2016 SUBARU OUTBACK Power Train Problems

The contact owns a 2016 Subaru Outback. The contact stated that the passenger’s side wheel window trim was slightly pivoted. The vehicle was taken to the dealer who determined that the trim needed to be replaced. The vehicle was not repaired because the dealer had not confirmed if parts had been ordered or received. The contact stated that while driving approximately 60 MPH in 2020, the vehicle experienced transmission failure and the vehicle came to a jerking stop, as if the parking brake had been activated. The vehicle was towed to the dealer and the contact was informed that the CVT transmission had failed and needed to be replaced. The contact stated that approximately 4 years later, several warning lights illuminated. The vehicle was taken to the dealer but no cause for the failure was found. The contact stated that after leaving the dealer, the failure reoccurred. The vehicle was returned to the dealer and was diagnosed with CVT failure. The CVT transmission was replaced. The contact was informed that the wiring harness needed to be replaced; however, the wiring harness had not been replaced. The manufacturer was informed of the failure and opened a case. The failure mileage was 35,000.

Mileage: 35,000

I’m unable to remove the car key from the ignition when the vehicle shifter is in Park.

The "SELECT LEVER COMPLETE" or fear shift neutral park sensor switch stops working. Subaru has acknowledged the issue and issued a TSB (NUMBER: 16-112-18R). The issue is that the car does not sense it is in park or Neutral, even though the shifter is in that position. For keyed cars, the key cannot be removed and for push to start the car rear gate does not open and an alarm sounds when doors are open when the ignition is on. The car warns to move shifter to Park, even though the car is shifted to park. Car has been serviced several times with complaints indicating symptoms of issue, but was never informed of cause and lever select was never replaced.

Transmission went out at 72,000 miles. Was told it was not covered by warranty even though I purchased extended warranty. Will never buy another Subaru again. Spoke to a person at customer service who said she would take care of it. Made 19 calls over 3 months and no one returned a call. Terrible customer service at the main office.

The contact owns a 2016 Subaru Outback. The contact stated that the vehicle was taken to an independent mechanic to be serviced; however, while the mechanic was inspecting the vehicle, he noticed oil splatter inside the engine compartment. The vehicle was diagnosed with an oil leak. The contact stated that while driving at an undisclosed speed, the oil warning light illuminated. The contact related the failure to NHTSA Campaign Number: 15V502000 (Power Train). The manufacturer was not made aware of the failure. The failure mileage was 74,315.

Mileage: 74,315

Subaru dealer diagnosed oil leaks on the valve cover gaskets. I took the car to an independent repair business and the problem was diagnosed as a camshaft carrier oil leak. Upon removing the necessary parts, the company reported to me they found chunks of silicone around the carrier. I first noticed a smell of something burning after Subaru had done an oil change about 2 months prior. I was also getting the Check Oil lamp about 2 months after the oil change. It was losing oil. That’s when I had Subaru diagnose the problem. The loss of oil could have started a fire. Parts are available for inspection.

The transmission, without warning, stopped functioning.

oil leak from power train

Battery corrosion on terminal post and drained for no reason, failed battery test and had to be replaced. Windshield has imperfections throughout and cracks easily. Shift mechanism will not release the vehicle key while in park. Squeaking sound emanating from passenger seat belt buckle. Excessive exhaust noise and odor from exhaust pipe. Rear hatch will not close completely unless slammed very forcefully. Belts under the hood squeak very loudly when started and subside when warmed up.

The contact owns a 2016 Subaru Outback. The contact stated while driving 65 MPH, the vehicle inadvertently started shuddering and jerking. The contact also stated that the vehicle was making abnormal sounds. There were no warning lights illuminated. The contact stated that she was able to continue to drive the vehicle. The vehicle was taken to an independent mechanic who diagnosed that the transmission had failed. Then, the vehicle was taken to the dealer who tests drove the vehicle and diagnosed that the transmission needed to be replaced. The manufacturer was notified of the failure and informed the contact that they would replace the transmission, but she would be responsible for the cost of the labor. The vehicle was repaired. The approximate failure mileage was 107,000.

Mileage: 107,000

Unable to turn key to off position when in neutral and unable to remove key from the ignition. In order to get the key out of the ignition, the car needs to be restarted and turned back off or the gear shift needs to be pushed as hard as possible into the neutral position multiple times. With the inability to turn the car totally off and remove the key, there are multiple safety issues that can arise. Was informed that the entire select lever assembly needs to be replaced due to a known issue by Subaru. The issue was reproduced by an independent service center. No warning lamps are illuminated.

Parking shifter sensor is failing intermittently. This prevents removing the key from the ignition. Seems to react better when you throw the shifter into park forcefully.

COMPLETE DRAINING OF BATTERY JUST SITTING THERE FOR NO REASON... WE SEE THIS IS AN ENORMOUS PROBLEM WITH OUTBACKS, AND WE HAVE ONE WITH GREAT PROBLEMS LEAVING US STRANDED !

