2008 MINI COOPER S Engine Problems

TIMING CHAIN JUMPED OUT OF TIMING AND CAUSED BENT VALVES.

Mileage: 70,000

MY CAR CAUGHT FIRE WHILE DRIVING. I HAD BEEN DRIVING FOR ABOUT AN HOUR ON THE HIGHWAY. THERE WAS NO WARNING. NO CEL OR ERRORS ON THE DASH DISPLAY. CAR WAS RUNNING NORMALLY. I NOTICED SOME SMOKE. AFTER PULLING TO THE SIDE OF THE ROAD FLAMES STARTED COMING FROM UNDER THE HOOD. THE CAR WAS STILL RUNNING NORMALLY. I SHUT OFF THE MOTOR AND GOT OUT. BYSTANDERS EMPTIED AN EXTINGUISHER THROUGH THE FRONT GRILLE BUT WITHIN MINUTES THE ENTIRE VEHICLE WAS ENGULFED. CAR WAS ALMOST COMPLETELY DESTROYED. FIRE BURNED THROUGH THE FIREWALL AND CONSUMED THE INTERIOR.

Mileage: 144,000

AT 32000 MILES AN OIL LEAK WAS NOTED ON THE GARAGE FLOOR. THE FOREIGN CAR REPAIR SHOP TROUBLESHOT THE LEAK. FINAL OUTCOME: REPLACE SUPERCHARGER ASSEMBLY, VACUUM BRAKE BOOSTER PUMP AND INTAKE MANIFOLD GASKET. TOTAL COST $3,014.78 FOR A VEHICLE THAT HAS A TRADE-IN VALUE OF LESS THAN $5,000. THE FOREIGN CAR EXPERT WAS AMAZED THAT THE TURBO HAD TO BE REPLACED WITH SUCH LOW MILEAGE.

Mileage: 32,094

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING 60 MPH, THE TIMING CHAIN FRACTURED, CAUSING A COMPLETE ENGINE FAILURE. ALL THE VALVES AND CYLINDER HEADS WERE BENT. THE CONTACT WAS ABLE TO COAST THE VEHICLE OVER TO THE SHOULDER EVEN AFTER THE VEHICLE LOST ALL POWER. THE VEHICLE WAS TOWED TO THE DEALER (MIDWESTERN AUTO GROUP, 6335 PERIMETER LOOP RD, DUBLIN, OH 43017, (614) 889-2571 WHERE IT WAS DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED AT A COST OF OVER $8,000. THE CONTACT NOTIFIED THE MANUFACTURER AND WAS PROVIDED A CLAIM NUMBER. THE MANUFACTURER DID NOT ASSIST WITH THE WARRANTY OR RECALL,S BUT OFFERED TO PAY $2,000 TOWARDS THE REPAIR COST. THE OFFER WAS GOOD FOR SIX MONTHS. THE FAILURE MILEAGE WAS 70,674.

Mileage: 70,674

WHILE DRIVING AT HIGHWAY SPEED ON I-71 N & N. BROADWAY EXIT IN COLUMBUS, OHIO ON MARCH 1, 2019 THE TIMING CHAIN BROKE AND CAUSED COMPLETE ENGINE FAILURE AND BENT ALL VALVES AND CYLINDER HEAD AND VALVES RESULTING IN $8821.97 IN DAMAGE TO MY ENGINE. THE CAUSE OF THE TIMING CHAIN FAILURE IS DUE TO THE PRINCE/PSA ENGINE DESIGN AND MANUFACTURING DEFECT ADMITTED TO IN THE CLASS ACTION LAWSUIT KNOW AS JOSHUA SKEEN AND LAURIE FREEMAN V. BMW OF NORTH AMERICA, L.LC. UNITED STATES DISTRICT COURT DISTRICT OF NEW JERSEY CIV. NO. 2:13-CV-1531-WHW-CLW. BMW DECLINED TO REPLACE MY ENGINE UNDER THE EXTENDED WARRANTY AGREED TO IN THE SETTLEMENT AGREEMENT OF THE ABOVE CITED ACTION. ALL AFFECTED VEHICLES SHOULD HAVE BEEN RECALLED AND MY ENGINE FAILURE COULD HAVE EASILY CAUSED LOSS OF LIFE. MY VEHICLE IS ONE OF THE CLASS VEHICLES, R56 N14 ENGINE PRODUCED BETWEEN 2006 THRU 2010. THIS IS A PRODUCT LIABILITY SAFETY CLAIM THAT IS NOT SUBJECT TO ANY STATUTORY/WARRANTY TIME LIMITATION. ALL CLASS VEHICLES SHOULD BE RECALLED DUE TO THE LOSS OF LIFE AND SAFETY RISKS. DO NOT WAIT FOR LOSS OF LIFE TO ENFORCE THE LIABILITY OF BMW FOR THEIR FAILURE TO SELF REPORT THE DESIGN DEFECT AND FAILURE TO VOLUNTARILY RECALL ALL AFFECTED VEHICLES.

Mileage: 70,674

MY MINI COOPER HAS A TIMING CHAIN PROBLEM IT RATTLES UPON STARTING AND I HAVEN'T DRIVEN IT .....I JUST FOUND OUT ABOUT THIS RECALL

Mileage: 105,000

THE VEHICLE LOST POWER WHILE DRIVING ON THE HIGHWAY AND A MINI DEALERSHIP HAS CONFIRMED THAT THE TIMING CHAIN IS THE PROBLEM ALONG WITH THE VALVES (POSSIBLY CAUSED BY THE TIMING BEING OFF). MULTIPLE CONVERSATIONS WITH MINI CUSTOMER RELATIONS HAVE GOTTEN NO WHERE AND THE MANUFACTURER REFUSES TO TAKE RESPONSIBILITY FOR THE KNOWN ISSUES WITH THE TIMING CHAIN IN THIS VEHICLE. DESPITE A CLASS ACTION LAWSUIT SPECIFICALLY ABOUT THE TIMING CHAIN, NO RECALL HAS BEEN ISSUED AND THE MANUFACTURER REFUSES TO ASSIST CUSTOMERS WITH NECESSARY REPAIRS TO THIS DEFECTIVE PART (AND OTHER DAMAGE CAUSED BY THE DEFECT). THESE TIMING CHAIN ISSUES ARE NOT ONLY AN UNDUE BURDEN ON THE CONSUMER, THEY CAN BE POTENTIALLY FATAL IF A TIMING CHAIN FAILS AT AN UNFORTUNATE MOMENT. MINI NEEDS TO ISSUE A RECALL.

Mileage: 136,000

WHILE TRAVELING ON I-10 IN TALLAHASSEE, FL AT HIGHWAY SPEED OF 70 MPH THE CAR SUDDENLY LOST POWER. BEING I THE CENTER LANE OF EIGHT (FOUR EACH DIRECTION) IT WAS ALMOST IMPOSSIBLE TO GET OUT OF TRAFFIC. SEVERAL VEHICLES MADE ABRUPT MANEUVERS TO AVOID A CRASH. ALSO AS I GOT OUT OF THE VEHICLE WAS NEARLY STRUCK BY OTHER CARS. I LATER FOUND OUT THIS WAS DUE TO A FAILED TIMING CHAIN WITH NUMEROUS COMPLAINTS AND NO RECALL. THERE WAS ALSO A CLASS ACTION SETTLEMENT AND STILL NO RECALL. THIS COULD HAVE WELL BEEN A FATAL INCIDENT.

Mileage: 120,000

CAR TAKES A WHILE TO "WARM UP" HOWEVER AFTER A VERY SHORT DRIVE THE HOOD IS HOT TO THE TOUCH. IT ALSO SMELLS HOT. I LOOKED ON LINE AND SEEN SEVERAL COMPLAINTS AND THERE IS ACTUALLY AN AFTER MARKET 'DEFLECTOR' TO CHANNEL HEAT FROM THE HOOD. I HAVE NOTICED THE PLASTIC HOOD SCOOP IS DEFORMED FROM HEAT. I FEEL IT IS A MATTER OF TIME BEFORE A FIRE OR OTHER REACTION, E.G., HEAT CAUSES ANOTHER PART TO FAIL AND CAR WONT STOP, ACCELERATE OR OTHER CAUSING A CRASH. I ALSO NOTICED THE HEADLIGHT WIRING TO BE FRAYED AS IF IT HAS BEEN HOT.

Mileage: 90,000

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V657000 (ENGINE AND ENGINE COOLING), BUT THE REPAIR WAS NOT COMPLETED BEFORE THE CONTACT OWNED THE VEHICLE. IN ADDITION, THE CONTACT EXPERIENCED A FAILURE CONCERNING NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS TAKEN TO A REPAIR SHOP WHO PROVIDED AN OIL CHANGE AND CLEARED A DTC. THE CONTACT LATER EXPERIENCED EXTREME SMOKE EMITTING ON THE OUTSIDE OF THE VEHICLE TO THE INSIDE OF THE VEHICLE. THE VEHICLE WAS COASTED OVER TO THE SIDE OF THE ROAD AND TOWED TO A REPAIR SHOP. THE MECHANIC DIAGNOSED THAT THE WATER PUMP LEAKED, THE ENGINE OVER HEATED, THE CYLINDER HEAD WAS WARPED, AND THE OIL FILTER HOUSING GASKET WAS LEAKY. THE MECHANIC DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE CONTACT WAS UNCERTAIN IF THE VEHICLE WOULD BE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 76,000.

