1999 MERCEDES BENZ E CLASS Suspension Problems

WHILE DRIVING CAR ON A LOCAL EXCURSION OF APPROXIMATELY 30 MILES, I NOTICED THAT THE STEERING WHEEL NO LONGER LINED UP STRAIT. TOWARD THE END OF THE TRIP, I NOTED WHAT SEEMED LIKE STEERING IRREGULARITIES, THEN A RUBBING/ WHINING NOISE COMING FROM THE FRONT LEFT. AFTER ARRIVING HOME AFTER DARK, I COULD SMELL HOT RUBBER. ALSO THE LEFT FRONT TIRE WAS HOT TO THE TOUCH. THE NEXT MORNING, I REMOVED MY FRONT LEFT TIRE TO INSPECT THE AREA. I FOUND THE END OF THE LOWER CONTROL ARM CRACKED OPEN FROM THE BOTTOM AND BENT UPWARD. THE CONTROL ARM IS HOLLOW AND APPEARED TO HAVE RUSTED FROM THE INSIDE OUT, WHICH APPARENTLY CAUSED THE FAILURE. THE LOWER BALL JOINT WAS BENT INWARD AND THE DRIVERS SIDE FRONT OF THE CAR WAS LOWER THAN THE PASSENGER SIDE. DURING MY TRAVELS, I HAD NOT HIT ANY BUMPS TO CAUSE SUCH DAMAGE. HAD THIS BROKEN ALL THE WAY THROUGH, I WOULD LIKELY HAVE LOST CONTROL OF THE VEHICLE. I FEEL VERY LUCKY. AFTER AN ONLINE SEARCH, I FOUND TWO OTHER INCIDENTS OF THIS HAPPENING IN THIS MODEL MERCEDES. ALSO, MY INDEPENDENT MERCEDES REPAIR SHOP HAS SEEN THIS FAILURE BEFORE. *TR

Mileage: 150,000

TL* THE CONTACT OWNS A 1999 MERCEDES BENZ E55. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT HEARD A LOUD POPPING NOISE OUTSIDE OF THE VEHICLE. SUDDENLY, THE STEERING WHEEL BEGAN TO TURN TO THE RIGHT AND THE FRONT PASSENGER SIDE OF THE VEHICLE COLLAPSED ONTO THE GROUND. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER, WHO STATED THAT THE PASSENGER SIDE UPPER SPRING PERCH FRACTURED, WHICH RESULTED IN A SEPARATION FROM THE FRAME. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE DEALER REGARDING THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.

Mileage: 125,000

I OWN A 1999 MERCEDES BENZ E55 AMG (W210). AFTER PARKING THE CAR WHILE GROCERY SHOPPING, I RETURNED AND FOUND THE FRONT OF THE VEHICLE MUCH LOWER THAN NORMAL. UPON FURTHER INSPECTION, THE DRIVER'S SIDE FRONT COIL SPRING AND TWO OTHER PARTS WERE FOUND LYING UNDER THE VEHICLE. I MOVED THE VEHICLE SLIGHTLY TO LOOK FOR ADDITIONAL BROKEN PARTS AND WAS ABLE TO DRIVE HOME AT 15 MPH, MAKING ONLY VERY MINOR TURNS (FOR APPROXIMATELY 1/4 MILE). UPON INSPECTION WITH THE WHEEL OFF, THE UPPER SPRING PERCH HAD BECOME ALMOST COMPLETELY SEPARATED FROM THE FRAME RAIL, SEVERED THE ABS SENSOR WIRE (WHICH CAUSED SEVERAL WARNING CODES RELATED TO THE ABS, BAS AND ESP BRAKING SYSTEMS), AND HAD ALSO CHIPPED THE INNER RIM OF THE WHEEL AND PUT A VERY LARGE SLASH NEAR THE BEAD OF THE TIRE. I HAD JUST INSPECTED THE PASSENGER SIDE THE WEEK PRIOR WHILE CHANGING A FLAT TIRE, AND WITNESSED NO CORROSION/RUST WHATSOEVER. VEHICLE HAS 90,000 MILES, HAS NOT BEEN DRIVEN IN THE WINTER, AND THE ONLY RUST ON THE VEHICLE IS WHERE THE SPRING PERCH TORE AWAY FROM THE FRAME RAIL. THE REST OF THE CAR, BODY AND UNDERCARRIAGE, IS RUST FREE. I CONTACTED MY LOCAL MERCEDES BENZ DEALER AND WAS OFFERED NO HELP, AND STRONGLY DISCOURAGED AGAINST THERE BEING ANYTHING THAT WOULD BE DONE FOR ME, AS IF THEY WERE READING A SCRIPT RELATING TO THE AGE OF THE CAR AND LOCATION/CLIMATE. I IMMEDIATELY CONTACTED MB USA, WHO IS CURRENTLY INVESTIGATING THE CLAIM. *TR