Mileage: 15,000

TL* THE CONTACT OWNS A 2016 SUBARU OUTBACK. THE CONTACT STATED THAT WHILE HIS WIFE HAD ATTEMPTED TO PARK THE VEHICLE, THE VEHICLE INDEPENDENTLY ACCELERATED WHILE AT A COMPLETE STOP. THE CONTACT STATED THAT THE VEHICLE JUMPED A CURB AND HIT A TREE; HOWEVER, HIS WIFE WAS UNSURE IF ANY WARNING LIGHTS HAD ILLUMINATED DURING THE FAILURE. THE AIR BAGS DID NOT DEPLOY UPON IMPACT AND THE CONTACT'S WIFE WAS NOT INJURED. THE POLICE WERE CALLED TO THE SCENE; HOWEVER, THE CONTACT WAS UNAWARE IF A POLICE REPORT WAS FILED. DUE TO THE FAILURE, THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS REPAIRED FOR THE DAMAGE. THE CONTACT STATED THAT PRIOR TO THE FAILURE, THE VEHICLE WAS PLACED UNDER RECALL NHTSA CAMPAIGN NUMBER: 15V794000 (POWER TRAIN) WHERE IT WAS SERVICED BY NORTH END SUBARU(757 CHASE RD, LUNENBURG, MA 01462). THE DEALER NOR THE MANUFACTURER HAD YET TO BE NOTIFIED OF THE FAILURE. THE VEHICLE HAD BEEN REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 44,343.

Mileage: 44,343

2.12 FEBRUARY 2021, VEHICLE MILAGE APPROACHING 42,000. TRAVELING FROM MAZAMA WA TO SEATTLE VIA WA HWY 20, US 97 AND I-90, TRAVELED +/- 200 MILES. TEMPERATURE RANGES FROM 10F TO 20F. TRAVELING WEST ON I-90 +/-50 MPH, LANES CLEAR, SNOW IN BETWEEN LANES. NEW MICHELIN TIRES ON ALL 4 WHEELS. HOLDING THE SPEED CONSTANT FOLLOWING 18-WHEEL RIG. SUBARU STARTED WOBBLING AS IF ONE OF THE TIRES WAS GOING FLAT. TRIED ACCELERATING AND SLOWING TO DETERMINE IF THIS WAS FRONT OR BACK TIRE. DETERMINED IT MUST BE A REAR TIRE. NO LOW-PRESSURE INDICATION ON THE INSTRUMENT GAGES (I HAVE HAD TIRE WARNING DURING SUMMER DRIVING AND FOUND A NAIL IN TIRE). NEXT OFF RAMP CHECKED ALL 4 TIRES, ALL APPEARED TO BE THE SAME IN APPEARANCE. RESUMED TRAVEL. DURING ACCELERATION AND DE-ACCELERATING NO DIFFERENTIAL SWAY. WHEN CONSTANT SPEED MAINTAINED AROUND 50 MPH SWAYING OCCURRED UN TO WE REACHED THE WEST SIDE OF SNOQUALMIE PASS AND THE TEMPERATURE WAS INTO THE 30'S. LAST YEAR WHEN HAVING VEHICLE SERVICED, I TOLD THE SERVICE CHECK-IN PERSON & A SUPERVISOR THE CAR WAS STALLING OUT WHEN HARD ACCELERATION DURING MERGING LEFT INTO HIGHWAY WHERE SPEED LIMIT WAS 50 MPH. THE CAR STALLED AND I KICKED THE ACCELERATOR. LUCKILY, THE CAR RESPONDED THE SUPERVISORS RESPONSE WAS 'THERE'S NO WAY THIS CAN HAPPEN'.

Mileage: 42,000

WHILE DRIVING ON THE HIGHWAY, THE TRANSMISSION IN MY 2016 SUBARU OUTBACK STARTED MAKING A LOUD GRINDING SOUND AND VIOLENTLY HALTED THE CAR TO A STOP. I WAS LUCKY ENOUGH THAT IT WASN'T DURING A BUSY TIME AND AN ACCIDENT WAS NARROWLY AVOIDED. THIS TRANSMISSION ONLY HAD 67,000 MILES ON IT AND IS ACTUALLY THE SECOND TRANSMISSION THAT CAR HAS HAD. IN 2018 THE TRANSMISSION HAD TO BE REPLACED AFTER 68,000 MILES. LUCKILY IT WAS FULLY COVERED UNDER AN EXTENDED WARRANTY I PURCHASED WHEN I BOUGHT IT. LATER THE TRANSMISSIONS WERE GIVEN A WARRANTY EXTENSION WHICH EXTENDED THE WARRANTY TO 100,000. THE NEWEST TRANSMISSION (THE ONE THAT JUST VIOLENTLY GRINDED TO A HALT ON THE HIGHWAY) CURRENTLY HAS 67,000 MILES ON THAT NEW TRANSMISSION, BUT SUBARU WILL NOT HONOR THE 100,000 WARRANTY EXTENSION BECAUSE THE REMAINDER OF THE VEHICLE HAS 135,000 MILES ON IT. I DO COUNT MYSELF LUCKY THAT THIS DIDN'T CAUSE AN ACCIDENT BECAUSE I HAD MY FAMILY IN THE VEHICLE WITH ME AND WE COULD'VE BEEN SERIOUSLY HURT.

