2007 MINI COOPER S Power Train Problems

MY CAR STARTED TO ACT FUNNY. ALMOST SOUNDING LIKE IT WAS SUFFOCATING. IT WOULD DIE ABOUT TEN TO FIFTEEN TIMES EVERY MORNING BEFORE I WOULD FINALLY GET THE CAR STARTED. IT WOULD SHUT OFF WHEN I STOPPED AT INTERSECTIONS. THE ONLY TIME IT RAN DECENT WAS WHEN I WAS DRIVING HIGHWAYS SPEEDS FOR 20 MINUTES OR MORE. I CHANGED OUT FILTERS, SPARK PLUGS, AND FLUIDS BUT NONE OF IT CHANGED THE WAY IT WAS RUNNING. COME TO FIND OUT IT THAT THE CHAIN AND CHAIN TENSIONER HAD BROKEN. THIS DAMAGE CAUSED ROUGHLY $1000 TO FIX. LUCKILY I CAUGHT IT IN TIME BEFORE IT DID ADDITIONAL DAMAGES TO THE CRANK SHAFT. WITH LOW MILES THE MECHANIC EVEN TOLD ME ITS A FAULT PART AND BRAKES EASILY. HE HAS HAD TO REPLACE NUMEROUS AMERICAN MODEL MINIS IN ITALY. MY COUNTRY CODE IS 39 IF YOU CALL. *TR

Mileage: 49,000

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT TRANSMISSION FLUID WOULD LEAK FROM THE VEHICLE WHEN DRIVING VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION WHERE IT WAS CONFIRMED THAT THE VEHICLE WAS LEAKING TRANSMISSION FLUID. THE AXLE AND SEAL FOR THE TRANSMISSION WAS REPLACED HOWEVER THE FAILURE RECURRED. THE VEHICLE WAS NOT FURTHER REPAIRED. THE CONTACT ALSO MENTIONED THAT THE TURBO OIL FEED LINE HAD TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 84000.

Mileage: 84,000

RAN A DIAGNOSTIC TEST AND THESE WARNINGS CAME UP - 2D52 SUPER KNOCKING 2DCD FUEL SHUT OFF DUE TO SUPER KNOCKING CYLINDER 3 2968 INLET CAMSHAFT SENSOR 2B64 INTAKE MANIFOLD, UNMETERED AIR BASED ON ALL OF THESE SOUND LIKE MY MINI COOPER HAS BAD FUEL AND/OR SERIOUS CARBON BUILD, I'VE JUST PURCHASED THIS CAR FROM A DEALERSHIP AND I AM EXPERIENCING DELAYS IN ACCELERATION, LOSS OF FORWARD PROPULSION.

Mileage: 55,302

I TOOK MY CAR INTO MY LOCAL SHOP AND HAD OIL CHANGE,NEW BATTERY,TIRES ROTATED AND ALIGNMENT .THEY COULD A NOISE FROM THE ENGINE AND THEY CHECKED IT OUT. CALL ME TO INFORM ME THAT I HAD TO TAKE TO THE MINI COOPER DEALERSHIP BECAUSE THE TIMING CHAIN NEEDED TO BE REPLACE. I CALLED MINI COOPER AND SPOKE TO [XXX] AT THE HOUSTON DEALERSHIP MOMENTUM MINI. SHE INFORMED ME THAT THE COST WOULD BE ANYWHERE FROM 4000 TO 10,000 DOLLARS. I EXPLAINED TO HER I HAD THE CAR FOR 1 YEAR AND HAVE ANY DRIVEN 6000 MILES IN A YEAR. AFTER DOING RESEARCH I NOTICED THAT OTHER PEOPLE WHERE HAVING THE SAME ISSUES WITH THERE MINI. I PURCHASED THIS CAR WITH 39,126 MILES ON IT AND MY DAILY DRIVE TO WORK IS A QUARTER MILE IF THAT. PLEASE HELP !!! INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 46,000

TL* THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT COOLANT WAS LEAKING FROM THE VEHICLE. THE CONTACT ALSO STATED THAT THE TRANSMISSION MOUNT WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS FOUND THAT THE COOLANT HOUSING AND THE TRANSMISSION MOUNT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 70,000.

