2007 MINI COOPER S Engine Problems

VEHICLE WAS STATIONARY IN MY DRIVEWAY, WAS NOT STARTED AND WAS UNATTENDED, HAD NOT BEEN STARTED IN OVER A WEEK AND KEYS WERE NOT IN THE VEHICLES. THE VEHICLE SPONTANEOUSLY BURST INTO FLAMES WHICH BURNED THE ENGINE BAY AND FRONT END OF THE CAR BEFORE THE FIRE DEPT. ARRIVED AND EXTINGUISHED THE FIRE WITH FOAM. THE CAR HAD BEEN SITTING UNSTARTED FOR OVER A WEEK. I AM UNSURE OF WHAT CAUSED THE FIRE AND BECAUSE OF THE EXTENSIVE DAMAGE TO THE ENGINE BAY I COULD NOT DETERMINE WERE THE FIRE ORIGINATED. PERHAPS A PROFESSIONAL FIRE EXAMINER COULD DETERMINE THAT. I AM BLESSED THAT THIS DID NOT HAPPEN WHILE PARKED IN MY GARAGE BUT WAS SCARY. I JUST WANT THIS INCIDENT ON RECORD SO THAT OTHERS WHICH OWN THIS PARTICULAR TYPE OF VEHICLE CAN BE WARNED ABOUT THE POTENTIAL DANGERS. I HAVE OWNED THIS VEHICLE SINCE NEW AND HAD A COUPLE OF UPDATES DONE PER BMW SUCH AS THE TAILPIPES AND TIMING CHAIN IN THE ENGINE. I WAS NOT AWARE OF ANY ADDITIONAL RECALLS OR UPDATES BUT APPARENTLY THERE HAVE BEEN SOME INCIDENCES OF FIRES SUCH AS MINE WHICH I LEARNED ABOUT AFTER SEARCHING THE INTERNET TO SEE IF SIMILAR ISSUES HAD BEEN DOCUMENTED. I WILL ATTACH A FEW PICTURES FOR YOU TO HELP WITH YOUR ASSESSMENT. THANK YOU FOR YOUR TIME AND CONSIDERATION. I HOPE THIS INFORMATION WILL BE SOME HELP TO OTHERS IN PREVENTING A SIMILAR SITUATION. I THANK GOD NO ONE WAS INJURED OR PROPERTY DAMAGED OTHER THAN MY CAR. THE FIRE DEPARTMENT MADE A REPORT BUT IT DID NOT INCLUDE INVESTIGATING THE CAUSE JUST A RESPONSE TO A FIRE. *TR

Mileage: 92,000

THE TURBOCHARGER HAD TO BE REPLACED, NEW TURBO GOT HOT AND MELTED THE VALVE COVER. THEN THE TURBOCHARGER CAUGHT FIRE WHILE IN MOTION IN A RURAL NEIGHBORHOOD. ALL WITHIN 6 MONTHS.

Mileage: 153,368

TIMING CHAIN TENSIONER BROKE AND MESSED UP THE ENGINE

Mileage: 100,000

MY VEHICLE IS CURRENTLY @ BRAMAN BMW WPB (5612423210) FOR A TIMING CHAIN PROBLEM WHICH WAS UNDER RECALL. THE SERVICE ADVISOR CALLED ME AND NOTIFIED ME THAT THE TIMING CHAIN BROKE INSIDE THE ENGINE & COMPLETELY DESTROYED THE MOTOR. TE TIMING CHAIN JOB ALONE ESTIMATE IS $3800, BUT THEYVE NOTIFIED ME THAT THE ENGINE IS UNREPAIRABLE & MUST BE REPLACED! THEY ALSO FAILED TO ACKNOWLEDGE THAT THIS HAPPEN WHILST DRIVING ON AN INTERSTATE, ALMOST CAUSING A HUGE ACCIDENT!! PLEASE HELP!! MINI APPARENTLY CARES MORE ABOUT MONEY THAN LIVES!!

Mileage: 80,000

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THERE WAS A CATASTROPHIC ENGINE FAILURE WITHOUT WARNING. THE VEHICLE WAS UNABLE TO BE DRIVEN AND WAS TOWED TO BRAMAN MINI OF PALM BEACH (2815 OKEECHOBEE BLVD, WEST PALM BEACH, FL 33409, (561) 257-4774). THE DEALER INDICATED THAT THE MANUFACTURER SERVICE CAMPAIGN WAS ONLY TO ADDRESS REPLACING THE TIMING CHAIN AND THAT THE REPLACEMENT OF THE ENGINE ASSEMBLY WAS NOT INCLUDED IN THE MANUFACTURER'S GUIDELINES OF THE SERVICE CAMPAIGN. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER TO DETERMINE IF THEY COULD APPROVE THE DEALER REPLACING THE TIMING CHAIN AND THE ENGINE ASSEMBLY. THE FAILURE MILEAGE WAS NOT AVAILABLE.

THERE WAS A RECALL FOR THE TIMING CHAIN, SO I HAD IT REPLACED IN THE RECALL PROGRAM THAT WAS OFFERED THROUGH MINI COOPER. LESS THEN 2 YEARS LATER, MY TIMING CHAIN BROKE AGAIN, AND HAS DAMAGED THE MOTOR OF MY CAR. IT WOULD NOT START

Mileage: 89,000

TIMING CHAIN MAKING LOUD NOISE WHEN STARTED

THIS CAR HAS BEEN A CONSISTENT USER OF OIL. IT USES A QUART AT ABOUT 500 MILES. THIS ENGINE HAS A REPUTATION FOR PROBLEMS ON MINI COOPER S MODELS AND THE PEUGEOT MODELS WITH THAT SAME ENGINE. I'VE HEARD THAT LATER MODELS DON'T BURN OIL. I'D LIKE TO KNOW WHY BMW HAS NOT RECALLED THEM. FIRST THE TIMING CHAIN, COOLING SYSTEM AND HIGH PRESSURE FUEL PUMP., THEY PAID FOR THE TIMING CHAIN AND THE FUEL PUMP.

Mileage: 100,000

MINI COOPER S - NUMEROUS ISSUES FOUND HAVING PURCHASED A USED 2007 MINI COOPER S FROM A SMALL DEALER IN TALLAHASSEE, FLORIDA, WE DID OUR RESEARCH UP-FRONT WITH A 'CARFAX REPORT' WHICH SHOWED NO ISSUES, WE ALSO DID A VIN DATABASE SEARCH FOR RECALLS AND FOUND NO OPEN RECALLS AND ASSUMED THAT IT WAS SAFE TO PURCHASE WHICH WE DID FOR JUST OVER $5,000. NOW THAT WE ARE NEARING A YEAR INTO OUR 4-YEAR PAYMENT PLAN, ON JANUARY 17, 2016, MY WIFE WAS DRIVING NORTH ON I-75 IN GEORGIA AND AT APPROX. MILE MARKER 211, THE ENGINE SEIZED AND SHE REQUIRED A TOW OFF THE INTERSTATE. LUCKILY, THERE WAS NO ACCIDENT OR INJURY- BUT IT SEEMS THAT WOULD HAVE HELPED OUR CASE' UPON ATTEMPTING REPAIRS, WE FIND NUMEROUS ISSUES WITH THE ENGINE (2007 R56/N16 4 CYLINDER TURBOCHARGED) INCLUDING TIMING CHAIN, WATER PUMP, VACUUM PUMP, ETC' BELOW ARE PHOTOS OF REMOVED PARTS FROM THE ENGINE ' THE VACUUM PUMP SEIZED AND BENT THE METAL COMPONENTS ' SINCE THIS IS CONNECTED TO THE 'EXHAUST CAMSHAFT', WHEN IT SEIZED IT SEIZED THE EXHAUST CAMSHAFT ' ON THE OPPOSITE END OF THIS CAMSHAFT IS A SPROCKET WHICH CONNECTS THE TIMING CHAIN (ANOTHER KNOWN ISSUE WITH THIS VEHICLE) ' THE BOLT AND SPROCKET DROPPED INTO THE ENGINE AND TIMING CHAIN AREA, CREATING A CATASTROPHIC FAILURE WHICH IT APPEARS WE ARE GOING TO BE 'LEFT HOLDING THE BAG' FOR

Mileage: 177,765

ENGINE, THERMOSTAT, GASKET, RADIATOR, COOLANT TUBE, AND BATTERY WENT OUT ON THE V AT THE SAME TIME. IT WAS RUNNING ROUGH AND JUST STOP RUNNING.

Mileage: 87,555

WE ARE A SECOND OWNER OF THIS MINI COOPER HAD IT ABOUT A YEAR. TURN THE CAR ON AND HEAR A RATTLE IN MOTOR. WORSE WHEN IT'S COLD. TOOK IT IN TO BE CHECKED IT THE TIMING TENSIONER. APPARENTLY THERE HAS BEEN AN ISSUE WITH THIS FOR SOMETIME. REPAIR COST IS AROUND $2000. CAR ONLY HAS 76,000 MILES THIS PART SHOULD BE PROVIDED UNDER WARRANTY. BUT WHEN IT BREAKS IT AFFECTS THE MOTOR AS WELL BECAUSE IT IS METAL IT TEARS THE MOTOR UP. MAKING A 10 DOLLAR PART COST THOUSANDS OF DOLLARS FOR REPAIR. I DON'T FEEL LIKE I AM LIABLE FOR THE EXPENSE THAT MINI KNEW WAS A PROBLEM AND NEVER RECALLED.

Mileage: 76,000

ENGINE WAS RUNNING EXTREMELY ROUGH AND VERY LOUD ENGINE NOISE RATTLE. TOOK THE CAR TO MINI COOPER SERVICE DEPARTMENT IN JACKSONVILLE FOR DIAGNOSTIC THEY NEED TO REPLACE THE TIMING CHAIN, THEY WANT TO CHARGE ME OVER 2,800. WHEN MY UNDERSTANDING THIS ISSUE WAS ADDRESSED BY A RECALL TO BE REPAIR WITHOUT CHARGE.

Mileage: 70,705

OIL FEED LINE LEAKING ON TURBO

Mileage: 62,000

I ARRIVED IN COUNTRY 2007 HAVE HAD PROBLEM WITH THE CK ENGINE LIGHT AND NOISE FROM THE ENGINE, THE LARGE CHECK ENGINE OVER STERING WHEEL BLK AND ENGINE LIGHT IN HECTOR METER ORANGE. IVE HAD IN SHOP MANY TIME FOR THIS PROBLEM LATEST WAS SEPT 2015 SAID TO CARBIN $1232.00 DECEMBER 2015 $599.00 DRIVING MINIUM THE ENGINE RUN WHEN THE CAR IS ENGINE IS OFF. ALSO PK UP HILL THE WILL MOVE WHEN THE EMG BKS OR UP AND GEIR IN NUTURAL.

Mileage: 23,000

ENGINE FAILURE OCCURRED WHEN DRIVING ON MAJOR FREEWAY AT POSTED SPEED LIMITED OF 75 MPH. PULLING OFF ON SLIP ROAD DUE TO ENGINE STOPPING. ONLY AFTER FULL STOP DID ENGINE WARNING LIGHTS COME ON. CHECKED UNDER HOOD AND FOUND COOLANT HAD EVACUATED THE SYSTEM. ENGINE WOULD NOT RESTART. TOWED TO MECHANIC AND FOUND THAT THE GEAR SHIFTER HAD WORN THROUGH COOLANT HOSE DUE TO ENGINEERING DEFECT.

Mileage: 90,000

TIMING CHAIN REPLACED AT 32K, JUST FAILED AGAIN AT 92K WITH MOBIL ONE OIL AND FILTER CHANGES EVERY 5K MILES. CHAIN JUMPED IN GARAGE DURING SHUT DOWN OF ENGINE. WOULD NOT RESTART. I CHECKED SPARK, FUSES FOR PRIMARY FUEL PUMP AND MADE A JUDGEMENT THAT IT WAS A FAILURE OF THE HIGH PRESSURE FUEL PUMP AND TOWED IT TO THE DEALER FOR WARRANTY REPLACEMENT. GOT THE CALL THE TIMING CHAIN JUMPED A LINK AND I WOULD NEED A REPLACEMENT AGAIN. CAN'T BELIEVE IT . THIRD CHAIN WITH GOOD LUBRICATION MAINTENANCE IN UNDER 92K.

