1994 PLYMOUTH VOYAGER Structure Problems

TL* THE CONTACT OWNS A 1994 PLYMOUTH VOYAGER. WHILE PARKED, THE CONTACT NOTICED THAT THE REAR PASSENGER SIDE SLIDING DOOR WOULD NOT CLOSE. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

Mileage: 145,000

TL*THE CONTACT OWNS A 1994 PLYMOUTH VOYAGER. WHILE CLOSING THE LIFT GATE, THE LIFT BAR FAILED AND SHATTERED THE REAR WINDOW. THE CONTACT SUSTAINED CUTS AND BRUISES ON HIS HANDS. THE INSURANCE INSPECTOR STATED THAT THE CAUSE WAS DUE TO A MECHANICAL FAILURE. RECALL # 99V213000 (STRUCTURE:BODY:HATCHBACK/LIFTGATE:HINGE AND ATTACHMENTS) WAS FOUND. THE CURRENT AND FAILURE MILEAGES WERE 114,000.

Mileage: 114,000

THE LIFTGATE SUPPORT BRACKET RECALL 99V210000 REMEDY FAILED. THIS RESULTED IN THE LIFTGATE OPENING WHILE DRIVING.*AK

Mileage: 1,000

THE SLIDING DOOR BECAME DISCONNECTED FROM THE VAN, AND FELL ONTO ON THE HIGHWAY. *JB

WHILE THE REAR HATCH WAS LIFTED, THE DOOR SUDDENLY RELEASED AND SLAMMED DOWN ONTO CONSUMERS BACK. *JB THERE WAS NO ADVANCED WARNING OF THE FAILURE. SCC

Mileage: 110,000

BOTH DOORS FAILED WITHIN 24 HOURS OF EACH OTHER. DT

CONSUMER STATES THAT WHILE DRIVING AT 35MPH THE HATCHBACK DOOR LIFTED UNLOCKING ITSELF CAUSING A DISTRACTION TO THE CONSUMER. DEALER NOTIFIED. TS

THE HINGES ON THE HATCH BACK HAS BROKEN OFF AT THE BOLT AREA. THE HATCH BACK CAN NOT BE CLOSED. THE OWNER TOOK THE VAN TO THE DEALERSHIP AND THEY PERFORMED A TEMPORARY FIX ON THE BOLTS/HINGES. NLMWITH THE HINGE BROKEN IT ALLOWS CARBON MONOXIDE TO ENTER THE VEHICLE. *JG

CONSUMER STATES THAT WHILE DRIVING THE LIFT GATE BOLTS SNAPPED. DEALER NOTIFIED. *MR

WHILE DRIVING ABOUT ANY MPH, COULD HEAR NOISE COMING FROM REAR DOOR, AND IT FELT LIKE DOOR WAS GOING TO BE OPENED. HAD CONTACTED DEALE, BUT IT COULD NOT BE FIXED. PLEASE PROVIDE MORE INFORMATION.*AK

DRIVER'S SIDE FRONT PILLAR WHERE HINGE OF DOOR IS ATTACHED HAS A STRESS FRACTURE NEAR LOWER HINGE.*AK

SLIDING DOOR HAS FALLEN OFF ON TWO OCCASIONS. AND NOW I CANT OPEN THE DOOR BECAUSE IT WILL FALL OFF AGAIN.*AK

AS CONSUMER LIFTED TAILGATE SMALL BOLT THAT HOLDS HINGES ON DRIVER'S SIDE SNAPPED. CONSUMER WAS NOT INJURED. NO PRIOR WARNING.*AK

LIFTGATE BROKE FROM THE HINGE. A RECALL NOTICE WAS RECEIVED BUT THE DEALER WOULDN'T REPAIR IT. THE PROBLEM WASN'T RELATED TO THE RECALL ID #99V213000 MANF#730.

