2005 MINI COOPER S CONVERTIBLE Steering Problems

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT THE ELECTRIC POWER STEERING WAS FAULTY. MINI OF LOVELAND (4055 BYRD DR, LOVELAND, CO 80538, (970) 292-5020) WAS NOTIFIED OF THE FAILURE, BUT A DIAGNOSTIC APPOINTMENT WAS NOT SCHEDULED. THE DEALER INDICATED THAT THE VEHICLE WAS EXCLUDED FROM EXTENDED WARRANTY PROGRAM: SI M32 02 15 (STEERING AND WHEEL ALIGNMENT). AN INDEPENDENT MECHANIC DIAGNOSED THAT THE POWER STEERING PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS ALSO NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 133,000.

Mileage: 133,000

ELECTRIC POWER STEERING PUMP HAS LOUD WHINE OR MOANING SOUND WITH ONLY 42,000 MILES ON IT. FLUID LEVEL IS GOOD AND SO FAR THE POWER STEERING IS STILL WORKING. IT DOES GET LOUDER WHILE TURNING BUT ALSO ANNOYING WHEN JUST IDLING.

Mileage: 42,000

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT STATED THAT WHEN THE VEHICLE WAS STARTED, IT WAS DIFFICULT TO TURN THE STEERING WHEEL. THE CONTACT STATED THAT THE POWER STEERING ASSIST FUNCTION FAILED TO OPERATE AS INTENDED. THE VEHICLE WAS TAKEN TO THE DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ELECTRO HYDRO POWER STEERING SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 22,000.

Mileage: 22,000

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE. THE CONTACT OBSERVED FLUID LEAKING FROM THE VEHICLE WITHOUT WARNING. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING HOSES NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE CONTACT STATED THAT THE POWER STEERING PUMP FAILED PREVIOUSLY. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

MY MINI COOPER S CONV, 2005, HAS BEEN HAVING STEEERING ISSUES FOR SOME TIME NOW. IT WILL RANDOMLY LOSE WHAT SEEMS LIKE THE POWER STEERING WHILE I AM DRIVING! I HAVE FOUND THAT BY TURNING THE CAR OFF (IF I AM STOPPED AND IN AREA WITH TIME TO TURN OFF MY CAR) THAT IT WORKS AGAIN FOR 10 MINUTES TO 30 MINUTES. OTHER TIMES I CAN DRIVE FOR 45 MINUTES NO PROBLEMS AT ALL. HOWEVER, MORE OFTEN THAN NOT THE STEERING GOES OUT IS NOT WORKING AS SOON AS I TURN THE CAR ON. I K NOW THAT I HAVE TO SELECT A DATE OF WHEN THIS HAPPENED AND I AM PUTTING TODAY'S DATE SINCE IT HAPPENS DAILY. HOWEVER, I WANT IT NOTED IT IS NOT ONLY TODAY.

Mileage: 60,000

I WAS LEAVING WORK LATE AT NIGHT WHEN I TRIED TO DRIVE THE CAR OUT OF THE PARKING LOT THE STEERING DISAPPEARED. IT WAS DIFFICULT TO MANEUVER THE CAR. I HAD THE CAR AT THE MINI DEARLSHIP EARLIER IN THE WEEK TO REPLACE LIGHT BULBS SO I CALLED THE DEALERSHIP TO FIND OUT WHERE WHAT THIS COULD BE, WHERE I COULD CHECK THE POWER STEERING FLUID LEVELS. THEY WERE NOT THAT HELPFUL. THEN LATER I LOOKED ONLINE AT ALL THE STEERING COMPLAINTS AND CALLED THE DEALERSHIP BACK AND WAS TOLD THAT THERE WAS A PROBLEM AND MY CAR (VIN#) WOULD BE COVERED FOR 13 YEARS/150,000. I AM REPORTING THIS BECAUSE ALL MINI'S WITH THIS PROBLEM SHOULD BE COVERED. DEALERSHIPS SHOULD CHECK VEHICLES FOR RECALLS WHEN CUSTOMERS CALL WITH PROBLEMS. I LIKE MY DEALERSHIP BUT I AM DISAPPOINTED THAT I HAD TO RESEARCH THIS DANGEROUS PROBLEM.

