2002 MINI COOPER Problems & Recalls

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer...

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer...

I purchased the vehicle used with airbag light showing on the speedometer gauge cluster. Searched with vin for recalls but showed 0 unrepaired recalls. Tried clearing the light with my Launch CREADER BMW V2 scan tool. Light flashes a few times and goes away but immediately appears on the speedometer...

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't h...

Driverside headlight assembly flickers everytime when you turn the key to position 1 with selector on off or auto. Flickers multiple times but doesn'tturn on unless I cycle the key on off until headlight does. This annoyance would reoccur the very next morning. Passenger headlight assembly doesn't h...

Unoccupied passenger side airbags; all front & backseat bags deployed after passenger side tires hit pothole on road. Pieces of interior, including decorative plastic, interior light covers were projected across cabin & hit me. I had no idea what had happened. Car shut off shortly after incident. It...

MY MINI COOPER NEEDS RECALL WORK DONE. I AM IN BILLINGS, MT AND 392 MILES FROM THE CLOSEST CERTIFIED PLACE TO GET IT REPAIRED. I CAN'T TRAVEL THAT FAR IN A 2002 VEHICLE WITH HIGH MILES DURING A PANDEMIC. I AM A SENIOR CITIZEN AND HAVE ISSUES THAT DO NOT ALLOW ME TO TRAVEL THAT FAR. I AM STUCK WITH A...

SO I BOUGHT A 2002 MINI COOPER LESS THAN A YEAR AGO AND IT CURRENTLY HAS 74K MILES AND ATTEMPTING TO PULL INTO A PARKING SPOT AT THE GROCERY MY STEERING GOES COMPLETELY OUT WHILE I WAS TRYING TO TURN INTO MY SPOT AND RIPPED OFF A BLACK MOLDING THAT GOES OVER THE FRONT PASSENGER WHEEL AND A SIGNIFICA...

Mileage: 75,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 50 MPH, THE STEERING WHEEL SEIZED AND THE POWER STEERING WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS ABLE TO COAST TO THE SIDE OF THE ROAD. THE CONTACT POWERED OFF AND RESTARTED THE VEHICLE, AND WAS ABLE TO DRIVE NORMALLY. THE C...

Mileage: 120,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WATER WAS ENTERING THE VEHICLE FROM THE SUN ROOF, WHICH CAUSED THE COMPUTER IN THE VEHICLE TO GET MOIST AND NOT OPERATE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE SUN ROOF RUBBER CONNECTOR NEEDED TO BE REPAIRED....

Mileage: 118,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 15 MPH OUT OF A PARKING LOT, THE VEHICLE MADE A LEFT TURN AND THE GEAR SHIFTER FAILED. IN ADDITION, THE GEAR SHIFTER CABLE DETACHED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR ...

AT 140,000 MILE: + AIR BAG LIGHT CAME ON. DEALER SAID THAT THE AIRBAG COMPUTER MODULE WILL COST $1,000 TO REPLACE. I SEE ON-LINE BLOGS AND NHTSA HAVE HAD NUMEROUS COMPLAINTS ON THE AIR BAG DASH LIGHT COMING ON AND NHTSA IS STILL INVESTIGATING.

Mileage: 140,000

ABS DASH LIGHT AND BREAK LIGHT SUDDENLY CAME ON. IN ADDITION TO THE AIR BAG LIGHT THAT SUDDENLY CAME ON, THE DEALER SAID THE COMPUTER MODULE FOR THE ABS WILL COST $1,000 (IN ADDITION TO THE AIRBAG MODULE OF $1.000). I SEE ON INTERNET BLOGS AND NHTSA THAT THIS IS A COMMON INCIDENT TOTAL AIR BA...

Mileage: 140,000

THE DASH LOW TIRE AIR LIGHT SUDDENLY CAME ON; IT COMES ON AFTER DRIVING FOR ABOUT 5 MINUETS. I'VE CHECKED ALL TIRES AND THEY ARE IN COMPLIANCE. I SEE THAT ON-LINE BLOGS THIS IS A MAJOR ISSUE

Mileage: 140,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE OPERATING THE VEHICLE, THE POWER STEERING WOULD SUDDENLY MALFUNCTION CAUSING THE STEERING WHEEL TO BECOME VERY DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSED THAT THE POWER STEERING PUMP HAD OVER HEATED CAUS...

Mileage: 30,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURE...

Mileage: 118,457

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING VARIOUS SPEEDS, THE ENGINE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE ELECTRONIC LEARNING MODULE AND THE PYRAMID WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT SEVERAL COMPONENTS WERE REPLACED DUE TO MANUFACTURE...

Mileage: 118,457

THE VEHICLE WAS PURCHASED USED IN 2011, SOON THERE AFTER THE AIR BAG LIGHT CAME ON, IT WAS TAKEN TO A LOCAL REPAIR SHOP AND THE AIR BAG LIGHT WAS RESET, I WAS ADVISED BY THE SHOP OWNER THAT THIS IS A COMMON PROBLEM IN THE OLDER MINI. HE ALSO ADVISED THAT IT IS EXTREMELY EXPENSIVE, AS MINI USA BASIC...

Mileage: 98,000

DRIVING CAR NORMALLY WHEN POWER STEERING WENT OUT CAUSING A GREAT DEAL OF LOSS OF VEHICLE CONTROL, MAKING TURNING VERY DIFFICULT. ENDED UP SWERVING INTO OTHER LANE, FORTUNATELY NO CARS WERE IN THE LANE AT THE TIME. HAD TO RE-START VEHICLE TO GAIN STEERING BACK. HAS HAPPENED NUMEROUS TIMES SINCE THIS...

Mileage: 126,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE TRANSMISSION FAILED ON THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER FOR SERVICE AND STATED THAT THE TRANSMISSION WAS FAILING. THE VEHICLE WAS NOT REPAIRED. WHILE DRIVING HOME, THE TRANSMISSION SEIZED. THE VEHICLE WAS THEN TOWED...

Mileage: 136,000

POWER STEERING PUMP IS VERY LOUD WHEN TURNING THE VEHICLE. CAN BE VERY HARD TO TURN WHEEL AT TIMES AND SOMETIMES THE POWER STEERING HAS CUT OUT WHILE DRIVING. MINI HAS A RECALL BUT WONT FIX FOR ME. *JS

Mileage: 80,346

EVER SINCE BUYING THIS CAR USED IN JANUARY OF 2012, THE SRS WARNING LIGHT HAS BEEN ON. THE CAR STORE WE BOUGHT THE VEHICLE FROM DID CANCEL THE CODE WHEN WE DISCOVERED IT WAS ON AFTER PURCHASE. HOWEVER, THE CODE CAME BACK. WE BROUGHT IT TO BE FIXED, AND I BELIEVE SOMEONE ELIMINATED THE COUPLER UND...

Mileage: 100,000

WHILE DRIVING MY MINI COOPER ON A MAJOR ROAD IN HEAVY TRAFFIC MY MINI COOPER EXPERIENCED A COMPLETE LOSS OF POWER TO THE WHEELS (SUDDEN TRANSMISSION FAILURE). MY ONLY OPTION TO AVOID BEING REAR-ENDED WAS TO STEER THE CAR OFF THE ROAD ( WITH THE REMAINING FORWARD MOMENTUM INTO A FAST FOOD PARKING LOT...

Mileage: 120,000

2002 MINI COOPER, MANUAL TRANSMISSION. LOW MILEAGE, ONLY 22,000 MILES ON IT. WHILE DRIVING IS CITY TRAFFIC, THE TRANSMISSION FAILED TO ENGAGE WHEN I SHIFTED INTO 1ST AND LIFTED THE CLUTCH TRYING TO START FROM A RED LIGHT. THERE WAS A SMALL "SPUTTER" AND THEN THE CAR COULD NOT BE DRIVEN. I WAS AB...

Mileage: 22,000

WHILE DRIVING EAST ON SHERIDAN DR. IN THE TOWN OF TONAWANDA, I EXPERIENCED A COMPLETE FAILURE OF THE POWER STEERING. I WRESTLED WITH THE CAR FOR THE REST OF THE DAY, AND WHEN I GOT HOME, I HEARD THAT THE POWER STEERING COOLING FAN WAS RUNNING CONTINUOUSLY, EVEN THOUGH THE CAR WAS SHUT OFF IN THE DR...

Mileage: 92,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 5 MPH, THE POWER STEERING ASSIST FAILED AND CAUSED THE VEHICLE TO BECOME DIFFICULT TO OPERATE. THE VEHICLE WAS NOT TAKEN TO A DEALER OR AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT NOTIFIED ABOUT THE FAILURE. THE FAI...

Mileage: 107,000

I HAVE 2002 MINI COOPER ORIGINAL OWNER AND I HAD WINDSHELD, TRANSMISSION REPLACED. MAIN ISSUE I STILL HAVE IS STREERING LOOSE POWER. I GOT A LETTER FROM MINI SAID IT EXTENDED WARRANTY NOT A RECALL. MINI CO. NEVER RECALL ANY ISSUES. CALL DEALER FOR THIS STREERING PROBLEM BUT MY 2002 MINI IS NOT UNDER...

I WAS EXITING FROM 35TH STREET IN NEWPORT NEWS, VA ONTO THE WARWICK BLVD OFF RAMP IN TRAFFIC, COASTING WITH THE BRAKES AT ABOUT 5 MPH, WHEN I WAS REAR ENDED BY A NAVY OPERATED FLAT NOSE SCHOOL BUS, WHICH FORCED MY VEHICLE INTO A LATE MODEL CHEVY TRAILBLAZER. MY AIR BAGS (FRONT AND SIDE) DID NOT DEPL...

Mileage: 200,350

I WAS EXITING FROM 35TH STREET IN NEWPORT NEWS, VA ONTO THE WARWICK BLVD OFF RAMP IN TRAFFIC, COASTING WITH THE BRAKES AT ABOUT 5 MPH, WHEN I WAS REAR ENDED BY A NAVY OPERATED FLAT NOSE SCHOOL BUS, WHICH FORCED MY VEHICLE INTO A LATE MODEL CHEVY TRAILBLAZER. MY AIR BAGS (FRONT AND SIDE) DID NOT DEPL...

Mileage: 200,350

I WAS EXITING FROM 35TH STREET IN NEWPORT NEWS, VA ONTO THE WARWICK BLVD OFF RAMP IN TRAFFIC, COASTING WITH THE BRAKES AT ABOUT 5 MPH, WHEN I WAS REAR ENDED BY A NAVY OPERATED FLAT NOSE SCHOOL BUS, WHICH FORCED MY VEHICLE INTO A LATE MODEL CHEVY TRAILBLAZER. MY AIR BAGS (FRONT AND SIDE) DID NOT DEPL...

Mileage: 200,350

THE POWER STEERING PUMP FAILED IN MY 2002 MINI COOPER FOR THE SECOND TIME. FIRST TIME IT HAPPENED WAS IN 2011 AND I GOT A NEW PUMP AND HAD IT PROFESSIONALLY INSTALLED. TODAY, 08/26/2013 MY SECOND POWER STEERING PUMP FAILED. THIS IS A KNOWN ISSUE WITH THIS VEHICLE AND THERE HAS NOT BEEN A RECALL. ...

