2004 SATURN ION Power Train Problems

1. THE IGNITION SWITCH WILL NOT DISENGAGE...SOMETIMES AFTER MOTOR IS TURNED OFF AND CAR IS IN PARK THE CAR MUST BE TURNED BACK ON FOUR OR FIVE TIMES BEFORE THE IGNITION WILL ENGAGE CORRECTLY. THE VEHICLE IS STATIONARY...IN THE PARK POSITION....KEY WILL LOCK INSELF AND NOT DISENGAGE. THE CAR WAS ON A CITY STREET WHEN THIS OCCURRED. IT BEGAN TO OCCUR FIVE MONTHS AGO...NOW IT HAPPENS AT LEAST TEN TIMES A WEEK. 2. ALL ELECTRICAL SYMBOLS ON DASHBOARD SAY: COOLANT...BUT WHEN CHECKED THE COOLANT IS FINE.

Mileage: 44,000

MY CAR HAS A STANDARD TRANSMISSION AND THE CLUTCH PEDAL ASSEMBLY FAILED CAUSING DANGEROUS AND DIFFICULT SHIFTING BETWEEN GEARS. THE END OF THE CLUTCH PEDAL ASSEMBLY IS PLASTIC AND IT BROKE AT THE JUNCTURE WHERE IT MEETS THE TRANSMISSION. UNBELIEVABLY, GENERAL MOTORS (GM) KNEW OF THE PROBLEM BUT TOOK NO REMEDIAL ACTION. COMPLAINT LETTERS ON THE INTERNET CLEARLY SHOW GM HAS KNOWN ABOUT THE PROBLEM FOR AWHILE BUT TAKEN NO ACTION. IT COST ME $609.74 TO HAVE THE SAFETY PROBLEM FIXED. I REPORTED IT TO GM AND ASKED TO BE REIMBURSED. THIS IS DANGEROUS: I HAD GREAT DIFFICULTY SHIFTING BETWEEN GEARS & ALMOST GOT RUN OVER BY OTHER MOTORISTS WHEN THERE WAS A DELAY IN LOCATING THE NEXT GEAR. GM SHOULD TAKE ACTION ON THIS BEFORE SOMEONE GETS KILLED.

Mileage: 120,370

TRANSMISSION IS BURNT. WHILE DRIVING THE TRANSMISSION SLIPS OUT OF GEAR. THE RPMS THEN REV AND THE CAR FAILS TO CONTINUE TO GO AT SPEED AND WILL NEED TO BE PULLED OVER. THIS ISSUE OCCURS WHEN THE VEHICLE IS IN MOTION ON CITY STREETS AND ON HIGHWAYS. THE VEHICLE ONLY HAS 58499 MILES ON IT. THE VEHICLE WAS CHECKED AT AAMCO AND THEY SAID THE TRANSMISSION WAS BAD AND NEEDED TO BE REPLACED.

Mileage: 58,000

TL* THE CONTACT OWNS A 2004 SATURN ION. WHILE DRIVING 60 MPH, THE SPEED INDEPENDENTLY REDUCED AND THE VEHICLE FAILED TO ACCELERATE WITHOUT WARNING. THE VEHICLE WAS RESTARTED, BUT FAILED TO MOVE. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE CVT FAILED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

Mileage: 110,000

AFTER THE CAR IS STOPPED AND PLACED IN PARK, THE ENGINE CAN BE SHUT OFF BUT THE KEY STAYS IN A ACCESORY MODE AND CAN NOT BE TURNED TO OFF OR REMOVED FROM THE IGNITION.

Mileage: 141,000

TL* THE CONTACT OWNS A 2004 SATURN ION. WHILE DRIVING AT 30 MPH, THE STEERING WHEEL WAS DIFFICULT TO TURN AND THE POWER TRAIN WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ONCE. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 142,000.

Mileage: 142,000

TL* THE CONTACT OWNS A 2004 SATURN ION. WHILE PARKING, THE SHIFT LEVER FAILED TO GO INTO PARK AND THE KEY BECAME STUCK IN THE IGNITION SWITCH. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE VEHICLE WAS WORKING UP TO STANDARDS. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000. THE VIN WAS NOT AVAILABLE.

Mileage: 100,000

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE GEAR LEVER WAS SHIFTED INTO REVERSE, BUT THE TRANSMISSION FAILED TO RESPOND. THE VEHICLE WAS TOWED TO A DEALER WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE TRANSMISSION WAS REPLACED ON THREE DIFFERENT OCCASIONS. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 126,000.

Mileage: 126,000

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME STUCK IN THE IGNITION SWITCH AND PREVENTED THE VEHICLE FROM TURNING OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN STATED THAT THE INTERLOCK PARKING MECHANISM FAILED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 165,648.

Mileage: 165,648

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED SHE WAS UNABLE TO REMOVE THE VEHICLE KEY FROM THE IGNITION SWITCH IT BECAME SEIZED. THE PROBLEM OCCURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO A DEALER WHO STATED THAT THE GEAR SHIFT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED ABOUT THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 154,006.

Mileage: 154,006

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT IT WAS DIFFICULT TO REMOVE THE KEY FROM THE IGNITION AFTER THE GEAR WAS PUT INTO PARK. THE VEHICLE WAS TAKEN TO A DEALER. THE TECHNICIAN DIAGNOSED THAT THE SHIFT MODULE WAS DEFECTIVE. THE VEHICLE WAS REPAIRED. THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 64,000.

Mileage: 64,000

TRANSMISSION FAILURE - SHORTLY AFTER THE 2004 SATURN ION HIT 100K MILES, THE TRANSMISSION FAILED. I HAD TO REPLACE THE TRANSMISSION AT THE DEALER FOR A COST OF $4,620.93. IN DOING RESEARCH IT APPEARS THAT FAILING 2004 SATURN ION TRANSMISSIONS ARE WIDESPREAD AROUND THE 100K MILE MARK. *TR

Mileage: 103,924

WAS TRAVELLING ON MY WAY HOME FROM WORK AND A FOX DARTED OUT IN FRONT OF ME IN THE CENTER OF THE ROAD. I SWERVED SLIGHTLY TO MISS THE FOX AND THE POWER STEERING IN THE CAR WENT OUT. I WAS UNABLE TO STRAIGHTEN THE WHEEL AND THE CAR WENT INTO A 180 DEGREE SPIN AND ENDED UP FACING THE OTHER DIRECTION FLIPPED UP ON THE PASSENGER SIDE. I CRAWLED OUT OF THE DRIVERS WINDOW. AIR BAGS DID NOT DEPLOY EITHER. HAD I NOT BEEN WEARING MY SEATBELT, I PROBABLY WOULD HAVE ENDED UP UNDERNEATH THE CAR AND IF TRAFFIC HAD BEEN COMING, I COULD HAVE KILLED SOMEONE ELSE IN ONCOMING TRAFFIC. *TR

Mileage: 134,000

TL* THE CONTACT OWNS 2004 SATURN ION. THE CONTACT STATED WHILE DRIVING OUT OF A PARING LOT THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE FAILURE OCCURRED TWICE. THE CONTACT RECEIVED A RECALL NOTIFICATION UNDER NHTSA CAMPAIGN ID NUMBER 14V153000 (STEERING); HOWEVER, THE PART WAS UNAVAILABLE. THE CONTACT ALSO STATED THAT WHEN CHANGING GEARS THE VEHICLE SHOOK AND RATTLED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 93,000.

Mileage: 93,000

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, SHE ATTEMPTED TO DEPRESS THE CLUTCH PEDAL BUT NOTICED THAT THE PEDAL HAD RAISED EIGHT INCHES FROM WHERE IT NORMALLY WAS, PREVENTING HER FROM SHIFTING GEARS. THE CONTACT MENTIONED THAT THE VEHICLE EVENTUALLY STALLED AND WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE TECHNICIAN DIAGNOSED THAT THE CLUTCH PEDAL WAS FRACTURED. AS A RESULT, THE MASTER CYLINDER, SLAVE CYLINDER AND THE CLUTCH PEDAL NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 77,362 AND THE CURRENT MILEAGE WAS 79,810.

