2008 MINI COOPER CLUBMAN S Problems & Recalls

The contact owns a 2008 Mini Cooper S. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The contact used an OBD scanner and retrieved a DTC regarding the passenger seat occupant de...

Mileage: 85,000

The contact owns a 2008 Mini Cooper S. The contact stated while driving at an undisclosed speed, the air bag warning light was illuminated. The vehicle was not taken to the dealer or an independent mechanic. The contact used an OBD scanner and retrieved a DTC regarding the passenger seat occupant de...

Mileage: 85,000

MY 2008 MINI COOPER S CLUBMAN APPEARS TO BE HAVING A PROBLEM WITH THE TIM ING CHAIN TENSIONER AND TIMING CHAIN. THE NOISE IS STEADILY GETTING WORSE. AFTER READING ABOUT THE CLASS ACTION LAWSUITS AROUND THE UNITED STATES I AM NOW AFRAID TO DRIVE THE CAR. IF THE TIMING CHAIN DESIRES TO COME APART ON ...

Mileage: 88,000

AIR BAG LIGHT ON.

AIRBAGS DID NOT DEPLOY IN ACCIDENT AT 40MPH DUE TO SENSOR FAILURE. DECELERATION WAS EXTREME ENOUGH TO FRACTURE MY BACK AND CAUSE CHEST INJURIES FROM STRIKING STEERING WHEEL. MINI COOPER REARENDED A SUBURBAN TRUCK THAT WAS STOPPED AT INTERSECTION CAUSING ENGINE TO BREAK LOOSE FROM MOUNTS AND HOOD ...

Mileage: 112,000

I HAVE HAD MAJOR PROBLEMS WITH MY ENGINE EVER SINCE I HAVE HAD MY MINI COOPER S CLUBMAN. THE TURBO IS LOOSE, THERE IS OIL BURNING OFF OF MY ENGINE, AND IT MAKES TERRIBLE SCREECHING SOUNDS THAT COME FROM THE ENGINE. I HAVE JUST LEARNED THAT IT IS COMMON FOR A MINI COOPER TO HAVE PROBLEMS WITH ITS TIM...

Mileage: 76,893

TIMING CHAIN JUMPED OFF OF DEAD CENTER. HAD TO REPLACE TIMING CHAIR TO NEW UPGRADED ASSEMBLY. COST WAS AROUND $1200.00. UPSET BECAUSE THIS HAS BEEN HAPPENING TO A LOT OF MINI COOPERS. SHOULD HAVE SOME KIND OF RECALL TO CONSUMERS. BMW KNOWS ABOUT THIS.WAS DRIVING HOME FROM OUT OF STATE.

Mileage: 121,532

THE TIMING CHAIN WAS REPLACED AT 90,000 MILE AND AND NOW NEED TO BE REPLACED AT 104,000 MILES

Mileage: 104,000

AIRBAG WARNING LIGHT WOULD COME ON INTERMITTANTLY WITH A PASSENGER IN THE SEAT. NOW STAYS ON ALL THE TIME WITH OR WITHOUT A PASSENGER. BAD PASSENGER SEAT MATS ARE UNDER RECALL IN MINI COOPER CONVERTIBLES BUT NOT COVERED IN CLUBMAN. $1200 REPAIR IS REQUIRED AND USES SAME PART AS THE CONVERTIBLE. ...

Mileage: 105,000

VEHICLE STARTED HAVING TROUBLE TURNING ON AND WHEN IT DID COME ON A LOUD CLANKING NOISE BEGAN. THE CAR COULD BARELY GO OVER 30MPH. 3 HR. DRIVE TOOK US ALMOST 6 HOURS TO GET TO DEALERSHIP. DEALERSHIP STATES IT IS THE TIMING CHAIN AND THE OIL PAN NEEDS TO BE REPLACED.WE FOUND EXCESSIVE WATER IN THE SP...

VEHICLE STARTED HAVING TROUBLE TURNING ON AND WHEN IT DID COME ON A LOUD CLANKING NOISE BEGAN. THE CAR COULD BARELY GO OVER 30MPH. 3 HR. DRIVE TOOK US ALMOST 6 HOURS TO GET TO DEALERSHIP. DEALERSHIP STATES IT IS THE TIMING CHAIN AND THE OIL PAN NEEDS TO BE REPLACED.WE FOUND EXCESSIVE WATER IN THE SP...