Mileage: 106,000

THE CAR HAS GONE BACK TO A MINI DEALER 4 TIMES SINCE WE'VE OWNED THE CAR BECAUSE OF THE AIR BAG LIGHT ON. LITTLE DID WE REALIZE WHEN WE TOOK IT ON A TRIP TO FLORIDA, THE WHOLE SYSTEM WAS SHUT DOWN. TOOK IT TO A MINI DEALER IN FLA. ON FEB. 15, 2012.....$2126.04 LATER. DROVE IT HOME TO HAVE THE LIGHT ...

Mileage: 73,420

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, THE VEHICLE BECAME EXTREMELY DIFFICULT TO STEER. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS BUT NO CAUSE FOR THE FAILURE WAS IDENTIFIED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FA...

Mileage: 130,000

I WAS ON THE FREEWAY WHEN MY POWER STEERING FAILED AND I NEARLY CRASHED WHILE TRYING TO CHANGE LANES AND EXIT THE FREEWAY. *TR

Mileage: 109,235

POWER STEERING FROZE UP CAR COULD NOT BE STEERED IN ANY DIRECTION. *TR

Mileage: 41,225

I WAS TRYING TO GET ONTO AN OFF RAMP AND WHEN I WAS INTO THE TURN I ALMOST RAN INTO A CONCRETE BARRIER BECAUSE THE WHOLE STEERING WHEEL LOCKED UP. THE STEERING WHEEL ALWAYS LOCKS UP SOMETIMES IT WITH A FEW MILES AND OTHERS IT IS GOOD UNTIL IT LOCKS UP. VERY DANGEROUS. *TR

Mileage: 123,000

AFTER A SHORT TRIP, I HAD JUST PARKED THE MINI. FORTUNATELY, IT WAS OUTDOORS AND WITHIN 50FT OF MY TOOL CHEST. ON TURNING OFF THE IGNITION AND REMOVING THE KEY, I NOTICED AN UNUSUAL NOISE; THE [ELECTRIC] POWER STEERING PUMP CONTINUED TO RUN. A FEW SECONDS LATER, SMOKE APPEARED. I RACED TO MY TOO...

Mileage: 123,400

AFTER A SHORT TRIP, I HAD JUST PARKED THE MINI. FORTUNATELY, IT WAS OUTDOORS AND WITHIN 50FT OF MY TOOL CHEST. ON TURNING OFF THE IGNITION AND REMOVING THE KEY, I NOTICED AN UNUSUAL NOISE; THE [ELECTRIC] POWER STEERING PUMP CONTINUED TO RUN. A FEW SECONDS LATER, SMOKE APPEARED. I RACED TO MY TOO...

Mileage: 123,400

POWER STEERING FAILS- CAR LOSES ALL POWER ASSISTED STEERING PUPM CONTINUES TO RUN AFTER ENGINE SHUT OFF, POSSIBLE FIRE RESULT. *TR

Mileage: 48,900

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STARTED THE IGNITION AND SHIFTED INTO REVERSE HOWEVER, THE GEAR SHIFTER FAILED TO MOVE OUT OF REVERSE AFTER SEVERAL ATTEMPTS. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHO ADVISED THAT THE SHIFT CABLE WAS DETACHED FROM THE TRANSMISSION SHIFT L...

Mileage: 148,200

I TURNED THE SEAT HEATER ON AND IT MELTED A HOLE IN THE LEATHER SEAT AND THE FOAM PADDING STARTED TO BURN. *TR

Mileage: 135,000

I TURNED THE SEAT HEATER ON AND IT MELTED A HOLE IN THE LEATHER SEAT AND THE FOAM PADDING STARTED TO BURN. *TR

Mileage: 135,000

MY POWER STEERING FAN CONTINUES TO RUN EVEN AFTER THE CARE IS TURNED OFF. IT COMPLETELY DRAINED MY BATTERY SO I REPLACED THE BATTERY. TWO WEEKS LATER THE SAME THING HAPPENED AND I LEARNED THAT MY POWER STEERING PUMP AND FAN ARE DEFECTIVE. ALSO INTERMITTENT LOSS OF POWER STEERING WHILE DRIVING AND NE...

Mileage: 86,156

MY POWER STEERING FAN CONTINUES TO RUN EVEN AFTER THE CARE IS TURNED OFF. IT COMPLETELY DRAINED MY BATTERY SO I REPLACED THE BATTERY. TWO WEEKS LATER THE SAME THING HAPPENED AND I LEARNED THAT MY POWER STEERING PUMP AND FAN ARE DEFECTIVE. ALSO INTERMITTENT LOSS OF POWER STEERING WHILE DRIVING AND NE...

Mileage: 86,156

MY POWER STEERING FAN CONTINUES TO RUN EVEN AFTER THE CARE IS TURNED OFF. IT COMPLETELY DRAINED MY BATTERY SO I REPLACED THE BATTERY. TWO WEEKS LATER THE SAME THING HAPPENED AND I LEARNED THAT MY POWER STEERING PUMP AND FAN ARE DEFECTIVE. ALSO INTERMITTENT LOSS OF POWER STEERING WHILE DRIVING AND NE...

Mileage: 86,156

TL* THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 20 MPH THE STEERING WHEEL BECAME DIFFICULT TO MANEUVER. THE CONTACT WAS ABLE TO PARK THE VEHICLE BUT STATED THAT THE POWER STEERING HAD BECOME INOPERABLE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE ...

Mileage: 45,065

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT WAS TRAVELING 20 MPH WHEN THE POWER STEERING ASSIST FAILED. THE VEHICLE WAS NOT TAKEN TO DEALER FOR INSPECTION AND THE MANUFACTURER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGES WERE 66,000.

Mileage: 66,000

FAULTY POWER STEERING PUMP CAUSING A LOSS OF COMPLETE CONTROL OF THE VEHICLE. 80,000+ INCIDENTS REPORTED WITH THIS MAKE/MODEL OF VEHICLE WITH THE KNOWLEDGE OF VEHICLE MANUFACTURER. THE PUMP HAS SINCE BEEN RE-MANUFACTURED TO FIX THE ISSUES BUT MINI OF NORTH AMERICA REFUSES TO ISSUE A RECALL FOR THE S...

Mileage: 120,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT WAS DRIVING 20 MPH WHEN THE STEERING ASSIST FAILED. THE DEALER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE STEERING RACK, POWER STEERING PUMP AND THE FAN MIGHT HAVE TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILE...

Mileage: 102,000

THE AIRBAG LIGHT WAS ON IN MY MINI. THERE WAS A RECALL ON THE CABLE TENSIONER, BUT ON MODELS OF 2003 AND ABOVE. I AM WANTING YOU TO RECONSIDER THE YEAR OF THIS RECALL TO INCLUDE 2002. I NEEDED TO REPLACE THE REP CABE F SEAT SIDE AIRBAG, REP CABLE BEL TENSIONER, CABLE STRAP, CABLE CONNECTOR, SHRINKIN...

Mileage: 121,000

MY WIFE HAS BEEN COMPLAINING OF INTERMITTENT LOSS OF POWER ASSIST. I DRIVE HER CAR VERY LITTLE HOWEVER I RECENTLY HAD THE PROBLEM HAPPEN TO ME. ONE OF MY HOBBIES IS SPORT CAR RACING (MOST RECENTLY AT SUMMIT POINT RACEWAY IN WV) SO I DO EXPECT THE UNEXPECTED HOWEVER IT IS SO INTERMITTENT IT IS OFTEN ...

Mileage: 48,000

MY WIFE HAS BEEN COMPLAINING OF INTERMITTENT LOSS OF POWER ASSIST. I DRIVE HER CAR VERY LITTLE HOWEVER I RECENTLY HAD THE PROBLEM HAPPEN TO ME. ONE OF MY HOBBIES IS SPORT CAR RACING (MOST RECENTLY AT SUMMIT POINT RACEWAY IN WV) SO I DO EXPECT THE UNEXPECTED HOWEVER IT IS SO INTERMITTENT IT IS OFTEN ...

Mileage: 48,000

I WAS DRIVING ALONG AND LOST THE POWER STEERING. IT WAS VERY DIFFICULT TO STEER. I GOT HOME PARKED THE CAR AND LET IT GO. THE NEXT MORNING IT WAS FINE. HOWEVER, THIS MORNING, 6/8/2012, IT HAPPENED AGAIN AS I WAS TURNING IN AN INTERSECTION. FORTUNATELY FOR ME THERE WEREN'T MANY CARS ON THE ROA...

Mileage: 89,000

WHILE DRIVING STEERING BECAME STIFF. ALMOST UNABLE TO TURN WHEEL WHEN I SLOWED TO PARK. AFTER TURNING CAR OFF AND BACK ON, PROBLEM RESOLVED. STILL HAPPENS AT LEAST ONCE PER DAY USUALLY WHILE SLOWING OR DOWNSHIFTING. ALWAYS RESOLVES AFTER RESTARTING CAR. *TT

Mileage: 88,670

POWER STEERING PUMP STOPPED FUNCTIONING MAKING CAR UNSAFE TO DRIVE. *TR

Mileage: 39,087

I WAS DRIVING THE CAR IN LACEY WA. SMOKE STARTED ISSUING FROM THE CAR. I IMMEDIATELY PULLED INTO A PARKING LOT. I OPENED THE HOOD AND SMOKE WAS ISSUING FORTH. AFTER 5 MINUTES, I SPOTTED FLAMES. I HAD A SMALL FIRE EXTINGUISHER BUT IT WAS INSUFFICIENT TO PUT OUT THE FLAMES. A PASSING MOTORIST AR...

Mileage: 60,500

COMPLETE LOSS OF POWER STEERING WHILE IN ONCOMING TRAFFIC LANE DURING OVERTAKING ON TWO LANE ROAD. STEERING REQUIRED AN EXTREME AMOUNT OF EFFORT. BARELY MANAGED TO MOVE BACK TO RIGHT HAND LAND BEFORE GETTING DANGEROUSLY CLOSE TO ONCOMING TRAFFIC. POWER STEERING DID NOT RECOVER FOR ANOTHER 2.5 MIN...

Mileage: 73,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRANSMISSION HESITATED IN A JERKING MOTION AND BEGAN TO DOWN-SHIFT INTO ANOTHER GEAR CONTINUOUSLY. IN ADDITION, THE ENGINE WARNING INDICATOR AND EP CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE V...

Mileage: 56,416

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 50 MPH, THE TRANSMISSION HESITATED IN A JERKING MOTION AND BEGAN TO DOWN-SHIFT INTO ANOTHER GEAR CONTINUOUSLY. IN ADDITION, THE ENGINE WARNING INDICATOR AND EP CODE ILLUMINATED ON THE INSTRUMENT PANEL. THE V...

