2002 MERCEDES BENZ ML500 Problems & Recalls

Motor vehicle accident head on and the airbags did not deploy.

There is a serious defect in the YAW rate sensors in these Mercedes ML W163's. Thank God I was driving down a secluded road and nobody was behind me, but my vehicles brakes locked up, on their own, even with my foot on the accelerator pedal, with no warning lights or warning signals. I have no err...

TL* THE CONTACT OWNS A 2002 MERCEDES-BENZ ML500. WHILE DRIVING 45 MPH, THE VEHICLE ACCELERATED AND THE LOW RANGE WARNING INDICATOR ILLUMINATED. THE CONTACT PULLED THE VEHICLE OVER AND TURNED OFF THE ENGINE. ONCE RESTARTED, THE VEHICLE OPERATED NORMALLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHAN...

Mileage: 201,000

HOUSE FROM POWER STEERING POMP IS LEAKING , DURING DRIVE I LOOSE POWER STEERING FLUID AND ALMOST I HIT CAT FROM ANOTHER LINE.

Mileage: 10,070

THIS WAS THE 3RD TIME IT HAPPENED, THIS TIME ON THE FREEWAY IN CALIFORNIA AND LASTED UNTIL THE CAR CAME TO A STOP. THE CAR WENT INTO BREAK MODE ON ITS OWN, THE CAR FISHTAILED AND CAME TO A STOP BEFORE RECOVERING. LUCKILY THE CAR BEHIND ME WAS ABLE TO STOP, I HEARD BREAKS SCREECHING, BUT NO KNOWN C...

Mileage: 150,000

I, 12 YEARS AGO WAS DRIVING MY ML 500 MERCEDES ON US 23 BETWEEN ANN ARBOR, MICHIGAN AND SYLVANIA, IN OHIO. MY CAR SUDDENLY LOST ALL POWER. I FORTUNATELY WAS ABLE TO SWERVE TO THE RIGHT AND THE CAR STOPPED. THIS OCCURRED TWICE. I HAVE SINCE SOLD MY CAR SEVERAL YEARS AGO. I CALLED MY DEALERSHIP ...

Mileage: 50,000

POWER STEERING FLUID LEAKING IN SMALL DRIPS WHEN PARKED. HARD TO STEER AT TIMES AND MAKES LOUD NOISE. HAVE CONCERNS THAT STEERING MAY BE AFFECTED AND CAUSE TOTAL LOSS OF STEERING. *TR

Mileage: 169,700

TL* THE CONTACT OWNS A 2002 MERCEDES ML500. WHILE DRIVING AT NIGHT AT ANY SPEED, THE CONTACT NOTICED AN OPTICAL DISTORTION ON THE REAR VIEW MIRROR WHICH AFFECTED HIS VISIBILITY OF THE VEHICLES LOCATED IN THE REAR. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED...

Mileage: 97,000

TL* THE CONTACT OWNS A 2002 MERCEDES BENZ ML 500. THE VEHICLE WAS REPAIRED BY AN AUTHORIZED DEALER UNDER THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 08V465000 (STEERING: HYDRAULIC POWER ASSIST: HOSE, PIPING, AND CONNECTIONS). WHEN RECEIVING THE VEHICLE FROM THE AUTHORIZED DEALER, THE CONT...

Mileage: 100,726

2002 MERCEDES BENZ ML 500. CONSUMER WRITES REGARDING VEHICLE BRAKE FAILURE *TGW THE CONSUMER STATED THE BRAKES FAILED ON THE VEHICLE DUE TO THE BRAKE LINES LEAKING. *JB

WHILE DRIVING AT 70 MPH WITH CRUISE CONTROL ON ESP/BAS LIGHT CAME ON. CRUISE CONTROL FAILED TO DISENGAGE WHEN BRAKE PEDAL PUSHED TO SLOW VEHICLE, CAUSING ENGINE TO RACE FORCING VEHICLE TO SPEED UP ALMOST CRASHING INTO VEHICLE AHEAD. CRUISE CONTROL COULD ONLY BE DISENGAGED BY PUTTING TRANSMISSION INT...

Mileage: 110,500

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ ML500. THE CONTACT STATED THAT THE VEHICLE WOULD NOT START AND AN HOUR LATER, HE WAS ABLE TO RESTART THE VEHICLE. A LOCAL MECHANIC STATED THAT THE CRANK SHAFT SENSOR CAUSED THE FAILURE. THE CONTACT IS CONCERNED ABOUT THE SAFETY RISK AND THAT THERE ARE NO RELA...

Mileage: 117,000

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ ML500. THE CONTACT STATED THAT THE BRAKE LIGHT SWITCH FAILED. THE FAILURE OCCURS CONSTANTLY AND PREVENTS HIM FROM SHIFTING OUT OF PARK. THE FAILURE HAS OCCURRED APPROXIMATELY ELEVEN TIMES. THE DEALER CONTINUED TO REPLACE THE STOP LIGHT SWITCH INSTEAD OF R...

