2003 MERCURY MOUNTAINEER Engine And Engine Cooling Problems

I PURCHASED A 2003 MERCURY MOUNTAINEER ON 2/15/14 AND I TOOK IT ON A ROAD TRIP ON 2/16/4 WITH MY GRANDKIDS. AFTER ENTERING THE HIGHWAY AND GAINING SPEED I STARTED TO SMELL A STRONG BURNT RUBBER AND EXHAUST SMELL. THE SMELL WAS VERY TOXIC AND STUCK TO OUR CLOTHING. ON 2/18/14, I TOOK IT TO THE DEALER FOR HIS MECHANIC TO TAKE A LOOK AT IT. THE MECHANIC SAID THERE WAS SOME DEGREASER THAT OVERFLOWED FROM A CUPLER AND LEAKED ONTO THE EXHAUST. I ASKED IF THERE WAS A LEAK AND THE MECHANIC RESPONDED BY SAYING NOT REALLY, WHICH MEANT THERE WAS A LEAK. THE MECHANIC ASSURED ME THAT THE PROBLEM WAS TAKEN CARE OF, BUT IF IT STILL OCCURS, THEY WOULD SEND IT IN FOR TWO DAYS. I CONTINUED TO SMELL THE TOXIC SMELL AND ON 2/19/14 THE HATCH ON LIFT GATE JUST CRACKED. ALSO WHEN I TURN AT A LOW SPEED, I HEAR A STRANGE SOUND AND VIBRATION, COMING FROM THE TIRE AREA. I'VE HEARD OF NUMEROUS ISSUES AND COMPLICATIONS WITH THE MERCURY MOUNTAINEERS. I DON'T WANT MY GRANDCHILDREN NOR MY LIFE PUT IN DANGER. A DRIVER SHOULD BE ENSURED WITH SAFETY WHEN DRIVING A VEHICLE. FORD DOESN'T CARE ABOUT THEIR CONSUMERS TO SELL DEFECTIVE AND NONSAFE VEHICLES. PLEASE RECALL THIS VEHICLE AS IT HAS TOO MANY ISSUES THAT CAN BE LIFE THREATENING, LIKE THE ROLLOVER RATE. *TR

Mileage: 105,000

WE HAVE EXPERIENCED TWO WELL KNOWN ISSUES WITH THE EXPLORER/MOUNTAINEER. THE BODY PANEL ON THE BACK HATCH IS CRACKED IN THE MIDDLE AND FRIDAY WE HAD THE SPARK PLUG BLOW OUT OF THE HEAD/SOCKET STRIPPING THE THREADS OUT TO THE POINT THAT THE COMMON REPAIR KIT USED FOR THESE INSTANCES WON'T WORK AND THE ONLY SOLUTION IS A REPLACEMENT HEAD WHICH IS QUOTED AT A $3500 JOB AND THE VEHICLE IS ONLY WORTH ABOUT $5700. I UNDERSTAND FORD ACCEPTS NO RESPONSIBILITY FOR THIS ENGINE/HEAD DEFECT DESPITE THE FACT THAT IT HAS OCCURRED ON FACTORY TIGHTENED PLUGS. *TR