Mileage: 56,416

POWER STEERING FAILED WHILE CAR WAS BEING DRIVEN. LUCKILY THE CAR WAS AT LOW SPEED AT THE TIME AND I WAS ABLE TO GET TO A SAFE STOP BY USING BRUTE FORCE TO STEER THE CAR. POWER STEERING THAN REAPPEARED INTERMITTENTLY OVER THE NEXT FEW DAYS, FINALLY FAILING COMPLETELY. MECHANIC SAYS POWER STEERING...

Mileage: 58,000

I WOULD LIKE TO REPORT A POWER STEERING FAILURE ON MY PREGNANT WIFE'S 2002 MINI COOPER. THE CAR ONLY HAS 61K MILES ON IT. SHE WAS DRIVING LAST NIGHT, IN THE RAIN, AND THE POWER STEERING PUMP WENT OUR AS SHE WAS ON A FREEWAY TRANSITION RAMP AT A SPEED OF 40-50 MPH. SHE ALMOST LOST CONTROL OF THE V...

Mileage: 61,000

WHEN I LEFT MY HOME I TURNED ON THE HEATED SEATS. AS I TRAVELED APPROXIMATELY A HALF MILE I FELT LIKE BOTTOM SEAT WAS EXCEPTIONALLY HOT AND TURNED THE BOTTOM OFF . SHORTLY THEREAFTER I SMELLED SMOKE AND FOUND THAT A HOLE HAD BURNED THROUGH THE SEAT BEHIND MY BACK. THERE WAS SMOKE, A HOLE ABOUT THE S...

Mileage: 52,060

POWER STEERING FAILURE--THE POWER STEERING IN MY MINI COOPER S 2002 BEGAN "CUTTING OUT" AND BECAME MORE FREQUENT OVER A FEW DAYS. THE "CUTTING OUT" HAPPENS WITHOUT WARNING AND IS POTENTIALLY QUITE DANGEROUS AS THE VEHICLE BECOMES ALMOST UNMANAGEABLE WHEN MAKING A TURN. THIS MAKES DRIVING THE VEHICLE...

Mileage: 118,000

POWER STEERING FAILURE--THE POWER STEERING IN MY MINI COOPER S 2002 BEGAN "CUTTING OUT" AND BECAME MORE FREQUENT OVER A FEW DAYS. THE "CUTTING OUT" HAPPENS WITHOUT WARNING AND IS POTENTIALLY QUITE DANGEROUS AS THE VEHICLE BECOMES ALMOST UNMANAGEABLE WHEN MAKING A TURN. THIS MAKES DRIVING THE VEHICLE...

Mileage: 118,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE POWER STEERING PUMP CONTINUED TO RUN WHILE THE ENGINE WAS TURNED OFF. THE VEHICLE WAS NOT TAKEN TO THE DEALER NOR REPAIRED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 49,000.

Mileage: 49,000

BOUGHT THIS CAR IN 2008 AND HAVE HAD VERY FEW ISSUES. THIS MONTH (NOVEMBER 2011) THE CVT (AUTOMATIC TRANSMISSION) WENT OUT. ONLY REPAIR APPARENTLY IS "REPLACEMENT" - RECEIVING QUOTES BETWEEN 7K AND 9K FROM THE DEALER AND AAMCO. NOW FINDING OUT THIS IS A VERY COMMON PROBLEM WITH ALL MINI COOPER CVT'S...

Mileage: 132,000

POWER STEERING FAILURE. THIS OCCURS INTERMITTENTLY. MOST RECENTLY, LAST WEEK, IT WAS OUT FOR 3 DAYS AND THEN IT STARTED WORKING AGAIN. *TR

Mileage: 106,871

THE POWER STEERING FAILED WHEN DRIVING. IT BECAME IMPOSSIBLE TO STEER. IT WAS AS THOUGH THE CAR STEERING BECAME LOCKED. I WAS VERY LUCKY TO HAVE A POLICE CAR STOP TO ASSIST ME TO MOVE ME TO A SAFE SPOT ON THE STREET. *TR

Mileage: 45,000

POWER STEERING FAILED WHILE GOING DOWN A MULTI-STORY PARKING LOT. VERY SCARY. CAR CORRECTED ITSELF. LATER THAT DAY IT HAPPENED AGAIN. CALLED MY MECHANIC (A MINI MECHANIC) AND WAS TOLD THIS HAPPENS ALL THE TIME WITH 2002-2005 MINI COOPERS. WILL NEED TO REPLACE PUMP AND FAN WHICH WILL COST ME $1200 IN...

Mileage: 78,000

TL*THE CONTACT OWNS A 2002 BMW MINI COOPER. THE CONTACT STATED THE STEERING FAILED WHILE DRIVING AT A LOW SPEED AND HAD TO BE HELD WITH FORCE WITH BOTH HANDS IN ORDER TO TURN IT, OR KEEP THE VEHICLE UNDER CONTROL. THERE WERE NO WARNING LIGHTS BEFORE OR AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAK...

Mileage: 114,000

TL*THE CONTACT OWNS A 2002 BMW MINI COOPER. THE CONTACT STATED THE STEERING FAILED WHILE DRIVING AT A LOW SPEED AND HAD TO BE HELD WITH FORCE WITH BOTH HANDS IN ORDER TO TURN IT, OR KEEP THE VEHICLE UNDER CONTROL. THERE WERE NO WARNING LIGHTS BEFORE OR AFTER THE FAILURE OCCURRED. THE VEHICLE WAS TAK...

Mileage: 114,000

I WAS DRIVING FROM EAST LOS ANGELES TO WEST LOS ANGELES (PLAYA DEL RAY) ON THE 105 WEST HGWY WHEN THE CARS TRANSMISSION WENT OUT. THIS HAPPENED IN THE MIDDLE OF THE FREEWAY IN LA DURING RUSH HOUR. I HAD TO SLOWLY MOVE OVER TO THE RIGHT HAND SIDE OF THE HIGHWAY UNTIL I COULD FIND AN AREA WITH A SHOUL...

POWER SYSTEM ON MY 2002 MINI COOPER WENT OUT. THIS SEEMS TO BE A COMMON OCCURRENCE. AND VERY DANGEROUS AND COSTLY. BMW HAD BETTER DO SOMETHING ABOUT THIS BECAUSE I ALMOST CREAMED A COP... *TR

Mileage: 150,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE HEADLIGHTS AND CABIN LIGHTS WOULD REMAIN ILLUMINATED AFTER THE VEHICLE WAS SHUT OFF. IN ADDITION, THE CONTACT STATED THAT HE WOULD OFTEN BECOME LOCKED INSIDE OR OUTSIDE OF THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A...

Mileage: 60,000

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE HEADLIGHTS AND CABIN LIGHTS WOULD REMAIN ILLUMINATED AFTER THE VEHICLE WAS SHUT OFF. IN ADDITION, THE CONTACT STATED THAT HE WOULD OFTEN BECOME LOCKED INSIDE OR OUTSIDE OF THE VEHICLE INTERMITTENTLY. THE VEHICLE WAS INSPECTED BY A...

Mileage: 60,000

TL* THE CONTACT OWNS A 2002 MINI COOPERS. THE CONTACT WAS DRIVING 40 MPH WHEN THE POWER STEERING FAILED. THE VEHICLE WAS TOWED TO A MECHANIC SHOP WHERE THEY INFORMED HIM THAT THE FUSE THAT CONTROLLED THE POWER STEERING CHARGING SYSTEM HAD BLOWN. THE COMPONENT WAS REPLACED AT A THE CONTACTS EXPENSE. ...

Mileage: 36,000

I ALWAYS MAINTAINED MY 2002 MINI COOPER AND AT 80K MILES THE TRANSMISSION BLEW UP JUST BEFORE I WAS TO ENTER A VERY BUSY FREEWAY IN LOS ANGELES, DOWNTOWN AREA. THERE WAS PLENTY OF OIL IN THE TRANSMISSION. I WAS TOLD IT WAS NOT A FAULT OF MY CARE AFTER THE MECHANIC LOOKED AT IT UPON TOW IN. IT JUST S...

Mileage: 80,000

I ALWAYS MAINTAINED MY 2002 MINI COOPER AND AT 80K MILES THE TRANSMISSION BLEW UP JUST BEFORE I WAS TO ENTER A VERY BUSY FREEWAY IN LOS ANGELES, DOWNTOWN AREA. THERE WAS PLENTY OF OIL IN THE TRANSMISSION. I WAS TOLD IT WAS NOT A FAULT OF MY CARE AFTER THE MECHANIC LOOKED AT IT UPON TOW IN. IT JUST S...

Mileage: 80,000

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO MAKE A LEFT OR RIGHT TURN THE STEERING WHEEL WAS DIFFICULT TO TURN. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND THE CURRENT MILEAGE WAS 82,4...

Mileage: 84,426

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING APPROXIMATELY 25 MPH AND ATTEMPTING TO MAKE A LEFT OR RIGHT TURN THE STEERING WHEEL WAS DIFFICULT TO TURN. THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WILL BE TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE FAILURE AND THE CURRENT MILEAGE WAS 82,4...

Mileage: 84,426

I BOUGHT A 2002 MINI COOPER AND WHILE DRIVING THE POWER STERERING QUIT WORKING. I CONTACTED A MINI REPAIR SHOP AND FOUND THAT THE POWER STEERING PUMP IS ELECTRIC AND IT'S RELAY OR OR ONE FOR IT'S COOLING FAN MIGHT HAVE FAILED. THEY TOLD ME THAT IT IS VERY COMMON AND WOULD COST OVER $1000. TO FIX IT....

Mileage: 59,957

POWER STEERING FAILURE ON MY 2002 R50 MINI COOPER. THE POWER STEERING WOULD ACT UP THE PREVIOUS COUPLE OE WEEKS BY THEN RESUME AS IF EVERYTHING WAS FINE. THEN PRIOR TO FIRST OF THE YEAR, IT JUST WENT OUT TOTALLY. *TR

Mileage: 120,000

I DRIVE A 2002 MINI COOPER AND AT 9:50AM THIS MORNING I DROVE MY CAR ABOUT A MILE TO MY OPTOMETRIST APPOINTMENT AND ALL WAS WELL WITH MY POWER STEERING. I WAS THERE FOR 45 MINUTES, LEFT, AND GOT IN MY CAR PULLED OUT OF MY SPOT WITH NO TROUBLE AT ALL, BUT ABOUT 20 FEET AWAY FROM MY PARKING SPOT I WE...

Mileage: 116,469

TL* THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT WAS ILLUMINATED AND THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE AND THE VEHICLE WAS NOT REPAIRED. THE VEHICLE WAS THEN TAKEN TO A LOCAL REPAIR SHOP WHERE THE AI...

Mileage: 50,000

MY 2002 MINI COOPER'S POWER STEERING FAILED SILENTLY AS I DROVE HOME FROM WORK A WEEK AGO, THOUGH WAS FINE AFTER RESTARTING THE CAR. SINCE THEN, IT HAS STARTED FAILING CONSISTENTLY. THIS LEADS TO VERY DANGEROUS DRIVING CONDITIONS BECAUSE I HAVE NO IDEA HOW HARD I WILL HAVE TO TURN ON THE WHEEL FOR A...

