2018 MAZDA MAZDA6 Problems & Recalls
Detailed safety information and owner complaints
Problem Breakdown
Compare to Other Years
Common Problems
Mazda North American Operations (Mazda) is recalling certain 2018 Mazda3, Mazda6, 2019 CX-3, 2018-2019 MX-5, CX-5, CX-9, and 2019-2020 Mazda2 vehicles. The impeller inside the low-pressure fuel pump ...
Mazda North American Operations (Mazda) is recalling certain 2018-2019 CX-5, Mazda6, and 2019 Mazda3 vehicles. A software error in the powertrain control module (PCM) may cause the engine to stall.
I recently discovered a significant oil leak near the exhaust manifold of my 2018 Mazda 6 (2.5L NA), which has resulted in visible smoke and a burning oil odor. Upon taking the vehicle to the nearest Mazda dealership for a diagnosis, the service department informed me that the vehicle has suffered a...
I recently discovered a significant oil leak near the exhaust manifold of my 2018 Mazda 6 (2.5L NA), which has resulted in visible smoke and a burning oil odor. Upon taking the vehicle to the nearest Mazda dealership for a diagnosis, the service department informed me that the vehicle has suffered a...
Cracked cylinder head causing oil leak and possible coolant leak. This is a known issue with this year and model. Mazda is trying to suggest the issue is only for the turbo engine, but the non-turbo engine is also defective, per countless reports online. I have a video from the service technician fr...
Was driving then car suddenly shut down and all panel lights turned on. The car would not start after an hour it started but was Perkins when driving. Mechanics were unable to diagnose the issue.
Premature caliper failure on front and rear. Ruined rotors at 40k miles, confirmed caliper failure by two service shops. Grinding/squeaking sounds intermittently been happening for since 30,000 miles
The contact owns a 2018 Mazda Mazda6. The contact stated upon taken the vehicle to the dealer for an oil change, the dealer notified the contact of a fuel leak. The dealer diagnosed the vehicle and informed the contact that the top of the fuel tank and bolts connected to the fuel pump were significa...
Mileage: 75,000
Bought used with 47k miles. Two weeks later, took it to my mechanic for an inspection, they found a massive oil leak on the back of the motor. Took it back to the dealership and they diagnosed it as a cracked cylinder head, for which there is a known TSB and warranty extension. Unfortunately, the wa...
I am having my brake pads changed at a local mechanic and when changing the pads, the mechanic was unable to change them because the rotors and calipers were rusted and the brake pistons stuck. The previous recall only considered Mazda 6 up to 2013 but my 2018 has had the same problem.
Software error/loss of engine power. No warning of this before it happens. The car completely loses power, and stalls or stops in the middle of me driving. This has happened on the freeway and risked my life as well as my husbands, and children. This same issue has been a previous recall and fixed i...
Coolant leaks at the cylinder head around the exhaust manifold causing my car to over heat. Also when my thermostat is set to the exact temperature for both sides my driver side blows cold and the passenger side blows hot
Coolant leaks at the cylinder head around the exhaust manifold causing my car to over heat. Also when my thermostat is set to the exact temperature for both sides my driver side blows cold and the passenger side blows hot
Driving in traffic and the engine temperature warning appeared on dash. Dealer has confirmed there is a large coolant leak from the cylinder head. Mazda released a technical service bulletin regarding the issue affecting Mazda6, cx-5 and cx-9, but I will have to pay for a head gasket replacement.
Cracked cylinder head near the exhaust manifold. Created a large oil leak. Oil on the exhaust is a fire hazard. After one quart of oil loss a low oil level light comes on. This is a reported problem. One version of the engine I have has a Mazda TSB and an extended warranty. TSB 01-0022/23 ...
My car has stalled out on me 6 times in traffic and wouldn’t restart for hours. I took it to the Mazda dealership and they told me nothing was wrong but it continues to happen. I need something done as soon as possible
My car has stalled out on me 6 times in traffic and wouldn’t restart for hours. I took it to the Mazda dealership and they told me nothing was wrong but it continues to happen. I need something done as soon as possible
My car has stalled out on me 6 times in traffic and wouldn’t restart for hours. I took it to the Mazda dealership and they told me nothing was wrong but it continues to happen. I need something done as soon as possible
Cracked Cylinder Head. At 50,400 miles. This is far too common of a problem for such a new car with so few miles. I have seen many similar reports online. My mechanic was baffled. This is a $5k cost AT LEAST. Mazda has a history of not covering these defects. And it IS a defect, not a simple wear an...
