1996 MERCURY COUGAR Problems & Recalls

TL* THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE CLIMATE CONTROL ADJUSTER FAILED. AS A RESULT, THE BLOWER WOULD ONLY FUNCTION ON HIGH AND THE CONTACT WAS UNABLE TO ADJUST THE DEFROST SYSTEM. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER TO HAVE THE FAILURE DIAGNOSED, BUT THEY ...

Mileage: 61,000

TL * THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING ANTI FREEZE ABNORMALLY. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE THE CONTACT WAS ADVISED THAT THE PLASTIC INTAKE MANIFOLD WAS FRACTURED AND WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. ...

Mileage: 140,000

TL*THE CONTACT OWNS A 1996 MERCURY COUGAR. THE CONTACT STATED THAT THE DRIVERS SIDE FRONT DOOR AND THE PASSENGERS SIDE FRONT DOOR WOULD OPEN WHILE DRIVING AT ANY SPEED. WHEN SHE CLOSED THE DOORS THEY COULD BE PUSHED OPEN WITH LITTLE EFFORT. FORD WAS CONTACTED AND STATED THAT THERE WERE NO RECALLS. ...

Mileage: 114,000

WHILE DRIVING MY 1996 COUGAR THIS PAST SEPTEMBER, WHICH HAS ONLY 40,360 MILES ON IT AND IS STORED MOST OF THE YEAR FOR THE PURPOSES OF COLLECTING AND PRESERVING THE VEHICLE INDEFINITELY, AT LOW SPEEDS I NOTICED THE OBVIOUS SIGN OF COOLANT AND THE SMELL OF COOLANT COMING FROM UP UNDER THE HOOD. I TH...

Mileage: 40,359

MOVEMENT OF THE FUEL LINES CAUSES THE NYLON FUEL LINE JUMPER TO CHAFE AGAINST THE FLOOR PAN. THIS WEAR CAN CAUSE A PIN HOLE IN THE FUEL LINE RESULTING IN FUEL LEAKAGE. RECALL # 97V159000 1992-93 MERCURY COUGARS...FORD RECALL LETTER TO YOU DATED 9-17-1997..MY COUGAR BUILT 4-'96...1996 WAS THE LAST YE...

Mileage: 80,700

1996 MERCURY COUGAR V6 3.8 LITER ENGINE. HEAD GASKET FAILURE. THIS ENGINE HAS NEVER OVERHEATED. ROUGHLY 80,000 MILES. $1200-1500 ESTIMATE FOR REPAIR. *NM

Mileage: 80,000

I WAS DRIVING AND SAW MY LOW COOLANT LIGHT WAS ON. PULLED INTO CAR PARTS COMPANY PARKING LOT. OPENED HOOD SAW COOLANT ON TOP OF MOTOR AND UNDERSIDE OF HOOD. COOLANT WAS LEAKING FROM FRONT OF THE INTAKE MANIFOLD. UPON INSPECTION REALIZED THE MANIFOLD IS MADE OF PLASTIC. I ATTEMPTED TO STOP THE LEAK W...

Mileage: 100,109

CAMPAIGN 96V007000----ON MY 96 COUGARXR7 PURCHASED IN 2001--HAD TO REPACE MOTOR DUE TO OVERHEATING--NEW MOTOR STARTED TO OVERHEAT/BLOWER CAUSED THIS OVER-HEATING--BECAUSE BLOWER CAME ON ERATICALLY MECHANIC DID NOT FIND IMMEDIATELY//CURRENTLY OUT OF POCKETEXPENSES AROUND 6000.00--DEALER SHOULD OF HAD...

Mileage: 12,918

DT: WITHOUT WARNING WHILE STEPPING ON BRAKE THE CAR WILL ACCELERATE, AND THE ENGINE WILL REV UP. CALLER HAS TO STOMP ON BRAKE HARD TO GET IT TO STAY STILL. CAR CAN BE IN GEAR OR IN PARK WHEN THIS HAPPENS. DEALER HAS NOT BEEN CONTACTED YET. MANUFACTURER HAS NOT BEEN CONTACTED YET. EVERY TIME HE HAS T...

