2009 MINI COOPER S Engine Problems

THERE IS A COOLING SYSTEM FAILURE IN MY CAR THAT HAS CAUSED CYLINDER HEAD ISSUES AND HEAD GASKET ISSUES. EVEN THOUGH MY CAR IS A 2009, IT ONLY HAS ABOUT 53,000 MILES. I PURCHASED THE CAR IN DECEMBER 2019 AND IN JANUARY 2020 THE CAR OVERHEATED WHILE DRIVING AND THEN I NOTICED THE COOLANT WAS LEAKING FROM THE CAR. I REPLACED THE HOSE AND THERMOSTAT. NOW IN AUGUST/SEPTEMBER 2020 THE CAR OVERHEATED AGAIN AND THERE WAS ALSO LEAKING FROM THE COOLANT. I TOOK THE CAR TO THE MECHANIC AND THEY SAID THE ENGINE NEEDS MAJOR REPAIR WORK. I RECENTLY NOTICED RECALLS ON THIS MAKE AND MODEL REGARDING THE ENGINE AND ENGINE COOLING, HOWEVER BASED ON MY EXPERIENCE WITH THIS CAR, I'M THINKING THIS MAY STILL BE AN ISSUE WITH THIS CAR. ADDITIONALLY, I REVIEWED THE CARFAX REPORT FROM THE PREVIOUS OWNERS AND THERE WAS NO INFORMATION ABOUT ANY RESOLVED RECALLS. HOWEVER, I SPOKE WITH THE BMW DEALERSHIP THAT THE CAR HAD WORK DONE AT FROM THE PREVIOUS OWNER AND THEY SAID THE RECALLS IN 2012 (AUXILIARY COOLANT PUMP) AND 2015 (HEAT SHIELD TURBO CHARGER) WERE RESOLVED. I ALSO CONFIRMED THIS WITH ANOTHER MINI COOPER DEALERSHIP. BASED ON THE CARFAX REPORT, THESE RECALLS MAY HAVE NEVER BEEN RESOLVED.

Mileage: 50,000

THE ELECTRIC AUXILIARY WATER PUMP FAILED AND CAUSED THE CIRCUIT BOARD TO OVERHEAT. IF THE CIRCUIT BOARD WERE TO OVERHEAT, IT CAN INCREASE THE RISK OF A FIRE. OTHER OBSERVATION: MISFIRE PRESENT AT SEVERAL CYLINDERS. INTAKE PORTS CARBONIZED.

DAILY ON COLD STARTS, THE CAR MISFIRES AND STALLS 2-20 TIMES BEFORE IT STARTS. THIS HAS JUST STARTED HAPPENING IN THE PAST 3 MONTHS.

Mileage: 119,580

VEHICLE WAS IN MOTION AT 55-60 MPH. VEHICLE CUT OFF AND WOULD NOT START OR TURNOVER. 15 MINUTES OF REST AND CAR WAS STARTED AND RPMS WERE FLUTTERING. MINI COOPER OF GRAND RAPIDS STATED THE TIMING CHAIN WAS "MOST LIKELY" "OUT". THEY ALSO STATED NO GOODWILL ASSISTANCE COULD BE PROVIDED WHILE ACKNOWLEDGING THE WINDOW, FOR A PREVIOUS LAWSUIT INVOLVING THEE 2009 MINI COOPER S, WAS CLOSED AND THE DEFECTIVE TENSIONER AND GUIDE RAILS (TO INCLUDE ENGINE DESIGN) WERE STILL IN MY MINI COOPER. CAR HAS STARTED ONCE SINCE BUT WILL NOT STAY RUNNING. OTHER CASES OF FUEL PUMPS FAILING ON SAID MODEL WERE ACKNOWLEDGED BUT "NO RECALLS HAVE BEEN ISSUED" SAID MINI, THUS NOT WARRANTING ANY REPAIR OR CONCERN FOR MY FAILED MINI. REPAIR ESTIMATE WAS 3,985$. AFTER MENTIONING THE PREVIOUS LAWSUIT DURING 2015, A 'RANDOM' DISCOUNT WAS ANNOUNCED OF 10-15% TO BRING SAID TOTAL TO EST. 2,900$. MY 2009 MINI COOPER S HAS HAD IDLE AND RPM ISSUES/FLUCTUATIONS FOR A COUPLE MONTHS AFTER PREVIOUS OWNER HAD JUST REPLACED THE TIMING CHAIN ASSEMBLY IN JANUARY OF 2019 WITH GENUINE MINI REPLACEMENT PARTS (FACTORY PARTS CAUSING THE SAME FACTORY DEFECT)

Mileage: 95,200

AUXILIARY WATER PUMP FAILURE. SAME ISSUE WITH OTHER IDENTICAL CARS WITH A RECALL BUT THIS ONE IS NOT LISTED. RECALL NUMBER FOR THIS IS 18V248000. THE SAME ISSUE IS HAPPENING WITH MY CAR BUT MINI SAYS IT ISN'T LISTED.

MY 2009 MINI COOPER S MADE RATTLE NOISE AND THE WHOLE TIMING CHAIN GOT REPLACED PLUS THE THERMOSTAT HOUSE AND WATER PUMP! THE ENGINE LIGHT STILL KEEPS ON AFTER TROUBLE-SHOOTING BY MY MECHANICS, WHICH MIGHT BE THE COMPUTER ISSUE WHICH HAS TO BE FIGURED OUT SOON! THE TIMING CHAIN ISSUE SHOULD BE UNDER FULLY-COVERED BY MANUFACTURER SINCE TOO MANY MINI COOPER OWNER HAVE THE SAME PROBLEM AND PAID THOUSAND OF DOLLARS TO FIX IT! MY MINI IS ONLY ABOUT 55K MILES AND ALREADY HAS TIMING CHAIN ISSUE!

Mileage: 55,000

I WAS DRIVING DOWN THE HIGHWAY AND MY CAR GAVE ME A WARNING THAT MY ENGINE TEMP WAS WAY TO HIGH. I WAS LUCKY ENOUGH TO HAVE A GOOD PLACE TO STOP AND CHECK OUT WHAY WAS GONG ON. I OPEN THE HOOD, THE ENGINE IS SMOKING AND THE COOLANT RESERVOIR IS NEAT EMPTY. I LOOK AND SEE A POOL OF ANTIFREEZE COMING FROM THE THERMOSTAT. THIS IS THE THIRD THERMOSTAT I HAVE INSTALLED ON THIS CAR AND THE SECOND FAULTY ONE I HAVE HAD IN 3 MONTHS. THIS IS ALSO THE SECOND TIME I HAVE HAD TO STOP ON THE HIGHWAY DUE TO A BADLY LEAKING THERMOSTAT.

Mileage: 77,000

THIS IS THE 2ND TIME THIS HAPPEND THE CAR STARTED TO ACELERATE BY ITS SELF WHEN STOPPED AND THE BRAKES COULDN'T HOLD THE CAR BACK, I THEN PUT THE CAR INTO NEWTRAL, THEN INTO PARK TAPPED THE GAS AND THE CAR ACTED NORMAL. IT WAS LIKE THE CAR HAD A MIND OF ITS OWN AND JUST STARTED TO GO WITHOUT MY FOOT ON THE GAS PEDAL . THE LAST TIME THIS HAPPEND WAS A YEAR AGO .I THOUGHT IT WAS A FLUKE BUT NOW IT HAPPEND AGAIN, I AM A VERY GOOD DRIVER BUT AFTER THIS HAPPEND AGAIN I THINK I MIGHT JUST GET RID IF THIS CAR ...IT REMINDED ME OF THE MOVIE CHRITINE WHEN THE CAR HAD A MIND OF ITS OWN. I WAS STOPPED AT A LIGHT WITH A CAR IN FRONT OF ME, THE WEATHER WAS 45 DEGREES AND WAS DRIVING FOR ABOUT 15 MINUTES ALREADY WHEN IT HAPPEND