Mileage: 100,000

I WAS DRIVING WHEN I SUDDENLY LOSS MY POWER STEERING, MAKING IT DIFFICULT TO STEER THE CAR. *TR

Mileage: 83,000

ON THE FIRST DAY OF OCCURRENCE, THERE WAS LOSS OF POWER STEERING. VERY DIFFICULT AND HARD STEERING. NO WARNING LIGHTS OR NO CHECK ENGINE LIGHTS CAME ON. MANAGED TO PARK SAFELY. STOPPED CAR AND TURNED OFF IGNITION. WAITED A FEW MINUTES. TURNED ON IGNITION AND NORMAL POWER STEERING RESUMED. OCCURRED ONE MORE TIME ABOUT 1 HOUR LATER. OCCURRED MULTIPLE TIMES IN THE COMING DAYS. IF IGNITION IS SHUT OFF THEN TURNED BACK ON, IT WILL RESUME NORMAL OPERATION. THIS HAS ALMOST CAUSED ACCIDENTS BECAUSE OF THE DIFFICULT STEERING AND MAINTAINING OF LANE ESPECIALLY ON CURVED ROADS AND TURNS. *TR

Mileage: 58,400

POWER STEERING PUMP FAILURE RESULTING IN HARD TO STEER SITUATION. *TR

Mileage: 61,000

POWER STEERING SUDDENLY FAILED RESULTING IN NEAR ACCIDENT. UPON REVIEW OF THIS SITE WARRANTY EXTENSION ON POWER-ASSIST STEERING PUMP AND COOLING FAN PUMP WAS ISSUED. DESPITE THE EXTENSION OF WARRANTY AND LACK OF DEALER OR AUTHORIZED SERVICE FACILITY IN LEXINGTON, KENTUCKY, MINI REFUSED TO HONOR WARRANTY UNLESS CUSTOMER TOWED VEHICLE, AT CUSTOMER'S EXPENSE, TO NEAREST AUTHORIZED DEALER WHICH WAS APPROXIMATELY 80 MILES AWAY. LEAVING WARRANTY EXTENSION ON KNOWN PROBABLE DEFECTIVE CONDITION WORTHLESS. BELIEVE INVESTIGATION SHOULD BE PERFORMED TO DETERMINE IF RECALL SHOULD BE ISSUED RELATING TO POWER ASSIST STEERING PUMP FAILURES. *TR

Mileage: 40,732

DRIVING APPROX. 15 MILES - MOSTLY INTERSTATE - TO ATTEND A FRIEND'S BIRTHDAY DINNER. WHILE PULLING INTO THE PARKING LOT, LOST POWER STEERING AND ALL INDICATOR WARNING LIGHTS STARTED FLASHING. I PROCEEDED TO A PARKING SPACE AND SAW SMOKE POURING OUT FROM UNDER THE HOOD. WHEN I RELEASED THE HOOD I COULD SEE AN ORANGE GLOW AT THE BOTTOM OF THE ENGINE (NIGHT TIME). WITHIN 30 SECONDS IT BURST INTO FLAMES. A 911 CALL TO LOCAL FIRE FIGHTERS WAS PLACED WHO RESPONDED WITHIN 15 MINUTES. SINCE THERE WERE TWO RESTAURANTS IN THE COMPLEX, EMPLOYEES OF EACH ONE HAD COME OUT WITH FIRE EXTINGUISHERS AND PUT OUT THE FIRE. THE CAR HAD TO BE TOWED TO MY WORK PLACE, FROM MY WORK PLACE TO ANOTHER CITY FOR REPAIRS. ONLY THE ACTUAL REPAIRS WERE COVERED UNDER WARRANTY, BUT NOT THE TOWING OR RENTALS. I HAD TO RENT A CAR FOR TWO WEEKS AND A WEEK AFTER PICKING MY CAR UP, I HAD OTHER THINGS TO GO OUT ON THE CAR CAUSED BY THE HEAT FROM THE FIRE. (DOMINO EFFECT). THE CAR HAD TO GO BACK INTO A SHOP WHERE IT TOOK MORE THAN 3 WEEKS TO GET ALL PARTS IN AND REPAIRS MADE, WHILE I INCURRED YET MORE EXPENSE OF A RENTAL CAR. I AM NOW IN DEBT ALMOST $3,000.00 AS A DIRECTLY RESULT OF THIS FAULTY SYSTEM. *TR

