2016 MINI COOPER Problems & Recalls

The rear brake lights and rear signal indicator lights keep going in and out arbitrarily. It's dangerous because it will work fine and then just randomly stop working and then work again. People can't tell if I'm stopping or turning when this randomly occurs. This is currently not a recall on my...

The rear brake lights and rear signal indicator lights keep going in and out arbitrarily. It's dangerous because it will work fine and then just randomly stop working and then work again. People can't tell if I'm stopping or turning when this randomly occurs. This is currently not a recall on my...

The rear brake lights and rear signal indicator lights keep going in and out arbitrarily. It's dangerous because it will work fine and then just randomly stop working and then work again. People can't tell if I'm stopping or turning when this randomly occurs. This is currently not a recall on my...

Oil filter housing failure. MINI issued a recall for this part in 2014 when the third generation MINI Cooper S/JCW first launched. Unfortunately they did not fix the part and now as time goes on, the issue is occurring with high frequency on every BMW/MINI and Toyota Supra with the BMW B46/B48 2.0L ...

Drivetrain error occurred. I pulled codes and found P0015. I added oil, cleared code. The next day the drivetrain error popped back up. Pulled codes and found P0366. I took the vehicle to mechanic for diagnostics and to find the issue. They found faults: 130F11 and 120408. When replacing engine oil ...

Drivetrain error occurred. I pulled codes and found P0015. I added oil, cleared code. The next day the drivetrain error popped back up. Pulled codes and found P0366. I took the vehicle to mechanic for diagnostics and to find the issue. They found faults: 130F11 and 120408. When replacing engine oil ...

While driving straight on an Interstate highway at approximately 65 mph, the right front and left rear brakes momentarily locked up after the windshield wipers were turned on due to light rain starting to fall. This happened multiple times, only when the wipers were turned on. There were no warnin...

While driving straight on an Interstate highway at approximately 65 mph, the right front and left rear brakes momentarily locked up after the windshield wipers were turned on due to light rain starting to fall. This happened multiple times, only when the wipers were turned on. There were no warnin...

Had recurring engine warning light which will only reset for one ignition cycle. Took to dealer to read code and result was "LIN bus communication fault for environmental air catalyst sensor". This is the same problem drivers of the Mini Cooper S model have reported and received an extended warran...

Rear passenger tail light casing/bucket had burnt connections. Replaced casing/bucket and bulb. Worked for short time, tail light failed a second time. Casing/bucket & bulb replaced, again worked for short time and then went out. Took vehicle to another mechanic after passenger side headlight failed...

Rear passenger tail light casing/bucket had burnt connections. Replaced casing/bucket and bulb. Worked for short time, tail light failed a second time. Casing/bucket & bulb replaced, again worked for short time and then went out. Took vehicle to another mechanic after passenger side headlight failed...

My Mini service adviser said the timing case cover is seeping and will continue to get worse until the seep becomes a leak and the oil starts dripping onto the manifold, potentially creating a fire. It is at the seepage stage now and therefore my extended warranty will not fix it. My Mini service ad...

Notes from Beckley Auto Service from 2-12-24. "Verified warning light on, retrieved one code for LIN bus communication fault for environmental air catalyst sensor. Checked and found technical service bulletin (TSB) from Mini Cooper M13 01 19. The chemical composition of the fan shroud contaminate...

* Component/ system that has malfunctioned and failed - The Driver side tail light circuit board and pig tail malfunctioned. The connector has corroded and the plastic plug housing looks melted on the earth / brown wire. This in return damages the the ground connection for the tail light rendering...

* Component/ system that has malfunctioned and failed - The Driver side tail light circuit board and pig tail malfunctioned. The connector has corroded and the plastic plug housing looks melted on the earth / brown wire. This in return damages the the ground connection for the tail light rendering...

There is a design issue resulting in failure of the connector for the rear tail light assembly. The connector corrodes and the plastic plug housing melts. This damages the ground connection for the tail light rendering the turn signal and brake light inoperable on the effected side. This has happ...

There is a design issue resulting in failure of the connector for the rear tail light assembly. The connector corrodes and the plastic plug housing melts. This damages the ground connection for the tail light rendering the turn signal and brake light inoperable on the effected side. This has happ...

Error signal "Secure vehicle with parking brake when stopped" Mini dealer says "common problem" with Mini transmissions and always due to fluid leaking thru shifter onto gear shift mechanism. Lots of forums stating this is common. Unclear why Mini not taking responsibility for this due to poor de...

*The condensation drain hose is not properly draining the condensate from the vehicle. The micro-filter is is absorbing condensate water from the evaporator housing. *After a while the water that sits, turns to mold. You dont know about it until it gets to that point. You breathe in mold, constant...

About two days ago I noticed my MINI started showing an error every time I got into the vehicle saying "Secure vehicle against rolling" I have seen numerous different discussions online but none seemed to come to a solution or single cause of this error. Everything still shifts completely fine in th...