Mileage: 92,000

WHEN DRIVING DOWN THE HIGHWAY AT 60 MPH, THE ENGINE LOST POWER AND HAD A HARD TIME GETTING IT TO THE NEAREST EXIT FOR SAFETY. WHEN I STOPPED THE CAR I ATTEMPTED TO CHECK THE FLUID LEVELS BUT THE CAR WAS TOO HOT TO CHECK AND I WAITED FOR ABOUT AN HOUR TO COOL. WHEN I WAS ABLE TO CHECK ALL LEVELS DOWN, INCLUDING THE OIL, WHICH I JUST HAD A CHANGE IN LESS THAN A WEEK PREVIOUS TO THIS INDENT. THE OIL LEVEL WAS DOWN 2 1/2 QUARTS AND THE WATER LEVEL WAS BELOW THE SAFETY LEVEL. WHEN I TOOK IT TO MY INDEPENDENT CERTIFIED BMW MECHANIC, HE ADVISED THAT THE TIMING BELT NEEDED TO BE REPLACED. I CALLED BMW AND MINI CORPORATE OFFICES AND THEY BOTH STATED THAT I SHOULD TAKE IT TO THE DEALERSHIP AND THEY MAY BE ABLE TO FIX AT A REDUCE COST. UPON FURTHER QUESTIONING, AND THEM STATING THAT THEY MAY NOT ASSIST DUE TO AGE, I CAME TO THE CONCLUSION THAT THE LIKELIHOOD OF THEM ASSISTING WAS ZERO. THEY STATE THAT THE WARRANTY WAS NO LONGER COVERING AND THAT THE CAR HAD TOO MANY MILES, 85K. I PREVIOUSLY HAD THE THERMOSTAT REPLACED, THE AIR INTAKE VALVE REPLACED, THE OIL PUMP REPLACED, AND NOW THE TIMING BELT TO THE SUM OF $4300 IN THE PAST YEAR AND HALF. WILL NEVER PURCHASE ANOTHER AND WILL NEVER ENCOURAGE ANYONE ELSE TO PURCHASE A BMW OR MINI PRODUCT. I WILL PAY AND CONTINUE TO DRIVE, BUT WILL PUT A MESSAGE ON IT TO NOT ASK ME OR COMMENT ON THE "CUTENESS" OF THE CAR BECAUSE IT IS A PIECE OF JUNK! I WOULD HAVE EXPECTED TO GET AT LEAST 200K OUT OF IT BEFORE THESE MAJOR REPAIRS SHOULD HAVE EVER OCCURRED! VERY FRUSTRATED, NOT TO MENTION DISAPPOINTED IN THIS HIGH PERFORMANCE VEHICLE THAT SELLS ITSELF WITH A SIMPLE DRIVE, BUT MECHANICALLY IS NOT SUPPORTED BY ITS MANUFACTURER.

Mileage: 85,000

THIS IS A COMPLAINT AGAINST THE TIMING CHAIN AND TENSIONER FOR THE MINI COOPER WHICH IS KNOWN TO BE FAULTY. THE TIMING CHAIN HAD BEGIN RATTLING AND WAS INSPECTED AT A MINI DEALERSHIP. THEY STATED THAT IT'S A KNOWN ISSUE WITH MINI. REPAIR FOR THIS JOB IS 3800 USD. THIS IS A TREMENDOUS PRICE TAG.THIS CAN LEAD TO A VERY VERY DANGEROUS SITUATION ON THE HIGHWAY HEADING TO WORK. *TR

Mileage: 65,000

IN 2013 MY MINI STARTED TO OVERHEAT. I HAD THE FLUIDS CHECKED AND EVERYTHING WAS OK. I DROVE APPROX., 10 MILES AND THE CAR COMPLETELY OVERHEATED, THE OIL LIGHT CAME ON AND THE CAR SMOKED AND ALMOST CAUGHT ON FIRE. I HAD IT TOWED TO THE DEALERSHIP (MINI NORTHWEST IN FIFE WA,) THEY SAID THERE WERE NO RECALLS AND I NEEDED A NEW MOTOR AND COOLING SYSTEM. I PAID 7500$$ FOR A NEW ENGINE INSTALLED BY THE MINI DEALERSHIP IN JULY 2013 AT MY OWN EXPENSE. ON DEC, 23RD 2014 I DROVE MY MINI APPROX. 12 MILES AND PARKED THE CAR IN THE DRIVEWAY. THE CAR WAS NOT OVERHEATING, NO WARNING LIGHTS CAME ON, 15 MINUTES LATER THE CAR HAD FLAMES SHOOTING OUT FROM THE HOOD. FIRE EXTINGUISHER WOULD NOT PUT OUT THE FIRE. THE CAR THEN MOVED APPROX. 5 FEET FORWARD UP AGAINST THE HOUSE AND BECAME COMPLETELY ENGULFED. THE TIRES BLEW UP THE SUNROOF BLEW UP AND THEN THE BACK WINDOW BLEW OUT. THE CAR IS A COMPLETE LOSS. MINI CLAIMS THEY HAVE NEVER HEARD OF THIS BEFORE, YET THERE ARE SEVERAL ARTICLES OF THE SAME THING HAPPENING TO OTHER CARS, INCLUDING A CLASS ACTION SUIT AND RECALLS. *JS

Mileage: 107,000

THIS IS A COMPLAINT AGAINST THE TIMING CHAIN AND TENSIONER FOR THE MINI COOPER WHICH IS KNOWN TO BE FAULTY. THE TIMING CHAIN HAD BEGIN RATTLING AND WAS INSPECTED AT A MINI DEALERSHIP. THEY STATED THAT IT'S A KNOWN ISSUE WITH MINI. REPAIR FOR THIS JOB IS 2000 USD. THIS IS A TREMENDOUS PRICE TAG.THIS CAN LEAD TO A VERY VERY DANGEROUS SITUATION ON THE HIGHWAY HEADING TO WORK. IMAGINE GOING 65 ON THE HIGHWAY THE CHAIN SNAP. LOST POWER AND CONTROL OF THE CAR. NOT ONLY THE DRIVER IS AT RISK BUT OTHER AS WELL. WHAT IF IT CAUSE A FAMILY IN THE CAR AN ACCIDENT. LET'S SAY 3 CAR WERE INVOLVED FILLED WITH FAMILIES BUT ONE PERSON DIED. YOU ARE CAUSING A LIFETIME OF HEARTACHE FOR NOT ACKNOWLEDGING THE FAULT IN YOUR ENGINE. PLEASE BE AWARE THAT PEOPLE LIVES ARE AT STAKE. IT'S BETTER THAT MINI SHOULD TAKE RESPONSIBILITY. IS MONEY SO MUCH MORE IMPORTANT TO MINI THAN THE LIVES OF PEOPLE. THE LIVES OF FAMILIES. IF FUTURE ACCIDENT CAN BE AVOIDED. IT MUST START NOW. DO THE RIGHT THING AND MAKE THIS RECALL HAPPEN. DON'T LET ME START ON CARBON BUILDUP. ENGINE DESIGN WASN'T TESTED THOROUGHLY. EVERYONE SHOULD BE GIVEN A COURTESY CLEAN EVERY 70000 MILES OR SO. ALREADY SHOW SIGN OF CARBON BUILDUP WITH 48K MILES. *TR

Mileage: 48,000

ON 27-OCT-2014, WHEN I WAS DRIVING HOME THE CHECK ENGINE LIGHT CAME ON AND IT GAVE A MESSAGE ABOUT THE CATALYTIC CONVERTER. LUCKILY I WAS CLOSE TO HOME AND THE MESSAGE JUST SAID TO SLOW DOWN WHICH I DID. I HAD IT TOWED TO A LOCAL MECHANIC THE NEXT DAY SINCE IT WAS NOT DRIVABLE.IT WAS REAL SHAKY AND DIDN'T FEEL SAFE TO DRIVE WHEN I STARTED THE ENGINE. THEY HAD THE VEHICLE FOR 3 DAYS AND CHECKED EVERYTHING FROM THE COILS, SPARK PLUGS, RAN A COMPRESSION TEST WHICH SHOWED THAT CYLINDER 3 WAS NOT GETTING ENOUGH POWER, ETC. THEY STATED THAT THERE WERE NO LEAKS OR FLUIDS FOUND IN THAT AREA LIKE THEY HAD EXPECTED SINCE THAT WAS THE ONLY CYLINDER THAT WAS NOT RUNNING PROPERLY. I CONTACTED MINIUSA TO SEE IF THEY WOULD FIX THE VEHICLE OUT OF GOODWILL BECAUSE THIS WAS A KNOWN ISSUE WITH THESE VEHICLES/ENGINES (R56). NEEDLESS TO SAY, MINIUSA WOULD NOT FIX THE REPAIR NOR WOULD THEY RESPOND TO MY EMAILS. MINI OF CONCORD OFFERED TO COVER 25% OF THE COST LEAVING ME TO PAY $3600 OUT OF POCKET FOR SOMETHING THAT THEY KNOW IS FAULTY. THIS IS UNACCEPTABLE. *TR

Mileage: 99,700

MINI USA WAS WELL AWARE OF THE MASSIVE TIMING CHAIN PROBLEM (AFFECTING 500,000 MINI COOPERS),BUT REFUSED TO FIX IT BECAUSE IT WAS OUT OF WARRANTY. I'VE COMPLAINED OF THE CANTANKEROUS RATTLE DURING A COLD START WHICH WAS CLEARLY RELATED TO THE FAILING TIMING CHAIN DUE TO A DEFECTIVE AND POORLY DESIGNED TIMING CHAIN TENSIONER. (APPARENTLY MINI HAS COME OUT WITH A NEW ONE DUE TO THIS PROBLEM). THE DEALERSHIP QUOTED ME $1800 TO REPLACE THE WHOLE CHAIN ASSEMBLY. I ULTIMATELY TOOK IT AN INDEPENDENT MINI MECHANIC AND HAD IT REPLACED FOR LESS ($1144). NOW I AM HEARING THAT MINI DEALERSHIPS ARE REPLACING THIS DEFECTIVE PART BEYOND THE WARRANTY PERIOD. I BELIEVE THAT THERE IS NOW A CAMPAIGN TO REPLACE THE TENSIONER AND CHAIN. THEY SHOULD HAVE REPLACED IT WHEN THE PROBLEMS WERE OBVIOUS AND SHOULD NOW COMPENSATE THOSE WHO'VE PAID OUT OF THEIR OWN POCKETS FOR THIS POORLY DESIGNED PART. *TR

Mileage: 48,934

MY CAR STARTED TO ACT FUNNY. ALMOST SOUNDING LIKE IT WAS SUFFOCATING. IT WOULD DIE ABOUT TEN TO FIFTEEN TIMES EVERY MORNING BEFORE I WOULD FINALLY GET THE CAR STARTED. IT WOULD SHUT OFF WHEN I STOPPED AT INTERSECTIONS. THE ONLY TIME IT RAN DECENT WAS WHEN I WAS DRIVING HIGHWAYS SPEEDS FOR 20 MINUTES OR MORE. I CHANGED OUT FILTERS, SPARK PLUGS, AND FLUIDS BUT NONE OF IT CHANGED THE WAY IT WAS RUNNING. COME TO FIND OUT IT THAT THE CHAIN AND CHAIN TENSIONER HAD BROKEN. THIS DAMAGE CAUSED ROUGHLY $1000 TO FIX. LUCKILY I CAUGHT IT IN TIME BEFORE IT DID ADDITIONAL DAMAGES TO THE CRANK SHAFT. WITH LOW MILES THE MECHANIC EVEN TOLD ME ITS A FAULT PART AND BRAKES EASILY. HE HAS HAD TO REPLACE NUMEROUS AMERICAN MODEL MINIS IN ITALY. MY COUNTRY CODE IS 39 IF YOU CALL. *TR

Mileage: 49,000

HAVE HAD A SEVERE RATTLING NOISE FROM ENGINE FOR SOME TIME NOW, RESEARCH SAYS THAT IT IS A FAULTY TIMING CHAIN TENSIONER PROBLEM. ALSO HAVE A LEAKING OIL SUPPLY LINE TO THE TURBO. BOTH PROBLEMS ARE MAJOR ISSUES FOR WHICH THERE HAS BEEN NO RECALLS FROM MINI. THESE ARE BOTH EXTREMELY EXPENSIVE REPAIRS WHICH I CAN NOT AFFORD.......THERE SHOULD BE RECALLS ON THESE PROBLEMS! PLEASE HELP..... *TR

Mileage: 100,000

THERE IS A DEFECT IN THE DESIGN OF THE OIL LINE FEEDING THE TURBO CHARGING UNIT. OIL NOW LEAKS DIRECTLY ONTO THE TURBO CHARGER CAUSING LARGE DISCHARGES OF SMOKE AT LOWER (CITY) SPEEDS FROM THE HOOD. THE BURNED OIL SMOKE IS NOT VISIBLE AT HIGHWAY SPEEDS, ALTHOUGH ONCE ONE SLOWS DOWN FOR A RAMP THE SMOKE POURS OUT AGAIN. DUE TO THE HIGH RISK OF FIRE THE CAR IS NO LONGER PARKED IN OUR GARAGE. IT IS PARKED TOWARDS THE END OF THE DRIVEWAY AS FAR FROM OUR HOUSE AS POSSIBLE. I BELIEVE THAT THIS SHOULD BE AN URGENT SAFETY ISSUE SEEING THAT THE ENGINE COULD CATCH FIRE AT ANY TIME. *TR