Mileage: 36,000

2002 MINI COOPER POWER STEERING FAILURE AFTER POWER STEERING PUMP REPLACED. THE CAR HAD NO POWER STEERING WITHIN 700 MILES OF HAVING THE POWER STEERING PUMP AND PUMP FAN REPLACED AND NOW AM TOLD IT IS THE POWER STEERING PUMP CABLE. *TR

Mileage: 13,500

RECENT NEWS REPORTS ALERTED ME ABOUT THE INVESTIGATION INTO MINI POWER STEERING FAILURES IN 2004-05 MINI COOPERS. I AM WRITING TO REPORT THAT A FEW YEARS AGO, I EXPERIENCED INTERMITTENT POWER STEERING FAILURE IN MY 2002 MINI COOPER (AT ABOUT 70K) MAKING STEERING VERY DIFFICULT. BECAUSE THE PROBLEM W...

Mileage: 70,000

POWER STEERING IN MY 2002 MINI COOPER FAILED. STEERING VEHICLE BECAME VERY DIFFICULT WITH LITTLE ABILITY TO TURN VEHICLE. REPAIR REQUIRED A NEW ELEC. STG PUMP AND COOLING FAN ($602) PLUS LABOR OF $384 FOR A TOTAL OF $986. *TR

Mileage: 32,421

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 2 MPH, THERE WAS A LOSS OF POWER STEERING WHICH CAUSED DIFFICULTY IN TURNING THE STEERING WHEEL. THE ENGINE WAS TURNED OFF AND RESTARTED. THE VEHICLE WAS ABLE TO CONTINUE IN OPERATION. THE FAILURE OCCURRED FOUR DIFFE...

Mileage: 98,500

JUST DRIVING ALONG AND CAR BEGAN TO SPUTTER, AND THEN TRANSMISSION LET GO. ENGINE REVVED, BUT THE GEARS WERE GONE. NO FORWARD OR REVERSE. NOTHING. *TR

Mileage: 93,101

TL*THE CONTACT OWNS A 2002 MINI COOPER S. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 10 MPH AND THE POWER STEERING FAILED. HE STATED THAT THE POWER STEERING FAILURE OCCURRED NO MATTER THE SPEED AND HAS OCCURRED AT OTHER SPEED LEVELS. HE CALLED THE DEALERSHIP AND WAS TOLD THAT THEY WOULD ...

Mileage: 67,000

SUDDEN FAILURE OF THE MANUAL 5 SPEED TRANSMISSION CAUSING CAR TO COME TO A SUDDEN STOP IN AN INTERSECTION, ENDANGERING THE DRIVER AND BLOCKING TRAFFIC. SOMETHING INTERNAL FAILS IN THE TRANSMISSION, CAR COMES TO T SUDDEN STOP, CANT BE PUSHED AS THE WHEELS LOCK UP AND MUST BE TOWED FROM THE ROAD. APPE...

Mileage: 80,000

1. NORMAL AROUND TOWN DRIVING. PASSENGER REAR LOWER CONTROL ARM SNAPPED ... STEEL FAILED UNDER STRESS ONE OF SEVERAL MANUFACTURE HOLES PUNCHED INTO THE MEMBER. 2. CAUSED THE VEHICLE TO BECOME INOPERABLE. 3. REQUIRED REPLACEMENT CONTROL ARM. BMW HAS SINCE RE-ENGINEERED THE CONTROL ARM. RE...

Mileage: 68,000

2002 MINI COOPER, POWER STEERING PUMP SHORTED OUT CAUSING A SMALL FIRE WHICH DESTROYED THE PUMP,FAN,WIRING HARNESS,POWER STEERING LINE. CAR HAD LESS THAN 50,000 MILES ON IT. COST OF REPAIR OVER 1200 DOLLARS. *TR

Mileage: 49,989

2002 MINI COOPER. POWER STEERING QUIT (MY WIFE DRIVING AND BY HERSELF) IN A TURN WITH ONCOMING TRAFFIC. NO INJURIES BUT VERY CLOSE. *TR

Mileage: 43,000

TL*THE CONTACT OWNS A 2002 MINI COOPER. THE VEHICLE SHUT OFF WHILE DRIVING APPROXIMATELY 25 MPH. THERE WERE NO WARNINGS PRIOR TO THE TRANSMISSION FAILURE. THE CONTACT FEELS THAT THIS IS A SERIOUS SAFETY ISSUE BECAUSE A CRASH COULD HAVE OCCURRED. THE FAILURE MILEAGE WAS 63,000.

Mileage: 63,000

I HAVE A 2002 MINI COOPER, I PURCHASED NEW. I HAVE HAD AN ONGOING PROBLEM SINCE IT WAS UNDER WARRANTY. MY AIR BAG WARNING LIGHT COMES ON. I HAVE HAD IT BACK TO THE DEALER AT LEAST 20+ TIMES FOR THE SAME PROBLEM. THEY STILL CAN NOT SEEM TO GET A PERMANENT FIX FOR THIS(NEXT APPOINTMENT JULY 9, 2009)....

Mileage: 85,000

I DROVE MY 2002 MINI COOPER APPROXIMATELY 6 MILES TO DROP OFF A FRIEND WHO WAS VISITING FROM OUT OF TOWN. I WAS HELPING MY FRIEND REMOVE HIS SUITCASE AND STANDING TO THE PASSENGER SIDE REAR OF THE CAR WHEN MY LEG MADE CONTACT WITH THE TAILPIPE CAUSING ABOUT A 2 INCH CRESCENT SHAPED BURN. THE TAILPI...

Mileage: 15,201

2002 MINI COOPER POWER STEERING HYDRAULIC ASSIST FAILS WITHOUT WARNING MAKING CAR DIFFICULT TO STEER. FAILURE IS INTERMITTENT AND MAY OCCUR ON THE HIGHWAY OR ON SURFACE ROADS. IN EITHER CASE THERE IS ABSOLUTELY NO WARNING. *TR

TRANSMISSION WHINING NOISE EVENTUALLY LEADING TO TRANSMISSION FAILURE. MINI IS AWARE OF THIS PROBLEM WITH CVT TRANSMISSIONS AND REFUSES TO ADMIT FAULT. VERY COMMON PROBLEM OCCURRING IN MOST 2002 VEHICLES WITH ONLY 40,000-60,000 MILES ON THEM. COST IS 7000 TO REPLACE. MINI DOES NOT OFFER REPAIR O...

Mileage: 67,700

TRANSMISSION BEARINGS FAILURE AFTER 82,000 MILES. NO BEARINGS KIT REPLACEMENT OFFERED. *TR

Mileage: 82,000

DRIVER'S SIDE AUTOMATIC WINDOW DOES NOT WORK; WILL BE REPLACING WINDOW MOTOR. *TR

Mileage: 65,000

PURCHASED A USED 2002 MINI COOPER ABOUT 3 1/2 YRS AGO W/ ABOUT 12K MILES. AT AROUND 15-17K MILES THE TRANSMISSION BASICALLY EXPLODED WHILE I WAS ON THE HIGHWAY. I WAS TOLD THAT THERE WAS A CRACK IN THE TRANSMISSION. MINI REPLACED IT WITH I'M GUESSING A REBUILT TRANSMISSION. AT THE TIME OF THE REPAIR...

Mileage: 60,000

PURCHASED A USED 2002 MINI COOPER ABOUT 3 1/2 YRS AGO W/ ABOUT 12K MILES. AT AROUND 15-17K MILES THE TRANSMISSION BASICALLY EXPLODED WHILE I WAS ON THE HIGHWAY. I WAS TOLD THAT THERE WAS A CRACK IN THE TRANSMISSION. MINI REPLACED IT WITH I'M GUESSING A REBUILT TRANSMISSION. AT THE TIME OF THE REPAIR...

Mileage: 60,000

MY 2002 MINI COOPER ELECTROHYDRAULIC POWER STEERING (EHPS) PUMP WILL NOT SHUT OFF CAUSING ASSOCIATED WIRING TO BECOME DANGEROUSLY HOT (SMELLS LIKE AN ELECTRICAL FIRE). THIS IS A COMMON PROBLEM WITH THE MINI COOPER AND THERE NEEDS TO BE A RECALL. I AM TRYING TO FIGURE OUT HOW TO KEEP MY MINI FROM C...

Mileage: 82,000

ABRUPT FAILURE OF THE POWER STEERING SYSTEM IN A 2002 MINI COOPER. *TR

Mileage: 51,000

BACK IN FEB 2008 THE STEERING ON MY 2002 MINI COOPER JUST WENT OUT WITH NO WARNING. I WAS LEFT WITHOUT POWER STEERING IN THE MIDDLE OF THE 101 FREEWAY, WHICH IS VERY DANGEROUS! I FIXED THE PROBLEM, WHICH WAS VERY EXPENSIVE AS IT WAS THE ENTIRE STEERING SYSTEM THAT FAILED AND FILED A COMPLAINT WITH M...

Mileage: 60,000

BACK IN FEB 2008 THE STEERING ON MY 2002 MINI COOPER JUST WENT OUT WITH NO WARNING. I WAS LEFT WITHOUT POWER STEERING IN THE MIDDLE OF THE 101 FREEWAY, WHICH IS VERY DANGEROUS! I FIXED THE PROBLEM, WHICH WAS VERY EXPENSIVE AS IT WAS THE ENTIRE STEERING SYSTEM THAT FAILED AND FILED A COMPLAINT WITH M...

Mileage: 60,000

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

Mileage: 62,000

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

Mileage: 62,000

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

Mileage: 62,000

CLUTCH AND CABLES FAIL AT 100 000KM. RATTLING NOISE AT START UP. VERY LOUD HUMMING NOISE COMING FROM THE STEERING. TRANSMISSION GONE AT 103 000KM. *TR

Mileage: 62,000

THE WARRANTY ON MY 2002 MINI COOPER RAN OUT AT 50K MILES. AT 53K MILES THE TRANSMISSION FAILED AND HAD TO BE REPLACED WITH A REBUILT TRANSMISSION FROM MINI. THE TOTAL COST OF THE REPAIR WAS $4,200. I HAVE BEEN IN CONTACT WITH MANY OTHER PEOPLE WHO ARE SUFFERING THE SAME FATE BECAUSE MINI WILL NO...

Mileage: 53,000

THE AUTOMATIC TRANSMISSION OF MY 2002 MINI COOPER FAILED WHILE MY FRIEND WAS DRIVING MY CAR. SHE WAS ON A WINDING COASTAL ROAD AND THE CAR DIED ON A BLIND CURVE, PUTTING HER AT GREAT DANGER. FORTUNATELY NOBODY WAS HURT. THE CAR WAS TOWED TO THE SAN FRANCISCO BMW DEALERSHIP, WHERE I WAS INFORMED I NE...

