2009 MITSUBISHI LANCER RALLIART Power Train Problems

S-AWC PUMP HAS A CORRODIBLE HOUSING AND IS PLACED IN AN AREA THAT IS EXPOSED TO SALT AND WATER FROM THE REAR PASSENGER-SIDE WHEEL. THE PLACEMENT OF THE PUMP IS A DESIGN FLAW AND HAS LED TO SEVERE CORROSION OF THE PUMP HOUSING AND FAILURE OF THE PUMP. THE FAILURE OF THE PUMP COMPLETELY DISABLES BOTH THE ACTIVE CENTER DIFFERENTIAL AND THE ACTIVE YAW CONTROL SYSTEMS, BOTH OF WHICH ARE INTENDED TO ASSIST THE DRIVER IN CONTROLLING THE CAR UNDER ADVERSE HANDLING SITUATIONS.

Mileage: 100,000

MITSUBISHI LANCER DCT470 SST TRANSMISSION RECALL - MY TRANSMISSION LOST EVEN GEARS WHILE DRIVING HOME FROM WORK. THE CAR SELECTED A LOWER GEAR AND THE CHECK ENGINE LIGHT TURNED ON. I PULLED OVER TO TROUBLESHOOT AND EVENTUALLY MADE IT HOME. THIS COSTLY REPAIR FORCED ME TO BUY ANOTHER CAR AND HAVE SINCE LEFT THE REPAIR UNATTENDED. THIS IS A KNOWN MANUFACTURER DEFECT. THE PROBLEM IS SO COMMON THAT A PETITION WAS STARTED TO HELP THOSE OTHERS THAT WERE ALSO AFFECTED BY THIS ISSUE. THE PROBLEM IS A SHIFT FORK MAGNET BECOMES DISLOCATED FROM THE BRACKET AND WILL NOT ALLOW THE TRANSMISSION TO SELECT EVEN GEARS. IN ORDER TO REPAIR, A SPECIALIST MUST DISASSEMBLE AND REBUILD THE CASE. IT IS NOT CAUSED FROM ANY MAINTENANCE NEGLECT NOR DRIVING HABIT OR ABUSE. IT CAN OCCUR IN ALL MODELS WITH THIS SPECIFIC TRANSMISSION. IT IS A WORLDWIDE ISSUE INCLUDING CANADA & AUSTRALIA. I HAVE NOT YET REPAIRED MY PERSONAL TRANSMISSION AND HOPE TO DO SO IN THE FUTURE. THE CAR HAS BEEN PARKED SINCE THE INCIDENT OCCURRED. MAYBE WITH YOUR HELP MITSUBISHI CAN RECTIFY THIS PROBLEM FOR ME, ALL THOSE AFFECTED, AND PREVENT IT FROM HAPPENING TO FUTURE OWNERS. PLEASE NOTE I'M NOT ALONE IN THIS ISSUE AND MORE PEOPLE WILL COME FORWARD HTTPS://WWW.CHANGE.ORG/P/MIGUEL-MELENDEZ-ALL-MITSUBISHI-LANCER-SST-DCT470-W6GDA-TRANSMISSION-SHOULD-BE-RECALLED

Mileage: 90,000

TAKATA RECALL SINCE I BOUGHT THE CAR THE ACD PUMP HAS BEEN FINE. BACK IN SEPTEMBER THE RED TRIANGLE CAME ON AND I DID SOME RESEARCH TO FIND OUT WHAT IT MEANT. I BARLEY DRIVE THE CAR BECAUSE OF THE ISSUE. IT SEEMS SEVERAL OTHER PEOPLE HAVE HAD THIS PROBLEM TOO. MITSUBISHI WANTS TO CHARGE ME $800-$1200 TO FIX IT. I REFUSE TO PAY THIS AMOUNT AFTER SEEING EVERYONE ELSE HAS THIS SAME ISSUE.