The contact owns a 2018 Mazda 6. The contact stated that while merging onto a freeway the vehicle did not accelerate while pressing the accelerator pedal, lost automotive power. After turning the engine off and back on the vehicle operated as normal but later while driving approximately 65 MPH the f...
Mileage: 67,000
At less than 95,000 miles, the car suddenly started overheating. Coolant level was fine, maybe ever so slightly low (could still see the coolant in tubing and some in reservoir, which was closer to low than full). Replaced ECT sensor, thermostat and water pump which seemed to fix the issue. Drove...
On [XXX] I purchased a Mazda 6 at Ocean Mazda in Miami, Florida. The car has 18,700 miles. The reason why the car has only 18K miles it's because out of the 4 years we have owned it, it was not used as much as a result of the COVID pandemic and my daughter attending online classes. I have always d...
Noticed slight coolant leak, took car to mechanic, he stated cylinder head was cracked, & causing coolant to spray everywhere. Towed car to dealer. Was given repair estimate of over $11,000, for a new engine. I see a safety bulletin online for my year make & model car. This overheating can apparentl...
Noticed slight coolant leak, took car to mechanic, he stated cylinder head was cracked, & causing coolant to spray everywhere. Towed car to dealer. Was given repair estimate of over $11,000, for a new engine. I see a safety bulletin online for my year make & model car. This overheating can apparentl...
Start engine when cold and it knocks/ taps from the valve cover very loud, found a tab for valve lifters. Mazda said I’m out of warranty and it would be a 2k fix on a car I just bought second hand. A lot of other drivers have experienced the same issue and have even said it’s a safety issues as ...
Mazda has a huge issue with there HLAs hydraulic lash adjusters. I've driven the car for 60k+ miles and it's ticked every since I got the car. And many people in the community also have the issue. And Mazda says it's fine and to rev the car above 3k rpms. This issue needs to be resolved. Before my w...
At 65,000 miles and on time maintenance a head gasket blew.
The engine has developed an oil leak that is a known manufacturing defect of Mazda 2.5 litre engines TSB #SA-031-21. The oil drips on the hot exhaust and sends smoke into the cabin and probably could start a fire. Also if the engine runs out of oil, it will cause the car to shut off and stall in tra...
Cracked Head , not caused by anything I did.
Was at a drive in window and car turned off and couldn't restart. Windows and lights would work but car wouldn't restart. Could of been driving and would of crashed. Had 3 people family in car. It was 9 pm had to have towed to nearest auto mechanic place 150.00. They are diagnosing and that is 186.0...
Was at a drive in window and car turned off and couldn't restart. Windows and lights would work but car wouldn't restart. Could of been driving and would of crashed. Had 3 people family in car. It was 9 pm had to have towed to nearest auto mechanic place 150.00. They are diagnosing and that is 186.0...
Was at a drive in window and car turned off and couldn't restart. Windows and lights would work but car wouldn't restart. Could of been driving and would of crashed. Had 3 people family in car. It was 9 pm had to have towed to nearest auto mechanic place 150.00. They are diagnosing and that is 186.0...
When I put my car on reverse the sensors beep continuously and give the impression that there are obstacles behind your car. I cleaned all the sensors, but noise is still there. I see a lot of posts regarding same issue.
Coolant leaking from head, informed by dealer the cylinder head is cracked and the entire engine needs to be replaced. The engine has just hit 80k miles at this point. This issue caused multiple instances of overheating while driving, one of which caused the vehicle to fail to move forward while on ...
I was driving my car, it overheated. I took it in and was told it needs a new engine. I was told it was not fault of my own why it overheated. It had 2 oil leaks and a blown head gasket.
Due to design issues, the engine cylinder head became cracked after normal everyday usage. Coolant began to leak badly and car engine became hot while driving.