Mileage: 76,000

THE TURBO OIL FEED LINE IS INHERENTLY FLAWED AND PREMATURELY FAILS BECAUSE OF A BAD DESIGN. THIS FAILURE CAUSES HOT OIL TO LEAK ALL OVER A HOT TURBO. I WAS LUCKY ENOUGH TO NOT HAVE MY ENGINE CATCH FIRE WITH THE FAILED O-RING ON MINE. I WAS DRIVING ON THE HIGHWAY WHEN LARGE CLOUDS OF SMOKE BEGIN TO FLOW FROM THE ENGINE COMPARTMENT. I WAS FORCED TO PULL OVER AND GET TOWED HOME. I WAS OUT OF WARRANTY BUT STILL VERY LOW MILEAGE (48K) WHEN MINE FAILED. *TR

Mileage: 48,000

PRISTINE CONDITION, LOW MILEAGE, DEALER SERVICED MINI COOPER S (OWNED SINCE NEW) BEGAN EXHIBITING A RATTLING NOISE FROM ENGINE AT 34K MILES. DEALER DIAGNOSED IT AS A TIMING CHAIN DEFECT AND TIMING CHAIN TENSIONER DEFECT. THIS IS A KNOWN ENGINE DEFECT. REFERENCE CLASS ACTION SUIT AND SETTLEMENT 338403. THIS SETTLEMENT BY BMW/MINI USA COVERS THIS FLAW AND BMW/MINI KNOWS THAT VEHICLES PRODUCED WITHIN THE 2007-2010 TIMEFRAME HAVE THIS FLAW. THIS FLAW CAN RESULT IN CATASTROPHIC ENGINE FAILURE. IN MY CASE, IT WAS NOISY UNDER ACCELERATION, AND WAS INTO THE DEALER FOR SERVICE WITHIN DAYS OF FIRST ISSUE. THIS IS A KNOWN FLAW. HOWEVER, BMW/MINI SETTLED THE CLASS ACTION LAWSUIT AND SET ASIDE MILLIONS OF DOLLARS FOR CLAIMS....BUT THOSE CLAIMS MUST BE FILED BY 7/1/16. I DID NOT HAVE THE ISSUE BEFORE THAT DATE, I HAD IT HAPPEN IN SEPTEMBER 2016 - TWO MONTHS LATER. I HAVE REQUESTED SOME ACCOMMODATION FROM BMW/MINI, HOWEVER THEY ARE REFUSING TO PARTICIPATE AT ANY LEVEL, EVEN THOUGH THEY KNOW THIS WAS A FLAWED PART AND COULD HAVE CAUSED SIGNIFICANT DAMAGE. I AM NOT EXPECTING FULL REIMBURSEMENT, BUT IF THEY KNOW THE CAR HAS A MAJOR FLAW, THEY SHOULD HAVE SOME COVERAGE IN PLACE FOR ANY OF THESE VEHICLES WITH THE FLAW. THUS FAR THE REGIONAL SERVICE MANAGER AND MINI USA HAVE INDICATED BECAUSE THIS HAPPENED AFTER 7/1/16 THEY WILL NOT ACCOMMODATE.

Mileage: 34,400

FUEL SMELL STARTED TO GET STRONGER IN THE CABIN AND OUTSIDE OF THE VEHICLE, BUT DID NOT SEE ANY LEAKS ON THE FLOOR TILL TODAY. I ALSO NOTICE THE GREEN TEMPERATURE NOTIFICATION COME ON TODAY. I HAD MY OIL CHANGED AT THE BMW/MINI DEALER IN ONTARIO LAST MONTH.

Mileage: 97,000

TIMING CHAIN AND TIMING CHAIN TENSIONER BROKEN AND DAMAGED THE ENGINE AT MILE 48544 - 48552

Mileage: 48,544

TL* THE CONTACT OWNED A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, AN ABNORMAL NOISE WAS HEARD AND THE CONTACT NOTICED THICK, GREY SMOKE COMING FROM THE FRONT OF THE VEHICLE. THE OIL WARNING LIGHT ILLUMINATED. THE CONTACT OPENED THE HOOD AND NOTICED FLAMES IN THE ENGINE COMPARTMENT. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT AND A FIRE REPORT WERE FILED. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS TOWED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 85,777.

Mileage: 85,777

I OWN A 2008 MINI COOPER S AND IT HAS 62000 MILES ON IT. AS MANY OTHER MINI OWNERS, I HAVE " RATTLE NOISE" ISSUE WHEN COLD START AND POPPED UP "ENGINE OIL PRESSURE TOO LOW" WARNING YESTERDAY WHEN DROVE HOME ON CITY STREET. THIS VEHICLE HAS HAD THE TIMING CHAIN TENSIONER/GUIDE CHANGED ONCE BEFORE AT 18,942 BY A MINI DEALER.

Mileage: 61,500

ENGINE RATTLE UPON STARTUP. NEXT THING I KNOW IS THE TIMING CHAIN GUIDES BROKE AND THE VALVES BENT. THOUSANDS IN REPAIR AND MINI WON'T COVER A THING.

Mileage: 109,000

AS MANY OTHERS HAVE POSTED HERE, MY ENGINE BEGAN RATTLING LOUDLY WHEN I WOULD START IT UP. TO ALLEVIATE THIS, I WOULD TOP OFF THE OIL AND GET FREQUENT OIL CHANGES, IN FACT, MORE OFTEN THAN MINI/BMW SUGGESTED IT SHOULD GET AN OIL CHANGE. THIS WOULD USUALLY TAKE CARE OF THE RATTLE. ONE NIGHT, THE ENGINE RATTLE KEPT INCREASING AND SUDDENLY THE CAR STOPPED IN THE MIDDLE OF A BUSY STREET JUST 20 FEET FROM RAILROAD TRACKS WITHOUT ANY WARNING LIGHTS OR INDICATIONS WHATSOEVER. I HAD IT TOWED TO A NEARBY MECHANICS SHOP I TRUST (NOT THE DEALERSHIP). THE TIMING CHAIN HAD BROKEN AND BENT THE VALVES AND I'M IN THE PROCESS OF HAVING A NEW ENGINE PUT IN (WITH THE SAME FAULTY TIMING CHAIN) TO THE TUNE OF $6,500. I CALLED MINI/BMW USA BECAUSE MY MECHANIC SAID HE'S SEEN THIS PROBLEM FREQUENTLY IN MY MODEL. MINI SAID THEY WOULD NOT DO ANYTHING FOR ME UNLESS THE CAR WAS DIAGNOSED BY THE MINI DEALERSHIP, AND EVEN THEN THERE WOULD BE NO GUARANTEE THEY WOULD COVER ANYTHING BECAUSE OF "MY VEHICLE'S AGE." MINI/BMW USA WOULDN'T EVEN ACKNOWLEDGE THAT THERE HAVE BEEN FREQUENT REPORTS OF TIMING TENSIONER/CHAINS HAVING PROBLEMS. I'M EVEN MORE SURPRISED HOW FREQUENT THIS PROBLEM IS NOW THAT I'M LOOKING ON THE NHTSA WEBSITE. THIS NEEDS TO BE A RECALL AND SOMETHING THAT MINI/BMW SHOULD COVER AND RESPOND TO, SINCE THERE HAVE BEEN SEVERAL CLASS ACTION LAWSUITS AGAINST THE COMPANY BECAUSE OF THIS.

Mileage: 90,000

AFTER MINI/BMW REPAIRED THE TIMING CHAIN TENSIONER AND THE TIMING CHAIN, MY TURBO OIL SUPPLY LINE DEVELOPED A SIGNIFICANT LEAK (WITHIN A WEEK/ WITHIN 200 MILES OF MINI SERVICE) CAUSING SMOKE TO ESCAPE FROM THE BONNET, OIL TO COVER THE FRONT ENGINE/TURBO/EXHAUST. OIL NOW PUDDLES BENEATH THE CAR WHEN PARKED. THE CAR HAS 89,XXX MILES. I FIRST NOTICED THE SMELL OF BURNING OIL WHEN DRIVING ACROSS TOWN AT A SPEED OF 40MPH. WHEN PARKING THE VEHICLE, UPON IDLE THE SMOKE BILLOWED FROM THE BONNET OF THE CAR. ACCORDING TO MINI FORUMS, THIS PROBLEM OF A FAILED O-RING IN THE TURBO OIL SUPPLY LINE IS A KNOWN PROBLEM RESULTING IN NUMEROUS FAILURES THAT CAN LEAD TO CATASTROHIC DAMAGE TO THE TURBO, CATALYTIC CONVERTER, AND ENGINE.

Mileage: 89,633

WHEN STARTING CAR, I GET A GRINDING, RATTLING NOISE FROM THE ENGINE. I HAVE BEEN TOLD THIS IS THE CHAIN TENSIONER ON THE CAR

Mileage: 45,000

PURCHASED AT 61,000 MILES 9/9/14; HAD SYNTHETIC OIL CHANGE 5/15; 9/29/15 CAR BEGAN TO HAVE A RATTLE BUT UNSURE IF IT WAS FRONT OF CAR OR BACK OF CAR. RATTLING STOPPED ON ACCELERATION. NO WARNING LIGHTS CAME ON. 10/4/15 CAR DIED AT 69,362 MILES WHILE DRIVING ON A TWO LANE ROAD ON A CURVE. WAS ABLE TO COAST TO GETTING HALF THE CAR OFF THE ROAD. BYPASSERS PUSHED ME OFF THE REST OF THE WAY. TOWED TO MECHANIC WHO SAID IT WAS THE TIMING CHAIN GUARD THAT SPLIT OFF. CALLED MINI THEY SAID THEIR DEALERSHIP SERVICE DEPT HAD TO LOOK AT IT. HAD IT TOWED TO OH 70 MILES AWAY. THEY TOLD ME I HAD AN OIL LEAK WHICH CAUSED THE FOLLOWING TO BE DAMAGED - CRANK SHAFT, HARMONIC BALANCER, CYLINDER HEAD, TIMING CHAIN AND GUARD AND MAYBE OTHER STUFF BUT THEY COULDN'T TELL WITHOUT FURTHER EXAMINATION. TOLD $5,000 PLUS TO FIX, BUT I SEE MINI ESTIMATE STATES $3,500-4,500. MY LOCAL MECHANIC FOUND NO EVIDENCE OF AN OIL LEAK CAUSING THE TROUBLE, NOR DID I HAVE AN OIL SPOT WHERE I PARKED MY CAR IN THE GARAGE OR WORK PARKING LOT. NO OIL OR ENGINE LIGHT CAME ON.