Mileage: 135,000

WE HAVE HAD 2 MAJOR ISSUES WITH THIS CAR: 1- MULTIPLE EPISODES OF BATTERY FAILURE REQUIRING A JUMP START OVER THE LAST YEAR. THIS HAS HAPPENED WHEN THE CAR WAS NOT USED FOR A WEEK, BUT ALSO RANDOMLY AFTER A DRIVE. JUST HAPPENED 4 DAYS AGO AFTER A 30 MINUTE HIGHWAY DRIVE- WHEN WE CAME BACK OUT TO THE CAR AFTER 15 MINUTES, IT WOULDN'T START. WE JUMP STARTED IT, AND IT WAS FINE FOR A FEW DAYS, BUT NOW DEAD AGAIN IN MY DRIVEWAY. THE CAR OFTEN HAS A SHUDDERING AND OCCASIONAL STALL WHEN STARTING IT. MOST WORRISOME, I WAS RECENTLY DRIVING WITH MY DAUGHTER AND AFTER WE EXITED THE HIGHWAY, AND SLOWED DOWN FOR A TOLL, THE CAR LOST IT'S ACCELERATION, DESPITE RPMS REVVING. WE PULLED TO THE SIDE OF THE ROAD, TURNED THE CAR OFF AND RE-STARTED, AND IT RAN REGULARLY HOME, BUT THIS WAS FRIGHTENING.

Mileage: 30,000

FOR A FEW YEARS OFF AND ON WITH THE CAR STOPPED AND ATTEMPTING TO COMPLETE PARKING, THE KEY WOULD NOT TURN FROM THE ACC TO OFF POSITION OR RELEASE THE KEY FROM THE IGNITION. OF THE SEVERAL TIMES WE MENTIONED IT TO MULTIPLE DEALERSHIPS, WE WERE TOLD IT WAS OUR TECHNIQUE, NOT A PROBLEM WITH THE VEHICLE. FINALLY A DEALERSHIP REPORTED THE SHIFT ASSEMBLY WAS NOT RECOGNIZING THE CAR WAS IN PARK THUS WOULD NOT TURN THE KEY PAST THE ACCESSORY POSITION TO OFF OR RELEASE THE KEY. THIS OCCURRED WITH MULTIPLE KEYS AND DIFFERENT PEOPLE. THE SAFETY ISSUE IS THAT YOU CANNOT LOCK THE CAR WITH THE KEY IN THE IGNITION. ALSO, IF YOU CANNOT REMOVE THE KEY AND LEAVE THE CAR, YOU ARE HANDING THE CAR OVER TO WHOMEVER WANTS TO STEAL IT. ONLY WITH LOTS OF TIME, STARTING THE CAR, PUTTING IT INTO ANOTHER GEAR, THEN BACK TO PARK AND TURNING IT OFF AGAIN, WITH LUCK THE ASSEMBLY RECOGNIZES YOU ARE IN PARK AND ALLOWS THE KEY TURN TO OFF AND ALLOWS THE KEY TO BE REMOVED. THE DEALERSHIP WHO IDENTIFIED THE DEFECTIVE SHIFT ASSEMBLY STATED THE ONLY FIX IS TO REPLACE THE ENTIRE ASSEMBLY AT A COST OF $1100.00.

Mileage: 50,000

TL* THE CONTACT OWNS A 2016 SUBARU OUTBACK. THE CONTACT WAS UNABLE TO RESTART THE VEHICLE. AAA WAS CONTACTED AND THE VEHICLE WAS JUMP STARTED. THE CONTACT STATED THAT THE FAILURE RECURRED 4 TIMES. THE VEHICLE WAS TAKEN TO COMPETITION SUBARU OF SMITHTOWN LOCATED AT 601 MIDDLE COUNTRY RD, ST JAMES, NY 11780 WHERE THE BATTERY WAS REPLACED. THE FAILURE RECURRED AND THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER AND THE BATTERY WAS REPLACED. THE FAILURE RECURRED AND THE CONTACT WAS INFORMED OF AN UNKNOWN VOLUNTARY MANUFACTURER RECALL TO REPLACE THE EXHAUST AND CATALYTIC CONVERTER HOWEVER, THE PART WAS NOT AVAILABLE. THE CONTACT WAS PROVIDED A LOANER VEHICLE. THE CONTACT WAS INFORMED A WEEK LATER TO RETURN THE LOANER AND RETRIEVE HIS VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 13,270.

