2005 MINI COOPER Electrical System Problems

The contact owns a 2005 Mini Cooper. The contact stated that there was water accumulated on the passenger's side front floorboard. The contact stated that the heater was causing some undisclosed issues. There were no warning lights illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 23V337000 (Electrical System). The contact called the local dealer and was informed that the VIN was not included in the recall. The vehicle was diagnosed, and it was determined that the sunroof drain tubes were clogged, the drain tubes were cleared, and an undisclosed reprogramming was completed. The vehicle was repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 172,843.

Mileage: 172,843

Driving at approximately 10-15 miles an hour entering a parking lot when I noticed flames coming out of the hood scoop of my 2005 Mini Cooper S. After brief inspection from my mechanic, it is believed to have been caused by the wiring harness for ABS or possibly the power steering unit since the fire originated from the rear/right hand side of the engine and those two components. I have a claim opened with USAA but during simple research, I have found tens, if not close to a hundred issues with similar characteristics. I know I am not the first R53 Mini Cooper (2002-2006 run) with this problem and this should be considered a hazard and public safety issue. I have included the link to many of the cases captured by the North American Motoring Association (a primarily North American Mini car association) which details 24 pages of these issues. https://www.northamericanmotoring.com/forums/stock-problems-issues/73527-spontaneous-engine-bay-fires.html?ispreloading=1

TL* THE CONTACT OWNS A 2005 MINI COOPER. WHILE DRIVING 60 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. WHEN THE VEHICLE WAS TURNED OFF, THE CONTACT NOTICED THAT THE ELECTRIC FAN KEPT RUNNING. THE FOLLOWING DAY, THE VEHICLE FAILED TO START. THE BATTERY WAS DEAD. WHEN ROADSIDE ASSISTANCE ARRIVED, THE BATTERY WAS JUMPSTARTED AND THE FAN REMAINED ACTIVE. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE POWER STEERING PUMP AND THE POWER STEERING FAN NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 67,000.

Mileage: 67,000

POWER STEERING PROBLEMS, AIR BAG OFF AND ON, CLUTCH WENT OUT NEAR ACCIDENT, ELECTRICAL ISSUES(MANY) WINDOWS UP AND DOWN ON THEIR OWN, EVER BRAKE NOT WORKING PROPERLY NUMEROUS ITEMS I HAVE THEM DETAILED ON PAPER

Mileage: 95,000

LOST POWER STEARING, HEAT AND AIR ALL AT THE SAME TIME.

Mileage: 90,000

AFTER AN HOURS DRIVE, I WAS STANDING OUTSIDE OF THE VEHICLE TALKING W/ THE CAR OFF. ALL OF SUDDEN SMOKE STARTS POURING OUT FROM UNDER THE HOOD. I QUICKLY OPENED THE HOOD TO HEAR SOME TYPE OF ELECTRICAL FAN/PUMP SOUND & SMOKE COMING FROM THE BOTTOM/REAR SIDE OF THE MOTOR. I WAS ABLE TO PULL THE BATTERY TERMINAL & THE NOISE/SMOKE STOPPED. I THEN SEARCHED ONLINE & FOUND THE KNOWN ISSUES OF THE ELECTRICAL ASSISTED POWER STEERING. I FOUND THE FUSE FOR THE CIRCUIT, A 100 AMP FUSE HIDDEN ON THE BOTTOM SIDE OF THE FUSE BOX THAT HAD NOT POPPED EVEN THOUGH THE PUMP WAS BURNING ITSELF UP. I HAD ENOUGH TOOLS W/ ME TO PULL THE FUSE, GET THE CAR STARTED & MAKE MY WAY HOME W/O THE POWER STEERING ASSIST.