Mileage: 70,000

I PURCHASED THE VEHICLE AS IS FROM A SMALL LOCAL LOT JANUARY OF 2013, EVERYTHING CHECKED OUT AS PERFECT. I LOVE THE CAR. WAS DRIVING HOME FROM WORK AND LUCKILY I WAS ABOUT 10 MILES FROM HOME AND AT THE SPEED OF 35 MPH WHEN IT FELT LIKE IT WAS STUCK IN A GEAR (CAR IS AUTOMATIC) THEN I NOTICED MY CHECK ENGINE LIGHT CAME ON. I REMAINED AT THE SPEED OF 35MPH OR LOWER BECAUSE I DIDN'T WANT TO TAKE ANY CHANCES. THEN MY BRAKE LIGHT CAME ON WHICH MADE ME THINK I HAD BRAKE ISSUES. I PARKED IT LIFTED THE HOOD AND IT WAS EXTREMELY HOT AND YOU COULD HEAR THE FANS RUNNING EXTRA HARD. WE TOOK IT TO A LOCAL GUY TO LOOK AT IT AS HE TOLD US HE JUST HAD A MINI IN WITH SAME ISSUE WEEKS BEFORE AND AAA CAME TO TOW IT TO HENDRICK MINI IN CHARLOTTE. THEY THOUGHT IT WAS VALUE STEMS AND ETC FIND OUT A FEW HOURS LATER NOT THE CASE I NEED A WHOLE NEW TRANSMISSION. THE CAR IS A '07 WITH ONLY 54K MILES ON IT IN PERFECT CONDITION. MAKES NO SENSE. MINI/BMW US HAS HEARD OF MY COMPLAINT AND HAS TOLD ME THERE IS NOTHING THEY WILL DO TO MAKE IT RIGHT. IF YOU ASK ME FROM EVERYTHING I'VE READ ONLINE THIS NEEDS TO BE A RECALL AS EVERYONE HAS HAD THE SAME ISSUE. THIS IS VERY UNSAFE AND I CAN'T AFFORD $9K TO PAY FOR A NEW TRANSMISSION. I LOVED MY MINI COOPER BUT AS IT STANDS RIGHT NOW I'M CAR LESS AND LEFT MAKING PAYMENTS ON A CAR I CANNOT EVEN DRIVE AND IT IS SITTING IN THE SHOP ON HOLD FOR THE TIME BEING. MINI/BMW NEEDS TO REALIZE ALL OF THE CUSTOMERS THEY ARE LOSING OVER THIS. *TR

Mileage: 54,500

I BOUGHT MY 2007 MINI USED 1 MONTH AGO. WHEN I WENT TO TEST DRIVE THE CAR THE ENGINE WOULD NOT START AND THERE WAS A CHECK ENGINE LIGHT ON. THE DEALER TOLD ME THAT THEY WOULD HAVE IT FIXED AND CALL ME BACK IN FOR A TEST DRIVE. I WENT BACK AND WHEN THE CAR STARTED IT HAD A VERY SLIGHT RATTLE THAT EVENTUALLY WENT AWAY. NOW IN THE MONTH TIME THAT I HAVE HAD THE CAR IT TAKES ME 6 OR 7 TRIES TO GET THE ENGINE TO START, AND WHEN IT RUNS IT HAS THE RATTLE THAT HAS PLAGUED SO MANY OTHER MINI OWNERS. ENOUGH IS ENOUGH. ACTION MUST BE TAKEN TO CORRECT THE INADEQUACY OF THE INFERIOR TIMING CHAIN SET UP. THE DEALER HAS TOLD ME THAT IT IS A "NORMAL" MINI NOISE AND THAT I WOULD HAVE TO GET USED TO IT. THAT IS IN A SENSE A "COP OUT" FOR A PROBLEM THAT IS HEAVILY KNOWN IN THE MINI COMMUNITY AND THAT BMW MINI IS WELL AWARE OF. THIS IS A MAJOR MECHANICAL DEFECT IN THE CAR AND BMW MINI NEED TO OWN UP TO REPAIR WITH AN UPDATED AND CURRENT CORRECTIVE ACTION OR REPLACE THE ENGINES FOR ALL THE LOYAL MINI OWNERS EXPERIENCING THIS VERY COSTLY PROBLEM THAT COULD LEAD TO TOTAL DRIVELINE FAILURE. WE PAID FOR A GOOD RUNNING RELIABLE VEHICLE AND ARE NOT GETTING WHAT WE PAID FOR. *TR

