2002 MERCURY COUGAR Engine And Engine Cooling Problems

TL* THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 55 MPH, THE VEHICLE SUDDENLY DECREASED TO 10 MPH. THE VEHICLE WAS TAKEN TO A DEALER AND THEY ADVISED HER THAT ALL THREE CATALYTIC CONVERTERS WERE CLOGGED AND THE FDM NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE FDM BUT NOT THE CATALYTIC CONVERTERS. THE MANUFACTURER WAS CONTACTED AND THEY OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 72,000. THE VIN WAS UNAVAILABLE.

Mileage: 72,000

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE WOULD OFTEN FAIL TO ACCELERATE AND INCREASE IN RPM'S. IN ADDITION, THE VEHICLE WOULD FREQUENTLY STALL. ONCE THE VEHICLE WAS TURNED OFF, IT WOULD RESTART IMMEDIATELY. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC BECAUSE THE WARRANTY WAS NO LONGER VALID. THE MECHANIC DIAGNOSED THE CAUSE OF THE FAILURE AS A FAULTY FUEL INJECTOR. THE VEHICLE WAS REPAIRED, BUT THE FAILURE STILL PERSISTS. THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE), ALTHOUGH THE FAILURES WERE IDENTICAL. THE MANUFACTURER WAS UNABLE TO PROVIDE ASSISTANCE. THE FAILURE MILEAGE WAS 60,000 AND CURRENT MILEAGE WAS 98,000.

Mileage: 60,000

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE VEHICLE BEGAN TO LOSE POWER WHILE DRIVING, WHICH MADE IT DIFFICULT TO STEER THE VEHICLE. HE EXPERIENCED DIFFICULTLY PULLING THE VEHICLE TO THE SIDE OF THE ROAD. AFTER APPROXIMATELY 15 MINUTES, THE VEHICLE WAS ABLE TO BE RESTARTED AND OPERATED NORMALLY. HE DROVE THE VEHICLE HOME AND LATER CALLED THE DEALER. THE DEALER ADVISED HIM TO BRING IN THE VEHICLE AND THEY MADE REPAIRS AT THE COST OF $697. THE FAILURE WAS IDENTIFIED AS BEING INCLUDED IN NHTSA CAMPAIGN ID NUMBER 04V421000 (FUEL SYSTEM, GASOLINE). THE FAILURE COULD CAUSE ENGINE HESITATION, LOSS OF POWER, SURGING, AND OTHER SIMILAR SYMPTOMS. OVER TIME, THE FILTER MAY BECOME SUFFICIENTLY BLOCKED AND CAUSE THE ENGINE TO STALL. THE FAILURE MILEAGE WAS 84,000 AND CURRENT MILEAGE WAS 86,000. UPDATED 07/16/08*LJ THE BUSHINGS AND CLUTCH WERE WORN. THE FUEL PUMP AND FUEL SENDER WERE REPLACED. THE ENGINE LIGHT WAS ON. THE DEALER REPLACED A LEAKING INTAKE. UPDATED 07/16/08

Mileage: 84,000

TL*THE CONTACT OWNS A 2002 MERCURY COUGAR. THE CONTACT STATED THAT THE ENGINE HESITATES AS IF THERE IS NO GAS FLOW. THE DEALER STATED THAT A DIAGNOSIS WAS NEEDED; HOWEVER, THE CONTACT STATED THAT A PREVIOUS DIAGNOSIS DID NOT FIND ANY FAILURES. THE REPAIR SHOP CHANGED THE ENGINE OIL, REPLACED THE FILTER, AND CLEANED THE FUEL INJECTION, BUT THE FAILURE WAS NOT CORRECTED. THE MANUFACTURER IS AWARE OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN RECALL NUMBER 04N02. THE FAILURE MILEAGE AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 106,881.

LOSS OF POWER, SURGING, SO I TOOK TO DEALER THEY CHANGED FUEL PUMP SUPPOSEDLY AND FILTER AND TRANSMISSION FLUID. ONE WEEK LATER I TOOK IT BACK BECAUSE IT CONTINUED TO DO THE SAME, THEY SAID THEY CHECKED A WIRE TO FUEL PUMP AND CHANGED A SPARK PLUG, AND HERE IT IS ANOTHER WEEK WITH THE SAME SYMPTOMS. *TR

Mileage: 74,500

NO PROBLEMS OR INDICATORS OF ANY PROBLEMS OR ISSUES. WAS DRIVING VEHICLE ON HIGHWAY AND CAR LOSS POWER. WAS ABLE TO PULL OFF TO SIDE OF ROAD. HAD VEHICLE EXAMINED AND WAS TOLD THE ENGINE SEIZED. HAD SECOND OPINION, AND MECHANIC DRAINED THE OIL AND SAID THERE WAS METAL SHAVINGS IN OIL, COULD NOT GIVE REASON AS TO WHAT CAUSED ENGINE TO LOCK UP. HAVE TO REPLACE THE ENGINE. WARRANTY EXPIRED. WAS TOLD FORD WOULD NOT COVER. HAD LESS THAN 45,000 MILES ON VEHICLE - THIS IS A DEFECTIVE OR MISBUILT MOTOR. *NM

