2016 SUBARU OUTBACK Visibility/wiper Problems

1.Windshield crack in the deicing area. Driving on a highway heard a loud boom as if a very big rock hit the car. 30-40 second later there was another boom of normal loudness. At this moment windshield crack has been noticed. The windshield will not be available, replacing it on 12/22/2025 2. Visibility has been affected 3. No, problem was not reproduced. Dealer representative said that the problem is not covered by Subaru. 4. Windshield was visually inspected by the dealership representative. I will try to collect more data at the windshield replacement shop. 5. There were no symptoms of the problem. N.B - the crack outside is flat, as if no rock hit happened. - I have camera's MP4, where sounds can be heard, 1GB

I had a rock thrown at my vehicle's windshield and required a replacement. I went to a Subaru dealership, Zeigler Subaru of Kenosha, local to me for a replacement. A day after I received my car, the windshield developed a hairline crack emanating from the bottom. I brought it back to the dealer and they replaced it again. After that time, it was a whole week and a half when I noticed a hairline crack, this time from the top working its way down. I brought it once again to the dealer for a replacement and a better explanation as to what is going on. 1.5 months later, I took my car again and was good for a little over a month, when I noticed the same hairline crack, this time from the bottom. I am up to having three windshields being installed and have no confidence in the safety and longevity of the vehicle I have. Subaru has had engineers come out to evaluate my vehicle and determined that its structural construction is not compromised and have tried to diagnose another probable cause coming from the windshield wiper heater and unplugged it. I have heard crack noises when driving at random intervals and have it noted to the dealership. no further update has been told to me as of the writing of this concern.

Media screen failure. Is available for inspection. Safety of pedestrians or other accident at risk because the screen is useless in bright sunlight. Planning to complain to dealer. No warning signal or alert when backing up when screen is unreadable. This has caused accidents x 3 for my family. Backed into another car with no warning.

Travelling on I-95 southbound at approx. 70 mph in the right lane at least 8-10 car lengths behind another vehicle in front of me. Clear skies, 78* F, calm weather. I heard a loud, sudden noise followed by wind and what sounded like glass on my roof, thought it was fireworks or a gunshot. Pulled over to make sure my dogs are OK (all good, just spooked!) and see what happened to the car when I observed a large hole and continued cracking noise in the sunroof - glass was pushed outwards/ convex rather than concave as if an object had struck the glass from above or in front of my vehicle. Notified insurance then carefully drove home the remaining 20 or so miles, called dealership and started researching the issue. There are nearly 40 reports of spontaneous sunroof explosions on NHTSA website for Subaru Outbacks. Dealing with Subaru Corporate and a local dealership for repairs.

Windshield cracks on its own. This is my 3rd time replacing windhield.

Windshield cracked on its own, this is the 3rd time I will be replacing windshield.

A crack appeared across the upper middle of the windshield. There was no event, damage, or accident involved. The crack just appeared one day. The crack runs across the windshield in the area of the rear view mirror and in front of the mounted cameras used for the collision avoidance, lane departure system.

Front windshield cracked all the way across. Have not replaced so it is available for inspection. The crack impairs vision. Confirmed by dealer in Macon, GA. Has not been inspected except by the service department at Subaru in Macon, GA. No warning lamps or messages.

Windshield cracked

Two windshields cracked in 6 years - this is a safety issue that should not happen.

