High Severity Issue
This component has been associated with crashes, fires, or deaths.
This Problem Across All Years
After MB performed required "Campaign" #2021070027 related to transmission, CDI, VGS and SCR (emissions controls), transmission now shift erratically and sometimes unpredictably, engine in now running a higher RPMs, oil pressure is higher and fuel economy (as measured by manual calculations) has decreased by not less than 15%. Vehicle was originally taken to MB dealer related to a repeated (3 times) intermittent/unexpected power loss and dash warning. Loss of power could lead to loss of control, especially at highway speeds. The vehicle was inspected and above noted campaign was applied. Mileage on the vehicle is currently 15000. Events took place between 12k and 14.5k. Degrade of fuel economy as well as other operations degradations took place after a service visit at 14.5k.
After MB performed required "Campaign" #2021070027 related to transmission, CDI, VGS and SCR (emissions controls), transmission now shift erratically and sometimes unpredictably, engine in now running a higher RPMs, oil pressure is higher and fuel economy (as measured by manual calculations) has decreased by not less than 15%. Vehicle was originally taken to MB dealer related to a repeated (3 times) intermittent/unexpected power loss and dash warning. Loss of power could lead to loss of control, especially at highway speeds. The vehicle was inspected and above noted campaign was applied. Mileage on the vehicle is currently 15000. Events took place between 12k and 14.5k. Degrade of fuel economy as well as other operations degradations took place after a service visit at 14.5k.
Stranded and required towing due to condensation and EIS Module The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect.
Stranded and required towing due to condensation and EIS Module The 2019+ Mercedes Sprinter EIS (Electronic Ignition System) module is bolted under the driver side dash board to the base of the A pillar where it meets with the firewall. The electrical connector of the module is pointing straight up - this is an issue because any liquids that might spill on the dash (dash cupholder) or any humidity from windshield interior condensation will drip right down the wiring and into the EIS module causing it to short out. _ If the EIS module shorts out, the vehicle will be inoperable until a new unit is fitted. _ The EIS module retails at $1800+ from Mercedes _ Had Mercedes installed the EIS module with the connector facing DOWNWARD - this moisture related issue would not exist. _ There is no drip loop provisions in the wiring. _ Mercedes is aware of the issue as they have created a plastic bag with part number A 638 546 00 35 and they are charging $20 for it. As of right now, Mercedes refuses to fix this issue preventatively. They will only repair it AFTER the EIS module has shorted out. They are refusing to treat this as a warranty claim even though it is clearly a manufacturer defect.
Driver reported that vehicle started rolling while the vehicle was in Park. The parking brake was engaged. Driver was able to stop the vehicle by physically keeping their foot on the brake. Vehicle sent to dealer. Dealer confirmed issue and repaired. Repair details and video of issue available. Other related issues have been identified on other vehicles.
It appears that driver pressed park and pulled the emergency brake. Its possible it wasn't pressed properly and dealer found no mechanical fault. Vehicle rolled forward and impacted another parked vehicle. This may be related to other issues at RemarkableFoods related to transmission being in "Park" or driver intending to put it in "Park". Video is available for review.
Driver reported that vehicle started rolling while the vehicle was in Park. The parking brake was engaged. Driver was able to stop the vehicle by physically keeping their foot on the brake. Vehicle sent to dealer. Dealer confirmed issue and repaired. Repair details and video of issue available. Other related issues have been identified on other vehicles.
It appears that driver pressed park and pulled the emergency brake. Its possible it wasn't pressed properly and dealer found no mechanical fault. Vehicle rolled forward and impacted another parked vehicle. This may be related to other issues at RemarkableFoods related to transmission being in "Park" or driver intending to put it in "Park". Video is available for review.
The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated while the vehicle was stationary, the accelerator pedal was depressed however, the vehicle failed to respond. The contact stated that there was no warning light illuminated. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The contact stated that the failure persisted. The manufacturer was informed of the failure. The failure mileage was approximately 10,000.
The contact owns a 2019 Mercedes-Benz Sprinter 3500. The contact stated while the vehicle was stationary, the accelerator pedal was depressed however, the vehicle failed to respond. The contact stated that there was no warning light illuminated. The contact took the vehicle to the local dealer however, the mechanic was unable to duplicate the failure. The contact stated that the failure persisted. The manufacturer was informed of the failure. The failure mileage was approximately 10,000.
DRIVER PARKED VAN ON A HILL, PUT THE VAN IN PARK AND EXITED THE VAN. WAS OUT OF THE VAN FOR APPROXIMATELY 15-20 SECONDS. DRIVER HEARD A POP AND A GRIND. TURNED AND WATCHED HIS VAN ROLL DOWN A HILL INTO A HOUSE. INCIDENT WAS ON A CITY STREET IN A NEIGHBORHOOD. VEHICLE WAS STATIONARY.*DT *TR
DRIVER PARKED VAN ON A HILL, PUT THE VAN IN PARK AND EXITED THE VAN. WAS OUT OF THE VAN FOR APPROXIMATELY 15-20 SECONDS. DRIVER HEARD A POP AND A GRIND. TURNED AND WATCHED HIS VAN ROLL DOWN A HILL INTO A HOUSE. INCIDENT WAS ON A CITY STREET IN A NEIGHBORHOOD. VEHICLE WAS STATIONARY.*DT *TR