Mileage: 58,000

MY CAR HAS A TRANSMISSION PROBLEM. HAVE TO REPLACE IT FOR $9000! IT S MINI COOPER S 2007 ONLY 29800 MILES!! THE DEALER WILL NOT REPINES ANYTHING AND THE WARRANTY IS OUT! *TR

Mileage: 29,800

MINI COOPER DRIVERS AROUND THE U.S. AND WORLD HAVE BEEN REPORTING A STRANGE KNOCKING/RUBBING NOISE COMING FROM THE ENGINE COMPARTMENT FOR THE YEAR 2007+ MINI COOPER. FROM THE MISC DEALER REPAIR DETAILS IT APPEARS TO BE A ISSUE WITH THE TIMING CHAIN AND TENSIONER SYSTEM. IT ALSO APPEARS THE WITHOUT BEING FIXED THE CAR WILL EVENTUALLY HAVE A TIMING CHAIN FAILURE AND POSSIBLE MOTOR DESTRUCTION. ON A GOOD NOTE BMW/MINI KNOW WHAT THE PROBLEM IS HOWEVER IS FAILING TO COME UP WITH OR ACKNOWLEDGE A PERMANENT SOLUTION. HOW MANY CUSTOMERS ISSUES WILL IT TAKE BEFORE BMW/MINI WILL ISSUE A FULL RECALL? *TR

Mileage: 28,000

TIMING BELT TENSIONER FAILED RESULTING IN SLACK IN THE TIMING BELT. FINAL RESULT WAS THE TIMING BELT SLACK CONTACTED PLASTIC CHAIN GUARDS WHICH BROKE OFF AND LODGED INSIDE THE ENGINE. AFTER BEING TOWED TO MINI SERVICE, THEY RECOMMENDED REPLACING THE ENTIRE ENGINE. THIS IS A SAFETY ISSUE BECAUSE THE CRITICAL TIMING CHAIN FAILURE LED TO PREMATURE ENGINE FAILURE. THERE WAS A STRONG SMELL OF SMOKE AND I HAD INITIAL CONCERN THAT THE CAR WAS GOING TO CATCH ON FIRE. I WAS LUCKY THAT THE INCIDENT DID NOT OCCUR WHILE DRIVING IN TRAFFIC AS I WOULD HAVE BEEN STUCK ON THE ROAD WITHOUT ANY POWER ENDANGERING MYSELF AND OTHER DRIVERS. MINI IS WELL AWARE OF THE ISSUE WITH THE TIMING BELT TENSIONER, BUT HAS FAILED TO PROACTIVELY ADDRESS THE ISSUE. THE SERVICE MANAGER AT MINI EVEN HAS A BAG FULL OF BENT RODS AT HIS DESK THAT HE SHOWED ME AND TOLD ME HE HAS HAD MULTIPLE CARS COME IN WITH THE SAME ISSUE. *JS

Mileage: 70,000

CAR MISFIRED AND HAD BACKFIRED; CHECK ENGINE LIGHT CAME ON. TOOK CAR RIGHT TO DEALER , THEY TOLD US IT IS A KNOWN ISSUE AND DOING NOTHING BUT CHARGING CUSTOMERS FOR THE REPAIR. THE TIMING CHAIN AND TIMING TENSIONER HAS A DESIGN FLAW THAT IS RECOGNIZED BUT NOTHING DONE. IF FULL FAILURE ON ROADWAY CAN CAUSE CATASTROPHIC ISSUES TO ME AND OTHERS . *JS

Mileage: 59,000

TIMING CHAIN FAILURE CAUSING $1800 DAMAGE. WAS TOLD IT IS A KNOWN ISSUE AND COULD'VE BEEN REPLACED PRIOR TO THE DAMAGE AND SAVED TIME, MONEY, AND POTENTIAL DANGER. THANKFULLY NOTHING HAPPENED TO HARM ANYONE. KNOCKING NOISE, SMOKE, ENGINE LIGHT CAME ON, RUNNING POORLY. HAS BEEN FIXED NOW. *TR