Mileage: 9,000

MY CAR LOST ALL OF THE POWER STEERING FLUID AND I ALMOST HAD AN ACCIDENT. I LOST ALMOST ALL STEERING CONTROL. IT IS RELATED TO MERCEDES BENZ RECALL #2003-040005. I RECEIVED A LETTER ABOUT THIS RECALL AND IT SAID MY CAR HAD ALREADY BEEN FIXED. THEY SAID THAT IS WHAT THEIR RECORDS SHOW. THAT IS N...

Mileage: 135,257

TL*THE CONTACT OWNS A 2002 MERCEDES BENZ ML500. THE CONTACT STATED THAT THE SEAL IN THE POWER STEERING PUMP FAILED AND THE VEHICLE BEGAN TO LOSE FUEL. THE REPAIR SHOP REPLACED THE POWER STEERING PUMP AT THE COST OF $525.22. THE VEHICLE WAS REPAIRED ACCORDING TO A RECALL FIVE YEARS PRIOR TO THIS F...

Mileage: 40,752

IN MARCH OF 2003 MERCEDES INITIATED A RECALL FOR MY VEHICLE FOR A PROBLEM WITH THE POWER STEERING HOSE, THE CAR WAS TAKEN IN FOR SERVICING AND THE PROBLEM SUPPOSEDLY FIXED. ON APRIL 2ND OF 2008 I TOOK THE CAR TO MERCEDES BECAUSE IT WAS MAKING A REALLY LOUD SOUND I WAS TOLD THAT THE POWER STEERING HO...

Mileage: 102,041

I HAVE 2002 MERCEDES ML-500 AND MY CLIMATE CONTROL DOES NOT WORKS AND BLOWING COOLED AIR ALL THE TIME EVEN WHEN I SELECTED TO FULL HOT. I DID BUY MERCEDES SHOP MANUAL AND AS I WAS READING THE SERVICE BULLETINS ISSUED BY MERCEDES MANUFACTURER I FOUND THAT THE FACTORY IS AWARE OF THIS ISSUE THE A/C S...

Mileage: 109,000

I HAVE 2002 MERCEDES ML-500 AND MY CLIMATE CONTROL DOES NOT WORKS AND BLOWING COOLED AIR ALL THE TIME EVEN WHEN I SELECTED TO FULL HOT. I DID BUY MERCEDES SHOP MANUAL AND AS I WAS READING THE SERVICE BULLETINS ISSUED BY MERCEDES MANUFACTURER I FOUND THAT THE FACTORY IS AWARE OF THIS ISSUE THE A/C S...

Mileage: 109,000

FOUND IDENTICAL PROBLEM PER NHTSA ACTION # EA08009 DEFECT INVESTIGATION. CONSTANT LOSS OF BRAKE PRESSURE. WARNING LIGHTS INDICATED LOW BRAKE FLUID. FOUND FLUID UNDER CAR AND IN FRONT LEFT WHEEL-WELL. UPON INSPECTION, FOUND BRAKE HARD LINE FROM MASTER CYLINDER WAS CHAFFED FROM ADJACENT FUEL LINE, CAU...

Mileage: 108,631

FOUND IDENTICAL PROBLEM PER NHTSA ACTION # EA08009 DEFECT INVESTIGATION. CONSTANT LOSS OF BRAKE PRESSURE. WARNING LIGHTS INDICATED LOW BRAKE FLUID. FOUND FLUID UNDER CAR AND IN FRONT LEFT WHEEL-WELL. UPON INSPECTION, FOUND BRAKE HARD LINE FROM MASTER CYLINDER WAS CHAFFED FROM ADJACENT FUEL LINE, CAU...

Mileage: 108,631

THIS CAR WAS PURCHASED IN SACRAMENTO CA IN AUG OF 06, AT THIS TIME WE ALSO PURCHASED AN EXTENDED 2 YEAR WARRANTY WHICH WE UNDERSTOOD TO BE EXPIRING IN AUG OF 08. THE CAR WORKED FINE WITH NO ISSUES UNTIL SEPT OF 07. I STARTED THE CAR AT 4 AM TO HEAD TO WORK AND IT MAKE A REALLY LOUD NOISE, IT GOT WOR...

WHILE DRIVING, ML500 BEGAN TO BRAKE RANDOMLY . ALSO ABS TURNED ON WHILE STOPPING AND ACCELERATING. ALSO BRAKES WERE CONSTANTLY SCREECHING. WARNING LIGHTS FOR ABS, BAS, AND WASHER FLUID. FLUID LEVEL WAS FINE. I TOLD DEALER ABOUT THESE PROBLEMS BEFORE WARRANTY HAD EXPIRED. THEY RAN A DIAGNOSTICS TEST ...

Mileage: 77,000

WHILE DRIVING, ML500 BEGAN TO BRAKE RANDOMLY . ALSO ABS TURNED ON WHILE STOPPING AND ACCELERATING. ALSO BRAKES WERE CONSTANTLY SCREECHING. WARNING LIGHTS FOR ABS, BAS, AND WASHER FLUID. FLUID LEVEL WAS FINE. I TOLD DEALER ABOUT THESE PROBLEMS BEFORE WARRANTY HAD EXPIRED. THEY RAN A DIAGNOSTICS TEST ...