Mileage: 80,000

CAME HOME ON TUESDAY NIGHT FROM MY GIRLFRIENDS HOUSE THEN IN THE MORNING MY BATTERY WAS DEAD. AS CONFUSED AS I WAS SINCE I KNEW I DIDNT LEAAVE ANY LIGHTS OR ANYTHING ON WENT AHEAD AND DECIDED TO JUMP THE CAR AND AS SOON AS I CONNECTED THE CABLES I HEARD A NOISE ALMOST LIKE A FAN NOISE COMING FROM UNDER THE CAR. I THEN PROCEEDED TO OPEN THE HOOD AND SEE OR TRY AND HEAR WHERE THE NOISE WAS COMING FROM. DECIDED TO LIFT THE CAR UP AND GET UNDERNEATH TO SEE WHERE THE NOISE WAS COMING FROM AND SURE ENOUGH IT WAS FROM INSIDE THE POWER STEERING PUMP. CHECKED FLUIDS AND WAS OK BUT FOR SOME ODD REASON THE PUMP JUST STAYS ON WHEN THE IGNITION IS TURNED OFF SO TO PREVENT BATTERY DRAINAGE I HAVE TO DISCONNECT A BATTERY TERMINAL EVERY TIME I NEED TO USE THE CAR. IM REQUESTING THAT MINIUSA TAKE CARE OF THIS BEING THAT THERE IS A WIDESPREAD PROBLEM WITH THIS ISSUE. *TR

POWER STEERING PUMP ON MY DAUGHTER'S CAR CAUGHT ON FIRE ABOUT THREE (3) WEEKS AGO WHILE SHE WAS STOPPED AT A RED LIGHT, LUCKILY SHE THOUGHT ENOUGH AND TURNED THE CAR OFF SO THE DAMAGE WAS ONLY TO THE POWER STEERING PUMP AND WIRING HARNESS . ONCE WE DISCOVERED WHAT HAD CAUGHT FIRE WE DID RESEARCH ON HOW TO MAKE THE REPAIR(S) AND CAME ACROSS THE RECALL FOR 2005 MINI COOPER S CONVERTIBLES POWER STEERING PUMPS, THEY ARE RECALLING THEM BECAUSE THEY FAIL AND SOMETIMES CATCH FIRE. THE RECALL IS FOR CARS PRODUCED UNTIL FEBRUARY 2005 AND MINE, ACCORDING TO THE DOOR STICKER, WAS PRODUCED IN MARCH 2005 SO MINI WILL NOT MAKE THE NECESSARY REPAIRS BECAUSE THEY SAY THEY 'FIXED' THE ISSUE. ONCE WE GOT UNDER THE CAR AND PULLED THE POWER STEERING PUMP OFF YOU COULD CLEARLY SEE IT WAS BURNED, THE LARGER POWER STEERING PUMP CONNECTOR WAS COMPLETELY BURNED AND MELTED TOGETHER, WE COULDN'T EVEN REMOVE THE PUMP WITHOUT CUTTING THE WIRING HARNESS. WHEN WE GOT THE PUMP OFF YOU COULD SEE THE PUMP WAS BURNED ON THE INSIDE AS WELL SO APPARENTLY THERE IS STILL AN ISSUE WITH THE POWER STEERING PUMPS FAILING AND CATCHING FIRE. I HAVE BEEN IN TOUCH WITH MINI NORTH AMERICA AGAIN AND AGAIN THEY REFUSE TO FIX THE ISSUED BECAUSE WELL, THERE'S NOT AN ISSUE, AGAIN ACCORDING TO THEM. THERE IS A CLASS ACTION LAWSUIT REGARDING THIS ISSUE SO I WILL RESEARCHING THAT AVENUE. *TR

Mileage: 112,500

MY BROTHER WAS DRIVING MY 2005 MINI COOPER S CONVERTIBLE WHEN HE SMELLED WIRES BURNING AND SMOKE, WENT TO PULL OVER AND THE CAR WAS HARD TO CONTROL. UPON INSPECTION THE MECHANIC SAID THAT THE POWER STEER PUMPS ELECTRONICS HAD CAUGHT FIRE AND BURNED THE ADJACENT PARTS. UPON CONTACT RAULPH SCHOMP MINI COOPER DEALER I WAS TOLD THAT MY VIN NUMBER WAS NOT INCLUDED IN THE CARS BEING REPLACED FOR SIMILAR PROBLEMS. THE CAR JUST HAD MAJOR WORK DONE TO THE POWER STEERING SYSTEM A YEAR AND HALF AGO BY THE SAME DEALER. SPOKE WITH THE MINI USA REP AND WAS TOLD THAT THIS WAS NOT BEING COVERED. *TR