Mileage: 90,000

FRONT SPRING SUPPORT FAILED ON 2000 MERCEDES E300 WHILE DRIVING ON THE HIGHWAY. THE COIL SPRING WAS EJECTED AND COULD HAVE PUNCTURED THE FRONT TIRE. CAUSE WAS DETERMINED TO BE A RUST AT THE WELD POINTS FOR THE UPPER CONSTRAINT FOR THE FRONT COIL SPRING. *TR

ON APRIL 27, 2008 MY CAR'S FRONT LEFT SIDE SPRING FAILED WHEN DRIVING BACK HOME AT A SPEED OF 30 MPH. IF I HAD BEEN DRIVING ON THE FREEWAY, I MAY HAVE LOST CONTROL AND GOT INTO AN ACCIDENT. WHEN THE PERCH RIPPED OFF, IT SOUNDS LIKE MY WHEEL CAME OFF. THE STEERING WAS JAMMED AND I PULLED OVER TO THE SHOULDER AND FOUND THE SPRING ON THE PAVEMENT. ON MAY 3, 2008 I DROVE TO NEAREST AUTO SHOP WHICH IS ABOUT 2 MILES AWAY AND PAID $80 FOR AN INITIAL CHECK UP AND THEY FOUND OUT THAT THEY COULDN'T FIX IT. THE SPRING PERCH RUSTED AWAY AND BROKE. I COMPLAINED WITH MERCEDES BENZ USA AND I DID NOT GET ANY ANSWER FROM THEM. IT'S BEEN IN MY GARAGE FOR FIVE MONTHS. *TR

Mileage: 99,059

ON APRIL 27, 2008 MY CAR'S FRONT LEFT SIDE SPRING FAILED WHEN DRIVING BACK HOME AT A SPEED OF 30 MPH. IF I HAD BEEN DRIVING ON THE FREEWAY, I MAY HAVE LOST CONTROL AND GOT INTO AN ACCIDENT. WHEN THE PERCH RIPPED OFF, IT SOUNDS LIKE MY WHEEL CAME OFF. THE STEERING WAS JAMMED AND I PULLED OVER TO THE SHOULDER AND FOUND THE SPRING ON THE PAVEMENT. ON MAY 3, 2008 I DROVE TO NEAREST AUTO SHOP WHICH IS ABOUT 2 MILES AWAY AND PAID $80 FOR AN INITIAL CHECK UP AND THEY FOUND OUT THAT THEY COULDN'T FIX IT. THE SPRING PERCH RUSTED AWAY AND BROKE. I COMPLAINED WITH MERCEDES BENZ USA AND I DID NOT GET ANY ANSWER FROM THEM. IT'S BEEN IN MY GARAGE FOR FIVE MONTHS. *TR