Mileage: 44,000

DT: WITHOUT WARNING WHILE STEPPING ON BRAKE THE CAR WILL ACCELERATE, AND THE ENGINE WILL REV UP. CALLER HAS TO STOMP ON BRAKE HARD TO GET IT TO STAY STILL. CAR CAN BE IN GEAR OR IN PARK WHEN THIS HAPPENS. DEALER HAS NOT BEEN CONTACTED YET. MANUFACTURER HAS NOT BEEN CONTACTED YET. EVERY TIME HE HAS T...

Mileage: 44,000

DRIVER'S DOOR LATCH MALFUNCTIONED. THEREFORE, THE DOOR DIDN'T CLOSE FULLY, AND COULD FLY OPEN WHILE DRIVING. THE ENTIRE LATCH HAD TO BE REPLACED. *AK

Mileage: 146,000

96 V 070 000/STRUCTURE DOOR ASSEMBLY LATCHES AND LOCKS: ON TWO SEPARATE OCCASIONS WHILE DRIVING, THE DRIVER DOOR FLEW OPEN BY ITSELF. THE VEHICLE WAS TAKEN TO THE DEALER. THE DEALER MADE SOME REPAIRS AT NO COST. THE CONSUMER HAS A CONCERN IF THE PROBLEM WILL RECUR. *JB *AK

Mileage: 58,000

CHECK FOR COOLANT LEAK AT INTAKE MANIFOLD. REPLACED INTAKE MANIFOLD. THERE WERE REGULAR OIL CHANGES AND TIRE ROTATION. *BF THE ENGINE LIGHT HAD COME ON, AND THE COOLANT LIGHT WOULD COME ON AND OFF. THE DEALER HAD TO REPLACE THE ENGINE SENSOR LIGHT AND ADDED A CUP OF WATER. THE CONSUMER'S SON...

Mileage: 36,654

CHECK FOR COOLANT LEAK AT INTAKE MANIFOLD. REPLACED INTAKE MANIFOLD. THERE WERE REGULAR OIL CHANGES AND TIRE ROTATION. *BF THE ENGINE LIGHT HAD COME ON, AND THE COOLANT LIGHT WOULD COME ON AND OFF. THE DEALER HAD TO REPLACE THE ENGINE SENSOR LIGHT AND ADDED A CUP OF WATER. THE CONSUMER'S SON...

Mileage: 36,654

CHECK FOR COOLANT LEAK AT INTAKE MANIFOLD. REPLACED INTAKE MANIFOLD. THERE WERE REGULAR OIL CHANGES AND TIRE ROTATION. *BF THE ENGINE LIGHT HAD COME ON, AND THE COOLANT LIGHT WOULD COME ON AND OFF. THE DEALER HAD TO REPLACE THE ENGINE SENSOR LIGHT AND ADDED A CUP OF WATER. THE CONSUMER'S SON...

Mileage: 36,654

I PURCHASED MY COUGAR IN 1996 BRAND NEW. I HAVE BEEN IT SOUL OWNER SINCE THE DATE OF PURCHASE. ON NOVEMBER 23, 2004 I WAS DRIVING TO WORK AND ABOUT HALF WAY THERE MY LOW COOLANT LIGHT CAME ON. THERE WAS NO OTHER SIGNS THAT MY CAR WAS IN TROUBLE, NO OVERHEATING ON MY TEMPERATURE GAUGE, SO I CONTIN...

I JUST PURCHASED VEHICLE FROM USED CAR LOT. DURING MY 3 MILE TRIP HOME THE CAR OVER HEATED AND WATER VAPOR WAS COMING IN THROUGH AIR CONDITIONING VENTS. WHEN I STOPPED AT MY HOME, I COULD SEE STEAM COMING FROM INSIDE ENGINE. WHEN I OPENED THE HOOD, I FOUND THAT THERE WAS CRACK IN A PLASTIC PART COMI...

