1998 SATURN SL Power Train Problems

COOLANT AROUND THE SPARK PLUG NEAREST THE TRANSMISSION, ENGINE OIL IS VISIBLE IN COOLANT TANK. INTERNET SEARCH REVEALED A CRACKED HEAD DUE TO FACTORY DEFECT IN HEAD CASTING. GM DID NOT ISSUE A RECALL! *TR

Mileage: 101,000

WHILE PARKING MY 1898 SATURN SL IN A HOSPITAL GARAGE, THE SHIFT LEVER WENT LIMP WITHOUT WARNING. THERE WAS NO WAY TO OPERATE THE TRANSMISSION. WHEN I REMOVED THE CONSOLE, I DISCOVERED THAT THE PLASTIC BUSHING THAT CONNECTS THE MANUAL SHIFT LEVER TO THE SHIFT CABLE WAS MISSING. THERE WAS NO LONGER ANY CONNECTION BETWEEN THE SHIFT LEVER AND THE CABLE TO THE TRANSMISSION. THE ENTIRE SHIFT CABLE ASSEMBLY HAD TO BE REPLACED TO FIX THE PROBLEM. SATURN TOLD ME THAT THE BUSHING IS MADE ONTO THE CABLE RATHER THAN BEING AVAILABLE AS A SEPARATE PART. IF THIS BUSHING HAD FAILED IN A TRAFFIC SITUATION IT COULD HAVE RESULTED IN AN ACCIDENT. THE BUSHING SHOULD BE DESIGNED SUCH THAT IF IT BRAKES; THE SHIFT LEVER WILL REMAIN CONNECTED TO THE SHIFT CABLE AND JUST CAUSE SLOPPY SHIFTING THEREBY WARNING THE DRIVER THAT REPAIR IS REQUIRED. I STILL HAVE THE OLD SHIFT CABLE ASSEMBLY. *JB

Mileage: 55,600

MY 23 YR OLD SON WAS TRAVELING FROM VENTURA, CA AT 75 MPH ON FWY 99 N BOUND IN THE MIDDLE LANE (OF 3) AT ABOUT 1 A.M. IN FRESNO, CA. JUST BEFORE ARRIVING AT HIS EXIT TO HWY 41 N, THE REAR END BEGAN TO SKID TO THE LEFT. DRIVER STEERED INTO THE SKID TO CORRECT WHILE STEPPING ON THE BRAKES TO REDUCE SPEED. SUDDENLY THE REAR END OF THE CAR WAS HURLED INTO THE AIR CAUSING THE ENTIRE VEHICLE TO GO AIRBORNE, CLEARING THE THIRD LANE (FAR RIGHT LANE) AND LANDING ON TOP OF ASPHALT BERM AND SOFT, SANDY EMBANKMENT RESULTING IN THE CAR ROLLING AND GOING AIRBORNE, BOUNCING OFF THE REAR END OF THE CAR AND GOING AIRBORNE YET A THIRD TIME LANDING UPSIDE DOWN ON THE SHOULDER OF THE FREEWAY WITH THE NOSE OF THE CAR EXTENDING INTO THE THIRD LANE. DRIVER RECEIVED MINOR INJURIES BUT CHP OFFICERS WERE ASTONISHED IT WAS NOT A FATALITY. CAR WAS TOTALED. TALKS WITH SATURN HEADQUARTERS HAS ONLY RESULTED IN DENIAL THAT THE SPINDLE COULD HAVE CAUSED THE ACCIDENT. THEY INSIST A TIRE BLOWOUT WAS MOST LIKELY THE CAUSE. PERSONAL INVESTIGATION REVEALED THERE WAS NO BLOWOUT. EVIDENCE POINTS TOWARD THE SPINDLE BREAKING ALLOWING THE WHEEL ASSEMBLY TO FOLD DOWN UNDER THE CAR CAUSING IT TO SKID TO THE LEFT. THE APPLICATION OF BRAKES BROUGHT THE FRONT END OF THE CAR DOWN ENOUGH TO ALLOW THE WHEEL ASSEMBLY TO CATCH THE FRAME ASSEMBLY AND PITCH THE CAR INTO THE AIR WHILE TEARING OUT THE ENTIRE REAR WHEEL WELL ASSEMBLY. PARTS OF THE WHEEL ASSEMBLY WERE FOUND 40 FEET BEFORE THE IMPACT OF THE CAR ON THE DRIVER'S SIDE (WHICH WOULD BE IMPACT #2) AS IT TUMBLED ACROSS THE FREEWAY EMBANKMENT. NO ONE SEEMS TO WANT TO FURTHER INVESTIGATE THE WRECKAGE INCLUDING OUR INSURANCE AND SATURN.*AK