Mileage: 134,600

I HAVE 2003 MERCURY MOUNTAINEER AND I HAVE HAD IT SINCE FEBRUARY 2007. I HAVE HAD NUMEROUS PROBLEMS WITH IT AND THE LAST PROBLEMS WAS THE BREAKING POINT. I HAVE THREE MORE YEARS TO PAY FOR THIS VEHICLE AND I WANT SOMETHING TO BE DONE ABOUT THE PROBLEMS WITH THIS VEHCILE. FORD SHOULD BE HELD RESPONSIBLE FOR THIS VEHICLE AND FIXING THE PROBLEMS ASSOCIATED WITH IT. I PURCHASED THIS VEHICLE FROM COMMUNITY FORD IN NEW ALBANY, MS IN FEBRUARY 2007 WITH 45,000 MILES ON IT. I COULDN'T GET AN EXTENDED WARRANTY OR ANY WARRANTY WITH THE VEHICLE I WAS TOLD. AFTER A YEAR, I HAD TO REPLACE THE FRONT END AND IT WAS $500.00 AT GEORGE'S TIRE SERVICES. I TOOK IT IN DUE TO THIS NOISE COMING FROM THE FRONT AND I WAS ADVISED THAT IF I DIDN'T HAVE THE WORK DID IT WOULD LOCK UP ON ME WHILE I AM DRIVING AND CAUSE AND ACCIDENT. I NOTICED THAT MY STRUCTURE BODY:HATCHBACK/TAILGATE HAS CRACKED COMPLETELY. MY SEAT BELT ON THE DRIVER SIDE IN THE BACK DON'T WORK. MY ENGINE COOLING SYSTEM AIRCOMPRESSOR HAS WENT OUT AND I HAVE ELECTRICAL PROBLEMS WHERE MY OIL GAUGE IS CONSTANTLY SAYING IT'S LOW. I HAVE MY OIL CHANGE EVERY 3000 MILES. I AM HEARING THIS NOISE IN THE REAR OF THE VEHICLE AND I DON'T KNOW WHAT IT IS AND CAN'T AFFORD TO GET GOING TO FORD TO SEE WHAT IT IS. I HAVE BEEN SMELLING THIS BURNING COMING FROM THE UNDER THE HOOD AND I DON'T KNOW WHAT IT IS EITHER. MY LASTEST PROBLEM IS MY TRANSMISSION IS GOING OUT AND I HAVE HAD THIS VEHICLE FOR TWO YEARS AND I HAVE THREE MORE YEARS OF PAYMENT ON THIS VEHICLE. MY TRANSMISSION COST ME AROUND $3500 AND I DON'T HAVE ANY WARRANTY ON IT. THIS IS A LEMON I HAVE PURCHASED AND I THINK SOMETHING SHOULD BE DONE ABOUT IT. *TR

Mileage: 60,000

THE HEATER STOP WORKING 3 DIFFERENT TIMES, THE FIRST TIME THEY REPLACED THE THERMOSTAT, 2ND COULD NOT FIND ANYTHING WRONG, DEALER THINKS MIGHT BE INTAKE MANIFOLD OR HEAD GASKET, 3RD TIME SAY MUST TAKE IT APART TO FIGURE OUT BUT PRESSURE TEST ARE WITHIN NORMAL RANGE. *TR

Mileage: 85,000

TL*THE CONTACT OWNS A 2003 MERCURY MOUNTAINEER. THE CONTACT STATED THAT THE REAR DRIVER'S SIDE WHEEL BEARING WAS REPLACED 3 TIMES WITHIN 16 MONTHS. ON OCTOBER 1, 2008, WHILE DRIVING OUT OF THE DRIVEWAY AT AN UNKNOWN SPEED, SHE HEARD A LOUD NOISE. THE VEHICLE WAS TOWED TO THE REPAIR SHOP AND THE MECHANIC STATED THAT THE REAR DRIVER'S SIDE WHEEL BEARING FAILED. THE CONTACT STATED THAT THE VEHICLE WAS NOT DRIVEN ON DIRT ROADS, ONLY IN THE CITY. SHE FEELS THAT EITHER THE WHEEL BEARING IS DEFECTIVE OR THE FORD DEALER DID NOT PROPERLY CORRECT THE PREVIOUS FAILURES. THE FORD DEALER STATED THAT THE VEHICLE IS OUT OF WARRANTY AND THE WHEEL BEARING IS ONLY GOOD FOR 12,000 MILES. THE MANUFACTURER TOOK A REPORT AND STATED THAT THEY WILL FORWARD HER INFORMATION TO THE DEALER. FROM THERE, THE DEALER WILL DETERMINE IF THE VEHICLE WILL BE REPAIRED. THE FAILURE MILEAGE WAS 74,494 AND CURRENT MILEAGE WAS 104,000. UPDATED 11/14/08 *CN THE DRIVER SIDE VISOR WAS HANGING DOWN, THE VEHICLE STALLED ON SEVERAL OCCASIONS. THE LOWER BALL JOINTS AND OUTER TIE ROD ENDS WERE REPLACED. THE REAR HATCH WINDOW CRACKED. THE VEHICLE WOULD CRANK, BUT IT WOULD NOT START. UPDATED 11/18/08. *JB

Mileage: 74,494

DT CONTACT STATES SHE WAS DRIVING 60 MPH WHEN THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER AND THE SERVICE MECHANIC SAID THAT THE CATALYTIC CONVERTER NEEDED TO BE REPLACED. THE CATALYTIC CONVERTER WAS REPLACED LAST YEAR. *NM