Mileage: 13,270

THE CVT TRANSMISSION FAILED AT 79K MILES AT HIGHWAY SPEEDS CAUSING THE CAR TO VIOLENTLY STALL. WE BARELY AVOIDED HITTING THE CARS AROUND US TRYING TO PULL OVER. LUCKILY THERE WAS NO CAR TO REAR END US. WE WERE VERY LUCKY THE TRAFFIC WAS LIGHT. THESE TRANSMISSIONS ARE DEFECTIVE AND WHEN THEY FAIL, THEY FAIL IN A SPECTACULAR MANNER CAUSING THE VEHICLE TO VIOLENTLY JERK AND STALL, A TRAUMATIC EVENT EQUIVALENT TO JUMPING ON THE BREAKS AT HIGHWAY SPEEDS. IT IS EXTREMELY DANGEROUS AND WILL CAUSE PEOPLE TO DIE IN CRASHES. SUBARU NEEDS TO RECALL EVERY SINGLE CVT AND STOP PUTTING THEM IN NEW CARS. EXTENDING THE WARRANTY IS INSUFFICIENT.

Mileage: 79,620

TL* THE CONTACT OWNS A 2016 SUBARU OUTBACK. THE CONTACT STATED THAT THE KEY WOULD NOT RELEASE FROM THE IGNITION. THE VEHICLE HAD TO BE TURNED ON AN OFF MULTIPLE TIMES IN ORDER FOR THE KEY TO RELEASE. THE VEHICLE WAS TAKEN TO STUCKEY SUBARU (500 BROAD ST, HOLLIDAYSBURG, PA 16648, (814) 695-9862) WHERE IT WAS DIAGNOSED THAT THE GEAR SHIFT LINKAGE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 50,017. CONSUMER STATES THAT THEY TOOK VEHICLE TO A LOCAL REPAIRMAN. THE TUMBLE AND SWITCH WERE REPLACED. CONSUMER EXPERIENCED ISSUE AGAIN A WEEK LATER AND TOOK VEHICLE TO STUCKEY SUBARU (HOLLIDAYSBURG, PA). THEY REPLACED THE GEAR SHIFT LEVER. CONSUMER STATES THAT ISSUE HAS BEEN RESOLVED. *DL

Mileage: 50,017

FRONT RIGHT CV JOINT STARTED MAKING A CLICKING SOUND THAT BECAME EXTREMELY BAD AFTER ONE MONTH. WE WERE TOLD TO REPLACE IMMEDIATELY DUE TO SAFETY HAZARD. HAD TO REPLACE THE CV AXEL COSTING OVER $600. GOT IT BACK FROM THE SUBARU DEALERSHIP, JUST TO BE TOLD THE LEFT ONE IS NOW GOING OUT AND WILL HAVE TO BE REPLACED AS WELL.

Mileage: 125,000

NOTICING WHEN I PARK MY CAR THE KEY WON'T RELEASE FROM IGNITION SWITCH WHEN CAR LEVER IS SET IN "P" POSITION. AS I PUSH IN AND TURN THE KEY FROM START TO LOCK THE KEY WILL STAY ACC POSITION WON'T GO INTO LOCK.

I REGULARLY CANNOT REMOVE KEY FROM IGNITION WHILE IN PARK. THE IGNITION DOES NOT SEEM TO RECOGNIZE THE VEHICLE IS IN PARK, SO I HAVE TO RESTART CAR, SHIFT DO DRIVE, RESHIFT TO PARK AND TRY TO REMOVE KEY MULTIPLE TIMES. THIS HAS BEEN HAPPENING CONSISTENTLY AND IS WORST WHEN PARKED ON A HILL.

Mileage: 35,000

SUBARU OUTBACK 2016 4DR 2.5I - VEHICLE BEGAN MAKING LOUD NOISE WHEN DRIVING IN THE HIGHWAY. NOISE COMING FROM THE REAR PASSENGER SIDE OF VEHICLE. TOOK TO SUBARU DEALER IN CHANDLER AZ AND DEALER CHANGED RIGHT-REAR WHEEL HUB BEARING. VEHICLE ONLY HAS 67 K MILES.

Mileage: 67,000

WOBBLING AND SHAKING OCCURS WHEN THE CAR IS IN MOTION (WHEN ACCELERATING). HAPPENS ON STREET AND ON HIGHWAY. SERVICE ADVISOR RECOMMENDED TRANSMISSION REPLACEMENT. PLEASE SEE ATTACHED EXTENDED WARRANTY OFFER FROM THE MANUFACTURER AS A RESULT OF PREVIOUS COMPLAINTS.