Mileage: 57,000

2005 MINI COOPER. CONSUMER WRITES IN REGARDS TO ENGINE ELECTRONIC FAILURE. CONSUMER HAS ANOTHER VEHICLE COMPLAINT LISTED IN ARTEMIS. *SMD THE CONSUMER STATED THE PROBLEM HE EXPERIENCED WITH HIS VEHICLE WAS A COMPUTER TEST CALLED COMPREHENSIVE COMPONENT KEPT READING INCOMPLETE. THE DEALER FOUND AN INTERNAL SHORT INSIDE THE ENGINE BASIC CONTROL COMPUTER. THE CONSUMER STATED THE COST TO REPLACE THE ELECTRONIC HARDWARE WAS $1968 WHICH WAS EXCESSIVE. *JB

I GOT IN MY VEHICLE AND SHUT THE DOOR. I TURN THE KEY TO ON, THE LOCKS WENT DOWN (LOCKS USUALLY GO DOWN WHEN CAR IS IN GEAR AND MOVING) I TURNED THE KEY FURTHER TO START THE ENGINE AND NOTHING HAPPENED. THE DOOR WOULD NOT OPEN, THE WINDOWS WOULD NOT GO DOWN, THE SUN ROOF WOULD NOT OPEN, THE FOB WOULD NOT WORK, AT THAT POINT I WAS LOCKED IN MY CAR. I HAD TO KICK OUT THE WINDOW TO GET OUT OF MY CAR. WHEN I DID GET OUT, I RE ENTERED THE CAR AND OPENED THE HOOD AND JIGGLED THE BATTERY CONNECTION. I SHUT THE HOOD AND TRIED TO START THE CAR AGAIN AND IT STARTED. I NOTICED AS I WAS DRIVING IT HOME THAT THE LIGHTS ON THE STEERING COLLUM WERE NOT WORKING AND THAT WHEN I PARKED IT AT HOME THE BRAKE LIGHTS STAYED ON. *TR

Mileage: 100,000

SUDDEN FAILURE OF POWER STEERING RESULTING IN VERY HIGH STEERING EFFORT, TRACED BY DEALER TO A WELL-KNOWN FAILURE MODE IN ELECTROHYDRAULIC POWER STEERING PUMP. PUMP AND ASSOCIATED FAN WERE REPLACED BY DEALER UNDER SPECIAL ("SECRET") WARRANTY COVERAGE, DUE TO COMMON INCIDENCE OF THIS FAILURE. EXISTENCE OF THIS SPECIAL WARRANTY WAS FOUND ONLY AFTER SEARCH AND LOCATION OF MANY IDENTICAL FAILURES ON THE INTERNET. THE VEHICLE BATTERY WAS FOUND TO BE COMPLETELY DISCHARGED UPON ARRIVAL AT DEALERSHIP. ONCE A SHOP BATTERY WAS CONNECTED, THE PUMP WAS FOUND TO BE RUNNING CONTINUOUSLY EVEN THOUGH THE VEHICLE IGNITION WAS IN THE FULL OFF POSITION. ALSO, THE ALTERNATOR WAS FOUND TO HAVE FAILED, PRESUMABLY BECAUSE OF EXCESSIVE STRESS IMPOSED BY THE DEFECTIVE PUMP ON THE VEHICLE ELECTRICAL SYSTEM. COST OF ALTERNATOR REPLACEMENT WAS NOT COVERED BY THE MANUFACTURER. THIS KNOWN FAILURE MODE IS BELIEVED TO BE A SIGNIFICANT SAFETY DEFECT. FORMAL RECALL OF AFFECTED VEHICLES BY NHTSA IS WARRANTED, SINCE SUDDEN LOSS OF POWER STEERING AT SPEED CAN RESULT IN LOSS OF VEHICLE DIRECTIONAL CONTROL. *JS

Mileage: 38,308

IN SEPTEMBER 2012 I NOTICED A LOUD FAN NOISE THAT WOULDN'T TURN OFF. THE CAR WAS ALSO OVERHEATING. I NOTICED THAT IT WAS VERY HARD TO STEER THE CAR, BUT I THOUGHT THAT WAS DUE TO THE OVERHEATING. MECHANIC DETERMINED FAILED CYLINDER HEAD GASKET IN 11/2012. THE RADIATOR WAS REPLACED AND THE THERMOSTAT WAS REPLACED. IN 11/2012 THE WATER PUMP WAS ALSO REPLACED. IN 12/2012 THE BATTERY HAD TO BE REPLACED. IN 06/2013 THE HEATER CORE WAS REPLACED. I BELIEVE THAT THESE ISSUES ARE DIRECTLY RELATED TO THE LOSS OF POWER STEERING AND THE ASSOCIATED FAN FAILING, WHICH CAUSED THE CAR TO OVERHEAT AND THE BATTERY TO FAIL. PLEASE SEE NHTSA COMPLAINTS 10453158, 10444328, 10379750, 10442431,10379459 FOR SIMILAR CASES OF THESE SAME ISSUES RELATED TO THE FAILURE OF POWER STEERING AND THE ASSOCIATED PUMP. *TR