VEHICLE STARTED HAVING TROUBLE TURNING ON AND WHEN IT DID COME ON A LOUD CLANKING NOISE BEGAN. THE CAR COULD BARELY GO OVER 30MPH. 3 HR. DRIVE TOOK US ALMOST 6 HOURS TO GET TO DEALERSHIP. DEALERSHIP STATES IT IS THE TIMING CHAIN AND THE OIL PAN NEEDS TO BE REPLACED.WE FOUND EXCESSIVE WATER IN THE SP...

THE CAR DEVELOPED ENGINE TROUBLE AT 51,934 MILES. WE CALLED OTTO'S MINI DEALERSHIP AND WERE TOLD THAT THE CAR WAS NO LONGER UNDER WARRANTY. WE THEN TOOK CAR TO A LOCAL REPAIR SHOP AND WERE TOLD THAT THE ENGINE NEEDED REPLACING DUE TO FAULTY TIMING CHAIN THAT RESULTED IN EXTENSIVE DAMAGE TO THE CYLIN...

Mileage: 51,934

THE OIL SUPPLY LINE TO THE TURBO ON THIS CAR LEAKS DUE TO A POOR DESIGN. THE PART(S) USED BY THE MANUFACTURER ARE NOT SUITABLE FOR THE APPLICATION AND FAIL, CAUSING NOT ONLY AN OIL LEAK, BUT A POTENTIAL TURBO FAILURE, AND WORSE, THE POTENTIAL FOR AN ENGINE FIRE, AS THE OIL LEAKS ONTO A HOT TURBO CH...

Mileage: 64,000

THE BANGO FITTING ON TOP OF THE TURBO STARTED RANDOMLY AND EXCESSIVELY LEAKING OIL WHILE IDLING IN MY DRIVEWAY. COULD HAVE CAUSED A FIRE. GOING TO HAVE TO REPLACE THE OIL INTAKE LINE, OIL, AND DO A ENGINE CLEANING. THIS IS VERY DANGEROUS AND COULD HAVE EASILY STARTED A FIRE WITH OIL POURING OVER ...

Mileage: 56,000

WE STARTED OUR 2008 MINI CLUBMAN S IN A PARKING LOT AND IT IMMEDIATELY INDICATED A CHECK ENGINE LIGHT (CEL) FOR 'LIMP' MODE. UPON FURTHER INSPECTION, THE UPPER GUIDE RAIL FOR THE TIMING CHAIN HAD SHATTERED. THE ODBII CODES WERE P0300, RANDOM MIS-FIRE, P0301 MIS-FIRE CYLINDER 1, P0303 MIS-FIRE CYLI...

Mileage: 51,000

I AM DEAF I DRIVE MY 2008 MINI CLUBMAN S MY MOTHER , BROTHER AND FRIEND HEARD MY ENGINE NOISE ENGINE ,I DON'T KNOW I CAN'T HEAR SO I OPEN OIL CAP I SAW BROWN PLASTIC PIECE I FOUND TIMING CHAIN GUIDE IS BAD, THAT IS SHORT LIFE THAT IS WRONG. *TR

Mileage: 92,000

IN NOVEMBER THE DEALER INFORMED ME MY OIL FEED LINES TO THE TURBO WERE LEAKING AND WOULD NEED TO BE REPLACED SOON. AFTER DOING SOME RESEARCH I HAVE FOUND THE COUPLINGS THAT ATTACHES THESE LINES TO THE TURBO ARE DEFECTIVE. ON THE INTERNET THERE ARE HUNDREDS OF COMPLAINTS ABOUT THIS ISSUE. THE DEALER...

Mileage: 40,000

I WAS A VICTIM OF THE "DEATH RATTLE" FROM THE TIMING CHAIN TENSIONER FAILURE. LUCKILY FOR ME, I RESEARCHED THE NOISE WHEN I FIRST HEARD IT AND WAS ABLE TO GET IT FIXED BEFORE IT DESTROYED MY ENTIRE ENGINE (ALTHOUGH MINI REFUSED TO PAY FOR THE REPAIRS). BUT OWNERS WHO ARE NOT AWARE OF ISSUE MAY KEEP ...