Rear tail lights have a bulb socket and a 6-pin connector that have a tendency to burn at the brown ground wire where the connector and bulb socket meet. Requiring replacement of both parts and disabling the rear tail light (brake, turn, and reverse lights). It requires rewiring the 6-pin connecto...

Rear tail lights have a bulb socket and a 6-pin connector that have a tendency to burn at the brown ground wire where the connector and bulb socket meet. Requiring replacement of both parts and disabling the rear tail light (brake, turn, and reverse lights). It requires rewiring the 6-pin connecto...

"Secure Vehicle from Rolling" comes up in instrument cluster and millions of Mini/BMW's have this problem due to a faulty gear shifter selector knob going bad due to a spring in the gear selector box. Annoying because the part fails over time and dealer wants $3000 for the fix. Please help!!

Tail light assembly including brake light and turn signal failed due to burnt electrical socket and connector. This is caused by a faulty grounding point that is very clearly a manufacturing issue but wasn't considered as a recall for some odd reason. This issue is prominent in several BMW 3,4, and ...

I purchased this vehicle on 9/03/2019 with 29,871 miles. I had to replace the clutch on 5/11/2020 at 39,690 miles. I am now having to purchase yet ANOTHER clutch on 10/17/2022 with 58,850 miles. Two clutches within 3 years is just unacceptable!

Transmission-get message when opening car door to put parking brake on to secure vehicle from rolling… Car does not roll, goes into gear with no problem… on the mini message board a lot of owners getting the same message….

SEAT BACK MECHANISM FAILED. COULD NOT LATCH IN PLACE. FAILED WITH NO WARNING WHILE DRIVING. MOTOR MOUNT BROKEN WITH MILAGE ONLY AT 56,000 MILES.

SEAT BACK MECHANISM FAILED. COULD NOT LATCH IN PLACE. FAILED WITH NO WARNING WHILE DRIVING. MOTOR MOUNT BROKEN WITH MILAGE ONLY AT 56,000 MILES.

Left side headlight has needed to be replaced three different times at a cost of $1400 each time.

Car only has 48000,00 miles and tie rods need replaced This is not normal ware for a car. My Ford Fusion has 98000.00 and just now needs tie rods. This has to be a defect

The harmonic balancer aka crank damper went on my 2016 4dr hardtop 1.5L Mini Cooper. Has 73,000 miles on it. It has been sitting at a garage now for almost a month waiting for bmw to have the part in stock (tentative date avail. Sept.20, making it 2months wait time) tried every possible 3rd party pa...

The harmonic balancer aka crank damper went on my 2016 4dr hardtop 1.5L Mini Cooper. Has 73,000 miles on it. It has been sitting at a garage now for almost a month waiting for bmw to have the part in stock (tentative date avail. Sept.20, making it 2months wait time) tried every possible 3rd party pa...

The harmonic balancer aka crank damper went on my 2016 4dr hardtop 1.5L Mini Cooper. Has 73,000 miles on it. It has been sitting at a garage now for almost a month waiting for bmw to have the part in stock (tentative date avail. Sept.20, making it 2months wait time) tried every possible 3rd party pa...

Check engine light comes on. The vehicle is giving code 1b8302. This code is for environmental air sensor BUS communication error. There is an extended warranty issued by Mini for other models for the exact same issue. Dealership/Mini will not cover the cost to repair my vehicle as it has been exclu...

TL* THE CONTACT CALLED ON BEHALF OF HER SON WHO OWNED A 2016 MINI COOPER S. THE CONTACT STATED THAT WHILE HER SON WAS DRIVING APPROXIMATELY 45 MPH, ANOTHER VEHICLE RAN A STOP SIGN AND CRASHED INTO THE DRIVER'S SIDE DOOR SENDING THE VEHICLE 10-15 FEET HEAD-ON INTO A TREE. THE CONTACT STATED THAT THE ...

Mileage: 43,500

REAR LIGHT CONNECTOR OVER HEATING, MELTING AND SHORTING.

REAR LIGHT CONNECTOR OVER HEATING, MELTING AND SHORTING.

WAS IN A SIGNIFICANT MOTOR VEHICLE ACCIDENT ON 2.18.20. DRIVING ON US-98WEST 2016 MINI COOPER 4DOOR WHEN LARGE CHEVY2500 PICKUP TRUCK STOPPED SUDDENLY IN FRONT OF ME. I WAS TRAVELING AT ABOUT 45-50MPH. I WAS WEARING MY SEATBELT. I SLAMMED ON BRAKES BUT MADE FULL CONTACT WITH BACK OF TRUCK, I WAS...

Mileage: 97,359

WAS IN A SIGNIFICANT MOTOR VEHICLE ACCIDENT ON 2.18.20. DRIVING ON US-98WEST 2016 MINI COOPER 4DOOR WHEN LARGE CHEVY2500 PICKUP TRUCK STOPPED SUDDENLY IN FRONT OF ME. I WAS TRAVELING AT ABOUT 45-50MPH. I WAS WEARING MY SEATBELT. I SLAMMED ON BRAKES BUT MADE FULL CONTACT WITH BACK OF TRUCK, I WAS...

Mileage: 97,359