Mileage: 77,362

WHILE DRIVING MY CAR ON MULTIPLE OCCASIONS I HAVE LOST THE ABILITY TO CONTROL THE STEERING WHEEL. ALSO, I HAVE EXPERIENCED MY CAR TURNING OFF WHILE DRIVING WHICH THANKFULLY HAS A RECALL ON IT BUT I WANT THE POWER STEERING TO BE RECALLED AS WELL BECAUSE IT HAS CAUSED AN ACCIDENT AND MULTIPLE NEAR MISSES. *TR

Mileage: 46,780

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING 45 MPH. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AND THE MANUFACTURE WAS CONTACTED. THE FAILURE MILEAGE WAS 77,500 AND THE CURRENT MILE WAS 77,590. UPDATED 6/10/14*CN UPDATED 8/4/17*CN

Mileage: 77,500

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE HAD MULTIPLE FAILURES. THE STEERING WAS ROUGH AND THE TRANSMISSION WAS CAUSING THE VEHICLE TO MAKE LOUD NOISES WHEN THE WHEELS WERE TURNED LEFT OR RIGHT. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER:14V047000 (AIR BAGS, ELECTRICAL SYSTEM) HOWEVER THE DEALER STATED THAT THE PARTS WOULD BECOME AVAILABLE MID APRIL. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIRS. AN AUTHORIZED DEALER WILL INSPECT THE TRANSMISSION AND STEERING FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 175. THE MILEAGE OF 175 WAS REAFFIRMED BY THE CONTACT. UPDATED 05/28/14 MA THE CONSUMER STATED THE VEHICLE BEGAN HAVING ISSUES 2 WEEKS AFTER IT WAS PURCHASED. THE VEHICLE WOULDNT START, IT HAD HIGH IDLING PROBLEMS, AND MOST RECENTLY THE STEERING COLUMN FAILURE. THE BATTERY AND THROTTLE WERE BOTH REPLACED. UPDATED 05/29/2014* JS

Mileage: 175

I PURCHASED 2004 SATURN ION 3 IN 2013 AND WITHIN 30DAYS I STARTED HAVING PROBLEMS WITH TRANSMISSION. VEHICLE WOULD STALL OUT AND BEGIN TO HESITATE AROUND 35MPH. I STARTED INQUIRING ABOUT TRANSMISSION ISSUES ON INTERNET AND OBSERVED THIS IS A COMMON ISSUE WITH THIS VEHICLE. I'M GETTING NO HELP WITH THIS ISSUE WITH GM DEALERSHIP. WITH ALL THE OTHER OWNERS COMPLAINTS ABOUT THIS TRANSMISSION ISSUE WITH THE SATURN ION THERE SHOULD BE A NATIONAL RECALL TO FIX TRANSMISSION DEFECT ON THIS VEHICLE.(CVT OR VTI TRANSMISSION). *TR

Mileage: 124,000

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT HE WAS UNABLE TO SHIFT OUT OF GEAR. THE VEHICLE WAS INSPECTED BY THE CONTACT WHO DIAGNOSED THAT THE CLUTCH PEDAL AND THE CLUTCH MASTER CYLINDER NEEDED TO BE REPLACED. IN ADDITION, THE PLASTIC GUIDE FOR THE SEAT BELT ON BOTH THE DRIVER AND PASSENGER SIDE BROKE CAUSING THE SEAT BELT TO LIE ON THE NECK INSTEAD OF ACROSS THE CHEST. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 120,000 AND THE CURRENT MILEAGE WAS 210,000.

Mileage: 120,000

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 20 MPH, A CLICK WAS HEARD WHEN THE CLUTCH PEDAL WAS DEPRESSED AND IT BECAME DIFFICULT TO DEPRESS. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS 200,000.

Mileage: 200,000

I STARTED MY CAR, PULLED FORWARD THROUGH THE PARKING LOT, DIDN'T REVERSE. HEADED DOWN WESTHEIMER AT ABOUT APPROX. 35 MPH. I DROVE ABOUT ONE MILE WHEN I HEARD THE WARNING CHIME AND MY POWER STEERING SUDDENLY WENT OUT. LUCKILY I WAS THE ONLY ONE ON THE ROAD BEING IT WAS ABOUT 1 AM. I PULLED INTO A GAS STATION TURNED MY CAR OFF AND BACK ON SUDDENLY IT WAS BACK. *TR

Mileage: 92,536

SHORTLY AFTER BUYING THIS VEHICLE, I HAVE HAD NUMEROUS FAILURES OF THE POWER ASSIST STEERING SYSTEM. AT ANY SPEED, AT ANY TIME, "PWR STR" DIS DISPLAYED ON THE OBD DISPLAY, SIMULTANEOUSLY AS THE MOTOR STOPPED FUNCTIONING, FORCING ME TO UNEXPECTEDLY MANUALLY STEER THE CAR UNTIL THE IGNITION WAS CYCLED AND THE SYSTEM RESET. SOMETIMES THIS HAPPENS 1-7 TIMES A DAY. I HAVE PERSONALLY CAME CLOSE TO HAVING A SINGLE CAR ACCIDENT DUE TO POWER ASSIST FAILURE WHILE CURVING. THERE ARE NO OTHER PREVIOUS FAILURES OF THE STEERING EQUIPMENT LEADING UP TO THIS ISSUE. *TR

Mileage: 138,000

APPROXIMATELY ONE WEEK AFTER I PURCHASED THE VEHICLE I NOTICED A GRINDING NOISE THAT WAS NOT FAVORABLE AND I WAS PRETTY SURE IT WAS THE TRANNY. I PURCHASED AN EXTENDED WARRANTY WITH THE CAR SO I TOOK IT TO THE DEALER FOR DIAGNOSTICS AND REPAIR. IT WAS CONFIRMED TO BE THE TRANNY AND THEY TRIED TO PUT A BANDAIDE ON IT BY FLUSHING IT AND CHANGING THE FLUIDS. ONE WEEK LATER SAME NOISE ONLY LOUDER. THEY REPLACED THE TRANNY. 30 DAYS AFTER THE FIRST REPAIR; THE NOISE RETURNED, THEY REPLACED SOME PARTS, IN THE TRANNY THEY JUST PUT IN IT. JUST OVER 12,0000 MILES LATER I WAS ATTEMPTING TO BACK UP AND THE CAR WOULD NOT GO IN REVERSE. I HAD IT TOWED AND THE TRANNY WAS AGAIN REPLACED, THAT WAS JUST UNDER 12,0000 MILES AGO AND THE TRANNY IS SLIPPING AGAIN, ONLY NOW THE EXTENDED WARRANTY PEOPLE SAY I AM OUT OF FUNDS BECAUSE THEY WILL NOT REPAIR A VEHICLE BEYOND IT'S WORTH. I HAVE HAD THE AXLE REPLACED TWICE AND IT NEEDS TO BE DONE AGAIN, EXTENDED WARRANTY AGAIN SAY'S THEY ARE DONE PAYING OUT ON THIS CAR EVEN THOUGH MY TIME OR MILEAGE IS NOT EXPIRED ON THE WARRANTY. ABOUT A MONTH AGO IT FAILED TO START AND BECAUSE I HAD READ THIS WEB SITE ON CONSUMER COMPLAINTS FOR THIS CAR I KNEW TO WAIT 5-15 MIN AND TRY AGAIN. THIS HAS HAPPENED SEVERAL TIMES BUT SO FAR IT EVENTUALLY STARTS. I PURCHASED THIS CAR ON CREDIT JUST OVER A YEAR AGO TO GET A RELIABLE VEHICLE BECAUSE I WORK 7 DAYS A WEEK OUT OF MY CAR AND IT IS BECOMING A NIGHTMARE NO-ONE WILL WAKE ME UP FROM. AND BECAUSE I AM UPSIDE DOWN ON THE LOAN I CANNOT EVEN TRADE IT IN FOR SOMETHING THAT IS RELIABLE. FOR THE AMOUNT OF COMPLAINTS I HAVE SEEN THERE SHOULD BE SOME RECOURSE TO THE CONSUMER. I HAVE HAD THE TRANNY REPLACED TWICE AND FIXED TWICE, THE AXLE HAS BEEN DONE TWICE AND NEED IT AGAIN. CHEVY BOUGHT THIS COMPANY OUT AND SHOULD HAVE TO HONOR THE STANDARDS FOR A SAFE VEHICLE OR STOP SELLING THEM TO UNSUSPECTING BUYERS. *TR