Mileage: 86,740

I HAD A TEMPORARY LOST OF POWER STEERING ASSIST. I DROVE TO A FEW BLOCKS TO STOP. THE PROBLEM DISAPPEARED AFTER I RESTARTED THE CAR AGAIN. THIS HAPPENED TWICE BEFORE WHILE MY WIFE WAS DRIVING A MONTH EARLIER OR SO. THIS IS VERY DANGEROUS, I HAD A VERY HARD TIME TO STEER THE CAR AND FIND A SAFE PLACE TO PARK. *TR

Mileage: 77,390

POWER STEERING PUMP COMES ON A SHORT TIME AFTER PARKED AND WILL NOT SHUT OFF. HAVE TO DISCONNECT BATTERY IN ORDER TO AVOID DRAINING POWER. POWER STEERING WHINE PRONOUNCED, POWER STEERING BEGINNING TO WORK INTERMITTENTLY. COMMON PROBLEM AMONG MODEL. *TR

Mileage: 128,000

BOUGHT THE VEHICLE IN FEB. 2012 A FEW MONTHS LATER ON SEVERAL OCCASIONS 15-20 TIMES, TO DATE. I HAVE LOST FULL CONTROL OF THE VEHICLE, NO STEERING CAPABILITY. SEVERAL TIME HAS BEEN WHILE TURNING OR EXITING THE FREEWAY, VEHICLE BECOMES DIFFICULT TO CONTROL. I HAVE BEEN CLOSE TO CAUSING SEVERAL ACCIDENTS DUE TO THE SAME PROBLEM. *TR

Mileage: 70,000

DROVE 8 MILES TO WORK. PARKED CAR AND TURNED IT OFF. SOMETHING KEPT RUNNING UNDER HOOD. I COULD HEAR IT. SOUNDED LIKE A FAN. WHEN LEFT WORK AT END OF DAY, BATTERY WAS DRAINED. HAD TO USE KEY MANUALLY TO GET INTO CAR. CAR WOULD NOT START. CALLED AAA. AAA TRIED TO JUMP START THE CAR. THE GUY GOT IT STARTED, BUT THEN IT SHUT DOWN WHILE HE STILL HAD THE JUMPER CABLES ON IT. HE SAID THAT WASN'T GOOD AND CAR WAS NOT SAFE TO DRIVE, EVEN IF IT COULD BE STARTED. CAR WAS TOWED TO MY HOME. AND THE NEXT DAY CAR WAS TOWED TO MINI DEALERSHIP. MINI SERVICE DIAGNOSED AND FOUND THAT THE ROOT CAUSE OF THE PROBLEM WAS THAT THE POWER STEERING PUMP HAD SHORTED OUT. MINI SERVICE REPLACED THE POWER STEERING PUMP AT A TOTAL COST TO ME OF $1,162.77. *TR

Mileage: 55,252

WAS DRIVING ON AN OVERPASS BETWEEN FREEWAYS WHEN MY POWER STEERING WENT OUT WITHOUT WARNING. I WAS BEGINNING MY TURN, AND COULD NOT CONTROL OR MOVE THE STEERING WHEEL AND HIT THE RAILING. CARS HAD TO DODGE QUICKLY TO NOT HIT ME. TURNED OFF IGNITION AND TURNED BACK ON AND IT WAS FINE - BUT WAS REALLY SHOOK UP. CONTINUED DRIVING TO WORK 3 MILES LATER AND IT DID IT AGAIN PULLING INTO THE PARKING LOT. LATER THAT DAY, STARTED THE CAR AND ONCE AGAIN NO POWER STEERING. HAD IT TOWED HOME, AND CHECKED IT THROUGHOUT THE WEEKEND, WITHOUT SUCCESS (TO GET IT TO A GARAGE) THEN THIS MORNING IT STARTED WORKING. DROVE 1/2 MILE TO GARAGE, AND IT DID IT AGAIN. CALLED BMW SERVICE AND THE MANAGER ACTED LIKE THIS WAS UNUSUAL AND SAID TO MAKE AN APPOINTMENT. CALLED ANOTHER BMW AND THE SAME STORY. CHECKED WITH MY GERMAN MECHANIC DOWN THE STREET AND HE SAID THAT IS THE #1 REASON HE SEES MINI'S 2005 IN THE STOP. 2ND WAS MY CONVERTIBLE TOP, WHICH QUITE IRONICALLY BROKE THE SAME DAY AS MY POWER STEERING. THE PASSENGER SIDE WON'T DISENGAGE. I'M LOOKING AT OVER $3000 TO FIX A CAR WITH ONLY 42K MILES ON IT. SHOULDN'T THESE PARTS BE RECALLED? I WAS SCARED FOR MY LIFE DRIVING ON THE FREEWAY AND ALMOST CAUSED A MAJOR ACCIDENT! *TR