Mileage: 60,246

WHILE I WAS DRIVING ON THE HIGHWAY APPROXIMATELY 65 MPH MY STEERING GAVE OUT AND LOCKED UP, ALMOST SLAMMING ME INTO THE GUARD RAIL. I WAS FORTUNATE ENOUGH TO STOP BEFORE TRAGEDY. UNFORTUNATELY I WAS BLOCKING A LANE OF TRAFFIC UNTIL I COULD FORCE MY WAY OF THE ROADWAY. THE SECOND INCIDENT HAPPENED AS I WAS TURNING INTO MY OWN DRIVEWAY. THE STEERING LOCKED UP AGAIN CAUSING ME TO MISS MY DRIVEWAY AND CRASH INTO THE DITCH. THE OTHER SAFETY ISSUES WITH MY CAR IS THE WINDSHIELD WIPERS WILL STOP WORKING AT RANDOM AND THE REVERSE AND TAIL LIGHTS WILL FAIL AT RANDOM. THE ENGINE LIGHT STAYS ON AND THE CODES READ EMISSIONS FAILURE. WHEN I TALK TO MINI COOPER CUSTOMER RELATIONS THEY GAVE ME AN EXTENDED 100,000 MILE WARRANTY ON THE POWER STEERING AND EMISSIONS. MINI COOPER CLAIMS THEY CAN'T DO THE SAFETY REPAIRS DUE TO A PART SHORTAGE. THEY EXTENDED MY ALREADY EXTENDED WARRANTY TO 150,000 MILES AND ARE WANTING TO CHARGE ME FOR DIAGNOSTICS ON THESE EXTENDED WARRANTY ISSUES. THEY WILL NOT OFFER ANY RESOLUTION AND CLAIM IT IS MY PROBLEM AS A CONSUMER AND CLAIM THE POWER STEERING ISSUES ARE NOT SAFETY RELATED. WHEN I ASKED ABOUT THE ELECTRICAL LIGHTING ISSUES THEY REPLIED WITH THAT'S NOT MINI COOPERS PROBLEM. *TR

Mileage: 95,900

OCCUPANT SEAT SENSOR FAILURE IN PASSENGER SEAT, AIRBAG LIGHT COMES ON AND STOPS AIRBAG OPERATION. I SEE THAT NHTSA HAS CONTACTED BMW FOR THIS PROBLEM AND FOR THIS MODEL YEAR; HOWEVER, BMW/MINI WON'T TAKE BLAME FOR AIRBAG FAILURE. BMW TAKES IRRESPONSIBLE ATTITUDE THAT EVEN THOUGH CAR HAS ONLY 36,000 MILES, SAFETY IS MY PROBLEM, NOT THIERS. AS A SIDE NOTE, DEALER SAYS PART IS $1200 PLUS INSTALLATION AND REPROGRAMMING. BMW, THE ULTIMATE DRIVING (AND KILLING) MACHINE. *TR

Mileage: 35,890

2005 MINI COOPER. WHILE DRIVING APPROXIMATELY 45 MPH, THE FRONT PASSENGER AIR BAG OFF INDICATOR ILLUMINATED WITH AN OCCUPANT POSITIONED IN THE SEAT. IN ADDITION, THE FAILURE WOULD OCCUR EVEN WHEN AN OCCUPANT WAS NOT PRESENT IN THE FRONT SEAT. THE ILLUMINATION NO LONGER CONTINUED WHEN THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER, WHO STATED THE PASSENGER SEAT MAT SENSOR WOULD NEED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 35,000. *TR

Mileage: 35,900

INTERMITTENT POWER STEERING FAILURES WHILE CAR IS IN MOTION. ONE MINUTE POWER STEERING FUNCTIONS, NEXT MINUTE, NO PS AT ALL. POWER STEERING PUMP CONTINUES TO RUN EVEN WHEN ENGINE IS OFF AND KEY OUT OF IGNITION. AFTER RETURNING TO VEHICLE, BATTERY IS DEAD AS A RESULT OF CONTINUOUSLY RUNNING PUMP OR FAN. *TR

