2003 SATURN L200 Engine And Engine Cooling Problems

The contact owns a 2003 Saturn L200. The contact stated that while his wife was driving 45 MPH, an abnormal whirling sound was coming from the vehicle and the vehicle stalled without warning. The contact's wife was unable to restart the vehicle and with the assistance of a police officer, she coasted the vehicle off to the shoulder of the roadway. The vehicle was then towed to an independent mechanic where the vehicle was diagnosed with a defective timing chain which resulted in engine failure. The dealer nor the manufacturer had yet to be notified of the failure. The vehicle had yet to be repaired. The failure mileage was unknown.

PARKED CAR AND NEXT MORNING WENT TO START AND CAR WOULD NOT START. IT WOULD ONLY TURN N NOT START. WENT TO WHERE BOUGHT IT N THEY DIAGNOSIS TIMING CHAIN WAS BROKE. *TR

Mileage: 91,200

I WAS DRIVING MY 2003 SATURN AND WHEN I STOP IT MADE A NOISE IN THE ENGINE. WHEN I WENT TO START IT,IT TURNED OVER REAL FAST AND WOULD NOT START. IT HAS SPARK AND FUEL BUT NO NOT THINK IT HAS COMPRESSOR. WOULD LIKE TO KNOW IF THIS CAR IS UNDER A RECALL FOR THE TIMING CHAIN. IT HAS 107,000 MILES ON IT. IT SEEM LIKE IT WOULD BE VERY COSTLY TO FIX. *TR

PREMATURE FAILURE OF TIMING CHAIN ON 2003 SATURN L200 AT 69,400 MILES. THIS CAR HAS THE SAME TIMING CHAIN COMPONENTS AS INVOLVED IN THE 2000 MODEL YEAR RECALL. THE PARTS WERE NOT REVISED UNTIL AFTER THIS CAR WAS BUILT. THE CAR WAS MAINTAINED WITH RECOMMENDED OIL CHANGE INTERVALS, BUT THE CHAIN STILL FAILED PREMATURELY. *TR

Mileage: 69,400

TL*THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT WAS UNABLE TO START THE VEHICLE. THE VEHICLE WAS TOWED TO THE DEALER AND A TECHNICIAN CONCLUDED THAT THE TIMING BELT AND ENGINE VALVES NEEDED TO BE REPLACED. ENGINE FAILURE WHILE DRIVING INCREASED THE RISK FOR A VEHICLE CRASH. NO REPAIRS WERE MADE. THE CURRENT AND FAILURE MILEAGES WERE 63000.

Mileage: 63,000

BODY-CONTROL MODULE FAILURE: WITHIN 3 MONTHS OF EACH OTHER, THE BODY-CONTROL MODULE (BCM) AND ENGINE COOLANT THERMOSTAT HAD TO BE REPLACED. SATURN DEALER, ON 3/28/2009 TOLD ME THAT THE BCM, IF NOT REPLACED, COULD LEAD TO SERIOUS FAILURES, SUCH AS FAILURE TO START, OVERHEATING AND OTHER PROBLEMS. OVER PRIOR SEVERAL WEEKS, THERE WERE INTERMITTENT READINGS ON DASHBOARD, INCLUDING CHECK ENGINE, SERVICE ENGINE, AIRBAG WARNING LIGHT AND ABS WARNING LIGHT. APPARENTLY NOTHING WRONG WITH THE ENGINE, AIRBAG OR BRAKES THEMSELVES, BUT THE BCM WAS GOING BAD, CAUSING THE READINGS ON DASHBOARD. BCM REPLACEMENT APPROX. $450 AND ENGINE COOLANT THERMOSTAT REPLACEMENT COST APPROX $300. *TR

Mileage: 56,000

THE TIMING CHAIN ON MY 2003 SATURN L200 WITH 108,000 MILES IS ABOUT TO FAIL AND APPARENTLY THERE IS A KNOWN (NHTSA INVESTIGATED EVEN) PROBLEM WITH THESE VEHICLES. $1300 I DON'T HAVE TO FIX IT. THIS IS ALONG WITH A SERIES OF AIR CONDITIONER PROBLEMS (IMPROPER TUBE MOUNTING SUCH THAT IT WORE THROUGH) COSTING OVER $1000 DOLLARS SINCE I PURCHASED THE VEHICLE. *TR