Mileage: 55,000

THE LITANY OF PROBLEMS WITH THIS UNSAFE AND UNRELIABLE VEHICLE IS LONG AND VARIED. MULTIPLE TRANSMISSION PROBLEMS, ELECTRICAL ISSUES, LOSING POWER WHILE DRIVING, ETC.. GM AND SATURN KNEW OF THESE ISSUES, ESPECIALLY THE ONES CONCERNING THE VTI TRANSMISSION, YET THEY CHOSE TO CONTINUE TO PUT THE PUBLIC AT RISK BY DENYING THEIR RESPONSIBILITIES TO CORRECT THESE PROBLEMS. THE ONLY REAL WAY, IN MY OPINION, TO MAKE THIS RIGHT IS TO FULLY RECALL AND REPLACE THESE VEHICLES. THIS CAR HAS BEEN NOTHING BUT A NIGHTMARE SINCE I BOUGHT IT BRAND NEW IN LATE 2003 AND CONTINUES TO BE A HAZARD. PLEASE FORCE GM TO DO THE RIGHT THING AND GET THESE CARS OFF THE ROAD BEFORE SOMEONE GETS KILLED. *TT

Mileage: 1,000

2004 SATURN ION VTI TRANSMISSION FAILURE, PULLING OUT OF A FAST FOOD DRIVE THRU AT A SLOW RATE OF SPEED, HUNDREDS OF MILES FROM HOME. IT HAS BEEN A KNOWN ISSUE THAT THIS TRANSMISSION WAS A POORLY MADE GM PRODUCT; SATURN WAS AWARE OF IT, GM HAS BEEN AWARE. RECALLS SHOULD HAVE BEEN MADE, BUT INSTEAD THEY ARE ALLOWED TO RIP OFF THE BUYER WITH TRANSMISSIONS THAT FAIL WITHIN 66,000 MILES. CAR HAS BEEN MAINTAINED PERFECTLY. THERE WILL BE NO MORE GM PURCHASES WITH MY DOLLARS. MY WORK IS WORTH A BETTER PRODUCT. *TR

Mileage: 66,252

2004 SATURN ION WITH AUTOMATIC TRANSMISSION, THE CAR STOPPED MOVING IN DRIVE WHILE TURNING ONTO THE FREEWAY. CAR WAS TOWED TO A SATURN DEALER WHICH THEY STATED THAT THE TRANSMISSION IS NO GOOD. NOTHING WAS DONE BECAUSE THEY WANT $5,000 TO FIX THE CAR. FOUND OUT THROUGH THE INTERNET NHTSA#10032327, STATES THAT SATURN GM WILL PAY 50% OF COST OF REPLACEMENT, SATURN DEALER WILL NOT HONOR SERVICE BULLETIN. *TR

Mileage: 143,000

TL* THE CONTACT OWNS 2004 SATURN ION. THE CONTACT WAS DRIVING 10 MPH WHEN THE VEHICLE ABNORMALLY SHIFTED INTO THE NEXT GEAR. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED THE CONTACT TO TAKE THE VEHICLE TO A DEALER FOR DIAGNOSIS. THE DEALER DIAGNOSED THE VEHICLE AS HAVING A FAULTY TRANSMISSION WHICH NEEDED REPLACING. THE DEALER ADVISED THE CONTACT THAT HE WOULD ONLY BE LIABLE FOR ONE HALF OF THE REPAIR COSTS. THE CONTACT DECLINED AND STATED THAT THE MANUFACTURER SHOULD BE LIABLE FOR THE FULL REPAIR COSTS DUE TO NUMEROUS TRANSMISSION COMPLAINTS FOUND ONLINE FOR HIS YEAR, MAKE AND MODEL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.

Mileage: 60,000

TL*THE CONTACT OWNS A 2004 SATURN ION. WHILE DRIVING APPROXIMATELY 25-30 MPH THE VEHICLE LOST POWER STEERING. SHE STATED THAT THE VEHICLE BECAME VERY DIFFICULT TO STEER AND SHE HAD TO HOLD ON TO THE SHIFTER AND THE STEERING WHEEL IN ORDER TO GAIN CONTROL OF THE VEHICLE. THE VEHICLE WAS MANUAL. THE CONTACT HAD TAKEN THE VEHICLE TO THREE LOCAL MECHANICS AND THEY ADVISED HER THAT THE STEERING COLUMN NEEDED TO BE REPLACED AND HAS REFERRED HER TO THE DEALER. THE VEHICLE WAS NOT TAKEN TO AN AUTHORIZED DEALER FOR THIS FAILURE. THE CONTACT STATED THAT THE FAILURE WAS INTERMITTENT AT FIRST BUT SHE NO LONGER HAS POWER STEERING. WHILE DRIVING THE VEHICLE ALSO LOCKED IN GEAR AND SHE COULD NOT SHIFT OUT OF GEAR. THE CONTACT STATED THE FAILURE HAPPENED AT 9,000 MILES. THE VEHICLE WAS TAKEN TO THE DEALER THIRTY SEVEN TIMES FOR THIS FAILURE AND THEY HAVE REPLACED THE WIRES BUT THE FAILURE CONTINUED TO OCCUR. THE DEALER HAS NEVER DIAGNOSED THE FAILURE BECAUSE THE CONTACT WOULD NOT PAY $500.00 FOR DIAGNOSTIC TESTING. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 83,000.

Mileage: 21,000

TL* THE CONTACT OWNS A 2004 SATURN ION. WHILE TRAVELING AT 35 MPH, THE VEHICLE WOULD NO LONGER ACCELERATE. THE DEALER PERFORMED A TRANSMISSION FLUSH ON THE VEHICLE TO CORRECT THE FAILURE. IMMEDIATELY AFTER THE REPAIR, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED AND THERE WERE NO FURTHER REPAIRS. THE CURRENT AND FAILURE MILEAGES WERE 87,000.

