2015 SHASTA AIRFLYTE Problems & Recalls

The entire front panel of my Shasta Airflyte travel trailer is separating from the pine bracing where the dinette is, creating a 2” gap at the floor where rodents and water could get in. It appears the screws meant to attach the panel to the bracing are sheared off or improperly installed. The sep...

The Shasta Airflyte trailer is clad in aluminum metal sheathing called a skin. The metal skins on the doors are held by a rubber spline molding but no screws or fasteners. The trailer door needs a decent amount of force to open/close which creates some flex so the metal skin gets loose and had poppe...

SEAMS ON THE EXTERIOR HAVE LEAKED ALLOWING WATER TO GET IN FROM DAY ONE. ELECTRICAL IN WALLS IS A POTENTIAL DANGER. SHASTA CLAIMS NO RESPONSIBILITY AND WILL NOT REPAIR ANY WATER DAMAGE.

SEAMS ON THE EXTERIOR HAVE LEAKED ALLOWING WATER TO GET IN FROM DAY ONE. ELECTRICAL IN WALLS IS A POTENTIAL DANGER. SHASTA CLAIMS NO RESPONSIBILITY AND WILL NOT REPAIR ANY WATER DAMAGE.

SEAMS ON THE EXTERIOR HAVE LEAKED ALLOWING WATER TO GET IN FROM DAY ONE. ELECTRICAL IN WALLS IS A POTENTIAL DANGER. SHASTA CLAIMS NO RESPONSIBILITY AND WILL NOT REPAIR ANY WATER DAMAGE.

2015 SHASTA AIRFLYTE. CONSUMER WRITE SIN REGARDS TO FAULTY DESIGN AND FRAME WELDING. *LD *TR *DT UPDATED 10/5/18*JB

CONCERNED THAT THE CHASSIS, FLOOR AND FRONT WALL MAY HAVE BEEN INCONSISTENTLY FASTENED TOGETHER. TSB: 53-0597 IN PLACE WITH 2 "KITS" RECOMMENDED. WITH RECOMMEND FIX I AM WORRIED ABOUT ALL THE WEIGHT AND TORQUE THAT WOULD BE APPLIED TO A BOLT ON FIX. SHASTA/FOREST RIVER SAID THAT A FLEXING FRAME IS O...

CONCERNED THAT THE CHASSIS, FLOOR AND FRONT WALL MAY HAVE BEEN INCONSISTENTLY FASTENED TOGETHER. TSB: 53-0597 IN PLACE WITH 2 "KITS" RECOMMENDED. WITH RECOMMEND FIX I AM WORRIED ABOUT ALL THE WEIGHT AND TORQUE THAT WOULD BE APPLIED TO A BOLT ON FIX. SHASTA/FOREST RIVER SAID THAT A FLEXING FRAME IS O...

TL* THE CONTACT OWNS A 2015 SHASTA AIRFLYTE. THE CONTACT STATED THAT PIECES OF THE FRAME (WHERE IT WAS WELDED) HAD DETACHED FROM THE VEHICLE. THE TORQUE/FRAME WAS NOT TAKEN TO THE DEALER. THE SHASTA/RIVERFOREST MANUFACTURER IS WORKING WITH THE FRAME MANUFACTURE TO PROVIDE A FIX FOR THE BODY/FRAME; H...

Mileage: 300

THERE IS UNSAFE ASSEMBLY OF THE SHASTA AIRFLYTE 2015 SUPPORT FRAME AS THE WELDS ARE IN ADEQUATE AND SOMETIMES ONLY WELDING TACKS HOLDING THE FRONT BRACE. THERE IS QUESTION WHETHER THE FRAME IS EVEN ATTACHED TO THE CHASSIS CORRECTLY. THE ROOT CAUSE OF THE ISSUE MIGHT BE THAT THE FRONT LATERAL STR...

Mileage: 1,200

RE: 2015 SHASTA RE-ISSUE. MY TRAILER, ALONG WITH SEVERAL HUNDRED OTHER TRAILERS, HAS A FRAME THAT IS NOT WELDED TOGETHER. THERE ARE PLACES WHERE THE GAP BETWEEN THE HORIZONTAL AND VERTICAL BEAMS IS OVER TWO INCHES - NO ATTEMPT WAS MADE TO CONNECT THE BEAMS. IN A FEW PLACES, THE WELDS APPEAR TO BE MA...

THE FRAME AND WELDING ON MY TRAILER IS FAULTY. THE TONGUE AND FRAME ASSEMBLY HAS SEPARATED, CAUSING THE BODY TO FAIL. IT CAUSED THE FRONT BODY/WALL TO SEPARATE FROM THE BENCH SEATS BY OVER AN INCH WITH EXPOSED SCREWS AND STAPLES. THE SKIN ON THE OUTSIDE IS BUCKLING ON THE FRONT, RUBBING ON THE PR...

Mileage: 3,000

THE FRAME AND WELDING ON MY TRAILER IS FAULTY. THE TONGUE AND FRAME ASSEMBLY HAS SEPARATED, CAUSING THE BODY TO FAIL. IT CAUSED THE FRONT BODY/WALL TO SEPARATE FROM THE BENCH SEATS BY OVER AN INCH WITH EXPOSED SCREWS AND STAPLES. THE SKIN ON THE OUTSIDE IS BUCKLING ON THE FRONT, RUBBING ON THE PR...

Mileage: 3,000

FAULTY OR LACK OF WELDS ON FRAME. INSIDE DINETTE WALL SEPARATING FROM SEAT. I WILL ATTACH PICTURES. WELDS ARE SLOPPY AND NOT ON SEAM ON ONE SIDE AND NO WELD ON THE OTHER. I'M AFRAID TO PULL IT ANYWHERE NOW DUE TO SAFETY CONCERNS.

THE TONGUE OF OF THE TRAILER IS NOT WELDED PROPERLY TO THE FRAME. THE MANUFACTURER COMPROMISED THE INTEGRITY OF THE FRAME BY NOTCHING THE FRONT CROSS MEMBER WITHOUT ADDING SUPPORT OR WELDING THE TONGUE IN PLACE WHICH HAS WEAKENED THE ENTIRE STRUCTURE CAUSING INTERNAL DAMAGE AND PLACING THE OWNER AT ...

THE TONGUE IS NOT PROPERLY WELDED TO THE FRAME CAUSING THE INSIDE BENCH AREA TO COME LOOSE FROM THE FRONT OF THE CAMPER.THERE ARE NOTCHES IN THE FRAME WHERE IT SHOULD HAVE BEEN WELDED TO THE FRAME. IF THIS COMES APART ON THE ROAD IT WILL DETACH FROM THE TONGUE AND WILL CAUSE A SERIOUS ACCIDENT. THI...

MY COMPLAINT HAS TO DO WITH THE REAR WINDOW OF MY SHASTA. WHEN I FIRST PURCHASED IT AND GOT IT HOME I NOTICED THERE WAS A LEAK. SINCE THEN THERE HAS BEEN A RECALL ON THE REAR WINDOWS. MY WINDOW WAS REPLACED AND NOW IT IS LEAKING AGAIN. IT IS COMING FROM THE FRAME WHERE IT ATTACHES TO THE TRAILER BEC...

OUR SHASTA AIRFLYTE HAS A CHRONIC WATER LEAK AND HAS SINCE WE TOOK POSSESSION OF IT IN DECEMBER OF 2014. THE SOURCE OF THE LEAK IS UNKNOWN, BUT THE WATER EXITS FROM INSIDE THE REAR EGRESS WINDOW FRAME. WE HAVE TO TAKE CARE IN INCLEMENT WEATHER TO MAKE SURE THE INSIDE OF THE TRAILER ISN'T DAMAGED BY ...

Mileage: 5,000

THE WINDOWS LEAK. THEY HAVE BEEN RESEALED TWICE BUT STEAL LEAK. I WAS TOLD BY THE DEALER DOING WARRANTY WORK THAT THEY CANNOT FIGURE OUT WHY. THEY HAVE NOT BEEN ABLE TO GET ANY HELP,FROM SHASTA. THEY HAVE ORDERED NEW WINDOWS BUT THEY ARE HAVING TROUBLE GETTING ANYONE TO EVEN FOLLOW UP ON THAT. THIS...

THE ROOF THAT WAS ADVERTISED AS A ONE PIECE BUT TURNED OUT TO BE A THREE PIECE HAS LEAKED IN TWO PLACES. THE DEALER THAT IS DOING WARRANT WORK SEALED UP THE SEAMS BUT NOT BEFORE THE WATER GOT IN THE WALL AND NOW CAUSED A MOLD SMELL IN THE TRAILER. I CANNOT CAMP IN THIS TRAILER WITH MOLD AS IT MAKES ...

WATER LEAKING FROM BEHIND SHOWER, WATER DAMAGE AND POSSIBLE BLACK MOLD ISSUE ON REAR WALL OF THE CAMPER FROM UNKOWN SOURCE. WE WERE TOLD THERE WOULD BE A GUARANTEE OF NO LEAKS FOR 50 YEARS! I WENT TO MAKE MY SON'S BED UP FOR THE NIGHT AND FOUND THE WATER DAMAGE AND BLACK MOLD. TRIED USING THE SHO...

WATER LEAKING FROM BEHIND SHOWER, WATER DAMAGE AND POSSIBLE BLACK MOLD ISSUE ON REAR WALL OF THE CAMPER FROM UNKOWN SOURCE. WE WERE TOLD THERE WOULD BE A GUARANTEE OF NO LEAKS FOR 50 YEARS! I WENT TO MAKE MY SON'S BED UP FOR THE NIGHT AND FOUND THE WATER DAMAGE AND BLACK MOLD. TRIED USING THE SHO...

THERE HAVE BEEN SEVERAL RECALLS ON OUR TRAILER ALREADY, AND WE HAVE WORKED WITH A LOCAL DEALER TO GET IT REPAIRED AS NECESSARY. INCLUDED IN THOSE REPAIRS WAS THE FRONT WALL OF OUR TRAILER SEPARATING FROM THE FRAME. I'M SURE YOU'LL AGREE THAT WOULD BE A VERY SERIOUS ISSUE HAD WE NOT CAUGHT IT QUICKL...

THERE WAS A PROBLEM WITH THE BACK JAULOSIE WINDOW FALLING OFF. SO I TOOK IT TO MY DEALER AND THEY REPLACED IT AND SUPPOSEDLY CHECKED THE OTHER WINDOWS. I JUST TOOK IT ON MY FIRST CAMPING TRIP AND ON THE WAY HOME THE FRONT JAULOSIE WINDOW FELL DOWN. NOT ON THE ROAD THANK GOODNESS, BUT IT WAS HANGI...

WE WERE AT THE MERCY OF A DEFECT AXEL ON OUR SHASTA CAMPER UNTIL THE RECALL TOOK PLACE. THANK YOU NHTSA FOR TAKING A LEADERSHIP ROLE IN THE SAFETY! WE TOOK OUR CAMPER TO OUR DEALER IN OCTOBER 2015 FOR REPAIR AS THE AXEL WAS CREATING ISSUES WITH ROAD HANDLING. IT TOOK ABOUT 6 MONTHS FOR THEM TO ...

WE BOUGHT THIS TRAVEL TRAILER BRAND NEW AND THE TIRES/AXLE RUBS THE INTER FENDER WELLS MAKING IT UN SAFE TO TOW

WE BOUGHT THIS TRAVEL TRAILER BRAND NEW AND THE TIRES/AXLE RUBS THE INTER FENDER WELLS MAKING IT UN SAFE TO TOW

REAR, EMERGENCY WINDOW FELL OUT. RECALL WAS ISSUED AND CAMPER WAS RETURNED FOR REPAIRS. CAMPING WORLD REPAIRED WINDOW IN ACCORDANCE WITH RECALL. TOOK CAMPER ON A ONE-NIGHT TRIP. STORED CAMPER AND FOUND REAR EMERGENCY WINDOW ON THE GROUND TWO DAYS LATER. CAMPER WAS STATIONARY. THIS IS AN ONGOING SAFE...

REAR, EMERGENCY WINDOW FELL OUT. RECALL WAS ISSUED AND CAMPER WAS RETURNED FOR REPAIRS. CAMPING WORLD REPAIRED WINDOW IN ACCORDANCE WITH RECALL. TOOK CAMPER ON A ONE-NIGHT TRIP. STORED CAMPER AND FOUND REAR EMERGENCY WINDOW ON THE GROUND TWO DAYS LATER. CAMPER WAS STATIONARY. THIS IS AN ONGOING SAFE...