WENT OUT TO MY CAR THIS MORNING AND NOTICED A LINEAR 6 INCH CRACK IN MY WINDSHIELD-IT EXPANDED FROM NEAR THE WIPER ON THE DRIVER SIDE UPWARD AND WITHIN 2 HOURS ANOTHER CRACK BEGAN ABOUT 5 INCHES LATERAL TO THE EVER EXPANDING FIRST CRACK WHICH IS NOW GREATER THAN 12 INCHES LONG. I CALLED DEVOE SUBARU IN NAPLES FLORIDA AND ASKED ABOUT WINDSHIELD CRACK AND REPAIR-I HAD BOUGHT THE CAR THERE 3 YEARS AGO. I WAS INFORMED THEY DO NOT REPAIR WINDSHIELDS, NEVER DID THEY MENTION THIS WAS A COMMON PROBLEM WITH THE OUTBACK. I CONTACTED SATELLITE WINDSHIELD REPAIR AND GAVE THEM MY INSURANCE INFO AND HOPEFULLY MY PROGRESSIVE INSURANCE WILL COVER THE WINDSHIELD AND THE EYESIGHT CALIBRATION.I THEN GOOGLED THE ISSUE AND FOUND THAT THIS IS A REAL AND FREQUENT ISSUE WITH THE SUBARU.

We have replaced about 5 windshields in this vehicle since we have owned it. The cracks form from the bottom of the windshield in the black area where a rock couldn't possibly chip the windshield. Subaru refuses to recognize this vin number as part of their class action law suit that was just settled and has refused to extend the warranty on this particular vehicle although they are covering replacement windshields for other 2016 Subaru Outbacks. They clearly recognize that there is a problem but are refusing to admit fault. You do not need to look far to find numerous complaints in forums on the internet with people describing this exact problem.

On November 15, 2021 my car was in the garage as normal. I started my car and I heard a "pop" I was headed out my driveway is when I notice a crack at the bottom of the windshield that is about 3" high and then curves for about 4".

Windshield cracks easily. On my 5th windshield, just replaced 2 weeks ago and it’s cracked again. The windshield cracks easily even with minor rock chips. This is the 5th windshield on this car.

Windshield cracked without any cause

The windshield cracked without receiving any kind of impact to it. No rock chip, sudden jolt, extreme temperatures or other weather event precipitated the cracking.

The adjustment of the passenger side side view mirror has malfunctioned. The mirror can not be adjusted properly for visibility of cars to the side of the vehicle. Only the driver-side window is operable. All other windows fail to open from the driver side control. The passenger window will no longer operate from the passenger side either. These windows would have to be broken in order to escape the vehicle in some situations (flooding). My mechanic says that this is a common problem in 2016 Subaru Outbacks. No warning lights were activated. A mirror not able to be adjusted for optimum sighting of other vehicles is surely a safety issue.

A small rock chip at bottom of the windshield, near the heated wiper park area, caused multiple cracks across the entire windshield. Replacement was required as visibility was impaired

Windshield spontaneously developed a crack; there had been no impact to the vehicle or windshield.

BATTERY IS DRAINED WHILE PARKED.

Mileage: 50,000

THE WINDSHIELD CRACKED IN AUGUST OF 2020 WITHOUT ANY IMPACT OR OUTSIDE CAUSE ACROSS THE MIDDLE OF THE WINDSHIELD ALMOST THE ENTIRE LENGTH OF THE GLASS. I HAD IT REPLACED AT THE DEALERSHIP AND IN APRIL OF 2021 THE NEW WINDSHIELD NOW HAS CRACKED DOWN THE MIDDLE OF THE GLASS. BOTH TIMES THE CRACKS APPEARED OVERNIGHT WITH THE VEHICLE IN A PARKED POSITION.

Mileage: 65,000

2016 SUBARU OUTBACK. A FOUR-INCH WAVY CRACK ON THE LEFT BOTTOM OF THE WINDSHIELD; A WEEK LATER ANOTHER CRACK OF ABOUT 6 INCHES APPEARED. THE CRACKS OCCURRED WITH THE SUBARU CAR IN MOTION ON A HIGHWAY.

Mileage: 67,000

WINDSHIELD BEGAN CRACKING NEAR THE BOTTOM (CLOSE TO THE WINDSHIELD WIPERS) BUT THERE WAS NO ROCK OR DAMAGE TO THE WINDSHIELD THAT PROMPTED THE CRACK. IT JUST APPEARED AND THEN HAS SPREAD ABOUT 2 FEET.