Mileage: 42,000

ELECTRIC POWER STEERING PUMP FAILED WHILE DRIVING, MAKING THE CAR UNDRIVEABLE. *TR

Mileage: 115,000

ELECTRIC POWER STEERING PUMP FAILED WHILE DRIVING, MAKING THE CAR UNDRIVEABLE. *TR

Mileage: 115,000

POWER STEERING PUMP STARTED WORKING INTERMITTENTLY, THEN FAILED. CONTACTED LOCAL MINI DEALER (MIDWESTERN AUTO GROUP), WHO ADVISED THAT I BRING IT IN TO "CONFIRM" AT THE DIAGNOSTIC COST OF $140. WHEN I INQUIRED AS TO WHY I SHOULD PAY A DIAGNOSTIC FEE WHEN I HAD I IDENTIFIED THE PROBLEM, MAG SERVICE MANAGER STATED AT THAT TIME THAT A FULL/PARTIAL REPAIR BY MINI USA WAS "HIGHLY LIKELY" IF I BROUGHT THE VEHICLE IN FOR DEALER SERVICE AND PAID THE FEE. AFTER NEARLY A MONTH OF BACK-AND-FORTH BETWEEN MINI USA, MAG, AND MYSELF NEITHER MINI USA NOR MAG WOULD OFFER ANY REPAIR ASSISTANCE. NEITHER MINI USA NOR MAG WOULD ACKNOWLEDGE THE NHTSA INVESTIGATION, THE RECALL IN CANADA, OR THE NUMEROUS ONLINE COMPLAINTS ABOUT THIS WELL-DOCUMENTED ISSUE. BOTTOM LINE: I EXPERIENCED A "SHAKE DOWN" FROM MAG AND MINI USA IN AN ATTEMPT TO CORRECT A KNOWN SAFETY ISSUE. DEPLORABLE PRACTICE. *TR

Mileage: 60,000

AT RANDOM TIMES, THE POWER STEERING FAILS, MOSTLY AT START-UP, BUT SOMETIMES WHILE DRIVING THE CAR. I ALWAYS NEED TO TURN OFF THE IGNITION, AND RESTART THE CAR, WHICH SEEMS TO TEMPORARILY RE-ENGAGE THE POWER ASSIST STEERING.

Mileage: 55,000

WHILE DRIVING DOWN STRAIGHT ROAD STEERING BEGAN TO INTERMITTENTLY "TIGHTEN UP" AND BECOME DIFFICULT TO MANAGE. ROAD AND WEATHER CONDITIONS WERE CLEAR AND DRY. NEXT MORNING POWER STEERING ASSIST FAILED COMPLETELY WHILE BACKING OUT OF DRIVEWAY, CAUSING VEHICLE TO ALMOST HIT A FENCE. VEHICLE HAD BEEN GARAGED ALL NIGHT AT AMBIENT TEMPERATURES. POWER STEERING UNEXPECTEDLY RETURNED TWO MILES LATER, CAUSING DRIVER TO OVER-CORRECT BECAUSE OF THE SUDDEN RETURN OF POWER STEERING ASSIST. THE INTERMITTENT NATURE OF THIS FAILURE IS THE MOST CONCERNING SAFETY ISSUE, AS THE DRIVER IS UNAWARE THAT EFFORT REQUIRED TO CHANGE LANES OR NAVIGATE A TURN MAY CHANGE DRASTICALLY AND UNEXPECTEDLY. OVER-CORRECTION IN TRAFFIC IS FRIGHTENING. VEHICLE HAS NOT BEEN SUBJECTED TO UNUSUAL OR EXTREME DRIVING CONDITIONS. *TR