Mileage: 174,000

VEHICLE WAS NOT RUNNING PROPERLY. TAKEN TO MECHANIC WHO TOLD ME THAT VEHICLE WAS 5 QUARTS LOW ON TRANSMISSION FLUID AND VEHICLE WOULD HAVE STOPPED RUNNING IF NOT TAKEN CARE OF AT THAT TIME. ALTHOUGH VEHICLE ONLY HAD 35000 MILES ON IT TRANSMISSION, WHICH HAD DEFECT, HAD TO BE REBUILT FOR $2400+.*AK

Mileage: 34,000

MY WIFE'S '98 SATURN SL1 HAS APPROXIMATELY 80,000 MILES ON IT. ABOUT A WEEK AGO, SHE WAS NO LONGER ABLE TO SHIFT OUT OF 1ST GEAR. AFTER TAKING THE CENTER CONSOLE OUT, I NOTICED THAT A RUBBER GROMMET THAT ATTACHED THE SHIFT ROD TO THE SHIFT CABLES HAD ROTTED AND BROKEN IN HALF. NORMALLY, THIS SHOULD HAVE BEEN VERY EASY TO REPLACE. A NEW GROMMET COULD VERY EASILY BE POPPED IN WITH AROUND 1/2 HOUR OF WORK. WHEN I APPROACHED THE LOCAL SATURN DEALERS, THEY SAID THEY DID NOT HAVE THE .50 CENT GROMMET AVAILABLE, AND THAT THE ENTIRE SHIFTER CABLE WOULD HAVE TO BE REPLACED (THERE IS NOTHING WRONG WITH THE CABLES THEMSELVES). THE PERSON WORKING THERE SAID THEY HAVE TO REPLACE THE WHOLE CABLES VERY OFTEN. TOTAL COST FOR THE CABLES AND LABOR IS AROUND $600. THEY DO NOT SELL THE GROMMET SEPERATELY. GETTING SUSPICIOUS, I WENT ON THE INTERNET TO RESEARCH THE PROBLEM. I FOUND MANY SITES WITH PEOPLE EXPERIENCING THE SAME PROBLEM (SEE HTTP://WWW.CHAOSMAGNET.COM/BLOG/ARCHIVES/000112.HTML, HTTP://WWW.AUTOGUIDE.NET/CGI-SEC/AUTOPARTS/MESSAGES/MSG.CGI?1589.SHTML, FOR EXAMPLE). ALL COULD EASILY HAVE FIXED THE PROBLEM BY GETTING A NEW RUBBER GROMMET. I BELIEVE THIS IS A SERIOUS PROBLEM THAT SATURN NEEDS TO DO SOMETHING ABOUT. SPENDING $600 FOR A $5 REPAIR IS REDICULOUS AND WRONG. ALSO, MY WIFE'S CAR IS COMPLETELY OUT OF COMISSION UNTIL THIS CAN BE REPLACED. MANY REPORTS FROM OTHER OWNERS I HAVE READ HAVE STATED THAT TO GET AROUND SPENDING $600, THEY ARE USING SELF MADE FIXES. THIS COULD BE VERY DANGEROUS TO DO, AND COULD CAUSE ACCIDENTS IN THE FUTURE. HOWEVER, THEIR OPTIONS ARE SOMEWHAT LIMITED UNLESS THEY WISH TO SPEND A LOT OF MONEY. AGAIN, THIS PROBLEM COULD BE EASILY RECTIFIED IF SATURN WOULD SIMPLY MAKE THE GROMMET AVAILABLE FOR SALE. REGARDS, JAMES LANGFORD.