Mileage: 69,362

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT STATED THAT WHILE PARKED, THERE WAS AN ABNORMAL BURNING OIL ODOR FROM THE VEHICLE. THE FAILURE RECURRED CONSTANTLY. THE CONTACT PARKED THE VEHICLE AND NOTICED OIL LEAKING ONTO THE GROUND. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 59,000.

Mileage: 59,000

TL* THE CONTACT OWNS A 2008 MINI COOPER S. WHILE DRIVING APPROXIMATELY 70 MPH, THE VEHICLE BEGAN TO DECELERATE AFTER THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD. THE VEHICLE WAS POWERED OFF AND BACK ON AND WAS ABLE TO BE DRIVEN; HOWEVER, THE VEHICLE WOULD NOT ACCELERATE PAST 55 MPH ON A 70 MPH HIGHWAY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT ONE OF THE CYLINDERS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 62,000.

Mileage: 62,000

THE TURBO OIL FEED LINE IS A KNOWN FAILURE POINT ON THE ENGINES PUT IN THIS GENERATION OF MINI COOPER S MODELS. THE OIL LINE USES A "O" RING GASKET BEHIND A PINCH/CRIMP CONNECTION. THIS CONNECTION IS DIRECTLY IN CONTACT WITH THE HOT SIDE OF THE TURBO AND FAILS DUE TO EXCESSIVE HEAT. THIS ALLOWS ENGINE OIL TO LEAK OUT OVER THE TURBO AND DOWN THE FRONT OF THE ENGINE. THIS COULD CAUSE THE ENGINE TO RUN LOW ON OIL AT BEST. AT THE WORST IT COULD CAUSE A FIRE IF THE TURBO GETS HOT ENOUGH TO IGNITE THE OIL THAT IS LEAKING OUT. *TR

Mileage: 99,610

TURBOCHARGER OIL FEED LINE LEAKING. THE PART IS POORLY DESIGNED AND ACCORDING TO THE RESEARCH I'VE DONE PRONE TO FAILURE. THE DEALER WANTS $1200 TO REPLACE IT. WHEN I QUESTIONED THE SERVICE PERSON ABOUT THE HEAT SHIELD RECALL FROM JUST LAST YEAR TO PREVENT THIS ISSUE FROM OCCURRING, HE REASSURED ME THAT THE HEAT SHIELD RECALL WAS BECAUSE OF THE NUMBER OF PAINT JOBS THEY HAD TO DO ON HOODS FROM THE HEAT OFF THE TURBO DAMAGING THE HOOD PAINT. I THINK MINI SHOULD COVER THE COST OF REPLACING THE OIL SUPPLY LINE SINCE THEY ARE WELL AWARE THAT THIS PART IS FAULTY, IT GETS TOO HOT AND LEAKS. THE HEAT SHIELD RECALL DOESN'T STOP THE DAMAGE ALREADY DONE. IT SEEMS MY 2008 MINI IS NOT IMMUNE TO ANY OF THE "KNOWN" ISSUES THIS CAR HAS. EVERYTIME I VISIT THE MINI DEALERSHIP IT'S ANOTHER WELL KNOWN ISSUE/REPAIR. WHILE THE DEALERSHIP WAS VERY HELPFUL WITH THE LAST ISSUE (TIMING CHAIN), THEY WERE NOT WITH THIS LATEST ONE. THEY SAID BECAUSE IT WAS OUT OF WARRANTY THERE WAS NOTHING THEY COULD DO. *TR

Mileage: 66,000

WHEN THE CAR ACCELERATING ON THE FIRST AND SECOND GEAR, THERE WAS A SMALL JERKING MOTION. TOOK IT TO THE SHOP AND THEY DIDN'T FIND ANY PROBLEM WITH THE CAR. ONE THE DAY OF THE INCIDENT DATE, 01/08, WHEN I STARTED THE CAR, THE CAR HAVE A LOUD ENGINE SOUND, SOUNDS LIKE THE CAR IS CHOCKING FOR AIR. THE ENGINE LIGHT IS ON WITH THE RPM POINTER RUNNING UP AND DOWN (GAS PADDLE IS UNTOUCHED). TOOK IT TO THE DEALER AND THE NEXT DAY AND THEY FOUND THERE IS OIL LEAKING FROM THE OIL FEED LINE TO THE TURBO. $1200 TO REPLACE THE PART. DID SOME RESEARCH ONLINE AND FOUND MANY MINI OWNER HAD THE SAME PROBLEM. *TR

Mileage: 64,000

I OWN A 2008 MINI COOPER S AND IT HAS 38600 MILES ON IT I HAVE OWNED IT FOR A YEAR AND HAVE TO REPLACE THE TIMING CHAIN. THIS VEHICLE HAS HAD THE TIMING CHAIN CHANGED ONCE BEFORE AT 13,485 BY A MINI DEALER. AS FOR THIS TIME IT IS STILL DRIVABLE AND HAS NOT CAUSED ANY INCIDENTS. *TR

THE DEALER INFORMED ME MY OIL FEED LINES TO THE TURBO WERE LEAKING AND WOULD NEED TO BE REPLACED SOON. AFTER DOING SOME RESEARCH FOUND THE COUPLINGS THAT ATTACHES THESE LINES TO THE TURBO ARE DEFECTIVE. THE DEALER SAYS THERE IS NOT A RECALL AND WILL COST APPROX: $1200.00. THE DEALER INSTALLED A TURBO SHIELD TO HELP WITH THE HEAT THAT IS CAUSING THE LINE TO PREMATURELY FAIL. WITH SO MANY AFFECTED SHOULDN'T MINI BE FIXING THIS ISSUE. *TR

Mileage: 44,740

I WAS DRIVING ON FREEWAY AND CAR JUST STALLED. I MADE IT TO SIDE OF FREEWAY. IT WAS A VERY DANGEROUS SITUATION BEING ON FREEWAY IN SMALL CAR THAT STALLED. LUCKILY, I WAS DRIVING IN THE FAR RIGHT LANE SO I WAS ABLE TO MAKE IT TO THE SHOULDER. REPAIR SHOP ADVISED THAT TIMING CHAIN BROKE. THERE WAS ADDITIONAL SERIOUS COLLATERAL ENGINE DAMAGE DUE TO TIMING CHAIN BREAKING. CAR IS PERFECTLY MAINTAINED AND REGULARLY SERVICED. *TR

Mileage: 63,000

THE FOLLOWING REPORTS ARE FROM: ORLANDO MINI 350 S. LAKE DESTINY DRIVE ORLANDO, FL 32810 (407) 835-2727 INCIDENT 1 @ 47,603 MILES: SERVICE ADVISOR [XXX]. [XXX] FOUND TIMING CHAIN RATTLE "NOISE AT IDLE UP TO 2,100 RPM. NOISE IS A RATTLE UNDER VALVE COVER NEAR CYL 1. INTERROGATED FAULT MEMORY, NO FAULTS. FOUND NOISE TO BE RELATED TO VALVE-TRAIN. PERFORMED STEPS OUTLINED IN BULLETIN 110207. MEASURED TIMING CHAIN SLACK AT 71.5MM. NEEDS COMPLETED REPLACEMENT TIMING CHAIN CASSETTE." REPLACED TENSIONERS (PART # 11-31-7-598-956, PART # 11-31-7-534-833), AND MANY OTHER PARTS. INCIDENT 2 @ 96,125 MILES: 100% CLIENT GOODWILL PROVIDED. [XXX] FOUND THAT THE "TIMING CHAIN TENSIONER FAILED, FOUND VEHICLE TIMING CHAIN TENSIONER TO HAVE FAILED CAUSING VEHICLE TO BECOME OUT OF TIMING, REPLACED TIMING CHAIN AND TENSIONER AT THIS TIME, CLEARED FAULTS FROM SYSTEM AND TEST DROVE VEHICLE, ALL OK..." REPLACED TENSIONERS (PART # 11-31-7-609-483 [ALREADY UPDATED FROM THE ONE USED ABOVE], PART # 11-31-7-534-833), AND MANY OTHER PARTS. INCIDENT 3 @ 105,543 MILES: SERVICE ADVISOR [XXX]) FOUND "DEFECT CODE 00 11 08 03 00, CHECK TIMING CHAIN TENSIONER, FOUND IT WAS AN UPDATED MODEL, OK AFTER THAT REPAIR" SINCE IT WAS UPDATED. NOTHING WAS REPLACED. NOISE GOT WORSE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

Mileage: 47,825

I WAS DRIVING IN A THREE LANE HIGHWAY WHEN THE ENGINE STOPPED SUDDENLY AND WOULD NOT RESTART. THE 2008 MINI COOPER S WAS TOWED TO A LOCAL MINI DEALER. I WAS INFORMED THAT THE TIMING CHAIN HAD BROKEN BECAUSE THE TIMING CHAIN TENSIONER HAD COLLAPSED. MINI USA INFORMED ME THAT THERE WAS A RECALL FOR THE TENSIONER WHICH MY CAR QUALIFIED FOR AND IF THE DEALER COULD STATE THAT WAS THE CAUSE THE ENGINE WOULD BE REPLACED FREE OF CHARGE. THE DEALER REFUSED TO MAKE THE CONNECTION AND REFUSES TO TELL ME AFTER A TEAR-DOWN WHAT CAUSED THE FAILURE. MINI IS TAKING NO RESPONSIBILITY AND I'M LEFT WITH A $12000 REPAIR BILL, BEYOND WHAT THE CAR IS WORTH. IT IS WELL DOCUMENTED THAT THE FAILURE OF THE TENSIONER CAUSES ENGINE FAILURE. *TR