Mileage: 181,000

CAR WENT INTO LIMP GEAR MODE ON FREEWAY, HIGH RPM AT 40 MPH. VEHICLE SHIPPED TO MINI DEALER 05/09/17 SAYING THERE WAS A TRANSMISSION ERROR CODE. DEALER SAID THEY TESTED VEHICLE AND IT WASN'T THE TRANSMISSION IT NEEDED A WATER PUMP AND CYLINDER NEED VALVE COVER. 67,117 MILES ON ODOMETER. ALSO FRONT CV AXLE BOOT LEAKING. HAD REPAIRS DONE ($1692.58) AFTER DISCOUNT. AT TIME OF PICKUP, DEALER ASKED TO KEEP THE VEHICLE A FEW MORE DAYS TO DOUBLE CHECK THE TRANSMISSION. A FEW DAYS LATER THEY SAY YES THERE IS A TRANSMISSION ERROR WITH THE CAR GOING AT HIGHER HIGHWAY SPEEDS AND IT WILL NEED A NEW TRANSMISSION! COST ($9000) I DID NOT HAVE THIS DONE.THE SERVICE ADVISOR TOLD ME THE VEHICLE WAS NOT SAFE TO DRIVE! THIS VEHICLE IS DRIVEN BY MY 16 YEAR OLD DAUGHTER TO AND FROM SCHOOL!

Mileage: 67,117

I PURCHASED A BRAND NEW MINI COOPER S IN 2009 W/ STANDARD 3 YEARS OF FACTORY MAINTENANCE AND I LATER ADDED ON AN EXTENDED WARRANTY A FEW YEARS LATER. 2014 I ENTERED INTO A 3 YEAR LEASE ON A BMW. ASIDE FROM MAINTENANCE, THE MINI WAS MOSTLY GARAGED EXCEPT FOR MAINTENANCE UNTIL TH AFTER A MONTH OF DRIVING IT, I HEARD A TICKING SOUND THAT MADE ME THINK IT NEEDED OIL ADDED, DESPITE HAVING ONE ABOUT 2 MONTHS PRIOR. I ADDED THE MINI SYNTHETIC OIL TO THE CAR AND THE TICKING SOUND STOPPED FOR A WEEK OR TWO. THEN IT STARTED RATTLING AND SHAKING SEVERELY WHEN DRIVING LOW SPEEDS OR AT AN IDLE. I CHECKED THE ON BOARD DIAGNOSTIC SYSTEMS, WHICH IS SUPPOSED TO CHECK OIL LEVELS AND THE GENERAL HEALTH OF THE CAR. NO ISSUES CAME UP BUT I STOPPED DRIVING IT BECAUSE I SAW THE OIL LIGHT COME ON, AND I KNOW THAT COULDN'T BE GOOD, ESPECIALLY SINCE OIL WAS ADDED BETWEEN CHANGES. I HAD THE CAR TOWED TO AN INDEPENDENT MINI MECHANIC, THEY TOLD ME THAT THE TIMING CHAIN NEEDED TO BE REPLACED, THERE WERE HOLES IN THE TURBO LINE AND SOME VARIOUS OIL LEAKS. THEIR ESTIMATE WAS ROUGHLY $2500 TO MAKE THE CAR DRIVABLE AGAIN. SPOKE TO MINI CORPORATE, URGED ME TO TAKE IT TO MINI DEALER FOR DIAGNOSTICS SO CORPORATE TO SEE WHAT HELP THEY'D OFFER ME ON THESE ISSUES BECAUSE THEY KNEW THE TIMING CHAIN BELT WAS AN ISSUE AND THEY KNEW THE CAR BURNS THROUGH OIL 50% FASTER THAN THEIR ELECTRONIC SYSTEM AND OWNERS MANUAL SAYS. THEY WERE AWARE OF THIS IN 2008 AND IT AFFECTED SEVERAL MINI COOPERS TO THE EXTENT OF BLOWING OUT THEIR ENTIRE ENGINE. A CLASS ACTION LAWSUIT WAS FILED BECAUSE MINI FAILED TO ISSUE A RECALL, WARN BUYERS, OR NOTIFY CURRENT ONES. THEY EXTENDED THE TIMING CHAIN BELT COVERAGE TO 7 YEARS OR 80K AFTER THE SUIT. MY CAR HAS 73K BUT IT'S 7 YEARS GOING ON 8. THE DEALER CONFIRMED DIAGNOSIS BUT MINI WON'T OFFER ANY HELP ON THE 3-4K REPAIRS. IF THIS HAPPENED 9 MONTHS AGO, THEY WOULD COVER IT.

Mileage: 73,000

TURBO LEAKING OIL - GASKETS - MAJOR COMPLAINTS ALL OVER THE INTERNET. MAYBE THIS IS SOMETHING THEY NEED TO REVIEW FOR DESIGN ERROR.

TIMING CHAIN TENSIONER BROKE CAUSING TIMING CHAIN TO BREAK AND RUINING VALVE TRAIN AND PISTONS. SINCE IT IS AN INTERFERENCE ENGINE. COMPLETE ENGINE TO BE REPLACED, WITH ONLY 25,000 ORGINIAL MILES ON VEHICLE.

Mileage: 25,000

TIMING CHAIN BROKE LEADING TO VEHICLE COMING TO A SUDDEN STOP. HAD THIS HAPPENED IN HEAVY TRAFFIC, IT COULD HAVE BEEN LIFE THREATENING. BMW REFUSES TO ASSIST.

Mileage: 80,000

TL* THE CONTACT OWNS A 2009 MINI COOPER S. WHILE DRIVING THE VEHICLE OR WHILE PARKED, THE COOLANT IN THE VEHICLE BEGAN TO LEAK PROFUSELY. THE FAILURE WAS PERSISTENT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE WATER PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 87,178.

Mileage: 87,178

I HAVE A MINI COOPER S 2009, WITH ONLY 50,000 MILES IN IT ,AND ALREADY ITS FAILING THE GUIDE AND SUPPORT RAIL THE HOLDS THE TIMING CHAIN, THOSE SUPPORTS ARE MADE OF PLASTIC WHICH I BELIEVE IT SHOULD BE SOME KIND OF METAL INSTEAD,WHEN THE SUPPORT GUIDES BREAKS THE CHAIN COMES OUT OF PLACE CRASHING THE ENGINE, WELL THE IS ECSACTLY WHAT HAPPEN TO ME , WHEN I WAS DRIVING IN THE FREEWAY, I HAD TO STOP AND GET MY CAR TOWED, BUT LUCKY ME I WASN'T IN THE MIDDLE OF FREWAY WHICH IT COULD CAUSE A BIG ACCIDENT, MAYBE DEATH. MOST OF CAR MAKERS LIKE HONDA HAS A MILES LIMIT FOR TIMING BELT REPLACEMENT, MINI COOPER S DONT, ITS BASE ON HOW MUCH YOU DRIVE IT ,THATS WHAT DEALER SAID. BOTTON LINE MINI USA SHOULD REPLACE THOSE PLASTIC PARTS FOR SOMETHING MORE DURABLE SPECIALLY IF ITS GOING TO MAKE YOUR CAR STOP ALL OF OF SUDDEN.

Mileage: 60

AT 30000 MILES THE TIMING CHAIN WAS REPLACED DUE TO A RECALL. CAR RATTLED FOR A FEW MONTHS PRIOR TO REPLACEMEN. AT 55OOO MILE MY CAR ENGINE LIGHT CAME ON AND LOST POWER. I WAS ABLE TO LIMP IT IN TO WORK ABOUT ANOTHER 5 MILES. MY HUSBAND DROVE IT TO MINI DEALERSHIP ANOTHER 10 MILES AWAY AND THEY STATED THAT IT BLEW A VALVE OR A PISTON QUOTING HIM A HEAD REPLACEMENT OF $5000 OR REPLACEMENT OF ENGINE FOR $10000. I PURCHASED THIS CAR NEW AND I HAVE MAINTAINED IT TO A T. READING ON LINE THIS SEEMS TO ALL BE RELATED TO THE TIMING CHAIN ISSUE. MINI IS NOT STANDING BY THEIR CAR AND REFUSING TO TAKE RESPONSIBILTY. HOPEFULLY IF WE ALL CONTINUE TO SQUEAK WE CAN GET THEM TO TAKE RESPONSIBILTY FOR FAULTY VEHICLES. I HAVE A NICE LOOKING NON RUNNING WORTHLESS CAR SITTING IN MY DRIVEWAY...ANYONE WANT IT!