Mileage: 92,400

KEY GETS STUCK IN IGNITION WHEN PUT INTO PARK AND CAN'T TAKE KEY OUT OF IGNITION AFTER TURNING CAR OFF.

Mileage: 52,000

CAR STALLED IN THE MIDDLE OF AN INTERSECTION. IT WAS TRULY FRIGHTENING BECAUSE THE BABY WAS IN THE CAR AND IT WAS DURING MORNING COMMUTE RUSH HOURS WHEN EVERYONE IS RUSHING. THE CAR IS RELATIVELY NEW WITH 35K MILES AND AM THE ONLY OWNER OF THE VEHICLE. WAS AT AN INTERSECTION AND WAITING FOR MY TURN TO MAKE A LEFT. THE CAR WAS IN 'DRIVE' AND I HAD MY FOOT ON THE BRAKE. HOWEVER, WHEN THE GREEN LEFT TURN ARROW CAME, I PRESSED THE GAS PEDAL AND THE CAR DID NOT MOVE. I MOVED FROM 'DRIVE' TO 'PARK' AND BACK TO 'DRIVE' AND PRESSED THE GAS PEDAL AGAIN AND THE CAR DID NOT MOVE. THE CHECK ENGINE LIGHT CAME ON. I MOVED FROM 'DRIVE' TO 'PARK' AND TURNED OFF THE CAR ENGINE. THEN I RESTARTED THE CAR AND MOVED FROM 'PARK' TO 'DRIVE' AND PRESSED THE GAS PEDAL AGAIN AND THE CAR DID NOT MOVE. I BEGAN PRESSING THE GAS PEDAL HEAVY TRYING TO AT LEAST MAYBE MOVE TO SAFETY AND ALL OF SUDDEN THE CAR FELT VERY SLUGGISH BUT IT MOVED. I UNDERSTAND THERE IS AN EXTENDED WARRANTY OFFERED BY SUBARU REGARDING THE TRANSMISSION, BUT WHAT HAPPENED TO ME WAS DANGEROUS TO MYSELF, MY FAMILY AND OTHERS ON THE ROAD. THIS REQUIRES FURTHER INVESTIGATION AS TO NOT PUT ANY PEOPLE'S LIFE AT UNNECESSARY RISKS.

Mileage: 35,000

WHEN STOPPED, UNABLE TO REMOVE KEY FROM IGNITION (UNABLE TO MOVE KEY FROM ACC POSITION TO LOCK POSITION SUCH THAT KEY REMAINS IN IGNITION). SAFETY CONCERN: UNACCOMPANIED CHILD COULD START VEHICLE. UNLOCKED VEHICLE COULD BE STOLEN WITH KEYS IN IGNITION.

Mileage: 42,500

THE AUTOMATIC TRANSMISSION DOES NOT ENGAGE OFTEN CAUSING A JERKING MOTION OF THE CAR WHICH IS UNDIAGNOSED FOR THE PAST 3 YEARS. SUBARU EXTENDED THE TRANSMISSION WARRANTY FOR ONE YEAR. I WANT IT FIXED. MY WIFE AND I HAVE COMPLAINED SINCE THE CAR WAS NEW (2016 MODEL)

Mileage: 100

MY 2016 SUBARU OUTBACK 3.6 LIMITED HAS 64,000 MILES ON IT. RECENTLY I NOTICED AN UNFAMILIAR NOISE. WHEN I BROUGHT IT TO A MECHANIC HE SAID IT NEEDED A WHEEL BEARING AND THE WHEEL WAS ABOUT TO FALL OFF. HE REPLACED THE WHEEL BEARING/HUB BUT SAID THE NOISE WAS STILL THERE AND SUGGESTED I BRING IT TO A SUBARU DEALER FOR FURTHER EVALUATION. WHEN I BROUGHT IT TO THE SUBARU DEALER THEY SAID IT NEED TWO ADDITIONAL WHEEL BEARINGS. THEY SAID IT WAS UNSAFE TO DRIVE AND GAVE ME A LOANER CAR UNTIL IT CAN BE FIXED. AS MY CAR IS STILL WAITING TO BE FIXED I DON'T HAVE ALL THE DOCUMENTATION YET. BUT I STILL DO WORRY WHEN AND IF THAT 4TH BEARING/HUB WILL FAIL.