Mileage: 65,875

POWER STEERING RANDOMLY COMPLETELY FAILS AT LOWER SPEEDS/ NO ASSIST AT ALL. *TR

Mileage: 101,000

FOR THE PAST 5 YEARS, THE POWER STEERING ON OUR MINI WOULD GO OUT AT RANDOM TIMES. THIS HAS HAPPENED ON THE FREEWAY (AT SPEEDS OF 60-70MPH) AND DRIVING AROUND TOWN (SPEEDS OF 10-35). IT WOULD GO OUT RANDOMLY WITH NO WARNING. MY WIFE COULD BARELY STEER THE CAR AND ALMOST GOT INTO A CRASH TRYING TO TURN RIGHT ONE DAY. LAST WEEKEND, THE POWER STEERING WENT OUT FOR GOOD. WE ARE TAKING IT IN ON MONDAY FOR MINI TO LOOK AT. I HAVE READ COUNTLESS ARTICLES OF THIS PROBLEM AND WANTED TO REPORT IT HAPPENING IN OUR VEHICLE. *TR

Mileage: 71,000

THE POWER STEERING PUMP IN MY 2005 MINI COOPER S CONVERTIBLE INTERMITTENTLY STOPS WORKING 1 TO 5 TIMES PER WEEK. THERE DOES NOT APPEAR TO BE ANY PATTERN TO IT, IT HAS HAPPENED AT COLD START, AFTER WARM START, HOT/COLD/WET/DRY WEATHER, LEVEL/SLOPED PARKING, WHILE DRIVING & STATIONARY, ETC. I'VE LEARNED TO LIVE WITH IT AS AN ANNOYANCE, UNTIL I RECENTLY HAD A VERY FRIGHTENING FAILURE THAT VERY NEARLY HAD *FATAL* CONSEQUENCES. I WAS DRIVING ROUGHLY 25 MPH, THE POSTED SPEED LIMIT, IN A RESIDENTIAL AREA, WHEN A YOUNG CHILD (I ESTIMATE 4-5 YEARS OLD) RAN INTO THE STREET FROM BETWEEN TWO PARKED CARS 5 OR 6 CAR LENGTHS IN FRONT OF ME. I SLAMMED ON THE BRAKES (ABS FULLY ENGAGED) AND ATTEMPTED TO SWERVE INTO THE ONCOMING [EMPTY] LANE AT AVOID... BUT MY STEERING PUMP WAS OUT AND I COULD NOT ALTER MY COURSE SUFFICIENTLY. I CAME TO A STOP WITH THE CHILD BARELY THREE FEET OFF MY FRONT BUMPER! SO NO DAMAGE OR INJURY, BUT... THIS FAILURE COULD EASILY HAVE BEEN MUCH, MUCH WORSE! *TR

Mileage: 51,000

MY DAUGHTER EXPERIENCED COMPLETE POWER STEERING FAILURE WHILE SHE WAS DRIVING HER MINI COOPER, NEARLY CAUSING A COLLISION WITH AN ONCOMING VEHICLE. I DROVE THE CAR AFTERWARD AND COULD NOT BELIEVE HOW HARD IT WAS TO STEER THE CAR (COMPARED TO A MANUAL STEERING VEHICLE). I CALLED MINI AT THEIR TOLL FREE NUMBER AND WAS TOLD THAT THEY HAD NO RECALL NOTICE FROM THE NHTSA, THEREFORE THEY HAD NO OBLIGATION TO FIX THIS INCREDIBLE DEFECT. I HOPE IT DOESN'T TAKE A BODY COUNT FOR THE NHTSA TO RECALL THE 223,000 MINI'S EFFECTED BY THIS EXTREMELY DANGEROUS DEFECT. *KB

Mileage: 30,000

MY DAUGHTER EXPERIENCED COMPLETE POWER STEERING FAILURE WHILE SHE WAS DRIVING HER MINI COOPER, NEARLY CAUSING A COLLISION WITH AN ONCOMING VEHICLE. I DROVE THE CAR AFTERWARD AND COULD NOT BELIEVE HOW HARD IT WAS TO STEER THE CAR (COMPARED TO A MANUAL STEERING VEHICLE). I CALLED MINI AT THEIR TOLL FREE NUMBER AND WAS TOLD THAT THEY HAD NO RECALL NOTICE FROM THE NHTSA, THEREFORE THEY HAD NO OBLIGATION TO FIX THIS INCREDIBLE DEFECT. I HOPE IT DOESN'T TAKE A BODY COUNT FOR THE NHTSA TO RECALL THE 223,000 MINI'S EFFECTED BY THIS EXTREMELY DANGEROUS DEFECT. *KB