Mileage: 65,000

I WAS DRIVING AT HIGHWAY SPEED WHEN WITHOUT WARNING THE CAR LOST PARTIAL POWER AND THE ENGINE LIGHT CAME ON AND BEGAN FLASHING. I PULLED OVER TO THE ROADSIDE AND TURNED THE ENGINE OFF. I LOOKED AT THE OWNER'S MANUAL TO SEE WHAT THE FLASHING ENGINE LIGHT INDICATES. NOTHING DEFINITIVE WAS STATED IN THE MANUAL, SO I STARTED THE ENGINE AND DROVE IT TO MY HOME ABOUT 10 MILES UNDER PARTIAL POWER. I CONTACTED A LOCAL GARAGE (MIENKE) AND LET THEM KNOW THE PROBLEM. THE GARAGE WAS ABOUT THREE MILES AWAY SO I DROVE IT TO THEM. THEY DIAGNOSED A LOSS OF COMPRESSION IN ONE OF THE VALVES THAT WOULD REQUIRE A VALVE JOB. I CONTACTED MINIUSA TO REPORT THE PROBLEM. THEY REQUESTED I TAKE IT TO THE LOCAL DEALER FOR DIAGNOSIS. I CONTACTED THE DEALER AND LET THEM KNOW WHAT OCCURRED AND ASKED IF IT WAS SAFE TO DRIVE THE APPROXIMATE 20 MILES TO THEIR LOCATION WITH A COMPROMISED ENGINE. THEY SAID IT WOULD BE OKAY AND BRING IT IN. THEY DIAGNOSED IT THE NEXT DAY WITH A FAILED TIMING CHAIN ($1800), VACUUM PUMP ($600) AND VALVE COVER ASSEMBLY ($385). I LET THEM KNOW THE TIMING CHAIN WAS ALREADY REPLACED BY A MINI DEALERSHIP AT 40781 MILES AND THEY SHOULD REPLACE IT AT NO COST AS THIS IS SUPPOSED TO LAST 100,000 MILES. THE DEALER WOULD NOT. I CONTACTED MINIUSA AGAIN TO REPORT THE ISSUE AND REQUEST TO HAVE THIS REPLACED AT NO COST. THEY HAVE NOT GOTTEN BACK TO ME YET AND IT IS STILL PENDING THEIR DECISION. I BEGAN TO LOOK ONLINE FOR SIMILAR ISSUES AND FOUND HUNDREDS OF COMPLAINTS FROM OWNERS REGARDING THE SAME ISSUE WITH THE TIMING CHAIN. MINI/BMW IS WELL AWARE OF THE ISSUE BUT STILL DOES NOT COVER THIS RECURRING PROBLEM. THIS IS AN EXPENSIVE REPAIR AND UNKNOWING MINI OWNERS ARE SPENDING THOUSANDS OF DOLLARS TO HAVE THEIR CARS PUT BACK ON THE ROAD. THERE IS ALSO A PENDING CLASS ACTION LAW SUIT IN NEW JERSEY FOR THIS SAME ISSUE. *TR

Mileage: 78,000

AFTER MULTIPLE FRUSTRATING COMPLAINTS AND UNSUCCESSFUL SERVICE ATTEMPTS ON 8/17/11, 9/1/11, 9/6/11, 9/21/11 AND 9/28/11 FOR MY 2007 MINI COOPER S (PURCHASED ON 8/16/11) AT MAYORS AUTO MALL SAAB LOCATED AT 6001 NORTHERN BOULEVARD, WOODSIDE NY 11377 AND FAILING INSPECTION ON 9/1/12; I WAS FED UP AND BROUGHT MY VEHICLE DIRECTLY TO HASSEL BMW MINI OF FREEPORT LOCATED AT 100 CLEVELAND AVENUE, FREEPORT NY 11520 ON 10/31/11. AFTER A SERVICE BILL OF $3,546 (SERVICE) +$141.21 (EVALUATION FEE) = $3,688.03 FROM BMW MINI, THE PROBLEMS WERE STILL NOT RESOLVED. I THEN FILED A LEMON LAW CASE AGAINST MAYORS AUTO MALL AND WON ON. DESPITE WINNING THE CASE, MAYORS AUTO MALL REFUSED TO RETURN MY MONIES FOR THE PURCHASE PRICE OF VEHICLE. AFTER CONTACTING DMV WITH THE ISSUE AND HAVING THEM SUSPENDING THEIR BUSINESS LICENSE, MAYORS AUTO MALL FINALLY REFUNDED MY MONIES FOR VEHICLE PURCHASE BUT IT WAS EXCLUDING SERVICE BILLS OF $3,688.03 FROM BMW MINI SINCE LEMON LAW DID NOT COVER THIS AMOUNT. I AM FILING A COMPLAINT AGAINST BMW MINI AND WOULD LIKE TO FIND OUT POSSIBLE REMEDIES FOR GETTING A REFUND SERVICES PAID TOWARDS A VEHICLE THAT I NO LONGER HAVE DUE TO LEMON LAW CASE AND AM OUT OF $3,688.03 FOR NO REASON. I UNDERSTAND BMW MINI IS CURRENTLY BEING SUED FOR THESE SAME ISSUES BY MANY CONSUMERS. PLEASE CONTACT ME WITH ANY POSSIBLE INFORMATION YOU MAY BE ABLE TO PROVIDE REGARDING MY CASE. I AM IN AWE SHOCK THAT I AM STILL DEALING WITH THIS AND IT HAS BEEN 3 YEARS ALREADY SINCE I HAD TO RETURN THE CAR TO MAYORS AUTO MALL. THANK YOU FOR YOUR CONCERN WITH THIS MATTER AND WOULD APPRECIATE ANY INFORMATION YOU ARE ABLE TO PROVIDE. *TR

Mileage: 51,842

TIMING CHAIN TENSIONER, A WELL KNOWN PROBLEM WITH THESE CARS... I WORKED MY A** OFF FOR A YEAR SAVING UP FOR ONE OF THESE CARS AND WHAT DO YOU KNOW THE TENSIONER GOES... MINI DOES NOT CARE ABOUT YOU OR THE CAR THEY SELL, ITS ALL ABOUT TAKING WHATS IN YOUR WALLET AND PUTTING IT IN THERES, DONT BUY ONE OF THESE CARS AND NOT EXPECT TO PAY FOR IT TWICE LITERALLY IN FIXING IT..

Mileage: 113,000

WAS DRIVING CAR DOWNTOWN AT A SPEED ON AVERAGE OF 15 MPH. TRIP ONLY LASTED 15 MINUTES WHEN I PARKED AND NOTICED SMOKE COMING FROM MY HOOD. SMOKE QUICKLY ESCALATED INTO A FIRE. CALLED 911 TO HAVE FIRE TRUCKS OUT. GRABBED A FIRE EXTINGUISHER FROM A NEARBY BUSINESS TO TRY TO PUT OUT THE FLAMES, BUT WAS UNABLE TO EVEN WHILE SPRAYING DIRECTLY AT THE FLAMES. FIREMEN HAD TO PRY OPEN THE HOOD TO GET TO THE ENGINE TO PUT OUT THE FIRE. CAR ENGINE WAS TOTALED. *TR

Mileage: 67,000

THE TIMING CHAIN TENSIONER FAILS CAUSING THE ENGINE TO SUFFER CATASTROPHIC FAILURE. THE CUSTOMER IS EXPECTED TO PAY OUT OF POCKET FOR A REPAIR EVEN THOUGH MINI HAS ADMITTED A POOR DESIGN AND ARE REPLACING TENSIONERS VIA A CAMPAIGN. THE CUSTOMER WILL NOT GET REIMBURSEMENT. *TR

Mileage: 100,000

I TRIED TO START MY CAR AND ONLY HEARD A SPINNING SOUND. FIRST I THOUGHT THE TRANSMISSION OR STARTER WOULD NEED REPLACING BUT AFTER HAVING IT TOWED TO THE MINI DEALERSHIP, I WAS INFORMED IT IS THE TIMING CHAIN. UPON FURTHER REVIEW I WAS INFORMED THAT THE TIMING CHAIN BELT HAD SHATTERED AND BENT THE VALVES, AND NOW THE PISTONS ARE BLOCKED AND A PLETHORA OF OTHER THINGS. THE TOTAL TO REPAIR THIS DOMINO EFFECT OF DAMAGE IS ABOVE $8,000 AND JUST THE CHAIN ALONE IS 1500 BUT I WAS INFORMED WOULD BE A GRAND MISTAKE BECAUSE THE CAR WILL NOT RUN. I AM A COLLEGE STUDENT WHO IS FINANCIALLY CHALLENGED AND AM NOW IN TOO DEEP TO EVEN TRY AND FLOAT. *TR

Mileage: 100,000

UPON STARTING THE VEHICLE THE ENGINE SOUNDS AS IF PARTS ARE LOOSE IN THE ENGINE AREA. IT LESSENS UP AFTER THE ENGINE WARMS UP BUT IS GETTING PROGRESSIVELY WORSE. IT APPEARS IT MAY BE THE TIMING CHAIN/ TENSIONER. *TR

Mileage: 55,385

WHILE DRIVING ON 580 CAR LOST ALL POWER WITHOUT WARNING. UPON FURTHER INVESTIGATION IT WAS DETERMINED THAT THE VACUUM PUMP FROZE UP, BOLT ON TIMING GEAR SHEARED OFF AND FELL INTO OIL PAN. OIL PUMP WAS DESTROYED AS A RESULT. ON 11/7/13 RECEIVED LETTER FROM MINI CORP. REGARDING A FAULTY TIMING CHAIN TENSIONER WITH PREMATURE WEAR, WHICH COULD CAUSE PROBLEMS. UPON REPLACEMENT OF TENSIONER ASSEMBLY, MECHANIC FOUND A FAULTY VACUUM PUMP WHICH FROZE WITHOUT WARNING. OIL DISTRIBUTION WAS COMPROMISED. THIS ABRUPT LOSS OF POWER PUT MY ENTIRE FAMILY IN JEOPARDY, WHICH COULD HAVE CAUSED BODILY INJURY OR DEATH. BMW CORPORATION HAS BEEN AWARE OF THE VACUUM PUMP PROBLEM SINCE 2012. VEHICLE WAS PURCHASED USED IN 3/15/11 WITH 32K MILES. MINI CORP LEAD ME TO BELIEVE THAT FINANCIAL ASSISTANCE MAY BE MADE AVAILABLE FOR REPAIRS. I HAVE BEEN DECLINED ANY ASSISTANCE FOR A FAILED VACUUM PUMP ASSEMBLY WHICH CAUSED CATASTROPHIC ENGINE FAILURE. THE VEHICLE HAS HAD REPORTS OF SIMILAR FAILURE. HIGHWAY SPEED, LOSS OF POWER, PUTTING VEHICLE AND OCCUPANTS IN PERIL CIRCUMSTANCE, BMW IS AWARE OF THIS ISSUE AND REFUSES TO ACKNOWLEDGE DESIGN OR MANUFACTURE/MECHANICAL FLAWS IN THE ENGINEERING OF THIS MOTOR. *TR

Mileage: 92,000

COMPLETE LOSS OF ENGINE OIL PRESSURE WHILE SURROUNDED BY SEMIS IN THE 3/4-MILE-LONG BIG WALKER MOUNTAIN TUNNEL WHILE TRAVELING NORTHBOUND ON I-77 (NEAR VIRGINIA EXIT 47). THANKFULLY THE ENGINE DIDN'T SEIZE AND I WAS ABLE TO PULL OFF ONCE THROUGH THE TUNNEL. ACCORDING TO MY MECHANIC, THE CAUSE WAS A CHECK VALVE IN THE VALVE COVER, WHICH MALFUNCTIONED IN A WAY THAT CREATED A VACUUM AND TRAPPED OIL IN THE TOP PART OF THE ENGINE. REPLACEMENT COVER HAD BEEN REDESIGNED TO PREVENT THE PROBLEM, SO IT SEEMS TO HAVE BEEN A KNOWN ISSUE. *TR

Mileage: 92,250

THE CAR LOST POWER AND WOULD NOT RUN AT IDLE SPEED. AFTER MUCH EFFORT, MANAGED TO GET THE CAR TO THE ONLY DEALER IN THE STATE. AFTER TWO FAILED DIAGNOSTICS AND TWO "REPAIRS," THE DEALER SAYS I NOW NEED THE TIMING CHAIN REPLACED. THERE ARE KNOWN ISSUES ABOUT THE TIMING CHAIN AND THE TENSIONER. BMW AND DEALER DENY RESPONSIBILITY AND NOW WISH TO CHARGE AN ADDITIONAL $1500 TO REPAIR. *TR

Mileage: 107,000

RATTLE AND OIL LEAK. LOSS OF FULL ENGINE POWER WHEN RESTARTED. DEALER SAYS ITS A TIMING CHAIN ASSEMBLY ISSUE. *TR

Mileage: 38,000

THE TIMING CHAIN GUIDES AND TENSIONER IN THE MINI COOPER ARE MADE FROM PLASTIC. THERE IS A SERVICE BULLETIN CREATED BY MINI USA TO ADDRESS THIS ISSUE, BUT NO RECALL. AS I WAS DRIVING HOME, MAKING A TURN ACROSS A BUSY INTERSECTION, MY TENSIONER BROKE, WHICH CAUSED MY VEHICLE TO DIE IN THE MIDDLE OF A TURN WITH ONCOMING TRAFFIC. I HAD TO GET OUT OF MY VEHICLE AND PUSH IT ACROSS THE INTERSECTION WHILE CARS WERE DRIVING BY. ALTHOUGH IT IS COMMON FOR VEHICLE ENGINES TO DIE OF DIFFERENT ISSUES, THIS IS A WELL-DOCUMENTED AND ACKNOWLEDGED PROBLEM FOR MINI COOPERS, BUT THERE HAS NOT BEEN ENOUGH OF A PUBLIC OUTCRY FOR A RECALL. THE SITUATION IS DANGEROUS, AS IT CAN CAUSE ENGINE FAILURE WHICH CAN RESULT IN A COLLISION. THE REMEDY IS A REPLACEMENT OF A MANUFACTURER-ACKNOWLEDGED FAULTY PART. *TR

Mileage: 103,000

DRIVING MINI COOPER S WHEN ALL OF A SUDDEN I LOST POWER TO THE CAR AND WAS ABLE TO GET IT OFF THE HWY. TIMING CHAIN BROKE AND DAMAGED THE ENGINE. THE CAR HAS 91,000 MILES ON IT. *TR

Mileage: 91,000

TIMING CHAIN FAILURE. HAPPENED ON FREEWAY. COMPLETE LOSS OF POWER, HAD TO BE TOWED. *TR

Mileage: 48,161

RECEIVED A LETTER FROM MINI ON 11/16/13 NOTIFYING ME OF POSSIBILITY OF FAULTY CHAIN TENSIONER, WHICH NEEDED TO BE "CHECKED FOR WEAR AND REPLACED IF NECESSARY," AND THAT I SHOULD CONTACT AN AUTHORIZED MINI DEALER TO ARRANGE AN APPOINTMENT. NO INDICATION THAT THE VEHICLE SHOULD NOT BE DRIVEN. TWO DAYS LATER (11/18/13), JUST AS I WAS ABOUT TO SCHEDULE AN APPOINTMENT, THE VEHICLE BEGAN TO SHAKE, THEN THE RED ENGINE LIGHT CAME ON, SO I SHUT DOWN THE VEHICLE AND HAD IT TOWED FIRST TO THE IMPORT SHOP THAT NORMALLY SERVICES THE MINI THEN, AFTER CONSULTATION WITH THAT MECHANIC ABOUT MINI'S RECALL LETTER, HAD IT TOWED TO A MINI DEALERSHIP, WHERE IT NOW SITS WAITING FOR DIAGNOSIS AND NEWS ABOUT WHAT ANY DAMAGE MIGHT COST TO REPAIR, WHETHER I WILL BE RESPONSIBLE FOR IT, AND WHETHER I WILL BE REIMBURSED FOR TWO TOW CHARGES AND A CAR RENTAL. *TR

Mileage: 87,210

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE STALLED AND OVER-HEATED, CAUSING SMOKE TO EMIT FROM UNDER THE ENGINE COMPARTMENT. THE VEHICLE WAS TAKEN TO THE DEALER HOWEVER, THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 11,562 AND THE CURRENT MILEAGE WAS 53,000.