Mileage: 64,000

I HAD A MAJOR ISSUE WITH THIS VEHICLE ON JUNE 24. WE WERE DRIVING BACK FROM OUR FAMILY VACATION WHEN I WAS PASSING A SEMI TRUCK ON A TWO LANE ROAD THE VEHICLE SUDDENLY LOST POWER TO THE WHEELS AND WOULD NOT ACCELERATE. AS I STEPPED ON THE GAS THE ENGINE REVVED UP BUT THE VEHICLE WAS NOT ACCELERATING. I THOUGHT IT SLIPPED OUT OF GEAR. I PUT IT IN NEUTRAL THEN BACK INTO DRIVE AND STILL HAD THE SAME PROBLEM. I PUT MY FLASHERS ON TO ALERT THE TRUCK THAT I WAS HAVING ISSUES. I PULLED ONTO THE SHOULDER AND HE PASSED ME. I NOTICED THE TACHOMETER READ BETWEEN THE 3 AND 4 MARK WHEN I PUT MY FOOT ON THE ACCELERATOR TRYING TO SPEED UP. HOWEVER, THE VEHICLE DID NOT SPEED UP AT ALL. I WAS ABLE TO PULL OFF THE ROAD ONTO A TURNOUT AREA. THE PASSENGER IN THE FRONT SEAT ASKED IF ANY WARNING LIGHT CAME ON. NO LIGHTS OF ANY SORT CAME ON. THE TEMPERATURE GAUGE WAS IN THE NORMAL OPERATING RANGE. AFTER THE CAR STOPPED I TURNED OFF THE IGNITION AND OPENED MY DOOR AND NOTICED FLAMES COMING FROM THE BOTTOM OF THE CAR. I IMMEDIATELY INSTRUCTED THE OTHER THREE (3) PASSENGERS TO IMMEDIATELY EXIT THE CAR BECAUSE OF THE FLAMES. LUCKILY WE WERE ABLE TO EXIT THE VEHICLE AND GET A SAFE DISTANCE AWAY TO CALL 911 FOR ASSISTANCE. UNFORTUNATELY THE FIRE CONTINUED TO BURN AND ENGULFED THE CAR. BLACK SMOKE STARTED TO APPEAR. THE FIRE DEPARTMENT SHOWED UP AND EXTINGUISHED THE FIRE. WE WATCHED HELPLESSLY WHILE OUR CAR AND POSSESSIONS WENT UP IN SMOKE. WE CONTACTED SUBARU AND FILED A COMPLIANT. THEY TOOK THEIR TIME AND EVENTUALLY SENT THEIR QA TEAM TO INSPECT WHAT WAS LEFT OF THE VEHICLE. THEY FINALLY SENT US AN EMAIL STATING THEY COULD NOT FIND THE ROOT CAUSE OF THE FIRE BECAUSE THE FIRE DAMAGE WAS TOO INTENSE. WE BOUGHT THIS VEHICLE NEW JUST TWO YEARS PRIOR AND IT ONLY HAD ABOUT 30K MILES AND HAD ALL THE FACTORY RECOMMENDED SERVICES AT THE DEALERSHIP. THE VEHICLE IS UNDER WARRANTY.

Mileage: 31,000

I HAD EXPERIENCED A SHUDDER, POP, REVVING RPMS OF THE VEHICLES BEFORE A SUDDEN POWER LOSS AT HIGHWAY SPEED (65MPH). I WAS UNABLE TO ACCELERATE AND HAD LIMITED STEERING TO GET OFF THE HIGHWAY SAFELY. THE VEHICLE HAD STALLED BY THE TIME I WAS ON THE SIDE OF THE ROAD. I WAS THEN UNABLE TO RESTART THE VEHICLE AFTER SEVERAL ATTEMPTS. A TOWING SERVICE WAS CALLED TO BRING IT TO A LOCAL DEALERSHIP. WITHIN AN HOUR TIME PERIOD THE VEHICLE RAPIDLY LOST ELECTRICAL POWER AND HAZARD LIGHTS WERE NO LONGER FUNCTIONAL. THIS UNFORTUNATELY WAS LATE AT NIGHTTIME, MAKING THE VISIBILITY OF THE VEHICLE VERY MINIMAL. THE VEHICLE WAS EVALUATED AT A LOCAL DEALERSHIP AND REPORTED THAT THERE WAS A SOFTWARE PROBLEM WITH THE CHARGING SYSTEMS OF THE CAR. THE SYSTEM WAS UPDATED, BUT THE DEALERSHIP COULD NOT PROVIDE AN EXPLANATION FOR THE REVVING ENGINE, SHUDDERING, POWER LOSS AND STALLING THAT OCCURRED PRIOR TO THE INABILITY TO RESTART THE VEHICLE ON THE SIDE OF THE ROAD.

Mileage: 35,042

HAD COMPLAINED ABOUT CAR JOLTING AT STOP LIGHTS ON OCCASION IN GEAR AT FULL STOP AT LIGHTS. NO DIAGNOSIS. CHANGED GAS THINKING IT MIGHT HELP. SEEMED TO. NO DIAGNOSIS. THEN CAR JUMPED HARD BACKWARDS IN REVERSE COMING OUT OF PARKING SPACE. COULD HAVE HIT CAR BEHIND HAD WE BEEN PARALLEL PARKED INSTEAD OF ANGLE. TOOK CAR IN AND DEALER REPLACED CVT AT NO CHARGE BUT WARNED US IT WOULD CONTINUE TO JUMP IN REVERSE WITH THE NEW CVT AND IT DOES JUST AS IT DID WHEN WE TOOK IT IN. NOW WE HAVE TO REMEMBER TO GRIND DOWN ON THE BRAKE PEDAL WHEN GOING INTO REVERSE. THAT ISN'T RIGHT OR SAFE.