Mileage: 43,191

I WAS DRIVING MY 2002 MINI ON THE FREEWAY AT 65 MPH AND I FELT A SUDDEN JOLTING AND SENSED A BACKWARD FORCE IMPEDING IT FROM GOING FORWARD. LUCKILY, IT WAS NIGHT TIME AND THERE WEREN'T MANY CARS, BECAUSE MY MINI STOPPED GOING FORWARD AND WAS MERELY RUNNING ON MOMENTUM. THE CAR GOT WORSE AND STARTED ...

Mileage: 98,901

BOTH PASSENGER AND DRIVER'S SIDE WINDOW MOTOR FAILURE (WITH WINDOW IN UP POSITION). PROBLEM WAS INTERMEDIATE OVER THE PAST THREE OR FOUR YEARS WITH FAILURE TWO OR THREE TIMES A YEAR. CURRENTLY DRIVER'S SIDE WINDOW HAS NOT WORKED FOR WEEKS. *TR

Mileage: 80,000

I AM THE SECOND OWNER (BOTH OLDER LADIES), OF A 2002 AUTOMATIC MINI COOPER WITH 46,000 MILES. YESTERDAY WHILE DRIVING HOME FROM WORK THE TRANNY FAILED. IT DOWNSHIFTED OR SOMETHING AND THE EP WARNING LIGHT CAME ON, WHICH MEANS TRANSMISSION FAILURE AND I WAS TWO FEET AWAY FROM BEING REAR ENDED! I COUL...

Mileage: 46,000

TRANSMISSION BLEW AT 34 THOUSAND MILES. *TR

Mileage: 34,000

THE AIRBAG LIGHT IN THE VEHICLE GOES ON, AND THE DEALER TOLD ME THAT NOTHING WAS WRONG, NOW THE AIRBAG LIGHT IS CONSTANTLY ON. *TR

Mileage: 53,000

CVT TRANSMISSION FAILED AFTER 32,000 MILES, NEEDING COSTLY REPLACEMENT. *TR

Mileage: 31,980

I RECENTLY HAD A 60K SERVICE ON MY 2002 MINI COOPER. A COUPLE DAYS LATER I DROVE FROM MONTEREY, CA TO LOS ANGELES, CA AND MY CAR WAS RUNNING FINE. ALL OF A SUDDEN OUT OF THE BLUE, MY POWER STEERING WENT OUT. I WAS DRIVING ON THE 101 FREEWAY AND COULD NOT TURN MY CAR. I WAS ABLE TO GET IT TO A REPAIR...

Mileage: 60,000

I WAS DRIVING MY 2002 MINI COOPER. I HAD DRIVEN 1/4 MILE AND THOUGHT I HEARD SOMETHING CRACK OR SPARK UNDER THE DASHBOARD ON THE PASSENGER SIDE OF THE VEHICLE. THEN I SAW SMOKE, PULLED OVER, GOT OUT, AND THE WHOLE CAR WENT UP IN FLAMES. *TR

Mileage: 42,000

POWER STEERING PUMP IS NOISY ALL THE TIME. I AM AFRAID THIS MAY LEAD TO FAILURE OF MY ABILITY TO STEER THE VEHICLE . THE CAR IS A 2002 MINI. *TR

Mileage: 126,800

THE POWER STEERING ON MY 2002 MINI COOPER S, 62,000 MILES, FAILS INTERMITTENTLY AND UNEXPECTEDLY WHILE DRIVING, CAUSING AN INSTANT AND UNEXPECTED LOSS OF POWER ASSISTED STEERING. THIS IS EXTREMELY DANGEROUS AND CAN CAUSE INJURY OR DEATH SHOULD LOSS OF POWER STEERING CAUSE THE DRIVER TO LOSE CONTROL ...

Mileage: 62,000

I HAVE A 2002 MINI COOPER WITH 52K MILES, THE TRANSMISSION HAS WENT OUT TWICE IN THE PAST 2 YEARS THE FIRST TIME AT 31K MILES. THE CLUTCH HAS ALSO WENT OUT AS WELL AS THE SUNROOF MOTOR, LEFT FRONT BRAKE CALIPER, WINDSHIELD WIPER MOTOR WITH A HOST OF SENSORS, GAUGES ETC... PARTS ARE IMPOSSIBLE TO GE...

Mileage: 56,344

I HAVE A 2002 MINI COOPER WITH 52K MILES, THE TRANSMISSION HAS WENT OUT TWICE IN THE PAST 2 YEARS THE FIRST TIME AT 31K MILES. THE CLUTCH HAS ALSO WENT OUT AS WELL AS THE SUNROOF MOTOR, LEFT FRONT BRAKE CALIPER, WINDSHIELD WIPER MOTOR WITH A HOST OF SENSORS, GAUGES ETC... PARTS ARE IMPOSSIBLE TO GE...

Mileage: 56,344

I HAVE A 2002 MINI COOPER WITH 52K MILES, THE TRANSMISSION HAS WENT OUT TWICE IN THE PAST 2 YEARS THE FIRST TIME AT 31K MILES. THE CLUTCH HAS ALSO WENT OUT AS WELL AS THE SUNROOF MOTOR, LEFT FRONT BRAKE CALIPER, WINDSHIELD WIPER MOTOR WITH A HOST OF SENSORS, GAUGES ETC... PARTS ARE IMPOSSIBLE TO GE...

Mileage: 56,344

I HAVE A 2002 MINI COOPER WITH 52K MILES, THE TRANSMISSION HAS WENT OUT TWICE IN THE PAST 2 YEARS THE FIRST TIME AT 31K MILES. THE CLUTCH HAS ALSO WENT OUT AS WELL AS THE SUNROOF MOTOR, LEFT FRONT BRAKE CALIPER, WINDSHIELD WIPER MOTOR WITH A HOST OF SENSORS, GAUGES ETC... PARTS ARE IMPOSSIBLE TO GE...

Mileage: 56,344

MY AUTOMATIC TRANSMISSION FAILED ON MY 2002 MINI COOPER RENDERING THE CAR WILL NOT START. THE DEALERSHIP WANTS $6000+ TO FIX THE TRANSMISSION. I HAD A SIMILAR ISSUE ABOUT 3 MONTHS AGO AND THEY JUST RESET THE CODE AND IT WORKED FINE. THEY SAID IF THEY TRIED RESETTING THE CODE AGAIN, THE CAR MAY JU...

Mileage: 122,000

I JUST FOUND THIS WEB SITE AND AFTER READING THROUGH THE VARIOUS ISSUES OTHER PEOPLE ARE HAVING WITH THEIR MINI, I DECIDED I SHOULD ALSO GO AHEAD AND SHARE MY ISSUES AS WELL. BACK IN APRIL OF 2004, I WAS HIT ON THE FRONT PASSENGER SIDE BY A HONDA ACCORD TRAVELING ABOUT 50 MILES AN HOUR AND MY AIRBA...

Mileage: 46,000

I JUST FOUND THIS WEB SITE AND AFTER READING THROUGH THE VARIOUS ISSUES OTHER PEOPLE ARE HAVING WITH THEIR MINI, I DECIDED I SHOULD ALSO GO AHEAD AND SHARE MY ISSUES AS WELL. BACK IN APRIL OF 2004, I WAS HIT ON THE FRONT PASSENGER SIDE BY A HONDA ACCORD TRAVELING ABOUT 50 MILES AN HOUR AND MY AIRBA...

Mileage: 46,000

CONSTANT GRINDING NOISE COMING FRONT MY FRONT BRAKES. HAD SENSORS REPLACED, FRONT AND REAR BRAKES REPLACED AND THE MASTER CYLINDER REPLACED AS WELL. STILL MAKING THE NOISE AND CAUSING EXTENDED BRAKING DISTANCE. FEELS EXTREMELY UNSAFE. *TR

Mileage: 110,000

I HAVE A 2002 MINI COOPER WITH A CVT AUTOMATIC TRANSMISSION. THE TRANSMISSION HAS FAILED. THE CARE HAS ABOUT 61,000 MILES. THE TRANSMISSION HAS TO BE REPLACED COSTING ME AT LEAST $6,000. *TR

2002 MINI COOPER WITH <55,000 MILES (SAME OWNER) THE SHIFT CABLE DETACHED FROM THE TRANSMISSION SHIFT LINKAGE WHILE I ATTEMPTED TO CHANGE GEARS. GEAR CHANGES ARE NO LONGER POSSIBLE AND THE TRANSMISSION REMAINS IN THE LAST GEAR SELECTED! PRIOR TO THIS -BUT WITHIN THE LAST 6 MONTHS, ALL THE WINDOW M...

2002 MINI COOPER WITH <55,000 MILES (SAME OWNER) THE SHIFT CABLE DETACHED FROM THE TRANSMISSION SHIFT LINKAGE WHILE I ATTEMPTED TO CHANGE GEARS. GEAR CHANGES ARE NO LONGER POSSIBLE AND THE TRANSMISSION REMAINS IN THE LAST GEAR SELECTED! PRIOR TO THIS -BUT WITHIN THE LAST 6 MONTHS, ALL THE WINDOW M...

2002 MINI COOPER WITH <55,000 MILES (SAME OWNER) THE SHIFT CABLE DETACHED FROM THE TRANSMISSION SHIFT LINKAGE WHILE I ATTEMPTED TO CHANGE GEARS. GEAR CHANGES ARE NO LONGER POSSIBLE AND THE TRANSMISSION REMAINS IN THE LAST GEAR SELECTED! PRIOR TO THIS -BUT WITHIN THE LAST 6 MONTHS, ALL THE WINDOW M...

AIR BAG LIGHT CAME ON AND STAYED ON. I TOOK IT TO THE DEALER, HE COULD NOT FIX THE PROBLEM. NOW I READ THAT THIS IS A COMMON PROBLEM WITH THE MINI. *TR

Mileage: 137,955

WE PURCHASED OUR 2002 MINI ON 10/10/06, W/55,059 MILES ON IT. 9 DAYS LATER THE CLUTCH WENT OUT, NOT COVERED BY EXTENDED WARRANTY THAT WE PURCHASED. WE TOWED IT BACK TO MINI SAN FRANCISCO SERVICE DEPT WHO INSISTED THAT WE WORE OUT THE CLUTCH AND IT WAS OUR PROBLEM, WEAR AND TEAR, ETC. ? AFTER 9 DAY...

Mileage: 67,829

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 60 MPH, THE CONTACT FELT A BUMP COMING FROM THE FRONT OF THE VEHICLE AND STATED THAT THE VEHICLE DROVE ROUGHLY. THE DEALER STATED THAT THE VEHICLE NEEDED A NEW TRANSMISSION. AS OF SEPTEMBER 6, 2007, THE DEALER HAD NOT REPAIRED THE VEHICLE. TH...

Mileage: 65,000

I RECENTLY WAS DRIVING HOME FROM SACRAMENTO WHEN MY CAR STOPPED DRIVING ON THE FREEWAY.... LUCKILY I WAS ABLE TO PULL OFF TO THE SIDE AND CALL FOR HELP... THE CAR WAS STILL RUNNING AND THE RPM'S WERE GOING UP, BUT WOULD NOT DRIVE OR REVERSE. I HAD NO IDEA WHAT THE PROBLEM WAS ESPECIALLY SINCE I HAD ...