Mileage: 11,562

I WAS DRIVING ON THE INTERSTATE, WHEN WITHOUT ANY WARNING OR INDICATORS, THE ENGINE SHUT OFF. I WAS STUCK IN A DANGEROUS PLACE, WITH HIGH-SPEED TRAFFIC FOR SOMETIME. THE DEALER WHO AS MY CAR SAYS: "THE PRIMARY CAUSE OF THE ENGINE FAILURE WAS THE LOCKING UP OF THE VACUUM PUMP. CONSEQUENTLY THIS CAUSED THE BOLT ON THE EXHAUST CAM SHAFT SPROCKET TO SHEER OFF CAUSING THE VEHICLE TO RUN OUT OF TIME. THE PISTONS THEREFORE MADE CONTACT WITH BOTH INTAKE AND EXHAUST VALVES, VERIFIED WITH BOROSCOPE INSPECTION, THUS BENDING THE VALVES AND CAUSING CATASTROPHIC FAILURE TO THE ENGINE. $6850.00 MINUS DISCOUNT TO REPLACE ENGINE. THIS IS OBVIOUSLY NOT AN ISOLATED INCIDENT. I HAVE HAD A LOT ISSUES WITH VARIOUS MINI ENGINE PARTS DETERIORATING, DESPITE FOLLOWING THE RECOMMENDED REGULAR MAINTENANCE SCHEDULES ' CLUTCH, FLY-WHEEL, THERMOSTAT, INTAKE SILENCER, SPARK PLUGS, TIMING CHAIN TWICE, WATERPUMP, RADIO HEAD UNIT, DRIVE BELT, HI-LO HORN, BOOT LATCH, BOOT CABLE, TO NAME A FEW. HOPEFULLY MINI WILL DO SOMETHING ABOUT THESE ISSUES. *TR

Mileage: 92,000

RAN A DIAGNOSTIC TEST AND THESE WARNINGS CAME UP - 2D52 SUPER KNOCKING 2DCD FUEL SHUT OFF DUE TO SUPER KNOCKING CYLINDER 3 2968 INLET CAMSHAFT SENSOR 2B64 INTAKE MANIFOLD, UNMETERED AIR BASED ON ALL OF THESE SOUND LIKE MY MINI COOPER HAS BAD FUEL AND/OR SERIOUS CARBON BUILD, I'VE JUST PURCHASED THIS CAR FROM A DEALERSHIP AND I AM EXPERIENCING DELAYS IN ACCELERATION, LOSS OF FORWARD PROPULSION.

Mileage: 55,302

UPON ACCELERATION WHEN THE TURBO CHARGER ENGAGES THERE IS A HIGH PITCHED SQUEAL WHICH CHANGES TONE DEPENDING UPON THE ACCELERATION. AFTERWARDS SMOKES STARTS LEAKING FROM THE HOOD SCOOP AND SIDES OF THE HOOD ITSELF. IT SMELLS OF BURNED OIL. I NOTICED OIL POOLING AT A CONNECTION POINT NEAR THE TURBO CHARGER UNIT. IN MID-AUGUST THE CAR FAILED IT'S EMISSIONS TEST DUE TO A CRACKED VALVE COVER. I HAD THE MINI DEALERSHIP REPLACE THE VALVE COVER WHICH WAS ENOUGH TO PASS INSPECTION. HOWEVER, THE TECHNICIAN INFORMED ME THAT I HAD AN OIL LEAK IN A LINE TO THE TURBO CHARGER THAT COULD START A FIRE AND TO WATCH MY OIL LEVEL CLOSELY. THE COST TO REPAIR THIS (AFTER NEARLY $900 ON THE VALVE COVER) IS SIMPLY BEYOND MY MEANS PRESENTLY. SINCE LEARNING ABOUT THE POSSIBLE DANGERS THE CAR IS NO LONGER PARKED IN THE GARAGE.

Mileage: 75,000

THIS VEHICLE HAS TWICE HAD A FAILURE OF THE TIMING CHAIN AS A RESULT OF A FAULTY TENSIONER, RESULTING IN CATASTROPHIC ENGINE FAILURE. THE FIRST INCIDENT OCCURRED FROM A DEAD STOP IN A PARKING LOT SO THERE WAS NO IMMEDIATE SAFETY ISSUE. THE SECOND INCIDENT, OCCURRING 12/03/2012, MANIFESTED AS THE VEHICLE WAS DE-ACCELERATING COMING OFF A HIGHWAY EXIT WITH A TOTAL LOSS OF POWER AT THE BOTTOM OF THE EXIT, IN A REMOTE AREA. MINI COOPER SENT THEIR TECHNICIANS IN 2007 A "SERVICE BULLETIN," SHORT OF A RECALL, WHEN THE TREND WAS DISCOVERED AMONG ITS "R56' MODEL ENGINES IN 2008. I HAD WARNED MINI OF SOUNDS WHICH LATER WERE DETERMINED BY INDEPENDENT EXPERTS TO BE THE TIMING CHAIN'S "DEATH RATTLE" PRIOR TO THE FIRST FAILURE, WHICH THEY ATTRIBUTED TO THE CAR'S "GO-KART LIKE START UP." AFTER 6 MONTHS OF STRUGGLING, MINI AGREED TO 80% OF THE REPAIR COSTS, WITH A NEW TIMING CHAIN UNDER A ONE YEAR WARRANTY. OTHER FAILURES SIDELINED THE VEHICLE FOR MONTHS IN THE INTERVENING TIME, AND DUE TO THE INCREDIBLE COST OF REPAIR THE VEHICLE HAD TO BE GARAGED UNTIL REPAIRED. SO ALTHOUGH OVER A YEAR PASSED BETWEEN TIMING CHAIN FAILURES, ABOUT ONLY ABOUT 39K MILES WERE DRIVEN IN THAT TIME. AS OF NOW, MINI IS ONLY OFFERING 50% CULPABILITY, THIS AFTER STARTING A VOCAL TWITTER CAMPAIGN. I STILL OWE $10K ON A VEHICLE THAT REQUIRES UP TO $5K IN REPAIRS- A REPAIR WHICH WILL ONLY REPLACE A DEFECTIVE PART WITH THE SAME DEFECTIVE PART. *TT

Mileage: 77,000

TIMING CHAIN FAILURE CAUSED IMMEDIATE ENGINE FAILURE AT HIGHWAY SPEED. DAMAGED TIMING CHAIN HOUSING CRACKED CAUSING OIL TO SPRAY THE HOT ENGINE. SUBSEQUENT OIL STARTED A SMALL FIRE THAT WAS EXTINGUISHED BY DRIVER. *TR

Mileage: 56,000

ENGINE BAY STARTED SMOKING. PULLED THE CAR OVER AND NOTICE THE TURBO OIL LINE WAS LEAKING HOT OIL EVERYWHERE. COULD OF RESULTED IN A ENGINE BAY FIRE. *TR

Mileage: 71,000

I TOOK MY CAR INTO MY LOCAL SHOP AND HAD OIL CHANGE,NEW BATTERY,TIRES ROTATED AND ALIGNMENT .THEY COULD A NOISE FROM THE ENGINE AND THEY CHECKED IT OUT. CALL ME TO INFORM ME THAT I HAD TO TAKE TO THE MINI COOPER DEALERSHIP BECAUSE THE TIMING CHAIN NEEDED TO BE REPLACE. I CALLED MINI COOPER AND SPOKE TO [XXX] AT THE HOUSTON DEALERSHIP MOMENTUM MINI. SHE INFORMED ME THAT THE COST WOULD BE ANYWHERE FROM 4000 TO 10,000 DOLLARS. I EXPLAINED TO HER I HAD THE CAR FOR 1 YEAR AND HAVE ANY DRIVEN 6000 MILES IN A YEAR. AFTER DOING RESEARCH I NOTICED THAT OTHER PEOPLE WHERE HAVING THE SAME ISSUES WITH THERE MINI. I PURCHASED THIS CAR WITH 39,126 MILES ON IT AND MY DAILY DRIVE TO WORK IS A QUARTER MILE IF THAT. PLEASE HELP !!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 46,000

WHILE IN IDLE AND ANY RPM, A RATTLE/GROWLING SOUND COULD BE HEARD COMING FROM UNDER THE TIMING CHAIN HOUSING OF THE ENGINE. WHEN SHIFTING IT WAS HARDER TO PLACE INTO GEAR WITHOUT GRINDING AND VERY EASY TO MISS A GEAR WHEN SHIFTING. MASTER MECHANIC DIAGNOSED THIS HAS A FAILING/FAILED TIMING CHAIN. A NEW TIMING CHAIN WAS INSTALLED, COSTING ME $1,400. ONE WEEK AFTER BEING FIXED THE SAME SOUND IS ARISING FROM THE TIME CHAIN HOUSING AND NEED TO BE TAKEN BACK IN FOR A NEW CHAIN YET AGAIN. THIS IS NOT THE FIRST TIME THE TIMING CHAIN HAS BEEN REPLACED ON THIS MINI COOPER, IT IS JUST THE 1ST WHILE I HAVE BEEN THE OWNER OF THE CAR AND SEEMS TO BE AN ONGOING ISSUE WITH IT. *TR

Mileage: 105,000

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT COOLANT WAS LEAKING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE TRANSMISSION MOUNT WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE COOLANT HOUSING AND THE TRANSMISSION MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

WHILE DRIVING WEST ON 580 HIGHWAY, MY CAR LOST POWER AND WAS UNABLE TO ACCELERATE OUT OF THE LANE. I WAS ABLE TO COAST OFF OF THE FREEWAY OUT OF THE WAY OF MOVING TRAFFIC. HIGHWAY PATROL WAS ABLE TO ASSIST WITH WARNING OTHER DRIVERS OF A MECHANICAL FAILURE. DUE TO A MECHANICAL VACUUM PUMP FAILURE, CAR LOST ALL POWER, AND THE ENGINE WAS A TOTAL LOSS. ALSO FAILED ON THE ENGINE WAS A CAM SHAFT FAILURE, TIMING CHAIN FAILURE. THIS IS CONSIDERED A TOTAL LOSS. REPAIRS COST MORE THAN THE CAR IS WORTH. COST OF REPAIRS PROVIDED BY DEALER IS ESTIMATED AT 9,700.00 DOLLARS MANUFACTURE AWARE OF OIL ISSUES WITH THE VACUUM PUMP, WHICH COULD LEAD TO A CATASTROPHIC ENGINE BREAKDOWN. OIL FEED HOLE ON THE PUMP CAN BECOME CLOGGED ON THE PUMP. VACUUM PUMP WILL INADEQUATELY SUPPLY OIL TO THE VITAL MOVING PARTS ON THE ENGINE.WE HAD JUST COMPLETED AN OIL CHANGE A WEEK BEFORE THIS FAILURE. MANUFACTURE INTERVALS FOR OIL CHANGES, PUT FAILURE OF PUMP A REALITY, NOT A POSSIBILITY. *TR

Mileage: 98,000

DAUGHTER WAS DRIVING THE VEHICLE AND WHILE STOPPED AT A TOLL BOOTH ON THE NJ TOLL ROAD, THE CAR SHUT DOWN AND COULD NOT BE RESTARTED. AFTER SEVERAL MECHANICS, THE 3RD MECHANIC HAS DIAGNOSED THE PROBLEM AS " LOCKED UP VACUUM PUMP ON ENGINE THAT CAUSED CAMSHAFT SPROCKET TO SNAP CAUSING BENT VALVES IN ENGINE,MOTOR OIL WAS FULL ." TOTALLY UNSAT. *TR