Mileage: 44,900

ONCE THE CONSUMER IS INSIDE THE VEHICLE SHE CAN STRONGLY SMELL GAS FUMES. THE DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 55,500

CONSUMER STATED VEHICLE HESITATED BETWEEN GEARS AT ANY SPEED. SERVICE TECHNICIAN COULDN'T DUPLICATE THE PROBLEM. PLEASE PROVIDE ANY FURTHER INFORMATION. *PH

WHILE TRAVELING ON HIGHWAY AT APPROXIMATELY 70 MPH, VEHICLE STALLS WITHOUT WARNING. THIS HAS HAPPENED 12 TIMES AT HIGH SPEEDS AND RESULTS IN LOSS OF POWER STEERING AND TWICE HAS RESULTED IN LOSS OF ALL ELECTRICAL POWER INCLUDING HEADLIGHTS. *JB

Mileage: 5,000

WHILE TRAVELING ON THE HIGHWAY THE VEHICLE SHUT DOWN WITHOUT PRIOR WARNING. AND THE VEHICLE WILL NOT RESTART AT ALL PLEASE PROVIDE ADDITIONAL INFORMATION DEALER IS AWARE OF THE PROBLEM

ON APPROX. THE 15TH OF MARCH, MY DAUGHTER LOST ALL POWER IN CAR WHILE DRIVING THROUGH LUNCH TRAFFIC IN TOWN AND WAS NEARLY REARENDED BY A PETROLUEM TANKER. WE BROUGHT CAR IN TO DEALERSHIP. THEY RAN A BATTERY TEST AND B/C THAT CAME BACK FINE THEY REFUSED TO DO ANY FURTHER TESTING. SHE WAS HAVING PROBLEMS GETTING THE KEY TO TURN OVER TO START CAR. THEY FIXED THAT PROBLEM AT THE SAME TIME. ON THE 15TH OF MAY, THE CAR CAME OUT OF THE SHOP FOR THE 2ND TIME AFTER IT HAD LOST POWER TWICE ON HER WHILE DRIVING AGAIN.HER. THE DEALERSHIP CONTACTED FORD HEADQUARTERS FOR RECALLS. NONE HAD BEEN POSTED, BUT FORD SAID IF THEY CHECK THE FUEL FILTER AT THE BOTTEM OF THE FUEL TANK WE WOULD PROBABLY FIND THE PROBLEM WITH LOSING ALL POWER(BRAKING, STEERING, ECT.) WAS THAT THE FILTER WAS CLOGGED THEREFORE NO GAS WAS GETTING TO THE MOTOR AND THUS THIS WAS WHY THE CAR WAS LOSING POWER. THEY REPLACED THE FUEL PUMP AND SAID THAT WAS A TEMPORARY FIX FOR APPROX THE NEXT 3000 MILES(FOR IT WAS HAPPENING ABOUT EVERY 3000 MILES). AND THAT WE WOULD HAVE TO BRING THE CAR IN EVERY 3000 MILES TO REMAIN SAFE FROM LOSING POWER WHEN IT BECAME CLOGGED AGAIN. WE DECIDED THAT SINCE FORD KNEW ABOUT THE PROBLEM AND REFUSED TO DO A RECALL TO FIX THE PROBLEM THAT ANYONE IN MY FAMILY WHO DROVE OR RODE IN THE CAR WOULD BE PUTTING THEIR LIFE IN DANGER SO WE TRIED TO TRADE THE CAR. THE DEALERSHIP WANTED US TO PAY A $6,000 DEFICIT SO WE DECIDED TO KEEP THE CAR UNTIL WE COULD COMPLETE THE LEMON LAW PROCESS. THREE WEEKS LATER, MY DAUGHTER STATED SHE HAD GOT REALLY BAD GAS MILEAGE(15 MILES TOOK 1/4 OF A TANK SHE MEASURED IT) THE DAY BEFORE AND SHE WAS AFRAID THAT THE CAR WAS GOING TO LOSE POWER AGAIN. IT WAS A FRIDAY SO THE CAR COULDN'T GO TO THE DEALERSHIP TIL THE FOLLOWING WEEK. THAT NIGHT, THE 6TH OF JUNE.SHE LOST BRAKES AND STEERING WHILE GOING AROUND A CURVE. THE CAR HIT SOMETHING IN THE DITCH AND ROLLED 1.5X'S TO REST UPSIDE DOWN. NO AIRBAGS DEPLOYED.SEATBEAT HELD HER IN CAR.PICTURES OF CAR AND SCENE AVAIL. *AK