THERMOSTAT FAILURE, AS DIAGNOSED BY DEALER. CAR UNDRIVEABLE. WORLD WIDE BAC KORDER ON THE PART FOR 2007-2010 MINI COOPERS. NO KNOWN DATE OF WHEN THE PART WILL BE AVAILABLE (OR IF) AND THE DEALER IN BEDFORD NH, STATED OVER 17,000 OF THESE PARTS ARE ON BACKORDER. A FAILED THERMOSTAT CAN LEAD TO ST...

Mileage: 62,500

WHILE DRIVING UP AN INCLINE ON A SEMI-RURAL ROAD IN ORANGE COUNTY, CA, MY CAR APPEARED TO BE UNABLE TO SHIFT GEARS (IT IS AN AUTOMATIC TRANSMISSION). MY HEAD LURCHED FORWARD AND BACK AGAIN FORCEFULLY, AND I WAS UNABLE TO DRIVE MORE THAN 20 MPH ON A 60 MPH SPEED LIMIT ROAD FOR THE NEXT MILE, UNTIL I...

Mileage: 75,800

WHILE DRIVING UP AN INCLINE ON A SEMI-RURAL ROAD IN ORANGE COUNTY, CA, MY CAR APPEARED TO BE UNABLE TO SHIFT GEARS (IT IS AN AUTOMATIC TRANSMISSION). MY HEAD LURCHED FORWARD AND BACK AGAIN FORCEFULLY, AND I WAS UNABLE TO DRIVE MORE THAN 20 MPH ON A 60 MPH SPEED LIMIT ROAD FOR THE NEXT MILE, UNTIL I...

Mileage: 75,800

THE THERMOSTAT HOUSING HAD A SMALL CRACK IN IT RESULTING IN EXCESSIVE COOLANT LEAK. DUE TO LACK OF TEMPERATURE GAUGE AND NO WARNING LIGHT, I WAS UNABLE TO TELL THAT MY ENGINE WAS OVERHEATING. THIS PROBLEM IS DUE TO A FAULTY PLASTIC THERMOSTAT HOUSING. *TR

Mileage: 62,500

OIL LEAK FROM TOP OF TURBO OIL LINE CONNECTOR NEAR BANJO BOLT. THIS IS DUE TO A FAULTY O-RING FROM THE MANUFACTURER. *TR

Mileage: 65,000

ENGINE HAD A COLD START RATTLE FOR A LONG TIME. THEN WHILE DRIVING, THE RATTLE GOT WORSE AND AFTER BEING DIAGNOSED AT THE DEALERSHIP, IT WAS DUE TO THE PLASTIC TIMING GUIDE BREAKING DUE TO NOT ENOUGH TENSION ON THE TIMING CHAIN. I HAD TO STOP DRIVING IMMEDIATELY AND GET MY CAR TOWED TO THE DEALERS...

Mileage: 62,000

I HAVE AN OIL LEAK ON THE PASSENGER SIDE THAT IS COMING FROM THE TENSIONER LOCATION. THE OIL IS DRIPPING ON THE EXHAUST CAUSING STEAM TO RISE FROM THE ENGINE. I AM AFRAID THAT THE CAR WILL EVENTUALLY BURN ENOUGH OIL TO CATCH ON FIRE. I WILL TOW THE CAR TO BRAMAN MINI PALM BEACH (PURCHASED CAR HERE T...

Mileage: 77,626

I JUST PURCHASED A PRE-OWNED 2008 MINI COOPER S 2MONTHS AGO... I JUST STARTED HAVING A COLD START ISSUE SINCE WHEN I BOUGHT THE CAR IT WAS HOT OUT AND NOW SINCE THE TEMP HAS DROPPED THE CAR HAS A CHATTER COMING FROM THE ENGINE BAY. I HAVE SEARCHED ALL OVER THE INTERNET AND I HAVE SEEN THERE ARE MANY...