Mileage: 105,000

I WAS DRIVING MY SATURN L200 ON A COUNTRY ROAD AT ABOUT 35 MPH. THE ENGINE SUDDENLY STOPPED RUNNING, AND WOULD NOT RESTART. THE CAR BECAME DIFFICULT TO STEER AND STOP WITHOUT THE POWER STEERING AND BRAKES. I CAME CLOSE TO RUNNING INTO A DITCH AS A RESULT OF THE DIFFICULTY IN CONTROLLING THE CAR. *TR

Mileage: 67,000

TL*THE CONTACT OWNS A 2003 SATURN L200. THE VEHICLE WAS PARKED AND THE CONTACT COULD NOT GET IT TO START. THE VEHICLE WAS TOWED TO A MECHANIC AND THEY STATED THAT THE TIMING CHAIN FAILED FOR THE SECOND TIME IN SEVEN MONTHS. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 93,800 AND FAILURE MILEAGE WAS 81,000.

Mileage: 81,000

CAR DIED WHILE TRAVELING ON LOCAL HIGHWAY. *TR

Mileage: 84,000

TL*THE CONTACT OWNS A 2003 SATURN L200. WHILE DRIVING 55 MPH, THE VEHICLE SUDDENLY SHUT OFF AND WAS UNABLE TO BE RESTARTED. PRIOR TO THE FAILURE, THE VEHICLE HESITATED WHILE DRIVING. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THEY STATED THAT THE TIMING CHAIN WAS THE CAUSE OF THE FAILURE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CURRENT AND FAILURE MILEAGES WERE 84,000.

Mileage: 84,000

TL*THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT STATED THAT HER SON'S VEHICLE FAILED AND COMPLETELY SHUT DOWN TWICE. THE CONTACT ALSO STATED THAT THE VEHICLE WOULD MAKE A LOOSE, RATTLING NOISE WHILE MAKING A TURN. SHE STATED THAT THERE WAS A RECALL ON THE VEHICLE INVOLVING THE STEERING MODULE. THE STEERING WHEEL WOULD LOCK AND HER SON COULD NOT RETURN IT TO THE PROPER POSITION. THE VEHICLE WAS TOWED TO THE DEALER AND THEY PROCEEDED TO SELL HER SON A WARRANTY, ALTHOUGH THE VEHICLE WAS ALREADY UNDER WARRANTY. THE DEALER WAS UNABLE TO LOCATE ANY FAILURES. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 55,253 AND FAILURE MILEAGE WAS 42,300. UPDATED 04/29/08. *LJ THE VEHICLE WOULD NOT SHIFT OUT OF PARK , THE ENGINE, AIR BAG AND ABS LIGHTS ILLUMINATED. UPDATED

Mileage: 42,300

TL*- THE CONTACT OWNS A 2003 SATURN L SERIES. WHILE DRIVING AT 30 MPH THE ELECTRICAL WARNING LIGHT ILLUMINATED ,AND THE FRONT END BEGAN TO SHAKE. THE CHECK ENGINE LIGHT ALSO ILLUMINATED. THE CONTACT STATED THAT SHE PULLED OVER AND TURNED THE VEHICLE OFF, AND RESTARTED THE VEHICLE AFTER WAITING ABOUT TEN MINUTES. THE CHECK ENGINE LIGHT REMAINED ILLUMINATED, WHITE SMOKE STARTED EXITING THE EXHAUST PIPE AND THE VEHICLE BEGAN TO SHAKE. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT STATED THIS OCCURRED ON FIVE DIFFERENT OCCASIONS. THE DEALER HAD REPLACED THE PUMP AND/OR GAS COOLANT, INSULATOR ASSEMBLY FRONT SUSPENSION SUPPORT, OXYGEN SENSOR AND EXHAUST SYSTEM. THE CURRENT MILEAGE WAS 48,000. *AK

Mileage: 48,000

TL* - THE CONTACT'S 2003 L SERIES SATURN WAGON STALLED. THE CONTACT'S VEHICLE WAS TOWED TO THE DEALER IN GREENSBORO, NC. NO WARNING LIGHTS OR NOISES WERE EXPERIENCED. THE CONTACT WAS DRIVING 72 MILES AN HOUR AT THE TIME OF THE INCIDENT, THE CAR DRIFTED AFTER IT LOSS POWER AND WOULD NOT RESTART. THE WARRANTY ENDED 3 TO 4 MONTHS AGO AND SHE INCURRED THE COST FOR THE REPAIRS. THE CONTACT REVIEWED A NOTICE ON NHTSA WEBSITE DEFECT PETITION DATED JANUARY 23, 2006 STATES NUMBER PE06006 WHICH STATES THAT THE TIMING CHAIN CAN CAUSE FAILURE AND STALLING.