Mileage: 60,000

THIS MORNING MY WIFE NOTICED A CRACK IN THE WINDSHIELD OF OUR 2016 3.6R SUBARU OUTBACK PURCHASED 3/2016. IT ORIGINATES AT THE BASE OF THE WINDSHIELD, PASSES OVER THE 6 RED DEFROSTER WIRES BELOW THE WINDSHIELD, AND EXTENDS ~10" UP ON THE DRIVERS SIDE TOWARD THE REAR VIEW MIRROR. THERE ARE NO PITS ETC., THIS CRACK ORIGINATED ON THE INSIDE OF THE WINDSHIELD. THIS CRACK PERFECTLY MATCHES THE CRACK PATTERN AND DESCRIPTION IDENTIFIED IN SUBARU SERVICE BULLETIN 12-192-15R, REVISED 11/19/15. THAT BULLETIN WAS ISSUED AS A RESULT OF SUBARU'S LOOSING A LAWSUIT IN CALIFORNIA REGARDING BROKEN GLASS WINDSHIELDS BECAUSE OF MANUFACTURING DEFECT. UNFORTUNATELY SUBARU IS ONLY REPLACING DEFECTIVE GLASS ON OUTBACKS UP TO VIN G3222455/G3210476. OUR MANUFACTURING VIN IS EARLY 2016, AND THE JUDGE IN THE CASE DID NOT EXTEND JUDGMENT AGAINST SUBARY TO COVER OUR OUTBACK. THIS IS EXACTLY THE SAME PROBLEM WITH OUR OUTBACK AS FOR THE CALIFORNIA CASE. HERE IN NEW JERSEY WE HAVE BEEN HAVING SEVERAL WEEKS OF HARSH WEATHER, OUTSIDE TEMPERATURE ~20 DEGREES F IN THE MORNING. THE OUTBACK IS GARAGED, IT IS A WARM GARAGE. EVEN THOUGH THIS IS A 2016, WE ASSUME THE EXTREME IS A FACTOR. THIS IS NOT A STONE HIT PROBLEM, ALL THE DRIVING IS NORTHERN NJ SURBURBAN ROADS, NOT HIGHWAY DRIVING. WE SEE MANY MANY COMPLAINTS DEFINITELY A MANUFACTURING ISSUE. ATTACHING A PHOTO OF CRACK. I RUN MY FINGER OVER THE CRACK AND ACTUALLY CAN'T FEEL ANYTHING, NO DINGS, NOTHING.

Mileage: 58,766

I DROVE MY CAR TO SKI. I PARKED MY CAR. THE SNOW ACCUMULATED ON WINDSHIELD. AND THEN I FOUND THE WINDSHIELD HAS A LONG CRACK.

Mileage: 45,000

2016 SUBARU OUTBACK'S FRONT WINDSHIELD CRACKED FOR NO APPARENT REASONS

Mileage: 60,927

II WAS DRIVING ON AN OPEN HIGHWAY WITH NO CARS IN CLOSE VICINITY WHEN WINDSHIELD CRACKED FOR NO APPARENT REASON. CRACK WAS ON DRIVER SIDE NEAR EDGE ABOUT 12 INCHES LONG. ON INVESTIGATION, THERE WERE NO NICKS OR PITS IN THE WINDSHIELD, JUST THE CRACK. WHEN THE WINDSHIELD WAS BEING REPLACED, THE TECHNICIAN STATED THAT IT WAS WIERD THAT A SIMILAR CRACK DEVELOPED ON THE PASSENGER SIDE OF THE WINDSHIELD AS HE WAS REMOVING THE SHIELD FROM THE CAR.

Mileage: 49,000

FRONT WINDSHIELD CRACKED, ORIGINATING FROM THE EDGE OF THE WINDOW, ABOUT 2 YEARS AGO WHILE PARKED WITHOUT ANY OVERHANGING HAZARDS OR ADVERSE WEATHER. THERE IS NO ASSOCIATED GLASS 'DING' FROM AN IMPACT. I BELIEVE THIS IS THE SAME PROBLEM THAT LED TO A LAWSUIT AGAINST SUBARU INVOLVING 2015-2016 OUTBACK'S.