Mileage: 44,769

I BOUGHT THIS 2007 MINI COOPER S PRE OWNED ABOUT 1 MONTH AGO. THIS CAR HAD APPROX. 32000 MILES ON IT WHEN I PURCHASED IT. AFTER DRIVING THE CAR FOR A FEW DAYS I NOTICED A BURNING SMELL LIKE RUBBER OR PLASTIC. I COMPLAINED TO THE MAN WHO SOLD THIS CAR TO ME AND HE HAD THE TURBO WATER PUMP REPLACED THROUGH THE RECALL DUE TO OVERHEATING. HEAT IN THE MOTOR REACHING MORE THAN 225 DEGREES CAN DESTROY MANY OTHER PARTS ON THIS CAR! NOW AFTER THE TURBO WATER PUMP REPLACEMENT THE CAR CONTINUES TO SMELL LIKE BURNING PLASTIC AND HE SAYS IT MUST TAKE A WHILE FOR THE ODOR TO LEAVE THE CAR. TWO WEEKS LATER THE CAR BEGINS LOOSING POWER AND ACTS LIKE IT HAS NO CLUTCH. I AM AN EXPERIENCED DRIVER AND HAVE OWNED MANY CARS WITH MANUAL GEARS. THIS CAR IS NOW IN THE SHOP FOR REPAIRS, A BURNED OUT CLUTCH, AND COULD EVEN BE TRANSMISSION PROBLEMS THAT ARE VERY PREMATURE AND SO MANY OTHER PEOPLE HAVE HAD THE SAME PROBLEM WITH THIS YEAR MAKE AND MODEL CAR. WHY CAN'T SOMETHING BE DONE TO HELP THOSE WHO WERE CHEATED BY OWNING SUCH A TROUBLESOME CAR. THIS CAR ALSO HAD THE TIMING CHAIN REPLACED A VERY LOW MILEAGE! *TR

Mileage: 33,849

VEHICLE PRODUCES LOUD METALLIC SOUNDS FROM THE LEFT SIDE OF THE ENGINE ON COLD START. MINI USA HAS REPEATEDLY STATED THIS IS OKAY, HOWEVER NOW AT 25000 MILES THE NOISE IS CONSTANT AND LOUD. READING DATA FROM OTHER MINI OWNERS THIS PROBLEM IS NOW EXTREMELY COMMON ON ALL MINI COOPERS WITH THE 1.6L PRODUCED AFTER 2007. MINI HAS QUIETLY REPLACED NUMEROUS BELT TENSIONERS TO FIX THIS PROBLEM BUT REFUSES TO ADMIT THIS IS A LARGE ISSUE OVER THE ENTIRE FLEET OF VEHICLES. ISSUE RESULTS IN A $3-4K LABOR BILL TO REPAIR. *TR

Mileage: 5,800

WHILE DRIVING IN HEAVY TRAFFIC FOLLOWING EXTENDED HIGHWAY SPEED, STOPPED AT TRAFFIC LIGHT AND ENGINE DIED WITH NO WARNING AND WOULD NOT RESTART. CAR HAD TO BE TOWED A CONSIDERABLE DISTANCE TO ORIGINAL DEALERSHIP. LEARNED THAT THE VACUUM PUMP SEIZED / LOCKED UP, CAUSING A CHAIN REACTION OF CATASTROPHIC RESULTS THAT TOTALLY DESTROYED ENGINE. CAR NEEDS COMPLETE NEW ENGINE AT 74,000 MILES (OUT OF WARRANTY)AND MINI USA ATTITUDE IS THAT SUCH ENGINE FAILURE IS NOT THEIR RESPONSIBILITY EVEN THOUGH THIS PARTICULAR MINI WAS IMPECCABLY MAINTAINED BEYOND MINI SERVCIE REQUIREMENTS, BUT TO NO AVAIL AS ENGINE BLEW AT A VERY YOUNG 74,000 MILES OF AGE AND THERE ARE REPEATED INSTANCES OF SAME ENGINE FAILURE ON INTERNET BMW/MINI BLOGS. NOTE: THIS CATASTROPHIC DAMAGE FOLLOWS LAST YEAR'S LARGE OUT OF WARRANTY EXPENSE OF REPLACING THE ENTIRE ELECTRONIC STEERING LOCK SYSTEM AS VEHICLE COULD NOT BE DRIVEN SAFELY AND AGAIN MINI FELT NO RESPONSIBILITY FOR EQUIPMENT FAILURE EVEN THOUGH THE PROBLEM WAS SUBSEQUENTLY ACKNOWLEDGED BY THE FACT THAT ELECTRONIC STEERING LOCK IS NO LONGER INSTALLED IN NEW MINI COOPERS! *TR