Mileage: 95,000

INTAKE MANIFOLD HAS DEVELOPED A CRACK. AS A RESULT, WATER LEAKED OUT, AND THE ENGINE OVERHEATED. *AK

Mileage: 275,000

PROBLEMS WITH VEHICLE'S INTAKE MANIFOLD. *MR ONE WEEK BEFORE THE INTAKE MANIFOLD PROBLEM THE VEHICLE WAS IN FOR A PROBLEM WITH THE BACK UP AND BRAKE LIGHTS, THE FAN BELT, AND THE VEHICLE OVER HEATED AFTER ATTEMPTING TO PASS ANOTHER VEHICLE ON THE HIGHWAY. *SC *JB

PROBLEMS WITH VEHICLE'S INTAKE MANIFOLD. *MR ONE WEEK BEFORE THE INTAKE MANIFOLD PROBLEM THE VEHICLE WAS IN FOR A PROBLEM WITH THE BACK UP AND BRAKE LIGHTS, THE FAN BELT, AND THE VEHICLE OVER HEATED AFTER ATTEMPTING TO PASS ANOTHER VEHICLE ON THE HIGHWAY. *SC *JB

WHILE DRIVING, THE HOOD FLEW UP WITHOUT WARNING. AS A RESULT THE WINDSHIELD SHATTERED. THERE IS A DEFECTIVE DESIGN TO THE HOOD LATCH. *JB *MR

Mileage: 109,000

HEADLIGHT SWITCH HAS SHORTED OUT MANY TIMES. LOCAL DELARSHIP KNOWS THE PROBLEM AND I HAVE HAD IT REPLACED BY A LOCAL SHOP THREE TIMES. FOD HAD CHECKED FOR ELECTRICAL SHORTS AND SAID THEY WERE ALL FINE.*AK AUTOMATIC TRANSMISION WENT OUT BECAUSE THE FILTER WASNT GETTING ENOUGH FLUID BECAUSE THE FIL...

Mileage: 40,550

HEADLIGHT SWITCH HAS SHORTED OUT MANY TIMES. LOCAL DELARSHIP KNOWS THE PROBLEM AND I HAVE HAD IT REPLACED BY A LOCAL SHOP THREE TIMES. FOD HAD CHECKED FOR ELECTRICAL SHORTS AND SAID THEY WERE ALL FINE.*AK AUTOMATIC TRANSMISION WENT OUT BECAUSE THE FILTER WASNT GETTING ENOUGH FLUID BECAUSE THE FIL...

Mileage: 40,550

I BOUGHT A MECURY COUGAR XR7 FEBURARY 1ST, 2003 AT CARMAX IN DULLES, VA. I HAVE HAD THE CAR APPROXIMATELY 3 WEEKS. LAST MONDAY FEBRUARY 10, 2003 I TOOK MY CAR TO INSPECTED BY THE STATE OF MARYLAND. I WAS ASSURED THIS CAR WOULD PASS INSPECTION. MY CAR FAILED INSPECTION. I AM NOW HAVING ENGINE PR...

I BOUGHT A MECURY COUGAR XR7 FEBURARY 1ST, 2003 AT CARMAX IN DULLES, VA. I HAVE HAD THE CAR APPROXIMATELY 3 WEEKS. LAST MONDAY FEBRUARY 10, 2003 I TOOK MY CAR TO INSPECTED BY THE STATE OF MARYLAND. I WAS ASSURED THIS CAR WOULD PASS INSPECTION. MY CAR FAILED INSPECTION. I AM NOW HAVING ENGINE PR...