Mileage: 87,000

AFTER ONLY 9 MONTHS OF OWNING MY ION I HAVE EXPERIENCED PROBLEMS WITH SHIFTING THE CAR IN AND OUT OF GEAR. IT IS A RANDOM OCCURRENCE AND CAN HAPPEN 8 TIMES IN A WEEK THEN NOT AT ALL FOR MONTHS. HOWEVER WHEN IT DOES HAPPEN IT IS A LIFE THREATENING EXPERIENCE AS I AM USUALLY DRIVING ON A MAJOR HIGHWAY. THE CAR WILL BE "LOCKED" INTO 4TH FOR EXAMPLE AND WHEN I TRY TO SHIFT TO 5TH I CAN NOT GET IT OUT OF 4TH. I HAVE TAKEN THE CAR TO THE SATURN DEALERSHIP A MINIMUM OF 20 TIMES FOR THIS PROBLEM, ONLY TO BE TOLD THAT THEY COULD NOT DO ANYTHING. I THEN TOOK IT TO A DIFFERENT DEALERSHIP WHERE THE TECH TOOK THE CAR HOME FOR 1 WEEK, EXPERIENCED THE PROBLEM FOR HIMSELF, AND TOLD ME ALL HE COULD DO WAS REPLACE A WIRE AND HOPE IT HELPED BECAUSE SATURN WOULD NOT LET HIM INVESTIGATE ANY MORE OPTIONS. IT DID ABSOLUTELY NOTHING TO HELP MY CAR. AND SINCE THE LAST TIME MY CAR HAS BEEN AT THE SATURN DEALERSHIP MY POWER STEERING NOW GOES IN AND OUT. APPARENTLY THEY BUSTED A SEAL AND FAILED TO MENTION THAT TO ME, SO NOT ONLY DO I HAVE TO WORRY ABOUT NOT BEING ABLE TO SHIFT, BUT ALSO LOSING MY POWER STEERING. THEY ONLY SOLUTION I CAN COME UP WITH IS TO TRY MY BEST TO GET THE CAR TO A SAFE SPOT AND TURN IT OFF AND LET IT SIT. THIS CAR HAS HAD MORE PROBLEMS THAN ANYONE SHOULD HAVE TO DEAL WITH: REVERSE SWITCH GOING OUT, AIRCONDITIONING GOING OUT, POWER WINDOWS NO LONGER WORK, POWER STEERING, AND NOT BEING ABLE TO SHIFT. I HAVE TO DRIVE THIS EVERYDAY WITH MY CHILDREN IN THE CAR WITH ME AT MOST TIMES. THIS SHOULD HAVE ALL BEEN TAKEN CARE UNDER THE ORIG. WARRANTY, AS IT ALL HAPPENED WITHIN THE FIRST 6-12 MONTHS OF OWNING THE CAR. LOL THAT'S WHAT I GET FOR BUYING A GM PRODUCT. *TR

Mileage: 9,000

I HAVE A 2004 SATURN ION. ABOUT 3 WEEKS AGO I HAD THE TRANSMISSION FLUID FLUSHED AND CHANGED. THEN ON JANUARY 13, 2010, MY CAR STALLED ON ME. I HAD IT TOWED TO THE SATURN DEALERSHIP AND CALLED THE NEXT MORNING. I WAS TOLD THAT THE TRANSMISSION WAS BAD AND NEEDED TO BE REPLACED. IT WAS A GENEROUS OFFER TO ONLY HAVE TO PAY HALF FOR THE REPAIR. I HAVE DONE SOME RESEARCH, AND ALTHOUGH THERE ARE REPORTS FOR ABOUT 15 SATURN VEHICLES ON RECALL LISTS, THE ION WAS NOT ONE OF WHICH I COULD READ ABOUT. IN SOME CASES, TRANSMISSION FAILURE FOR THE SATURN VUE CAN BE A RECURRING PROBLEM; FOR THE SAME CUSTOMER. *TR

Mileage: 98,700

I WAS ONCE A LOYAL GENERAL MOTORS CUSTOMER ' THAT IS UNTIL GM NEARLY KILLED ME. I'M THE UNFORTUNATE OWNER OF A 2004 SATURN ION WITH AN AILING TRANSMISSION THE DEALERSHIP REFUSES TO REPAIR, AND I AM NOT ALONE. IN MY CASE, THE TRANSMISSION FAILURE NEARLY COST ME MY LIFE. THIS PAST SATURDAY, I WAS ATTEMPTING TO MERGE FROM 315 N ONTO INTERSTATE 270 E. EXITING THE ENTRANCE RAMP AT THAT INTERCHANGE IS OFTEN A HAZARD UNDER THE BEST CONDITIONS. AS I ACCELERATED INTO THE RIGHT-HAND LANE OF TRAFFIC, MY CAR SHUTTERED VIOLENTLY AND LOST ALL FORWARD MOMENTUM. I SWERVED BACK TO AVOID BEING REAR-ENDED BY THE CLOSING TRAFFIC ON 270 E, NEARLY SIDESWIPING ANOTHER VEHICLE STILL IN THE EXIT LANE. I DRIFTED TO THE SIDE OF THE ROAD UNABLE TO GET THE TRANSMISSION TO ENGAGE. AFTER LETTING THE CAR REST FOR A FEW MINUTES I TRIED AGAIN TO GET IT INTO GEAR, ULTIMATELY HAVING TO LEAVE IT IN A PARKING LOT. DESPITE GM AGREEING TO A CLASS ACTION SETTLEMENT ON APRIL 16, 2009, SATURN DEALERSHIPS HAVE RECENTLY BEEN ADVISED TO SUSPEND ALL EXTENDED WARRANTY REPAIRS UNDER THE AGREEMENT. SATURN CUSTOMER SERVICE, UNDER DIRECT INSTRUCTION FROM GM, HAS TAKE THE POSITION THAT THE AGREEMENT WAS MADE BY GM PRIOR TO THE DECLARATION OF BANKRUPTCY ON JUNE 1, 2009 AND NOW HAS NO LEGAL OBLIGATION TO COMPLETE THE REPAIRS. GM ALSO FAILED TO NOTIFY THE 150,000 OWNERS OF AFFECTED VUE AND ION MODELS THAT DUE TO AN ACKNOWLEDGED DESIGN FLAW, THEIR CARS MIGHT DROP IN OR OUT OF GEAR, EVEN AT HIGH SPEEDS, POSING SIGNIFICANT DANGER TO OPERATORS, PASSENGERS AND OTHER MOTORISTS. HOW MANY ACCIDENTS AND INJURIES HAVE AND WILL OCCUR DUE TO GM'S LACK OF ACTION? LIVES LIKELY HAVE AND WILL BE LOST DUE TO THIS KNOWN DEFECT. GM IS PAYING ROULETTE WITH THE LIVES OF ITS CUSTOMERS AND THE DRIVERS WHO SHARE THE ROADS WITH THEM. GM HAS FAILED TO COMPLY WITH THE LEGAL TERMS OF A CLASS ACTION SETTLEMENT, FAILED TO NOTIFY CUSTOMERS OF A POTENTIALLY DEADLY DEFECT AND FAILED TO PAY THE COST OF REPAIRS THEY AGREED IN FEDERAL DISTRICT COURT. *TR

Mileage: 94,039

TRANSAXLE GRINDING/WHINING NOISE IN 3RD OR 4TH GEAR, EXCESSIVE ENGAGEMENT OR DISENGAGEMENT EFFORT WHILE SHIFTING INTO 3RD OR 4TH GEAR, WILL NOT SHIFT INTO EITHER 3RD OR 4TH GEAR. *TR

Mileage: 72,000

ENGINE STARTED A FAINT SQUEALING NOISE ON 24 NORTH DURING RUSH HOUR TRAFFIC, WAS IN THE FAST LANE AND MANAGED TO GET OVER AND PULL OUT OF THE LANE, HOWEVER THERE WAS VERY LITTLE SHOULDER AND IT WAS NOT SAFE TO GET OUT OF THE CAR, MY TWO YOUNGER CHILDREN WERE IN THE BACK SEAT, HAD TO DRIVE ON THE EDGE OF THE SHOULDER TO THE NEXT EXIT WHICH WAS APPROX 11 MILES BEFORE I COULD GET OFF THE INTERSTATE TO A SAFE PLACE, TRAFFIC GOING APPROX 80 MILES PER HOUR AND CAR WOULD NOT GO MORE THAN 50 MPH, AS GETTING OFF THE INTERSTATE TIMING CHAIN BROKE IN MIDDLE OF THE INTERSECTION BYSTANDERS PUSHED CAR TO A SAFE LOCATION. HAD IT TOWED HOME, WAS TOLD TENSION ROD SEIZED AND TIMING CHAIN BROKE. HAD TO REPLACE TOTAL ENGINE FOR 5K, CAR OUT OF WARRANTY, LESS THAN 5 YEARS OLD AND 88K MILES. MECHANIC COULD NOT FIND ANY REASON FOR SEIZURE AS CAR HAD PLENTY OF OIL AND HAD BEEN MAINTAINED REGULARLY. *TR