Mileage: 74,000

THE ENGINE BEGAN TO MAKE A LARGE RATTLING NOISE AND THE CHECK ENGINE LIGHT EVENTUALLY CAME ON. I STOPPED THE CAR AND CHECKED THE OIL TO SEE IF IT WAS LOW AND DISCOVERED THAT I WAS NOT ABLE TO GET THE DIP STICK BACK IN. AT THIS POINT I CALLED A TOW TRUCK AND TOOK IT TO A LOCAL MECHANIC BECAUSE THERE ISN'T A MINI DEALER WITHIN 100 MILES OF MY LOCATION. TURNS OUT IT WAS THE TIMING CHAIN TENSIONER WHICH IS A COMMON PROBLEM FOR THE COOPER S AND MINI HAS RELEASED THREE FIXES AND CLAIM THE LATEST TSB WILL FIX THE PROBLEM. MY CAR HAS LESS THAN 40,000 MILES AND I HAD TO SPEND $1,700 DOLLARS FOR A $26 DOLLAR PART THAT WAS FAULTY TO BEGIN WITH. MINI KNEW THEY HAD A PROBLEM AND TRIED TO FIX IT BUT FAILED ON TWO SEPARATE OCCASIONS THERE'S NO TELLING HOW LONG THIS NEW FIX WILL HOLD UP. NOT TO MENTION MY CAR IS STILL LOUDER THAN IT USE TO BE BEFORE THE PROBLEM AND IT SOUNDS LIKE A DIESEL ENGINE AT IDLE. THIS NOISE DOESN'T GIVE ME CONFIDENCE THAT THE LATEST FIX WILL LAST AND MINI NEEDS TO SERIOUSLY TAKE A LOOK AT THE PROBLEM AND SEND OUT A RECALL BEFORE THE TIMING CHAINS START CAUSING LIFE THREATENING PROBLEMS. *TR

Mileage: 37,720

I ALMOST HAD A TIMING CHAIN/TENSIONER FAILURE. TOOK MY '07 MCS INTO THE MINI DEALER FOR ITS 4 YEAR SERVICE. THEY FOUND THAT THE 'TIMING CHAIN TENSIONER IS WEAK AND NEEDS TO BE REPLACED' OR 'TENSIONER WORN AND CAUSING EXCESSIVE CHAIN SLACK AND CHAIN NOISE'. I BOUGHT MY MINI NEW, IT NOW HAS 35464 MILES AND THIS SHOULD FALL INTO THE CATEGORY AS 'UNUSUAL'. THIS SHOULD NOT BE A PART THAT WEARS OUT OR SUFFERS FAILURE WITH SO FEW MILES. AS I CHECKED OUT THIS FAILURE ON THE WEB I QUICKLY FOUND OUT THAT THIS IS NOT UNUSUAL BUT IS HAPPENING QUITE FREQUENTLY. I MISSED THIS BEING COVERED UNDER THE WARRANTY BY 2 WEEKS. MY LOSE? MAYBE; MAYBE NOT, AT LEAST I DID NOT DESTROY THE ENGINE. ACCORDING TO THE SERVICE DEPARTMENT PAPERWORK THEY REPLACED THE CHAIN TENSIONER WITH AN UPDATED 551 TENSIONER, P/N: 11 31 7 607 551, @ $26.21 ($146 FOR INSTALLATION). IT APPEARS THAT MINI/BMW KNOWS ABOUT THE PROBLEM AND REDESIGNED THE PART TO PREVENT PROBLEMS IN THE FUTURE, HOPEFULLY. IF THIS IS TRUE WHY DON'T THEY RECALL THE CARS AND JUST TAKE CARE OF IT. HAD I HAD THE BAD LUCK OF DESTROYING THE ENGINE MY OPINION ON ALL THEIR PRODUCTS WOULD HAVE DRASTICALLY CHANGED. I ALSO OWN A '11 BMW 335XI. *TR