Mileage: 99,059

ON APRIL 27 2008 MY CAR'S FRONT LEFT SIDE SPRING PERCH FAILED WHEN DRIVING HOME AT A SPEED OF 30MPH. IF I HAD BEEN DRIVING ON THE FREEWAY, I MAY HAVE LOST CONTROL AND GOT INTO AN ACCIDENT. WHEN THE PERCH RIPPED OFF, IT SOUNDED LIKE MY WHEEL CAME OFF. THE STEERING WAS JAMMED AND I PULLED OVER TO THE SHOULDER AND FOUND THE SPRING ON THE PAVEMENT. IT HAPPENED WHEN I WAS DRIVING BACK HOME. ON MAY 3, I DROVE TO THE NEAREST AUTO SHOP WHICH IS ABOUT 2 MILES AWAY AND PAID $80 FOR AN INITIAL CHECK UP AND THEY FOUND OUT THAT THEY COULDN'T FIX IT. THE SPRING PERCH RUSTED AWAY AND BROKE. I HAVE HAD 4 MERCEDES SO FAR, 1984 300D, 1987 SEL 420, 1991 300D AND THIS 1999 E300D. I'VE NEVER HAD ANY PROBLEMS WITH THE SPRING PERCHES WITH THE 3 OLDER MODELS BUT, THIS 1999 E300D HAD THIS PROBLEM. THIS 1999 E300D WILL BE THE LAST MERCEDES I WILL EVER OWN. *TR

Mileage: 99,059

TL*THE CONTACT OWNS A 1999 MERCEDES BENZ E CLASS. ON AUGUST 27, 2007, WHILE DRIVING 10 MPH, THE CONTACT HEARD A LOUD CLUNKING NOISE COMING FROM THE VEHICLE. HE DECELERATED AND NOTICED THAT THE DRIVER SIDE HOOD APPEARED LOWER TO THE GROUND THAN THE PASSENGER SIDE. HE PULLED OVER AND NOTICED A COIL SPRING ROLLING ACROSS THE ROAD. THE VEHICLE WAS TOWED. HE STATED THAT HE DID NOT DRIVE OVER ANYTHING THAT MAY HAVE CAUSED THE FAILURE. THE DEALER STATED THAT THE FRONT SPRING PERCH MOUNT WAS RUSTED AND SHEARED OFF OF THE VEHICLE. THE VEHICLE IS NOT UNDER WARRANTY AND HAS NOT BEEN REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 120,000.

Mileage: 120,000

PURCHASED A USED 1999 MERCEDES BENZ E300 TURBO DIESEL END OF FEB 2006 WITH 92,494 MILES FROM A JAGUAR/LAND ROVER DEALER. TRADED IN A 1985 MERCEDES BENZ 300 TURBO DIESEL. BROUGHT CAR TO THE MECHANIC THAT DOES ALL MY WORK TO HAVE ALL FLUIDS CHANGED AND THE CAR CHECKED. MECHANIC CALLED TO RECOMMEND I NOT DRIVE THE CAR UNTIL THE LEFT FRONT SPRING CAP WAS REPLACED. I VISITED THE MECHANIC AND VIEWED THE LEFT FRONT SPRING CAP. WHEN THE MECHANIC PUT HIS FINGER ON THE LEFT FRONT SPRING CAP HIS FINGER NAIL CHIPPED OFF FLAKES OF METAL IT WAS ENOUGH TO CONVINCE ME NOT TO DRIVE THE CAR UNTIL IT WAS REPAIRED. MY CONCERN WAS THAT THE LEFT FRONT WHEEL WOULD COME OFF AND CAUSED A SERIOUS ACCIDENT INCLUDING POSSIBLE DEATHS IF THE SPRING CAP PARTED AND THE SPRING CAME OFF AT HIGHWAY SPEEDS. I PAID MY MECHANIC TO INSTALL A NEW FRONT SPRING CAP TO PREVENT A FAILURE. I DID NOT BRING THIS TO THE JAGUAR/LAND ROVER'S DEALER OR MERCEDES BENZ'S ATTENTION BECAUSE TO MY KNOWLEDGE THE CAR WAS NOT UNDER WARRANTY AND I NEEDED THE CAR REPAIRED SO I COULD USE IT. LATTER REVIEW OF THE MERCEDES BENZ CLUB OF AMERICA WEB SITE FORUMS SHOWED THAT THIS IS A COMMON PROBLEM WITH THE E300/320 MERCEDES BENZ AS THE BODY IS THE SAME (MERCEDES BODY DESIGNATION IS W210). *JB

Mileage: 94,663

FAIL OF SPRING PERCH ON 1999 MERCEDES E-CLASS DUE TO POOR MANUFACTURING PROCESS POSSIBLE RESULTING IN FATAL INJURY. *JB

Mileage: 7,500