Mileage: 88,900

MY SATURN 2004 ION HAS BEEN BREAKING DOWN SINCE I PURCHASED IT USED IN 2005. THEY HAVE PUT IN 2-3 TRANSMISSIONS AND EVERYTIME IT IS COLD IT WON'T START. A COUPLE TIMES THE WOULD START BUT NOT SHIFT INTO GEAR! THE TECH'S COULD NOT FIGURE OUT WHAT WAS WRONG SO MY DAD (WHO DOES NOT WORK ON CARS ) FIGURED OUT IT WAS A LOOSE WIRE! THEY HAVE REPLACED THE STABILIZER BAR BUSHINGS AT LEAST 3 TIMES! THE CARS HEAT AND RADIO WOULD JUST SHUT OFF AND TURN BACK ON THEY ALSO FIXED THAT A COUPLE TIMES. MY CAR WILL BE PAID OFF SHORTLY BUT I WILL NOT BE ABLE TO KNOW WHAT IT IS LIKE TO NOT HAVE A CAR PAYMENT BECAUSE AT ANY MOMENTS NOTICE MY 2004 SATURN ION MIGHT FALL APART!!!!! *TR

TL*THE CONTACT OWNS A 2004 SATURN ION. THE CLUTCH PEDAL ON THE VEHICLE HAS A RETAINER THAT DOES NOT HAVE THE PROPER DURABILITY. AFTER A FEW MONTHS, THE RETAINER DETACHES AND CAUSES THE CLUTCH PEDAL TO RAISE UPWARDS. AS A RESULT, THE DRIVER IS UNABLE TO PROPERLY SWITCH GEARS FAST ENOUGH. WHEN THE FAILURE FIRST OCCURRED ON JULY 20, 2007, THE DEALER REPLACED THE CYLINDER AXULATOR, MASTER CLUTCH, THE ENTIRE CLUTCH PEDAL, AND THE RETAINER. THE REPAIR LASTED FOR 15 MONTHS. RECENTLY, WHILE ATTEMPTING TO SWITCH GEARS AT 15 MPH, THE CONTACT NOTICED THAT THE CLUTCH HAD ONCE AGAIN LOST THE RETAINER AND CAUSED THE PEDAL TO RAISE. THE CONTACT WAS UNABLE TO DETERMINE WHERE THE CLUTCH WAS LOCATED, WHICH NEARLY CAUSED A CRASH. HE CALLED THE DEALER AND WAS INFORMED THAT THE VEHICLE COULD NOT BE REPAIRED FOR FREE BECAUSE IT WAS NO LONGER UNDER WARRANTY. THE CONTACT BELIEVES THAT THIS IS A SAFETY ISSUE THAT THE MANUFACTURER SHOULD BE RESPONSIBLE FOR REPAIRING. HE CALLED THE MANUFACTURER DIRECTLY AND THEY REFUSED TO MAKE ANY REPAIRS. THE VEHICLE CURRENTLY HAS NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 59,751 AND CURRENT MILEAGE WAS 80,210.

Mileage: 59,751

WHILE DRIVING THE CAR LOCKS UP AND IS IMPOSSIBLE TO SHIFT IN AND OUT OF GEAR. THIS USUALLY HAPPENS IN 3RD, 4TH AND 5TH GEAR. THE CAR HAS TO SHUT OF FOR A PERIOD OF TIME AND IT USUALLY WILL UNLOCK THE SYSTEM. I HAVE BEEN STRANDED ON THE INTERSTATE WITH MY TWO YOUNG CHILDREN IN THE CAR, UNABLE TO GET TO SAFETY BECAUSE I CANNOT SHIFT INTO A LOWER GEAR TO MOVE OFF THE ROAD. THIS CAR IS A DEATH TRAP, AND SATURN REFUSES TO FIX IT, EVEN THOUGH I BROUGHT IT IN UNDER THE ORIGINAL WARRANTY. THIS PROBLEM HAS BEEN OCCURING FOR NEARLY 4 YEARS NOW. *TR

I HAVE A 2004 SATURN ION 2 AUTOMATIC TRANSMISSION. ANY DAY THAT THE TEMPERATURE IS LESS THAN 20 DEGREES IT WILL NOT START. SOMETIMES AFTER ABOUT HALF AN HOUR OF TRYING IT WILL START, BUT NOT VERY OFTEN. ALSO IT OFTEN IDLES AT AN EXTREMELY HIGH RPM. IT SOUNDS TERRIBLE WHEN IT DOES THIS. ALSO WHEN IT IDLES HIGH IT SEEMS TO HAVE TROUBLE SHIFTING GEARS. IT'S VERY TWITCHY AND JERKY. *TR

Mileage: 70,000

ON JUNE 25, 2007 THE 2004 SATURN ION QUAD COUPE CAME TO A DEAD STOP IN THE MIDDLE OF AN INTERSECTION. AFTER NUMEROUS ATTEMPTS TO START THE CAR I WAS FORCED TO HAVE THE CAR TOWED TO A SATURN DEALERSHIP IN FORT LAUDERDALE. I WAS TOLD THAT THERE WAS A POSSIBILITY THAT IT WAS THE TRANSMISSION AND THAT SATURN HAD EXTENDED THE WARRANTY ON CERTAIN TRANSMISSIONS MINE INCLUDED . WHEN I ASKED IF THERE HAD BEEN A RECALL WAS TOLD NO. ALSO, I WAS TOLD I SHOULD HAVE THE CAR BACK BY FRIDAY 6/29/07. LATER THAT DAY I WAS INFORMED THAT IT WAS THE VTI TRNSMISSION AND PARTS NEEDED TO BE ORDERED. I SHOULD HAVE MY CAR BACK ON FRIDAY, 6/29/07. ON FRIDAY I WAS TOLD THAT THE TRANSMISION WAS GOING TO NEED TO BE COMPLETELY REPLACED AND THE PART HAD BEEN ORDERED. I WOULD GET THE CAR BACK ON 7/2/07, WEEK SINCE IT HAD BEEN BROUGHT IN I WAS TOLD THAT THE PARTS HAD NOT ARRIVED ,AND THAT I WOULD HAVE THE CAR BACK ON THURSDAY SINCE WEDNESDAY. TODAY THURSDAY 7/5/07 I HAVE NOW BEEN TOLD THE CAR WAS NOT READY, AND THAT IT MAY NOT BE READY TOMORROW. WHY NOT RECALL CARS AFFECTED. *AK

THE FAILURE WAS TO THE ARM THAT HELD THE CLUTCH PEDAL IN PLACE ON THE 2004 SATURN ION REDLINE. THE PART BROKE AND THE CLUTCH WAS COMPLETELY INOPERABLE ,AS SUCH THE CAR WAS RENDERED INOPERABLE. 5 MINUTES EARLIER I WAS ON A MAJOR HIGHWAY DOING 60 MPH AT WHICH SPEED I COULD HAVE LOST ALL CONTROL OF THE CAR AND CAUSED A MAJOR ACCIDENT IN WHICH LIVES MAY HAVE BEEN LOST. THE DEAL OFFERED TO REPLACE THE PLASTIC ARM WITH ANOTHER PLASTIC ARM. THE PART THAT REPLACED MINE HAD A DIFFERENT PART NUMBER THAN ON THE ORIGINAL CAR, I WAS NOT SURE IF THIS WAS JUST A NEW PART NUMBER OR IF THE PART HAD BEEN REPLACED DUE TO PREVIOUS INCIDENTS. IF THERE WAS ANY HISTORY ON THIS PART I WAS NOT ABLE TO GAIN THE INFORMATION FROM THE DEALER, WHO WAS VERY UNWILLING TO COMPLY. THE DAMAGED PART WAS NOT RETURNED TO ME BECAUSE THEY CLAIMED THEY HAD TO RETURN ALL PARTS COVERED UNDER WARRANTY TO THE MANUFACTURER. *AK

