSISTANCE WITH THIS MATTER.. SINCERELY. [XXX] [XXX] OR HOME [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) *JS

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 45 MPH, THE VEHICLE STALLED UNEXPECTEDLY. THE VEHICLE NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 35,000.

Mileage: 35,000

I HAVE A MAZDA 2012 THAT SPONTANEOUSLY STALLS WHILE DECELERATING. IT ALSO STALLS PREDICTABLY ON AN INCLINE. MAZDA CORPORATION HAS STATED "THE STALLING ON AN INCLINE IS A CHARACTERISTIC OF ALL CX-9 MODELS" AND ARE NOT WILLING TO FIX IT. THEY HAVE INFORMED ME THAT STALLING WHILE DECELERATING IN MY CAR HAS NOT BEEN ABLE TO BE RECREATED BY THEIR TECH SO THEY ARE DOING NOTHING ABOUT IT. I HAVE BEEN IN TWO NEAR MISS ACCIDENTS. THE CAR LOSES POWER STEERING AND BRAKING AND THE DRIVER HAS LITTLE TO NO CONTROL WHEN IT STALLS. PLEASE WATCH THIS VIDEO OF A BRAND NEW (LOANER FROM THE DEALER WHILE THEY LOOKED AT MY 2012 CX-9) 2013 CX-9 (125 MILES ON IT). THIS IS THE "CHARACTERISTIC" I AM REFERRING TO, PLEASE ADVISE FUTURE BUYERS OF THIS VERY UNSAFE "CHARACTERISTIC". WHEN IT STALLS IN MY DRIVEWAY, I CANNOT BRAKE "SHARPLY" OR EFFECTIVELY ENOUGH TO STOP THE CAR FROM DRIFTING INTO THE ROAD. HTTP://YOUTU.BE/PBZHVIEIHKC. *TR

Mileage: 17,000

INCIDENT -1 TRAVELING ABOUT 45 MPH DECELERATING TO MAKE A RIGHT TURN, THE CAR STALLS OUT LEAVING ME WITH NO CONTROL OF STEERING AND LITTLE ABILITY TO BRAKE. INCIDENT 2- MAKING RIGHT TURN (DECELERATING) CAR STALLS OUT LEAVING ME WITH NO STEERING AND LITTLE BRAKING CONTROL. INCIDENT 3- PULLED UP INTO DRIVEWAY ON SLOPE. PUT THE CAR IN REVERSE TO BACK OUT, CAR STALLED OUT LEAVING ME WITH VERY LITTLE ABILITY TO BRAKE. *TR

Mileage: 12,000

TL* THE CONTACT OWNS A 2012 MAZDA CX-9. THE CONTACT STATED THAT THE VEHICLE WOULD CONSUME EXCESSIVE OIL WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATED. THE CONTACT STATED THAT THE TECHNICIAN MENTIONED THAT THE CONSUMPTION OF OIL WAS UNUSUAL AND COULD CAUSE THE ENGINE TO FAIL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 900 AND THE CURRENT MILEAGE WAS 42,000. *TR

Mileage: 900

I HAD AN INCIDENT YESTERDAY RESULTING IN A MINOR COLLISION. MY ACCELERATOR STUCK, MY ENGINE KEPT REVVING, AND I COULD NOT STOP. I KEPT APPLYING THE BRAKES BUT IT FELT AS IF EVERYTHING LOCKED UP. I REARENDED THE PERSON IN FRONT OF ME NO DAMAGE TO THEIR CAR AND ONLY MINOR TO MINE. I AM NOW AFRAID TO DRIVE THE VEHICLE. MY HUSBAND CONTACTED THE DEALERSHIP AND THEY ARE WAITING TO HEAR BACK FROM MAZDA CORPORATE. *TR

Mileage: 15,049