Mileage: 69,011

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE ENGINE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A MECHANIC FOR INSPECTION AND THEY STATED THAT THE TIMING CHANGE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 41,000. UPDATED 07/12/13*LJ

Mileage: 41,000

WITH ONLY 23,000 MILES, ENGINE EXHIBITED A LOUD RATTLING NOISE AT IDLE, AND RUNNING UP TO ABOUT 2800 RPM, WHEN NOISE WOULD DISAPPEAR. TOOK IT IMMEDIATELY TO DEALER, WHO DIAGNOSED IT AS A FAILURE OF THE TIMING CHAIN TENSIONER PISTON; THAT FAILURE CAUSED THE CHAIN TO SKIP AND THROW THE CAM TIMING OUT OF ALIGNMENT, ACCORDING TO THE DEALER... COST OF $188.00 TO REPLACE TIMING CHAIN TENSIONER, AND $471 TO DIAGNOSE CAM TIMING SKIP AND RESTORE CAM TIMING... TOTAL COST $659. DEALER REFUSED TO SUBMIT CLAIM TO MINI NORTH AMERICA FOR GOODWILL COVERAGE, DESPITE OUTSTANDING CONDITION, LOW MILEAGE, REGULAR DEALER MAINTENANCE, AND PROPER OIL LEVELS AND CHANGE INTERVALS. THIS ISSUE WITH THE TIMING CHAIN TENSIONER FAILURE AND RESULTING DAMAGE IS WELL KNOWN AND WELL DOCUMENTED AND SHOULD BE THE SUBJECT OF A RECALL AND REPAIR OF ENTIRE TIMING CHAIN SYSTEM AT MINI'S COST-- SEVERE CASES CAN RESULT IN CATASTROPHIC ENGINE FAILURE AT HIGHWAY SPEED AND POTENTIAL CRASHES/FATALITIES. NHTSA, PLEASE MAKE MINI DO THE RIGHT THING!!!! *TR

Mileage: 23,060

I WAS THE ONE THAT REPORTED THE "DEATH RATTLE" ON MY WIFE'S MINI COOPER A FEW WEEKS AGO. I'M HAPPY TO REPORT THAT THE ENGINE WAS NOT DAMAGED AND MINI FIXED IT FOR $1800, WHICH WAS RIGHT IN LINE WITH THEIR ESTIMATE. THEY REPLACED THE TIMING CHAIN (IT WAS STRETCHED 70MM... 70!!), THE TENSION PULLEY, THE GUIDE, CHANGED THE OIL, REPLACED THE AUX WATER PUMP (WAS A RECALL SO IT COST $0), RETIMED THE ENGINE, WASHED THE CAR, AND CLEANED THE ENGINE BAY. THE GOOD NEWS IS THAT THE CAR RUNS LIKE NEW. THE GREAT NEWS IS THAT THE SERVICE MANAGER TOLD ME HE CALLED MINI ON MY BEHALF AND THEY GAVE US A $500 DISCOUNT ON THE REPAIR SINCE THE CAR WAS "ONLY A COUPLE OF YEARS OUT OF WARRANTY". PERHAPS THAT MEANS MINI IS FINALLY WAKING UP TO THIS PROBLEM? I'LL NEVER UNDERSTAND HOW BETWEEN THE TIMING CHAIN STRETCHED 70MM, AND THE BROKEN PIECE OF GUIDE RATTLING AROUND FOR WHO KNOWS HOW LONG, DIDN'T DESTROY THE ENGINE... BUT I'M NOT COMPLAINING. ANYWAY, JUST WANTED TO LET OTHER MINI OWNERS KNOW THAT THERE'S HOPE AFTER ALL. AND $1300 IS BETTER THAN $1800 ANY DAY OF THE WEEK. CAR RUNS GREAT AND NEITHER MY WIFE AND I REALIZED HOW MUCH POWER THE CAR HAD LOST. WE'RE STILL GETTING RID OF IT THOUGH... ENOUGH IS ENOUGH... EVERY TIME SOMETHING GOES WRONG WITH THIS CAR, IT'S DRAMA. AND THIS WAS THE LAST STRAW. GOOD LUCK EVERYONE. *TR

Mileage: 52,000

CAR HAS TIMING CHAIN NOISE ON COLD START-UP AND IF LEFT UNREPAIRED, IT WILL RESULT IN TIMING CHAIN FAILURE AND ENGINE DESTRUCTION. THIS IS A WIDESPREAD PROBLEM ON 2007 AND LATER MINI COOPER S. DEALER REFUSES TO REPAIR OUT OF WARRANTY AND, EVEN IF REPAIRED, THE PROBLEM WILL RETURN. THERE ARE CASES OF MULTIPLE ENGINE FAILURES TO SAME CAR. CAR ALSO USES 1 QUART OF OIL EVERY 2,000 MILES. *TR

Mileage: 12,000

I HAVE BEEN EXPERIENCING A MAJOR FLAW WITH OIL SUPPLY/RETURN LINES TO THE TURBO. A CONDITION EXISTS WHERE IF LEFT UNATTENDED AND UNCARED FOR CREATES THE HIGH RISK OF FIRE AND SUBSEQUENT LOSS OF ENGINE/VEHICLE. THIS EVENT CAN HAPPEN AT ANY TIME THE CAR IS BEING DRIVEN AND/OR LATER PARKED. THE RISK IS CREATED WHEN OIL ACCUMULATES, EITHER THROUGH TIME OR OVER A LEISURE DRIVE, AND COLLECTS NEAR/ON THE EXHAUST MANIFOLD & TURBO COMPONENTS, BOTH OF WHICH OPERATE AT EXTREMELY HIGH TEMPERATURES. IT IS BECOMING A DAILY TASK TO LOOK UNDER THE CAR HOOD AND INVESTIGATE FOR ACCUMULATION OF OIL NEAR THESE PARTS DUE TO THE FACT THAT THE CAR SMELLS OF BURNING PETROLEUM. NEED I BE MORE APPARENT OF BURNING OIL THAT WILL BURN AND DESTROY A CAR DUE TO A FAULTY PRODUCT? THIS HAS BEEN OCCURRING FOR THE MAJORITY LIFE OF THE CAR BUT HE ISSUE HAS NEVER BEEN PROFESSIONALLY ADDRESSED DUE TO DISREGARD OF THE MINI/BMW DEALERSHIPS TO ACCEPT THIS DESIGN FLAW. IF RESEARCHED FURTHER, THERE ARE MANY STANDARD EXAMPLES OF THIS DESIGN FLAW AND NUMEROUS DESCRIPTIONS, IMAGES, EXAMPLES, FORUMS, AND COMPLAINTS OF THIS FLAW OCCURRING IN MANY CARS OF VARIOUS STYLES, MILEAGE, AND TRIMS OCCURRING WITHIN THE SAME YEAR MODEL OF 2007. I HAVE ALSO EXPERIENCE MANY OF THE MAJOR FLAWS ALREADY LISTED AND COMPLAINED ABOUT ON THE NHTSA SUCH AS THE ??DEATH RATTLE?? BELT TENSIONER FAILING (LUCKILY NO CATASTROPHIC ENGINE FAILURE AND WHICH HAS BEEN LISTED NUMEROUS TIMES ON NHTSA, NUMEROUS), VALVE COVER REPLACEMENT (ALSO LISTED), ETC. NHTSA, ADDRESS THIS PROBLEM AS IT IS AN AVID AND DANGEROUS SAFETY ISSUE. THE COMMON PERSON DOES NOT CHECK UNDER THE HOOD DAILY AND ITS ONLY TIME BEFORE SOMEONE PARKS THEIR MINI IN A GARAGE AND THE HOME GOES DOWN IN FLAMES. I PERSONALLY DON??T PARK THE MINI IN THE GARAGE FOR FEAR OF FIRE. DO NOT REPAIR THE MINI WITH THE SAME FAULTY OIL LINE DESIGN. RECALL DESIGN. *TR

Mileage: 89,900

MY 2007 MINI COOPER S THERMOSTAT HOUSING HAS STARTED LEAKING TO THE POINT THAT IT WOULD CAUSE THE ENGINE TO OVERHEAT AT PROLONGED STOPS IN TRAFFIC IF FLUID IS NOT PUT IN THE OVERFLOW TANK. I HAVE BEEN READING VARIOUS THREADS REGARDING THIS ISSUE AND SEE THAT THERE ARE SEVERAL REPORTS OF THIS FAILURE, HOWEVER MINI DOES NOT SEEM TOO WORRIED ABOUT THIS PART. *TR

Mileage: 77,000

JUST WANTED TO REPORT ANOTHER CASE OF THE "DEATH RATTLE". MY WIFE HAS A 2007 MINI COOPER S WE BOUGHT NEW IN SEPT. 2007. SHE COMPLAINED OF A LOUD RATTLE WHEN SHE STARTED THE CAR FOR ABOUT 5-10 MINUTES UNTIL WARM. THOUGHT IT MIGHT BE A LOOSE EXHAUST COMPONENT UNTIL IT STARTED HAVING IDLE ISSUES. WE TOOK IT TO A LOCAL SHOP AND THEY "REBOOTED" THE COMPUTER AND THE IDLE PROBLEMS WENT AWAY BUT THE RATTLE PERSISTED. OUR CLOSEST MINI DEALER IS AN HOUR AWAY SO WE DON'T TAKE IT TO THEM UNLESS WE HAVE TO. EARLY LAST WEEK THE OIL LIGHT CAME ON. CHECKED THE OIL AND OIL LEVEL WAS FINE... ALTHOUGH THE DIPSTICK DID NOT WANT TO GO BACK IN THE ENGINE. OIL LIGHT WOULD COME AND GO OVER THE NEXT FEW DAYS. SHE TOOK IT TO THE LOCAL SHOP AGAIN TO HAVE THE RATTLE CHECKED AND THE OIL CHANGED SINCE IT WAS ALMOST DUE. THEY FOUND THE GUIDE FOR THE TIMING CHAIN WAS BROKEN AND LAYING IN THE BOTTOM OF THE COVER. THEY CALLED OUR CLOSEST MINI DEALER, SAID IT WAS A "COMMON PROBLEM" WITH TURBO MINIS, AND WE SHOULDN'T DRIVE IT. HAD IT TOWED TO MINI AND THAT'S WHERE IT SITS. THEY HAVEN'T WORKED ON IT YET AND THEY WILL CALL ME WHEN THEY DO, BUT AN EARLY ESTIMATE IS ~$1800 TO REPAIR, AS LONG AS THE ENGINE ISN'T DAMAGED (WHICH IT ISN'T AS THE CAR STARTS AND RUNS FINE). I ASKED MINI ABOUT IT BEING COVERED UNDER SOME SORT OF WARRANTY AFTER READING ALL THE HORROR STORIES SINCE IT'S A KNOWN PROBLEM BUT THEY SAID SINCE THE OIL LEVEL WAS LOW, AND LOW OIL LEVELS EXACERBATE THE PROBLEM, THERE'S NOTHING THEY CAN DO. HAD NO IDEA THE OIL LEVEL WAS LOW UNTIL THE LIGHT CAME ON. PRETTY SAD THAT THIS "COMMON PROBLEM" STILL HASN'T BEEN FIXED AFTER ALL THESE YEARS. WIFE IS NOW A FULL-TIME STUDENT AND HER SCHOOL IS OVER AN HOUR AWAY. SHE MAKES THAT DRIVE TWICE A DAY, THREE TIMES A WEEK. HOW THAT BROKEN PIECE DIDN'T GET TANGLED IN THE TIMING CHAIN AND DESTROY THE ENGINE I'LL NEVER KNOW. *TR

Mileage: 50,000

TURBO OIL SUPPLY LINE FROM ENGINE TO TURBO LEAKING EXCESSIVE OIL REQUIRING REPLACEMENT. POOR ENGINEERING DESIGN OF COMPRESSION FITTING LED TO PREMATURE FAILURE. CONTINUED OPERATION OF VEHICLE WITH THIS CONDITION WOULD RESULT IN CATASTROPHIC ENGINE AND OR ENGINE TURBO FAILURE. MINI OF MARIN WAS NOTIFIED OF THE ONGOING ISSUES AND WERE TOLD THEY HADN'T HEARD OF THE ISSUE. CAR SMOKES UP IF DRIVEN SLOW. MUST BE ADDRESSED IN RECALL. *TR

Mileage: 48,000

WITHOUT WARNING OR CAUSE, THE TIMING CHAIN & TENSIONER FAILED, WHICH RUINED MY ENGINE. JUST THE TIMING CHAIN COSTS $2000-$3000 TO FIX, BUT SINCE MY ENGINE IS GONE AS WELL THAT NUMBER IS MORE LIKE $6000-$7000. THIS IS A 2007, AND SINKING HALF OF THE VALUE OF THE CAR BACK INTO IT DOES NOT MAKE SENSE. THIS IS A HUGE ISSUE THAT NEEDS TO BE DEALT WITH. IT IS OBVIOUSLY A MANUFACTURER ISSUE AS OTHERS HAVE ALSO REPORTED THIS ISSUE AT VARIOUS MILEAGE STAGES. PLEASE DO SOMETHING ABOUT THIS. *TR