Mileage: 34,408

THESE CARS COME WITH A FAULTY TIMING CHAIN. MINI COOPER WON'T DO A RECALL ON THE VEHICLE. I AM HAVING TO PAY 1500.00 TO FIX THIS ISSUE AND THE I HAVE NO WARRANTY. I HAVE HEARD FROM MANY AND SEEN THE REVIEWS ABOUT THIS ISSUE. IT HAPPENS TO VEHICLE OWNERS WITH LESS MILES. MINI NEEDS TO MAKE A RECALL F...

Mileage: 59,000

I OWN A 08 MINI COOPER CLUBMAN WITH 48,000 MILES AND THE WARRANTY JUST RAN OUT ON JUNE 2812: I TOOK IT IN FOR A REPAIR IN MAY AND NO ONE AT THIS DEALER MENTIONED THE TIMING BELT TENSIONER! I WAS DRIVING DOWN MY ROAD AND THANK GOD THE SPEED LIMIT WAS ONLY 35 WHEN SUDDENLY THE BELT JUMPED AND MY CAR L...

Mileage: 48,000

TIMING CHAIN AND TENSIONER FAILURE AT 39K, COMMON PREMATURE FAILURE PART ON THIS ENGINE WHEN I LOOKED ONLINE. WE LOVE OUR CLUBMAN, BUT JUST GLAD IT DIDN'T HAPPEN WHEN WE WERE ON THE INTERSTATE! *TR

Mileage: 39,000

CAR CAUGHT FIRE AND BURNED UP (TOTALED) IN MY DRIVEWAY AFTER IT WAS SHUT OFF. FIRE STARTED IN THE ENGINE COMPARTMENT ABOUT 10 MINUTES AFTER I SHUT IT OFF AND GOT OUT OF THE CAR. IT NEARLY BURNED DOWN MY HOUSE TOO -- FRONT STEPS AND FENCE CAUGHT FIRE BEFORE THE FIRE DEPARTMENT GOT THERE AND EXTINGU...

Mileage: 35,000

SHORT FALL OF TIMING CHAIN TENSIONER CAUSING OIL TO BE PUMPED OUT OF THE ENGINE RESULTING IN CATASTROPHIC ENGINE PROBLEMS AND/OR TIMING CHAIN ISSUES. *TR

Mileage: 70,000

EVERY TIME I COLD START MY 2008 MINI COOPER CLUBMAN S THERE IS A VERY LOUD KNOCKING NOISE, THERE HAS BEEN NO RECALL BUT I WORRY ABOUT THE STABILITY OF THE ENGINE TIMING. *TR

Mileage: 30,192

EVERY TIME I COLD START MY 2008 MINI COOPER CLUBMAN S THERE IS A VERY LOUD KNOCKING NOISE, THERE HAS BEEN NO RECALL BUT I WORRY ABOUT THE STABILITY OF THE ENGINE TIMING. *TR

Mileage: 30,192

SUNROOF SHATTERED WHILE DRIVING ON HIGHWAY. NOTHING HITTING THE SUNROOF, JUST SHATTERED WITH GLASS FALLING INTO THE BACK SEAT. *TR

Mileage: 28,000

THE AIRBAG CONTROL MODULE ON THE MINI COOPER IS UNDERNEATH THE PARKING BRAKE AND DRINK HOLDERS. LIQUID SPILLED FROM THE DRINK HOLDER HAS RENDERED THE MODULE UNUSABLE AND CREATED A SAFETY ISSUE. MINI IS BLAMING THE CUSTOMER FOR THIS ISSUE. *TR

Mileage: 18,000

MINI COOPER CLUBMAN S ROUGH RATTLE IN THE ENGINE COMPARTMENT UPON IGNITION OF THE VEHICLE. SOUNDS LIKE A LIFTER. CONTINUES UNTIL 1 MINUTE OF OPERATION THEN SUBSIDES. *TR

Mileage: 3,000

"PASSENGER AIRBAG IS OFF" LIGHT WILL ILLUMINATE WHILE DRIVING AND WHILE AN ADULT PASSENGER IS SITTING IN THE FRONT RIGHT SEAT. *TR

Mileage: 9,500

WHEN THE WEATHER IS WARMER, SAY 80+, THE PASSENGER AIRBAG DISABLED LIGHT ILLUMINATES WITH A FULL GROWN ADULT SEATED AND BELTED. DEALER, OF COURSE, CANNOT RECREATE. *TR

Mileage: 14,500