INTAKE MANIFOLD CRACKED. MADE OF A PLASTIC MATERIAL. IS THERE ANY RECALLS OUT THERE FOR THIS? IF NOT, WHY NOT? WHY WOULD YOU PUT PLASTIC MATERIAL IN THE ENGINE? *LA

Mileage: 89,805

INTAKE MANIFOLD IS MADE OF PLASTIC. THERE WAS A FAILURE IN THE PLASTIC MATERIAL ON THE WATER CROSS-OVER JACKET (PORTION OF THE MANIFOLD). THIS CAUSED ALL THE COOLANT TO FLOOD OUT. I FOUND FORD HAD ISSUED A TSB (97M91) THROGH ITS OWNERS NOTIFICATION PROGRAM (ONP) IDENTIFYING FATIGUE AND FAILURE OF...

Mileage: 80,000

TEMPERATURE GAUGE WENT UP, CAR OVERHEATED. TOOK VEHICLE TO INDEPENDENT SHOP, AND TECHNICIAN STATED THAT INTAKE PLASTIC MANIFOLD CRACKED.*AK

WHILE DRIVING AT 40 MPH AND WITH NO WARNING. THE HOOD FLEW OPEN. DEALER NOTIFIED. *AK *SCC *JB

THERE WAS A LOUD KNOCKING NOISE FROM UNDER THE HOOD, AND HAD TAKEN THE VEHICLE TO SEVERAL PEOPLE AND WAS TOLD THAT IT WAS SOMETHING INTERNAL AND WILL NEED A NEW ENGINE. THE CONSUMER WOULD LIKE TO KNOW IF THERE WAS A DEFECT IN THE MANUFACTURING. *SCC

Mileage: 26,701

TEAR ALONG FRONT FACE OF UPPER INTAKE MANIFOLD. CALLED SEVERAL SALVAGE YARDS TO FIND REPLACEMENT AND WAS TOLD BY ALL THAT THEY CAN'T KEEP THESE IN STOCK. WHEN I DID LOCATE ONE THE MANAGER AT THE SALVAGE YARD ASKED WHAT HAPPENED TO MY INTAKE. I SHOWED HIM WHERE THE INTAKE SPLIT OPEN AND HE INFORME...

THE IGNITION HAS FAILED ON TWO OCCASIONS. CAR WOULDN'T SHUT OFF BY IGNITION KEY. HAD TO SHUT OFF VIA FUEL SHUTOFF. MR

VEHICLE WAS GOING 20MPH RIGHT BALL JOINT LOCKED UP. VEHICLE STEERED STARIGHT, BUT WAS PULLING RIGHT. EVERTUALLY, VEHICLE STOPPED ITSELF. MERCURY DEALER WAS NOTIFIED.*AK

IF HEAT IS LEFT ON MODULE IT WILL CATCH ON FIRE.*AK

ON FIVE OCCASIONS WHILE DRIVING VEHICLE STARTED TO ACCELERATE INTERMITTENTLY. VEHICLE BEEN TO DEALER ON TWO OCCASIONS, AND THEY COULD NOT DUPLICATE THE PROBLEM. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION.*AK

TRUNK LID WILL OPEN WHILE DRIVING, THIS HAS HAPPENED NUMEROUS TIMES. DEALER DETERMINED AN ELECTRICAL PROBLEM. *AK *JB

WHILE TRAVELING ON I-4 FROM TAMPA, THE LEFT REAR TIRE TREAD SEPARATED FROM THE TIRE. APPROXIMATELY 15 TO 20 INCHES OF TREAD BECAME SEPARATED.*AK

THE CONSUMER HAD A RECALL FOR ENGINE. DEALERSHIP REPLACED DEFECTIVE PART FROM RECALL. SIX MONTH LATER, REPLACEMENT PART DIDN'T WORK. DEALERSHIP MECHANIC TOLD HER THAT SHE NEEDED A NEW ENGINE. ENGINE LIGHT CAME ON WHILE CONSUMER WAS DRIVING. AND STAYED ON. SHE COMPLAINED THAT ENGINE COO...