Mileage: 92,000

AS I WAS DRIVING THE CAR, THE HOOD IN THE FRONT STARTED TO RELEASE SMOKE. THERE WAS ALSO A SMOKING SMELL. THIS CONTINUED THROUGHOUT THE RIDE. BROUGHT THE CAR TO A MECHANIC WHO INDICATES THAT THE CAR IS LEAKING OIL ONTO THE ENGINE, MAKING IT EXTREMELY DANGEROUS TO DRIVE AS IT CAN CAUSE A FIRE. THIS PROBLEM CONTINUES TO EXIST AFTER I REPLACE THE OIL PIPE. *TT

Mileage: 32,000

I HAVE NOW EXPERIENCED MY SECOND TIMING CHAIN TENSIONER FAILURE WITHIN A THREE YEAR PERIOD. COUNTLESS REPORTS ARE SURFACING AROUND THE GLOBE OF THE FAULTY DESIGN, AND THE MANUFACTURER (BMW) HAS ACKNOWLEDGED A DESIGN FLAW. THEY HAVE YET TO ISSUE A RECALL AS THE FEDERAL GOVT HAS NOT YET MANDATED THE REPAIR. THIS IS A VERY DANGEROUS SITUATION (AND EXPENSIVE ~ $2K) SHOULD THE SYSTEM FAIL. THE ONLY NOTICE IS A RATTLING SOUND IN THE ENGINE COMPARTMENT PRIOR TO FAILURE. BMW CLAIMS THE TENSIONER SHOULD BE GOOD FOR UPWARDS OF 120K MILES. MY VEHICLE HAS LESS THAN 50K AND THIS IS THE 2ND FAILURE I'VE EXPERIENCED IN THE LAST 3 YEARS. CONSIDERING THE NUMBER OF MINI COOPER VEHICLES ON THE ROAD, A NATIONWIDE RECALL IS THE ONLY MEASURE TO ENSURE THIS PROBLEM IS ADEQUATELY ADDRESSED. *TR

THE 2008 MINI COOPER S STARTED MAKING THE INFAMOUS "DEATH RATTLE" NOISE. I TOOK IT TO A MECHANIC WHO SPECIALIZES IN IMPORTS. HE CHANGED THE OIL, WHICH WASN'T DUE FOR ANOTHER 2,000 MILES, AND HE CHANGED THE OIL FILTER. THE NOISE CONTINUED SO HE ADDED OIL STABILIZER TO ENSURE THAT OIL WAS BEING FILTERED. THE NOISE STILL PERSISTS AT START-UP, AND GOES AWAY AFTER THE CAR WARMS UP FOR A COUPLE MINUTES. THE MECHANIC TOLD ME I'D HAVE TO GET THE TIME CHANGING BELT REPLACED TO FIX THE "DEATH RATTLE," WHICH IS A COMMON THING IN MINI CARS. *TR

Mileage: 66,500

FOUND LARGE OILY MARK UNDER PARKED CAR. TURNS OUT TO BE THE THERMOSTAT HOSE LEAKING DUE TO CRACKS BECAUSE OF BEING MADE OF PLASTIC. THIS IS A KNOWN DESIGN ISSUE BY MINI/BMW THAT COULD CAUSE AN ENGINE TO OVERHEAT PRODUCING A FILE OR BLOWING THE ENGINE. THIS SHOULD COME UNDER A RECALL. CHECKING ONLINE, YOU CAN SEE THAT IT WAS SUCH AN ISSUE LAST YEAR, THAT DEALERS WERE NOT EVEN ABLE TO GET PARTS FOR WEEKS DUE TO THE NUMBER OF FAILURES. CALLING THE DEALER, THEY READILY ADMIT IT IS A HUGE PROBLEM AND THEY HAVE TO REPLACE LOTS OF THEM. OF COURSE, IT IS $600 A POP FOR THE FIX. DUE TO THE LARGE COST AND ADMITTED DESIGN FLAW, THESE SHOULD ALL BE PLACED UNDER A RECALL BEFORE SOMEONE IS BADLY HURT. ALSO ANYONE THAT HAS HAD TO HAVE THIS FIXED SHOULD BE REIMBURSED FOR THAT EXPENSE. *TR

Mileage: 27,500

WHEN YOU START THE CAR IN THE MORNING WHILE ITS COLD AND START DRIVING, YOU HEAR A RATTLING NOISE IN THE ENGINE WHICH COMING OUT OF THE TIMING-BELT AREA. IT STARTED 5 DAYS AGO. *TR

Mileage: 36,800

MY MINI HAS A FAULTY OIL SUPPLY LINE GOING TO THE TURBO CHARGER. THE DEALERSHIP HAS KNOWN ABOUT THESE FAULTY LINES FOR SOMETIME. INSTEAD OF REPLACING THE LINE WITH A BETTER DESIGN THEY HAVE INSTALLED HEAT SHIELDS TO PREVENT THE HEAT FROM BURNING UP THE O-RING IN THE FITTING ON THE LINE. THEY INSTALLED ANOTHER HEAT SHIELD ON 2/21/14 OVER TOP OF THE OIL LINE TO PREVENT THE HEAT FROM BURNING UP THE O-RING THAT IS ALREADY BAD. NOW THEY INFORM ME THAT SINCE THE HEAT SHIELDS ARE IN PLACE I NEED TO PAY TO HAVE THE OIL LINE REPLACED WHICH COST $805.00. I THINK THAT MINI COOPER SHOULD HAVE RECALLED ALL THESE VEHICLES AND REPAIRED THE FAULTY OIL LINES SINCE THEY HAVE BEEN DOING THIS FROM 2007 MODELS TO 2011 MODELS. THIS IS A BAD SAFETY PROBLEM UNDER THE HOOD BECAUSE WHEN THE OIL GOES TO LEAKING ON THE TURBO CHARGER WHICH IS REALLY HOTTER THAT THE EXHAUST MANIFOLD IT CAUSES EXCESSIVE SMOKE FROM COMING OUT OF UNDER THE HOOD AND COULD CAUSE A LARGE FIRE FUELED BY MOTOR OIL PUMPING OUT ON TOP OF TURBO CHARGER. ALLOWING THE DEALERSHIPS TO PUT SHIELDS OVER TOP OF THE BAD OIL LINE NEEDS TO BE STOPPED. THEY NEED TO FIX THE PROBLEM THAT EXISTS FOR FREE AND NOT TRY TO COVER UP THE PROBLEM AS THEY DID ON MY CAR AND THEN TELL ME THAT THE OIL LINE NEEDS TO BE REPLACED. AFTER THE WARRANTY RUN OUT. THEY WERE WELL AWARE OF THE PROBLEM THEN AND NOW BECAUSE OF THEM PUTTING HEAT SHIELDS ON TO PREVENT THIS PROBLEM.THE OIL SUPPLY LINE SHOULD HAVE BEEN REPLACED AND THEN THE SHIELDS PUT ON. THANKS, HOPE TO SEE A RECALL VERY SOON. *TR

Mileage: 60,000

TURBO CHARGER FUEL SUPPLY LINE IS LEAKING ON MY 2008 MINI COOPER S. THE DEALER SUGGESTED A REPLACEMENT COST OF $750. THERE ARE MANY COMPLAINTS ONLINE ABOUT THIS ISSUE AND THE LEAK IS HAPPENING DUE TO POOR DESIGN. THE LEAK MAY CAUSE FIRE DAMAGE AND MIGHT CAUSE EXTENSIVE DAMAGE TO THE CAR. *TR

TURBOCHARGER OIL FEED LINE LEAKING. THE PART IS POORLY DESIGNED AND ACCORDING TO THE RESEARCH I'VE DONE PRONE TO FAILURE. THE PART IS NOT COVERED BY THE CPO WARRANTY AND THE DEALER WANTED $1400 TO REPLACE IT. I REPLACED IT MYSELF WITH A BETTER DESIGNED AFTERMARKET PART. I THINK MINI SHOULD COVER THE COST OF REPLACING THE PART WITH A BETTER DESIGN. *TR

Mileage: 68,000

LOUD ENGINE NOISE COMING FROM CHAIN TENSIONER AT STARTUP. SOUNDS LIKE DIESEL ENGINE. ALSO HAPPENS DURING COLD ENGINE START. *TR

Mileage: 48,700

TURBO OIL SUPPLY LINE IS LEAKING OIL ON MY 2008 COOPER S, THE DEALER HAS RECOMMEND REPLACEMENT AT A COST OF $900. I INITIALLY TOOK THE CAR IN FOR A RECALL TO INSTALL A HEAT SHIELD ON THE SAME OIL LINE, SOME ONLINE RESEARCH (INCLUDING MANY OFFICIAL COMPLAINTS HERE) HAS SUGGESTED THAT THE LACK OF A HEAT SHIELD HAS CAUSED THIS FAILURE, YET IT IS NOT COVERED UNDER THE RECALL. YET ANOTHER UNFORTUNATE DEFECT IN THE MINI DESIGN, I'VE ALREADY BEEN THROUGH THE TIMING CHAIN/TENSIONER DEBACLE. *TR