Mileage: 98,000

I WAS DRIVING TO WORK AND THE CAR STARTED ACTING STRANGE. IT WOULD ONLY SWITCH TO SELECT GEARS. I TOOK IT STRAIGHT TO A MITSUBISHI SERVICE WHERE THEY INFORMED ME THAT TRANSMISSION WAS FAILING. THEN THEY TOLD ME IT WOULD COST $12000 TO REPAIR. THEY ALSO SAID THE CAR NEEDS A NEW AWD DIFFERENTIAL PUMP BUT THAT WOULD BE FREE. UPON MY RESEARCH AND WHAT ONE OF THE TECHS TOLD ME AWD PUMP CAN SCREW UP THE TRANSMISSION. HOW CAN THEY NOT COVER THE COST OF REPAIR FOR TRANSMISSION IF A FAULTY PART CAUSED IT.

Mileage: 81,300

AS I WAS DRIVING MY CAR IT BEGAN TO JERK I PULLED OVER AND SHUT THE CAR OFF WHEN I STARTED IT AGAIN THE AWC LIGHT CAME ON AND WAS NOT FUNCTIONING AFTER WHEN PULLING OFF I NOTICED THE CAR DID NOT WANT TO SHIFT GEARS UNLESS IN MANUAL FOR SO THE SST HAD FAILED ON ME

Mileage: 84,000

4WD SERVICE REQUIRED LIGHT POPPED UP IMMEDIATELY WHEN ACCELERATING. ACD PUMP MAY HAVE FAILED. MITSUBISHI DOES NOT COVER THIS AS IT IS NOT "PART OF THE DRIVETRAIN". CAN BE DANGEROUS WHEN PUMP GOES OUT. *TR

Mileage: 44,000

I STOPPED AT A LIGHT, THE WHEN I WENT TO MAKE A LEFT TURN MY DASH BEGAN TO FLASH A "SERVICE REQUIRED" LIGHT AT ME. AFTER DOING SOME INVESTIGATION, IT TURNS OUT THAT IT IS AN EXTREMELY WELL KNOWN AND UNADDRESSED ISSUE WITH THE CAR'S ACD PUMP FAILING. IT'S A DESIGN FLAW THAT COSTS THOUSANDS OF DOLLARS TO FIX, BUT FAILURE OF THE PART IS PRACTICALLY GUARANTEED. WHY THERE'S NO RECALL YET IS COMPLETELY RIDICULOUS. *TR

Mileage: 75,000

I STARTED MY CAR THE AWC SELECTION LIGHT STARTED FLASHING. AS I DROVE IT STOPPED FLASHING. THEN THE AWC SERVICE REQUIRED LIGHT CAME ON I BROUGHT IT TO THE DEALER THEY TURNED THE LIGHT OFF SAID IT WAS A ECU UPDATE. AS IT GOT WARM OUT IT CAME ON PERIODICALLY BUT WOULD TURN OFF. EVERY TIME I BROUGHT IT TO THE DEALER THEY COULDN'T DUPLICATE THE PROBLEM. NOW THE LIGHT HAS COME ON AND STAYED ON. THE CODES ARE FOR PUMP FAILURE. *TR

Mileage: 35,000

AWC PUMP FAILED AFTER ABOUT 20,000 MILES IN THE CAR. PROBLEM SEEMS TO BE VERY COMMON FOR THE EVO X AND REALLIART MODELS 2008 AND AFTER. CAR DOES NOT HANDLE WELL WITH THIS SETTING AND IS NOT SAFE TO DRIVE IN THE WINTER BECAUSE CAN'T SET TO SNOW MODE. COST TO REPLACE IS AROUND $2K AND MITSU KEEPS STATING THIS IS NOT COVERED BY POWERTRAIN WARRANTY AND IS A MAINTENANCE ITEM. NEVER HEARD OF A $2K MAINTENANCE ITEMS. THERE ARE NUMEROUS REPORTS THAT STATE THE CAUSE OF THIS IS THE WRONG TYPE OF OIL USED AND THE FACT THAT THE PART IS NOT MADE OF DURABLE MATERIAL CAUSING RUST AND FAILURE. SEEMS TO BE A DESIGN FLAW. PLEASE HELP. *TR

