2004 PORSCHE 911 GT3 Problems & Recalls

THE CAR WAS BEING DRIVEN WHEN SUDDENLY THE COOLANT SYSTEM FAILED AND COOLANT SPILLED FROM UNDER THE ENGINE CAUSING MY CAR TO SKID OUT OF CONTROL. THE COOLANT ALSO POSED A HAZARD TO OTHER CARS ON THE ROAD DUE TO THE EXTREMELY SLIPPERY NATURE OF THE LIQUID. THE CAR HAD TO BE TOWED TO AN INDEPENDENT M...

Mileage: 25,500

I WAS DRIVING AROUND A CORNER ABOUT 40 MPH WHEN THE CAR SUDDENLY SPUN AROUND. I THEN SAW STEAM COMING FROM THE ENGINE. UPON FURTHER INSPECTION THERE WAS COOLANT ON THE GROUND. ONE OF THE COOLANT FITTINGS HAD COME COMPLETELY LOOSE, AND ALL THE COOLANT HAD LEAKED OUT. THE ONLY REAL FIX IS TO WELD ALL ...

Mileage: 59,600

I WAS DRIVING AROUND A CORNER ABOUT 40 MPH WHEN THE CAR SUDDENLY SPUN AROUND. I THEN SAW STEAM COMING FROM THE ENGINE. UPON FURTHER INSPECTION THERE WAS COOLANT ON THE GROUND. ONE OF THE COOLANT FITTINGS HAD COME COMPLETELY LOOSE, AND ALL THE COOLANT HAD LEAKED OUT. THE ONLY REAL FIX IS TO WELD ALL ...

Mileage: 59,600

ON VERY HOT DAY, OVER 100 DEGREES F, AFTER HAVING JUST EXITED A FREEWAY ONTO A CITY STREET, WHILE ACCELERATING FROM RED LIGHT, A GLUED-IN WATER COOLANT PIPE/TUBE POPPED OUT FROM ITS CAST HOUSING, CAUSING CATASTROPHIC LOSS OF ALL COOLING FLUIDS WHICH SPILLED ONTO THE ROADWAY, IMMEDIATE INCREASE IN EN...

Mileage: 53,400

ON VERY HOT DAY, OVER 100 DEGREES F, AFTER HAVING JUST EXITED A FREEWAY ONTO A CITY STREET, WHILE ACCELERATING FROM RED LIGHT, A GLUED-IN WATER COOLANT PIPE/TUBE POPPED OUT FROM ITS CAST HOUSING, CAUSING CATASTROPHIC LOSS OF ALL COOLING FLUIDS WHICH SPILLED ONTO THE ROADWAY, IMMEDIATE INCREASE IN EN...

Mileage: 53,400

A COOLANT LINE FITTING THAT IS EPOXIED INTO THE BLOCK BECAME SUDDENLY AND COMPLETELY DISCONNECTED. THE COOLANT ALL FLOWED OUT OF THE LEAK NEARLY INSTANTLY. THE POOL OF COOLANT CREATED A HAZARD FOR FOLLOWING CARS AND THE MOTOR NEEDED TO BE SHUT DOWN IMMEDIATELY AND THE CAR TOWED TO A SERVICE FACILI...

Mileage: 41,000

WENT TO STREETS OF WILLOW DRIVING EVENT. DURING 3RD RUN SESSION I NOTICED STEAM COMING FROM BEHIND AS I WAS TAKING A 180 DEGREE TURN. I IMMEDIATELY STOPPED THE CAR WHEN IT WAS SAFE TO DO SO AND SHUT THE ENGINE OFF. STEAM KEPT BILLOWING AND THE CAR SEEMS TO HAVE LOST ALL IT'S COOLANT IN A FEW SECONDS...