THE PROBLEM PERSISTED AND CONCERN WITH STALLED VEHICLE, SERVICED AND PROBLEM STILL CONTINUE. *BF THESE PROBLEMS ELEVATED TO VEHICLE STALLING, THE ALTERNATOR WAS REPLACED, THERE WERE CONTINUOUS OCCURRENCES OF THE BATTERY FAIL/CHECK ENGINE INDICATOR LIGHT, VIBRATION WHEN BRAKING, AND THE TORQUE CONVERTER LOCKED. THE CONSUMER REQUESTED A NEW LEASE AND OR EARLY TERMINATION OF THE LEASE. *SC

TO THIS DATE THE FOLLOWING PROBLEMS ARE PRESENT: GAS GAUGE STICKS, AIR BAG WARNING LIGHT COMES ON AND OFF, DRIVER'S SIDE DOOR RATTLES AND KNOCKS, DRIVER'S SIDE WINDOW TAPS, DRIVER'S SIDE WINDOW GRINDS WHILE MOVING UP AND DOWN, CLOCK AND RADIO DO NOT LIGHT UP OR WORK WHEN START VEHICLE, SUN ROOF RATTLES AND KNOCKS, WIND GETS CAUGHT BETWEEN ROOF AND HEADLINER WHICH CREATES A LOUD VIBRATION, THE PASSENGER SIDE WINDOW ALSO RATTLES AND KNOCKS, THERE IS A LOUD RHYTHMIC CHIRP TOWARD REAR OF VEHICLE, HEATING AND COOLING CONTROLS SQUEAL WHEN TURNING ON OR SWITCHING VENT SETTINGS, DRIVER'S SEAT FEELS ROUGH WHEN MOVING ON SEAT TRACK, THE 3RD STEERING WHEEL STILL HAS DEFECT UNDER THE LEATHER WHICH PROTRUDES, DRIVER'S SIDE LEATHER SEAT WAS DAMAGED AFTER BEING AT THE DEALERSHIP, 2ND ROW MIDDLE SEAT IS ALMOST IMPOSSIBLE TO LOCK IN FOLDED POSITION, FRONT WINDSHIELD WIPER CONTROL DOES NOT STAY WITHIN SETTING, THE VEHICLE VIBRATES AND THE STEERING WHEEL SHAKES WHEN TURNING THE WHEEL AT A SLOW SPEED, THE THIRD ROW CUP HOLDER ON THE DRIVER'S SIDE DOES NOT STAY DOWN IN THE FITTING, THERE IS A STRONG EXHAUST SMELL IN THE CABIN WHEN ENGINE IS IN HARD ACCELERATION, ENGINE STARTS TO STALL WHILE DRIVING. STEERING WHEEL WAS DEFECTIVE BY BEING MALFORMED CAUSING THE AIRBAG TO BE INEFFECTIVE. THE SECOND STEERING WHEEL WAS ALSO ILL FITTED CAUSING SHARP PROTRUDING PARTS ON THE STEERING WHEEL. THE DEALERSHIP HAS HAD TO REPAIR OR REPLACE THE FOLLOWING: BODY WORK TO DEFECTIVE PAINT ON ROOF, FRONT HOOD, AND DRIVER'S SIDE FENDER. THE DEALERSHIP DAMAGED PAINT IN TWO AREAS AND ONLY PROVIDED TOUCH UP PAINT. REPLACED NOISY REAR WINDSHIELD WIPER MOTOR, REAR HATCH GLASS BECAUSE DEFROST WOULD NOT WORK, REAR HATCH HINGES, DRIVER'S SIDE SEAT TRACK. SUSPENSION PROBLEMS WITH VIBRATION AND PITCHING. VEHICLE LURCHES FORWARD UPON ACCELERATION. *LA

VEHICLE STALLS WHEN COMING TO A COMPLETE STOP. DEALERSHIP CANNOT DUPLICATE THE PROBLEM, AND ARE UNABLE TO FIX IT.*AK

Mileage: 30

CONSUMER STATED THAT WHILE DRIVING AND WITHOUT WARNING THE VEHICLE WILL SURGE FORWARD CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED