2004 SATURN VUE Engine And Engine Cooling Problems

I TOOK THE VEHICLE TO MY AUTO REPAIR SHOP BECAUSE OF THE RECENT ONSET OF AN UNUSUAL RUMBLING SOUND WHEN DECELERATING. AFTER A TEST DRIVE AND INSPECTION THE MECHANIC WROTE THESE COMMENTS ON THE REPAIR INVOICE. "DETERMINED FRONT FRAME RUSTED THROUGH CAUSING EXTREME MOVEMENT OF ENGINE CRADLE AND ENGINE ASSEMBLY. UNIBODY IS RUSTED OUT. THIS VEHICLE IS PROBABLY TOTALED AND THIS INFORMATION SHOULD BE GIVEN TO THE NHTSA. CAUTION: THIS VEHICLE IS DANGEROUS TO DRIVE AND SHOULD BE TAKEN OFF THE STREET IMMEDIATELY." BOTH THE MECHANIC AND MYSELF FEEL THAT THIS SHOULDN'T HAVE HAPPEDED TO A TEN YEAR OLD CAR WITH LESS THAN 86,000 MILES THAT HAS BEEN PRPERLY MAINTAINED. THE MECHANIC ALSO PHOTOGRAPHED THE DAMAGE. YOUR PROMPT ATTENTION WOULD BE GREATLY APPRECIATED. *TR

Mileage: 85,987

I TRIED TO RESTART MY ENGINE. ALTHOUGH IT TURNED OVER, IT WOULDN'T START. SO I TOOK MY CAR TO A CERTIFIED MECHANIC, AND HE CONCLUDED THAT THERE HAS BEEN A SHORTAGE IN THE SYSTEM, WHICH CAUSED A FUSE TO BE BLOWN. HE REPLACED THE FUSE, AND MY CAR STILL DIDN'T START. AFTER THAT, HE USED HIS DIAGNOSTIC MACHINE, AND SAW THAT I NEEDED A NEW IGNITION SWITCH, WHICH IS WHY IT DIDN'T START. *TR

Mileage: 88,000

TL* THE CONTACT OWNS A 2004 SATURN VUE. THE CONTACT STATED WHILE DRIVING 60 MPH THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO THE DEALER. THE DEALER STATED THAT THE TRANSMISSION WOULD NEED REPLACING. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER OF THE TRANSMISSION WAS NO LONGER IN BUSINESS. THE VEHICLE MANUFACTURER WAS CONTACTED BUT PROVIDED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGE WAS 115,000. UPDATED 07/06/12 *BF THE CONSUMER ALSO STATED SHE RETURNED TO THE DEALER SEVERAL TIMES, TO FIX THE FUEL GAUGE PROBLEM. THE CHECK ENGINE LIGHT ILLUMINATED, WHICH TURNED OUT TO BE A FAULTY 02 SENSOR. UPDATED 10/02/12

Mileage: 115,000

THE TRANSMISSION IS FAULTY, AND COSTS MORE TO REPAIR THAN THE PRICE OF THE ENTIRE VEHICLE. *TR

Mileage: 142,000

TIMING BELT BROKE AND CAUSED VEHICLE TO STALL WHILE DRIVING DOWN THE ROAD AT 45MPH, THIS IN TURN CAUSED MAJOR VALVE DAMAGE TO VEHICLE. POOR ENGINEER DESIGN/FLAWED. STILL PAYING PAYMENTS AND NOW OWE LARGE REPAIR BILL. IT WAS 1,500 MI OUT OF EXTENDED WARRANTY I PURCHASED AT THE DEALER. I HAVE ONLY OWNED THE VEHICLE BARELY 2 YEARS AND IT HAS BEEN IN FOR MANY MISC. REPAIRS INCLUDING BOTH BRAKE CYLINDERS. *TT

Mileage: 73,000

WHEN THE CAR IS IDLING, THE AC STOPS ALTOGETHER. WHEN THE CAR IS IN MOTION, IT SOMETIMES WORKS AND SOMETIMES DOES NOT. WHEN IT DOES WORK, IT DOES RUN AT FULL CAPACITY AND WILL SOMETIMES EVEN BLOW HOT AIR EVEN THOUGH THE AC IS TURNED ON. IT IS HIT OR MISS WHEN TURNING THE VENT SETTINGS AS IT DOESN'T ALWAYS REDIRECT THE AIR FLOW. ALSO, IT IS HIT OR MISS FOR THE AC TO TURN OFF WHEN SWITCHED TO THE OFF POSITION (HOT OR COLD AIR MAY CONTINUE TO BLOW). *TR

Mileage: 105,000

I WOULD LIKE TO FILE A COMPLAINT ON MY 2004 SATURN VUE. I HAVE DONE A LOT OF LOOKING AROUND ON THE INTERNET AND FOUND THAT THERE HAS BEEN A LOT OF TIMING CHAIN FAILURES ON THE SATURNS. I RECENTLY HAD MINE GO OUT ON MY VUE AT 90,000 MILES AND AM IN THE PROCESS OF GETTING IT FIXED WHICH COULD COST ME UPWARDS OF $2,000. IS THERE ANY FORM OF A RECALL O THIS AND WHAT ARE IF ANY ARE MY OPTIONS FOR EITHER SATURN FIXING IT OR REIMBURSING ME ANY AMOUNT. COULD YOU PLEASE CONTACT ME WITH ANY INFORMATION YOU HAVE . THANKS IN ADVANCE FOR YOUR HELP. *TR

Mileage: 90,000

REPEATED FAILURE OF IGNITION CONTROL MODULE/COIL PACK ON 2004 VUE 2.2 ECOTEC MOTOR CAUSED DAMAGE TO CATALYTIC CONVERTER AND O2 SENSOR JANUARY 6, 2009 THEN AGAIN MARCH 31, 2009. *TR

Mileage: 107,000

CAR HAD A STRANGE TICKING NOISE ,DROPPED THE CAR OFF AT SATURN DEALER SHIP AND WAS TOLD THAT I NEEDED TO REPLACE A TIMING CHAIN,FOR A FEE OF 1,000 DOLLARS ,I SEARCHED NHTSA AND FOUND A RECALL EXACTLY LIKE THIS ONE BUT FOR A 2001 ONLY. MY CAR IS A 2004 AND ONLY HAS 34,000 MILES. *TR

Mileage: 34,000

SATURN VUE AWD 2004 PISTON ROD BECAME BENT , ACCORDING TO A MECHANIC THAT LOOKED AT THE CAR, ALTHOUGH THERE WAS PLENTY OF OIL IN THE CAM CASE, THE ENGINE WIL NOT RUN AND NEEDS TO BE REPLACED. I WOULD LIKE TO KNOW IF THERE WERE ANY RECALLS ON THIS MODEL VEHICLE CONCERNING THE ENGINE. *TR

Mileage: 76,050

I HAVE UNFORTUNATELY OWNED MY SATURN 2004 VUE FOR 2 YEARS. THE FIRST 3 MONTHS OF HAVING IT, AFTER HAVING TO REPLACE MY 2003 VUE FOR ALL THE PROBLEMS IT HAD WAS IN THE SHOP THE FIRST 4 MONTHS OF PURCHASE. THE POWER ENGINE FAILURE LIGHT WOULD GO ON AND I WOULD LOSE ALL POWER TO THE CAR. THEY HAD NO IDEA HOW TO FIX IT. THEN THE BACK WINDSHIELD SHATTERED. THE GAS MILEAGE IS HORRIBLE AND THE WHOLE GAS TANK AND ODOMETER HAS HAD TO BE REPLACED. I WOULD FEEL THE CAR UP WITH GAS AND THE ODOMETER WOULD GO TO FULL AND MOVE BACK UP TO HALF FULL. THE CAR IS IN THE SHOP AGAIN FOR THROTTLE AND ENGINE PROBLEMS AGAIN. HAVE HAD THE REAL DISPLEASURE OF WORKING WITH A VERY RUDE LADY AT SATURN BY THE NAME OF MARCIA WHO CLEARLY DOES NOT CARE ABOUT ONES SAFETY IN THEIR VEHICLE. ACCORDING TO SATURN THE NEWER VEHICLES HAVE HAD THESE PROBLEMS FIXED. HOWEVER, I MUST SAY HAVING BEEN A SATURN OWNER FOR 12 YEARS NOW MY FAITH IN THEIR PRODUCT IS GONE. *JB

CHIME SOUNDS WHEN STARTING VEHICLE AND PLACING INTO REVERSE OR DRIVE. CAR SOMETIMES STALLS WHEN CHIME IS SOUNDING. ACCORDING TO MANUFACTURER, THE CHIME INDICATES A PROBLEM WITH THE ENGINE. ACCORDING TO MANUFACTURER, SATURN, IT IS COVERED BY TSB 1700388. THIS HAS BEEN GOING ON SINCE AUGUST OF 2005. INCREASE IN FREQUENCY AND SEVERITY. DEALER UNABLE TO FIX PROBLEM EVEN WHEN FOLLOWING TSB. *NM

Mileage: 12,786

NEW 2004 SATURN VUE(2WD) WITH 3.5 LITER V6, PURCHASED IN JULY 2004 1ST SYMPTOM: POOR FUEL EFFICIENCY 16MPG CITY INSTEAD OF 20MPG; WORSE DURING RAIN 22-24MPG HWY INSTEAD OF 28MPG; 19MPG OVERALL AVERAGE -DEALER RESPONSE NORMAL FOR FIRST 5K MILES, I'M NOW OVER 8K 2ND SYMPTOM: ENGINE BACKFIRES AFTER COLD START; WORSE DURING RAIN -DEALER RESPONSE NO TROUBLE FOUND, CHANGED OIL 3RD SYMPTOM: SLOW TO START WHEN PARKED ON SLIGHT UPWARD INCLINE -HAVEN'T NOTIFIED DEALER YET 4TH SYMPTOM: LOW COOLANT LIGHT CAME ON BUT COOLANT LEVEL WAS OK -WILL BE TAKING IT IN TO DEALER I'M CONCERNED ABOUT TAKING IT IN FOR SERVICE AFTER READING SIMILAR REPORTS ON THIS VEHICLE AND NUMEROUS TALES OF POOR RESOLUTION. PLEASE NOTIFY OR POST ABOUT ANY NEW BULLETINS OR RESOLUTIONS THAT MAY BE HELPFUL.*AK