Mileage: 32,062

IT IS BECOMING APPARENT THAT THE CLUTCH MASTER CYLINDER ON THE 2.2L AND 2.4L SATURN ION IS DEFECTIVE. THERE HAVE BEEN MANY COMPLAINTS ABOUT THIS ON MULTIPLE FORUMS ACROSS THE INTERNET. I PERSONALLY HAVE HAD MINE REPLACED ONCE AND IT NEEDS REPLACED AGAIN. MY FEAR IS THAT I WILL BE DRIVING AND THAT IT WILL GO OUT COMPLETELY AND NOT ALLOW ME TO SHIFT, POSSIBLY CAUSING AN ACCIDENT. *JB

Mileage: 25,000

SATURN ION 2004. TWO MAJOR DEFECTS. I PURCHASED THE CAR NEW IN OCTOBER 2004. IN OCTOBER 2005, THE TRANSMISSION FAILED, AND REQUIRED COMPLETE REPLACEMENT. SATURN STATED THERE HAD BEEN MANY CONCERNS ABOUT THE TRANSMISSION, SO REPLACED IT FOR FREE. (MINUS MY INCURRED COSTS OF TRAVEL). SECOND MAJOR DEFECT: MAY 2006, A CYLINDER HEAD CRACKED. SATURN HAS AGREED TO "REPLACE" THE CYLINDER HEAD, BUT I HAVE TO PAY FOR $800.00 OF THE REPAIRS. A 2 YEAR OLD VEHICLE SHOULD NOT HAVE THESE TWO MAJOR DEFECTS. THE CAR CURRENTLY HAS 79K MILES. I KNOW THAT "REPLACING" THE CYLINDER HEAD WILL GET THE CAR RUNNING AGAIN, BUT IT WILL NEVER BE THE SAME...AND I STILL OWE 10,000 DOLLARS ON THE CAR. THANK YOU FOR YOUR CONSIDERATION. *NM

Mileage: 56,000

MULTIPLE EPISODES WITH THIS CAR OF SUDDEN ACCELERATION ESPECIALLY WHEN PUTTING CAR INTO DRIVE OR REVERSE. ROADSIDE ASSISTANCE HAS HAD TO START CAR FOR ME 2 TIMES. ANOTHER TIME THE CAR STALLED WHILE IDLING 4 TIMES WITHIN 30 MINUTE DRIVE. TONIGHT THE CAR LOST POWER COMPLETELY WHILE I WAS DRIVING. I SEE MULTIPLE COMPLAINTS ON THIS PAGE FOR THE SAME PROBLEM. SATURN HAS NOT BEEN ABLE TO FIND ANY PROBLEMS ON THEIR COMPUTER. I WOULD LIKE TO FIGHT THIS WITH THE LEMON LAW BUT I AM SO AFRAID TO DRIVE THIS CAR NOW THAT I WANT TO JUST GET RID OF IT AS SOON AS POSSIBLE. *JB

2004 ION 3 QUAD PURCHASED NEW IN 2004 CURRENTLY HAVE 18K MILES ON IT. SO FAR WE HAVE HAD TO REPLACE FRONT STABILIZER BUSHING, HEATER BLOWER MOTOR AND WINDSHIELD WIPERS. ALL HAVE BEEN UNDER WARRANTY. THE ELECTRIC STEERING STILL DOESN'T SEEM CORRECT. SOMETIMES THE CAR PULLS WHEN YOU RAPIDLY ACCELERATE AND IS VERY TOUCHY. I DID READ THAT GM MADE SOME CHANGES TO THE ELECTRIC STEERING FOR 2005 ION, BUT DEALERSHIP WILL NOT (SAYS CAN NOT) MAKE THE CHANGES TO THE 2004. NOW WE HAVE THE LOSS OF POWER PROBLEM. HAS DONE IT WHEN CAR IS COLD AND HOT, USUALLY WHEN ACCELERATING, BUT ONCE JUST DRIVING 35 MPH. IT'S NOT A STALL JUST LIKE A LOSS OF POWER. CAR DOESN'T SHAKE OR JERK. ALMOST LIKE YOU TOOK YOUR FOOT OFF THE GAS FOR A SECOND. I'VE TAKEN IT BACK TO THE DEALER ONCE FOR THIS AND THE DEALER RESPONSE IS THE SAME AS OTHERS HAVE REPORTED "NO COMPUTER CODES, COULD NOT REPRODUCE, NO PROBLEM FOUND". IT'S AT THE SHOP NOW BECAUSE THE CHECK ENGINE LIGHT CAME ON 12/2 AND WE AGAIN COMPLAINED THAT THE CAR LOST POWER AFTER PICKING IT UP THE LAST TIME. THE LAST TIME IT FAILED MY WIFE WAS TAKING OFF FROM A RED LIGHT AND THE GUY BEHIND ALMOST HIT HER WHEN THE SATURN LOST POWER. LOOSING FAITH IN SATURN'S ENGINEERING. *NM

SHIFTER KNOB IN 04'SATURN ION REDLINE FELL OFF THE COLUMN WHILE SHIFTING 1-2. OCCURRED IN A PARKING LOT, ABLE TO STOP VEHICLE. ALL GEARS LOCKED OUT DUE TO REVERSE LOCKOUT, WAS ABLE TO REPLACE KNOB BY HAND AND UNLOCK GEARS. ALSO HAVE HAD CAP ON SHIFTER KNOB REPEATEDLY FALL OFF WHILE DRIVING, TO NO CONSEQUENCE OTHER THAN INCONVENIENCE. *NM

Mileage: 13,200

I FIRST TOOK MY 2004 SATURN 3 ION QUAD COUPE TO THE DEALER WITH A TRANSMISSION PROBLEM. AS I WOULD ACCELERATE THE CAR WOULD LOSE SPEED. I NEVER KNEW WHEN THIS WAS GOING TO HAPPEN. IT HAPPENS AT ANY SPEED. AT THE TIME OF MY FIRST COMPLAINT THERE WAS 27,539. I NOW HAVE 33,020 AND FINALLY AFTER 3 MONTHS AND 12 TRIPS TO THE DEALER THEY ARE PUTTING IN A NEW TRANSMISSION. EVERY TRIP TO THE DEALER RESULTED IN MY BEING TOLD THAT THE COMPUTER SAID NOTHING WAS WRONG WITH MY CAR. THEY KEPT THE CAR FOR A WEEK WHILE THEIR MANAGER DROVE IT TO WORK AND HOME EVERYDAY AND HE SAID THE CAR NEVER ACTED UP ON HIM. I LEFT THE DEALERSHIP AND 2 MILES DOWN THE ROAD IT STARTED ACTING UP. I HAD TO CALL THE SATURN CUSTOMER SERVICE NUMEROUS TIMES ABOUT THE PROBLEM. I WROTE THEM 2 LETTERS AND FINALLY WHEN I SENT THEM LEMON LAW PAPERS AND TOLD THEM THEY COULD BUY IT BACK THEY DECIDED THAT I NEEDED A NEW TRANSMISSION. IN THE 3 MONTHS TRYING TO GET THIS PROBLEM FIXED SATURN REPLACED THE CRUISE CONTROL SWITCH, THE INPUT/OUTPUT SPEED SENSOR AND COVER GASKET, THEN THEY REPLACED THE COVER ASSEMBLY, VARIABLE DRIVE AND DRIVEN PULLEY A AND NOW THE WHOLE TRANSMISSION IS BEING REPLACE. IT IS NOW IN THE SHOP FOR WHO KNOWS HOW LONG AND THEN IT WILL BE FOR SALE. *NM