Mileage: 55,000

2003 SATURN L200 WITH 48,000 MILES DIED WHILE DRIVING. WE HAD TO QUICKLY SWERVE TO OPPOSITE SIDE OF ROAD WHERE THERE WAS A SHOULDER IN ORDER TO GET OUT OF THE TRAFFIC LANE(NO SHOULDER ON THE LANE WE WERE IN). CAR WAS TOWED, AND WAS DIAGNOSED WITH A BROKEN TIMING CHAIN, PROBABLE ENGINE DAMAGE, AND POSSIBLE FUEL PUMP FAILURE. SINCE I JUST PUT A NEW ALTERNATOR AND BATTERY IN THE VEHICLE THREE WEEKS PRIOR, I CONTACTED MANUFACTURER AND TALKED WITH DEALER ABOUT WORKING WITH ME TO FIX THIS CAR. THEY WOULD NOT EVEN DISCUSS NEXT STEP UNTIL I AUTHORIZED (PAID FOR) A $750 TEAR DOWN OF THE MOTOR TO "FULLY DIAGNOSE" THE PROBLEM. I REFUSED TO TO AUTHORIZE, BECAUSE ALL OF THE BURDEN AT THAT POINT WOULD BE ON ME, WHATEVER HAPPENED. SITUATION WAS NEVER RESOLVED; I TRADED THE CAR (AT A DRASTIC REDUCTION OF VALUE DUE TO ITS NON-WORKING CONDITION). *NM

Mileage: 48,400

MY SERVICE ENGINE LIGHT CAME ON. THE FIRST TIME I TOOK IT TO SATURN DEALERSHIP IN LYNCHBURG, VIRGINIA THEY TOLD ME THEY COULD NOT FIND A PROBLEM. IT HAS COME ON AGAIN AND IS READING THE SAME CODE. I HAVE TO TAKE IT BACK AGAIN FOR THE SAME PROBLEM. THE CODE READS P1887. I TRULY THINK THAT THIS IS A PROBLEM WITH THE SATURN L 2003. *JB

Mileage: 49,728

TIMING CHAIN BREAKS PREMATURELY RESULTING IN LOSS OF POWER CREATING A POTENTIAL ROAD HAZARD. *JB

Mileage: 32,000

PROBLEMS WITH VEHICLE'S POWER STEERING SYSTEM.*MR CONSUMER NOTICED THE FAILURE WHEN DRIVING OFF THE LOT BUT THOUGHT I WAS DUE TO COLD WEATHER. LATER SHE LEARNED THE RACK AND PINION NEEDED TO BE REPLACED DUE TO FLUID LEAKING. AFTER THE REPAIR, CONSUMER STARTED HEARING GRINDING NOISE WHEN TURNING. ON 10/08/03, THE CONSUMER LEARNED THE STEERING PUMP HAD TO BE REPLACED. AFTER PICKING UP THE VEHICLE ON THIS DATE, CONSUMER HEARD MORE NOISES. THIS TIME IT WAS A AIR POCKET IN THE STEERING FLUID. IN ADDITION, THE AUTOMATIC CLIMATE CONTROL SYSTEM FAILS TO WORK AS DESIGNED. IT'S PROGRAMMED AT 87 DEGREES WHEN ITS COLD OUTSIDE. INSTEAD OF HEAT, IT WOULD BLOW WARM THEN COLD AIR. THE COMPUTER WAS REPROGRAMMED AND THE PROBLEM BECAME WORST THAN AT FIRST. THERE WERE COUNTLESS OTHER PROBLEMS WITH THIS VEHICLE. *PH

Mileage: 15,758