Mileage: 55,000

DEFECTIVE TIMING CHAIN AND TENSIONERS CAUSING ADDITIONAL DAMAGE TO THE EXHAUST VALVES PREVENTING COMPRESSION IN THE ENGINE AS IS DESCRIBED IN ONE OF MANY CLASS ACTION SUITS.

Mileage: 660,000

TIMING CHAIN BROKE WELL BEFORE 10 YEAR OR 100000 MILES. THIS TIMING CHAIN BREAKAGE CAUSED MY ENGINE TO FAIL DUE TO PISTON DAMAGE OR CYLINDER DAMAGE. MY ENGINE NOW NEEDS TO BE REPLACED. MY VEHICLE WAS MOVING WHEN THE SOUND OCCURRED. WHEN I RESEARCHED THIS SOUND, I LEARNED IT MAY BE THE TIMING CHAIN AND TOOK IT TO THE GARAGE TO BE REPLACED. THE GARAGE REPLACED THE TIMING CHAIN AND WHEN THEY TOOK IT FOR A TEST DRIVE, IT DIDN'T SEEM TO BE RUNNING RIGHT AND AFTER FURTHER INSPECTION IT WAS DETERMINED THAT THE ENGINE WAS RUINED AND NEEDED TO BE REPLACED.

Mileage: 72,000

TL* THE CONTACT OWNS A 2009 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 40 MPH, THE VEHICLE FAILED TO ACCELERATE WHEN THE ACCELERATOR PEDAL WAS DEPRESSED AND BEGAN TO JERK. IN ADDITION, A LOUD KNOCKING SOUND WAS HEARD FROM THE HOOD OF THE VEHICLE WHEN DRIVEN AND OILS LEAKS WERE DISCOVERED WHEN PARKED. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 44,000.

Mileage: 44,000

SINCE I GET MY UNTIL NOW I REPAIR TWO TIMES . THE FIRST TIME I WAS CHANGE THE PART OF THE TOP OF THE MOTOR I DON'T REMEMBER THE NAME. BUT THIS ONE THAT IS THE MOST STRAGE I WAS DRIVING AND IN THE MIDDLE OF THE ROAD THE MOTOR STOP INTANLY. THE MOST STRANGE IS 10 MINUTES AFTER DRIVE THE CAR ALL THIS HAPPEN SO THAT MEAN IS NO SAFE. AND NOW WHAT I HAVE TO DO....

Mileage: 29,800

THE PROBLEM OCCURRED WHEN THE TENSIONER FOR THE TIMING CHAIN NO LONGER APPLIED PRESSURE TO THE GUIDE RAIL. THIS CAUSES THE TIMING CHAIN TO FLAP AGAINST THE THE GUIDE RAILS EVENTUALLY BREAKING THEM. THERE WAS A NOISE THAT WAS CREATED HEARD DURING COLD START UP AND EVENTUALLY WENT AWAY WHEN THE ENGINE GOT WARM. THE ITEMS REPAIRED WERE A FAULTY CHAIN TENSIONER, TIMING CHAIN, CHAIN GUIDE RAIL, BEARING BOLT, BEARING BOLT GASKET, CRANK SHAFT SPROCKET, CRANKSHAFT PULLEY BOLT, VALVE COVER GASKET, PERMATEX HYLOMAR GASKET MAKER, SERPETINE BELT, SOLENOID, AND VANOS. THIS ISSUE APPEARED WELL BEFORE BMWS SUGGESTED MAINTENANCE PERIOD OF 120,000 MILES, OR 10 YEARS.

Mileage: 68,250

UPON TH EENGINE HEATING AND COOLING THE PLASTIC GASKET ON TH EENGINE OIL COOLER CAN GET PINCHED, CAUSING AN OIL LEAK. MINI COOPERS IN PRIOR YEARS - 2002-2007 HAD THE SAME ISSUE AND MINI HAD A RECALL. IF I SPEND THE $1,800 TO GET THE REPAIR THE NEXT TIME THE ENGINE HEATS UP AND COOLS - THE GASKET COULD BECOME PINCHED AGAIN - THUS CAUSING A LEAK. MINI COOPER OF ATLANTA IS YES THIS COULD HAPPEN AND I WOULD HAVE TO GET IT REPAIRED AGAIN. MINI COOPER NEEDS TO ENSURE THE 2 PLATES OF THE METAL OIL COOLER ARE SECURE AND CANNOT EXPAND AND SHRINK - UPON ENGINE USAGE. THIS IS THE SAME MANUFACTURING FLAW MINI COOPER HAD IN 2002 - 2007 - SO WHY HASN'T MINI COOPER BEEN TOLD TO FIX THEIR PROBLEM - VERSES THROWING THE RESPONSIBILITY TO THE CUSTOMER?

Mileage: 50,000

ENGINE CEASED WHILE TRAVELING ON HIGHWAY. PREVIOUSLY TOOK CAR TO MINI DEALER WHEN ENGINE LIGHT WAS ON AND WAS TOLD THAT THE ENGINE LIGHT WAS PROBABLY ON BECAUSE OF THE GAS CAP AND THEIR WAS NOTHING TO WORRY ABOUT. *TR

Mileage: 95,000

LEAKING TURBO OIL FEED LINE AND FAILING TIMING CHAIN. *TR

Mileage: 65,000

AIR BAG WARNING LIGHT COMES ON WHILE DRIVING. BMW NORTH AMERICA HAD ISSUED A RECALL FOR THE 2005 - 2008 MODELS, BUT NOT AFFECTED 2009 (2008 PRODUCTION DATE) MODELS. PERSISTENT OIL LEAKS FROM AND AROUND OIL FILTER HOUSING AND TURBO OIL LINES. OIL LEAKS DIRECTLY ON EXHAUST MANIFOLD DOWN PIPE, POTENTIALLY STARTING A FIRE, HASN'T YET, BUT THERE HAS BEEN PLENTY OF SMOKE AND IN ONE INSTANCE, A SMALL FLARE-UP WHEN OIL DRIPPED ON THE PIPE AS THE CAR WAS IDLING IN THE GARAGE AFTER A SHORT TRIP. *TR

Mileage: 64,500

TL* THE CONTACT OWNS A 2009 MINI COOPER S. WHILE DRIVING AT 45 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 113,000.....UPDATED 07/22/15 *BF UPDATED 10/06/2017*CN

Mileage: 113,000

TIMING CHAIN, WENT ,,THE DEALER SAID IT WAS THE SELF ADJUSTING TIMING CHAIN, IF IT SELF ADJUSTS THERE MUST BE A MANUFACTURE DEFECT,,LOOKED ON LINE AND FROM 2007-2009 500,000 CAR HAD THE SAME PROBLEM THE COST TO FIX IS $2200 DEALER SAID NOT WORTH FIXING AND SENT ME TO LOOK AT A NEW CAR. *TR