Mileage: 85,103

POWER STEERING PUMP FAILURE. *TR ## VIN FAILED ##

Mileage: 87,000

SON RETURNED FROM TOWN, A 10 MINUTE DRIVE, PARKED CAR IN GARAGE. NEXT MORNING THERE WAS A STRONG SMELL OF AN ELECTRICAL FIRE COMING FROM THE CAR. OPENED THE HOOD AND THE SMELL OF FIRE WAS OVERWHELMING. TOP OF STEERING FLUID PUMP APPEARED TO BE CHARRED. FAMILY AFRAID TO DRIVE CAR TO DEALER, SOME 35 MILES AWAY. AFTER STARTING CAR, ELECTRICAL FIRE SMELL RETURNS. *TR

Mileage: 65,000

THE POWER STEERING PUMP STOPS OPERATING WHILE THE VEHICLE IS IN MOTION. IT HAS HAPPENED THREE TIMES TO DATE: THE FIRST INCIDENT WAS AT LOW SPEED IN A PARKING STRUCTURE; THE SECOND INCIDENT HAPPENED AT FREEWAY SPEED; THE MOST RECENT INCIDENT OCCURRED ON A SURFACE STREET WHILE DECELERATING TO A STOP. IN EACH CASE, CONTROL OF THE CAR WAS MAINTAINED BUT WAS VERY DIFFICULT. THE PUMP FUNCTION WAS RESTORED BY STOPPING AND CYCLING THE VEHICLE IGNITION TO OFF AND THEN RESTARTING THE ENGINE. *TR

Mileage: 59,925

INTERMITTENTLY AND RARELY, WHEN THE CAR FIRST STARTS, THE POWER STEERING DOES NOT WORK. IT IS VERY DIFFICULT TO MOVE THE STEERING WHEEL AT ALL, AND THERE IS NO APPARENT EFFECT ON THE WHEELS OF THE CAR. EACH TIME THIS HAS HAPPENED, I HAVE IMMEDIATELY TURNED OFF THE CAR AND RESTARTED. RESTARTING THE IGNITION HAS BEEN ENOUGH TO REGAIN THE POWER STEERING. AFTER THIS HAPPENED BETWEEN 5 AND 10 TIMES OVER THE PAST YEAR, I REALIZED IT WAS A PATTERN AND DECIDED TO LODGE A COMPLAINT. I ALSO REALIZED THAT THE LOUDER-THAN-ORDINARY STEERING FAN NOISE MIGHT BE ANOTHER SYMPTOM OF PROBLEMS WITH THE POWER STEERING. IN MID-SEPTEMBER 2011, THE CAR BATTERY DIED. THE STEERING FAN WAS VERY LOUD. I NOW WONDER IF THE BATTERY FAILURE WAS DUE TO THE STEERING FAN, ALTHOUGH NO ONE AT THE DEALERSHIP COMMENTED ON THE VERY LOUD FAN THAT WAS EXTREMELY NOTICEABLE WHEN THEY RESTARTED THE CAR. *TR

Mileage: 71,000

ALL BULBS ARE GOOD BUT YET I HAVE NO BRAKE LIGHTS ARE TURNING SIGNALS TOP BRAKE LIGHT IS ALL I HAVE WHEN I TURN ON SIGNALS WINDOWS GO DOWN SUNROOF OPENS. *TR