Mileage: 31,000

I WAS DRIVING AT MILLER MOTORSPORTS IN TOOELE UTAH IN DRIVERS EDUCATION EVENT WHEN MY ENGINE TEMPERATURE GAUGE STARTED TO INCREASE FROM 180 DEGREES UP PAST 200 DEGREES. AS THE TEMPERATURE GAUGE WENT TO 250 DEGREES, A COOLANT FAILURE LIGHT CAME ON. I PULLED OFF THE TRACK AND SHUT DOWN THE CAR WITHIN...

Mileage: 28,010

I WAS DRIVING AT MILLER MOTORSPORTS IN TOOELE UTAH IN DRIVERS EDUCATION EVENT WHEN MY ENGINE TEMPERATURE GAUGE STARTED TO INCREASE FROM 180 DEGREES UP PAST 200 DEGREES. AS THE TEMPERATURE GAUGE WENT TO 250 DEGREES, A COOLANT FAILURE LIGHT CAME ON. I PULLED OFF THE TRACK AND SHUT DOWN THE CAR WITHIN...

Mileage: 28,010

THE EPOXY HOLDING AN ALUMINUM ELBOW THAT CONNECTS A COOLANT HOSE TO THE WATER PUMP (I BELIEVE) LET GO, THE ELBOW WORKED ITS WAY LOOSE FROM THE PUMP AND EMPTIED THE COOLANT FROM THE SYSTEM OUT ONTO THE ROAD SURFACE. I BECAME AWARE OF THE PROBLEM WHEN I NOTICED THAT THE ENGINE TEMPERATURE NEEDLE HAD ...

Mileage: 40,800

WHILE DRIVING AT A DRIVERS EDUCATION EVENT AT WATKINS GLEN RACE TRACK, A COOLANT FITTING CAME APART AND OUT OF ITS HOUSING RELEASING ABOUT 3-4 GALLONS OF COOLANT ONTO THE TRACK. LUCKILY NO ACCIDENT OCCURRED. SINCE THE CAR WAS STILL UNDER WARRANTY PORSCHE AGREED TO COVER THE FAILURE UNDER GOOD WILL A...

Mileage: 37,292

A COOLANT LINE CAME LOOSE THEN I WAS DRIVING THE CAR. I WAS VERY LUCKY I DID NOT SPIN IN THE COOLANT, AND GET IN A SERIOUS ACCIDENT. THIS IS A VERY SERIOUS SAFETY ISSUE. THE LINES WERE ORIGINALLY "GLUED" IN FROM THE FACTORY. THIS WAS A POOR DESIGN AND IS A WEAKNESS OF THE CAR WHICH COULD HAVE BE...

Mileage: 34,000

A COOLANT LINE CAME LOOSE THEN I WAS DRIVING THE CAR. I WAS VERY LUCKY I DID NOT SPIN IN THE COOLANT, AND GET IN A SERIOUS ACCIDENT. THIS IS A VERY SERIOUS SAFETY ISSUE. THE LINES WERE ORIGINALLY "GLUED" IN FROM THE FACTORY. THIS WAS A POOR DESIGN AND IS A WEAKNESS OF THE CAR WHICH COULD HAVE BE...

Mileage: 34,000

WHILE DRIVING THE CAR ON TRACK, A COOLANT FITTING BROKE LOOSE AND DUMPED ALL THE ANTIFREEZE DOWN ONTO THE TRACK SURFACE. A VEHICLE ON TRACK BEHIND ME RAN OVER THE ANTIFREEZE, LOST CONTROL AND SKIDDED OFF THE TRACK. THE DRIVER OF THE OTHER CAR WASN'T INJURED AND THERE DIDN'T APPEAR TO BE MUCH DAMAGE ...

Mileage: 36,500

COOLANT PIPES LEAKING AFTER DRIVE. *TR

Mileage: 46,012

THIS IS IN RESPONSE TO MY AWARENESS OF NHTSA PE13-009. I AM THE THIRD OWNER OF A 2004 PORSCHE GT3 THAT I USE PRIMARILY FOR TRACK DRIVING DAYS AND OCCASIONALLY FOR STREET USE. WHEN I PURCHASED THE CAR IN 2010, I WAS AWARE OF MANY REPORTS FROM OWNERS OF SIMILAR CARS THAT HAD EXPERIENCED SUDDEN COOL...

