Recall 10V015000
POWER TRAIN:CLUTCH ASSEMBLY:PEDAL/HAND LEVER(MOTORCYCLE)
Defect Description
DAIMLER BUSES IS RECALLING CERTAIN ORION TRANSIT BUSES EQUIPPED WITH THE MORSE REMOTE THROTTLE CONTROL. THE MORSE REMOTE THROTTLE CONTROL PANEL IS LOCATED IN THE ENGINE COMPARTMENT AND A SWITCH ON IT IS LABELED, "THROTTLE"; "OFF" OR "FRONT" AND "ON" OR "REAR" SELECTING THE ACTIVE ENGINE CONTROL STATION. IF A PERSON OPERATING THE ENGINE FROM THE "REAR" POSITION (AT THE ENGINE) FAILS TO PLACE THE SWITCH IN THE "OFF" OR "FRONT" POSITION AND THE ENGINE RPM WAS SET TO ABOVE IDLE DURING MAINTENANCE FOR EXAMPLE, WHEN THE BUS IS STARTED FROM THE DRIVER'S STATION THE ENGINE COULD CHANGE TO THE HIGHER RPM RESULTING IN UNWANTED ENGINE POWER.
Safety Consequence
THE BUS COULD ACCELERATE AT A HIGHER RATE THAN ANTICIPATED INCREASING THE RISK OF A CRASH.
Remedy
DAIMLER WILL PROVIDE INSTRUCTIONS TO MODIFY THE WIRING TO THE MORSE THROTTLE CONTROL SWITCH. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON APRIL 1, 2010. OWNERS MAY CONTACT DAIMLER BUSES AT 1-800-716-7466.
Affected Vehicles
| Year | Make | Model |
|---|---|---|
| 1992 | ORION | II |
| 1992 | ORION | V |
| 1993 | ORION | II |
| 1993 | ORION | V |
| 1994 | ORION | V |
| 1995 | ORION | V |
| 1995 | ORION | VI |
| 1996 | ORION | V |
| 1997 | ORION | V |
| 1998 | ORION | II |
| 1998 | ORION | V |
| 1999 | ORION | V |
| 2000 | ORION | V |
| 2001 | ORION | V |
| 2002 | ORION | V |
| 2002 | ORION | VI |
| 2002 | ORION | VII |
| 2003 | ORION | V |
| 2003 | ORION | VII |
| 2004 | ORION | VII |
| 2005 | ORION | V |
| 2005 | ORION | VII |
| 2006 | ORION | V |
| 2006 | ORION | VII |
| 2008 | ORION | V |
| 2008 | ORION | VII |
| 2009 | ORION | VII |
Check your vehicle: Visit NHTSA.gov and enter your VIN to see if your specific vehicle is affected.