THE CONSUMER HAD A RECALL FOR ENGINE. DEALERSHIP REPLACED DEFECTIVE PART FROM RECALL. SIX MONTH LATER, REPLACEMENT PART DIDN'T WORK. DEALERSHIP MECHANIC TOLD HER THAT SHE NEEDED A NEW ENGINE. ENGINE LIGHT CAME ON WHILE CONSUMER WAS DRIVING. AND STAYED ON. SHE COMPLAINED THAT ENGINE COO...

GAS LINE LEAK POSITIONED OVER ELECTRICAL WIRE. *AK

THE GAS DID NOT SHUT OFF DURING IMPACT,ALONG WITH THE AIRBAGS NOT DEPLOYING. THE DRIVER COULD OF BEEN KILLED TODAY. PLEASE FIND OUT WHY THE AIR BAGS DID NOT DEPLOY. THANK YOU JAYNE HOWARD. *AK

TIRE BLEW OUT ON CITY STREET GOING APPROX 35MPH. TIRE PRESSURE WAS CHECKED ON 5-28-98 AND ALSO 9-2-98 BY FORD DEALER. HAVE INFO ON SERVICE TICKETS. FIRESTONE REP SAID TIRE HAD BEEN DRIVEN WITH LOW PRESSURE AND ALSO ON GLASS. SIDEWALL BLEW OUT. THIS PERSON WAS NOT WORTH TALKING TO. PURCHASED ANOTHER ...

TIRE BLEW OUT ON CITY STREET GOING APPROX 35MPH. TIRE PRESSURE WAS CHECKED ON 5-28-98 AND ALSO 9-2-98 BY FORD DEALER. HAVE INFO ON SERVICE TICKETS. FIRESTONE REP SAID TIRE HAD BEEN DRIVEN WITH LOW PRESSURE AND ALSO ON GLASS. SIDEWALL BLEW OUT. THIS PERSON WAS NOT WORTH TALKING TO. PURCHASED ANOTHER ...

WHEN AIRBAGS DEPLOYED, SEATBELT BECAME UNLATCHED

ABOUT A MONTH AFTER PURCHASING THE CAR, I HAD A FLAT ON THE FRONT PASSENGER SIDE TIRE. WE TOOK THE CAR TO DISCOUNT TIRES WHO TOLD US THAT THE TIRE ON THE BACK DRIVERS SIDE WAS SEPARATING AND HAD TO BE REPLACED. THEY REFUSED TO FIX THE FLAT UNTIL WE REPLACED THE TIRE DUE TO SAFETY. WE BOUGHT A REP...

TRANSMISSION PROBLEM EXISTED BUT I DIDN'T RECOGNIZE "SHUDDER". DEALER RECCOMMENDED ADDITIVE TO TRANSMISSION. FLUID JUST AFTER I PURCHASED CAR (NEW). NOW SHUDDER IS SO BAD I HAVE TO GET TRANSMISSION WORK.*AK

THE FIRST TIME THE FRONT ROTORS HAD TO BE RESURFACED THE VEHICLE ONLY HAD 10,000 MILES ON IT, THAN IT WAS RESURFACED AGAIN AND FINALLY WE HAD TO HAVE NEW ROTORS INSTALLED. THE SAME PROBLEM STARTED HAPPENING AGAIN CAUSING THE BRAKES TO WEAR, ROTORS RESURFACED AGAIN, THAN NEW TIRES IN THE FRONT WERE W...

THE FIRST TIME THE FRONT ROTORS HAD TO BE RESURFACED THE VEHICLE ONLY HAD 10,000 MILES ON IT, THAN IT WAS RESURFACED AGAIN AND FINALLY WE HAD TO HAVE NEW ROTORS INSTALLED. THE SAME PROBLEM STARTED HAPPENING AGAIN CAUSING THE BRAKES TO WEAR, ROTORS RESURFACED AGAIN, THAN NEW TIRES IN THE FRONT WERE W...