Mileage: 35,464

2007 MINI COOPER HAD LOUD SOUND COMING FROM ENGINE COMPARTMENT, SOUNDED LIKE A DIESEL ENGINE WHEN COLD, DEALER REPLACED TIMING CHAIN TENSIONER AT 32K MILES, VEHICLE HAS BEEN BACK TO DEALER SEVEN TIMES, ONLY TWICE FOR SCHEDULED SERVICE, NOW VEHICLE IS STARTING TO MAKE SAME NOISE AGAIN. VEHICLE WAS SERVICED @36K MILES, NOW WITH 42K MILES, ENGINE OIL IS DOWN 2 QUARTS AND DEALER SAYS ITS MY FAULT. *TR

Mileage: 32,000

TL*THE CONTACT OWNS A 2007 MINI COOPER S. WHILE DRIVING 30 MPH, THE CLUTCH BEGAN TO SLIP. THE CONTACT STATED THAT THERE WAS NO POWER MOVING TO THE REAR WHEELS. BECAUSE OF THE FAILURE, THE VEHICLE WOULD NOT ACCELERATE PAST 10 MPH. THE VEHICLE STALLED AND WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CLUTCH WAS REPLACED. THE VIN WAS UNAVAILABLE. THE FAILURE MILEAGE WAS APPROXIMATELY 33,000 AND THE CURRENT MILEAGE WAS APPROXIMATELY 35,000.

Mileage: 33,000

TL*THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THE CLUTCH WOULD NOT ENGAGE OR SHIFT INTO FIRST, SECOND OR ANY OTHER GEAR. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THE CLUTCH WAS REPLACED. THE FAILURE RECURRED WITHIN TWO WEEKS AND THE VEHICLE WAS TAKEN BACK TO THE DEALER. THE VEHICLE WAS NOT REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THEY COULD NOT OFFER ASSISTANCE SINCE THE VEHICLE WAS NO LONGER UNDER WARRANTY. THE CURRENT MILEAGE WAS APPROXIMATELY 40,000. THE FAILURE MILEAGE WAS APPROXIMATELY 25,000.

Mileage: 25,000

I BOUGHT 2007 MINI COOPER S PRE-OWNED CAR ON 8/24/09 WHICH HAS 3,627 MILES ON IT AT $24,000. ON 10/25/09, IS ONLY 3 MONTHS LATER, I WAS DRIVING A CAR AND NOTICED SMELLING SOMETHING BURNING. THE CAR WON'T GO IN GEAR AND MOVE. ON THAT NIGHT, THE CAR STOPPED IN THE MIDDLE OF THE LOAD. EVEN IF I PUSH A GAS, IT JUST DOES MAKE NOISY SOUND AND SMELL REALLY BAD, AND IT NEVER MOVE. NEXT DAY IT WAS TOWED TO THE ORLANDO MINI DEALER. THE DEALER SAYS THAT THE CLUTCH WAS BURNED OUT AND THIS REPAIR (PER THE DEALERS ESTIMATE IS $3,000)IS NOT COVERED BY THE WARRANTY BECAUSE IT WAS DRIVEN BY AN INEXPERIENCED PERSON OR NEGLECTED. I AM AN EXPERIENCED MANUAL CAR DRIVER AND WHAT THE DEALER TOLD ME IS NOT TRUE. IT IS ONLY 4,000 MILES AND IT SHOULD NEVER HAPPEN IF WE DRIVE IN A NORMAL WAY. THE DEALER DID NOT LISTEN TO ME AND I ENDED UP GOING A RELIABLE LOCAL MECHANIC AND PAYING $2,200 TO FIX IT WITHOUT WARRANTY. THE GUY AT THE MECHANIC SAYS MINI CLUTCH IS A VERY COMMON PROBLEM AND HE HAS FIXED SEVERAL TIMES BEFORE. I ALSO WENT TO A WEBSITE AND REALIZED THAT MANY PEOPLE HAVE THE SAME PROBLEM AND EVEN SAY IT MIGHT HAPPEN AGAIN SOON. I BELIEVE IT WAS A DEFECTED CLUTCH AND WOULD LIKE TO COMPLAIN ABOUT IT. I HAVE ALL EVIDENCES AVAILABLE. I WOULD APPRECIATE IF YOU COULD HELP ME TO RECOVER MY MONETARY DAMAGES. *TR