Mileage: 20,500

I WAS PULLING OUT OF A PARKING SPOT AND MY AWC LIGHT CAME ON. I TOOK IT TO THE DEALER AND THEY TOLD ME THAT THERE WAS NOTHING WRONG WITH MY AWD PUMP. I HAD TO PAY A $45.00 DIAGNOSTIC FEE FOR THEM TO LOOK AT IT. I AM WORRIED THAT THE PUMP WILL EVENTUALLY FAIL COMPLETELY AND I WILL OUT OF LUCK. I KNOW THAT THE PUMP GOES BAD ON THESE CARS, AS I HAVE READ A TON OF DIFFERENT COMPLAINTS ABOUT THEIR RALLIART/EVO HAVING THE SAME ISSUE. *TR

Mileage: 57,200

AS I WAS DRIVING HOME FROM WORK I GOT A SERVICE REQUIRED ON SCREEN, SHUT MY CAR OFF IT WENT AWAY. NEXT DAY DRIVING TO WORK SAME THING. IT CONSISTENTLY COMES ON WELL DRIVING AND GOES AWAY ON START UP. HAD AN ALIGNMENT DONE, BALANCED ALL TIRES AND NO CHANGE. SHOP INFORMED ME OF A CODE C161E. ACD PUMP FAILURE. MITSUBISHI STATED AS ITS OVER 60K MILES I HAVE NO POWER-TRAIN COVERAGE AND A NEW PUMP AND REPLACEMENT WAS AROUND $2000. KINDA STRANGE A PART THAT SEEMS TO HAVE SO MANY ISSUES ALL OVER THE US AND CANADA THE CAN'T DO A RECALL? *TR

Mileage: 63,442

THERE IS AN ALL WHEEL TRACTION CONTROL PUMP FOR ONE OF THE CARS MAIN FEATURES. THIS PUMP IS LOCATED DIRECTLY BEHIND THE REAR WHEEL. WHEN YOU LIVE IN AN AREA THAT IS COLD AND THE ROADS ARE SALTED THE PUMP GETS SPLASHED WITH SALTY ROAD WATER AND CORRODES THE PUMP. THIS LEADS THE PUMP TO FAIL AND EXTREMELY LOW MILES. THE WORST PART IS THAT FOR SOME REASON MITSUBISHI DOES NOT COVER THIS UNDER ITS PUMPS OR POWER TRAIN WARRANTY. IT IS ALSO AND INCREDIBLY EXPENSIVE PART. MY PART FAILED BEFORE 40,000 MILES. *TR

Mileage: 38,000

AS I WAS DRIVING MY CAR TO WORK LAST WEEK A LIGHT CAME ON THAT LOOKS LIKE MY TIRES ARE UNBALANCED..?... THINKING I MIGHT NEED NEW TIRES, I BROUGHT MY CAR TO THE DEALERSHIP. THE DEALERSHIP ASSURED ME THAT I DID NOT NEED TIRES. I HAD MY OIL CHANGED AND MY TIRES ROTATED INCLUDING A FRONT END ALIGNMENT AND AN INSPECTION. WHEN I STARTED TO DRIVE AWAY FROM THE DEALERSHIP, A LIGHT CAME ON AGAIN. I TURNED AROUND AND BROUGHT IT RIGHT BACK.THE DEALER PUT MY CAR ON A MACHINE AND TOLD ME THE ISSUE IS "CODE C161E" -INTERMITTENT ISSUES WITH AWD CONTROL PUMP AND THIS PART ALONE WOULD COST $2000.00.MY CAR IS A 2009 WITH ONLY 31000 MILES ON IT. THE DEALER TOLD ME THAT MY THREE YEAR WARRANTY IS UP HOWEVER I STILL HAVE 5000 MILES. HOW COULD THIS HAPPEN WITH SUCH MINIMAL MILES? I DRIVE MY CAR TO WORK AND HOME MOSTLY AND TAKE GOOD CARE OF IT. WHEN I RESEARCHED THIS ISSUE ONLINE I FOUND MULTIPLE PEOPLE WITH THE SAME ISSUE AND HAVE REPORTED THE ISSUE. HOWEVER, NOTHING SEEMS TO BE GETTING RESOLVED EXCEPT BAD FEELINGS. IF THIS IS SUCH A HUGE ISSUE (AS IT SEEMS TO BE ONLINE) WHY DOES MITSUBISHI NOT DO SOMETHING ABOUT THIS. HOW CAN THEY JUST GET AWAY WITH A MALFUNCTIONING AUTO PART THAT NORMAL EVERYDAY PEOPLE, STILL MAKING CAR PAYMENTS, CAN NOT AFFORD. I WOULD REALLY APPRECIATE ANYTHING YOU COULD DO TO HELP ME GET THIS ISSUE REPAIRED AS I DO NOT WANT TO GET RID OF MY CAR. I DO NOT FEEL THIS SHOULD BE THE CONSUMERS PROBLEM BUT THE MANUFACTURERS. THANK YOU VERY MUCH FOR YOUR TIME. *TR