Just noticed my coolant was leaking underneath my car and i went to mazda to check and it came out being a cracked cylinder the car are driven by my daughter from school to work only and has 68k miles, mazda doesn’t want to fix because supposedly the engine warranty only last until 60k
Mazda is producing and installing bad belt tensioner sand bad belts for new cars belt tensioner only lasts about 27,500 miles and belt only lasts 11 month/14,000 miles belt tensioner is a major safety issue
Mazda is producing and installing bad belt tensioner sand bad belts for new cars belt tensioner only lasts about 27,500 miles and belt only lasts 11 month/14,000 miles belt tensioner is a major safety issue
Timing chain cover leak
The contact owns a 2018 Mazda Mazda6. The contact stated that he had experienced a transmission surged on five separate occasions since owning the vehicle. There were no warning lights illuminated. The contact had taken the vehicle to the dealer after each failure and various unknown repairs and so...
Mileage: 10,000
The contact owns a 2018 Mazda Mazda6. The contact stated that he had experienced a transmission surged on five separate occasions since owning the vehicle. There were no warning lights illuminated. The contact had taken the vehicle to the dealer after each failure and various unknown repairs and so...
Mileage: 10,000
Took care for routine maintenance to car dealer (Ourisman Mazda Rockville MD). No problems with car. They reported that I had an 'Coolant Leak at the Cylinder Head'. Cost to fix: $6412.47 They reported that it was 'normal wear and tear'. I found a service bulletin from Mazda whereby they admit ...
The contact owns a 2018 Mazda Mazda6. The contact received notification of NHTSA Campaign Number: 21V875000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The dealer was made aware of the issue; however, the contact was informed that the parts were not yet a...
Mileage: 49,000
Hello, I contacted Fremont mazda dealer to fix the below recall. I booked multiple appointment with this dealer to fix the recall but after visiting there service center location they give me reason they are unable to fix it by saying they don't have a part required for fixing the recall Manufactu...
The contact owns a 2018 Mazda Mazda6. The contact stated that while driving at low speeds, the vehicle would hesitate upon the depression of the accelerator pedal without warning. The contact then received notification of NHTSA Campaign Number: 21V875000 (Fuel System, Gasoline) however, the part to ...
Mileage: 27,000
I took my car in for scheduled maintenance and the technicians at the Mazda dealer found out the tensioner and belt needed to be replaced, when the car is less than 36k in miles. Vehicles being repaired under warranty but a tensioner should not be going out this early in the lifespan of a 2 year old...
I took my car in for scheduled maintenance and the technicians at the Mazda dealer found out the tensioner and belt needed to be replaced, when the car is less than 36k in miles. Vehicles being repaired under warranty but a tensioner should not be going out this early in the lifespan of a 2 year old...
I took my car in for scheduled maintenance and the technicians at the Mazda dealer found out the tensioner and belt needed to be replaced, when the car is less than 36k in miles. Vehicles being repaired under warranty but a tensioner should not be going out this early in the lifespan of a 2 year old...
After only 3 years and less than 17,000 miles of driving, the soul red crystal metallic paint is chipping in many spots on the front of the body. There are at least 100 small chips on the hood, bumper, and front fenders. All of this occurred under normal driving conditions.
THE DRIVER SIDE MIRROR VIBRATES AT HIGHWAY SPEEDS MAKING IT EXTREMELY HARD TO SEE WHAT'S IN THE GLASS.
Mileage: 15,000
THE FRONT AND REAR SUSPENSION POPS, CLUNKS, THE VEHICLE SHAKES, VIBRATION ALSO HAPPENS, IT ALSO CAUSING TIRES TO BE REPLACED FASTER THAN NORMAL THEY GO BOLD IN THE CENTER ITS CAUSING NOW THE AXLES TO SHAKE AT NIGHT TIME YOU CAN SEE THE REFLECTION FROM HEADLIGHTS BOUNCING, THEY HAVE TSB'S ON THIS SUS...
Mileage: 400
THE FRONT AND REAR SUSPENSION POPS, CLUNKS, THE VEHICLE SHAKES, VIBRATION ALSO HAPPENS, IT ALSO CAUSING TIRES TO BE REPLACED FASTER THAN NORMAL THEY GO BOLD IN THE CENTER ITS CAUSING NOW THE AXLES TO SHAKE AT NIGHT TIME YOU CAN SEE THE REFLECTION FROM HEADLIGHTS BOUNCING, THEY HAVE TSB'S ON THIS SUS...