Mileage: 132,000

A FEW WEEKS AFTER I BOUGHT THE VEHICLE, I NOTICED THAT THERE WAS A NOISE WHEN STARTING THE ENGINE COLD. THIS "RATTLING" NOISE WOULD CONTINUE UNTIL THE ENGINE HEATED UP & GO AWAY. I TOOK THE CAR IN THEY CHANGED THE OIL & TOLD ME THAT THE COOLANT WAS LOW. HE ASKED IF THE CAR WAS OVERHEATING WHICH IT WAS NOT. HE TOLD ME TO KEEP A CLOSE EYE TO SEE IF THE CAR OVERHEATS. I MADE AN APPOINTMENT TO TAKE THE CAR TO A LOCAL MECHANIC JUST TO BE SAFE. A FEW DAYS LATER, DRIVING 65MPH ON THE FREEWAY I NOTICED SMOKE COMING OUT OF MY EXHAUST & THE HOOD, CLOSER TO THE WINDSHIELD NOT THE FRONT BY THE RADIATOR. SMOKE STARTED COMING FROM THE VENTS AND SMELLED "RUBBERY". THE THERMOSTAT SYMBOL APPEARED & THEN THE OIL LIGHT. I TOOK IT TO CARMAX WHO SAID "SRY, NO EXTENDED WARRANTY, NO HELP". I TOOK IT TO THE LOCAL MECHANIC. HE TOLD ME INITIALLY THAT THE THERMOSTAT WAS BLOWN AND THERE WAS A MATERIAL FAILURE OF THE HOUSING (IT WAS CRACKED), HE REPLACED ALL THE PIPES FROM THE COOLANT: $482. THE MECHANIC CALLED & SAID THAT HE COULD NOT "BURP" THE VEHICLE & THAT IT MADE A WEIRD SOUND SO THEY HAVE TO "BLEED IT OVERNIGHT". THIS DID NOT SOLVE THE ISSUE SO THEY HAD TO TAKE THE ENGINE APART & FIND THE PROBLEM. THE HEAD CASKET WAS BLOWN & QUOTED ME A REPAIR BILL OF $5000+ .THE OWNER OF THE SHOP CALLED BMW AND ASKED IF THEY COULD DO A "GOOD FAITH" REPLACEMENT WHICH THEY SAID THEY WOULD DO IF THE CAR HAD LESS THAN 80,000 MILES ON IT... MINE HAD 85,000 MILES ON IT... FROM WHAT I AM READING ON THE COMPLAINT BOARD, THIS IS A VERY COMMON ISSUE!! AS A RN IF THERE IS A FAILURE IN ANY PRODUCT WE IMPLANT IN PATIENTS, THERE IS AN IMMEDIATE RECALL, SO WHY, WHEN BMW CLEARLY KNOWS THIS IS AN ISSUE DO THEY WAIT FOR HARD-WORKING PEOPLE LIKE ME TO BE PUT IN THIS HORRIBLE SITUATION!!! I HOPE THAT BMW STEPS UP AN HONOR IT'S "GOOD FAITH" BEYOND 80,000 MILES AND REPLACE THE CAR. *TR

Mileage: 85,000

I STOPPED AT A RED LIGHT ON A BUSY CITY STREET. THE MINI COOPER S ENGINE STOPPED RUNNING AND WOULD NOT START. THAT DAY WAS HEAVY SNOW AND THE ROADS WERE VERY DIFFICULT TO DRIVE ON. I COULD NOT MOVE THE CAR. AFTER SOMETIME WAITING ON A TOW TRUCK THE FOUR WAY FLASHERS QUIT WORKING. FORTUNATELY NO ONE RAN INTO THE CAR. I DISRUPTED TRAFFIC FOR ABOUT AN HOUR UNTIL THE POLICE WERE ABLE TO PUSH THE CAR OFF THE ROAD. THE CAR WAS TOWED TO THE MINI DEALER AND IT WAS DETERMINED THE TIMING CHAIN BROKE. THE CAR ONLY HAS 32,000 MILES ON IT. RESEARCHING, I SEE THAT MANY MINI OWNERS HAVE EXPERIENCED THE TIMING CHAIN FAILING. MY 17 YEAR OLD DAUGHTER USUALLY DRIVES THIS CAR. I AM GLAD I WAS DRIVING IT WHEN THIS HAPPENED AND FORTUNATE THE CAR WAS NOT MOVING WHEN THE ENGINE FAILED. *TR

Mileage: 32,000

2009 MINI COOPER S - I, LIKE SO MANY OTHER MINI COOPER OWNERS, HAVE JUST FALLEN VICTIM TO THE "DEATH RATTLE" OF THE [KNOWN BY BMW] DEFECTIVE/FAULTY AND NON-RECALLED TIMING CHAIN ISSUE. IT'S ABSURD THAT WE CONTINUE TO EXPOSE THIS FAR TOO COMMON DEFECT OF A PRODUCT THAT WAS ORIGINALLY DEEMED AS A "NON-SERVICE" ITEM GOOD FOR THE OPERATING LIFE OF THE ENGINE. MOST OWNERS EXPERIENCE PROBLEMS WITHIN THE FIRST 50,000 MILES. I PURCHASED THIS WELL MAINTAINED (AT A LOCAL MINI DEALER) MINI FROM A PRIVATE PARTY JUST DAYS AFTER THEY PERFORMED AN EXPENSIVE 'WALNUT TREATMENT' TO CLEAR OUT EXCESSIVE CARBON BUILD UP. WITHIN 100MI OF THIS SERVICE, THE 'DEATH RATTLE' STARTS. I AM NOW BEING TOLD THAT IT WILL RUN JUST OVER $2400 (I'VE UNCOVERED ABOUT $400 IN TOTAL PARTS) TO CORRECT AN ISSUE BMW HAS BEEN HIDING BEHIND FOR YEARS; THEY'VE EVEN ISSUED A WARNING TO SERVICE ADVISORS TO NOT RE-INSTALL THE DEFECTIVE PARTS, BUT DENY THE PART TO ACTUALLY BE DEFECTIVE OR IN NEED OF RECALL. WHEN WILL ANYONE STAND UP FOR THE LITTLE GUY, THE CONSUMER, AND DEMAND THIS WELL KNOWN, OFTEN OCCURRING, EXTREMELY EXPENSIVE AND POTENTIALLY DANGEROUS DEFECT BE CORRECTED AT THE COST OF THE MANUFACTURER? I NOW HAVE AN $11,500 PAPER WEIGHT. *TR

Mileage: 48,100

MY TIMING CHAIN HAS NOW STARTED TO FAIL FOR THE 4TH TIME ON THIS CAR. THE TIMING CHAIN TENSIONERS FAIL AND MINI DOES NOTHING TO CORRECT THE ISSUE PAST THE WARRANTY PERIOD. *TR

Mileage: 86,000

ONCE YOU SEARCH THE 'DEATH RATTLE' ON GOOGLE, YOU CAN GET LOTS OF INFO ABOUT WHAT IS GOING ON AND THE DEATH RATTLE IS REALLY COMMON ON THE R56. IT IS REALLY A COMMON PROBLEM AND MINI SHOULD TAKE THE RESPONSIBILITY OF THAT. *TR

Mileage: 70,700

TOOK VEHICLE IN FOR INSTALLATION OF THE HEAT SHIELD FOR TURBO FEED LINE. THIS IS A RECALL AND NEWLY INSTALLED PART TO PROTECT THE TURBO FEED LINE DUE TO OVERHEATING. ONCE IT WAS INSTALLED I WAS INFORMED THAT THE TURBO LINE IS FAILING AND THE DEALER WANTS TO CHARGE ME $1500 TO REPAIR THE LEAKING LINE. THE FAILURE OF THE LINE IS OBVIOUSLY DUE TO EXCESSIVE HEAT AROUND THIS LINE... THE SAME REASON THEY ARE INSTALLING A HEAT SHIELD. THIS IS RIDICULOUS AND THE ITEM SHOULD BE RECALLED AND REPLACED! *TR