Mileage: 30,000

MY 2005 MINI COOPER S CONVERTIBLE HAD A FIRE IN THE ENGINE COMPARTMENT REPORTEDLY CAUSED BY THE FAILURE OF THE POWER STEERING PUMP. I PULLED INTO MY DRIVEWAY AND TURNED OFF MY CAR. I HAD NO PROBLEM STEERING THE CAR UP TO THAT POINT. I GOT OUT AND WENT INTO THE HOUSE. MY WIFE CAME INSIDE AND TOLD ME MY CAR SMELLED FUNNY AND WAS SMOKING (LIGHT) UNDER THE HOOD. I RAISED THE HOOD AND SMOKE WAS COMING OUT FROM UNDER THE HEAT SHIELD IN THE REAR OF THE ENGINE, WHICH IS BELOW THE POWER STEERING RESERVOIR AND ABOVE THE PS PUMP. I COULD HEAR SIZZLING, WHICH I INTERPRETED AS WATER. I WENT INSIDE TO CALL A MECHANIC FRIEND AND THEN REALIZED IT WASN'T A GOOD IDEA TO LEAVE A SMOKING CAR ALONE. WHEN I CAME OUTSIDE AGAIN, THE SMOKE HAD TURNED DARK AND HEAVIER. WHEN I REACHED THE CAR, I COULD SEE A RAGING FIRE BELOW THE HEAT SHIELD. I RAN INTO MY GARAGE AND RETURNED WITH A FIRE EXTINGUISHER WHICH I USED TO PUT OUT THE FIRE. I HAVE BEEN TOLD BY MY INSURANCE ADJUSTER THAT THE PUMP CAUSED THE FIRE AND THEY WOULD ONLY REIMBURSE FOR THE DAMAGE CAUSED BY THE POWER STEERING PUMP, NOT FOR THE PUMP ITSELF. I WAS TOLD THAT PS FAILURE IS A COMMON PROBLEM ON MINI COOPERS OF MY YEAR (AS WELL AS MANY OTHERS) AND MODEL. AFTER CHECKING THE INTERNET, I DON'T UNDERSTAND WHY THERE HAS NOT BEEN A MFGR.'S RECALL AND WHY THERE HAS NOT BEEN A NHTSA INVESTIGATION. THIS COULD HAVE BEEN VERY CATASTROPHIC! *TR

Mileage: 43,000

2005 MINI COOPER S CONVERTIBLE WITH 65K MILES. ORIGINAL OWNER. YESTERDAY MY POWER STEERING WENT OUT AS I DROVE HOME FROM WORK. NO WARNING SIGN AND IT WAS HARD TO TURN THE STEERING WHEEL AND MANEUVER THE CAR. I WAS GLAD IT WAS ME DRIVING AND NOT MY WIFE. SCARY EXPERIENCE WHEN DRIVING AT 65MPH+ ON THE HIGHWAY. *TR

Mileage: 64,500

BOUGHT MINI COOPER USED FROM DEALER JUST PRIOR TO GOING TO FLORIDA FOR 2 WKS. WHEN ALMOST HOME FROM FLORIDA POWER STEERING WENT OUT. MY 3000 MILE USED CAR WARRANTY HAD JUST RAN OUT SO CHECKED ON RECALLS, FOUND NONE. BUT I DID FIND OUT THERE WAS AN INVESTIGATION IN PROGRESS. CONTINUED TO DRIVE VEHICLE OCCASIONALLY AND FOUND THE STEERING SOMETIMES WORKED AND AGAIN WOULD CUT OUT WITH NO WARNING, MAKING IT DIFFICULT TO STEER WHEN NOT EXPECTED. THEN ONE DAY I CAME HOME AND SHUT THE VEHICLE OFF BUT THE STEERING PUMP WOULD NOT SHUT OFF. I HAD TO DISCONNECT THE BATTERY TO GET IT TO STOP. WHEN I RECONNECTED THE BATTERY IT WOULD START RIGHT BACK UP AGAIN. THAT'S WHEN I DECIDED I NEEDED TO BITE THE BULLET AND TAKE IT IN TO BE FIXED. I RECONNECTED THE BATTERY AND DROVE IT TO A MINI COOPER DEALER WHO TOLD ME IT WAS THE STEERING PUMP THAT WAS BAD, THAT IT HAD INTERNAL ELECTRONICS THAT FAIL. I HAD THEM REPLACE IT FOR A TOTAL COST OF $1072.38 AND THAT CAME WITH A 2 YR WARRANTY. PLEASE NOTE ~ THE VEHICLE HAD A WHIRRING NOISE WHEN I BOUGHT IT THAT I THOUGHT WAS FROM THE TURBO. I FOUND OUT LATER IT WAS THE STEERING PUMP MAKING THE NOISE. WHEN THE NEW PUMP WAS INSTALLED IT WAS A LOT QUIETER. *TR