Mileage: 216

ENGINE STALLED AT VARIOUS SPEEDS, WHICH WAS DANGEROUS WHILE ON THE ROAD. TOOK VEHICLE TO DEALER FOR A CHECK UP, BUT THE CAUSE WAS UNDETERMINED.*AK VEHICLE ACCELERATED TOO FAST WHEN PRESSING GAS PEDAL TO START AUTO AFTER STALLING. *BF *NM

NEW VEHICLE WITH LESS THAN 2,500 MILES-2004 VUE. THEY WANT TO "FIX" REPLACE/REPAIR ENGINE FAILURE. WE KNOW THAT OTHER SYSTEMS CAN/WILL BE AFFECTED BY TOTAL BREAKDOWN ON INTERSTATE-IMMEDIATE ENGINE BLOW-NO POWER ETC. WE ARE NOT SATISFIED WITH THE "OFFER" OF REPAIR AND MINIMUM "WARRANTY" COVERAGE AS "ADDITIONALLY COURTESY OFFER". *JB

Mileage: 2,400

I PURCHASED A 2004 SATURN VIEW, NEW, AUGUST 21, 2004. ON SEPTEMBER 18, 2004 I DROVE THROUGH WATER ON THE ROAD, ANKLE DEEP. THE ENGINE STOPPED, AND IT HAD TO BE TOWED. THE CAR HAD 2,000 MILES ON IT. THE MECHANIC WHO WAS SENT BY SATURN'S 800 ROADSIDE ASSISTANCE NUMBER LOOKED AT THE CAR AND SAID I PROBABLY BURNED OUT THE ALTERNATOR BECAUSE IT'S ON THE BOTTOM. HE SAID THE PROBLEM WAS TO BE RECTIFIED ON THE 2005 MODEL. WHEN I CALLED THE SERVICE DEPARTMENT ON 9/20 THE SERVICE PERSON (EITHER JACOB OR BRIAN) I SPOKE TO SAID THAT THE AIR INTAKE, NEAR THE BOTTOM HAD SUCKED ROAD WATER INTO THE ENGINE AND DAMAGED THE ENGINE. IT WAS PROBABLY BECAUSE WHEN I DROVE THROUGH THE WATER IT CREATED A WAVE AND THE WAVE WATER WAS SUCKED INTO THE AIR INTAKE. THEY WOULDN'T KNOW WHAT WAS WRONG UNTIL THE ENGINE WAS TAKEN APART. HE ALSO SAID IT WOULD NOT BE COVERED BY THE WARRANTY BECAUSE IT IS NOT A MANUFACTURERS DEFECT (ALTHOUGH I WOULD BEG TO DIFFER SINCE WHAT MANUFACTURER PUTS AN AIR INTAKE WHERE ROAD WATER CAN BE SUCKED INTO THE ENGINE) AND HE ALSO SAID THE L300 MODEL ALSO HAVE THEIR AIR INTAKE AT THE BOTTOM OF THE ENGINE. I CONTACTED SATURN IN TENNESSEE (CLAIM 1-13554677) AND AN AREA SERVICE MANAGER NAMED MARCIA TOLD ME THAT AFTER THEY REVIEWED MY SITUATION THEY WERE NOT WILLING TO DO ANYTHING FOR ME. WHAT I HAVE IS AN SUV WITH AN AIR INTAKE THAT IS IN A POSITION WHERE EVERY TIME THERE'S WATER, I RISK DAMAGING MY ENGINE , AND THE LAST 3 YEARS WE'VE AVERAGED 103 INCHES OF SNOW EACH WINTER). I DID ASK SATURN TO GET ME OUT OF THIS VEHICLE AS IT IS NOT FIT FOR PERFORMANCE AS WARRANTED FOR AN SUV, BUT THEY SAID NO. THIS VEHICLE, BY EXPLANATION FROM THE MECHANIC AND SERVICE PERSON, WAS DEFECTIVELY DESIGNED WHICH CAUSED THE AIR INTAKE TO SUCK WATER INTO THE ENGINE DAMAGING IT. I WOULD APPRECIATE YOUR LOOKING INTO THIS AND HOPEFULLY BEING ABLE TO OFFER ME A SOLUTION TO MY HAVING TO RETAIN A DEFECTIVELY DESIGNED, UNRELIABLE VEHICLE. *AK

Mileage: 2,040