TL* THE CONTACT OWNS A 2015 SHASTA AIRFLYTE. THE CONTACT STATED THAT THE AIR CONDITIONER OVERHEATED AND CAUSED THE FAILURE IN THE UNIT. THE CONTACT STATED THAT THE CABINET WHERE THE AIR CONDITIONING UNIT WAS LOCATED WAS HOT TO THE TOUCH AFTER THE FAILURE. THE RV WAS TAKEN TO THE DEALER WHERE A SAFET...

TL* THE CONTACT OWNS A 2015 SHASTA AIRFLYTE. THE CONTACT STATED THAT THE AIR CONDITIONER OVERHEATED AND CAUSED THE FAILURE IN THE UNIT. THE CONTACT STATED THAT THE CABINET WHERE THE AIR CONDITIONING UNIT WAS LOCATED WAS HOT TO THE TOUCH AFTER THE FAILURE. THE RV WAS TAKEN TO THE DEALER WHERE A SAFET...

TL* THE CONTACT OWNS A 2015 SHASTA AIRFLYTE. THE CONTACT STATED THAT THE AIR CONDITIONER OVERHEATED AND CAUSED THE FAILURE IN THE UNIT. THE CONTACT STATED THAT THE CABINET WHERE THE AIR CONDITIONING UNIT WAS LOCATED WAS HOT TO THE TOUCH AFTER THE FAILURE. THE RV WAS TAKEN TO THE DEALER WHERE A SAFET...

I HAVE HAD THE SHACKLE "FIX" ON MY CAMPER, BUT STILL DO NOT HAVE BUT ABOUT 1 3/4" AT THE TOP OF THE TIRE AND 3/4" ON THE INSIDE WALL. I WENT TO A CAMPING PARK AND THE TIRE RUBBED THE TOP OF THE WHEEL WELL, AND THE INSIDE WALL. THERE ARE ALSO RUB MARKS ON THE INSIDE WALL OF THE TIRE. THERE IS 3 3/...

Mileage: 500

NONE OF THE WEIGHT RATINGS ON THE REISSUE SHASTA AIRFLYTE'S ARE CORRECT. THE AXEL HAS A LABEL ON IT PLACED THERE BY THE MANUFACTURER THAT SAYS GAWR 3500 LBS. THE SAME AXEL IS ON THE 16' AND THE 19'. SO NO RATING CAN EXCEED 3500 LBS. YET MINE SAYS GVWR IS 3635.

Mileage: 500

WINDOW GLASS FELL OUT AND WAS JUST BEING HELD BY THE CRANK ATTACHMENT.

Mileage: 300

AFTER ARRIVING HOME FROM PICKING UP THE TRAILER I HAD NOTICED THE INNER DRIVER SIDEWALL OF THE TIRE HAVING RUB MARKS. AFTER CLOSER INSPECTION, THE TIRE SIDEWALL CLEARANCE TO THE DRIVER SIDE WHEEL WELL HAS ONLY 1/4" TO 5/16" OF CLEARANCE. THE TIRE CLEARANCE ON TOP IS ALSO ONLY 1" CAUSING RUB MARKS ON...

Mileage: 700

AFTER ARRIVING HOME FROM PICKING UP THE TRAILER I HAD NOTICED THE INNER DRIVER SIDEWALL OF THE TIRE HAVING RUB MARKS. AFTER CLOSER INSPECTION, THE TIRE SIDEWALL CLEARANCE TO THE DRIVER SIDE WHEEL WELL HAS ONLY 1/4" TO 5/16" OF CLEARANCE. THE TIRE CLEARANCE ON TOP IS ALSO ONLY 1" CAUSING RUB MARKS ON...

Mileage: 700

AFTER ARRIVING HOME FROM PICKING UP THE TRAILER I HAD NOTICED THE INNER DRIVER SIDEWALL OF THE TIRE HAVING RUB MARKS. AFTER CLOSER INSPECTION, THE TIRE SIDEWALL CLEARANCE TO THE DRIVER SIDE WHEEL WELL HAS ONLY 1/4" TO 5/16" OF CLEARANCE. THE TIRE CLEARANCE ON TOP IS ALSO ONLY 1" CAUSING RUB MARKS ON...

Mileage: 700

THE TIRES ON THIS TRAILER ARE P225/75R15 WITH A WEIGHT RATING OF 1874 @35 PSI. AFTER DERATING THESE TIRES BY DIVIDING 1.10, THE SINGLE ADJUSTED RATING IS NOW 1704 FOR A COMBINED RATING OF 3408. THE AXLE TAG CLEARLY DISPLAYS 3500 LB. THESE TIRES FROM THE FACTORY DO NOT MEET OR EXCEED THE AXLE RATING....