Mileage: 16,000

KEY STICKS IN THE IGNITION AND WILL NOT COME OUT. THE FAILING PARK POSITION SWITCH DID NOT ALLOW THE KEY TO BE TURNED TO THE FULLY OFF POSITION FOR KEY REMOVAL.

Mileage: 42,000

THIS ISSUE IS A SAFETY ENHANCEMENT REQUEST AFFECTING TOP OF THE LINE SUBARU OUTBACK 2016 LIMITED/PREMIUM MODELS EQUIPPED WITH KEYLESS IGNITION SYSTEMS. THIS ISSUE IS SIMILAR TO THAT REPORTED IN NHTSA ID NUMBER:10881286. ISSUE: IT IS POSSIBLE FOR A DRIVER TO INADVERTENTLY TURN OFF THE ENGINE (WE ARE ONLY HUMAN) USING THE START/STOP BUTTON WHEN THE VEHICLE IS IN DRIVE, PARK OR NEUTRAL. IF VEHICLE IS ON A SLOPE, THE VEHICLE WILL ROLL FORWARDS OR BACKWARDS ON IT'S OWN. THIS PRESENTS A SERIOUS RISK OF GRAVE BODILY HARM TO PEOPLE IN THE PATH OF THE UNATTENDED MOVING VEHICLE. THIS ALREADY HAPPENED WITH MY VEHICLE, LUCKILY IT HAPPENED INSIDE MY GARAGE ON A VERY SLIGHT SLOPE AND MY CLOSED GARAGE DOOR STOPPED THE VEHICLE. IF MY CHILDREN HAD BEEN BEHIND THE VEHICLE, REMOVING THEIR SCHOOL BAGS, THEY WOULD HAVE BEEN PINNED TO THE GARAGE DOOR BY A 3500 LB VEHICLE. UNACCEPTABLE. I REPAIRED THE SLIGHT DAMAGE BODY WORK ON THE VEHICLE AT THE DEALER BUT THAT IS IRRELEVANT COMPARED TO THE SAFETY RISK PRESENTED BY THIS "WORKS AS DESIGNED" BEHAVIOR OF THE CAR. POSSIBLE WORKAROUND: 1. SUBARU NEEDS TO CHANGE THIS BEHAVIOR AND ELIMINATE THE RISK BY AUTOMATICALLY ENGAGING THE ELECTRIC "PARK BRAKE" THAT IS ALREADY INSTALLED IN THIS MODEL VEHICLE, WHEN THE ENGINE IS TURNED OFF. 2. DISABLE ENGINE STOP UNTIL TRANSMISSION IS SET TO PARK. THE CURRENT AUDIBLE WARNING IS INSUFFICIENT. MY 15 YEAR OLD VEHICLE DID NOT ALLOW THE KEY TO BE REMOVED FROM THE IGNITION SLOT UNTIL PARK LEVER WAS ENGAGED TO PREVENT THIS EXACT PROBLEM. *TR

Mileage: 4,000

1ST OCCURRENCE: WHILE DRIVING ON A COUNTY ROAD, ALL WARNING LIGHTS CAME ON. BROUGHT VEHICLE BACK TO DEALER, DEALER REPLACED THE TRANSMISSION. *TR

Mileage: 7,000

LESS THAN 1 WEEK LATER, 2ND OCCURRENCE: WHILE DRIVING ON INTERSTATE, ALL WARNING LIGHTS CAME ON AND VEHICLE SUDDENLY LOST FORWARD MOVEMENT. VEHICLE WAS RUNNING BUT NOT ENGAGING ENOUGH TO PROPEL VEHICLE. TOWED TO DEALER, DEALER REPAIRED PILOT PIN IN TRANSMISSION. *TR

Mileage: 7,200

3RD OCCURRENCE: WHILE DRIVING ON A STATE HIGHWAY, VEHICLE JERKED, ALL WARNING LIGHTS CAME ON AND VEHICLE LOST MOVEMENT WITH RESISTANCE. TOWED TO DEALER. *TR

Mileage: 8,000

WHEN I BACK UP AND STOP AND PUT TRANSMISSION INTO DRIVE THERE IS A 3 TO 4 SECOND HESITATION BEFORE THE VEHICLE GOES FORWARD. THIS HESITATION PUTS ME INTO RISK AS I BACK OUT OF DRIVEWAY ONTO A BUSY URBAN STREET. THE DEALERSHIP SAYS THIS THE WAY THE CVT TRANSMISSION WORKS. THE PROBLEM WAS BROUGHT TO THE ATTENTION OF THE DEALER THE 1ST WEEK THAT I PURCHASED THE CAR ON 09/30/2015. THE PROBLEM STILL EXISTS WHEN GOING FROM A QUICK REVERSE TO DRIVE.