Mileage: 53,600

BOUGHT CAR FROM DEALERSHIP AFTER A LOT OF RESEARCH ON ISSUES WITH THESE CARS AN COMPLAINTS. BROUGHT VARRO MINI DEALERSHIP AND ASKED ABOUT TIMING CHAIN AND TENSIONER AND WAS TOLD MINE WAS FINE EVEN THOUGH THEY NEVER OPENED UP COVER TO INSPECT CHAIN OR TENSIONER. HAVE BEEN BACK THREE DIFFERENT TIMES WITH MULTIPLE ISSUES WITH TIMING CHAIN/TENSIONER HORRIBLE RATTLE. MINI SAYS THERE IS NO KNOWN DEFECTS WITH TIMING CHAIN/ TENSIONERS EVER BROUGHT UP. I THEN WAS TOLD BY MY BROTHER THAT HE I TAKING HIS MINI IN FOR A SERVICE ACTION ON THE TIMING CHAIN/TENSIONER, TURBO HEAT SHIELD, THERMOSTAT HOUSING. WE HAVE EXACT SAME CAR, SAME BUILD DATE, AND ROLLED OUT FROM SAME FACTORY BUT MINI STATES OURS ISN'T COVERED UNDER THE SERVICE ACTION EVEN THOUGH WE HAVE THE EXACT SAME CAR AND EVERYTHING. AND MY BROTHER IS ALSO OUT OF WARRANTY BUT THEIRS IS GETTING FIXED FREE. PLEASE HELP. I AM AWARE OF THE FREEMAN-SKEEN CLASS ACTION LAWSUIT AND HAVE FILE A COMPLAINT WITH BBB SO I GUESS I'LL HAVE TO FIND LEGAL HELP SINCE THEY DON'T PAY ATTENTION TO NHTSA COMPLAINTS. *TR

Mileage: 26,000

IT HAS OIL LEAKS AROUND TURBO LINE WHICH THE OILS MAKE SMOKES AS THE OIL DRIP CONTACTS WITH DOWN PIPE. THIS MAY RESULT IN SERIOUS DAMAGE TO THE CAR. *TR

Mileage: 67,000

WHILE DRIVING MY MINI THE CHECK ENGINE LIGHT CAME ON. I TOOK IT TO A LOCAL REPAIR SHOP THAT SPECIALIZES IN MINI'S. THE MANAGER TOLD ME THAT THE CRANKCASE VALVE NEEDS TO BE REPLACED AND IT IS BUILT INTO THE VALVE COVER. UPON INSPECTION THE MECHANIC ALSO DISCOVERED MY TIMING CHAIN IS ALMOST RUINED ALSO. I HAVE BEEN HEARING THE TIMING CHAIN RATTLE UPON START UP. *TR

Mileage: 29,976

TIMING CHAIN MAKING TERRIBLE RATTLE. AFTER RESEARCH THIS SEEMS TO BE A NEW AND QUITE COMMON PROBLEM. THIS NEEDS TO BE RECALLED. *TR

Mileage: 43,000

ENGINE RATTLE ON COLD START INDICATED A LOOSE OR STRETCHED TIMING CHAIN. REQUIRED A PREMATURE REPLACEMENT OF TIMING CHAIN, GUIDES AND TENSIONER

Mileage: 46,674

TIMING CHAIN MECHANISM (TENSIONER SEEMED TO BE MAIN CULPRIT) FAILING AND SYSTEM NEEDED REPLACEMENT. TOTAL COST $2500. CAR HAD 33,000 EASY MILES ON IT. MECHANIC SAID TIMING SYSTEM WAS ON THE VERGE OF FAILING TRAUMATICALLY AND DESTROYING THE ENGINE. REPORTED IT TO MINI, WHO ADMITTED THEY HAVE BEEN HAVING A LOT OF TROUBLE WITH THOSE BUT THERE HAD BEEN NO RECALL SO THEY COULDN'T HELP ME. REPLACEMENT PARTS WERE DIFFERENT SERIAL NUMBERS THAN THE ORIGINALS INDICATING, PER MY MECHANIC, THEY HAD REDESIGNED THE PARTS.

Mileage: 33,000

WHILE TURNING AT A HIGHWAY INTERSECTION, THE TIMING CHAIN FAILED WHICH, IN TURN, DESTROYED THE ENGINE. I WAS STRANDED IN THE MIDDLE OF THE INTERSECTION. I HAVE BEEN GIVEN A QUOTE OF 7,200.00 TO REPLACE THE ENGINE WITH A NEW ONE. *TR

Mileage: 44,000

I CHANGE MY OIL EVERY 3K ON THE DOT. I CHECK IT REGULARLY. FULLY SYNTHETIC EVERY TIME. I WAS TOLD WHEN I BOUGHT MY MINI WITH 42K THAT THE RATTLE UNDER THE HOOD WAS NORMAL. AT APPROX. 50K I HEARD THE SAME METAL RATTLE THAT SOUNDED LIKE A CHAIN SMACKING PLASTIC, SO I BROUGHT IT IN TO BE CHECKED. NOW I'M STUCK WITH A TIMING CHAIN REPLACEMENT THAT'S GOING TO COST UPWARDS OF $2,000. NOW I'M NOT ONE TO COMPLAIN OF NORMAL WEAR AND TEAR PARTS BUT WHO HAS A TIMING CHAIN GO OUT AT 50K? IF YOU GOOGLE TIMING CHAIN ISSUES YOU WILL SEE. THERE ARE TONS OF PEOPLE WHO ARE HAVING THE SAME ISSUE. LUCKILY MINE WAS CAUGHT IN MY DRIVEWAY. IF THIS CHAIN GOES OUT ON A HIGHWAY... THIS CAN EASILY CAUSE A FATAL ACCIDENT... PLEASE DON'T WAIT FOR AN ACCIDENT TO HAPPEN. GET THESE CHAINS REPLACED WITH ONES THAT HAVE BEEN QUALITY CONTROLLED. THIS IS A TRUE SAFETY HAZARD. *TR

Mileage: 50,000

MY MINI HAS HAD REGULAR SERVICE AT HABBERSTAD MINI SINCE I PURCHASED IT. I HAD COMPLAINED ABOUT ENGINE NOISE IN NOVEMBER 2011 AND THEY FOUND THE OIL WAS LOW AND REFILLED IT. AT EACH SERVICE I MENTIONED THE NOISE AND NOTHING WAS FOUND EXCEPT TO TELL ME I NEED INDUCTION SERVICE, REPLACE LEAKING WATER PUMP (EVEN AFTER THE RECALL FOR THIS PART WAS DONE ALREADY) AND COOLANT EXCHANGE FOR $1300. THE LOUD RATTLING ENGINE NOISE PERSISTED AND CAR BECAME ALMOST UNDRIVEABLE. IT TOOK THEM 3 DAYS TO FIND THAT THE TIMING CHAIN ETC. NEEDED TO BE REPLACED, WHICH AFTER SOME RESEARCH ONLINE I HAD ALREADY FOUND TO BE THE PROBLEM. OF COURSE MY WARRANTY WAS NOW UP SO I HAD TO PAY $3000. AND MY CAR ONLY HAS 38,000 MILES ON IT. THIS IS ABSOLUTELY UNACCEPTABLE!! I WAS TOLD BY THE DEALERSHIP THAT THEY HAVEN'T HEARD ANYTHING ABOUT THIS AND I SHOULD CALL MINI DIRECTLY AND LODGE A COMPLAINT, WHICH I DID. I WOULD LIKE TO HAVE THIS ISSUE INVESTIGATED, AS MINI MUST CERTAINLY HAVE HEARD FROM MORE CUSTOMERS BESIDES ME AND THEY ARE DOING NOTHING ABOUT IT. THE CUSTOMERS ARE GETTING STUCK PAYING FOR A DESIGN FLAW. PLEASE DO AN INVESTIGATION AND MAKE THEM ISSUE A RECALL TO REPAIR THIS DEFECT AND REFUND OUR REPAIR COSTS. MINI NEEDS TO STAND BEHIND THEIR MOTORER PLEDGE AND GIVE US THE QUALITY PRODUCT THEY ADVERTISE. *TR

Mileage: 38,432

HAD TO TAKE MY MINI COOPER S WITH JCW PACKAGE IN TO CORRECT A SERVICE LIGHT ISSUE. WAS CARBON BUILD UP ON THE VALVES. CLEANED IT FOR 1500.00. DROVE IT ABOUT A MONTH AND THE TURBO BYPASS SOLENOID VALVE FAILED. BACK TO THE MINI COOPER DEALER IN CLEAR LAKE. THEY REPLACED THE SOLENOID AND DID A OIL CHANGE FOR 550.00 GOT IT HOME AND NOTICED IT HAD A FAINT SMELL OF SOMETHING BURNING. THOUGHT IT COULD BE THEY GOT SOME OIL ON SOME PARTS THAT GET HOT. ONE WEEK AFTER THE TURBO SOLENOID WAS REPLACED I NOTICED A OIL SPOT ON MY GARAGE FLOOR. RAISED THE HOOD AND THE TURBO HAD A OIL FILM ON IT AND THE AIR INTAKE SUPPLY ON THE TURBO WAS LOOSE AND PRACTICALLY OFF THE TURBO. TOOK IT TO DEALER. THEY SAID LOOK LIKE OIL DRAIN BOLT LEAKING. REPLACED IT BUT THE ALSO CLEANED THE OIL OFF THE TURBO? NOT SURE WHY. I DIDN'T TELL THEM IT LOOKED LIKE IT WAS LEAKING. MAYBE THEY KNEW? DROVE IT HOME AND IT STILL SMELLED LIKE SOMETHING BURNING. LOOKED UNDER THE HOOD AND THE TURBO WAS COVERED WITH OIL. BACK TO THE DEALER. THEY CAN FIX IT FOR 1200.00 IT IS THE TURBO OIL FEED SUPPLY AND RETURN LINE. ALSO THE OIL DETERIORATED THE AIR INTAKE LINE AND CAUSED IT TO DEFORM SO THAT IT NO LONGER WILL STAY ON THE TURBO INTAKE. AFTER FURTHER INVESTIGATION LOOKS LIKE THE TURBO OIL FEED LINE IS A MAJOR ISSUE. MULTIPLE REPORTS OF THIS FAILURE. I ALSO SAW A SERVICE BULLETIN FOR THE HEAT SHIELD ON THE OIL FEED LINE. BUT THEY FAILED TO DO THE INSTALL ON MINE. EVEN THOUGH I HAVE HAD IT IN FOR SEVERAL SERVICES SINCE THE BULLETIN. THERE IS DEFINITELY A ISSUE WITH THE OIL FEED LINE TO THE TURBO. WON'T BE PURCHASING ANOTHER BMW PRODUCT. WILL NOT BE USING THIS DEALERS SERVICE IF I DECIDE TO KEEP THE MINI. *TR