WHILE ACCELERATING TO 40 MPH CONSUMER SHIFTED FROM SECOND TO THIRD GEAR AND FLOOR SHIFTER FAILED. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

Mileage: 35,000

SHIFTER ARM CLUTCH LINKAGE BUSHING BROKE WHILE SHIFTING GEAR. *JB

Mileage: 130,000

MANUAL TRANSMISSION LINKAGE BROKE. THE PLASTIC THAT LOCKS THE BALL OF THE LINKAGE TO THE SOCKET OF THE SHIFTER CRACKED, AND BECAME SEPERATED WHILE IN OPERATION.*AK

1998 SATURN WITH 49,000 MILES NEEDED THE WHOLE TRANSMISSION TO BE REBUILT. THE VALVE BODIES ARE KEPT IN STOCK AT SATURN OF ROUTE 23 BECAUSE THIS IS SUCH A COMMON PROBLEM WITH SATURN. THE CAR HAD BEEN PROPERLY MAINTAINED, TRANS SERVICE AT 25,500 MILES. SATURN WILL TAKE NO RESPONSIBILITY IN THE COST OF REPAIRS. I'VE NOTED THAT SATURN IS ON SEVERAL WEBB SITES WITH TRANSMISSION FAILURES DOCUMENTED.

Mileage: 49,000

CONSUMER NOTICED UPON STARTING VEHICLE PARK PAW WOULD NOT SHIFT OUT OF PARK. DEALER HAS BEEN CONTACTED. *AK THIS HAPPENED ON FOUR DIFFERENT OCCASIONS. CONSUMER HAD TO ROCK THE VEHICLE, RESTART, PUMP THE BRAKES AND GIGGLE THE LEVER BEFORE IT WOULD RELEASE. WHEN CHANGING GEAR A SCRAPPING SOUND WAS HEARD AND SATURN STATED IT WOULD GET WORSE. AFTER FOUR TIMES, CONSUMER HAD IT REPLACED AT A COST OF $#144.09. CONSUMER NOTED SATURN WOULD NOT WORK ON HIS VEHICLE MAYBE BECAUSE HE FILLED A COMPLAINT FOR SHABBY WORK. *PH

Mileage: 61,007

PROBLEMS WITH GEAR SHIFT ON 1998 SATURN SL1. *MR THE GEAR SHIFT WOULD NOT COME OUT OF PARK AND THE BCSI SOLENOID WAS REPLACED. *SCC *JB

WHILE DRIVING, THE ENGINE STALLED. THE DEALER REPLACED THE CRANKSHAFT SENOR AND COOLANT TEMPERATURE SENSOR, HOWEVER THE ENGINE STALLED AGAIN. *AK THE POWER STEERING AND IGNITION SWITCH NEEDED TO BE REPLACED. THE GEAR DID NOT SHIFT PROPERLY, MAINLY IN FIRST GEAR. *JB

SMALL PLASTIC RING IN SHIFTER LINKAGE BROKE WHILE IN TRAFFIC LEAVING CAR STUCK IN FIRST GEAR.*JB

Mileage: 79,500

THE VEHICLE STALLED INTERMITTENTLY WHILE DRIVING. THE CAM SWITCH WAS REPLACED TWICE, THE IDLE CONTROL WAS ADJUSTED AND THE THROTTLE WAS REPLACED YET THE PROBLEM RECURRED. THE VEHICLE LUNGED FORWARD WHEN THE VEHICLE WAS SHIFTED IN REVERSE. THE TRANSMISSION WAS REPLACED. *NM