Mileage: 31,834

ALL WHEEL CONTROL PUMP UNITS CONTINUE TO FAIL WITH OUT MITS... ATTEMPTING TO RESOLVE THE ISSUE. COSTING MIN $2000 FOR REPAIRS. THEY MOST OF THE TIME REFUSE TO REPLACE A POORLY ENGINEERED AWC PUMP. UNDER A SUPPOSED AWESOME WARRANTY. THESE UNITS ARE FAILING ALL OVER CANADA & US. WITH MITS KNOWING ITS A PROBLEM. BUT NOT RESOLVING IT. HELP US OWNERS PLEASE. I DON'T WANT TO OR SHOULD HAVE TO REPLACE A $2000 PUMP EVERY 10,000 KMS. *TR

Mileage: 77,000

TL* THE CONTACT OWNS A 2009 MITSUBISHI LANCER RALLIART. THE CONTACT STATED THAT ONLY CERTAIN GEARS COULD BE ENGAGED WHEN DRIVING AT VARIOUS SPEEDS. WHEN SHIFTING INTO REVERSE, THE INDICATOR MODULE WOULD INDICATE THAT THE VEHICLE WAS IN REVERSE BUT THE VEHICLE WOULD NOT ENGAGE IN REVERSE. WHEN ATTEMPTING TO REVERSE, THE TRANSMISSION WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE THEY ADVISED HIM THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 25,000.

Mileage: 25,000

THE TRANSMISSION TC-SST IS FAILING ON THE 2009 RALLIART FROM MITSUBISHI THE GEARS GO CRAZY ON ME AND JUMP AROUND AND GEARS ARE SLIPPING AND GETTING STUCK. OTHER PEOPLE WITH THE SAME CAR HAVE EXPERIENCED THE SAME THING I THINK IT SHOULD BE RE-CALL TO GET THIS FIXED. IT CAN CAUSE A MAJOR ACCIDENT ON THE HIGHWAY WHICH IT ALMOST DID FOR ME. *TR

