2022 MERCEDES BENZ SPRINTER 2500 Problems & Recalls

Hello. There is a Crosswind Assist feature on the van that is downright dangerous. When it engages it breaks and corrects the vehicle in a way that will result in an actual crash, worse than what the feature is intended to do. This could be a great feature if it didn’t cause more harm than good. I...

The secondary alternator on our 2023 Winnebago Revel failed and caught fire. Fortunately, it happened when the vehicle was stopped so the fire was quickly put out and the damage limited to the alternator itself and the belt that ran the alternator. Had the failure happened in motion, a broken belt c...

The secondary alternator on our 2023 Winnebago Revel failed and caught fire. Fortunately, it happened when the vehicle was stopped so the fire was quickly put out and the damage limited to the alternator itself and the belt that ran the alternator. Had the failure happened in motion, a broken belt c...

The contact owns a 2024 Winnebago Revel RV built on a 2022 Mercedes-Benz Sprinter 2500 Chassis. The contact stated while the RV was idling, the heater was activated, and the contact's wife made him aware that there was an abnormal smoke odor. Additionally, the contact stated that while the RV was id...

Mileage: 600

I have a 2022 Mercedes Sprinter with the M274 engine. At approximately 139,100 miles the check engine light came on and my driver was stranded on [XXX] . I took the vehicle to Mercedes-Benz of Kansas City South for diagnosis. I was told that the #4 piston cracked and scored the engine wall. I was qu...

Charging issue with house battery side of class B camping van. It became somewhat apparent the system was not charging properly and quickly escalated to a high overcharge situation, followed by evidence of electrical short in smells and possible smoke in engine bay. The car was in for service for...

My van has a "cross wind assistance" feature that can not be turned off. Apparently it helps to keep the vehicle in the lane during cross wind situation, I found it to be way too aggressive and turning itself for no apparent reason. I find it that while it may be helpful in some situations it certai...

My van has a "cross wind assistance" feature that can not be turned off. Apparently it helps to keep the vehicle in the lane during cross wind situation, I found it to be way too aggressive and turning itself for no apparent reason. I find it that while it may be helpful in some situations it certai...

On [XXX], I purchased a new 2022 Mercedes Benz Winnebago Adventure Wagon (“RV”) from La Mesa RV located in Phoenix, AZ. Prior to purchase, while doing research online, it came to my attention that there was an NHTSA Safety Recall for this particular year/model that affected wires under the seat...

On [XXX], I purchased a new 2022 Mercedes Benz Winnebago Adventure Wagon (“RV”) from La Mesa RV located in Phoenix, AZ. Prior to purchase, while doing research online, it came to my attention that there was an NHTSA Safety Recall for this particular year/model that affected wires under the seat...

The engine fan fell off, broke off, sheered off at the bolt that attaches it to the engine. The van is brand new this happened with less then 3000 miles on it. We realized an issued when the van gave a warning to stop immediately and turn off engine. This warning came on 3-4 times as we tried to as...

I have had to have the EGR valve cleaned out 4 times in 18000 miles. The dealer states it carbonized and causes bucking and hard shifting. This is a great hardship as to lost time of vehicle in service. Smithtown Mercedes has told me it is a known issue with no current resolution other than cleaning...

I have had to have the EGR valve cleaned out 4 times in 18000 miles. The dealer states it carbonized and causes bucking and hard shifting. This is a great hardship as to lost time of vehicle in service. Smithtown Mercedes has told me it is a known issue with no current resolution other than cleaning...

Crosswind Assist feature can't be disabled at the moment and is extremely dangerous. This "feature" can randomly kick on while driving around others and unexpectedly do things like breaking / swerving etc... which is extremely dangerous for both the drivers but others that might not understand what...

It’s feels like hard shifting losing power on a highway Check engine light on I bought the van brand new. I have this issue since 4000 mile on the dashboard. I brought it in over six times for repairs. Nothing has been resolved.

Mercedes has not issued a remedy for the recall in a timely manner and has not been able to issue a date when the remedy will be available.

The contact owns a 2022 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number 24V160000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the battery warning light had illuminated. The contact was instructed...

Side wind assist is an absolute disaster. It triggers when passing semi trucks and immediately brakes the van and veers into the lane with the truck. This causes the truck to take evasive action and the cars behind to have to brake abruptly. It also will do the same without warning with both mi...