STATIONARY VEHICLE ROLLS BACK SIGNIFICANTLY WHEN ON ANY INCLINE WHEN IN GEAR. IT HAS AN AUTOMATIC TRANSMISSION WHICH ROLLS IN DRIVE AND REVERSE. THE DEALER SAID ALL VEHICLES ROLL WHEN IN GEAR. I HAVE OWNED 13 VEHICLES IN MY LIFE, THE ONLY VEHICLES THAT WOULD ROLL IN GEAR WERE MANUAL TRANSMISSION VEHICLES WHICH IS WHY THE LAST 8 VEHICLES I HAVE OWNED HAVE BEEN AUTOMATIC. THE DEALER DENIED THIS WAS A PROBLEM BUT ON THE SUBARU OUTBACK FORUM, THIS IS A KNOWN PROBLEM FOR AT LEAST THE PAST TWO ITERATIONS OF THIS VEHICLE. THE FIRST OCCASION THE VEHICLE ROLLED BACK ON A GOOD SLOPE FOR AT LEAST THREE FEET AND THEN THE TIRES SPUN WHEN I DEPRESSED THE ACCELERATOR. THE HILL ASSIST FEATURE ON THIS CAR MAY HAVE BEEN OF ASSISTANCE BUT I WAS UNFAMILIAR WITH IT. THE HILL ASSIST FEATURE SHOULD NOT HAVE TO BE ENGAGED DURING NORMAL DRIVING. HAD THIS SLIPPAGE HAPPENED AT A STOPLIGHT, THE VEHICLE WOULD HAVE ROLLED INTO ANOTHER AND CAUSED DAMAGE TO BOTH VEHICLES. ABSOLUTELY DANGEROUS AND UNACCEPTABLE. THE TRANSMISSION ACTS LIKE A MANUAL WITHOUT A CLUTCH.

Mileage: 275

STATIONARY VEHICLE ROLLS BACK SIGNIFICANTLY WHEN ON ANY INCLINE WHEN IN GEAR. IT HAS AN AUTOMATIC TRANSMISSION WHICH ROLLS IN DRIVE AND REVERSE. THE DEALER SAID ALL VEHICLES ROLL WHEN IN GEAR. I HAVE OWNED 13 VEHICLES IN MY LIFE, THE ONLY VEHICLES THAT WOULD ROLL IN GEAR WERE MANUAL TRANSMISSION VEHICLES WHICH IS WHY THE LAST 8 VEHICLES I HAVE OWNED HAVE BEEN AUTOMATIC. THE DEALER DENIED THIS WAS A PROBLEM BUT ON THE SUBARU OUTBACK FORUM, THIS IS A KNOWN PROBLEM FOR AT LEAST THE PAST TWO ITERATIONS OF THIS VEHICLE. THE FIRST OCCASION THE VEHICLE ROLLED BACK ON A GOOD SLOPE FOR AT LEAST THREE FEET AND THEN THE TIRES SPUN WHEN I DEPRESSED THE ACCELERATOR. THE HILL ASSIST FEATURE ON THIS CAR MAY HAVE BEEN OF ASSISTANCE BUT I WAS UNFAMILIAR WITH IT. THE HILL ASSIST FEATURE SHOULD NOT HAVE TO BE ENGAGED DURING NORMAL DRIVING. HAD THIS SLIPPAGE HAPPENED AT A STOPLIGHT, THE VEHICLE WOULD HAVE ROLLED INTO ANOTHER AND CAUSED DAMAGE TO BOTH VEHICLES. ABSOLUTELY DANGEROUS AND UNACCEPTABLE. THE TRANSMISSION ACTS LIKE A MANUAL WITHOUT A CLUTCH.

Mileage: 275

I WAS IN A STORE PARKING LOT. I DROVE APPROX. 2 BLOCKS AND CAME TO A FULL STOP WHERE THERE WAS A PEDESTRIAN CROSSING. I ACCELERATED MAKING A LEFT TURN AND BEGAN CLIMBING A SMALL HILL TO EXIT THE PARKING AREA. I TRAVELED APPROXIMATELY 20 FEET AND MY CAR LOST ACCELERATION. I PLACED MY FOOT ON THE GAS PEDAL AND PRESSED IT DOWN APPROX. 50 PERCENT. WHILE DOING SO, I DID NOT HEAR THE ENGINE RACING. THE SPEEDOMETER REGISTERED 2 MILES PER HOUR. I BRAKED, CAME TO A FULL STOP AND TOOK MY CAR OUT OF GEAR. I MOVED IT BACK TO DRIVE AND THE CAR RESPONDED NORMALLY.

Mileage: 560