Mileage: 59,000

TL*THE CONTACT OWNS A 2002 BMW MINI COOPER. WHILE DRIVING 35 MPH HE NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE, AS WELL AS PIECES OF BURNING PLASTIC FALLING FROM THE VEHICLE. HE ATTEMPTED TO APPLY THE BRAKES HOWEVER, THE VEHICLE WOULD NOT STOP. HE THEN NOTICED FLAMES COMING FROM THE ENGINE...

Mileage: 86,000

TL*THE CONTACT OWNS A 2002 MINI COOPER. WHILE DRIVING 65 MPH, THE SHIFT CABLE COMPLETELY DETACHED FROM THE MANUAL TRANSMISSION AND PREVENTING THE CONTACT FROM SHIFTING GEARS. THE VEHICLE WAS TOWED TO A TRANSMISSION SPECIALTY SHOP AND THEY RECONNECTED THE SHIFT CABLE. BMW STATED THAT THE VEHICLE W...

Mileage: 48,750

TL*THE CONTACT OWNS A 2002 MINI COOPER. THE CONTACT STATED THAT HER TRANSMISSION FAILED WHILE DRIVING 30 MPH. THE DEALER INFORMED HER THAT THERE IS WARRANTY EXPIRED THAT COVERED THE TRANSMISSION. THE VEHICLE HAS A CVT TRANSMISSION AND, ACCORDING TO THE NHTSA WEBSITE, THERE ARE MANY OTHERS WITH TH...

Mileage: 57,600

WHILE DRIVING HOME FROM WORK IN THE 2002 MINI COOPER THE CAR HAD ABOUT 70,000 MILLES ON IT AND I NOTICED THE TEMPERATURE GAUGE GOING UP, AND ASSUMED MY CAR WAS JUST OVERHEATING. I PULLED INTO A SERVICE STATION AND PUT SOME WATER IN THE COOLANT RESERVOIRAND THE TEMPERATURE GAUGE RETURNED TO NO...

Mileage: 70,000

TL* - THE CONTACT OWNS A 2002 MINI COOPER. THE DRIVER AND PASSENGER DOORS WOULD NOT OPEN IF THE VEHICLE WAS LOCKED WITH THE REMOTE. THE DEALER WAS CALLED AND AN ESTIMATE FOR THE REPAIR WAS GIVEN OVER THE PHONE. THE COMPONENT THAT NEEDED TO BE REPLACED WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGE...

Mileage: 18,500

DURING A 10-MINUTE COMMUTE TO WORK, MY RIGHT REAR CONTINENTAL CONTITOURING CONTACT CH95 (GRAND TOURING ALL-SEASON) 175/65HR15, PURCHASED AND INSTALLED ON 6/29/06, FAILED. THE TREAD PORTION SEPARATED FROM THE TIRE SIDES. THE SIDES REMAINED ATTACHED TO THE WHEEL RIM. THE TREAD, MINUS THE TIRE SIDES, S...

Mileage: 47,160

I PURCHASED A PRE-OWNED MINI COOPER WITH 34,000 MILES ON IT. 5-SPEED TRANSMISSION. SHORTLY AFTER PURCHASE, I NOTICED A "STUDDER/HESITATION" ON TAKE OFF FROM A DEAD STOP IN FIRST GEAR. THIS HAPPENED ABOUT A DOZEN TIMES. I TOOK IT TO MY MECHANIC TO DEMONSTRATE THE PROBLEM. ON THE TEST DRIVE, THE ...

Mileage: 35,000

POWER STEERING MOTOR FAILURE ON MINI COOPER. 1 - WHILE DRIVING, THE STEERING BECAME VERY DIFFICULT, AT TIMES ALMOST IMPOSSIBLE. 2 - ONCE HOME WHILE PARKING THE CAR, SMOKE STARTED TO BILLOW OUR FROM UNDER THE HOOD. TURNED OFF THE IGNITION, SMOKE CONTINUED TO BILLOW AND GET THICKER, OPENED THE HO...

Mileage: 60,000

WINDSHIELD WIPERS FAILED WHILE DRIVING IN RAIN. THE DEALER DIAGNOSED PROBLEM AS WIPER MOTOR FAILURE. I NOTICED THAT THE WIPER MOTOR WAS EXPOSED DIRECTLY TO THE WEATHER AND MOISTURE BECAUSE IT IS LOCATED DIRECTLY UNDERNEATH THE COWL INTAKE AND I FELT THAT WAS THE CAUSE OF THE FAILURE. IT'S EXPOSED TO...

Mileage: 56,800

2002 MINI COOPER CLUTCH AND TRANSMISSION FAILURE AT 68,000 MILES. NM

Mileage: 68,000

THIS IS A FOLLOW-ON TO INVESTIGATION PE05053 ORIGINALLY OPENED ON 09/27/2005. I TOO HAVE EXPERIENCED INTERMITTENT ILLUMINATION OF THE AIR BAG WARNING LAMP ON MY MY 2002 MINI COOPER. THE INCIDENTS OF INTERMITTENT AIRBAG WARNING LAMP ILLUMINATION STARTED ON 12 FEB 06 AND HAVE CONTINUED SINCE THAT TI...

Mileage: 53,289

TWO-CAR CRASH AT AN INTERSECTION - AIRBAGS IN 2002 MINI COOPER S FAILED TO DEPLOY. CAR 1 (2002 MINI COOPER S) WAS DRIVING WEST ON TOTTEN POND RD. IN WALTHAM, MA AT APPROX. 30 MPH, APPROACHING GREEN LIGHT AT INTERSECTION OF TOTTEN POND RD/WINTER ST AND WYMAN ST. CAR 2 (2001 CHEVY VAN) WAS TRAVELING...

Mileage: 65,000

AIRBAG LIGHT REMAINS LIT. WHILE STILL UNDER WARRANTY, I HAD THE DEALER (FLOW MINI, WINSTON-SALEM, NC) "RESET" IT ON AT LEAST TWO SEPARATE OCCASIONS. SERVICE EMPLOYEE TOLD ME THE LIT LIGHT WOULD NOT AFFECT AIRBAG DEPLOYMENT/SAFETY. WITHIN DAYS (MILES) OF "RESETTING" IT, THE LIGHT COMES BACK ON AND WI...

(1) EVENTS LEADING UP TO FAILURE - NORMAL WEAR AND TEAR, CAR DRIVEN 40K+ MILES (2) FAILURE & CONSEQUENCE - BOTH BEARINGS IN THE STEERING COLUMN BEGAN TO FAIL. DETAILS NOT EXACTLY AVAILABLE SINCE I DIDN'T HAVE THE OPPORTUNITY TO INSPECT THEM, BUT BEARINGS WOULD GRIND WHEN TURNING THE STEERING WHEEL...

Mileage: 40,000

THE SHIFT LINKAGE CAME DISCONNECTED FROM THE TRANSMISSION. I HAS UNABLE TO CHANGE GEARS. I LOOKED ON THE NHTSA SITE AND FOUND THAT THE CAR WAS RECALLED FOR THIS EXAC PROBLEM. I HAD ASKED THE DEALER ABOUT SUCH A RECALL SEVERAL YEARS AGO. THEY DENIED AND CONTINUE TO DENY THAT SUCH A RECALL EXISTS. AF...

Mileage: 23,800

DT: THE CONTACT OWNED A 2002 BMW MINI COOPER S. THE CONTACT COMPLAINED STEERING FAILURE. THE STEERING WAS NOT OPERATING. . COULD DRIVE BUT COULD NOT STEER BECAUSE THERE WAS NO POWER STEERING. THE STEERING SYSTEM WAS BROKE A COUPLE OF MONTHS AGO , AND THEY REPAIRED IT. CURRENTLY, THE DEALERSHIP W...

DT: CALLER BURNED VERY BADLY HER LEG BECAUSE THE TAIL PIPE STUCK OUT TOO FAR. TAIL PIPE DID NOT HAVE A GUARD OVER IT. THEY WERE LOCATED IN THE MIDDLE OF THE VEHICLE IN THE BACK INSTEAD ON THE SIDE OF THE BACK. DEALER SAID TO CALL MANUFACTURER, AND THE MANUFACTURER WAS NOT VERY NICE . MANUFACTUR...

Mileage: 18,000

2002 MINI COOPER S HAS HAD A SECOND AIRBAG SYSTEM FAILURE. WHEN ELECTRONICS ASSOCIATED WITH THE AIRBAG SYSTEM DETECT A FAILURE, THE AIRBAG SYSTEM IS DISABLED UNTIL TAKEN TO THE DEALER TO HAVE FIXED. LOOKING UNDER THE SEATS TO SEE WHAT THE ISSUE COULD BE, DISCOVERED THE "FIX" PERFORMED BY THE DEALE...

Mileage: 51,000

DT: THE CONTACT NOTICED THAT IF USING THE REMOTE TO LOCK THE DOORS AND IF ANYONE WAS INSIDE THE VEHICLE THEY WERE UNABLE TO GET OUT OF THE VEHICLE. THE HANDLES NOR THE DOOR LOCK WILL UNLOCK THE DOOR. CONSUMER HAS TO USE THE REMOTE. THE CONTACT FELT THAT THIS WAS SOME TYPE OF COMPUTER DEFECT. HE TOOK...

8" CRACK IN FRONT WINDSHIELD. CRACK IS LOCATED ON LOWER RIGHT HAND (PASSENGER) SIDE OF VEHICLE THAT STARTS BELOW THE WINDSHIELD SEAL. THE GOES UP 3" THEN CURVES LEFT AND TRAVELS FOR 5". CRACK APPEARED AFTER THE CAR WAS PARKED IN A SECURE GARAGE FOR 3 DAYS, AND HAS GROWN ABOUT 1" A WEEK.

Mileage: 1,090

THE AIR BAG SYSTEM WARNING LIGHT HAS BEEN ON 8 TIMES IN 3 YEARS OF OWNERSHIP. (THE INCIDENT DATE I REPORT BELOW IS SIMPLY THE MOST RECENT OCCURENCE) EACH TIME REQUIRES A TRIP TO THE DEALER TO RESET THE SYSTEM. WHEN THE WARNING LIGHT IS ON THE VEHICLE'S AIRBAG SYSTEM IS DE-CTIVATED, AND THEREFORE T...

2002 MINI COOPER [XXX]. CAR HAS BEEN TO THE DEALER AT LEAST FOUR TIMES TO ADDRESS THE AIR BAG LIGHT BEING LIT, IN 44,000 MILES. VARIOUS HARNESSES HAVE BEEN REPLACED THREE TIMES AND THE AIR BAG SENSOR ONCE. NOW, AT 44,500 MILES, THE AIR BAG LIGHT IS ON AGAIN FOR A FIFTH TIME. I'VE BEEN TOLD BY TH...