Mileage: 11,979

TRANSMISION HESITATES AND JERKS BEFORE GOING INTO ANY GEAR. PROBLEM HAS EXISTED FOR 3 MONTHS.DEALER WAS NOTIFIED, AND FOUND A FAULTY TRANSMISSION VALVE.*AK

WHEN ACCELERATING TRANSMISSION DOESN'T SHIFT INTO GEAR. ALSO, BATTERY IS LEAKING FLUID, DETERIORATING WIRE HARNESS TO TRANSMISSION. DEALER STATED PROBLEM WILL REOCCUR BECAUSE WIRES DO NOT HAVE A PROTECTIVE COVERING. *AK

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

CLUTCH WAS IN PERFECT CONDITIONS, FALIURE WAS IN THE PRESSURE PLATE THAT OPERATES THE CLUTCH. PARTS DEPARTMENT TOLD ME THAT THIS WAS NOT UN-COMMON FOR MANUAL TRANSMITIONS ON SL1 FROM 96-99 AND WHEN NEW PARTS WERE PURCHASED AT THE DEALER, THERE HAD BEEN A DESIGN CHANGE WHICH INCREASED THE TOTAL COST FOR THE REPAIR. WHY WAS A NEW DESIGN IMPLEMENTED IF THERE WAS NOTHING WRONG WITH THE OLD ONE. JUST IN HAWAII/OAHU THERE HAS BEEN ABOUT HALF A DOZEN OF LOW MILAGE MANUAL TRANS WITH CLUTCH SYSTEM FALIRES.

CLUTCH WAS IN PERFECT CONDITIONS, FALIURE WAS IN THE PRESSURE PLATE THAT OPERATES THE CLUTCH. PARTS DEPARTMENT TOLD ME THAT THIS WAS NOT UN-COMMON FOR MANUAL TRANSMITIONS ON SL1 FROM 96-99 AND WHEN NEW PARTS WERE PURCHASED AT THE DEALER, THERE HAD BEEN A DESIGN CHANGE WHICH INCREASED THE TOTAL COST FOR THE REPAIR. WHY WAS A NEW DESIGN IMPLEMENTED IF THERE WAS NOTHING WRONG WITH THE OLD ONE. JUST IN HAWAII/OAHU THERE HAS BEEN ABOUT HALF A DOZEN OF LOW MILAGE MANUAL TRANS WITH CLUTCH SYSTEM FALIRES.

CAUTION: SATURN AUTOMATIC TRANSMISION MAY BE DANGEROUS IF IT HESITATES AND CLUNKS INTO GEAR OR DOWNSHIFTS INAPPROPRIATELY. SATURN'S COMPUTER DIAGNOSTIC SYSTEM MAY NOT DETECT DANGEROUS TRANSMISSION CONTROL CONDITION. SATURN CORP. POLICY ON PAYING DEALER FOR DIAGNOSTIC WORK FOR WARRANTY ITEMS MAY DISCOURAGE DEALER FROM FURTHER INVESTIGATING POSSIBLY DANGEROUS CONDITIONS.*AK

CONSUMER WAS TRAVELING 55MPH ON WET ROADS VEHICLE DOWNSHIFTED INTO LOW GEAR AT HIGHWAY SPEED. CONSUMER LOST CONTROL AND CRASHED INTO A CONCRETE BRIDGE WHICH GUIDED HIM TO A STOP. TWICE VEHICLE WAS IN SHOP FOR CLUNKING, AND TWICE WITH DOWNSHIFTING ADDED. VEHICLE IN A REPAIR SHOP TO SEE WHAT DAMAGE HAS BEEN DONE.*AK THE CONSUMER SAYS THE DEALER SHOULD HAVE ADDRESSED THE SYMPTEMS OF POTENTIALLY DANGEROUS TRANSMISSION PROBLEM DURING THE 4 SERVICE PERIODS. THE VEHICLE WAS A TOTAL LOSS. THE CONSUMER WAS SEKKING FINANCIAL REIMBERSEMENT FOR THE LOSS AND EXPENSES. *YH