Mileage: 77,000

WHILE DRIVING, ML500 BEGAN TO BRAKE RANDOMLY . ALSO ABS TURNED ON WHILE STOPPING AND ACCELERATING. ALSO BRAKES WERE CONSTANTLY SCREECHING. WARNING LIGHTS FOR ABS, BAS, AND WASHER FLUID. FLUID LEVEL WAS FINE. I TOLD DEALER ABOUT THESE PROBLEMS BEFORE WARRANTY HAD EXPIRED. THEY RAN A DIAGNOSTICS TEST ...

Mileage: 77,000

WHILE DRIVING, ML500 BEGAN TO BRAKE RANDOMLY . ALSO ABS TURNED ON WHILE STOPPING AND ACCELERATING. ALSO BRAKES WERE CONSTANTLY SCREECHING. WARNING LIGHTS FOR ABS, BAS, AND WASHER FLUID. FLUID LEVEL WAS FINE. I TOLD DEALER ABOUT THESE PROBLEMS BEFORE WARRANTY HAD EXPIRED. THEY RAN A DIAGNOSTICS TEST ...

Mileage: 77,000

THE VEHICLE WAS PARKED AT A PARKING LOT FOR APPROXIMATELY 2 HRS. I ATTEMPTED TO START THE ENGINE. IT STARTED THEN ABRUPTLY STOPPED. THIS HAPPENED 3 TIMES. UPON THE 4TH ATTEMPT THE ENGINE WOULD NOT START AT ALL. I LOOKED AT THE DASH LIGHTS THE COMPUTER WAS SHOWING ERROR START. I PROCEEDED TO JIGG...

Mileage: 51

THE VEHICLE WAS PARKED AT A PARKING LOT FOR APPROXIMATELY 2 HRS. I ATTEMPTED TO START THE ENGINE. IT STARTED THEN ABRUPTLY STOPPED. THIS HAPPENED 3 TIMES. UPON THE 4TH ATTEMPT THE ENGINE WOULD NOT START AT ALL. I LOOKED AT THE DASH LIGHTS THE COMPUTER WAS SHOWING ERROR START. I PROCEEDED TO JIGG...

Mileage: 51

I OWN A 2002 MERCEDES BENZ ML500. A WEEK AGO I EXPERIENCED SUDDEN ACCELERATION WHILE DRIVING ON AN INTERSTATE. AS I WAS ACCELERATING THE CAR SUDDENLY ACCELERATED (THE GAS PEDAL WENT TO THE FLOOR) AND I WAS UNABLE TO STOP THE CAR DESPITE FULLY DEPRESSING THE BREAK PEDAL. THE CAR REACHED 80+ MPH AN...

WARRANTY ISSUES AND/OR MANUFACTURING DEFECTS THAT SHOULD BE COVERED BY WARRANTY. ON OCTOBER. 21, 2003 TOOK MY ML500 YEAR 2002 TO DEALER FOR SQUEALING AND SCRAPING BRAKES. SERVICE DEPARTMENT COULD NOT DIAGNOSE THE PROBLEM THE SQUEALING AND SCRAPING AND TOLD ME THAT BRAKE DISC AND PADS LOOKS FINE. H...

Mileage: 22,014

TGHE ACCELERATOR PEDAL IS STICKY AND NOTCHY. THIS CONDITION MADE SMOOTH ACCELERATION EXTREMELY DIFFICULT. *AK *TS

WARRANTY ISSUES AND/OR MANUFACTURING DEFECTS THAT SHOULD BE COVERED BY WARRANTY. *PH AT THE FIRST 10,000 MILES, THE CONSUMER NOTICED BRAKE TRAVEL WAS TOO LONG AND WAS ADVISED BY AN SERVICE ADVISOR THAT THIS WAS NORMAL. HOWEVER AT LESS THAN 3,000 MILES, THE BRAKES WERE STILL NOT ADEQUATE AND T...

Mileage: 10,000

THE GEARS JAMMED WHEN THE CONSUMER ATTEMPTED TO PUT THE VEHICLE IN REVERSE. THE VEHICLE WOULD REV TO ABOUT 2000 RPM'S OR MOR BUT THE VEHICLE STILL WOULDN'T MOVE. AFTER SEVERAL ATTEMPT THE VEHICLE WOULD EVENTUALLY MOVE. THE DOORS WERE DIFFICULT TO CLOSE. THE VEHICLE CONSUMED ALOT OF FUEL. THE FU...

Mileage: 9,000

TRANSMISSION STUCK IN FIRST GEAR, THREE ATTEMPTS TO REMEDY BY OWNER, FINALLY ON FOURTH ATTEMPT.(PLACING IN PARK AND TURNING OFF AN ON IGNITION) TRANSMISSION FINALLY WOKED NORMALLY. CONTACTED MANUFACTURER THROUGH ROADSIDE ASSISTANCE TOLD TO RETURN VEHICLE TO DEALER, CONTACTED DEALER, WAS TOLD THAT ...