2015 POLARIS SPORTSMAN 1000XP Problems & Recalls
Detailed safety information and owner complaints
Problem Breakdown
Compare to Other Years
Common Problems
The contact owns a 2015 Polaris Sportsman 570. The contact stated while starting the vehicle. The engine ran for approximately 10 minutes and shut off. The contact stated that the failure recurred while driving. Several unknown warning lights were illuminated. The vehicle was towed to the residence....
The contact owns a 2015 Polaris Sportsman 570. The contact stated while starting the vehicle. The engine ran for approximately 10 minutes and shut off. The contact stated that the failure recurred while driving. Several unknown warning lights were illuminated. The vehicle was towed to the residence....
THE ELECTRICAL SYSTEM SHORTS OUT WHEN THE VEHICLE GETS WET AND IT DRAINS THE BATTERY. WATER GETS INTO THE DRIVE BELT WHEN THE VEHICLE GETS WET AND THE BELT SLIPS.
Mileage: 200
THE ELECTRICAL SYSTEM SHORTS OUT WHEN THE VEHICLE GETS WET AND IT DRAINS THE BATTERY. WATER GETS INTO THE DRIVE BELT WHEN THE VEHICLE GETS WET AND THE BELT SLIPS.
Mileage: 200
EXHAUST PIPES FROM MOTOR TO MUFFER CHERRY RED AND PLASTIC MELTING HOT TO THE TOUCH IF U RIDE IT FOR MORE THAN TEN MINS ON DIRT ROAD OR IN CREEKS.
Mileage: 3
THE POOR DESIGN OF THE EXHAUST SYSTEM ROUTES THE HEADER PAST PLASTIC AND YOUR ANKLE AREA. MY EXHAUST HAS, SEVERAL TIMES, HEATED UP TO CHERRY RED. THE LAST TIME IT CAUGHT ON FIRE AND MELTED THE PLASTIC AND BURNED MY BOOT (MY BODILY DAMAGE TO PERSONS). POLARIS REFUSES TO ADMIT A PROBLEM. THE HEAT...
Mileage: 191
EXHAUST TO HEAT
Mileage: 1,750
ATV POLARIS SPORTSMAN 1000 XP 2015 ALMOST NEW, 120 MILES ON IT. EXHAUST HEAT MELTED THE TRANSMISSION SPEED SENSOR HARNESS, FENDER AND OTHER SMALLER PLASTIC PARTS. FLEXIBLE HEAT SHIELDS WERE NOT ENOUGH AND DISTROYED AS WELL. VEHICLE GOT ON FIRE (MELTED PLASITC IGNITED), I TURNED THE FIRE WITH HAN...
Mileage: 120
ATV POLARIS SPORTSMAN 1000 XP 2015 ALMOST NEW, 120 MILES ON IT. EXHAUST HEAT MELTED THE TRANSMISSION SPEED SENSOR HARNESS, FENDER AND OTHER SMALLER PLASTIC PARTS. FLEXIBLE HEAT SHIELDS WERE NOT ENOUGH AND DISTROYED AS WELL. VEHICLE GOT ON FIRE (MELTED PLASITC IGNITED), I TURNED THE FIRE WITH HAN...
Mileage: 120
ATV POLARIS SPORTSMAN 1000 XP 2015 ALMOST NEW, 120 MILES ON IT. EXHAUST HEAT MELTED THE TRANSMISSION SPEED SENSOR HARNESS, FENDER AND OTHER SMALLER PLASTIC PARTS. FLEXIBLE HEAT SHIELDS WERE NOT ENOUGH AND DISTROYED AS WELL. VEHICLE GOT ON FIRE (MELTED PLASITC IGNITED), I TURNED THE FIRE WITH HAN...
Mileage: 120
THE MUFFLER GETS SO HOT IT MELTS THE PLASTIC FENDER STARTS ON FIRE
Mileage: 420
THE MUFFLER GETS SO HOT IT MELTS THE PLASTIC FENDER STARTS ON FIRE
Mileage: 420
AFTER RIDING ON SLOWER TRAILS OR FAST SPEEDS. IT DOESN'T MATTER THE MUFFLER BEGINS TO GLOW ORANGE. CAUSING RIDER DISCOMFORT AND FIRE DANGER TO BOTH VEHICLE AND A DANGER TO ARE BELOVED NATIONAL FOREST. I HAVE TAKEN BACK TO DEALER AND GOT THE IMPROVED EXHAUST SPRINGS AND DONUT INSTALLED. ALSO HAD NEW ...
THE MUFFLER IN THE EXHAUST SYSTEM GLOWS RED AS A CHARCOAL BRIQUET UNDER ALL OPERATIONAL SPEEDS. THIS PRODUCES VERY EXCESSIVE HEAT AND RENDERS THE PLASTIC ABOVE THE REAR FENDER WELL UNTOUCHABLE. THE USFS APPROVED HEAT SHIELD IS VERY FLIMSY AND AT ONE POINT A TWIG GOT CAUGHT BETWEEN THE SHIELD AND THE...
Mileage: 20
MUFFLER ON THIS MACHINE BECOMES RED HOT WITH NORMAL USE, AT SPEEDS OF 15-25 MPH PLASTIC IN AREA OF MUFFLER AND HEAT SHIELD BECOMES TO HOT TO TOUCH, IN SOME CASES MELTING PLASTIC BODY PARTS. IF THIS RED HOT MUFFLER WERE TO COME IN CONTACT WITH BRUSH THERE WOULD BE HIGH PROBABILITY OF FIRE. POLARIS D...