Mileage: 102,761

ENGINE ALL OF A SUDDEN STARTS MAKING A RATTLING NOISE. TOOK IT IN TO DEALER, TIMING CHAIN GUIDES HAD BROKEN AND CHAIN WAS STRETCHED. WAS INFORMED THERE WAS A MINI CAMPAIGN ABOUT THIS BUT MY VEHICLE WAS NOT INCLUDED. EXPENSIVE REPAIR AND POTENTIALLY DANGEROUS SITUATION IF CHAIN HAD BROKEN. WAS INFORMED AFTER WORK WAS DONE THAT CLUTCH WAS BAD AS WELL. HAD DRIVEN THE VEHICLE THE DAY BEFORE WITHOUT ISSUE BUT AFTER ONLY 10 MILES FROM THE DEALERSHIP CAR WOULD NOT MOVE FROM STOPPED SINCE CLUTCH WOULD NOT ENGAGE. EXTREMELY EARLY FOR THIS AMOUNT OF REPAIRS TO BE NEEDED, I QUESTION THE DURABILITY OF THESE PARTS AND THIS BRAND. BOTH OF THESE SUDDEN WEAR FAILURES COULD HAVE BEEN EXTREMELY DANGEROUS IF THEY HAD OCCURRED ON THE HIGHWAY. *JS

Mileage: 41,932

DRIVING ON 405 FWY IN SOUTHERN CALIFORNIA TURNING OUT OF FREEWAY OFF RAMP IN THE POURING RAIN. THE CAR DEAD STOPPED. VERY DANGEROUS, CARS COMING OFF FREEWAY BEHIND ME WAS A 911 SITUATION. AFTER SOMEONE PUSHED ME OFF TO THE SIDE OF THE ROAD HAD CAR TOWED. NO ENGINE LIGHT WARNING TO INDICATE PROBLEM OF TENSIONER (TIMING CHAIN BREAKAGE). ENTIRE ENGINE WAS REPLACED/REBUILT BECAUSE OF EXTENSIVE DAMAGE TO ENGINE. BMW APPARENTLY IS AWARE OF THE TIMING CHAIN DEFECT AND HAS NOT ISSUED SERVICE BULLETIN OR RECALL. I'M HEARING THERE IS A CLASS ACTION SUIT BECAUSE OF THE MANY COMPLAINTS. THE FACT THAT I COULD HAVE VERY EASILY BEEN KILLED OR SERIOUSLY INJURED IS WHY I AM ISSUING A COMPLAINT (NOT TO MENTION MY BILL FOR $6200.00 I HAVE ON MY CREDIT CARD) AND THE THREE WEEKS IT TOOK TO FIX. NATURALLY I WAS 6 MONTHS OUT OF MY WARRANTY. *TR

Mileage: 48,000

TURBO OIL FEED LINE LEAK, OIL FILTER HOUSING GASKET WHICH IS COSTING ME CLOSE TO 1200$. *TR

Mileage: 47,000

TL* THE CONTACT OWNS A 2009 MINI COOPER S. THE CONTACT STATED THAT COOLANT WAS LEAKING FROM THE RADIATOR. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS REPAIRED BY THE PREVIOUS OWNER UNDER NHTSA CAMPAIGN ID NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 44,000.

Mileage: 44,000

MY CAR HAS BEEN LEAKING OIL AND THE DEALERSHIP DETERMINED IT WAS DUE TO THE TIMING CHAIN TENSIONER. THEY ARE CHARGING $357.98 TO HAVE IT FIXED. MY CAR WAS PURCHASED BRAND NEW AND HAS ONLY 50,000 MILES ON IT. AS SOON AS MY 4-YEAR WARRANTY EXPIRED, MY CAR HAS BEEN IN THE SHOP MULTIPLE TIMES DUE TO ENGINE ISSUES. SERVICES THAT HAVE BEEN PERFORMED AT 50,000 MILES: 1. THERMOSTAT IS LEAKING COOLANT- $ 671.99 2. WATER-PUMP ALSO LEAKING COOLANT- $661.20 3. COOLANT FLUSH- $169.80 I USE ONLY PREMIUM GAS FOR MY CAR, PERFORM REGULAR OIL CHANGES, AND MAINTAIN MY CAR METICULOUSLY. THESE PROBLEMS SHOULD NOT BE OCCURRING AFTER 4.5 YEARS OF DRIVING. I BELIEVE THAT MINI PRODUCES FAULTY CARS THAT DO NOT LAST, HAVE ABSOLUTELY ZERO RELIABILITY, AND THEN CHARGES AN EXORBITANT AMOUNT TO FIX SOMETHING THAT SHOULD HAVE NOT BEEN BROKEN IN THE FIRST PLACE. *TR

Mileage: 51,000

KNOWN ISSUES: TIMING CHAIN AND INTAKE VALVES. ENGINE LIGHT CAME ON AT APPROX 40,000 MILES. DEALERSHIP DIAGNOSED 2 ISSUES THAT SEEM TO BE KNOWN RECURRING ISSUES FOR THIS MAKE/MODEL: CARBONIZED INTAKE VALVES REQUIRING CLEANING, AND REPLACE TIMING CHAIN. THIS BILL WILL COST OVER $2600. SEVERAL COMPLAINTS HAVE APPEARED FOR INTAKE VALUE BUILDUP AND ALSO FOR THE TIMING CHAIN ISSUES. INTERNET SEARCHES SHOW THIS AS A COMMON ISSUE AND ALSO A KNOWN ISSUE BY BMW MINI. THIS SHOULD HAVE BEEN A RECALL AS THEY KNOWINGLY SOLD THESE DEFECTED CARS IN 2009. WITH ONLY 40K MILES TO DATE, I PLAN TO KEEP THIS CAR FOR AT LEAST 4 MORE YEARS. MAY NOT BE POSSIBLE WITH BILLS LIKE THIS ONE. *TR

FIRE DID NOT OCCUR, BUT THERE IS A RISK. MANY MINI COOPER MODELS WITH TURBOCHARGERS ARE EXPERIENCING A LEAKY OIL FEED LINE TO THE TURBO AFTER APPROXIMATELY 25,000 MILES. DUE TO A POORLY INSULATED RUBBER GASKET. IT IS A MANUFACTURING FLAW, BUT MINI HAS FAILED TO ACKNOWLEDGE THE ISSUE. THIS IS A FIRE RISK. THE OIL IS ALLOWED TO LEAK INTO THE ENGINE BAY, AND IT CAN DESTROY THE ENGINE BECAUSE MINI COOPERS DO NOT HAVE AN OIL SENSOR. *TR

Mileage: 33,000

WAS TOLD BY MECHANIC AT DEALERSHIP TIMING CHAIN TENSIONER HAD BEEN REPLACED WHILE IN FOR SERVICE IN PAST BUT NOW IT NEEDS REPLACED ANOTHER EMPLOYEE 2 DAYS LATER SAYS NO RECORD OF IT. I NEED TO PAY FULL AMOUNT. TOO EARLY FOR TIMING CHAIN REPLACEMENT TO BE REQUIRED IN A DECENT CAR. DEFECT. NEEDS RECALL. *TR

Mileage: 46,230

I STARTED THE CAR AND A LOUD RATTLING NOISE CAME FROM THE ENGINE. I DROVE ABOUT 5 MILES AND THE OIL CHECK LIGHT CAME ON. I DECIDED TO TAKE IT TO A JIFFY LUBE THAT WAS WITHIN 2 MILES AND THEN THE ENGINE LIGHT CAME ON. BY THE TIME I GOT TO JIFFY LUBE THE CAR DIDN'T HAVE ANY OIL LEFT. THE CAR WAS SERVICED BY THE MINI DEALER ONLY 4 MONTHS PRIOR. HAD THE CAR TOWED 1 1/2 HOURS TO THE NEAREST MINI DEALER. MOST OF THE DAMAGE WAS CAUSED BY THE TIMING TENSIONER CHAIN. THE DEALER SAID MINI WOULD COVER THOSE REPAIRS BUT THE TURBO OIL FEED LINE WAS LEAKING TOO AND I WOULD HAVE TO PAY FOR THAT. IT COST ME $900.00. I ASKED IF THE CAR HAD A HEAT ON IT AND HE SAID NO BUT THAT I DON'T REALLY NEED ONE. I THOUGHT THERE HAD BEEN A SERVICE BULLETIN PUT OUT SPECIFICALLY BECAUSE OF THE HEAT FROM THE TURBO CAUSING THIS ISSUE BUT HE SAID IT HAD NOTHING TO DO WITH IT. *TR