Mileage: 44,000

WE PURCHASED A CAR BRAND NEW IN SAVANNAH, GA AND SINCE HAVE REPLACED WINDSHIELD THREE TIMES. IT HAS A SMALL CRACK AGAIN. ALL OUR REPLACEMENTS OCCURRED AGAINST OUR INSURANCE. OUR COVERAGE HAS INCREASE IN PREMIUMS. PREVIOUSLY, I NEVER HAD AN ISSUE WITH WINDSHIELD CRACKED ON REGULAR OCCURRENCE. ANOTHER ISSUE - WHEN IT RAINS THE VISIBILITY IS EXTREMELY POOR. DESPITE I BUY THE EXPENSIVE WIPERS TO REPLACE THEM AT LEAST ONCE IN 12 MONTHS UNABLE TO ADJUST/INCREASE THE WIPER SPEED FOR THE HEAVY RAIN MAKES THE DRIVING EXTREMELY DANGEROUS. OPTIONAL EYESIGHT WHICH WAS ADDED AS AN OPTION IS SHUTS ITSELF DUE TO THE HEAVY RAIN AND IS NO HELP. EYESIGHT IS ALSO UNDERPERFORM WHAT WAS PROMISED BY MANUFACTURER. ALL ABOVE APPLIES FOR VEHICLE IN MOTION.

Mileage: 56,210

SPONTANEOUS CRACK DEVELOPED DOWN THE PASSENGER SIDE OF THE WINDSHIELD IN MY 2016 SUBARU OUTBACK WHILE DRIVING. NO OBVIOUS REASON SUCH AS IMPACT WITH STONE OR ROCK WAS INVOLVED- LARGE CRACK JUST SUDDENLY APPEARED. HAVE READ MANY REPORTS OF OTHERS HAVING SAME ISSUE, AND SUBARU HAS HAD AT LEAST 3 CLASS ACTION LAWSUITS FILED AGAINST THEM FOR THIS EXACT ISSUE. *TR

Mileage: 103,000

THIS IS THE 2ND WINDOW THAT HAS HAD TO BE REPLACED IN 2 1/2 YEARS. IT APPEARED TO CRACK SPONTANEOUSLY. *TR

Mileage: 48,000

TL* THE CONTACT OWNS A 2016 SUBARU OUTBACK. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE WINDSHIELD CRACKED WITHOUT IMPACT. THE CONTACT STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED AT PEACOCK SUBARU HILTON HEAD (111 DRIVERS WAY SUITE A, HARDEEVILLE, SC 29927) FOR A CRACKED WINDSHIELD. THE VEHICLE WAS TAKEN BACK TO THE SAME DEALER AND THE CONTACT WAS INFORMED THAT THE WINDSHIELD NEEDED TO BE REPLACED HOWEVER, NO ADDITIONAL ASSISTANCE WAS PROVIDED. THE WINDSHIELD WAS NOT REPLACED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 53,688.

Mileage: 53,688

MY VEHICLE WAS IN MOTION ON A HIGHWAY WHEN A PEBBLE STRUCK THE WINDSHIELD AND A CHIP WAS FORMED ON 8/26/2016. THIS CHIP WAS IMMEDIATELY REPAIRED. THIS WAS ONLY MONTHS FROM PURCHASING A BRAND NEW 2016 SUBARU OUTBACK; FACTORY TO DEALER. THEN, WHILE PARKED, IT WAS NOTED THAT THE CHIP FORMED A SPREADING CRACK ON 11/13/2017. AT THIS POINT, THE WINDSHIELD WAS REPLACED WITH NEW, ORIGINAL SUBARU GLASS. *TR