Mileage: 710

THE TIRES ON THIS TRAILER ARE P225/75R15 WITH A WEIGHT RATING OF 1874 @35 PSI. AFTER DERATING THESE TIRES BY DIVIDING 1.10, THE SINGLE ADJUSTED RATING IS NOW 1704 FOR A COMBINED RATING OF 3408. THE AXLE TAG CLEARLY DISPLAYS 3500 LB. THESE TIRES FROM THE FACTORY DO NOT MEET OR EXCEED THE AXLE RATING....

Mileage: 710

THE TIRES ON THIS TRAILER ARE P225/75R15 WITH A WEIGHT RATING OF 1874 @35 PSI. AFTER DERATING THESE TIRES BY DIVIDING 1.10, THE SINGLE ADJUSTED RATING IS NOW 1704 FOR A COMBINED RATING OF 3408. THE AXLE TAG CLEARLY DISPLAYS 3500 LB. THESE TIRES FROM THE FACTORY DO NOT MEET OR EXCEED THE AXLE RATING....

Mileage: 710

TRAILER HAS 225-75/15 COKER CLASSIC TIRES WHICH ARE UNDERATED FOR THE 19' MODEL/WT. ALSO, TIRES ARE NOT TRAILER RATED. SEEMS THE SHASTA (FOREST RIVER CO.) USED PASSENGER TIRES THAT ARE OVER WIDTH CAUSING RUBBING ON TIRE SIDE WALLS AGAINST THE WHEEL WELL. STILL CURRENTLY WAITING TO HEAR BACK FROM SHA...

TRAILER HAS 225-75/15 COKER CLASSIC TIRES WHICH ARE UNDERATED FOR THE 19' MODEL/WT. ALSO, TIRES ARE NOT TRAILER RATED. SEEMS THE SHASTA (FOREST RIVER CO.) USED PASSENGER TIRES THAT ARE OVER WIDTH CAUSING RUBBING ON TIRE SIDE WALLS AGAINST THE WHEEL WELL. STILL CURRENTLY WAITING TO HEAR BACK FROM SHA...

TRAILER HAS 225-75/15 COKER CLASSIC TIRES WHICH ARE UNDERATED FOR THE 19' MODEL/WT. ALSO, TIRES ARE NOT TRAILER RATED. SEEMS THE SHASTA (FOREST RIVER CO.) USED PASSENGER TIRES THAT ARE OVER WIDTH CAUSING RUBBING ON TIRE SIDE WALLS AGAINST THE WHEEL WELL. STILL CURRENTLY WAITING TO HEAR BACK FROM SHA...

I'M CONCERNED ABOUT THE SAFETY OF SEVERAL FEATURES OF MY BRAND NEW 2015 SHASTA AIRFLYTE TRAVEL TRAILER (BY FOREST RIVER). BASED ON INITIAL INSPECTION OF INTERIOR FIXTURES ALONE, IT'S APPARENT THERE WAS NOT A LOT OF FORESIGHT WHEN DESIGNING THESE, AND QUALITY CONTROL WAS SERIOUSLY LACKING. CORNERS W...

Mileage: 85

I'M CONCERNED ABOUT THE SAFETY OF SEVERAL FEATURES OF MY BRAND NEW 2015 SHASTA AIRFLYTE TRAVEL TRAILER (BY FOREST RIVER). BASED ON INITIAL INSPECTION OF INTERIOR FIXTURES ALONE, IT'S APPARENT THERE WAS NOT A LOT OF FORESIGHT WHEN DESIGNING THESE, AND QUALITY CONTROL WAS SERIOUSLY LACKING. CORNERS W...

Mileage: 85

I'M CONCERNED ABOUT THE SAFETY OF SEVERAL FEATURES OF MY BRAND NEW 2015 SHASTA AIRFLYTE TRAVEL TRAILER (BY FOREST RIVER). BASED ON INITIAL INSPECTION OF INTERIOR FIXTURES ALONE, IT'S APPARENT THERE WAS NOT A LOT OF FORESIGHT WHEN DESIGNING THESE, AND QUALITY CONTROL WAS SERIOUSLY LACKING. CORNERS W...

Mileage: 85