Mileage: 52,522

WHILE DRIVING THE CAR (GAS) STARTED RUNNING ROUGH AND SOUNDED LIKE IT WAS A DIESEL. AFTER SOME RESEARCH I FOUND THAT THE TENSIONERS IN THE ENGINE ARE WORN OUT. I HAD THE UPPER REPLACED, BUT THE OTHERS ALSO NEED REPLACING. BASED ON MY OWN RESEARCH, IT APPEARS THE PROBLEM IS RELATED TO THE MANUFACTURER'S RECOMMENDED OIL CHANGE. THE COMPANY RECOMMENDS CHANGING OIL EVERY 15000 MILES WITH SYNTHETIC OIL. THE FIX IS SUPPOSEDLY TO CHANGE THE OIL AT HALF THAT, 7500. I'VE BEEN TOLD THIS COULD RESULT IN THE TIMING CHAIN COMING OFF AND THE ENGINE BEING TRASHED. *TR

Mileage: 54,008

WE STARTED HEARING A LOUD NOISE AROUND 27,000 MILES. CAR WAS JUST OVER FOUR YEARS OLD AND OUT OF WARRANTY. ENDED UP WITH A TIMING CHAIN ISSUE AND IT NEEDED TO BE REPLACED. REPEATED CALLS TO MINI DEALER AND MINI USA PROVIDED WORTHLESS, STUCK WITH WHOLE REPAIR AND NO ASSISTANCE. *TR

Mileage: 27,454

WE STARTED HEARING A LOUD NOISE AROUND 27,000 MILES. CAR WAS JUST OVER FOUR YEARS OLD AND OUT OF WARRANTY. ENDED UP WITH A TIMING CHAIN ISSUE AND IT NEEDED TO BE REPLACED. REPEATED CALLS TO MINI DEALER AND MINI USA PROVIDED WORTHLESS, STUCK WITH WHOLE REPAIR AND NO ASSISTANCE. *TR

Mileage: 27,454

MY MINI COOPER S WAS PURCHASED BRAND NEW, AND HAD ALL REGULAR MAINTENANCE DONE AT THE DEALERSHIP. HOWEVER, ONCE THE WARRANTY EXPIRED I TOOK THE CAR TO MY REGULAR MECHANIC WHO HAS PERFORMED WORK FOR MYSELF AND FAMILY FOR TWELVE YEARS. AFTER READING THIS WEBSITE, AND IT'S COMPLAINTS THE SAME PROBLEMS HAVE OCCURRED TO ME. THE OIL LINES BEGAN TO LEAK BECAUSE THERE WAS A CLOG, AND IT CAUSED THE TURBO TO BURN OUT. PARTS AND LABOR FOR A USED TURBO CAME OUT TO BE AROUND $1,800. A NEW TURBO ALONE WOULD HAVE COST ROUGHLY 2,000. NOW SEVERAL THOUSAND MILES LATER, THERE WAS AN OIL LEAK NOTICED UNDER THE CAR. I TOOK IT TO THE DEALERSHIP THIS TIME, TO SEE WHAT THE EXACT PROBLEM WAS AND AN ESTIMATE BEFORE TAKING IT TO MY MECHANIC. THEY FOUND "SEVERAL LEAKS" OF WHICH THEY REPLACED THE WATER PUMP, THE WATER PUMP GASKET, VALVE COVER GASKET, AND FINALLY THE OIL FILTER GASKET. AFTER THE $1,800 BILL FOR THAT WAS PAID, A CALL WAS RECEIVED DECLARING THAT THE CRANK CASE NOW HAS A LEAK IN IT AS WELL AND NEEDS TO BE RESEALED. WITH THE OIL LEAKING FROM THAT, THE CLUTCH COULD ALSO BE BURNING OUT AND NEED TO BE REPLACED COSTING AN ADDITIONAL $5,400. THE REPAIR BILL ON THIS ALONE WOULD BE ENOUGH TO BRING NORMAL HARD WORKING PEOPLE TO TEARS. ALSO, THE COLD START RATTLE IDENTIFYING THE TIMING BELT ISSUES HAS BEGUN ON MY CAR. THERE ARE THOUSANDS UPON THOUSANDS OF COMPLAINTS ABOUT THIS ON THE INTERNET. GLAD TO KNOW BMW TAKES CARE OF IT'S CUSTOMERS AND IGNORES THE COMPLAINTS. *TR

Mileage: 55,000

I HAD BEEN SERVICING MY 2008 MINI COOPER S AT THE DREYER & REINBOLD BMW MINI DEALERSHIP FOR THE LIFE OF THE CAR, WHICH I BOUGHT NEW. I JUST HAD IT IN THE SHOP AROUND 50K MILES AND WAS NOT TOLD THAT I SHOULD CONSIDER CHANGING MY TIMING BELT. ONE DAY I WENT TO START MY CAR AND IT WOULDN'T START. I TOWED IT TO THE DEALER AND THEY TOLD ME MY TIMING BELT HAD BROKEN AND DAMAGED MY ENGINE. I AM NO FACED WITH REPLACING MY ENGINE AND A BILL OF $6600+. THIS DEFECT THAT WAS NOT BROUGHT TO MY ATTENTION HAS RUINED MY ENGINE AND AFTER THOROUGH RESEARCH OF FELLOW MINI DRIVERS, I AM HESITANT ABOUT WHAT OTHER DEFECTS MAY COME ABOUT IN THE FUTURE FOR THIS CAR. THIS SHOULD BE BROUGHT TO THE ATTENTION OF THE MANUFACTURER AND THERE SHOULD BE A LAWSUIT OR RECALL IN PLACE TO COMPENSATE MINI OWNERS FOR THIS FAULTY PART. *TR

Mileage: 55,450

I CURRENTLY HAVE AN OIL LEAK DEVELOPING FROM THE TURBO OIL LINE THAT HAS RESULTED FROM A FAILED O-RING WITHIN THE LINE ITSELF. DUE TO A DESIGN FLAW, THE HEAT FROM THE TURBO WEARS AWAY THE O-RING, WHICH RESULTS IN OIL LEAKING FROM WHERE THE LINE IS BOLTED TO THE TURBO VIA A BANJO BOLT. THIS IS A SERIOUS PROBLEM BECAUSE IF THE LINE FAILS, THE TURBO BECOMES STARVED OF OIL AND BURNS UP, WHICH ULTIMATELY CAUSES THE WHOLE TURBO UNIT TO BE REPLACED. ALSO, THE OIL LEAKING ONTO THE TURBO HAS A POTENTIAL TO CATCH FIRE, SINCE THE TURBO BECOMES VERY HOT DURING NORMAL DRIVING. ALSO IF ANY OIL LEAKS DOWN TO THE EXHAUST PIPING UNDERNEATH THE TURBO, THOSE PLACES ALSO POSE A FIRE HAZARD. MINI RECOGNIZES THIS TO BE AN ISSUE, BUT REFUSES TO DO ANYTHING OTHER THAN ADD A HEAT SHIELD AROUND THE CONNECTION TO THE TURBO. THE LINE STILL HAS A RUBBER O-RING IN IT THAT WILL FAIL OVER REPEATED HEAT CYCLES, AND THE LINE NEEDS TO BE REDESIGNED. *TR

Mileage: 89,151

THE CAR HAS BEEN SMELLING LIKE BURNT OIL FOR ABOUT A WEEK. I TOOK IT IN TO THE SHOP ON SATURDAY. TODAY, TUESDAY, WHEN I WAS SUPPOSED TO PICK IT UP, I WAS TOLD THAT I NEED THE FOLLOWING REPAIRS BECAUSE THERE ARE "LEAKS": 1) WATER PUMP 2) TIMING CHAIN 3) VALVE COVER 4) OIL FEED AND RETURN LINE THE CAR HAS AROUND 36,500 MILES ON IT AND WE ARE LOOKING AT ABOUT 8,000.00 WORTH OF REPAIRS! WHAT??? I PAID ALMOST 30,000.00 FOR THIS CAR AND NOW HAVE TO SPEND ADDITIONAL MONEY TO KEEP IT RUNNING? THE EXTENDED WARRANTY THAT I PURCHASED WILL COVER THE FIRST THREE ITEMS ON THE LIST. THE OIL FEED AND RETURN LINE IS NOT CURRENTLY COVERED UNDER THE WARRANTY, EVEN THOUGH AFTER A BRIEF INTERNET SEARCH, I FIND THAT THIS IS A VERY COMMON PROBLEM WITH THESE CARS. I WOULD LIKE TO HAVE THIS ISSUE INVESTIGATED, AS MINI MUST CERTAINLY BE AWARE OF THIS PROBLEM AND IS DOING NOTHING ABOUT IT. THE CUSTOMERS ARE GETTING STUCK PAYING FOR A DESIGN FLAW AND THIS IS NOT ACCEPTABLE AT 36,000 MILES. THE COST OF THIS REPAIR FROM MY DEALER IS 1400.00!! PLEASE DO AN INVESTIGATION AND MAKE THEM REPAIR THIS DEFECT!! *TR

Mileage: 36,500

THERE IS A LEAK AT THE OIL SUPPLY LINE LEADING INTO TO THE TURBO HOUSING. THIS IS A MAJOR OIL LEAK AND SAFETY HAZARD. OIL LEAKING ONTO THE HOT TURBO CAN POTENTIALLY CAUSE A FIRE. ASIDE FROM THE POTENTIAL FIRE HAZARD, THE LEAK, HAD IT GONE UNNOTICED, COULD HAVE CAUSED AN ENGINE FAILURE. THE LOCAL MINI DEALERSHIP SAID THE REPLACEMENT WOULD COST AROUND $1,000 WITH OEM PARTS. *TR