Mileage: 5,000

MY WINDSHIELD SPONTANEOUSLY CRACKED ON THE DRIVER'S SIDE NEAR THE WIPER BLADE, WHILE DRIVING WITH A FACTORY WINDSHIELD. THE 6" CRACK FROM THE CORNER ALMOST IMMEDIATELY TURNED INTO A CRACK ACROSS THE ENTIRE WINDSHIELD - AGAIN NO TRAUMA OR ROCKS. I WAS DRIVING STRAIGHT ON A HIGHWAY WITH NO POTHOLES OR ANYTHING. I HAD THE WINDSHIELD REPLACED AND IT HAS AGAIN SPONTANEOUSLY CRACKED WITH NO TRAUMA (NO ROCK OR BUG IMPACT OR OTHER IMPACTS/DAMAGES) ON THE PASSENGER SIDE BY THE WIPER BLADE. I BELIEVE THAT THE SUBARU WINDSHIELD AS WELL AS THE DEFROST SYSTEM ARE DEFECTIVE. THIS WILL BE MY THIRD WINDSHIELD IN UNDER 3 MONTHS. OTHER SUBARU OUTBACK OWNERS HAVE COMPLAINED ABOUT THIS AND SUBARU CONTINUES TO BLAME IT ON ROCKS. THE SECOND CRACK HAPPENED WHILE MY VEHICLE WAS STATIONARY IN THE DRIVEWAY!

Mileage: 50,000

IN FEBRUARY 2019 I HAD TO REPLACE THE WINDSHIELD IN MY 2016 SUBARU OUTBACK BECAUSE OF A CRACK THAT STARTED FROM THE PASSENGER SIDE EDGE FROM A VERY TINY CHIP, AND PAID ABOUT $950 (OEM EQUIPMENT AND DUE TO THE EYESIGHT SYSTEM CALIBRATION REQUIRED). ON FEBRUARY 29, 2020, I DISCOVERED A CRACK IN THE NEW WINDSHIELD, IN A SIMILAR PLACE (PASSENGER SIDE, TINY CHIP AT THE EVERY EDGE (BLACK PART OF WINDSHIELD), THAT THEN EXTENDED HALF WAY ACROSS THE WINDSHIELD. I COULD NOT REMEMBER ANYTHING HITTING THE WINDSHIELD TO CAUSE THE TINY CHIP, AND IT REALLY WAS TINY AND VERY SHALLOW. THE CAR HAD BEEN PARKED ALL DAY IN A SAFE, SECURE AREA. THE CRACK WAS NOT THERE IN THE MORNING WHEN I PARKED THE CAR, BUT WAS THERE BY THE END OF THE DAY. PHOTO ATTACHED. IT DOES NOT SEEM REASONABLE TO HAVE TO REPLACE A WINDSHIELD ANNUALLY! SUBARU HAS A PROBLEM WITH THEIR WINDSHIELDS!

Mileage: 42,000

I HAD PURCHASED MY CAR IN FEB 2016. WE HAD TO HAVE WINDSHIELD REPLACED 90 DAYS LATER. AND THEY TOLD ME " THE GLASS IS THINNER DUE TO EYE SIGHT. I'VE HAD WIND SHIELD REPLACED 2 OTHER TIMES SINCE THEN. WE WERE DRIVING DOWN THE HIGHWAY,AND IT WAS STRUCK BY ROCKS. I WENT TO SUBARU AND THEY STATED THERE WAS NOTHING WRONG WITH THEIR GLASS. AND EACH TIME IT WAS REPLACED. 1 AT THEIR COST AND 2 AT MIND. ALL OF THE PAPERS WORK I CAN GET FROM INS. COMPANY