Mileage: 438
MUFFLER ON THIS MACHINE BECOMES RED HOT WITH NORMAL USE, AT SPEEDS OF 15-25 MPH PLASTIC IN AREA OF MUFFLER AND HEAT SHIELD BECOMES TO HOT TO TOUCH, IN SOME CASES MELTING PLASTIC BODY PARTS. IF THIS RED HOT MUFFLER WERE TO COME IN CONTACT WITH BRUSH THERE WOULD BE HIGH PROBABILITY OF FIRE. POLARIS D...
Mileage: 438
WHEN I RIDE THIS BRAND NEW SPORTSMAN XP 1000 THE EXHAUST SYSTEM GETS GLOWING RED HOT, PLASTIC FENDERS NEAR THE EXHAUST ARE UNTOUCHABLE, REAR TIRE IS EXTREMELY HOT, AND SOME GRASS THAT WAS THROWN ONTO THE EXHAUST CAUGHT FIRE. THIS IS A TWO WEEK OLD ATV WITH 13 MILES ON IT. I AM NOT RIDING THIS MACH...
Mileage: 13
WHEN I RIDE THIS BRAND NEW SPORTSMAN XP 1000 THE EXHAUST SYSTEM GETS GLOWING RED HOT, PLASTIC FENDERS NEAR THE EXHAUST ARE UNTOUCHABLE, REAR TIRE IS EXTREMELY HOT, AND SOME GRASS THAT WAS THROWN ONTO THE EXHAUST CAUGHT FIRE. THIS IS A TWO WEEK OLD ATV WITH 13 MILES ON IT. I AM NOT RIDING THIS MACH...
Mileage: 13
EXHAUST RUNNING SO HOT PLASTIC FENDERS MELTED. CONCERNED ABOUT FIRE. JUST RIDING SLOWLY ON AN OFF-ROAD TRAIL . DEALER REPLACED UNDER WARRANTY AND THE MELTED AGAIN WITHIN 20 MILES OF NEXT RIDE.
Mileage: 200
EXHAUST BECOMES RED HOT ONLY AFTER A COUPLE MINUTES OF RIDING. THE EXHAUST MUFFLER IS VERY CLOSE TO THE PLASTIC FENDER AND RIGHT REAR TIRE. BECAUSE IT GETS SO HOT AND SITS SO CLOSE TO THE REAR TIRE I FEAR THAT THERE WILL BE A FIRE. IN FACT, I HAVE NOTICED LEAVES AND GRASS CATCH FIRE FROM NORMAL RIDI...
Mileage: 86
EXHAUST BECOMES RED HOT ONLY AFTER A COUPLE MINUTES OF RIDING. THE EXHAUST MUFFLER IS VERY CLOSE TO THE PLASTIC FENDER AND RIGHT REAR TIRE. BECAUSE IT GETS SO HOT AND SITS SO CLOSE TO THE REAR TIRE I FEAR THAT THERE WILL BE A FIRE. IN FACT, I HAVE NOTICED LEAVES AND GRASS CATCH FIRE FROM NORMAL RIDI...
Mileage: 86
AFTER A 15 MINUTE RIDE, THE MUFFLER WAS SO HOT IT WAS GLOWING RED. THE HEAT PUT OFF BY THE MUFFLER ACTUALLY MELTED MY REAR BODY PANEL ABOVE THE EXHAUST. THE HEAT COULD HAVE EASILY CAUSED A FIRE HAD I PARKED THE UNIT WITHOUT FIRST CHECKING THE EXHAUST, WHICH I DO AFTER EVERY RIDE AFTER READING SIMILA...
Mileage: 209
AFTER A 15 MINUTE RIDE, THE MUFFLER WAS SO HOT IT WAS GLOWING RED. THE HEAT PUT OFF BY THE MUFFLER ACTUALLY MELTED MY REAR BODY PANEL ABOVE THE EXHAUST. THE HEAT COULD HAVE EASILY CAUSED A FIRE HAD I PARKED THE UNIT WITHOUT FIRST CHECKING THE EXHAUST, WHICH I DO AFTER EVERY RIDE AFTER READING SIMILA...
Mileage: 209
THE EXHAUST MUFFLER GETS SO HOT IT GLOWS ORANGE AND YOU CAN SMELL MELTING PLASTIC. I STOPPED RIDING THIS MACHINE DUE TO IT BEING A MAJOR FIRE HAZARD.
Mileage: 50
THE EXHAUST MUFFLER GETS SO HOT IT GLOWS ORANGE AND YOU CAN SMELL MELTING PLASTIC. I STOPPED RIDING THIS MACHINE DUE TO IT BEING A MAJOR FIRE HAZARD.
Mileage: 50
PURCHASED THIS 2015 SPORTSMAN 1000 XP BRAND NEW IN FEBRUARY. MOST OF IT'S OPERATION HAS BEEN LOWER SPEEDS AT A LOCAL ATV PARK. THIS PAST WEEKEND, I HAD A CHANCE TO USE IT ON TRAILS IN A NATIONAL FOREST IN NORTHERN WISCONSIN. I NOTICED THAT OPERATION ABOVE 25-30 MPH RESULTED IN RED HOT METAL ON TH...
Mileage: 260