Mileage: 30,000

FUEL LEAK A/P MINI SERVICE; NOT COVERED BY EXTENDED WARRANTY; AFTER EXTENSIVE RESEARCH ADVISED SERVICE REPRESENTATIVE OF THE REPORTED DESIGN FLAW IN CRIMP DEVICE HOLDING OIL LINE CONNECTING TO TURBO. ADVISED BY INDEPENDENT MECHANIC TURBO UNIT DEFECTIVE, NEEDS REPLACEMENT. MINI OF FAIRFIELD RETURNED VEHICLE IN AN UNSAFE MANNER WITH STRIPPED BOLTS AND IMPROPER PLACEMENT OF OIL PAN. AFTER CALLING BMW OF NORTH AMERICA MINI OF FAIRFIELD DECIDED TO CHANGE OIL LINES WITHOUT CHANGING TURBO UNIT. ON DRIVING VEHICLE NOTICED SMOKE COMING FROM HOOD; VEHICLE REVVING IN PARK, AND A METALLIC SOUND COMING FROM UNDER VEHICLE; RETURNED TO MINI SERVICE AND AFTER FURTHER EVALUATION (DIAGNOSTIC FEE $100)I WAS ADVISED THAT CAR IS SAFE TO DRIVE; I TRIED 2 DIFFERENT MINI SERVICE DEPARTMENTS NEITHER WOULD REPLACE TURBO UNIT CONSIDERING THE FIRE HAZARD AS REPORTED. *TR

Mileage: 47,000

CHECK ENGINE LIGHT CAME ON....EXCESSIVE CARBON BUILD UP. HAPPENED AGAIN AT 68K MILES .... *TR

Mileage: 31,059

I PURCHASED THIS CAR WITH 24K MILES ON IT. IT NOW HAS A LITTLE OVER 28K MILES. IT HAS BEEN STARTING AND RUNNING JUST FINE, UNTIL THE WEATHER TURNED COLDER. NOW IF THE CAR SITS OUTSIDE FOR A FEW HOURS WITH THE TEMP BELOW ABOUT 45 DEGREES, THE ENGINE RATTLES AND SOUNDS HORRIBLE WHEN I FIRST START IT. THIS IS A VERY LOUD RATTLE COMING FROM THE PASSENGER SIDE OF THE ENGINE. THE NOISE IS SO BAD THAT I AM AFRAID TO DRIVE THE CAR UNTIL IT WARMS UP AND THE SOUND GOES AWAY. AFTER A LITTLE RESEARCH ONLINE, I AM SHOCKED TO SEE HOW MANY PEOPLE HAVE THIS PROBLEM AND THAT IT IS THE TIMING CHAIN TENSIONER AND GUIDE SYSTEM. I WISH I HAD RESEARCHED THESE CARS BEFORE MAKING A PURCHASE BECAUSE NOW I OWN AN EXPENSIVE PROBLEM. *TR

Mileage: 28,000

TIMING CHAIN BROKE..I WAS DRIVING ON THE ROAD ON MY WAY HOME COMING TO A STOP SIGN SLOWING MY SPEED LUCKILY TO MAKE A LEFT TURN WHEN I HEARD AN AWFUL NOISE COMING FROM THE ENGINE. I TRIED MAKING MY LEFT TURN WHEN THE LIGHT TURNED GREEN AND IT STARTED SPUTTERING VERY SLOWLY MOVING. I MADE IT HOME SPUTTERING..LUCKILY WAS CLOSE TO HOME OTHERWISE I WOULD HAD TO HAVE IT TOWED. AFTER SOME LONG AND FRUSTRATING TROUBLESHOOTING FROM A NICE NEIGHBOR, HE FOUND OUT THAT THE TIMING CHAIN HAD BROKEN CAUSING SEVERAL OTHER PROBLEMS. HE ALSO FOUND OUT THAT IT HAD VERY LITTLE OR NO OIL. WHICH I HAD NO INDICATION FROM THE CAR COMPUTER THAT IT WAS EVEN LOW. THIS MAY HAVE CONTRIBUTED TO THE TIMING CHAIN PROBLEM BUT AGAIN I HAD NO CAR INDICATION. IT WILL COST ME AT LEAST $7000.00 FOR COST AND LABOR TO FIX SINCE IT IS NOT UNDER WARRANTY OR NOT EVEN SURE IF IT'S COVERED...THIS IS MY 3RD MINI..FIRST ONE WAS A LEASED ONE AND I UPGRADED TO A MINI S WHEN THE LEASE WAS OVER AND LEASED ANOTHER ONE. I BOUGHT THIS ONE WHEN THE SECOND LEASE WAS OVER..EVER SINCE I BOUGHT THIS ONE..I HAVE HAD SO MANY PROBLEMS WITH THE ENGINE. EVERYTHING IS DOCUMENTED ON HOW MANY TIMES I HAVE TAKEN IT IN...SO VERY DISAPPOINTED WITH THIS ONE!!!! *TR

Mileage: 63,931

TOTAL LOSS OF POWER AS I WAS CROSSING A MAJOR HIGHWAY, CAR TOWED TO LOCAL BMW CERTIFIED MECHANIC, SHOWS TIMING CHAIN MISFIRE, NEEDS TOTAL REPLACEMENT WITH MULTIPLE COMPONENTS NEEDING REPLACED DUE TO TIMING CHAIN PROBLEM. 3300$ WORTH OF DAMAGE TO ENGINE. APPARENT PROBLEM WITH TIMING CHAIN ON THOUSANDS OF MINI COOPER AND THEY HAVE NOT CALLED A RECALL ON THE PIECE. THIS WAS ALMOST A MAJOR ACCIDENT FOR ME AND IS CAUSING ME THOUSANDS OF DOLLARS TO REPLACE AND MAJOR INCONVENIENCE. *TR

Mileage: 86,000

UPON STARTUP OF THE ENGINE, THERE IS A LOUD NOISE COMING FROM THE ENGINE. A VERY UNHEALTHY SOUND. SOUND IS UNUSUAL FOR ANY GAS ENGINE, LET ALONE ONE WITH ONLY 57,000 MILES. *JS SEARCHED THE INTERNET FOR OTHER MINI COOPERS EXPERIENCING THIS PROBLEM. MANY COMPLAINTS ALL OVER THE INTERNET FOR EXACTLY THIS PROBLEM. MANY OWNERS REPORTING EARLY ENGINE FAILURE, AS EARLY AS 12,000 MILES REPORTED BY A MINI DEALER IN MAINE. MOST OWNERS ARE SEEING THE PROBLEM WITH 40-50,000+ MILES. THE LOCAL MINI DEALER SAYS THE REPAIR IS NOT COVERED BY WARRANTY, AND REPAIRS ARE APPROX. $2,000. TIMING CHAINS USUALLY DO NOT NEED REPLACEMENT EVEN AFTER 100,000 OF USE, SOME CARS NEVER REPLACE TIMING CHAINS UNTIL 200,000 MILES. THIS CAR SEEMS TO EAT TIMING CHAINS AROUND 40-50,000 MILES.