INTAKE MANIFOLD HAD DEVELOPED A CRACK AND WAS LEAKING COOLANT. THIS CAUSED VEHICLE TO STOP. HAD VEHICLE TOWED TO DEALERSHIP/MECHANIC IN MISSISSIPPI FOR REPAIRS. *AK *ML

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

WHILE DRIVING AT APPROXIMATELY 70 MPH TREAD ON FIRESTONE TIRES SEPARATED ON REAR DRIVER'S SIDE,CAUSING DAMAGE TO WHEEL WELL AND FENDER/BUMPER. *AK *ML

INTAKE MANIFOLD IS MADE OF A COMPOSITE MATERIAL THE HEAT OF MOTOR MUST HAVE CRACKED IT, THE CRACK IS RIGHT BEHIND WHERE THE ALTERNATOR SITS. SO, IT IS ON THE FRONT OF THE INTAKE. WHY IS AN INTAKE MADE OF PLASTIC ANYWAY?

TOP OF ENGINE, MADE OUT OF PLASTIC ,DEVELOPED A TEAR IN IT.CONSUMER ORDERED NEW PART WHICH IS NOW REVISED AND MADE OF STRONGER MATERIAL. *AK

THE REAR BRAKE ROTORS NEED TO BE CUT DUE TO WARPING. THIS IS THE FIRST PROBLEM WITH THE REAR BRAKES BUT, THE FRONT ROTORS HAVE HAD TO BE CUT DOWN EVERY 12,000-15,000 MILES SINCE NEW. AT 48,000 MILES THE FRONT ROTORS COULD NOT BE CUT ANY MORE AND NEEDED REPLACED. THEY WERE CUT THREE TIMES BEFORE BEIN...

WHILE DRIVING AND ATTEMPTING TO ACCELERATE THE VEHICLE WOULD SHUT DOWN AND TRANSMISSION WOULD QUIT PULLING. THEN WITHOUT ANY WARNING IT WOULD REPAIR ITSELF, BUT WOULD JERK IN THE PROCESS. DEALER AND MANUFACTURER HAVE BEEN NOTIFIED. *AK

ENGINE IDLE PULLEY REPLACED.

REPLACED WEAK MOTOR MOUNT.

WINDSHIELD WIPER MOTOR FAILED/REPLACED.

REPLACED WIRING HARNESS.

REPLACED LEFT FRONT DOOR SWITCH.

ACCELERATOR CABLE HAD TO BE REATTACHED TO POST.

DASHBOARD REFLECTS ON WINDSHIELD, CAUSING DECREASED VISIBILITY. *AK

SEAT BELT LOCKS UP.

CRUISE CONTROL FAILED.

POWER STEERING FAILS INTERMITTENTLY, CAUSING LOSS OF CONTROL.

VEHICLE DIFFICULT TO CONTROL AFTER DRIVING OVER ROUGH ROAD.

DESIGN OF CRUISE CONTROL BUTTONS CAUSE THEM TO BE DEPRESSED ACCIDENTLY.

THE WINDOW ON THE DRIVER'S SIDE OF THE VEHICLE BLEW OUT WHILE DRIVING THE VEHICLE ABOUT (55) MPH. THE WINDOW HAS BEEN REPLACED. *AK

POWER STEERING CONTROL MODULE FAILED.

FAN CUT THE COMPUTER WIRES.

VISUAL PROBLEM, THE DASHBOARD DISPLAYS INTO THE WINDSHIELD AND DRIVER CANNOT SEE THE HIGHWAY PROPERLY. *AK

WHEN APPLYING THE BRAKES ON DRY BUMPY PAVEMENT THE BRAKES WILL FAIL, CAUSING LOSS OF VEHICLE CONTROL. PLEASE GIVE FURTHER DETAILS. *AK

DIFFICULTY USING CRUISE CONTROL BUTTONS.

SHOULDER CAUSES DISCOMFORT.

THE BRAKE ROTORS HAVE RUSTED, RESULTING IN CAR MAKING NOISES AND AFTER THE BRAKES WERE APPLIED, THE STEERING WHEEL VIBRATED. PLEASE GIVE MORE DETAIL INFORMATON. *AK

TRANSMISSION DOES NOT SHIFT PROPERLY.