Mileage: 73,000

A SIGNIFICANT ENGINE OIL LEAK WAS DETECTED BY OIL SPOTS UNDER PARKED CAR. THE DIP STICK REGISTERED 1 QUART LOW. A QUART WAS ADDED AND THE CAR DRIVEN ABOUT 100 MILES THE NEXT DAY. UPON RETURN, THE OIL WAS A QUART LOW AGAIN. DURING THE PRECEDING TWO WEEKS THERE HAD BEEN SEVERAL INSTANCES OF A BURNING OIL SMELL AND ON TWO OCCASIONS SMOKE COMING FROM UNDER THE HOOD. THIS WAS DURING A RAINY PERIOD AND THE SMOKE WAS INITIALLY THOUGHT TO BE STEAM FROM GETTING WATER IN THE ENGINE COMPARTMENT FROM PUDDLES ON THE ROADS. WHEN I TOOK THE CAR IN FOR SERVICE, THE DEALER FOUND THAT THE OIL LINE TO THE TURBO WAS LEAKING AS WELL AS THE OIL FILTER HOUSING SEAL. BOTH OF THESE COMPLAINTS HAVE BEEN NOTED IN THE DATABASE PREVIOUSLY. THE COST TO REPAIR WAS APPROXIMATELY $1000 USD. *TR

Mileage: 96,400

I HAVE OWNED THE MINI SINCE NEW. ALWAYS REGULARLY SERVICED AT THE MINI DEALER. RECENTLY I STARTED THE ENGINE AND IT SOUNDED MORE LIKE A DIESEL ENGINE, VERY NOISY AND UNUSUAL. TOOK IT TO THE MINI DEALER AND AS I EXPLAINED WHAT THE SYMPTOMS WERE, THE FRONT DESK PERSON THAT TOOK MY DETAILS DIAGNOSED THE PROBLEM. THE PRELIMINARY DIAGNOSIS WAS CONFIRMED LATER THROUGH AN INSPECTION BY A TRAINED TECHNICIAN. LIKE MANY, MANY MINI OWNERS I HAVE HAD A TIMING CHAIN PROBLEM. THAT THE FRONT DESK STAFF CAN DIAGNOSE A PROBLEM LIKE THIS MADE ME CURIOUS, IT MUST BE SUCH A COMMON PROBLEM THAT THE DEALER SEES IT REGULARLY. SOME RESEARCH CONFIRMED THIS WAS A WIDESPREAD PROBLEM WITH MINIS. OWNERS HAVE HAD TERMINAL ENGINE DAMAGE WITH ENGINES THAT ARE LOW MILEAGE AND SIMPLY SHOULD NOT HAVE ANY PROBLEMS. THIS ISSUE WITH THE ENGINE IS SERIOUS AND CAN LEAD TO A MAJOR ACCIDENT BECAUSE OF A CATASTROPHIC ENGINE FAILURE WHILE DRIVING AT HIGHWAYS SPEEDS. ALTHOUGH I WAS LUCKY, AND DO NOT HAVE A HUGE OUT OF POCKET EXPENSE AS I HAVE EXTENDED WARRANTY COVERAGE, I STILL BELIEVE THIS IS AN IMPORTANT SAFETY MATTER THAT BMW/MINI APPEAR TO BE IGNORING. IT SHOULD BE THE SUBJECT OF A VEHICLE SAFETY RECALL. IT IS POOR ENGINEERING AND DESIGN ON THEIR PART, THAT SHOULD BE RECTIFIED. *TR

Mileage: 49,200

WE PURCHASED THIS CAR IN LATE SEPT./EARLY OCT. 2012 WITH 29K MILES ON THE CAR. MY WIFE DRIVES THIS CAR, AND WHILE TRAVELING ON THE INTERSTATE, AS SHE WAS ENTERING THE OFF RAMP IN FOREST LAKE, MN HER CAR STARTED TO JERK/RUN LIKE CRAP (LATE JANUARY 2013). SHE WAS ABLE TO DRIVE THE CAR HOME, I TRIED TO FIGURE OUT THE ISSUE, BUT EVERYTHING I CHECKED TEST GOOD, SO I BROUGHT IT TO A LOCAL IMPORT TECH, AND HE DIAGNOSED THE FAILURE TO BE THE TIMING CHAIN TENSIONER, ALLOWING THE TIMING TO JUMP. HE SAYS HE STARTED UP THE MOTOR TO TEST FURTHER, IT IDLED FOR LESS THAN A MINUTE BEFORE THE MOTOR DIED AND NOW WILL NOT START. I NOW, AFTER OWNING THE CAR FOR 3-4 MONTHS, HAVE A MAJOR ENGINE FAILURE. I DO NOT CARE TO THINK WHAT WOULD HAVE HAPPENED IF THIS HAPPENED WHILE MY WIFE WAS TRAVELING DOWN THE INTERSTATE AT HIGH SPEEDS.... THANKX *TR

Mileage: 35,900

THE TIMING CHAIN HAS LOCKED UP. I NOTICE THAT THIS IS A COMMOM COMPLAINT. *TR

Mileage: 30,000

STRANGE KNOCKING/RUBBING NOISE COMING FROM THE ENGINE COMPARTMENT FOR THE YEAR 2007+ MINI COOPER. FROM THE MINI DEALER REPAIR DETAILS IT APPEARS TO BE A ISSUE WITH THE TIMING CHAIN AND TENSIONER SYSTEM. IT ALSO APPEARS THAT WITHOUT BEING FIXED THE CAR WILL EVENTUALLY HAVE A TIMING CHAIN FAILURE AND POSSIBLE MOTOR DESTRUCTION. THIS COULD OCCUR WHILE DRIVING AND I COULD LOSE CONTROL OF THE VEHICLE CAUSING A CRASH. MINI WILL NOT FIX THIS PROBLEM THAT THEY KNOW ABOUT WITHOUT THE VEHICLE STILL BEING UNDER WARRANTY. I CALL FOR A RECALL. *TR

Mileage: 33,000

THE OIL INPUT LINE TO THE TURBO HAS STARTED TO LEAK. THE CAR IS CURRENTLY SIDELINED BECAUSE OF CHANCE OF FIRE OR FAILURE OF THE TURBO. *TR

Mileage: 52,000

MY CAR HAD BEEN MAKING A RATTLING SOUND OFF AND ON FOR A SHORT TIME (MOSTLY IN THE COLD MORNINGS) I DROVE FROM HOUSTON TO DALLAS. WHEN PARKED ON THE SIDE ROAD, MY CAR WOULD NOT START UP. I HAD NO SERVICE LIGHT OR ANY OTHER LIGHTS COME ON. TOOK IT TO THE DEALERSHIP AND I WAS TOLD MY TIMING BELT WAS BROKEN. I HAVE NO MEANS TO PAY FOR THE REPAIR. WHILE SEARCHING THE INTERNET IT APPEARS THIS IS A VERY COMMON PROBLEM AND MINI COOPER/BMW ARE AWARE OF THIS AND HAVE DONE NOTHING ABOUT IT. *TR

Mileage: 40,000

THE CAR STARTED LEAKING SMALL AMOUNTS OF OIL IN THE GARAGE, APPROXIMATELY THE SIZE OF A DIME. WHEN THE CAR WAS PARKED YOU COULD SMELL A SLIGHT OIL BURNING ODOR. THE CAR SAT FOR 3 DAYS, WAS DRIVEN AND SMOKE BEGAN COMING OUT FROM UNDER THE HOOD. THERE WAS NO FIRE. THE RESULT IS THAT THE "TURBO OIL FEED LINE" AND "CRANKCASE TO VALVE COVER HOSE" WERE REPLACED BECAUSE BOTH WERE LEAKING OIL. AT 50700 MI, WE HAD TO REPLACE THE VALVE COVER AND CCV ASSEMBLY. THIS CAR WAS REPAIRED UNDER THE RECALL PE11036 FOR A COOLING FAN ISSUE. CONSIDERING THE LOW MILEAGE ON THIS VEHICLE, IT SEEMS TO ME THAT THERE HAVE BEEN TOO MANY ISSUES WITH IT RELATED TO THE TURBO CHARGER AND OIL SYSTEM. FROM READING OTHER ISSUES ONLINE IT APPEARS THAT THERE ARE DESIGN FLAWS WITH THE SHIELDING OF THESE COMPONENTS FROM HIGH HEAT SOURCES ON THE ENGINE. THESE REPAIRS ARE VERY EXPENSIVE AND ARE NOT RELATED TO POOR OR ABUSIVE DRIVING HABITS. *TR

Mileage: 54,667

THE OIL FEED LINE FOR THE TURBOCHARGER LEAKED ENOUGH OIL TO ALLOW ENOUGH SMOKE INTO THE CABIN TO GREATLY DECREASE VISIBILITY. THE FITTING IS COMPRISED OF A BANGO FITTING THAT IS CRIMPED TO THE FEED LINE WITH AN O-RING IN THE FEED LINE. THE O-RING IS THE COMPONENT THAT FAILED AND MY ENGINEERING BACK ROUND HAS LED ME TO THE ROOT CAUSE BEING THAT THE O-RING HAS SEEN ENOUGH THERMAL CYCLED TO DETERIORATE LEADING TO THE LEAK. THIS IS UNACCEPTABLE FROM A RELIABILITY STANDPOINT AND I KNOW THAT I AM NOT THE ONLY MINI OWNER THAT HAS HAD THIS HAPPEN TO THEM. MINI NEEDS TO OWN UP TO THIS DESIGN FLAW. *TR

Mileage: 80,000

THE TIMING CHAIN TENSIONER BACKED OUT OF THE ENGINE BLOCK ALLOWING ENGINE OIL TO BE PUMPED OUT OF THE ENGINE. THE TENSIONER WORKS ON ENGINE OIL PRESSURE AND IT BACKED OUT FAR ENOUGH TO ALLOW THE ENGINE OIL THAT NORMALLY PRESSURIZED THE PISTON TO BE PUMPED OUT OF THE ENGINE. I WAS LUCKY ENOUGH TO SEE THE STREAK OF OIL AS I BACKED OUT OF THE DRIVEWAY, BUT IF I HAD NOT I AM SURE THAT MORE DAMAGE AND POTENTIAL FIRE WOULD HAVE OCCURRED. THIS IS SURPRISING AS THIS SAME PART WAS REPLACED UNDER A RECALL FOR BEING FAULTY. I BELIEVE THAT THIS IS STILL A DESIGN FLAW AND SOMETHING THAT SHOULD BE ADDRESSED BY MINI. *TR

Mileage: 80,000

TL* THE CONTACT OWNS A 2008 MINI COOPER S. THE CONTACT STATED THAT SMOKE WAS SEEN COMING FROM THE ENGINE. THE VEHICLE WAS UNABLE TO COOL DOWN SO THE CONTACT HAD THE VEHICLE TOWED TO A DEALER FOR DIAGNOSIS BUT THEY WERE UNABLE TO DUPLICATE OR DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE FAILURE RECURRED AND HE WAS UNABLE TO DRIVE THE VEHICLE FOR MORE THAN A FEW MILES WITHOUT IT OVERHEATING. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS APPROXIMATELY 7,400. THE CURRENT MILEAGE WAS APPROXIMATELY 8,234. THE VIN WAS UNAVAILABLE.