Mileage: 57,010

STARTED TO HEAR A KNOCKING NOISE COMING FROM THE ENGINE COMPARTMENT. ISSUE WITH THE TIME CHAIN. SO BENT OUT OF SHAPE THAT THE CHAIN ALMOST BROKE. I HAVE ALWAYS KEPT ON TOP OF CHANGING MY OIL AND GETTING MY CAR SERVICED EVERYTIME IT NEED IT SO I DON'T UNDERSTAND WHY THIS WOULD EVEN HAPPEN. WHEN RESEARCHING MY PROBLEM I SAW THAT ITS EXTREMELY COMMON FOR MODELS SINCE 2007+ TO EXPERIENCE THIS. THIS NEEDS TO BE RECALLED. THERE'S NO REASON FOR A OWNER TO HAVE TO PAY 200-2000 DOLLARS WHEN THEY HAVE DONE EVERYTHING RIGHT WITH SERVICING AND OIL CHANGES ETC. IM JUST GLAD I WASN'T ON THE HIGHWAY WHEN THIS HAPPENED TO ME BECAUSE HAVING YOUR ENGINE BELT BREAK IN A BUSY HIGHWAY DOESN'T SOUND SAFE. *TR

Mileage: 35,100

THIRD COMPLAINT AND COUNTING..... I WENT TO START MY MINI, ONLY TO NOTICE IT WAS LEAKING OIL HEAVILY UNDER MY CAR. I BROUGHT IT TO MY REPAIR SHOP WHO TOLD ME IT MIGHT BE THE O RING. THEY REPLACED IT AND TOLD ME TO BRING IT BACK A WEEK LATER. I RETURNED FRIDAY JULY 19TH TO HAVE THEM LOOK UNDER THE HOOD. THERE WAS OIL EVERYWHERE. ALL OVER THE ENGINE. THE SEAL WAS FINE! IT TURNS OUT THE VACUUM PUMP NEEDS TO BE REPLACED AND POSSIBLY THE TIMING CHAIN AT A LATER DATE. THE COST FOR THE PUMP AND LABOR IS $574.00. SO FAR I HAVE SPENT ALMOST $4000.00 ON REPAIRS. I DON'T HAVE AN ESTIMATE FOR THE TIMING CHAIN, I CAN ONLY IMAGINE. I ONLY BOUGHT MY MINI IN FEBRUARY AT 49K MILES AND SHE'S BEEN IN THE SHOP LONGER THAN SHE'S BEEN DRIVEN. I DON'T KNOW WHAT TO DO ANY MORE AND WISH THAT BMW/MINI WOULD ACKNOWLEDGE THAT ALL R56 ENGINES ARE DEFECTIVE. IF I KNOWN I WOULD HAVE BOUGHT ANOTHER BETTER RELIABLE CAR THAN A MINI AND THAT IS COMING FROM A PERSON WHO LOVES MY MINI. *TR

Mileage: 55,177

THIS IS THE SECOND COMPLAINT I'VE MADE WITHIN SIX MONTHS OF PURCHASE: I WAS DRIVING ALONG THE HIGHWAY AT 70MPH WHEN THE REDUCE SPEED ENGINE LIGHT CAME ON. BEFORE I HAD A CHANCE TO REDUCE SPEED THE CAR CAME TO A COMPLETE STOP ON THE FAST LANE OF THE HIGHWAY. THE CAR BEHIND ME SWERVED AS I MANAGED TO RESTART MY 2009 MINI COOPER S AND PULL INTO THE SLOW LANE. I MANAGED TO AVOID COLLISION AND PLACED HAZARDS ON. I GOT MY MINI TO BRADY'S AUTO REPAIR. THE MECHANIC TOLD ME THAT THE LOSS OF ENGINE POWER WAS DUE TO TURBOCHARGE FAILURE ON AN ORIGINAL MINI PART. HE SAID THAT BMW DONE A RECALL FOR THE SAME PART WHICH IS IN THE 2009 MINI COOPER S AND COULDN'T FIGURE OUT WHY THEY HADN'T DONE IT FOR MINI. THE TURBOCHARGE WAS COMPLETELY REPLACED ON MY MINI AT THE EXPENSE OF $2778.47. I CONTACTED MINI WHICH STATED THAT THERE IS NO RECOURSE AND NOTHING THEY CAN DO. I'M RESPONSIBLE FOR THE REPAIR. I AM NOT HAPPY WITH THIS AT ALL AS I HAD MY TWO CHILDREN IN THE MINI WHEN THIS INCIDENT HAPPENED AND IT COULD HAVE LEAD TO LOSS OF LIFE IF THE DRIVER BEHIND ME HADN'T TAKEN ACTION. I HOPE THE NHTSA DOES INVESTIGATE THIS MATTER IN ALL MINI COOPERS. *TR

Mileage: 55,008

FIRST NOTICED THE RATTLE WHILE DRIVING THE CAR. EVERYTIME SUBSEQUENTLY AFTER THAT WHENEVER I TURNED THE CAR ON I WOULD HEAR A LOUD RATTLING NOISE UNDER THE HOOD. CAR IS A 2009 MINI COOPER S WITH 38,005 MILES ON IT. TIMING CHAIN AND ASSEMBLY NEEDS TO BE REPLACED. DEALERSHIP QUOTED ME $5,000 TO REPAIR. THE CAR WAS JUST OUT OF WARRANTY AND MINI USA DIDN'T WANT TO HELP OUT WITH REPAIR COST. SEEMS LIKE A LOTS OF THESE FAIRLY NEW CARS HAVE THIS ISSUE. DEALERSHIP THAT QUOTED ME SAID THEY HAD 5 THEY WERE WORKING ON JUST THIS WEEK. THEY EXPECTED MINI TO ISSUE A RECALL BUT WERE SURPRISED THEY HADN'T. GUYS IN THE PARTS DEPARTMENT WERE ALL TO FAMILIAR WITH ALL THE PARTS THAT WERE REQUIRED TO FIX THE PROBLEM. THEY HAD THEM READILY ACCESSIBLE AND EXPRESSED THEIR SYMPATHY OF HAVING TO PAY $$ TO FIX WHAT UNQUESTIONABLY IS A MANUFACTURE DEFECT. PLEASE HELP US GIVE MINI A FRIENDLY NUDGE INTO ISSUING THIS RECALL. *TR

Mileage: 37,970

TURBO OIL FEEDLINE / PIPE FAILURE, RESULTING IN LEAK, POSSIBLY DUE TO EXCESSIVE HEAT. *TR

Mileage: 51,000

THE TIMING CHAIN HAS AN ISSUE AND RATTLES REALLY LAUD. THIS IS CAUSING ISSUES WITH THE VEHICLES IDLE AND SPEED DURING DRIVING. *TR

Mileage: 30,000

MINI RELEASED A SERVICE BULLETIN (CAMPAIGN: SIM 11 02 12) REGARDING FAULTY TIMING CHAIN TENSIONER. AT APPX. 40K MILES, MY COOPER S WAS TAKEN IN FOR SERVICE AND IT WAS REPORTED THERE WAS A "RATTLE" IN THE FRONT OF THE ENGINE. THE DEALERSHIP REPLACED THE TENSIONER UNDER WARRANTY. NOW THE SAME ISSUE HAS OCCURRED. I AM BEING TOLD THE ENTIRE TIMING CHAIN ASSEMBLY NEEDS REPLACEMENT AT AN APPROXIMATE COST OF $3K. MINI HAS OFFERED TO PAY 1/2 THE COST. THERE IS NO EXPLANATION WHY THE REPAIR IS NOT COVERED UNDER 2 YEAR REPLACEMENT TENSIONER WARRANTY; SINCE THIS ORIGINAL ISSUE WAS ONLY PARTLY ADDRESSED WHILE IN 50K CAR WARRANTY. MY MINI NOW HAS 77K. ONCE WARRANTY REQUEST IS SUBMITTED FROM DEALER TO MINI CORPORATE, DECISION IS FINAL. THERE IS NO APPEAL. FAILURE TO PERFORM SERVICE WILL RESULT IN ENGINE FAILURE IN NEAR FUTURE. *TR

Mileage: 77,000

TL* THE CONTACT OWNS A 2009 MINI COOPER S. THE CONTACT STATED THAT WHILE PARKED, THE ENGINE FAN FAILED TO DEACTIVATE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 12V008000 (ENGINE AND ENGINE COOLING). THE APPROXIMATE FAILURE MILEAGE WAS 49,000.

Mileage: 49,000

TL* THE CONTACT OWNS A 2009 MINI COOPER S. THE CONTACT STATED THAT SHE NOTICED THE ENGINE HAD A LEAK. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION AND THEY STATED THE WATER PUMP AND THE TURBO CHARGER NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 75,000.