Mileage: 69,500

POWER STEERING FAILURE. *TR

Mileage: 46,000

THE CAR ( 2005 MINI COOPER) WAS COMPLETELY DEAD OVERNIGHT. WE CHARGED THE BATTERY AND A FAN WOULDN'T TURN OFF WHICH MUST HAVE CAUSED THE DRAIN. WE HAD IT FIXED. IT WAS A FAULTY RELAY IN THE POWER STEERING PUMP, WHICH HAD ALSO BEEN LEAKING ONTO THE ENGINE. READ ON THE INTERNET THAT THOUSANDS OF PEOPLE ARE HAVING THIS VERY ISSUE. WE SPENT $1,000 TO FIX THIS ON A CAR WITH 40,000 MILES! *TR

Mileage: 40,000

2005 MINI COOPER S CONVERTIBLE - PENDING A SECOND REPLACEMENT OF THE POWER STEERING PUMP/COOLING FAN ASSEMBLY DUE TO FAILURE - THE WHOLE ASSEMBLY WAS REPLACED 18 MONTHS AGO AND THE REPLACEMENT FAN HAS ALREADY STOPPED RUNNING, CAUSING A SEVERE LEAK OF PS FLUID (TWICE FOUND COMPLETELY EMPTY) AND RESULTANT POWER STEERING FAILURE. FIRST FAILURE SUMMER 2008, REPEAT FAILURE WINTER 2010. *TR

Mileage: 98,000

I OWN A 2005 MINI COOPER S CONVERTIBLE & NOTICED MY POWER STEERING STARTING TO MAKE NOISE ABOUT A WEEK AGO. NOW IT IS WORKING VERY INTERMITTENTLY. I HAVE NOTICED IN DOING SOME RESEARCH THAT MANY OTHERS HAVE HAD THIS PROBLEM. I TOOK IT TO THE DEALER AN THEY WANT TO REPLACE MY POWER STEERING PUMP WHICH IS GOING TO BE VERY COSTLY. I AM TO SAY THE LEAST A LITTLE DISAPPOINTED THAT A CAR WITH THE BMW NAME ON IT IS HAVING THIS MANY COMPLAINTS. *TR

POWER STEERING QUIT UNEXPECTEDLY. I WAS IN A PARKING LOT, JUST STARTED THE CAR, AND HAD NO POWER STEERING. I DROVE IT A FEW MILES DOWN THE ROAD TO A GAS STATION, TURNED IT OFF, AND WHEN TURNED BACK ON AGAIN IT WORKED FINE. ORIGINALLY HAPPENED ON 2/12/11 AND HAS NOT RECURRED AS OF 2/22/11. *TR

Mileage: 105,600

2005 MINI COOPER 'S' CONVERTIBLE. THE POWER STEERING WILL OCCASIONALLY STOP WORKING WHILE DRIVING MAKING IT DIFFICULT TO STEER. IF YOU SHUT OFF THE ENGINE AND RESTART THE CAR IT RESETS AND WORKS AGAIN. IT NORMALLY HAPPENS WHEN SLOWING FOR A STOP OR MAKING A TURN, WHICH YOU DON'T NOTICE UNTIL YOU START MOVING AND FIND YOU ARE UNABLE TO TURN THE CAR. LUCKILY I HAVEN'T PULLED OUT INTO ONCOMING TRAFFIC. THE DEALER SAID IT WAS PROBABLY THE PUMP AND THEY WOULD REPLACE IT FOR APPROXIMATELY $680. *TR

Mileage: 28,000