Mileage: 7,400

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

Mileage: 43,000

AS I WAS DRIVING MY CAR STARTED CHUGGING. I PULLED OVER AND KEPT CHUGGING. I STOPPED THE CAR, LOOKED UNDER THE HOOD AND SAW IF SOMETHING WAS WRONG. DID NOT SEE ANYTHING. STARTED IT UP AGAIN AND ONCE I ACCELERATED IT STOPPED CHUGGING. DROVE IT VERY SCARCELY AND BROUGHT IT INTO THE DEALERSHIP. WAS TOLD IT WAS A TIMING CHAIN. VERY LUCKY THAT IT HAS NOT SNAPPED OR SKIPPED BECAUSE YOU WOULD HAVE POSSIBLY LOSE CONTROL. THE CAR ONLY HAS 36000 MILES ON IT AND HAS HAD THE OIL LEVEL TOPPED OFF EVERY FEW FILL UPS. THEY DO NOT LOOK AT THIS AS A MANUFACTURING DEFECT, EVEN THOUGH IT HAS HAPPENED ON QUITE A FEW CARS. MY LOCAL MECHANIC SAID HE HAS NEVER HEARD OF A TIMING CHAIN SNAPPING OR STRETCHING TO WHERE IT NEEDS TO BE REPLACED AT 36000 MILES. IT IS DANGEROUS AND ALSO VERY COSTLY TO PAY FOR. *TR

Mileage: 35,900

BEGAN TO HEAR LOUD KNOCKING NOISE FROM ENGINE OF MY 4 YEAR OLD MINI @ 66000 MILES. HAVE HAD MY MINI SERVICED ACCORDING TO THE SCHEDULE AT THE SAME DEALERSHIP FOR 4 YEARS. AFTER HEARING THE NOISE DID RESEARCH ONLINE TO NOTICE THAT MINIS HAVE A TIMING BELT /TENSIONER ISSUE. NOTICED ON THE SAME NIGHT THAT MY OIL LIGHT CAME ON AND THE INTERESTING THING IS THAT I JUST HAD MY OIL CHANGED IN AUGUST OF 2012 AND THIS WAS NOVEMBER 2012. TOOK CAR TO DEALER AND THE SERVICER SAID THEY HAD HEARD OF SOME MINI'S TIMING CHAINS FAILING AT 14K MILES. AFTER DIAGNOSIS HE NOTES THAT IT IS THE TIMING CHAIN AND THAT THE OIL FILTER GASKET WAS LEAKING WHICH CAUSED THE TIMING CHAIN TO FAIL. THIS IS NOT CORRECT AS MY VEHICLE HAS NEVER LEAKED OIL, AND I HAD JUST GOTTEN MY OIL CHANGED 3 MONTHS EARLIER AND NO MENTION WAS MADE BY MY SERVICE TECHNICIAN. THIS SEEMS TO BE A COMMON ISSUE IN MINIS AND THEY ARE NOT PROVIDING ANY KIND OF RELIEF. *TR

Mileage: 66,300

DRIVING IN THE MOUNTAINS WHEN I BEGAN TO SMELL BURNT OIL. AS SOON AS I WAS ABLE TO I PULLED OVER, IMMEDIATELY THERE WAS A CLOUD OF SMOKE COMING FROM UNDER THE FRONT HOOD. I OPENED THE HOOD AND THOUGH THERE WAS NO FIRE IT APPEARED THAT THE SMOKE WAS COMING FROM OIL LEAKING ONTO THE TURBO FROM THE OIL FEED LINE. AFTER LETTING THE CAR COOL I PROCEEDED HOME. NOW WHENEVER THE CAR IS SITTING IDLE I CAN SMELL BURNT OIL AND AFTER GETTING HOME I CAN SEE OIL POOLING ON THE TOP OF THE TURBO. I HAVE BEEN TOLD THERE IS AN ISSUE WITH THE CONNECTION ON THE TURBO OIL FEED LINE DUE TO THE DESIGN OF THE LINE AND HEAT FROM THE TURBO AND I WILL HAVE TO REPLACE THIS AT MY OWN COST. *TR

Mileage: 70,000

KNOCKING NOISE WHEN STARTING AND RUNNING. I THOUGHT IT WAS FROM THE WRONG FUEL ADDED TO IT, OR LOW OIL WHEN I PURCHASED IT. I CORRECTED THOSE TWO ISSUES, BUT IT STILL MAKES THE KNOCKING NOISE. I AM VERY AFRAID IT WILL SEIZE. I BELIEVE THE TIMING CHAIN AND TENSIONER SYSTEM NEEDS TO BE REPLACED. *TR

I WAS TOLD MY WARRANTY EXPIRED END OF JUNE. I BOUGHT MINI-S 08 USED IN FEBRUARY FROM A MINI DEALERSHIP IN WESTCHESTER, ELMSFORD, NY. I NOTICED A KNOCKING NOISE THAT TO ME DIDN'T SOUND NORMAL NOT TOO LONG AFTER I BOUGHT THE CAR. THE PEOPLE AT MINI TOLD ME IT WAS FROM SOMETHING ELSE, A LOOSE PIECE AND THAT THEY "FIXED THE PROBLEM." THIS NOISE ONLY BECAME WORSE, AND NOW THE CAR IS AT 45,000 MILES AND NOT EVEN 6 MONTHS FROM PURCHASE. THE NOISE BECAME EVEN LOUDER, WHICH THEN IT SOUNDED LIKE A TRACTOR TRAILER. I CHANGED THE OIL, THE NOISE WASN'T AS LOUD BUT STILL THERE. MY MECHANIC SAID THAT THE TIMING BELT IS GOING TO SNAP SOON, AND IS A DANGEROUS PROBLEM THAT CAN CAUSE AN ACCIDENT, AND ONCE IT BREAKS, THE WHOLE ENGINE WILL BE DESTROYED. *TR

Mileage: 38,000

MY CAR STARTED MAKING A WEIRD NOISE IN THE FRONT OF THE CAR NEAR THE ENGINE WHEN I TURNED IT ON. THEN IT CONTINUED TO MAKE THE LOUD NOISE AS I DROVE. I TOOK THE CAR TO THE DEALER AND THEY SAID THE TIMING CHAIN STRETCHED AND CAUSED THE GUIDE RAIL TO BREAK, WHICH FELL INTO THE OIL PAN. THE DEALER SAID I WAS LUCKY MY ENGINE DIDN'T LOOK UP WHILE I WAS ON THE HIGHWAY. THIS WAS A $2100 FIX ON A 4 YEAR OLD CAR WITH 53,000 MILES. *TR

Mileage: 53,500

THE TURBO CHARGER HAS TOTALLY FAILED (CAR IS UNDER HALF POWER) AND THE TOP GUIDE ON THE TIMING CHAIR (TENSIONER SYSTEM) IS BROKEN. I HAVE DONE THE PROPER MAINTENANCE WITH EXCEPTIONAL CARE. THE TURBO IS COOLED BY THE KNOWN FAILED AUXILIARY WATER PUMP WITH INTEGRATED CIRCUIT BOARD AND IS CURRENTLY UNDER RECALL. MINI/BMW IS REFUSING TO COVER THESE FAILURES CLEARLY CAUSED BY DEFECTIVE PARTS AND DESIGN (OIL LINE LEADING TO TURBO GETS GUMMED UP BECAUSE IT IS TOO SMALL). THEY ARE ATTEMPTING TO CHARGE ME OVER $5200 TO REPAIR THE CAR (20% OF THE VEHICLE COST IN 2008) FOR WHAT IS ABSOLUTELY A MANUFACTURER PROBLEM. MY CAR IS NOT OPERATIONAL AND HAS NOT BEEN OPERATIONAL FOR OVER 2 WEEKS WHILE I CONTINUE TO 'FIGHT' BMW'S DETERMINATION NOT TO COVER THESE PROBLEMS. READING COUNTLESS BLOGS WITH OWNERS EXPERIENCING THE SAME PROBLEM(S) I BELIEVE BMW IS INTENTIONALLY SELLING A PRODUCT IT KNOWS IS DEFECTIVE AND COLLECTING THOUSANDS OF DOLLARS ON REPAIRS. NO CAR SHOULD EXPERIENCE A TOTAL FAILURE OF A TURBO AND BROKEN TIMING CHAIN IN 60K MILES. THIS IS OUTRAGEOUS AND NHTSA SHOULD PROTECT US CONSUMERS FROM THIS FRAUDULENT ACTIVITY BY ISSUING A RECALL - SOONER THAN LATER. *TR

Mileage: 59,952