Mileage: 14,500

I'LL TURN THE CAR ON AND PUT IT INTO REVERSE BUT THE GEAR DOES NOT ENGAGE. THE REVERSE LIGHT ON THE DISPLAY PANEL JUST CONTINUES TO BLINK. ANOTHER ISSUE INVOLVING THE TRANSMISSION OCCURS WHEN TRYING TO ACCELERATE. WHEN APPLYING PRESSURE TO THE GAS PEDAL, THE CLUTCH FAILS TO ENGAGE CAUSING IT TO SLIP WHEN SHIFTING GEARS. ALSO WHEN TRYING TO ACCELERATE TO PASS ANOTHER VEHICLE THE CAR WILL NOT ACCELERATE, THE RPMS JUST SHOOT THROUGH THE ROOF FURTHER PROVING OF CLUTCH SLIPPAGE. AT THIS POINT, THE CAR WILL LOSE THE ABILITY TO SHIFT TO 2, 4, OR 6 GEAR MAKING NORMAL CITY/HIGHWAY DRIVING VERY HAZARDOUS. WHEN COMING TO A STOP THE CAR WILL DOWNSHIFT FROM 5TH TO 3RD AND THEN TO 1ST PUTTING TONS OF PRESSURE ON THE BRAKES INSTEAD OF DECELERATING THE CAR GRADUALLY. THE CAR ACTUALLY HESITATES AT THIS POINT AS IF IT DOES NOT WANT TO STOP. WHEN ACCELERATING FROM A COMPLETE STOP THE CAR WILL RED LINE FIRST GEAR AND THEN SHIFT TO 3RD AND REPEAT TO SHIFT TO 5TH GEAR. THIS IS NOT SAFE AT ALL, AS I LOSE THE ABILITY TO MANUALLY SELECT GEARS. THIS HAS BEEN AN ONGOING OCCURRENCE IN MY 2009 MITSUBISHI LANCER RALLIART SINCE DECEMBER OF 2009, AND IT IS NOW MARCH 1, 2010. I HAVE BROUGHT THIS ISSUE TO THE ATTENTION OF THE SERVICE DEPARTMENT WITHOUT ANY HELP OR ACCEPTANCE OF THIS BEING UNDER WARRANTY. THERE ARE SEVERAL OTHER CASES WHERE PEOPLE ARE EXPERIENCING THE SAME/SIMILAR ISSUES. THIS TRANSMISSION PROBLEMS IS A SERIOUS ISSUE, ALMOST AN ACCIDENT WAITING TO HAPPEN. *TR

Mileage: 18,849

I'LL TURN THE CAR ON AND PUT IT INTO REVERSE BUT THE GEAR DOES NOT ENGAGE. THE REVERSE LIGHT ON THE DISPLAY PANEL JUST CONTINUES TO BLINK. ANOTHER ISSUE INVOLVING THE TRANSMISSION OCCURS WHEN TRYING TO ACCELERATE. WHEN APPLYING PRESSURE TO THE GAS PEDAL, THE CLUTCH FAILS TO ENGAGE CAUSING IT TO SLIP WHEN SHIFTING GEARS. ALSO WHEN TRYING TO ACCELERATE TO PASS ANOTHER VEHICLE THE CAR WILL NOT ACCELERATE, THE RPMS JUST SHOOT THROUGH THE ROOF FURTHER PROVING OF CLUTCH SLIPPAGE. AT THIS POINT, THE CAR WILL LOSE THE ABILITY TO SHIFT TO 2, 4, OR 6 GEAR MAKING NORMAL CITY/HIGHWAY DRIVING VERY HAZARDOUS. WHEN COMING TO A STOP THE CAR WILL DOWNSHIFT FROM 5TH TO 3RD AND THEN TO 1ST PUTTING TONS OF PRESSURE ON THE BRAKES INSTEAD OF DECELERATING THE CAR GRADUALLY. THE CAR ACTUALLY HESITATES AT THIS POINT AS IF IT DOES NOT WANT TO STOP. WHEN ACCELERATING FROM A COMPLETE STOP THE CAR WILL RED LINE FIRST GEAR AND THEN SHIFT TO 3RD AND REPEAT TO SHIFT TO 5TH GEAR. THIS IS NOT SAFE AT ALL, AS I LOSE THE ABILITY TO MANUALLY SELECT GEARS. THIS HAS BEEN AN ONGOING OCCURRENCE IN MY 2009 MITSUBISHI LANCER RALLIART SINCE DECEMBER OF 2009, AND IT IS NOW MARCH 1, 2010. I HAVE BROUGHT THIS ISSUE TO THE ATTENTION OF THE SERVICE DEPARTMENT WITHOUT ANY HELP OR ACCEPTANCE OF THIS BEING UNDER WARRANTY. THERE ARE SEVERAL OTHER CASES WHERE PEOPLE ARE EXPERIENCING THE SAME/SIMILAR ISSUES. THIS TRANSMISSION PROBLEMS IS A SERIOUS ISSUE, ALMOST AN ACCIDENT WAITING TO HAPPEN. *TR

Mileage: 18,849