Mileage: 87,000

ON THREE OCCASIONS, MY 2005 MINI COOPER HAS HAD POWER STEERING FAILURE. EACH TIME, I WAS DRIVING AT SPEEDS BETWEEN 35-45MPH AND HAS PUT ME IN DANGEROUS POSITIONS WHERE I WAS UNABLE TO STEER MYSELF OUT OF MAJOR MATERIALS AND ONTO A SAFER ROAD. I AM NOT STRONG ENOUGH TO EASILY OVERPOWER MY VEHICLE'S STEERING. MY FIRST EXPERIENCE HAPPENED AS I WAS DRIVING 35MPH ON A BUSY ROAD AT PEAK HOUR. I WAS ON A FOUR LANE ROAD, TWO IN EACH DIRECTION. I WAS IN THE LEFT HAND LANE COMING UP TO MY APT WHEN MY STEERING WENT OUT. I WAS UNABLE TO MANEUVER TO THE RIGHT LANE TO PULL OVER DUE TO THE SHEER STRENGTH NEEDED AND HIGH TRAFFIC VOLUMES. I IMMEDIATELY PUT MY HAZARDS ON TO ALERT MOTORISTS AND SLOWED DOWN MY SPEED. I WAS LEFT STRANDED BEFORE A MAJOR CURVE IN THE ROAD. I WAS UNABLE TO MOVE MY CAR IN EITHER DIRECTION. A SECOND EXPERIENCE OCCURRED PRIOR TO A CURVE AS I WAS EXITING AN INTERSTATE HIGHWAY. AS I ATTEMPTED TO TURN THE WHEEL I NOTICED THE WHEEL WAS STIFF/RIGID. I COULD NOT MAKE THE CURVED EXIT RAMP AND BLOCKED TREMENDOUSLY HIGH SPEEDING EXITING TRAFFIC BEHIND ME. I BELIEVE THIS IS A SIGNIFICANT DANGER TO DRIVERS. PRIOR TO EACH INCIDENT, THERE WERE NO WARNINGS/LIGHTS INDICATING ISSUES OF ANY KIND. I WOULD SUGGEST AN INVESTIGATION, AS I WAS NOT ABLE TO FIND ANY RECALLS FROM MINIUSA. I HAVE SEARCHED THE INTERNET AND HAVE FOUND MANY FORUMS (USA & UK) OF MINI OWNERS DISCUSSING EACH OF THEIR INCIDENTS CAUSED BY POWER STEERING FAILURES. I STRONGLY BELIEVE THIS IS NOT AN ISOLATED PROBLEM AND COULD CAUSE GREAT HARM TO OWNERS. IT IS COMMON THAT ONCE AN ACCIDENT/DEATH HAS OCCURRED DUE TO FAULTY PARTS, A RECALL IS MADE. AN INVESTIGATION SHOULD BE MADE BEFORE THIS HAPPENS. *TR

Mileage: 77,000

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT THE VEHICLE WAS RESISTANT TO STARTING ATTEMPTS. THE CONTACT NOTICED THAT THE BATTERY WAS DRAINED AND THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY DIAGNOSED THAT THERE WAS AN INTERNAL SHORT IN THE ELECTRONIC WATER PUMP. THE DEALER ADVISED THE CONTACT THAT THE SHORT CAUSED THE BATTERY TO DRAIN . THE VEHICLE WAS REPAIRED AT THE OWNER'S EXPENSE. THE FAILURE MILEAGE WAS 74,000 AND THE CURRENT MILEAGE WAS 77,000.

Mileage: 74,000

I USE MY MINI COOPER THE NIGHT BEFORE PARKING IT AT AROUND 10:00PM THE NIGHT OF DECEMBER 22ND, 2011. THE NEXT MORNING WENT TO WORK AS USUAL BY MASS TRANSIT. AT AROUND 8:00AM I RECEIVED A CALL FROM MY NEIGHBOR TELLING ME THAT MY CAR WAS ON FIRE. THE SUPERINTENDENT OF MY BUILDING HAD SEEN THE CAR SMOKING AND BY THE TIME HE CAME BACK TO GRAB AN EXTINGUISHER THE CAR HAD CAUGHT ON FIRE. THE FIRE WAS PUT OF IN SHORT TIME AND THE FIRE DEPARTMENT ASSURED THE FIRE WAS OFF SPREADING FIRE RETARDANT, A POWDER TALC LIKE OVER THE AREA THAT CAUGHT FIRE. THE FIRE WAS OVER THE RIGHT SIDE GRILLE BETWEEN THE WINDSHIELD AND HOOD. THE ESTIMATE OF RECORD PREPARED BY GEICO ADJUSTER DESCRIBES DAMAGES IN THE INSTRUMENT PANEL, DASH PAD CROSSMEMBER, SUPERCHARGER, AIR GRILLE AND MUCH MORE PARTS. THE CAR HAS BEEN CONSIDERED TOTAL LOSS BY GEICO AND CURRENTLY GOING THROUGH THE PROCESS TO TRY TO SETTLE BUT HAVEN'T BECAUSE THE ESTIMATE THEY GAVE ME FOR THE VALUE OF THE CAR IS VERY LOW COMPARED TO WHAT I PAID FOR IT AND THE LOW MILEAGE OF IT. THIS IS TERRIBLE SINCE I HAVE NOT FINISH PAYING THE CAR, I'M SHOCKED A CAR CAN CATCH FIRE BY ITSELF I WOULD APPRECIATE IF SOMEONE CAN HELP ME WITH THE PROBLEM OF MINI COOPERS CATCHING WHILE PARKED A RECALL FOR THE SAME PROBLEM IS ALL OVER THE INTERNET TODAY JAN 17TH, 2012. OR GUIDE ME IF THE INSURANCE COMPANY WILL DO SOMETHING REGARDING THE RECALL, ALTHOUGH THEY ARE NOT RECALLING THE MODEL OR YEAR MY CAR WAS MADE. *TR

Mileage: 36,000

DRIVING HOME FROM WORK AT ABOUT 70 MPH, THE POWER STEERING FAILED. I WAS GOING AROUND A BEND IN THE ROAD WHEN SUDDENLY THE POWER STEERING FAILED THAT ALMOST CAUSED AN ACCIDENT. WITHOUT NOTICE THE CAR REVERTED TO "RACK-AND-PINION" MODE. I WAS FORTUNATE THAT TIME TO GAIN CONTROL OF THE CAR AND DID NOT GO OVER THE SIDE OF THE ROAD OR HIT ANOTHER CAR. I DIDN'T DRIVE THE CAR FOR SEVERAL MONTHS THEN TOOK IT TO A FEW MECHANICS FOR AN ESTIMATE. DEALER SAYS REPLACE THE STEERING PUMP AT $1200 BUT THEY WILL NOT HONOR ANY ASSISTANCE DUE TO THE PREMATURE FAILURE OF THE STEERING PUMP OR THE ELECTRICAL CONNECTION TO THE COOLING FAN FAILURE. THE POWER STEERING FAN QUITS THEN THE PUMP GETS HOT AND SHUTS OFF. I CALLED MINI USA TODAY AND THEY SAID THEY WILL NOT ASSIST ME IN PAYING FOR THE MANUFACTURING DEFECT. MY PUMP FAILURE IS INTERMITTENT SUGGESTING THAT THE PROBLEM IS ELECTRICAL AND ON POINT FOR A RECALL ON 2004 MINI COOPERS. MY CAR HAS THE SAME PROBLEM AND WAS MANUFACTURED IN 2004, BUT IS THE 1707 CAR OUTSIDE THEIR "OFFICIAL" RECALL RANGE. MINI/BMW SENT A "MR. DRIVER" LETTER OUT ON 12/2004 FOR THIS "RECALL." MY CAR HAD NOT BEEN PURCHASED YET. THE DEALER SAYS THAT REPLACING THE STEERING PUMP WILL SOLVE ALL THE PROBLEMS INCLUDING THE ELECTRICAL ISSUE. APPARENTLY, THE NEW STEERING PUMP HAS A DESIGN FEATURE THAT ELIMINATES THE ELECTRICAL FAILURE PROBLEM (DEFECT CODE: 0032630100 & LABOR CODE: 0055719). THE MORE THE PUMP OVERHEATS BECAUSE OF THE FAN NON-OPERATION PROBLEM, THE PUMP WILL NEED TO BE REPLACED, IT WILL BE BURNT OUT. ONE THING IS SURE, I HAVE A PREMATURE FAILURE OF THE STEERING PUMP MAKING MY CAR DANGEROUS TO DRIVE. I CAN'T AFFORD TO FIX IT. NOR DO I BELIEVE, I SHOULD BE RESPONSIBLE FOR THE MANUFACTURES DESIGN FAILURE. THE CAR IS NOT FIT TO DRIVE AS INTENDED. WHY IS BMW GETTING AWAY WITH THIS? MANY THOUSANDS AND THOUSANDS OF DRIVERS HAVE THIS SAME PROBLEM. *KB

Mileage: 61,000

4/10/2008 AIRBAG LIGHT ON DASH CAME ON INTERMITTENTLY - MINI DEALER COULD NOT DUPLICATE PROBLEM 9/23/2008 AIRBAG LIGHT ON DASH CAME ON AND STAYED LIT - MINI DEALER FOUND MICRO-CRACKS IN OC3 SEAT MAT FAULT CODE FC71 STORED IN MR55K CHECKED FAULTS REPLACED OC3 SEAT MAT INSTALLED SEAT AND ENABLE SEAT MAT WITH GT1 CLEARED FAULTS SUMMER 2011 - AIRBAG LIGHT ON DASH CAME ON INTERMITTENTLY OCTOBER 2011 - AIRBAG LIGHT ON DASH CAME ON AND STAYED LIT 11/15/2011 - MINI DEALER REFUSES TO COVER UNDER WARRANTY, DESPITE KNOWN ISSUES WITH THIS COMPONENT HAVING A HISTORY OF BEING DEFECTIVE. *TR

Mileage: 45,830

THE STEERING WHEEL ON MY MINI COOPER HAS BECOME HARD TO STEER ON AND OFF FOR THE LAST COUPLE OF DAYS. AT THE ONSET, I WAS GOING AT ABOUT 15 TO 20MPH AND TURNING RIGHT. THE STEERING GOT HARD TO TURN AND I WAS HAVING DIFFICULTY STAYING OUT OF ON COMING TRAFFIC. I PULLED OFF TO THE SIDE OF THE ROAD, TURNED OFF THE CAR AND HOOD UNDER THE HOOD TO SEE IF THERE WAS ANYTHING TO EXPLAIN WHAT WAS GOING ON. I WAS NOT ABLE TO IDENTIFY ANYTHING TO EXPLAIN THIS OCCURRENCE, SO I RESTARTED THE CAR AND IT WAS BACK TO NORMAL. SINCE THEN IT HAS DONE THIS ON AND OFF SEVERAL OTHER TIMES. I CALL THE MECHANIC AND WAS TOLD THESE VEHICLES HAVE LOTS OF PROBLEMS WITH THE STEERING PUMP, COOLING FAN AND RELY SWITCH.

Mileage: 97,005

THE POWER STEERING IN OUR 2005 MINI COOPER HAS A RECENT HISTORY (WITHIN THE PAST YEAR) OF INTERMITTENTLY FAILING, MAKING THE CAR DIFFICULT, IF NOT IMPOSSIBLE, FOR OUR SMALL-SIZED DRIVERS (ABOUT 100 LBS.) TO MANEUVER. THIS HAS PROVED DANGEROUS ON THE ROAD, BUT INJURIES HAVE SO FAR BEEN AVOIDED, JUST WHEN WE WERE GOING TO GET IT FIXED, THE PROBLEM APPEARED TO SELF-CORRECT. THIS WEEK, HOWEVER, THE CAR HAS FAILED TO START OR TAKE A CHARGE TO A ONE-YEAR-OLD BATTERY. OUR RELIABLE AND TRUSTWORTHY MECHANIC CANNOT DIAGNOSE THE SOURCE OF THE PROBLEM, BUT WE ARE WONDERING IF THERE MAY BE A DRAIN ON THE BATTERY FROM THIS POWER STEERING PROBLEM. *TR

Mileage: 46,000

2005 MINI COOPER PASSENGER LIGHT COMES ON WITH OR WITHOUT ANY PASSENGER SITTING. HOWEVER, AFTER DRIVING FOR A WHILE GOES AWAY. WHEN THE CAR IS TURNED OFF AND STARTED AGAIN, THE PASSENGER LIGHT STAYS ON AGAIN. THIS IS NOT NORMAL. I HAVE SEEN OTHER RECALLS FOR DIFFERENT YEARS, WHY 2005 IS NOT A RECALL? *TR

Mileage: 42,500

MY 2005 MINI COOPER S AUTOMATIC SUDDENLY STOPPED TWICE FOR NO APPARENT REASON WHILE DRIVING. CAR WAS ONLY 4 MONTHS OLD, ABOUT 4000 MILES ON CAR. I WAS ACTUALLY IN MOTION, AND THE CAR JUST STOPPED MOVING! I HAD TO TURN OFF THE CAR AND RESTART IT. EML AND CHECK ENGINE LIGHTS CAME ON ONCE THE CAR STOPPED. THE CHECK ENGINE LIGHT STAYED ON FOR A FEW DAYS, THEN WENT OFF, SO I ASSUMED IT WAS A FLUKE AND NOTHING TO WORRY ABOUT (OTHERWISE I ASSUME THE LIGHT WOULD STAY ON). THE SECOND TIME IT HAPPENED WAS EXACTLY THE SAME SCENARIO AS THE FIRST. I HAVE SINCE LEARNED THAT MINI IS CALLING THIS "LIMP MODE", BUT I HAD NEVER RECEIVED ANY RECALL NOTIFICATION FROM MINI, OR ANYTHING INDICATING THAT THEY KNEW ABOUT THIS PROBLEM. HOWEVER, THE DID KNOW, BASED ON WHAT I HAVE READ OF OTHERS WHO COMPLAINED TO THEM ABOUT THE EXACT SAME PROBLEMS!! YET MINI APPARENTLY DID NOT NOTIFY DEALERSHIPS, BECAUSE THE FIRST ONE I CALLED HAD NO IDEA WHAT THE PROBLEM WAS WHICH I DESCRIBED, AND WASN'T GOING TO TAKE ME FOR SERVICE UNTIL 2 WEEKS LATER. I CALLED A SECOND DEALER WHO IMMEDIATELY KNEW THE PROBLEM, AND SAID IT WAS A VOLUNTARY RECALL. STILL I HAD NOT HEARD ANYTHING FROM MINI USA. I TOOK MY CAR IN AND IT WAS FIXED IN AN HOUR--THEY REPROGRAMMED THE DME. THIS IS A SAFETY ISSUE! I STILL HAVEN'T HEARD ANYTHING FROM MINI ABOUT A SAFETY RECALL FOR THIS PROBLEM! MAYBE THEY DIDN'T NOTIFY ME BECAUSE I HAD IT TAKEN CARE OF ALREADY, BUT HAD THIS HAPPENED ON THE FREEWAY, RATHER THAN IN MY NEIGHBORHOOD, I COULD BE DEAD NOW! WHY ISN'T MINI NOTIFYING OWNERS WHO PURCHASED THE 2005 AUTOMATICS!! WHY AREN'T THEY ISSUING A RECALL? ARE THEY WAITING FOR SOMEONE TO BE KILLED? *JB

Mileage: 4,000

WHILE ACCELERATING ONTO THE HIGHWAY, THE CAR LOST POWER TO THE WHEELS AND DID NOT OPERATE PROPERLY UNTIL I TURNED THE CAR OFF AND BACK ON. THE CAR WAS BROUGHT TO THE DEALERSHIP AND THE PROBLEM WAS NOT FOUND OR CORRECTED. A SECOND INCIDENT OCCURRED A FEW WEEKS LATER, AGAIN AS THE CAR WAS ACCELERATING FROM A STOP. THIS TIME, THE POWER RETURNED WITHOUT HAVING TO SHUT THE CAR OFF. *JB

DT: CONSUMER WAS DRIVING HOME WHEN PEOPLE STARTING HONKING AND WAVING AT CONSUMER. BRAKE LIGHTS WERE NOT WORKING. CONSUMER HAD DEALER COME AND GET VEHICLE, DEALER TOLD CONSUMER THAT IT WAS AN ELECTRICAL PROBLEM. CONSUMER SAID THAT VEHICLE WAS IN HER POSSESSION FOR 24 HOURS WHEN BRAKE LIGHTS FAILED. CONSUMER BOUGHT VEHICLE NEW FROM DEALER , WHO SUPPOSEDLY FIXED IT. BUT CONSUMER HAD NOT BEEN ABLE TO CHECK TO SEE IF BRAKE LIGHTS ACTUALLY WORKED. CONSUMER STATED THAT IT WAS SIGNIFICANT THAT THIS HAPPENED AFTER DEALER HAD DONE THE SAFETY PREPARATIONS FOR DELIVERING THE CAR. DEALER SAID THAT THE PREPARATIONS WERE DONE, AND THEY CHECKED THE LIGHTS AND ALL THE FLUID LEVELS.*AK

Mileage: 79