CONSUMER WAS CLOSING TAILGATE AND GLASS SHATTERED. IT WAS COLD OUTSIDE, NO HEAT WAS ON. DEALER WILL BE CONTACTED. THIS WAS 2ND INCIDENT. *AK

SLIDING DOOR ON SIDE OF TRUCK FELL OFF IN PARKING LOT.*AK

CONSUMER REPAIRED LIFTGATE SUPPORTING BOLTS PRIOR TO RECALL 95I001001 AND IS REQUESTING REIMBURSEMENT. *SLC

CONSUMER REPAIRED LIFTGATE SUPPORTING BOLTS PRIOR TO RECALL 95I001001 AND IS REQUESTING REIMBURSEMENT. *SLC

THE DOOR POST ON RIGHT AND LEFT FRONT DOORS IS BREAKING OUT OF THE MAIN FRAME WHERE THE HINGE BOLTS ON I HAVE TALKED TO 5 AUTO BODY REPARE SHOP AND THEY SAY THAT THEY HAVE SEEN SEVERAL OF THIS TYPE OF PROBLEM IN THE LAST 2-3 YEARS. *AK

CHARGED $178.15 TO INSTALL SPECIAL SHIELD TO PREVENT THE PROBLEM AFTER THE 6TH FAILURE. *AK

WHILE MAKING A RIGHT TURN THERE IS A "BANGING" NOISE WHICH SOUNDS LIKE SOMETHING MAY FALL OUT AND CAUSE A CRASH. DEALER REPLACED STEERING RACK AND PINION TWICE AND STRUTS. THERE WAS A CRACK K FRAME WHICH THE DEALER HAD TO WELD BACK TOGETHER, BUT THE PROBLEM IS STILL OCCURRING. DEALER COULD NOT DETERMINE CAUSE OF THE PROBLEM. PLEASE PROVIDE FURTHER INFORMATION.*AK

PASSENGERS IN THE REAR OF THE VAN WERE THROWN OUT OF THE LIFTGATE OF THE VEHICLE DURING THE ACCIDENT POSSIBLE DUE TO LIFTGATE FAILURE RESULTING IN DEATH OF ALL 3 PASSENGER. NLM

CONSUMER TRIED ON SEVERAL OCCASION TO HAVE THE VAN REPAIRED UNDER RECALL (99V-213), WAS UNABLE HAVE REPAIR DUE TO DEALER PROBLEM. YH

RECALL # 99V213000 DIAMLER CHRYSLER/LIFTGATE SUPPORT BRACKET: OWNER HAS BEEN WATING FOR OVER A MONTH TO GET REPAIRS MADE. ALSO, OWNER HAS BEEN TO DEALER THREE TIMES AFTER MAKING AN APPOINTMENT. EACH TIME, THE DEALER HAS USED PARTS TO COMPLETE RECALL FOR OTHER OWNERS. *AK

CONSUMER CONTACTED THE DEALER IN REFERENCE TO RECALL NUMBER 99V213000/ MANUFACTURER'S RECALL 730 CONCERNING LIFTGATE SUPPORT BRACKET. DEALER STATED NO PARTS WERE AVAILABLE, AND REFUSED TO CORRECT THE RECALL. *AK

DOORS ARE COMING OFF HINGES. AFRAID DRIVER/PASSENGER WILL FALL OUT. ALSO, CARRIES SMALL CHILDREN IN AUTOMOBILE. *AK

WINDSHIELD WIPER ON THE REAR WINDOW STOPPED WORKING WITHOUT WARNING, WHEN IT IS ACTIVATED IT MAKES A NOISE, BUT IT DOESN'T WIPE THE WINDOWS. DEALER HAS BEEN CONTACTED. ALSO, AIR COMPRESSOR IS GIVING OUT, THE ANTI-FREEZE FERON COMPARTMENT STOPPED WORKING, AND THE REAR GATE FELL OFF WHILE DRIVING. *AK *ML

THE REAR DOOR STRUTS ON BOTH OF SIDES ARE BROKEN WHICH CAUSES THE DOOR TO RELEASE FROM THE UPRIGHT POSITION. PLEASE GIVE ANY FURTHER DETAILS.