Mileage: 75,000

12/14/12: I DROVE HOME FROM WORK. I HAD NO PROBLEMS DRIVING, BUT HEARD A BIT OF A COLD START KNOCK. 12/15/12: CAR DIDN'T START IN THE MORNING. I IMMEDIATELY GOT THE CAR TOWED TO HERB CHAMBERS IN BOSTON, WHERE I HAD EXCLUSIVELY TAKEN IT TO EVERY MAINTENANCE CHECK-UP AND ISSUE I HAD SINCE I PURCHASED IT NEW AT THE SAME LOCATION, EVEN AFTER MY WARRANTY HAD EXPIRED. 12/16/12: HERB CHAMBERS PERFORMED A DIAGNOSIS FOR $135, AND SAID THAT THE TIMING CHAIN WAS BROKEN, WHICH WOULD COST $2,500 TO FIX. HOWEVER, THEY ALSO SAID THAT OTHER ENGINE PARTS MAY BE BROKEN, BUT THEY WOULDN'T KNOW UNTIL THEY STARTED WORKING ON THE TIMING CHAIN. AS YOU CAN SEE, I WAS NOT HAPPY AT ALL WITH THIS INCONCLUSIVE DIAGNOSIS. DO I PAY $2,500 FOR THEM TO THEN TELL ME IT ACTUALLY NEEDS A NEW ENGINE FOR CLOSE TO $10,000, OR DO I TOW IT ELSEWHERE? 12/17/12: TOWED CAR TO GERMAN PERFORMANCE SERVICE FOR A MORE COMPLETE DIAGNOSIS, WHICH SHOWED THAT THE TIMING CHAIN AND TENSIONER WERE BROKEN, AS WELL AS MOST VALVES AND OTHER ENGINE PARTS. WE CONCLUDE THAT IT IS CHEAPER TO REPLACE THE ENTIRE ENGINE ($3,213 + $1,980 OF LABOR = $5,193) THAN TO FIX EVERYTHING INDIVIDUALLY, WHICH WOULD BE MORE LABOR INTENSIVE. 12/21/12: I CONTACTED MINI USA TO INFORM THEM ABOUT MY SITUATION AND HOW UNPLEASED I WAS WITH HERB CHAMBER'S EXTREMELY VAGUE DIAGNOSIS, AS WELL AS MINI'S MAJOR TIMING CHAIN FLAW. MINI USA COMPLETELY IGNORED MY REQUEST FOR THE SOLE REASON THAT I TOOK MY CAR TO A 3RD PARTY MECHANIC. THEY SAID THAT IF I HAD STAYED AT THE DEALER (EVEN THOUGH THEY GAVE ME AN INCOMPLETE DIAGNOSIS), THAT THEY MAY HAVE HELPED ME OUT. 12/30/12: I CONTACTED HERB CHAMBERS BOSTON WITH THE SAME CONCERNS. THEY UNDERSTOOD MY POINTS, BUT SAID THAT UNFORTUNATELY THEY CANNOT FORCE THE MANUFACTURER TO DO ANYTHING THEY DO NOT WANT TO DO. AS A SMALL GESTURE, THEY DID GIVE ME BACK WHAT THEY CHARGED ME FOR THEIR INITIAL DIAGNOSIS ($135). *TR

Mileage: 63,963

TURBO OIL LINES LEAKING OIL. NO CHECK ENGINE LIGHT HAS BEING ACTIVATED. *TR

Mileage: 81,000

VEHICLE WAS TAKEN TO DEALERSHIP IN FEB 2012 FOR A RATTLING NOISE. SERVICE CENTER AT BRAMAN MIAMI SAID THAT THEY COULD NOT DUPLICATE THE NOISE, SO IT WAS ASSUMED THEY FOUND NOTHING WRONG WITH THE VEHICLE. PRIOR TO THIS, THE VEHICLE HAD BEEN IN THE SHOP 2-3 TIMES DUE ENGINE MALFUNCTION LIGHT, ROUGH IDLE AT COLD START AND LOSS OF TURBO POWER DUE TO LEAKAGE IN TURBO OIL FEED LINES. THIS WAS REPAIRED IN EARLY 2012/LATE 2011. IN DECEMBER OF 2012, WHILE DRIVING THE RATTLING NOISE OF THE COMPLAINT IN FEB 2012 INTENSIFIED AND OIL LIGHT ILLUMINATED WHILE DRIVING. CAR WAS PULLED OVER TO SAFE LOCATION. ONCE CAR WAS STOPPED, THE ENGINE MALFUNCTION LIGHT ALSO ILLUMINATED. DRIVER CHECKED OIL LEVEL, WHICH APPEARED LOW BUT WITHIN THE MARKS ON THE DIPSTICK. OIL SPLATTER WAS OBSERVED ON THE HOOD AND ON ENGINE. RUBBER GASKET FEEDING TO ENGINE WAS OBSERVED TO BE DISPLACED WHERE OIL APPEARED TO HAVE LEAKED OUT. VEHICLE WAS TOWED TO BRAMAN MIAMI. SERVICE DEPARTMENT REPORTED THAT FAILURE WAS CAUSED BY TIMING CHAIN/TENSIONER ISSUE. SERVICE DEPT IS CHARGING 17K USD FOR REPAIRS AS IT IS NOT FOUND TO BE UNDER THE SCOPE OF WARRANTY OF PREVIOUS REPAIRS TO THE TURBO OIL FEED LINES. MINI HAS BEEN CONTACTED TO SEE IF ANY RELIEF CAN BE PROVIDED AS THIS SEEMS TO BE A COMMON ISSUE WITH THESE VEHICLES. *TR

Mileage: 62,100

DRIVING VEHICLE HEARD SOME ENGINE NOISE AND OBSERVED RED OIL INDICATOR CAME ON. PULLED OVER AND CHECKED OIL LEVEL, APPEARED TO BE LOW.. I IMMEDIATELY PUT IN TWO QUARTS OF OIL ONLY TO SEE IT ALL SEEP OUT AND THROUGH BOTH FRONT WHEEL WELLS. APPEARED TO BE AN ISSUE WITH THE TIMING CHAIN TENSIONER. *TR

Mileage: 53,328

THE TIMING TENSIONER ON MY MINI COOPER S BACKED OUT, RESULTING IN A MASSIVE OIL LOSS WHILE AT HIGHWAY SPEEDS. THIS IS APPARENTLY A KNOWN ISSUE BY MINI, BUT NO KNOWN RECALL HAS BEEN ISSUED AT THIS POINT. *TR

Mileage: 52,000

WATER PUMP FOR TURBOCHARGER REPLACED IN MAY (RECALL) AND TURBOCHARGER WARRANTY EXTENDED VIA MINI OF AMERICA LETTER. TURBOCHARGER FAILED IN AUGUST, BUT MINI OF AUSTIN BLAMED FAILURE ON LACK OF OIL CHANGES. ALL OIL CHANGES PERFORMED BY THAT DEALERSHIP WHENEVER THE CAR TOLD US IT WAS DUE. CRAPPY RESPONSE FROM MINI OF AMERICA AS WELL. *TR

Mileage: 68,500

PURCHASED USED VEHICLE IN JUNE 2012. ON TODAYS DATE, UPON COLD START VEHICLE BEGAN MAKING KNOCKING NOISES AS IF LIFTERS WERE INVOLVED. AS CAR WARMED UP NOISE BECAME LESS APPARENT, BUT PROMPTED ME TO TAKE TO LOCAL MECHANIC. MECHANIC ADVISED THAT TIMING CHAIN NEEDS ADJUSTING/REPLACING AND NEEDS TO GO TO DEALER (AN HOUR TRAVEL). UPON PERUSING WEB INFO ON VEHICLE AND YEAR, THIS ISSUE APPEARS TO BE A PREVALENT MAFUNCTION IN THIS VEHICLE CAUSING MAJOR ENGINE FAILURE. *TR

Mileage: 43,709

TIMING BELT FAILURE DUE TO RESTRICTOR BELT DEFECT. *TR

Mileage: 57,120