Mileage: 44,500

WENT OUT TO DINNER WITH MY PARENTS - GONE APPROXIMATELY 2 HOURS - CAME BACK TO FIND THE CAR COMPLETELY BURNED. FIRE DEPARTMENT WAS CALLED BY A NEIGHBOR. THERE WAS NO INDICATION AT ALL THAT THERE WAS ANYTHING WRONG WHEN WE PARKED THE CAR. HAVE FOUND OTHER CASES (VIA THE INTERNET) IN THE UK THAT TH...

Mileage: 61,000

AIR BAG FAILURE LIGHT. 2ND TIME IN 2 YEARS. WIRING HARNESS CONNECTOR SEPARATED WHEN THE DRIVER SIDE SEAT MOVES ALL THE WAY BACKWARD. DEALER INSTALLED LONGER HARNESS.

Mileage: 20,132

WHILE DRIVING ON THE HIGHWAY BETWEEN 50-55 MPH, PUT VEHICLE IN NEUTRAL GEAR TO COAST BEFORE SLOWING DOWN, WENT TO GEAR DOWN , AND VEHICLE WILL BRAKE BUT NOT CHANGE GEARS. THIS COULD RESULT IN AN ACCIDENT. THIS FAILURE OCCURRED DUE TO THE DEFECT DESCRIBED IN RECALL 02V201000 CONCERNING TRANSMISSION ...

Mileage: 9,000

MINI COOPER 2002 SUFFERED A STRESS CRACK OF THE WINDSHIELD THAT HAD TO BE REPLACED. NO ROCKS OR CHIPS CAUSED THE CRACK. IT WAS NOT COVERED UNDER THE VEHICLE'S 36,000 MILE BUMPER TO BUMPER WARRANTY.*AK

Mileage: 22,101

AIR BAG INDICATOR LIGHT COMES ON BECAUSE OFEXCESS WEAR ON THE WIRING UNDER THE DRIVERS SEAT. REPAIR HAS BEEN MADE THREE TIMES. A SIMPLE SOLUTION NEEDS TO BE DEVELOPED. AUTO IS 2002 MINI COOPER MFD IN JUNE OF 2002. *AK

Mileage: 12,000

THE AIRBAG LIGHT CAME ON I TOOK CAR IN AND TOOK THE CAR TO MINI DEALER. THE SIDE AIRBAG HARNESS IS BAD AND NEEDS TO BE REPLACE.*AK

Mileage: 8,000

I HAVE A JULY 2002 BUILD, MINI COOPER S .TO DATE I HAVE HAD 6 WINDSHIELDS INSTALLED.MOST HAVE SUFFERED STRESS RELATED FAILURE,BUT 2 STARTED AS MINIMAL ROCK STRIKES ,WHICH LATER RESULTED IN LONG (10- 14 INCH) CRACKS.GLASS IS SUB-STANDARD,TOO THIN ,AND TOO SOFT.I DEFINATELY FEAR FOR MY SAFETY AS LONG ...

Mileage: 26,654

WINDSHIELD ON MY 2002 MINI COOPER S HAS CRACKS IN 2 PLACES WHICH STARTED FROM THE EDGES OF THE WINDSHIELD. BOTH CRACKS APPEARED WHEN THE CAR WAS SITTING IN THE DRIVEWAY. THE DEALER SAYS THEY ARE "ROCK CHIPS" THOUGH THERE'S NO VISIBLE IMPACT. *AK

Mileage: 18,000

1. INTERIOR DOOR LATCH MECHANISM INOPERABLE IN FREEZING CONDITIONS - WILL NOT RELEASE (UNABLE TO EXIT CAR) - WAS ABLE TO ENTER CAR - CLOSED DOOR - COULD NOT EXIT. BAD SITUATION AS POWER WINDOWS WERE ALSO FROZEN SHUT. 2. WINDSHIELD CRACKS (2ND WINDSHIELD - SEE OTHER THREADS ON THIS KNOWN FAILUR...

Mileage: 35,000

1. INTERIOR DOOR LATCH MECHANISM INOPERABLE IN FREEZING CONDITIONS - WILL NOT RELEASE (UNABLE TO EXIT CAR) - WAS ABLE TO ENTER CAR - CLOSED DOOR - COULD NOT EXIT. BAD SITUATION AS POWER WINDOWS WERE ALSO FROZEN SHUT. 2. WINDSHIELD CRACKS (2ND WINDSHIELD - SEE OTHER THREADS ON THIS KNOWN FAILUR...

Mileage: 35,000

WHILE DRIVING AT HIGHWAY SPEED FUEL TANK EXPLODED WITHOUT WARNING. AS A RESULT, ENGINE FAILED. *AK

Mileage: 20,000

WHILE DRIVING AT HIGHWAY SPEED FUEL TANK EXPLODED WITHOUT WARNING. AS A RESULT, ENGINE FAILED. *AK

Mileage: 20,000

THE CONSUMER ACCIDENTALLY LOCKED THE VEHICLE WITH THE REMOTE KEY WHILE OCCUPANTS WERE STILL IN THE VEHICLE. THE OCCUPANTS COULD NOT MANUALLY UNLOCK ANY OF THE DOORS TO GET OUT OF THE VEHICLE. THE DEALER SAID THERE WAS NOT A REMEDY FOR THIS PROBLEM. PLEASE PROVIDE FURTHER DETAILS. *JB

MY WINDSHIELD SUSTAINED AN 8 INCH LONG CRACK ON THE LOWER CORNER DRIVER SIDE JUST ABOVE THE VIN NUMBER. THIS HAPPENED ONE COLD MORNING WHILE WARMING UP THE ENGINE AT THE DRIVEWAY. BMW DENIED WARRANTY COVERAGE BECAUSE OF A STONE PIT A SIZE OF A PEN DOT ALONG THE CRACKED AREA. I FOUND OUT THAT THERE A...

Mileage: 32,500

MY 2002 MINI COPPER HAS HAD THE AIR BAG LIGHT COME ON ON SEVERAL OCCASIONS NOW. REPAIRED WITH NEW WIRING HARNESS IN 11/03; NOW IN 1/04 BAG LIGHT HAS COME ON AGAIN. DEALER VIA PHONE CANNOT TELL ME IF THE BAGS WORK PROPERLY UNTIL DIAGNOSED. I HAVE CHECKED WEB FORUMS FOR THIS VEHICLE AND THIS SEEMS ...

Mileage: 7,000

MY 2002 MINI COPPER HAS HAD THE AIR BAG LIGHT COME ON ON SEVERAL OCCASIONS NOW. REPAIRED WITH NEW WIRING HARNESS IN 11/03; NOW IN 1/04 BAG LIGHT HAS COME ON AGAIN. DEALER VIA PHONE CANNOT TELL ME IF THE BAGS WORK PROPERLY UNTIL DIAGNOSED. I HAVE CHECKED WEB FORUMS FOR THIS VEHICLE AND THIS SEEMS ...

Mileage: 7,000

WINDSHIELD CRACKED FROM THE LOWER DRIVER'S SIDE AFTER TURNING THE HEATER ON WHILE VEHICLE WAS WARMING UP PARKED ON THE DRIVEWAY. DEALER REFUSED TO REPLACE IT UNDER WARRANTY. *LA

AIR BAG WARNING LIGHT CAME ON AND STAYED ON, WHICH INDICATED THAT AIR BAGS WERE INOPERATIVE. DEALERSHIP SERVICED THE VEHICLE, BUT THE PROBLEM RECURRED WITHIN 2000 MILES.*AK

Mileage: 18,000

-STALLING WHEN CHANGING FROM REVERSE TO DRIVE. HAS ALSO STALLED ONCE ON THE INTERSTATE. -RPM'S KEEP REVVING BETWEEN 3000 & 5000 WHEN I HIT 55-60 MPH. ONCE I PASS 60 MPH THE RPM'S DECREASE TO A REASONABLE LEVEL. THIS HAPPENS EVERYDAY WITHOUT FAIL. *LA

Mileage: 20,000

LARGE CRACK OCCURED IN THE WINDSHIELD. DEALER CLAIMED IT WAS CAUSED BY A STONE, AND NOT COVERED, AND INHERENT WITH THE DESIGN OF THE CAR (A MORE UPRIGHT WINDSHIELD THAN MANY OTHER CARS). I HAVE HEARD OF NUMEROUS SIMILAR HAPPENINGS.

WINDSHIELDS ARE FAILING ALL OVER THE COUNTRY ON MINI COOPER AUTOMOBILES. I AM CURRENTLY ON MY 3RD WINDSHIELD IN AS MANY MONTHS - STRESS CRACKS APPEARED FROM THE ROOF PILLARS IN BOTH CASES. WE NEED A RESOLUTION TO THIS - EITHER BETTER GLASS OR STRUCTURAL IMPROVEMENTS.*AK

Mileage: 10,100

INTERMITTENT COMPLETE LOSS OF POWER FOR 2-3 SECONDS WHEN STARTING FROM STANDSTILL.OCCURS UNDER VARIOUS CLIMATIC CONDITIONS AND EITHER WITH COLD OR WARM ENGINE.EXTREMELY DANGEROUS WHEN MERGING INTO TRAFFIC FROM A SIDE STREET OR INTERSECTION.*AK

Mileage: 10,280

MY 2002 MINI COOPER S HAS SOME ENGINE MANAGEMENT ISSUES THAT HAVE RESULTED IN SEVERAL CLOSE CALLS IN TRAFFIC SITUATIONS THAT I FEEL ARE UNSAFE, AND HAVE YET TO BE RESOLVED OR DEFINITELY ADDRESSED BY THE MANUFACTURER. THE MOST SEVERE ISSUE IS A TOTAL LOSS OF ENGINE POWER AFTER ACCELERATION ON CLEAN ...

Mileage: 5,000

THERE IS A COMPLETE POWER FAILURE AT VARIOUS SPEEDS INCLUDING 55 MPH. THIS DEFECT OR CONDITION CAN RESULT IN SERIOUS INJURY OR DEATH. WHEN IT HAPPENED ON RT. 66 IN ARLINGTON VA AT 9:30 PM, IT CAUSED A NEAR-COLLISION WITH SEVERAL OTHER VEHICLES TRAVELING ON THE ROAD. THERE WAS NO WARNING LIGHT, NO...

Mileage: 12,950

WINDSHIELD CREAKING, CRACKLING. REPLACED TWICE BY DEALER DUE TO WIND LEAKAGE. WINDSHIELD IS TOO THIN AND PITS WAY TOO EASILY. WIFE IS AFRAID OF SAFETY BECAUSE OF THE NOTORIOUSLY HIGH INCIDENCE OF SPONTANEOUS CRACKING WINDSHIELDS. MINI USA CONTINUES TO DENY ANY PROBLEMS, BUT INFORMAL SURVEYS OF DEA...

