2002 MERCEDES BENZ C230 Electrical System Problems

There is an old recall campaign for the Camshaft Seal, # 2009100001. This car is among those affected by this problem and should be covered for issues and repairs.

TAKATA RECALL ESL (ELECTRIC STEERING LOCK) COMPONENTS THE MOTOR FAILS TO UNLOCK THE STEERING THE FIRST TIME, BUT WORK IN FOLLOWING ATTEMPTS. SOME TIMES IT TAKES 1 TO 4 HOURS FOR ESL TO UNLOCK. THIS HAPPENS ONLY WHEN THE VEHICLE IS PARKED WEATHER OVERNIGHT OR JUST COMING OUT OF THE STORE SHOPPING.

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ C230. WHILE DRIVING BETWEEN 15-20 MPH, THE VEHICLE FAILED TO ACCELERATE. WHILE DEPRESSING THE ACCELERATOR PEDAL, THE ABS AND CHECK ENGINE WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE WIRE HARNESS MELTED AND NEEDED REPLACEMENT. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.

Mileage: 12,000

THE POWER SEAT MODULES CONTINUOUSLY DRAIN THE BATTERY CAUSING DEAD BATTERY WITHIN 24-48 HOURS. THE SEATS MUST BE UNPLUGGED TO STOP THE PROBLEM. MERCEDES DEALERSHIP WANTS $100 TO DIAGNOSE AND $1,500 PER SEAT MODULE. THERE ARE HUNDREDS OF PEOPLE ONLINE WITH THE SAME PROBLEM MAKING THIS A DEFECT. *TR

Mileage: 50,000

BOTH FRONT POWER SEAT MODULES DRAIN BATTERY WHEN CAR IS OFF. *TR

Mileage: 70,000

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ C 230. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE THE MECHANIC ADVISED THAT THE FUEL PUMP WIRING AND SEVERAL OTHER WIRES WERE BURNED. THE MECHANIC ADVISED THAT IF THE FUEL TANK HAD BEEN FULL OF GASOLINE, THE VEHICLE WOULD HAVE CAUGHT ON FIRE. THE MECHANIC WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE MANUFACTURER ADVISED THE FAILURE WAS NOT CONSIDERED A SAFETY ISSUE AND WOULD NOT PROVIDE ANY ASSISTANCE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 99,000.

Mileage: 99,000

WHILE DRIVING ON HIGHWAY OUT OF STATE AT APPROX. 60MPH CAR SUDDENLY BUCKED AND ALL POWER CUT OUT, ALL LIGHTS ON CONTROL PANEL LIT UP- HIT CLUTCH AND GAS, VEHICLE RESTARTED. NEAREST DEALER WOULD NOT SEE ME FOR 2 WEEKS, DEALER IN ANOTHER STATE DID DIAGNOSTIC ESTIMATED REPAIR AT CLOSE TO $4,000; ALREADY GAVE OVER $1800 AS DOWNPAYMENT TOWARD PARTS. REPAIR ? SCHEDULED FOR NEXT WEEK. READ OTHER COMPLAINTS, BELIEVE MANUFACTURER SHOULD TAKE SOME RESPONSIBILITY HERE, AND WANT REASSURANCE IF REPAIR DOES NOT WORK I WILL NOT BE CONTINUOUSLY CHARGED WHILE THEY REPLACE EVERYTHING UNTIL THE GET IT RIGHT. SAID COMPUTER DID NOT READ A DEFECT. CAR HAS BEEN SERVICED BY DEALERS ONLY AT EVERY RECOMMENDED SERVICE MILESTONE. *TR

Mileage: 56,000

MY 2002 MERCEDES C230 KOMPRESSOR KEEPS DRAINING THE BATTERY. I HAVE HAD THE BATTERY AND THE ALTERNATOR REPLACED. NO ONE, INCLUDING THE DEALER CAN DETERMINE WHAT IS CAUSING THE DRAIN. ONLINE FORUMS FROM MERCEDES OUTLINE THAT THIS IS A REGULAR ISSUE THAT MERCEDES IS AWARE OF, BUT NO RECALL HAS BEEN ISSUED. *JB

Mileage: 43,000

ERROR MESSAGE APPEARING ON MY INSTRUMENT CLUSTER DISPLAY STATING THAT "UNDER VOLTAGE CONSUMER DEFECTIVE!" ALONG WITH A "BATTERY/ALTERNATOR VISIT WORKSHOP" ERROR. TAKING THE CAR TO A SERVICE STATION INDICATES THAT THE VOLTAGE REGULATOR IS FAULTY. CURRENTLY THERE IS A RECALL FOR ALL MERCEDES MODELS EXCEPT MINE IN THE USA. EVENTUALLY THE BATTERY BECAME DISCHARGED. *JB

Mileage: 47,320

THE CONSUMER STATES THAT WHILE DRIVING ONTO A RAMP, THE ELECTRONIC STABILITY PROGRAM HAD FUNCTION ERRATICALLY. THE CONSUMER APPLIED THE RIGHT REAR BRAKES CAUSING THE VEHICLE TO DRIVE INTO THE CURB. THE CONSUMER FEELS THAT THIS DEFECTIVE PART IS LIFE THREATENING. SCC

THE C230 COUPE SHUT OFF WHILE ON HIGHWAY

Mileage: 2,000

I HAVE TAKEN MY VEHICLE IN FOR REPEATED REPAIR: 1-7-02 TO 1-14-02, 2-14-01 TO 2-19-02, 3-4-02 TO 3-7-02, 5-2-02 TO 5-3-02, 5-21-02 TO 5-28-02, AND THE DEALER HAS NOT FIXED THE PROBLEM WITH THE CAR SHUTTING OFF ON ME. THERE IS AN ELECTRICAL PROBLEM, BECAUSE THE CAR WUILL SHUT OFF ON THE HIGHWAY, IN TRAFFIC, GOING UP A HILL, THEN THE DASHBOARD WILL LIGHT UP, MENTIONING SYSTEM FAILURE. I HAVE USED THE SOS BUTTON IN MY CARE REPEATEDLY TO GET HELP, BUT THAT IS STILL NOT GOOD ENOUGH. I HAVE ALSO CONTACTED MERCEDES BENZ USA, AND MERCEDES IN STUTTGART GERMANY. I HAVE PUT THEM ON NOTICE TO PURCHASE THE CAR BACK FROM ME, AND THEY HAVE A WEEK AND A HALF LEFT TO RESPOND. I TRY TO NOT TO DRIVR THE CAR A LOT, WHICH DEFEATS THE PURPOSE OF PURCHASING A NEW VEHICLE, BUT FRANKLY, I AM SCARED THAT SOMETHING MIGHT HAPPEN, BECAUSE IT HAS SHUT OFF ON ME ON I75 GOING 60 PLUS MILES AN HOUR. IT IS CERTAINLY A SAFETY HAZARD.*AK