Mileage: 1,700

WINDSHIELD CRACKED IN L SHAPE . ON DAY AFTER SNOW FALL. WHEN CLEARED THERE WAS THE CRACK

Mileage: 46,500

I HAVE A 2016 SUBARU OUTBACK, WHICH I'VE OWNED SINCE NEW (09/15/2015). I'VE HAD TO REPLACE 8 WINDSHIELD SO FAR, SOMETIMES WITHIN 3 MONTHS, OR EVEN 2 DAYS APART. I DRIVE AROUND SAN FRANCISCO BAY AREA (NOT STATISTICALLY HIGHER RISK FOR WINDSHIELD DAMAGE) THIS CONSTANT ISSUE WITH THE WINDSHIELD AFFECTS THE SAFETY OF THE CAR IN CASE OF FOREIGN OBJECT IMPACT OR SPONTANEOUS CRACKING, BECAUSE OF REDUCED VISIBILITY AND COMPROMISED STRUCTURAL/IMPACT PROTECTION

Mileage: 64,880

TL* THE CONTACT OWNS A 2016 SUBARU OUTBACK. THE CONTACT STATED THAT A FRACTURE WAS EVIDENT ON THE WINDSHIELD BY THE REAR VIEW MIRROR IN THE MIDDLE. THE CONTACT STATED THAT THE FRACTURE WAS HORIZONTAL OF WHERE THE REARVIEW MIRROR WAS ATTACHED. MICHAEL'S SUBARU OF BELLEVUE (15150 SE EASTGATE WAY, BELLEVUE, WA 98007 (425) 641-2002) OFFERED FOR THE CONTACT TO HAVE THE VEHICLE TAKEN TO DEALER FOR A DIAGNOSIS AND INSPECTION. THE MANUFACTURER WAS NOT CONTACTED NOR INFORMED OF THE FAILURE. THE CONTACT STATED THAT THE INSURANCE COMPANY WOULD BE MADE AWARE OF THE ISSUE IF THE MANUFACTURER FAILED TO ASSIST IN HAVING THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS 40,000. THE VIN WAS NOT AVAILABLE.

Mileage: 40,000

CRACK IN WINDSHIELD DIRECTLY BEHIND THE REARVIEW MIRROR HORIZONTALLY AND VERTICALLY WITH NO VISIBLE SIGNS OF IMPACT, FOUND ONE GETTING INTO THE CAR WHICH WAS IN OUR GARAGE

Mileage: 75,000

NUMEROUS WINDSHIELD CRACKS, SEEMS TO OCCUR SPONTANEOUSLY.

Mileage: 59,000

I HAVE NOTICED A SMALL CRACK IN THE LOWER CORNER OF THE WINDSHIELD AND I HAVE NOT BEEN WITH A ROCK OR ANY OBJECTS. I PURCHASED THE SUV THE FEBRUARY OF 2019 AND IT APPEARED TO HAVE A NEW DEALERSHIP WINDSHIELD. I HAVE SEEN MANY COMPLAINTS ONLINE INCLUDING LAWSUITS REGARDING SUBARU WINDSHIELDS THAT SPONTANEOUSLY CRACK. THE WINDSHIELDS FROM SUBARU SEEM TO BE VERY FRAGILE AND I HAVE CONCERNS OF A DEFECT.

DRIVING TO WORK ON THE HIGHWAY AND THE WINDSHIELD JUST POPPED AND CRACKED. LITTLE SHARDS OF GLASS FLEW ONTO THE DASHBOARD. HAPPENED UNDER THE DRIVERS SIDE WIPER.

Mileage: 45,000

JUNE 2019 - WINDSHIELD CRACKED WITHOUT ANY APPARENT IMPACT FROM ANYTHING, DRIVING BY MYSELF. REPLACED WINDSHIELD, AND WITHIN TWO WEEKS, THE SAME THING HAPPENED - WINDSHIELD CRACKED WITHOUT ANY APPARENT IMPACT FROM ANYTHING. VEHICLE WAS MOVING IN BOTH INSTANCES. OCCURRED ON HIGHWAY DRIVING. IN BOTH INSTANCES, CRACK STARTED SMALL AND WENT HORIZONTALLY ACROSS THE MIDDLE OF THE WINDSHIELD IMPAIRING MY VISION AND CAUSING A SAFETY ISSUE.