Mileage: 27,539

I HAVE A 2004 SATURN ION RED LINE WITH A MANUAL TRANSMISSION (ONLY TRANSMISSION OFFERED). I WAS SHIFTING FROM FIRST TO SECOND GEAR, IN TRAFFIC, AND THE ENTIRE SHIFT KNOB ASSEMBLY CAME OFF IN MY HAND. THE KNOB FELL TO THE DRIVER'S SIDE FLOOR, CAUSING ME TO LOOK DOWN. I WAS ABLE TO STOP THE VEHICLE IN TIME TO AVOID THE CAR IN FRONT OF ME. THE VEHICLE IS THEN DIFFICULT TO SHIFT, AND THE PULL UP FOR REVERSE FEATURE WAS VERY DIFFICULT. THERE ARE A NUMBER OF COMPLAINTS ON HTTP://WWW.SATURNFANS.COM. THE "FIX" IS TO EPOXY THE KNOB BACK ONTO THE SHIFTER BAR AS IT IS A PRESS FIT DESIGN (NO MECHANICAL LOCK OR FASTENERS).*JB

Mileage: 17,160

WHILE DRIVING APPROXIMATELY 65-70 MPH ON AN INTERSTATE, MY VEHICLE JUST DIED - NO WARNING. THIS WAS THE SECOND TIME IT HAD HAPPENED. THERE IS NO POWER & MUST BE PULLED OFF THE ROAD & RESTARTED. THIS IS A VERY DANGEROUS CONDITION - RAPID DECELERATION ON A CONGESTED HIGHWAY COULD BE FATAL. WHEN I TOOK IT TO THE DEALER, THEY TOLD ME NOTHING SHOWED UP ON THE COMPUTER, THEREFORE NOTHING WAS WRONG WITH THE CAR. TALKING TO THE SATURN CUSTOMER SERVICE REP RETURNED THE SAME RESPONSE. I AM VERY AFRAID TO DRIVE THIS VEHICLE, IT IS A VERY HAZARDOUS CONDITION AND THE CAR IS ONLY ONE YEAR OLD. IT IS A 2004 SATURN ION. THE DEALER REFUSES TO REPLACE ANYTHING BECAUSE "NOTHING IS WRONG. *JB

Mileage: 13,400

DT: CONSUMER STATES THAT VEHICLE DOES NOT ACCELERATE FROM A STOPPED POSITION. AT DIFFERENT TIMES IT COULD TAKE APPROXIMATELY 10-15 SECONDS TO GO. THIS OCCURS MOSTLY WHILE THE VEHICLE IS STOPPED, AND HAPPENED ONCE WHEN VEHICLE WAS GOING. CONSUMER TOOK VEHICLE TO SATURN DEALER, AND WAS TOLD NOTHING THEY COULD DO UNLESS THEY COULD DUPLICATE THE ACTION. *AK *JB

Mileage: 3,400

DURING BRAKING, WHEN GEARS SHOULD BE DOWNSHIFTING, MY AUTOMATIC SATURN ION 3 RPMS WOULD SEEM TO BE RACING UPWARDS BY SEVERAL 1000'S. I COMPLAINED ON 2 PRIOR OCCASSIONS TO DEALER WHO COULD NOT "DUPLICATE THE PROBLEM". ON 05/13/05 I WAS BACKING OUT OF MY GARAGE, CAR SEEMED TO LURCH BACKWARDS. WHEN I PUT IT IN DRIVE IT THE RPMS RACED ABOVE 3000. IT LURCHED ME OUT OF MY DRIVEWAY AND INTO THE ROAD. PUT IN REVERSE AND WAS ABLE TO STOP AND PARK. TURNED IGNITION OFF AND RESTARTED. IN PARK CAR WAS IDLING AT 3500 RPMS. RESTARTED SEVERAL TIMES WITH SAME RESULT. CALLED ROADSIDE ASSISTANCE B/C CAR IS STILL UNDER WARRANTY. TOW GUY HAD TO BRAKE ENTIRE TIME HE WAS LOADING CAR ONTO STEEP INCLINE OF TRUCK BED B/C HE SAID CAR WAS QUICKLY MOVING FORWARD AND UP ON IT'S OWN. WAITED W/ SERVICE PEOPLE AT SATURN TO MAKE SURE THEY COULD "DUPLICATE THE PROBLEM". THEY DID. REPLACED THE THROTTLE POSITION SENSOR. COMPLAINED HARSHLY B/C THIS WAS 3RD TIME IN. CAR HAD TO BE TOWED IN MARCH B/C IT WOULDN'T START IN THE A.M. TOW GUY COULDN'T START EITHER. OF COURSE SATURN COULD NOT DUPLICATE THAT PROBLEM EITHER AND STATED THAT IT WAS PROBABLY THE COLD WEATHER. DON'T LIVE IN ALASKA... MARCH IN SOUTH CAROLINA DOES NOT WARRANT A 1 YR OLD, GARAGE KEPT CAR NOT STARTING. DEALERSHIP STATED THEY COULD NOT DUPLICATE PROBLEM OF NOT STARTING OR OF RPMS AND THEY DID NOTHING. SATURN MADE EFFORTS, AFTER THE MAY INCIDENT, TO COMPENSATE. WILL UPDATE WHEN ALL DETAILS ARE WORKED OUT.

Mileage: 35,700

TRANSMISSION SLIPS GEARS WHEN DRIVING DOWN HILL. CONSUMER DOES NOT HAVE TO DEPRESS THE ACCELERATOR OR BRAKE PEDAL. VEHICLE WILL JUST SLOW DOWN TO 10 MPH. WHILE DRIVING UP THE HILL VEHICLE WILL ACCELERATE UP TO 25 MPH. *AK

I BOUGHT MY 04 ION2 IN JANUARY OF LAST YEAR. ABOUT ONE MONTH AFTER MY PURCHASE I NOTICED THAT MY CAR WOULD DOWNSHIFT WHILE BRAKING DOWNHILLS, WHICH WOULD CAUSE THE RPMS TO ACCELERATE EXTREMELY HIGH. THE CAR WOULD THE JERK ITSELF BACK INTO THE GEAR IT WAS SUPPOSE TO BE IN. THIS WENT ON FOR MONTHS AND IS STILL OCCURING. I HAVE BROUGHT MY CAR TO SATURN OF SPRINGFIELD COUNTLESS TIMES. AT ONE POINT I WAS IN THERE MUTLIPLE TIMES IN ONE WEEK. NOT ONLY DID IS ACCELERATE GOING DOWNHILL BUT IT WON'T SHIFT INTO THE NEXT GEAR GOING UP HILL, AND TO TOP IT OFF WHEN I ENTER THE HIGHWAY THE CAR WONT SHIFT INTO 5 GEAR WHEN I AM ACCELERATING, I HAVE TO REMOVE MY FOOT FROM THE GAS PEDAL TO ALLOW THE CAR TO SHIFT. SATURN HAS TOLD ME COUNTLESS TIMES THAT THERE IS NOTHING WRONG WITH MY CAR. I ONLY AVERAGE ABOUT 16 MILES TO THE GALLON NO MATTER IF IT IS THE HIGHWAY OR CITY. I HAVE GOTTEN TO THE POINT WERE SATURN CALLS ME THE NEXT DAY AFTER EVERY SERVICE CALL. OH AND I JUST HAD TO HAVE MY POSTIVE BATTERY CABLE REPLACED BECAUSE IT WOULDN'T STAY ATTACHED TO THE BATTERY WHICH WOULD'T ALLOW THE CAR TO START.*AK

RECEIVED FIRST SATURN ION 04 AND WITHIN ONE WEEK OF PURCHASE CAR WAS DISPLAYING CLEAR SIGNS OF EITHER AN ELECTRICAL OR COMPUTER PROBLEM. WAS REPLACED WITH A SECOND ION O4. NOTICED A STRANGE CLUNKING SOUND. BROUGHT CAR IN AT 3600 MILES, AND IT WAS TRANSMISSION MOUNTS, WHEEL BEARINGS, AXELS, AND BREAK ROTORS. CAR WAS RETURNED WITH A BROKEN PIECE IN THE INTERIOR, AND SMELLING OF BURNING PLASTIC. I BELIEVE THAT THIS CAR IS DEFECTIVE, AND SATURN REFUSES TO DO ANYTHING OTHER THAN MAKE REPAIRS UNDER WARRANTY. I THINK THAT I SHOULD BE ISSUED A REFUND, DUE TO FAULTY CONSTRUCTION. *NM