Mileage: 400
THE FRONT AND REAR SUSPENSION POPS, CLUNKS, THE VEHICLE SHAKES, VIBRATION ALSO HAPPENS, IT ALSO CAUSING TIRES TO BE REPLACED FASTER THAN NORMAL THEY GO BOLD IN THE CENTER ITS CAUSING NOW THE AXLES TO SHAKE AT NIGHT TIME YOU CAN SEE THE REFLECTION FROM HEADLIGHTS BOUNCING, THEY HAVE TSB'S ON THIS SUS...
Mileage: 400
I WAS DRIVING ON A STREET AND MY CHECK ENGINE LIGHT, TCS/DSC LIGHT, SBS/SCBS LIGHT, MRCC LIGHT, AND WARNING LIGHT APPEARED ON MY DASHBOARD. MY CAR THEN STARTED PUTTING OR JERKY. IT FELT AS MY CAR WAS VERY WEAK AS IF IT WAS GOING TO GIVE OUT. THIS IS THE THIRD TIME THESE SAME MALFUNCTIONS APPEARED. E...
Mileage: 26,198
MY MAZDA6 SPONTANEOUSLY CAUGHT ON FIRE WHILE IT WAS PARKED ON A STREET AND COMPLETELY BURNED DOWN. THE FAULT/PROBLEM CAUSE IS UNKNOWN AT THIS TIME BUT I SUSPECT THERE WAS WIRING/ELECTRICAL FAULT AND MANUFACTURING AND DESIGN DEFECT. BOTH THE SHERIFF'S DEPARTMENT AND FIRE DEPARTMENT WERE INVOLVED IN A...
MY MAZDA6 SPONTANEOUSLY CAUGHT ON FIRE WHILE IT WAS PARKED ON A STREET AND COMPLETELY BURNED DOWN. THE FAULT/PROBLEM CAUSE IS UNKNOWN AT THIS TIME BUT I SUSPECT THERE WAS WIRING/ELECTRICAL FAULT AND MANUFACTURING AND DESIGN DEFECT. BOTH THE SHERIFF'S DEPARTMENT AND FIRE DEPARTMENT WERE INVOLVED IN A...
MY MAZDA6 SPONTANEOUSLY CAUGHT ON FIRE WHILE IT WAS PARKED ON A STREET AND COMPLETELY BURNED DOWN. THE FAULT/PROBLEM CAUSE IS UNKNOWN AT THIS TIME BUT I SUSPECT THERE WAS WIRING/ELECTRICAL FAULT AND MANUFACTURING AND DESIGN DEFECT. BOTH THE SHERIFF'S DEPARTMENT AND FIRE DEPARTMENT WERE INVOLVED IN A...
AFTER LESS THAN A YEAR OF LEASING THIS VEHICLE, AN ABUNDANCE OF ROCK CHIPS HAVE SHOWN UP, MORE THAN ANY OTHER CAR I'VE LEASED. THIS PAINT SEEMS EXTREMELY SUSCEPTIBLE TO FOREIGN OBJECTS. (THIS WOULD BE THE SOUL RED COLOR THEY USE.) ITEMS THAT SHOULDN'T CAUSE A SCRATCH DO, AND ROAD DEBRIS CAUSES CHIPS...
Mileage: 8,000
I GOT THIS CAR IN MAY OF 2019 SO THE CAR IS STILL NEW AND EVER SINCE I PURCHASED THE VEHICLE I'VE BEEN HAVING ISSUES WITH IT FIRST WERE THE CALIPERS STICKING AND MAZDA GAVE ME A HARD TIME TO REPAIR THE ISSUE AFTER THE FACT KNOWING THAT IT WAS A MANUFACTURING ISSSUE AND STILL TRIED TO CHARGE ME I TOO...
