2018 NEWMAR DUTCH STAR Problems & Recalls

Window Adhesive Failure Adhesive failure may cause the vent portion of the window to detach, increasing the risk of a crash or injury. NHTSA Campaign Number: 21V571000 Manufacturer Newmar Corporation Components EQUIPMENT, STRUCTURE Had to purchase 4 windows from Newmar For the window failures in NHT...

I used the Hydralift to carry my wife’s motorcycle, a 2018 Indian Chieftain. When you mount a Hydra lift on the back of an RV you no longer have access to the receiver hitch that came with the RV. Because of that Hydralift adds a receiver hitch to the lift so that you can flat tow a vehicle behind...

The driver's side window is a dual pane window. The glass has lost its seal letting moisture in between the panes causing a drivers visibility issue. Driver is unable to see in the rear mirror or to the left side of the vehicle. Vehicle manufacturer claims vehicle is out of warranty and denied any r...

The driver's side window is a dual pane window. The glass has lost its seal letting moisture in between the panes causing a drivers visibility issue. Driver is unable to see in the rear mirror or to the left side of the vehicle. Vehicle manufacturer claims vehicle is out of warranty and denied any r...

Entry door unlatches and allows door to open at highway speed, unless secondary deadbolt lock is manually latched. This occurred twice on my recent trip. Manufacturer has worked/examined this issue on 2 previous occasions. Standard door latch does not secure door as designed.

Blowout and tire separation, Drivers front, traveling N on I-25 mile marker 7, south of Trinidad Co. Using Tire Patrol sensors on all motorhome tires and tow vehicle. After replacing tire and rim and on our way back home I noticed a low tire pressure on the right front tire. On inspecting the sens...

Three week ago today we were 500 miles into a road trip when the check engine light and alarm went off - we exited interstate at the next exit, called Spartan, and read off the codes. We were told that it was a DEF sensor that would be derating our engine and we need to get somewhere soon.. We w...

We got the check engine light on after starting up our coach on July 6. We got several fault codes: SPN 3364 FMI 9, SPN 1761 FMI 9, SPN 3031 FMI 9. The codes indicated that we had a faulty DEF Header and it needed to be replaced. And if we drove the coach at some point it would "derate" to 5 m...

Since purchasing this RV new, I have had the DEF Head fail twice. 1st time was Sep 2019 with a mileage of 14066 and the 2nd time was April 2021 with a mileage of 16018. Both times DEF Header Assemblies were replaced. When these fail the motor can de-rate at any time. Very dangerous when travelin...

Since purchasing this RV new, I have had the DEF Head fail twice. 1st time was Sep 2019 with a mileage of 14066 and the 2nd time was April 2021 with a mileage of 16018. Both times DEF Header Assemblies were replaced. When these fail the motor can de-rate at any time. Very dangerous when travelin...

When preparing to leave, my coach received a check engine light, and 3 error codes from the Cumins ECU. SPN 3364, 1761 and 3031. All FMI code 9. My engine is Likely now debated to 5% power and I was just able to return it to the driveway at the house. Thankfully I hadn’t gotten onto the busy i...

When preparing to leave, my coach received a check engine light, and 3 error codes from the Cumins ECU. SPN 3364, 1761 and 3031. All FMI code 9. My engine is Likely now debated to 5% power and I was just able to return it to the driveway at the house. Thankfully I hadn’t gotten onto the busy i...

The failure has occurred in the emission system. The DEF SENSOR set off 2 Check Engine light warnings on the dash. It did not tell me any other information. I was fortunate to return from my trip without incident. However, after speaking with the chassis manufacturer (Spartan), I was fortunate to ...

Shortly after departing from J&J RV Park in Hot Springs, Arkansas, in my vehicle, a motorhome, two yellow check-engine lights illuminated on the dashboard. I continued driving for 52 miles to my next destination, Downtown Riverside RV Park in North Little Rock, Arkansas. The engine ran normally, a...

Diesel Exhaust Fluid Control unit failed 04/28/21 @ 21,151 miles. Unfortunately this can cause the motor to de-rate with speed restricted to 5mph. Very dangerous on the freeway. Problem was confirmed by the Cummins codes generated and verified by both Spartan motors as well as the repair facility...

THE FRAMELESS WINDOWS, USUALLY THE VENT PORTION HAS SEPARATED FROM THE DUAL PANES. THE SEALS COME APART CAUSING THE OUTER PANE TO BE ABLE TO SEPARATE FROM THE INNER PANE. THIS COULD SEPARATE WHILE DRIVING DOWN THE ROAD. I HAVE BEEN FORTUNATE SO FAR AS I HAVE NOTICED THE PROBLEM BEFORE DRIVING. THIS ...

Mileage: 11,000

CHECK ENGINE LIGHT CAME ON, CONTACTED CUMMINS WITH CODE. I WAS TOLD THE DEF HEAD NEEDED TO BE REPLACED. MOTORHOME HAD 5211 MILES. MADE AN APPOINTMENT AND HAD HEAD REPLACED

Mileage: 5,000

DEF SYSTEM FOR DIESEL ENGINE STARTED TO FAIL CAUSING REDUCTION IN PERFORMANCE OF MOTOR HOME. IF I HAD NOT BEEN ABLE TO GET DIRECTLY TO A FREIGHTLINER SERVICE CENTER, I WOULD HAVE ENDED UP ON THE INTERSTATE ABLE TO GO ONLY FIVE MILES PER HOUR AND NEEDING TO BE TOWED. THIS IS AN ON GOING KNOWN PROBLEM...

Mileage: 10,000

THE DRIVER'S WINDSHEILD WIPER DOES NOT CONTACT THE GLASS EXCEPT AT THE VERY TOP FOR THE LAST 30% OF THE STROKE LEAVEING THE PORTION DIRECTLY IN FRONT OF THE DRIVER WITHOUT THE NEEDED VIEW. NEWMAR REPLACED THE WIPER BLADE, BUT STILL HAVE THE PROBLEM.

Mileage: 6,500