Mileage: 115,000

I TOOK MY MINI S IN TO THE SHOP FOR BRAKE MAINTENANCE, TO BE TOLD THAT THE TENSIONER HAD FAILED AND THE TIMING CHAIN KIT HAD TO BE REPLACED. UNNECESSARY TO MENTION, THIS IS A VERY EXPENSIVE REPAIR. AFTER DOING MUCH RESEARCH, I HAVE FOUND THAT THE TENSIONER IN THE MINI HAS BEEN AN ISSUE FOR QUITE SOME TIME, SOME SITES HAVE QUOTED SINCE 2007. HAD I NOT TAKEN MY CAR IN FOR A COMPLETELY UNRELATED ISSUE, MY TIMING CHAIN COULD HAVE BROKEN, RESULTING IN A THROWN ROD AND A BLOWN ENGINE, WHICH CAN BE INCREDIBLY DANGEROUS. THIS TENSIONER IS A DEFECTIVE PIECE WHICH CAUSES SIGNIFICANT DAMAGE TO THE TIMING CHAIN AND AREA COMPONENTS WHEN IT FAILS. DUE TO THE NATURE OF THIS ISSUE AND THE NUMBER OF COMPLAINTS SEEN ON THE WEB, A MANUFACTURER'S RECALL SHOULD BE MADE. *TR

Mileage: 41,000

TOOK VEHICLE IN TO MINI OF THE WOODLANDS TO HAVE RECALL WORK DONE TO THE VEHICLE AND WHILE IT WAS THERE HAD THEM DO A DIAGNOSTIC TO ENSURE CAR WAS IN GOOD SHAPE. WAS TOLD THAT IT NEEDED A NEW TIMING CHAIN AND THAT I SHOULDN'T DRIVE IT. WAS TOLD TO TOW IT HOME OR LEAVE IT WITH THEM AND THEY WOULD FIX IT FOR CLOSE TO $2500. THE CAR HAS 37,000 MILES. REALLY? FEEL LIKE THERE'S A NICE SCAM GOING ON WITH A PRODUCT THAT HAS OBVIOUS DEFECTS WITH THIS TIMING CHAIN ISSUE. THERE ARE COMPLAINTS ALL OVER THE INTERNET. NO VEHICLE SHOULD NEED A NEW TIMING BELT WITH THIS LOW OF MILEAGE. MINI NEEDS TO DO THE RIGHT THING AND ISSUE A RECALL FOR THIS PROBLEM. *TR

Mileage: 37,000

ON 2/4/13 HAD MY CAR TAKEN TO GLOBAL IMPORTS BMW/MINI DEALERSHIP ON 5925 PEACHSTREET IND.BLVD.ATLANTA,GA. (THE CYLINDER HEAD COVER HAD TO BE REPLACED,WAS LEAKING, I PAID $1291.45 FOR THE SERVICE). I PICKED UP MY CAR ON 2/5/13, ACCORDING TO THEM IS WAS GOOD TO GO. STARTED HEADING BACK HOME, WHEN THE ENGINE LIGHT POPPED UP AGAIN, THE CAR STARTED SMOKING,SHAKING,IT WOULD NOT DRIVE HIGHER THAN 40MILES., GOT OFF I-75 IN MACON GA, CALLED ROADSIDE SERVICES, HAD CAR TOWED BACK TO THE DEALERSHIP MENTIONED ABOVE FOR REPAIRS. THEY KEPT IT FOR A WEEK. THEY CALL ON 2/20/13 TELLING MY THE CAR WAS READY FOR PICK UP. I RETURNED TO ATLANTA THE FOLLOWING DAY 2/21/13. THEY CHARGED ME FOR SERVICE $3,991.57 . HEADED BACK TO FLORIDA ON 2/23/13, AND NOT EVEN HALF WAY, ON I-75, THE ENGINE LIGHT POPPED UP AGAIN, THE CAR WOULD NOT HIGHER THAN 40MILES, HAD CAR TOWED TO THE MINI OF SOUTH ATLANTA DEALERSHIP IN UNION CITY,AND IM AWAITING TO HEAR FROM THEM WHEN TO COME AND PICK UP MY CAR. WHEN THE RECALL WAS FIRST ANNOUNCED,I TRIED TO CONTACT BMW/MINI HEADQUATERS, THEY TOLD ME I WILL RECEIVE A LETTER IN THE MAIL REGARDING THE RECALL,WHICH I NEVER RECEIVED. I NEED HELP FORCING THESE PEOPLE TO BE RESPONSIBLE, FIX MY CAR OR IF NOT REIMBURSE ALL THE MONEY I HAVE INVESTED IN REPAIR (NOT ONLY IN ATLANTA BUT IN FLORIDA AS WELL). PLEASE I NEED YOUR ADVISE. A VERY FRUSTRATED MINI COOPER S DRIVER . *TR

Mileage: 65,852

TURBO CHARGER OIL FEED LINE - VERY POOR DESIGN CRIMPED TUBE WITH AN O-RING SEAL FAILED IN VERY HOT ENVIRONMENT AND CAUSED LARGE OIL LEAK ONTO HOT CATALYTIC CONVERTER. STOPPED CAR BEFORE FIRE STARTED. DEALER WANTED $1,300 TO INSTALL A NEW $50 OIL LINE OF THE SAME POOR DESIGN. EVERY SINGLE 2007+ MINI COOPER S HAS A SIMILAR OIL LINE - THEY ARE ALL FAILING AT FAIRLY LOW MILEAGE - NO EXCEPTIONS. MINI SHOULD REDESIGN THIS PART AND ISSUE SAFETY RECALL AND RE-IMBURSE THOSE THAT ALREADY PAID TO REPAIR OIL LINE. *TR

Mileage: 54,180

TURBO OIL FEED PIPING FAILS AT CONNECTOR. BANJO TYPE FITTING ON TUBING FAILS ON CONNECTION ABOVE TURBO, SPILLING OIL ON TURBO UNIT. PRODUCES SMOKE AND A POTENTIAL FIRE HAZARD. *TR

Mileage: 72,000

AS WITH ALOT OF OTHER MINI COOPER S MODELS FOR THIS YEAR, MY TIMING CHAIN STARTED TO RATTLE, THE DEALER REPLACED IT UNDER WARRANTY, NOT ONCE, BUT TWICE, THE WATER PUMP HAD BEEN REPLACED, FUEL PUMP REPLACED, THROTTLE BODY REPLACED AND THE LIST COULD CONTINUE. NOW THE CAR HAS 98,234 MILES ON IT AND IT IS SITTING AT THE DEALERSHIP WITH A BLOWN MOTOR FROM BAD #3 CYLINDER, LEAKING HEAD GASKET, AND VALVE ISSUES. THIS CAR HAS SEVERAL DESIGN FLAWS THAT THE MANUFACTURER WILL NOT OWN UP TO. FOR A CAR WITH A PRICE TAG OF OVER $32, 000 MADE FROM BMW, YOU WOULDN'T EXPECT ANY OF THIS. *TR

Mileage: 36,000

I OWN A 2007 MINI COOPER S, THAT I PURCHASED BRAND NEW IN JUNE OF 2007. I IMMEDIATELY FELL IN LOVE WITH THE CAR AND KNEW THAT THIS WOULD BE THE LAST CAR I WOULD EVER OWN. IT IS A $31,000 CAR THAT I HAVE BLOOD, SWEAT, AND TEARS MADE EXPENSIVE ($560/MONTH) PAYMENTS ON FOR THE LAST FIVE YEARS. ABOUT TWO YEARS INTO OWNING THIS CAR, I NOTICED WHEN IT WAS COLD OUT THAT MY MINI WOULD GET WHAT IS NOW KNOWN AS "THE DEATH RATTLE". WHEN I CALLED RALPH SCHOMP MINI (WHERE I HAD PURCHASED IT), THEY TOLD ME THAT THE NOISE WAS NOTHING THAT I HAD TO WORRY ABOUT AND THAT IT JUST HAD TO DO WITH COLD WEATHER. A YEAR AFTER THAT MY MINI WOULD STRUGGLE TO GET MOVING, I THOUGHT IT WAS A BATTERY PROBLEM, AGAIN THE MECHANICS AT RALPH SCHOMP MINI TOLD ME NOT TO WORRY ABOUT IT, AGAIN JUST COLD WEATHER. A COUPLE WEEKS AGO, I NOTICED THAT MY CAR WAS ACTING UP SEVERELY. THE CHECK ENGINE LIGHT CAME ON. THEN A COUPLE DAYS LATER IT WENT OFF AND IT SEEMINGLY STOPPED HAVING ISSUES. ABOUT A WEEK AFTER THAT, IT STARTED ACTING UP AGAIN AND THE CHECK ENGINE LIGHT CAME BACK ON. I ATTEMPTED TO TAKE IT TO ANOTHER AUTO PLACE TO HAVE IT DIAGNOSED, BUT IT WAS NON-CONCLUSIVE, AND THE SYMPTOMS ONLY GOT WORSE. I HAD MY MINI TOWED BACK TO RALPH SCHOMP MINI, AND THEIR DIAGNOSIS RESULTED IN SAYING THAT THE TIMING CHAIN TENSIONER MALFUNCTIONED AND HAD COME LOOSE WHICH DID SIGNIFICANT DAMAGE TO THE ENGINE AND THAT I WOULD NEED TO REPLACE THE ENGINE. AN ENGINE SUPPOSEDLY BUILT TO LAST AT LEAST TO 250,000 MILES ONLY MADE IT UNTIL 52,000 MILES AND WILL COST ME AS MUCH AS $8,000 TO REPAIR. MY WARRANTY EXPIRED LITERALLY SIX MONTHS AGO, AND I AM ONLY ABOUT THREE MONTHS AWAY FROM HAVING HER PAID OFF. IN LOOKING UP THIS ISSUE ONLINE, MANY OTHER 2007 MINI OWNERS HAVE ALSO HAD THIS ISSUE. I AM INCREDIBLY DISAPPOINTED IN THE ENTIRE SITUATION, AND WOULD ENCOURAGE A RECALL TO BE ISSUED ON 2007 MINI COOPER S. *TR

Mileage: 52,000

A CAR STOPPED SHORT IN MY PATH CAUSING ME TO BRAKE HARD AND STALL. SINCE I DIDN'T APPLY THE CLUTCH DURING THE EMERGENCY STOP I PRESSED THE CLUTCH PEDAL TO THE FLOOR IN AN ATTEMPT TO RESTART THE ENGINE. WHEN IT FAILED AFTER SEVERAL ATTEMPTS I HAD IT TOWED TO MINI OF BALTIMORE. THEY TOLD ME IT HAD NO COMPRESSION AND THAT THE EXHAUST CAM HAD JUMPED 180 DEGREES OUT OF TIMING. THIS SOUNDS LIKE A TIMING BELT TENSIONER PROBLEM THE SERVICE MANAGER GAVE ME AN ESTIMATE OF $2800. AFTER FURTHER RESEARCH I FOUND THIS IS A COMMON PROBLEM BUT MINI WON'T ISSUE A RECALL FOR THIS COMMON PROBLEM. *TR

Mileage: 48,000

WAS DRIVING BACK FROM VACATION, AND UPON GETTING OFF THE HIGHWAY WE HAD NOTICED A LOUD RATTLING WAS COMING FROM THE ENGINE. BROUGHT THE CAR TO A MECHANIC WHO SAID THE TIMING CHAIN TENSIONER HAD FAILED, RESULTING IN THE TIMING CHAIN TO BE LOOSE AND DESTROY THE RAILS IT RODE ON. UPON LOOKING INTO THIS ISSUE FURTHER, DISCOVERED THERE IS A TSB OUT ABOUT THIS ISSUE, AND MANY OWNERS HAVE HAD THIS SAME PROBLEM, BUT IT IS NOT A RECALL YET. *TR

Mileage: 47,050

CHECK ENGINE LIGHT ON AND OFF INTERMITTENTLY; ENGINE ROUGH ON START UP; SOUNDS LIKE RATTLING CHAINS WHEN SHIFTING; MINI SAID OUR OIL WAS TOO LOW SUBSEQUENTLY DESTROYING OUR TIMING CHAIN; TECH WAS AMAZED THAT THE CHAIN GUIDES WERE SHORN OFF AS WELL; MINI DOES NOT HAVE A CHECK OIL INDICATOR LIGHT ON THE CONSOLE; WE CHANGE OUR OIL EVERY 5000 MILES EVEN THOUGH MINI RECOMMENDS EVERY 15000. SO, WE HAD TO REPLACE THE TIMING CHAIN ON A 5 YEAR OLD CAR WITH LESS THAN 44,000 MILES. COMPLAINED TO MINI CORPORATION AND PROCEEDED WITH CONFLICT RESOLUTION EXPERT. MINI DENIED OUR CLAIM BECAUSE OUR OIL WAS LOW AT THE TIME OF THE INCIDENT. REPAIR COST $1,950.83 AND WE ARE STILL MAKING A CAR PAYMENT ON THIS NEWER VEHICLE. RESEARCHED SIMILAR COMPLAINTS ON THE INTERNET AS WELL AS TALKING WITH 3 ACQUAINTANCES WHO OWN A MINI. WE ARE FORTUNATE WE CAUGHT THIS ISSUE BEFORE WE HAD TO REPLACE OUR ENGINE. ACCORDING TO THEIR WEBSITE, BMW/MINI FINDS OIL USAGE AT 1 QUART PER 1000 MILES AS ACCEPTABLE. IF THAT IS THE CASE, THEY NEED TO INSTALL A CHECK OIL INDICATOR LIGHT ON THE CONSOLE AND CHANGE THEIR MAINTENANCE SCHEDULE FROM 15000 TO 3000 MILES. *TR