WHILE DRIVING THE SIDE AIR BAGS DEPLOYED. THE VEHICLE WAS TOWED TO THE DEALERSHIP. BMW OF NORTH AMERICA REPURCHASED THE VEHICLE. *AK *CB *NLM

Mileage: 8,700

WINSHIELD CRACK FROM BIRD SAP!*AK

Mileage: 19,864

STRESS CRACKED WINDSHIELD IN 2002 MINI COOPER S.*AK

Mileage: 15,000

CRACKED WINSHIELD IN TWO DIFFERENT PLACES. OCCURRED ABOUT 10 MINUTES APART WHILE DRIVING IN SLOW TRAFFIC AT ABOUT 100 DEGREES. *AK

Mileage: 10,995

WE OWN A MINI COOPER S. LIKE HUNDREDS OF OTHERS WHO HAVE NOT YET FILED A COMPLAINT, WE HAD A CRACKED WINDSHIELD FOR NO APPARANT REASON. THE WINDSHIELD SEEMS TO BE VERY THIN AND SOFT. AND VERY SUCCEPTABLE TO CRACKS AND ROCK CHIPS, PITTING FOR LACK OF ANOTHER WORD.

Mileage: 23,000

WHEN THE AIR CONDITIONING IS ON, CAR STALLS OR STUMBLES WHILE STARTING MOVEMENT IN FIRST GEAR. THIS CAUSES MERGES, LEFT TURNS TO GET DANGEROUS. HOT WEATHER INCREASES THE OCCURRENCE OF THE PROBLEM.*AK

Mileage: 5,950

WHEN THE AIR CONDITIONING IS ON, CAR STALLS OR STUMBLES WHILE STARTING MOVEMENT IN FIRST GEAR. THIS CAUSES MERGES, LEFT TURNS TO GET DANGEROUS. HOT WEATHER INCREASES THE OCCURRENCE OF THE PROBLEM.*AK

Mileage: 5,950

STOPPED AT LIGHT WHEN I HEARD A SMALL CRACK NO OTHER VEHICLES OR TRAFFIC AROUND UPON INVESTIGATION I FOUND A SMALL STAR LIKE CRACK IN THE WINDSHIELD. WITHIN THE NEXT MONTH BEFORE CRACK COULD BE FIXED WINDSHIELD WAS CHIPPED BY ROAD DEBRIS IN TWO SEPARATE PLACES AND ON TWO SEPARATE DAYS. WINDSHIELD G...

Mileage: 4,500

BROKEN WINDSHIELD 2002 MINI COOPER S. *NLM

I AM WRITING TO COMPLAIN ABOUT THIN/WEAK WINDSHIELDS IN MY MINI COOPER S. I AM ON MY THIRD WINDSHIELD IN LESS THAN A YEAR. THE GLASS IS INCREDIBLY THIN AND CRACKS WITH THE SLIGHTEST IMPACT. I CONSIDER THIS UNSAFE. IN ADDITION I KNOW OF MANY PEOPLE WHO ARE HAVING THE SAME PROBLEM. *NLM

Mileage: 16,150

WINDSHIELD PITS FROM SAND VERY EASILY. WINDSHIELD CRACKED FROM DRIVER'S SIDE TO MIDDLE OF WINDOW WHILE BACKING OUT OF FLAT DRIVEWAY. REPLACED UNDER WARRANTY BY DEALER. TWO MONTHS LATER, SMALL AMOUNT OF BLOWING SAND PITS WINDSHIELD AGAIN. 2002 MINI COOPER. *NLM

Mileage: 8,458

CAR STALLS RANDOMLY WHEN COMMING TO A STOP. THIS HAPPENS ON ON MANUEL TRANSMISSION. WHEN DEPRESSING THE CLUTCH IT REVS DOWN AND IDOLS LOW AND STALLS WHEN APPROAHING A STOP. AFTER AN INITAL STALL POWER IS REDUCED AND IS SLUGGISH WHEN THE GAS IS DEPRESSED.*AK

Mileage: 16,956

THE TRANSMISSION FAILED WITHOUT WARNING. *JB

MY MINI COOPER HAS DEVELOPED A HUGE CRACK IN THE WINDSHIELD. THE DEALER SAID THE CRACK WAS STARTED BY A CHIP FROM ROAD DEBRIS, HOWEVER CRACKED WINDSHIELDS ARE A WELL KNOW PROBLEM WITH THE MINI. MANY MINI OWNERS HAVE REPLACED THEIR WINDSHIELDS 3 OR 4 TIMES. BEFORE I BUY A NEW WINDSHIELD I WOULD LIKE ...

MINI COOPER S 2002 HAD A CRACK START AND GROW UNTIL IT SPANNED THE WINDSHIELD. HAD TWO SUBSEQUENT ROCK CHIPS THAT GREW INTO MASSIVE CRACKS. THE WINDOW SEEMS TO CRACK TOO EASILY. *AK

THE WINDSHIELD ON MY 2002 MINI COOPER S DEVELOPED TWO CRACKS IN IT'S WINDSHIELD. I PURCHASED THIS CAR IN SEPT OF 2002. THE FIRST CRACK DEVELOPED AFTER OWNING THE CAR ABOUT 4 MONTHS AND MINI USA WOULD NOT REPLACE THE WINDSHIELD. NOW A SECOND CRACK HAS DEVELOPED 3 MONTHS LATER. *TT

Mileage: 8,000

THE CHECK ENGINE LIGHT HAS BEEN ON SINCE WE BROUGHT THE CAR HOME. MINI HAS ATTEMPTED FIX THE PROBLEMS UNSUCCESSFULLY 8 TIMES, CULMINATING WITH THE DEALER GETTING INTO A TRAFFIC ACCIDENT WHILE TEST DRIVING THE VEHICLE. *NLM

Mileage: 300

I NEED TO COMPLAIN ABOUT THE WINDSHIELD ON THE MINI COOPER 2002. ONE WEEK AFTER I GOT MY CAR, I WAS DRIVING ALONG AND ALL OF THE SUDDEN A CHIP APPEARED. I NEVER SAW OR HEARD ANYTHING HIT IT. I HAVE SINCE GOTTEN ABOUT 10 CHIPS IN MY WINDSHIELD. EVER SINCE I GOT THE CAR, MY WINDSHIELD HAS CREAKED ...

Mileage: 12,000

STRESS FRACTURE OF WINDSHIELD ABSENT SPECIFIC IMPACT FROM OUTSIDE SOURCE. NUMEROUS POSTS ON INTERNET FORUMS, INCLUDING THE MANUFACTURER SPONSORED MINI OWNER'S SITE REVEAL AN INCREASING NUMBER OF WINDSHIELDS DEVELOPING APPARENT STRESS FRACTURES. MY PERSONAL EXPERIENCE AND THAT OF OTHERS IS THAT THE W...

Mileage: 1,850

I OWN A MINI COOPERS 2002. I HAD A CRACKED WINDSHIELD IN JANUARY OF 2003. I AM SURE THIS WAS DUE TO A MANUFACTURING DEFECT. MY DEALER SAW OTHERWISE. MINI USA NEEDS TO ADDRESS THIS FLAW IN THEIR DESIGN. MY REPLACEMENT WINDSHIELD WAS NOT COVERED UNDER WARRANTY, AS IT SHOULD HAVE BEEN FOR SUCH A DEFECT...

Mileage: 8,600

THE WINDSHIELD OF MY 2002 MINI COOPER S CRACKED WHILE SITTING IN A PARKING LOT. IT WAS FINE IN THE MORNING BUT THERE WAS AN 8" CRACK WHEN I HOPPED IN FOR THE DRIVE HOME. I'M GUESSING THE HEAT (90 DEGREES F, WINDOWS UP, SUN REFLECTOR ON DASH) CAUSED A CONTAMINANT WITHIN THE WINDOW TO CAUSE STRESS, WH...

Mileage: 15,500

WINDSHIELD CRACK. THERE ARE NUMEROUS OTHER OWNERS REPORTING SIMILAR CRACKS IN THEIR WINDSHIELDS. MINI HAS STATED THEY HAD A PROBLEM WITH THE GLASS CRACKING DUE TO IMPROPER INSTALLATION IN PREVIOUS BUILDS AND CURRENTLY HAVE A SURVEY FOR THE DEALERS TO PERFORM AN INSPECTION ON ANY WINDSHIELD REPLACE...

Mileage: 15,800

2003 MINI COOPER CVT. VEHICLE STALLS IN TRAFFIC CONDITIONS. BOGGS DOWN, LUNGES UPON ACCELERATION. POWER FAILURE. NO INDICATOR LIGHTS ON DASH WARN OF PROBLEM. VEHICLE HAS BEEN SERVICED ON THREE OCCASIONS FOR SAME PROBLEMS. BOGGS DOWN AND LUNGES CORRECTED BY REPROGRAMMING ON FIRST SERVICE. AFTE...

THE VEHICLES REAR HATCH IS ELECTRONIC AND IF THE VEHICLES BATTERY DIED THERE WOULD BE NOT WAY TO INTO THE BATTERY COMPARTMENT. THE DEALER WAS NOTIFIED. *NLM

WILDLY STUMBLES WHILE AUTO IS STOPPED. IT IS INTERMITTENT THERE IS ON CONSISTENCY TO THIS PROBLEM. *JB

Mileage: 3,000

THE AIR BAG LIGHT ILLUMINATED ON THE DASH BOARD, THE DEALER WAS UNABLE TO RECTIFY THE PROBLEM. *JB

THE HEAD LIGHT FAILED TWICE, THE DEALER REPLACED THE MODULE AND THEN THE COMPUTER CHIP. *JB

THE DOOR LOCKS ACTIVATED INTERMITTENTLY WHILE DRIVING. THE VEHICLE HAD BEEN EXAMINED BY THE DEALER TWICE, HOWEVER THEY COULD NOT FIND THE PROBLEM. *JB

THE INTERIOR LIGHTS FLASHED INTERMITTENTLY. *JB

CAR ALMOST STALLS WHEN TRYING TO ACCELERATE FROM A COMPLETE STOP. ACCELERATION RATES VARY AND SOMETIMES ARE DANGEROUSLY SLOW CAR LUNGES WHEN TRYING TO MOVE SMALL DISTANCES

Mileage: 5,125

CAR ALMOST STALLS WHEN TRYING TO ACCELERATE FROM A COMPLETE STOP. ACCELERATION RATES VARY AND SOMETIMES ARE DANGEROUSLY SLOW CAR LUNGES WHEN TRYING TO MOVE SMALL DISTANCES

Mileage: 5,125

I AM HAVING A PROBLEM WITH MY 2002 MINI COOPER, IT IS EXPERIENCING PROBLEMS WITH THE TRANSMISSION AND IT HAS BEEN IN THE SERVICE DEPARTMENT IN THREE SEPARATE OCCASION TOTALLYING 54 DAYS, THE LAST TIME THAT IT WAS IN THE SERVICE DEPARTMENT IT WAS 40 DAYS. THEY FINALLY SAID THE PROBLEM WAS CORRECTED, ...

VEHICLE WILL HESTITATE TO ACCELERATE AND INTERMITTENTLY LY STALL WHILE DRIVING. CONTACTED DEALER.CAUSE UNKNOWN.*AK