The Cross Wind Assist feature on the Mercedes Sprinter is extremely flawed and dangerous. It is also the only assistance system you cannot disable. We have brought it up to Merceds Benz mechanics and dealers and they are aware of the issues, but say there is currently no fix from corporate. I hav...

The Cross Wind Assist feature on the Mercedes Sprinter is extremely flawed and dangerous. It is also the only assistance system you cannot disable. We have brought it up to Merceds Benz mechanics and dealers and they are aware of the issues, but say there is currently no fix from corporate. I hav...

My message belongs to all vehicle manufacturers. Especially the business/commercial vehicles like mine . Which we spent most of our time inside it, during the work periods'. I would like to ask a favor to take a better attention when it comes to Safety/Comfort /look. We don't Race or Camp but work...

My message belongs to all vehicle manufacturers. Especially the business/commercial vehicles like mine . Which we spent most of our time inside it, during the work periods'. I would like to ask a favor to take a better attention when it comes to Safety/Comfort /look. We don't Race or Camp but work...

My message belongs to all vehicle manufacturers. Especially the business/commercial vehicles like mine . Which we spent most of our time inside it, during the work periods'. I would like to ask a favor to take a better attention when it comes to Safety/Comfort /look. We don't Race or Camp but work...

The contact owns a 2023 Storyteller Overland Classic Mode 4x4 RV built on a 2022 Mercedes-Benz Sprinter 2500 Chassis. The contact stated that while driving at 65 MPH, the rear driver's side wheel was leaking air. The low tire pressure warning light was illuminated. The contact inflated the rear driv...

Mileage: 17,000

The contact owns a 2022 Mercedes-Benz Sprinter 2500. The contact stated while driving at various speeds with the cruise control activated, the vehicle experienced phantom braking, with the traction control warning light illuminated. The contact stated that the failure had occurred several times whil...

Mileage: 6,800

The contact owns a 2022 Mercedes-Benz Sprinter 2500. The contact stated while driving at various speeds with the cruise control activated, the vehicle experienced phantom braking, with the traction control warning light illuminated. The contact stated that the failure had occurred several times whil...

Mileage: 6,800

At least 5 occurneces, all at elevations above 7000' and in moderately warm weather. After normal engine start, put vehicle in reverse, able to roll out of parking spot, but throttle completely unaffected by accelerator position. Leaving vehicle in a dangerous position. Putting back in park, vehi...

At least 5 occurneces, all at elevations above 7000' and in moderately warm weather. After normal engine start, put vehicle in reverse, able to roll out of parking spot, but throttle completely unaffected by accelerator position. Leaving vehicle in a dangerous position. Putting back in park, vehi...

The “Cross Wind Assist” my vehicle came equipped from the factory with has nearly caused me to have a serious accident due directly to -totally - distracting me when driving the speed limit on a major highway. The “Cross Wind Assist” activates with no notice to the driver and indiscriminate...

The “Cross Wind Assist” my vehicle came equipped from the factory with has nearly caused me to have a serious accident due directly to -totally - distracting me when driving the speed limit on a major highway. The “Cross Wind Assist” activates with no notice to the driver and indiscriminate...

The contact owns a 2022 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 23V444000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for th...

The contact owns a 2022 Mercedes-Benz Sprinter 2500. The contact received notification of NHTSA Campaign Number: 23V444000 (Fuel System, Gasoline) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for t...

Mileage: 23,000

While driving the MB sprinter with distronic cruise control and there are no vehicles around the cruise control option on the sprinter will disable itself and fail to restart until it senses another vehicle object around. I have noticed this many times while driving long distance on the interstate.

While driving the MB sprinter with distronic cruise control and there are no vehicles around the cruise control option on the sprinter will disable itself and fail to restart until it senses another vehicle object around. I have noticed this many times while driving long distance on the interstate.

I drove on the freeway with Cruise Control engaged. Suddenly, the control kicked off, and the meter board displayed the following warnings: "Active Brake Assist Functions Limited. See Operator's Manual" and "Active Distance Assist Inoperative." I immediately contacted Mercedes-Benz road assistance, ...

I drove on the freeway with Cruise Control engaged. Suddenly, the control kicked off, and the meter board displayed the following warnings: "Active Brake Assist Functions Limited. See Operator's Manual" and "Active Distance Assist Inoperative." I immediately contacted Mercedes-Benz road assistance, ...