Mileage: 43,483

I BOUGHT MY 2007 MINI USED 1 MONTH AGO. WHEN I WENT TO TEST DRIVE THE CAR THE ENGINE WOULD NOT START AND THERE WAS A CHECK ENGINE LIGHT ON. THE DEALER TOLD ME THAT THEY WOULD HAVE IT FIXED AND CALL ME BACK IN FOR A TEST DRIVE. I WENT BACK AND WHEN THE CAR STARTED IT HAD A VERY SLIGHT RATTLE THAT EVENTUALLY WENT AWAY. NOW IN THE MONTH TIME THAT I HAVE HAD THE CAR IT TAKES ME 6 OR 7 TRIES TO GET THE ENGINE TO START, AND WHEN IT RUNS IT HAS THE RATTLE THAT HAS PLAGUED SO MANY OTHER MINI OWNERS. ENOUGH IS ENOUGH. ACTION MUST BE TAKEN TO CORRECT THE INADEQUACY OF THE INFERIOR TIMING CHAIN SET UP. THE DEALER HAS TOLD ME THAT IT IS A "NORMAL" MINI NOISE AND THAT I WOULD HAVE TO GET USED TO IT. THAT IS IN A SENSE A "COP OUT" FOR A PROBLEM THAT IS HEAVILY KNOWN IN THE MINI COMMUNITY AND THAT BMW MINI IS WELL AWARE OF. THIS IS A MAJOR MECHANICAL DEFECT IN THE CAR AND BMW MINI NEED TO OWN UP TO REPAIR WITH AN UPDATED AND CURRENT CORRECTIVE ACTION OR REPLACE THE ENGINES FOR ALL THE LOYAL MINI OWNERS EXPERIENCING THIS VERY COSTLY PROBLEM THAT COULD LEAD TO TOTAL DRIVELINE FAILURE. WE PAID FOR A GOOD RUNNING RELIABLE VEHICLE AND ARE NOT GETTING WHAT WE PAID FOR. *TR

Mileage: 58,000

MY CAR HAS A TRANSMISSION PROBLEM. HAVE TO REPLACE IT FOR $9000! IT S MINI COOPER S 2007 ONLY 29800 MILES!! THE DEALER WILL NOT REPINES ANYTHING AND THE WARRANTY IS OUT! *TR

Mileage: 29,800

ENGINE TIMING CHAIN TENSIONER MALFUNCTIONING CAUSING DECREASED ACCELERATING POWER AND A LOUD RUBBING/KNOCKING NOISE WHEN DRIVING, THAT WILL CAUSE ENGINE DAMAGE IF NOT PROMPTLY FIXED. IT IS A WELL KNOW MINI COOPER PROBLEM (2007 MODELS TO CURRENT YEAR) AND THE MINI DEALERSHIP I TOOK MINE TO HAS HAD MANY COMPLAINTS ABOUT THE ISSUE. MINI HAS CAME OUT WITH REPLACEMENT PARTS AND A SERVICE GUIDE ON HOW TO REPAIR THE ISSUE AT A HEFTY COST (IF THE ENGINE HASN'T ALREADY BEEN DAMAGED); HOWEVER, MINI/BMW HAS NOT ISSUED A RECALL OR REPLACEMENT AT NO COST TO CONSUMERS TO BACK UP THEIR PRODUCT. ESTIMATES FOR REPAIR IN MY AREA WERE $1300-$1600 IF REPAIRABLE BECAUSE AGAIN, IT WILL CAUSE ENGINE FAILURE IF NOT FIXED QUICKLY. MY CAR HAS 41,000 AND HAVE HAD MY MINI SERVICED AT THE DESIGNATED TIME INTERVALS AT ONLY MINI SERVICES AREAS. SUCH A MAJOR REPAIR THAT COULD HAVE EVENTUALLY CAUSED MY ENGINE TO STOP WORKING SHOULD NOT HAPPEN AT 41,000 MILES. MINI/BMW SHOULD BACK UP THERE PRODUCT WITH REPAIRS AND NEEDS TO FIND AN ULTIMATE FIX BECAUSE IT IS AN ISSUE EVEN IN THE CURRENT MODELS. *TR

Mileage: 41,000

TIMING CHAIN TENSIONER REPLACED JULY OF 2011 NOW AUG31,2012 LOUD NOISE TIMING CHAIN STRETCHED SO REPLACED & TENSIONER REPLACED AGAIN. *TR

Mileage: 46,205

IN JANUARY 2012 WITH 37,000 MILES ON IT MY MINI STARTED HAVING VERY NOISY STARTS. THE NOISE WOULD GO AWAY AFTER IT WARMED UP. TOOK THE VEHICLE TO MINI DEALER AND THEY SAID THAT IT WAS THE TIMING CHAIN AND TENSIONER. THEY AGREED TO REPLACE THE TIMING CHAIN, TENSIONER GUIDES ETC FOR HALF PRICE AS A GOOD WILL GESTURE. NOW I FIND OUT THAT THIS IS A COMMON PROBLEM. *TR

Mileage: 37,570

TL* THE CONTACT OWNS A 2007 MINI COOPER S. WHILE DRIVING APPROXIMATELY 35 MPH THE CONTACT NOTICED A BURNING ODOR. THE CONTACT STOPPED THE VEHICLE ON THE SHOULDER AND NOTICED SMALL FLAMES AND SMOKE COMING FROM UNDER THE HOOD. THE CONTACT WAS ABLE TO EXTINGUISH THE FIRE WITH A BLANKET. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING WHERE THE TECHNICIAN STATED THAT THE OIL RETURN LINE THAT WAS CONNECTED TO THE TURBO CHARGER HAD BEGAN LEAKING OIL AND CAUSED THE FIRE. THE VEHICLE WAS REPAIRED HOWEVER, AFTER THE REPAIR THE CONTACT WAS DRIVING APPROXIMATELY 65 MPH WHEN THE VEHICLE SUDDENLY STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER A SECOND TIME FOR DIAGNOSTIC TESTING. THE TECHNICIAN THEN STATED THAT THE TURBO CHARGER AND THE ENGINE WOULD HAVE TO BE REPLACED. THE TECHNICIAN STATED THAT THE TURBO CHARGER COULD HAVE BEEN DAMAGED DURING THE FIRE. IN ADDITION, THE CONTACT HAD PREVIOUSLY EXPERIENCED INTERMITTENT STALLING AND THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TIMING BELT TENSIONER WAS REPLACED. THE APPROXIMATE FAILURE MILEAGE WAS 60,800.

Mileage: 60,800

THE ENGINE QUIT WHILE PREPARING TO ENTER A HIGHWAY. THE CAR WAS ACCELERATING TO TURN ONTO THE HIGHWAY AND IT JUST QUIT AND PARTIALLY BLOCKED THE HIGHWAY. LUCKILY THE HIGHWAY WAS ON A SLOPE AND TO PREVENT FROM BLOCKING THE HIGHWAY AND RISK INJURY, I WAS ABLE TO COAST INTO A FIRE STATION ALONG THE HIGHWAY AND FROM THERE PUSH THE CAR OUT OF THE WAY OF TRAFFIC. THE CAUSE OF THE FAILURE IS A BROKEN TIMING CHAIN WHICH BROKE WITH NO WARNING. THE REPAIR WILL COST ABOUT $4000. THE FACT THAT IT BROKE AS I WAS ENTERING A HIGHWAY AND WITH NO ON-COMING TRAFFIC WAS VERY LUCKY. THERE IS NO WARNING FOR THE ENGINE TO STOP. THIS SEEMS LIKE A COMMON PROBLEM FOR 2007 MINIS AND AS THESE CARS AGE THE LIKELY HOOD OF THE PROBLEM OCCURRING INCREASES. THIS CAN HAPPEN AT ANY TIME THE ENGINE IS RUNNING AND WITHOUT WARNING. THIS IS A SAFETY ISSUE AS AN ABRUPT ENGINE FAILURE CAN HAPPEN ANYWHERE AND WITHOUT NOTICE. IT WAS OVER 100F THE DAY MY ENGINE QUIT, I WAS OVER 90MILES AWAY FROM HOME IN A SPARSELY POPULATED RURAL AREA WITH NO CELL PHONE COVERAGE. IF IT HAD HAPPENED 15 MILES IN EITHER DIRECTION IT COULD HAVE BEEN HOURS BEFORE ANYONE FOUND ME AND MY CAR. *TR

Mileage: 56,000

WITHOUT WARNING THE CAR STARTED JERKING AND RUNNING VERY ROUGHLY AND THE ENGINE WARNING LIGHT CAME ON. WE BROUGHT THE CAR INTO THE MINI DEALER TO BE DIAGNOSED. WHILE THE DEALER WAS VERY HELPFUL, THE DIAGNOSES WAS DISTURBING AT BEST. AFTER TEARING APART THE MOTOR, CLEANING IT AND REASSEMBLING, THE PROBLEM REMAINED. IT WAS "MINI SERVICES" RECOMMENDATION TO THE DEALER THAT THE TIMING BELT BE CHANGED. THIS IS A 13 HOUR PROCEDURE THAT COST JUST OVER $2000 AND PROVIDES NO GUARANTEE THAT IT WILL SOLVE THE PROBLEM. IN ADDITION, THEY MAY RUN INTO MORE PROBLEMS ONCE THEY ARE INSIDE OF THE ENGINE. TO ADD INSULT TO INJURY, THE TIMING BELT TENSIONER HAD ALREADY BEEN REPLACED DO TO A SIMILAR PROBLEM WHILE UNDER WARRANTY. WE HAVE ELECTED TO PAY $5000 FOR A NEW MOTOR AND 2 YEAR WARRANTY SO AT LEAST WE WOULD HAVE A SLIGHT PIECE OF MIND THAT THE PROBLEM WOULD NOT REOCCUR AT OUR EXPENSE. I COMPLETELY UNDERSTAND THE RISKS OF OWNING A VEHICLE BEYOND THE WARRANTY PERIOD. I JUST WISH BMW MINI WOULD RECOGNIZE THIS PROBLEM AND STAND BEHIND WHAT APPEARS TO BE A RAMPANT PROBLEM WITH THE "TIMING-BELT-TENSIONER" ON THE 2007 S MODELS. I WAS SHOCKED TO SEE THE PAGES OF OWNERS THAT ARE REPORTING THE SAME PROBLEM. MY WIFE LOVES THIS CAR. THERE IS NO WAY I WOULD PURCHASE ANOTHER MINI PRODUCT AFTER PAYING OVER $30,000 FOR THE 2007 63,000 MILE DISPOSABLE MODEL. *TR

Mileage: 63,000

TIMING CHAIN AND TENSIONER FAILURE MENTIONED BY OTHERS ALSO OCCURRED IN MY CAR. FAILURE IN MY CASE WAS PROGRESSIVE: STARTED WITH ROUGH STARTS, NOISY IDLE (FROM CHAIN IMPACTING COVER!) PROGRESSED TO NON-EXISTENT ACCELERATION ABOVE 4000 RPMS (A SAFETY ISSUE ON THE HIGHWAY) . BROUGHT THE CAR TO MECHANIC AND WHILE HE WAS INVESTIGATING THE OBVIOUS AIR LEAK, CAR FAILED TO START. DEALER EVENTUALLY DISCOVERED BENT VALVES FROM IMPACT WITH PISTON PREVENTING PROPER SEAL, BUT ONLY AFTER REPLACING SNAPPED TENSIONER GUIDES AND TIMING CHAIN DROPPED INTO OIL PAN FOR $2,525. HAD THIS OCCURRED WHILE DRIVING IT POSES A SIGNIFICANT SAFETY ISSUE. THEN THEY TELL ME THEY CAN REPLACE ALL VALVES FOR $4,500. TOTAL COST, OVER $7,000. EFFECTIVELY, THIS IS A TOTAL ENGINE FAILURE AND IT WOULD BE CHEAPER TO DROP IN A COMPLETE NEW ENGINE. MINI AND THEIR DEALERS ARE WELL AWARE OF THIS PROBLEM AND AS IT CAN - AND HAS - RESULTED IN FAILURES FOR OTHER MOTORISTS AT HIGHWAY SPEEDS IT POSES SIGNIFICANT SAFETY RISK AND SHOULD BE ADDRESSED WITH A RECALL. *TR

Mileage: 103,000

ENGINE IS RATTLING HORRIBLY. IN DOING SOME RESEARCH IT SOUNDS LIKE WHAT MOST ARE CALLING THE "RATTLE OF DEATH". THE TIMING CHAIN IS MAKING ENTIRELY TOO MUCH NOISE. AND CAR IS RUNNING POORLY. I CAN NOT AND WILL NOT DRIVE THIS CAR TILL IT IS REPAIRED! THIS IS A POTENTIAL CATASTROPHIC ENGINE FAILURE. MINI COOPER KNOWS ABOUT THIS MAJOR ENGINEERING PROBLEM AND WILL NOT ISSUE A RECALL. REPAIR ESTIMATES ARE AS MUCH AS $2500.00 FOR TIMING CHAIN AND TIMING CHAIN TENSIONER. *TR