Mileage: 14,600

I PURCHASED MY 2004 PORSCHE GT3 IN MAY OF 2009. IT HAD JUST UNDER 20,000 MILES ON IT. IN AUGUST, 2010, I WAS DRIVING ON TRACK AT TEXAS MOTOR SPEEDWAY AND ONE OF THE COOLANT FITTINGS CAME LOOSE FROM THE ENGINE. THE EPOXY THAT HOLDS THE PRESS-FIT COUPLER TO ONE OF THE HEAT EXCHANGERS HAD LOST ITS A...

Mileage: 20,000

I HAD PRO-ACTIVE REPAIRS PERFORMED ON MY 2004 PORSCHE GT3 COOLANT SYSTEM DUE TO KNOWN ISSUE OF COOLANT PIPES SEPARATING FROM THE ENGINE. I HAD THE REPAIR PERFORMED BECAUSE I WAS AFRAID OF LOSING CONTROL OF MY VEHICLE (IT IS MY DAILY DRIVER) OR CAUSING A CRASH BEHIND ME. THE REPAIRS COST ME $3900 + C...

Mileage: 18,000

I HAD PRO-ACTIVE REPAIRS PERFORMED ON MY 2004 PORSCHE GT3 COOLANT SYSTEM DUE TO KNOWN ISSUE OF COOLANT PIPES SEPARATING FROM THE ENGINE. I HAD THE REPAIR PERFORMED BECAUSE I WAS AFRAID OF LOSING CONTROL OF MY VEHICLE (IT IS MY DAILY DRIVER) OR CAUSING A CRASH BEHIND ME. THE REPAIRS COST ME $3900 + C...

Mileage: 18,000

EXPERIENCED SUDDEN COOLANT LOSS WHILE DRIVING ON PUBLIC ROADWAY. A BONDED-IN ALUMINUM TUBE (SPIGOT) ON THE COOLANT DISTRIBUTION MANIFOLD POPPED OFF, RESULTING IN A MASSIVE, INSTANT COOLANT LOSS. THE COOLANT DUMPED ALL OVER THE REAR TIRE, CAUSING THE VEHICLE TO GO IN TO AN UNCONTROLLABLE SKID, RENDER...

Mileage: 51,000

THE COOLANT LINES ON THIS CAR HAVE WELL KNOWN AND DOCUMENTED FAILURE PROBLEMS. I AM VERY CONCERNED FOR MY SAFETY AND THE SAFETY OF MY PASSENGERS AND AS SUCH AM GOING TO HAVE THE REPAIRS COMPLETED AS A PRECAUTIONARY MEASURE. WITH THE FAILURE RATE OF THE COOLANT FITTINGS ON THESE CARS, AND THE USUAL...

Mileage: 24,148

I BOUGHT THIS CAR BRAND NEW FROM PORSCHE AND ALTHOUGH IT ONLY HAS AROUND 14,000 MILES ON IT, I FEEL I MUST LIMIT USE OF THE CAR UNTIL IT GETS THE GLUED COOLANT LINES REPAIRED. I HAVE NOT HAD A FAILURE YET BUT THE RISKS OF WAITING UNTIL THAT HAPPENS ARE HIGH AND COULD EASILY GO BEYOND THE FINANCIAL ...

Mileage: 14,000

EARLY COOLANT PIPE LEAKAGE AT ONE OF THE FITTINGS. UNABLE TO REPAIR WITHOUT ENGINE REMOVAL. I CHOSE TO REPAIR ALL COOLANT FITTINGS AT THAT TIME. *TR

Mileage: 16,525

PREVIOUS OWNER STATED THAT COOLANT LINES DISCONNECTED DUE TO FAILURE OF THE FITTINGS. COOLANT WAS SPILLED ALL OVER THE ROAD BEHIND HIM. ANOTHER DRIVER BARELY MISSED THE COOLANT BUT THERE COULD HAVE BEEN A MAJOR ACCIDENT. PORSCHE FIXED THE PROBLEM UNDER WARRANTY, BUT THE FITTINGS WERE NOT WELDED AS T...