Mileage: 4,000

2007 MINI COOPER S - MANUAL TRANSMISSION WOULD NOT ALLOW GEARSHIFTS AND COULD ONLY BE DRIVEN IN FIRST GEAR. DEALERSHIP STATED CLUTCH CAME APART AFTER 8 MONTHS OF OWNERSHIP. DEALERSHIP REPLACED WITH REMANUFACTURED CLUTCH, FLYWHEEL, GEARBOX OIL AND CLIP UNDER WARRANTY. IN JULY OF 2009 I NOTICED THAT THE TRANSMISSION WAS SHIFTING ROUGH AND THE CLUTCH WAS MAKING A SQUEAKING SOUND WHEN APPLIED. DEALERSHIP GOT A WORK ORDER FROM MINI USA TO REMOVE THE CLUTCH/TRANSMISSION. ON AUGUST 12, 2009 THE DEALERSHIP REMOVED THE CLUTCH/TRANSMISSION AND REPLACED THE PLASTIC PART CAUSING THE NOISE, BUT NOTICED THE FLYWHEEL HAD HEAT DAMAGE AND CRACKING AGAIN. THIS TIME THE DEALERSHIP AND MINI USA STATE THAT THIS WAS CAUSED BY "WEAR AND TEAR" AND NOT COVERED UNDER THE MANUFACTURES WARRANTY DESPITE BEING COVERED 15K MILES EARLIER. CURRENT MILES ON VEHICLE ARE 31K WITH 19K REMAINING ON MANUFACTURERS WARRANTY. *TR

Mileage: 31,000

I PURCHASED A 2007 MINI-COOPER S AND AT 10K MILES (1 YEAR OLD) THE CLUTCH NEEDED TO BE REPLACED. I DON'T UNDERSTAND HOW A NEW CAR WITH 10K MILES NEEDS A NEW CLUTCH. THE DEALERSHIP AND THE MANUFACTURER BOTH SAID IT WAS MY FAULT AND THERE WAS NOTHING WRONG WITH THE CAR. THEY QUOTED ME OVER $3K TO REPAIR. I HAVE BEEN DRIVING MANUAL CARS FOR 15 YEARS AND HAVE NEVER HAD A PROBLEM WITH A CLUTCH. *TR

CAR CLUNKS WHILE GOING OVER ROUGH ROADS. AS PER DIAGNOSIS FROM MINI DEALERSHIP, THE "TRANSMISSION MOTOR MOUNT IS TOO SMALL AND DOES NOT DAMPEN SHOCK FROM ROAD BUMPS OR ACCELERATION TORQUE" AND WAS REPLACED. *TR

Mileage: 8,000

2007 MINI COOPER, PURCHASED NEW, APPROX 21,000 MILES. PARKED CAR WOULD NOT GO INTO REVERSE. MANY WEB FORUMS INDICATE ONGOING PROBLEMS WITH MINI TRANSMISSIONS. *TR

Mileage: 21,000

TL*THE CONTACT OWNS A 2007 MINI COOPER S. THE CONTACT STATED THAT THE CLUTCH ALWAYS EMITTED AN ODOR OF BURNING PLASTIC. THE ENGINE GRADUALLY REVVED WITHIN A 48 HOUR PERIOD. WHILE DRIVING 30 MPH, THE CLUTCH FAILED. THE DEALER STATED THAT A NEW CLUTCH NEEDED TO BE INSTALLED AT THE ESTIMATED COST OF $3,300. THE VIN WAS UNKNOWN. THE FAILURE AND CURRENT MILEAGES WERE 5,000.

Mileage: 5,000