DRIVER'S AND PASSENGER'S DOORS ARE TOO HEAVY FOR THE HINGES. THEREFORE ,OVER A LENGTH OF TIME ,THE LATCH MECHANISM WILL NOT BE ABLE TO HOLD THE DOOR, EVEN WITH IT BEING LOCKED. *AK

CONSUMER NOTICED DOORS NOT CLOSING AND OPENING CORRECTLY. DOORS AT BOTH WELDINGS BROKE LOOSE FROM THE HINGES. CONSUMER CONTACTED PLYMOUTH DEALERSHIP TO SET AN APPOINTMENT FOR REPAIRS. *AK

SLIDING SIDE DOOR COMPLETELY FELL OFF THE VEHICLE ONTO THE GROUND WHICH COULD HAVE CAUSED INJURIES. *AK

DOOR HINGE ASSEMBLY /BODY CRACKED, DOOR SAGS AND DOES NOT SECURE EASILY . BRAKES FAILED WHEN APPLIED AT 60MPH DUE TO CRACKED PISTIONS AND WHEEL CYLINDER LEAK.

LIFTGATE SUPPORT SHOCK FAILED CAUSING DOOR TO FALL DOWN ON PASSENGERS HEAD. (QCAW)

THE SHOCK/BRACKET SUPPORTING HATCHBACK AT THE TOP HAD SHEARED OFF & SWUNG AROUND & SHATTERED THE REAR WINDOW. AT THE TIME THE BRACKET BROKE, WAS SHUTTING THE LIFTGATE HATCH. *AK

SLIDING DOOR FALLS OFF. ALSO, ONCE YOU HITTING A BUMP IN THE ROAD IT BEGAN TO COME LOOSE. THE BACK END OF THE SLIDING DOOR ALSO COMES OUT WHILE DRIVING, CONSUMER STATES THAT THEY HAVE TO PULL OFF THE ROAD IN ORDER TO FIX THE DOOR, CONSUMER HAS CONTACTED THE DEALER, THEY STATED IT WAS NOTHING THEY COULD DO ABOUT IT BECAUSE IT WASN'T UNDER WARRANTY. *AK

SLIDING DOOR HANDLE ON VEHICLE BROKE. CAUSE UNKNOWN. PLEASE DESCRIBE. *AK

FAILURE OF THE SLIDING DOOR, WHEN OPENING THE SLIDING DOOR, THE DOOR FELL OFF. *AK

SIDE SLIDING DOOR ROLLED BY ITSELF AND STRUCK CHILD IN THE HEAD. *AK

PURCHASED THRUCK NEW AND ON THREE OCCASIONS THE SLIDING DOOR CAME OFF. PLEASE DESCRIBE . *AK

EXPERIENCING DRIVER SIDE DOOR HINGE FAILURE, DOOR SAGS. TT

REAR WINDOW VENT SHEARED WHILE IT WAS PARKED. TT

RECALL REPAIRS FOR REAR HATCH REFUSED DUE TO UNAVAILABILITY OF PARTS.

OWNER HAS NOTICED WHEN HITTING BUMP OR ABNORMAL ROAD CONDITIONS, WARNING CHIME STARTS AND REAR LIGHT ILLUMINATES ERRATIC. PLEASE DESCRIBE DETAILS. TT

WHILE DRIVING REAR HATCH DOOR POPPED OPEN. TT

SIDE SLIDING DOOR FAILURE, DOOR FELL OFF THE RAIL. TT

REAR LIFTGATE APPEARS TO BE CLOSED/LOCKED, OPENS WHILE DRIVING; ONE OCCASION, DOG FELL OUT OF REAR DOOR. TT

REAR HATCH/LIFTGATE OPENS WHILE DRIVING AT ANY SPEED. TT

ON TWO OCCASIONS, REAR HATCH HAS FAILED OPENING. OWNER IDENTIFIES ON ONE TIME, NO WARNING WAS GIVEN. TT

VEHICLES REAR HATCH RIGHT GATE HINGE BROKE DUE TO POOR DESIGN.BOLT BROKE. TT

BELL SYSTEM KEEP GOING OFF AS IF THE REAR DOOR LATCH FAILED, OWNER THINKS DEALER DISCONNECT BELL SYSTEM. TT

VEHICLE SLIDING DOOR FELL OFF WHILE IN USE. TT

TAIL GATE OPENED 2 TIMES BY ITSELF FOR NO APPARENT REASON.VEHICLE WAS PARKED ON BOTH OCCURANCES. TT