Mileage: 35,000

FAILURE OF FACTORY GLUED IN COOLANT FITTING CAUSED AN INSTANT DUMP OF COOLANT ONTO THE REAR TIRES OF THE CAR CAUSING LOSS OF CONTROL AND A SPIN. THIS IS A WELL DOCUMENTED PROBLEM IN ALL PORSCHE GT3'S AND PORSCHE TURBO'S AND PORSCHE REFUSES TO IDENTIFY THE DESIGN FLAW OF HAVING THESE FITTINGS GLUED ...

Mileage: 22,000

COOLANT LINES CAME LOOSE WHERE THEY WERE GLUED TO THE MOTOR. I HAVE SEEN CATASTROPHIC FAILURES, AND DID NOT WANT TO HAVE AN ACCIDENT. HAD THE MOTOR REMOVED, AND REPAIR SHOP SAID SOME OF MINE WERE LOOSE AND SHOWED SIGNS OF LEAKING. HAD ALL WELDED AT AN INDEPENDENT SHOP. PORSCHE WOULD NOT FIX UNLE...

Mileage: 30,000

WHILE PARTICIPATING IN THE ONE LAP OF AMERICA IN 2012 I HAD A COOLANT PIPE FITTING (BEHIND THE ALTERNATOR) COME LOOSE CAUSING THE CAR TO DUMP ALL ITS ANTIFREEZE ON THE TRACK. 3 CARS BEHIND ME RAN INTO THE ANTIFREEZE AND HAD OFF ROAD EXCURSIONS BUT LUCKILY NO DAMAGE OCCURRED TO ANY OTHER VEHICLE. U...

Mileage: 46,628

ENGINE HAS PRESS FIT (AND GLUED) COUPLINGS FOR COOLANT LINES. WHEN COUPLING FAILS, THERE IS RAPID COOLANT LOSS WHICH IS A TOXIC HAZARD AS WELL AS POTENTIALLY DANGEROUS TO TRAFFIC. *TR

Mileage: 12,500

PRESSED FITTINGS FOR THE COOLING SYSTEM FAILED DUMPING COOLANT ON THE REAR TIRES CAUSING THE CAR TO CRASH. THE REPLACEMENT PART FAILED THE SAME WAY THREE WEEKS LATER.

Mileage: 28,000

DRIVING IN A HIGH PERFORMANCE DRIVING EVENT ON A HOT DAY GOING AROUND A FAST RIGHT HAND TURN AND FELT THE CAR BEING A LITTLE LOOSE THEN NOTICED THE ON BOARD COMPUTER FLASHING LOW COOLANT. I SLOWED DOWN AND PULLED IN TO A SAFE PLACE TO CHECK THE MOTOR AND SAW A COOLANT J SHAPED PRESS FITTING COMPLETE...

Mileage: 39,000

PORSCHE GT1 ENGINE PRESS FIT COUPLING FOR COOLANT LINES. WHEN COUPLING FAILS, THERE IS RAPID COOLANT LOSS WHICH IS A TOXIC HAZARD AS WELL AS POTENTIALLY DANGEROUS TO TRAFFIC. ALSO, WITHOUT COOLANT THE ENGINE IS IN JEOPARDY OF OVERHEATING. *TR

Mileage: 35,000

PORSCHE GT1 ENGINE PRESS FIT COOLANT COUPLING FAILURE. HIGH PRESSURE COOLANT COUPLER FAILS CAUSING RAPID LOSS OF ALL COOLANT. THIS IS NOT ONLY A TOXIC HAZARD, BUT A SAFETY CONCERN ON THE ROAD. FURTHER, LOSS OF COOLANT JEOPARDIZES ENGINE LIFE. THE GT1 ENGINE HAS 8 PRESS FIT COUPLINGS. SO FAR, 2 ...

Mileage: 23,000