Mileage: 17,669

MY CAR HAS BEEN MAKING A RATTLING SOUND FOR ABOUT 6 MONTHS. ALTHOUGH THE CAR HAS BEEN SERVICED TWICE DURING THAT TIME, NO TECHNICIAN OR MINI SERVICE DEPARTMENT REPRESENTATIVE SAID ANYTHING ABOUT THE RATTLE. WHILE DRIVING ON THE HIGHWAY I NOTICED MY CAR BEGINNING TO RUN... FUNNY. NOT LONG AFTER, THE ENGINE POWER LIGHT CAME ON. APPROXIMATELY 10-15 MILES LATER, MY CAR STOPPED IN THE MIDDLE OF THE ROAD. BECAUSE THE CAR WOULD NOT RESTART, IT WAS TOWED TO A MINI SERVICE DEPARTMENT. I WAS TOLD THE PROBLEM WAS THE TIMING CHAIN, AND IT NEEDED TO BE REPLACED. THERE ARE COUNTLESS NUMBERS OF THESE REPORTS ON THE INTERNET. INSPITE OF THE NUMBERS OF COMPLAINTS AND REPAIRS, MINI/BMW HAS REFUSED TO TAKE RESPONSIBILITY FOR THE PART. IT WAS VERY FORTUNATE THERE WAS NO CRASH OR FATALITY, AGAIN MY CAR STOPPED IN THE MIDDLE OF THE ROAD WITH VERY LITTLE WARNING. *TR

Mileage: 78,000

THE TIME CHAIN JUMPED WHICH NEEDS TO BE REPLACED. THIS SHOULDN'T HAPPEN WITH SUCH LOW MILES ON THE CAR. MINI REFUSED TO ACCEPT RESPONSIBILITY. IT IS A VERY EXPENSIVE REPAIR TO REPLACE THE TIMING CHAIN.. THE CAR BEGAN TO MAKE KNOCKING NOISE AND RUN ROUGH. COULDN'T DRIVE THE CAR AND HAD TO HAVE IT TOWED TO MINI COOPER SERVICE DEPT. *JS

Mileage: 60,000

THE COLD START RATTLE WAS/IS BEING CAUSED BY THE TIMING CHAIN TENSIONER (WHICH IS IN TURN POWERED BY AN OIL-PRESSURIZED PISTON). MORE SPECIFICALLY THE SOUND IS CAUSED WHEN THE TENSIONER PISTON DOESN'T EXTEND ALL THE WAY (OR AT ALL) WHICH THEN ALLOWS THE TIMING CHAIN TO COME IN CONTACT WITH THE GUIDES ON THE ENGINE COVER. *TR

THE TIMING CHAIN TENSIONER BRACKETS ALL BROKE ON MY 07 MINI. MY MECHANIC STATED THAT THIS IN NOT A NEW ISSUE AND THE IT IS A FREQUENT PROBLEM THAT HE DEALS WITH ON SEVERAL MINIS. THEY ARE MADE OF PLASTIC AND WHEN CRACKED OR BROKEN THEY ALLOW MY TIMING CHAIN TO SLIP CAUSING DAMAGE TO MY ENGINE. I HAVE ALREADY SPENT OVER 2000 DOLLARS IN REPAIRS FOR THIS PROBLEM, AND IT HAS HAPPENED TWICE IN THE LAST 5 YEAR THAT I HAVE OWNED THE VEHICLE. BMW/MINI MUST TAKE RESPONSIBILITY FOR THEIR DEFECTIVE ENGINE PARTS. THERE SHOULD BE A RECALL ON THESE VEHICLES FOR IT CAN CAUSE ENOUGH DAMAGE TO WERE YOU WOULD NEED A NEW ENGINE. *TR

Mileage: 37,000

I HAVE HAD AN ISSUE WITH MY 07' MINI COOPER S ENGINE'S TIMING CHAIN SINCE 2010. THE TENSIONER BRACKETS FOR THE TIMING CHAIN THAT CAME WITH MY 07 MINI ARE MADE OUT OF PLASTIC AND BREAK EASILY, CAUSING THE TIMING BELT TO SLIP AND DAMAGE MY ENGINE. IT HAS CURRENTLY COST ME 1500 DOLLARS IN REPAIRS TO FIX THE ISSUE. THE REPAIR CAN ONLY BE A TEMPORARY FIX BECAUSE THE BRACKETS WERE SIMPLY REPLACED WITH THE SAME PLASTIC BRACKETS THAT BROKE PREVIOUSLY. I AM SIMPLY AWAITING THE DAY THEY BREAK AGAIN. THIS IS NOT A NEW ISSUE, AS I HAVE SEEN MULTIPLE COMPLAINTS OF THIS VERY SAME ISSUE ALL OVER THE INTERNET AND BMW NEEDS TO BE HELD RESPONSIBLE FOR THEIR DEFECTED ENGINES. I SUGGEST A RECALL BE PLACED ON THE 07 - 10 MINI COOPERS, COOPER S, AND CONVERTIBLES, FOR THEIR DEFECTIVE TENSIONER BRACKETS FOR THE TIMING CHAIN BECAUSE IT CAN CAUSE SEVERE DAMAGE TO THE ENGINE IF NOT DESTROY THE ENGINE COMPLETELY. *TR

Mileage: 40,000

MINI COOPER 2007 - RATTLES WHEN COLD. TOOK THE CAR TO THE DEALER. FELT TO BE A PROBLEM WITH THE TIMING CHAIN. I DID SOME RESEARCH. IT'S A KNOWN PROBLEM AND CAN LEAD TO THE ENGINE SEIZING DURING DRIVING. IT'S A SAFETY ISSUE THAT MINI IS WELL AWARE OF. MY CAR ONLY HAS 40,000 MILES ON IT. THE REPAIR WOULD COST ~$2500. IF I DON'T REPAIR IT, I WORRY ABOUT THE ENGINE FAILING WHILE I'M ON THE HIGHWAY - OR WORSE, WITH MY KIDS IN THE CAR DURING A DRIVE. MINI KNOWS ABOUT THIS AND HAS DIRECTED DEALERS SPECIFICALLY ON THIS PROBLEM. COUNTLESS ONLINE COMPLAINTS ABOUT THE SAME THING. MINI SHOULD OFFER A RECALL AND FIX THIS KNOWN DEFECT BEFORE ANYONE LOSES CONTROL OF A CAR WHILE DRIVING AND SOMEONE GETS HURT. UPDATED IVOQ 07/09/12. *TT

Mileage: 40,000

TOOK MY CAR INTO THE MINI DEALER TODAY DUE TO THE FACT THAT IT WAS IDLING LOW, SOUNDED LIKE A DIESEL WHEN IT TURNED ON AND MADE A KNOCKING NOISE. MINI LET ME KNOW THAT IT WAS IN FACT MY TIMING CHAIN AND TENSIONER SYSTEM THAT WAS MAKING THIS SOUND AND NEEDED TO BE REPLACED. IF IT HAD NOT BEEN REPLACED, I COULD HAVE EXPERIENCED COMPLETE ENGINE FAILURE. MY MINI IS NOT THE ONLY ONE THAT HAS HAD THIS PROBLEM, THEREFORE I FEEL LIKE MINI SHOULD COVER THE COST OF FIXING MY TIMING CHAIN AND TENSIONER SINCE IT IS GOING TO COST ME APPROXIMATELY $2,500 TO FIX IT. I GUESS I SHOULD BE THANKFULLY THAT I WAS ABLE TO GET MY MINI TO THE DEALER BEFORE IT SUFFERED A COMPLETE ENGINE FAILURE. *JS

Mileage: 68,000

ONE MONTH AFTER MINI OF CONCORD REPLACED MY HIGH PRESSURE FUEL PUMP FOR THE GASOLINE LEAK AND STRONG GAS SMELL WITHIN THE CABIN, AGAIN THE GAS SMELL STARTED UP IN THE CABIN (FOR ALL TRIPS). I TOOK IT BACK TO MINI OF CONCORD (THIS IS 14 MONTHS AFTER BUYING CAR), AND THEY AGAIN FOUND A LEAK IN THE HIGH PRESSURE FUEL PUMP AND LINE, AND REPLACED THE PARTS - AGAIN. THIS WAS THE THIRD OF FOUR REPLACEMENTS OF THE HIGH PRESSURE FUEL PUMP ON MY CAR. *TR

Mileage: 29,758

EIGHT MONTHS AFTER MINI OF CONCORD REPLACED MY HIGH PRESSURE FUEL PUMP FOR THE GASOLINE LEAK AND STRONG GAS SMELL WITHIN THE CABIN, AGAIN THE GAS SMELL STARTED UP IN THE CABIN (FOR ALL TRIPS). I TOOK IT BACK TO MINI OF CONCORD (THIS IS 22 MONTHS AFTER BUYING CAR), AND THEY AGAIN FOUND A LEAK IN THE HIGH PRESSURE FUEL PUMP AND LINE, AND REPLACED THE PARTS - AGAIN. THIS WAS THE FOURTH REPLACEMENT OF THE HIGH PRESSURE FUEL PUMP ON MY CAR! THEY ALSO REPLACED THE TIMING CHAIN TENSIONER BECAUSE OF THE LOUD NOISE IT WAS MAKING ON STARTUP. AND THE INLET CAMSHAFT POSITION SENSOR. *TR

Mileage: 44,399

IN EARLY JANUARY 2008, 5 MONTHS AFTER PURCHASING MY CAR, IT STARTED TO SMELL STRONGLY LIKE GASOLINE INSIDE THE CABIN, AND I WAS CONCERNED THAT THERE WAS A RISK OF FIRE. I PULLED OVER AND LET THE CAR SIT, AND RESTARTED IT, BUT THE SMELL RESUMED. I BROUGHT IT IN TO MINI OF SF, AND THEY FOUND A LEAK IN THE HIGH PRESSURE FUEL PUMP AND LINE, AND REPLACED THE PARTS. THIS WAS THE FIRST OF FOUR REPLACEMENTS OF THE HIGH PRESSURE FUEL PUMP ON MY CAR. *TR

Mileage: 10,470

IN AUGUST OF 2008, 12 MONTHS AFTER PURCHASING MY CAR, IT FOR A 2ND TIME IN 1 YEAR, STARTED TO SMELL STRONGLY LIKE GASOLINE INSIDE THE CABIN. I BROUGHT IT IN TO MINI OF CONCORD, AND THEY FOUND A LEAK IN THE HIGH PRESSURE FUEL PUMP AND LINE, AND REPLACED THE PARTS - FOR A 2ND TIME. THIS WAS THE SECOND OF FOUR REPLACEMENTS OF THE HIGH PRESSURE FUEL PUMP IN MY CAR. *TR

Mileage: 27,793

I JUST BOUGHT A MINI COOPER S WITH 70,000 MILES ON IT AND THE ENGINE LIGHT CAME ON. I NOW SEE WHERE ERROR CODE P0012 IS AFFECTED BY SERVICE BULLETIN SIM-11-02-07 AND PUMA MEASURE 10686850-13. THE FACT THAT THE ENGINE PROCESS AFFECTING THE OIL CONDITION IS THE START OF THIS OCCURRENCE AND YIELDING SOME ISSUES WITH THE VANOS UNIT AND THE TIMING CHAIN, I AM AT A LOSS. NOW THIS IS MY PROBLEM, AND IT IS ALL THE FAULT OF MINI. I AM WONDERING WHAT TO DO?? *TR

Mileage: 70,000

MINI ISSUED A SERVICE BULLETIN ON FAILED TIMING CHAIN TENSIONERS IN 2009. SERVICE BULLETINS SIM-11-02-07 AND PUMA MEASURE NUMBER 10686850-13. THE BULLETIN STATES THAT WHEN A CUSTOMER COMES IN WITH A TENSIONER PROBLEM THAT ALL CARS AFFECTED WILL RECEIVE A NEW TIMING CHAIN, CHAIN GUIDES, CAM SPROCKETS AND VANOS UNIT. ON 6/23/10 MY VEHICLE REQUIRED THIS REPAIR. BECAUSE I WASN'T AWARE OF THE SERVICE BULLETINS THE MINI DEALERSHIP ONLY REPLACED MY VEHICLES TENSIONER WITHOUT REPLACING THE OTHER PARTS...THE TENSIONER IS AN EASY REPLACE AND THE ACTUAL TIMING CHAIN IS A 9.9 HOUR JOB SO I'M ASSUMING THEY TOOK THE EASY ROUTE WITH LESS ACCUMULATING LABOR. NOW WE'RE 23 MONTHS INTO THAT REPAIR AND THE TIMING CHAIN TENSIONER HAS GONE BAD...AGAIN. THIS TIME THE TENSIONER GOING OUT ALSO CAUSED THE TIMING CHAIN TO FAIL ALONG WITH THE CHAIN GUIDES. MINI WILL REPLACE THE TENSIONER AGAIN, WHICH IS A 26 DOLLAR PART, BECAUSE IT IS WITHIN THE 24 MONTH WARRANTY...BUT BECAUSE THE MINI DEALER THAT LAST REPLACED THE TENSIONER DID NOT FOLLOW THE BULLETINS ISSUED AND REPLACE THE OTHER PIECES INVOLVED IN THE BULLETIN, THEY SAY I'M RESPONSIBLE. MINI NOW WANTS TO CHARGE ME 1967 DOLLARS FOR THE REPAIR OF THE TIMING CHAIN AND CHAIN GUIDES BECAUSE IT SAYS THE OTHER PARTS ARE NOT COVERED. THE CAR HAS 50,062 MILES (WARRANTY IS TO 50K). THERE ARE WELL OVER 200 ENTRIES THAT I FOUND ON THE INTERNET WITH THIS PROBLEM AND A PETITION WITH OVER 650 SIGNATURES. WHEN IS SOMETHING GOING TO BE DONE? *TT

Mileage: 30,767