WHILE DRIVING ABOUT 30 MPH CONSUMER HEARD A NOISE, STOPPED AFTER INCREASING SPEED. SHORTLY AFTER, CONSUMER NOTICED SMOKE FROM UNDER HOOD. PARKED VEHICLE,AND NEXT MORNING THERE WAS TRANSMISSION FLUID UNDER VEHICLE, TOWED TO DEALER, WHO FOUND A DIFFERENTIAL PIN HAD COME LOOSE IN TRANSMISSION, AND CAUSED A HOLE IN TRANSMISSION. *AK

VEHICLE'S TRACTION CONTROL FAILED, CAUSING THE VEHICLE TO HYDROPLANE AND SPIN OUT OF CONTROL AND OFF HIGHWAY. WHILE SPINNING, ABS BRAKES FAILED AND CAUSED WHEELS TO LOCK UP.

NO SUMMARY

VEHICLE WANDERS FROM SIDE TO SIDE WHEN DRIVING AT APPROXIMATELY 30-60MPH. LOUD BANGING NOISE OCCURS WHEN GOING OVER BUMPS. HIGH FREQUENCY WHINING FROM THE ENGINE THAT ADDS TO THE NOISE. ALSO, TRANSMISSION SHIFTING HAS TOO LITTLE OR TOO MUCH POWER. DEALER/WESTERN REGION MFR. CONTACTED AND CANNOT REMEDY THE PROBLEM. PROBLEM STILL EXISTS. PROVIDE FURTHER INFORMATION. *AK

WHILE DRIVING 60 MPH THE TRANSMISSION WENT OUT WITHOUT ANY WARNING. DRIVER WAS ABLE TO COAST TO THE SIDE OF THE ROAD SAFELY. THE VEHICLE TOWED TO THE DEALERSHIP WHERE THE TRANSMISSION WAS REPLACED. *AK *ML

TRANSMISSION FAILED.

TRANSMISSION FAILED. YH

TRANSMISSION JERKING AND EXPERIENCES UNWANTED SURGES ALMOST RESULTING IN COLLISIONS.

THE PROBLEM IN A NUTSHELL IS UNEXPECTED/UNPREDICTABLE APPARENT LOSS OF BRAKING.

WHILE DRIVING AT 10 MPH AND COMING TO A HALT THE COMPUTER SHUT DOWN AND NOTHING IN THE CAR WORKED. DEALER CONTACTED TWO TIMES IN THE SAME DAY WITH THE SAME PROBLEM AND ATTEMPTED TO REMEDY THE PROBLEM. CONSUMER DROVE THE CAR AWAY WITH NO GUARANTEE THE PROBLEM WOULD NOT REOCCUR. CONSUMER IS NOT SATISFIED WITH THE SITUATION. SEVERAL REPAIRS OF DUE TO LOSS OF POWER, HOWEVER VEHICLE STILL EXPERIENCES PROBLEMS. TRANSMISSION EXPERIENCED PROBLEMS DURING SHIFTING, FOUND SCUFFED VALVES, REPLACED VALVES THAT WERE BINDING. *AK

TRANSMISSION CONVERTER HOUSING WAS POUROUS AND ALLOWED TRANSMISSION FLUID TO LEAK OUT. THE CONVERTER HOUSING HAD TO BE REPLACED, WITH NEW GASKETS, FILTER AND SEALANT.

WHEN TRAVELING 35 MPH, GOING UP AN INCLINE AND VEHICLE IS PLACED IN FOURTH GEAR, THE VEHICLE WILL DROP FROM FOURTH GEAR INTO SECOND AND WILL ACCELERATE. CONSUMER HAS CONTACTED THE DEALER. DEALER STATES NORMAL OPERATIONS. PLEASE PROVIDE ANY FURTHER DETAILS. *AK

IGNITION KEY STICKING DUE TO FAULTY BRAKE LOCK SHIFT AND CABLE PARK INTERLOCK.