Mileage: 11,000
I GOT THIS CAR IN MAY OF 2019 SO THE CAR IS STILL NEW AND EVER SINCE I PURCHASED THE VEHICLE I'VE BEEN HAVING ISSUES WITH IT FIRST WERE THE CALIPERS STICKING AND MAZDA GAVE ME A HARD TIME TO REPAIR THE ISSUE AFTER THE FACT KNOWING THAT IT WAS A MANUFACTURING ISSSUE AND STILL TRIED TO CHARGE ME I TOO...
Mileage: 11,000
I GOT THIS CAR IN MAY OF 2019 SO THE CAR IS STILL NEW AND EVER SINCE I PURCHASED THE VEHICLE I'VE BEEN HAVING ISSUES WITH IT FIRST WERE THE CALIPERS STICKING AND MAZDA GAVE ME A HARD TIME TO REPAIR THE ISSUE AFTER THE FACT KNOWING THAT IT WAS A MANUFACTURING ISSSUE AND STILL TRIED TO CHARGE ME I TOO...
Mileage: 11,000
TL* THE CONTACT OWNS A 2018 MAZDA 6. WHILE THE CONTACT'S FRIEND WAS DRIVING 55 MPH, HE VEERED OFF THE SIDE OF THE ROAD INTO A DIRT PATCH, AND STRUCK AN OBJECT. THE AIR BAGS DEPLOYED AND THE DRIVER'S SEAT BELT UNBUCKLED UPON IMPACT. THE AIR BAG DEPLOYMENT BURNED THE CONTACT'S RIGHT UNDERARM. MEDICAL ...
Mileage: 18,000
VEHIXLE HAS OPEN RECALL #3719F. TOOK VEHICLE IN FOR SERVICE ON JULY 15 AND ACCORDING TO NHTSA RECALL HAS EVEN OUT SINCE JUNE 27.2019. TO THIS DAY I HAVE NOT GOTTEN ANY LETTER OR ANYTHING STATING CAR HAS OPEN RECALL WHEN THE CAR CAN TURN OF RANDOMLY. WILL BE TAKING CAR IN ON 08/26/19 BUT I'M CONCERN...
Mileage: 7,200
VEHIXLE HAS OPEN RECALL #3719F. TOOK VEHICLE IN FOR SERVICE ON JULY 15 AND ACCORDING TO NHTSA RECALL HAS EVEN OUT SINCE JUNE 27.2019. TO THIS DAY I HAVE NOT GOTTEN ANY LETTER OR ANYTHING STATING CAR HAS OPEN RECALL WHEN THE CAR CAN TURN OF RANDOMLY. WILL BE TAKING CAR IN ON 08/26/19 BUT I'M CONCERN...
Mileage: 7,200
WHILE MERGING ONTO THE FREEWAY ON MY WAY HOME FROM WORK, THE SUNROOF EXPLODED. I WAS DRIVING STRAIGHT ON THE FREEWAY WITH LIGHT TRAFFIC AT APPROXIMATELY 70 MPH. I DID NOT SEE ANY DEBRIS OR ROCKS AND AFTER STOPPING DID NOT FIND ANY DEBRIS OR SIGNS OF ANYTHING HAVING HIT THE GLASS. THERE WAS JUST A...
Mileage: 1,823
I MADE A STOP AT A TRAFFIC LIGHT AND THE GREEN LIGHT CHANGE I PRESSED THE GAS AND THE MAZDA6 STALLED AND THEN DRAGGED TO TAKE OFF WHICH ALMOST CAUSED AN ACCIDENT.
Mileage: 3,200
I MADE A STOP AT A TRAFFIC LIGHT AND THE GREEN LIGHT CHANGE I PRESSED THE GAS AND THE MAZDA6 STALLED AND THEN DRAGGED TO TAKE OFF WHICH ALMOST CAUSED AN ACCIDENT.
Mileage: 3,200
EXCESSIVE PAINT CHIPPING. KNOW PROBLEM. NORMAL, EVERYDAY DRIVING; NO ROCKY ROADS, GRAVEL TRUCKS, ETC.
Mileage: 11,400
2018 MAZDA 6. CONSUMER WRITES IN REGARDS TO DEFECTIVE RADIO. *LD *TR
2018 MAZDA 6. CONSUMER WRITES IN REGARDS TO DEFECTIVE RADIO. *LD *TR