Mileage: 50

VEHICLE WAS PURCHASED BRAND NEW AND HAD TRANSMISSION REPLACED. THERE HAD BEEN A LEAK IN THE TRANSMISSION , AND GRINDING SOUND WHEN VEHICLE WAS COLD . CONSUMER STATED THAT DEALERSHIP WAS DOING NOTHING TO HELP WITH THIS PROBLEM. CONSUMER DID NOT FEEL SAFE DRIVING, FEARING THAT THE VEHICLE WILL SHUT DOWN. *AK

Mileage: 48

WHILE ACCELERATING, THE VEHICLE DOWN SHIFTED. THE CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND DROVE IT TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE CONSUMER THAT THE TRANSMISSION CHIP NEEDED TO BE REPLACED. THE PROBLEM RECURRED AND WAS TAKEN BACK TO THE DEALER FOUR TIMES. THE MECHANIC WAS UNABLE TO DUPLICATE THE PROBLEM. *JB ON NUMEROUS OCCASIONS THE VEHICLE DID NOT SHIFT PROPERLY. THE VEHICLE WOULD FEEL AS IF THE TRANSMISSION WAS SLIPPING. THE RPM WOULD GO UP BUT THE VEHICLE DID NOT ACCELERATE AND NO PROBLEM WOULD BE FOUND BY THE SERVICE DEALER. THE CONSUMER HAD ALMOST EXPERIENCED 2 REAR END COLLISIONS AND 1 BROADSIDE COLLISION. *SC *JB

Mileage: 22,960

I BOUGHT A SATURN ION 2 IN JANUARY SINCE THAT DAY I HAVE ONLY GOT AN AVERAGE OF 22.5 MPG THAT IS 270 MILES PER 12 GALLON TANK (AND IT STILL CONTINUES). IN MARCH AS I WAS DRIVING DOWN A BACK ROAD, IT LURCHED, THE CHECK ENGINE LIGHT CAME ON, IT BOGGED DOWN, AND WOULD NOT ACCELERATE OVER 50MPH AND WAS EXTREMELY SLUGGISH, FELT LIKE I WAS DRIVING A GOLF CART. I HAD IT TOWED TO THE DEALER. THE RECALLS ON THE FUEL FILTER AND COMPUTER SYSTEM WERE COMPLETED. THE DEALER INFORMED ME THAT THE CAR WAS "OPERATING AS DESIGNED" AND THE PROBLEM COULD NOT BE REPEATED. JUNE 10TH, THE CAR REPEATED THE SAME PROBLEM. I TOOK IT IN AGAIN, THEY DID THE 6,000 MILE SERVICE ON IT. PER MY RECORDS, EVERYTHING "CHECKED OUT". THE PROBLEM COULD NOT BE REPEATED. THE CAR WAS "OPERATING AS DESIGNED. 3 WEEKS LATER, DRIVING ON THE FREEWAY, THE CAR ONCE AGAIN, LURCHED, THE CHECK ENGINE LIGHT CAME ON, AND WENT FROM 65  40 MPH. THANKFULLY I DID NOT GET REAR-ENDED. I EXITED THE FREEWAY, HAD TO STOP AT A LIGHT, THEN DURING A LEFT HAND TURN HAD DIFFICULTY GETTING THE CAR TO ACCELERATE. THE CAR FINALLY CORRECTED ITS PROBLEM, AND I WAS ABLE TO DRIVE HOME. I TOOK THE CAR TO THE DEALERSHIP YET AGAIN, THEY COULD NOT REPLICATE THE PROBLEM. THEY REPLACED MY VALVE BODY AND NOW MY CAR IS RUNNING WORSE THEN IT WAS BEFORE. I STOPPED BY THE DEALERSHIP A DAY AGO, AND TALKED TO THE MAINTENANCE MANAGER, AND HE STATED THAT HE HOPES THEY REPLACE THE CAR, SINCE THERE IS NOTHING THEY CAN DO ABOUT IT. THEY HAVE TRIED EVERYTHING. MY CAR IS UNSAFE TO ME AND OTHERS AROUND. IT IS A SAFETY ISSUE. I AM NO LONGER COMFORTABLE DRIVING MY CAR. I HAVE OPENED A CASE WITH SATURN CUSTOMER ASSISTANCE. THIS PROBLEM THAT I HAVE EXPERIENCED AND AS I HAVE READ OTHERS TOO, IS EXTREMELY UNSAFE!*AK

Mileage: 2,674

WE OWN A 2004 SATURN ION3 QUAD COUPE, IT HAS A DIFFERENT TRANSMISSION THEN THE OTHERS. WE BOUGHT THE VEHICLE ON DECEMBER 31, 2003. IT HAD 91 MILES ON IT. WE NOTICED THE TRANSMISSION SEEMED TO HESITATE A LITTLE GOING FROM FIRST INTO SECOND. WHEN WE TOOK IT IN FOR IT'S FIRST OIL CHANGE IN MARCH, WE ASKED THEM TO LOOK AT THE TRANSMISSION. THEY REPORTED BACK THAT IT WAS NORMAL FOR A 4 CYLINDER TO ACT THE WAY IT WAS. ASSUMING THEY KNEW WHAT THEY WERE TALKING ABOUT WE LEFT IT AT THAT. WE TOOK IT IN AGAIN FOR PAINT DAMAGE THEY HAD CAUSED WHEN THEY HAD THE VEHICLE FOR THE OIL CHANGE, AND AGAIN ASKED THEM TO LOOK AT THE TRANSMISSION (ONLY ABOUT A WEEK LATER). THEY AGAIN REPORTED THEY TEST DROVE AND IT WAS FINE. NOW THIS PAST WEEK FOR IT'S SECOND OIL CHANGE ON TUESDAY, JUNE 29TH, WE AGAIN ASKED THEM BECAUSE IT SEEMED TO HAVE GOTTEN WORSE. THEY AGAIN REPORTED IT WAS NORMAL OPERATION. NOT A WEEK AFTER THAT REPORT ON SUNDAY, JULY 4TH AMIDST OUT 4TH OF JULY CELEBRATION WE DROVE A BLOCK AND A HALF FROM HOME AND TURNED A CORNER ONTO THE MAIN ROAD. WHEN I WENT TO ACCELERATE THE CAR REVVED AND DIDN'T SWITCH INTO SECOND GEAR. IT FOUGHT TO GO FASTER IN FIRST GEAR, BUT NEVER SWITCHED. WE NOTICED IMMEDIATELY AND TRIED PARKING AND AGAIN MOVING INTO DRIVE, THINKING MAYBE IT HAD DROPPED ITSELF INTO NEUTRAL. AGAIN THE SAME THING, WE SLOWLY TURNED THE CORNER AND PUTTED OUR WAY BACK DOWN THE BLOCK TO THE DRIVEWAY AT 5 MILES AN HOUR SO AS NOT TO FURTHER DAMAGE THE ENGINE DUE TO TRANSMISSION FAILURE. THE CAR CURRENTLY HAS 7000 MILES ON IT AND A TRANSMISSION THAT DOESN'T WORK. WE MEET WITH THE DEALERSHIP TODAY TO DISCUSS RETRIBUTION. *NM

Mileage: 7,100

WHEN I ACCELERATE ON HIGHWAY THE CAR DOES NOT PICK UP SPEED, IT BUCKS THEN PUSHES ITSELF. THE ENGINE IS VERY LOUD. SOUNDS LIKE GRINDING OR WHIRRING. THEY HAVE HAD TO CALIBRATE THE VEHICLE 2 TIMES IN THE 3 MONTHS I HAVE HAD THIS CAR. IT IS IN THE SHOP AGAIN TODAY. (3RD TIME). *AK

Mileage: 1,500

VTI TRANSMISSION CAUSES SUDDEN VEHICLE DECELERATION. *AK

Mileage: 3,000