When parked or stopped at elevation (above 9,000) feet, the throttle doesn’t work. The vehicle just rolls down the hill (if on one) or stays put if on a flat surface. This is dangerous because I could roll into someone, and if alone, I am stranded with a vehicle that doesn’t work. I have contact...

Upon starting the van (brand new, less than 300 mi driven) everything functions normally in P, however as soon as I shift into D, there is no power and the gas pedal is completely unresponsive (Can push pedal to the floor and still 0 RPM). This issue happens randomly, though the common factor that m...

Upon starting the van (brand new, less than 300 mi driven) everything functions normally in P, however as soon as I shift into D, there is no power and the gas pedal is completely unresponsive (Can push pedal to the floor and still 0 RPM). This issue happens randomly, though the common factor that m...

Upon starting the van (brand new, less than 300 mi driven) everything functions normally in P, however as soon as I shift into D, there is no power and the gas pedal is completely unresponsive (Can push pedal to the floor and still 0 RPM). This issue happens randomly, though the common factor that m...

Shadows from an overpass/bridge or large signs over the highway cause sometimes causes the front collision mitigation triangle lights to go off with warning sounds. Occasionally, automatic braking has occurred at highway speeds.

The vehicle will lose power at high altitudes. I will push the gas pedal all the way down and the RPMs do not move nor does the vehicle move. This has left me in dangerous situations at intersections. I have spoken with a Mercedes dealer in Denver and they have multiple reports of this problem. ...

The vehicle will lose power at high altitudes. I will push the gas pedal all the way down and the RPMs do not move nor does the vehicle move. This has left me in dangerous situations at intersections. I have spoken with a Mercedes dealer in Denver and they have multiple reports of this problem. ...

The vehicle will lose power at high altitudes. I will push the gas pedal all the way down and the RPMs do not move nor does the vehicle move. This has left me in dangerous situations at intersections. I have spoken with a Mercedes dealer in Denver and they have multiple reports of this problem. ...

At elevations above about 6,500ft, the Sprinter is essentially immobile or becomes intermittently unresponsive to the gas pedal when it is depressed. This happens routinely at elevation and has led to unresponsive acceleration while driving. The unresponsive accelerator has compromised safety when t...

At elevations above about 6,500ft, the Sprinter is essentially immobile or becomes intermittently unresponsive to the gas pedal when it is depressed. This happens routinely at elevation and has led to unresponsive acceleration while driving. The unresponsive accelerator has compromised safety when t...

At elevations above about 6,500ft, the Sprinter is essentially immobile or becomes intermittently unresponsive to the gas pedal when it is depressed. This happens routinely at elevation and has led to unresponsive acceleration while driving. The unresponsive accelerator has compromised safety when t...

My transportation business invested in a Commercial Sprinter Van 2500 4x4 2022, that was purchase on November 19th, 2022. We use these cargo van to transport LTL throughout United States and Canada. On December 23rd, 2022 the vehicle was involved in an incident that almost resulted to death of the d...

My transportation business invested in a Commercial Sprinter Van 2500 4x4 2022, that was purchase on November 19th, 2022. We use these cargo van to transport LTL throughout United States and Canada. On December 23rd, 2022 the vehicle was involved in an incident that almost resulted to death of the d...

My transportation business invested in a Commercial Sprinter Van 2500 4x4 2022, that was purchase on November 19th, 2022. We use these cargo van to transport LTL throughout United States and Canada. On December 23rd, 2022 the vehicle was involved in an incident that almost resulted to death of the d...

Brand new van with less than 1000 miles on it. Driving in the High Sierras 8600 - 9000 ft. Altitude seems to be related to this problem. I have not had the problem in San Francisco on steep hills. Problem: When leaving a stop, on any uphill slope RPMs will stay well under 2000 and the van barely mo...

The contact purchased a 2022 Mercedes-Benz Sprinter 2500. The contact stated that two days before taking possession of the vehicle, he was notified by the dealer that the vehicle was included in NHTSA Campaign Number: 22V131000 (Suspension). The contact was informed that the part to do the recall re...

The distronic cruise control system cuts out after a period of seeing no vehicles in front, sometimes an hour, sometimes two hours. But when this happens, it then begins disabling other safety systems like emergency braking. There is no way to quickly reset the system. I spoke with the Mercedes Benz...

The distronic cruise control system cuts out after a period of seeing no vehicles in front, sometimes an hour, sometimes two hours. But when this happens, it then begins disabling other safety systems like emergency braking. There is no way to quickly reset the system. I spoke with the Mercedes Benz...