Mileage: 75,000

ON 10/10/2019 WE NOTICED A LONG CRACK IN THE WINDSHIELD OF THIS VEHICLE FOR NO CAUSE. WE JUST GOT INTO THE CAR AND NOTICED. THIS IS THE THIRD TIME THIS HAS HAPPENED SINCE WE BOUGHT OUR 2016 SUBARU OUTBACK IN JUNE 2016. THE FIRST TWO TIMES (LAST ONE REPAIRED IN MARCH 2019) THE CRACK STARTED AT THE BOTTOM OF THE WINDSHIELD AS NUMEROUS PEOPLE HAVE REPORTED. INSURANCE WILL NOT PAY IN NEW MEXICO, SO WE HAVE TO KEEP REPLACING AT OVER $300 A TIME. THIS IS CLEARLY A FAULT IN THE DESIGN OR QUALITY OF THE GLASS. WE RESPECTFULLY REQUEST THAT YOU INVESTIGATE THIS FOR US AND MANY OF THE OWNERS OF THESE VEHICLES. IT IS UNACCEPTABLE TO HAVE TO KEEP PAYING THE FULL PRICE FOR NEW WINDSHIELDS. SUBARU NEEDS TO ADMIT A FAULT IN DESIGN AND PROVIDE CONSUMERS WITH WINDSHIELDS AT NO COST - PREFERABLY DESIGN ONE THAT WILL NOT CRACK. THIS IS THE FIRST VEHICLE IN 35 YEARS THAT HAS EVER CRACKED. THANK YOU FOR INVESTIGATING THIS ISSUE.

Mileage: 68,000

WINDSHIELD CRACKED WITHOUT ANY OBJECT IMPACT. CRACK STARTED AT THE BOTTOM PASSENGER SIDE. SAME LOCATION AS LISTED IN A CLASS ACTION SUIT FOR 2015 AND EARLY MODEL 2016 CARS. VEHICLE WAS IN MOTION ON CITY STREETS AT ABOUT 35MPH WHEN I HEARD THE NOISE. I DID NOT NOTICE THE CRACK UNTIL LATER IN THE DAY, AS IT WAS VERY LOW ON THE WINDSCREEN AND WAS NOT VISIBLE FROM THE DRIVERS POSITION IN THE CAR. THE CRACK HAS SINCE SPREAD ACROSS AND UP THE WINDSCREEN. SUBARU OF AMERICA HAS DENIED MY REQUEST FOR A REPAIR AND I WILL BE DOING SO AT MY OWN EXPENSE LATER TODAY.

Mileage: 50,000

I RECEIVED A SMALL CHIP FROM A ROCK THAT THEN SPREAD TO ABOUT AN 8 INCH CRACK. IT'S BEEN THAT WAY WITH NO CHANGE FOR MONTHS. THEN THIS MORNING WE DROPPED TO 26 DEGREES AND WHEN I TURNED ON THE DEFROSTER FOR THE WINDSHIELD THE CRACK SHOT ACROSS THE ENTIRE WINDSHIELD. I HADN'T EVEN MOVED THE CAR YET. I HAVE BEEN TOLD BY SAFELITE THAT THIS WINDSHIELD WAS FAULTY AND SUBARU SHOULD REPLACE IT UNDER WARRANTY BUT THE SUBARU HERE IN MISSOULA, MT IS REFUSING TO DO SO. I SEE THAT CA HAD THE SAME ISSUE AND THEY SUED SUBARU. DO I HAVE TO DO THAT TOO TO GET THEM TO HELP ME?

Mileage: 42,000

ABOUT A WEEK A GO I NOTICED A CRACK IN THE WINDSHIELD ON THE PASSENGER SIDE. I CAN NOT ATTRIBUTE IT TO A ROCK OUR OTHER ROAD DEBRIS. CLOSE INSPECTION SHOWS A VERY SMALL CHIP DIRECTLY UNDER THE WIPER BLADE, WHICH WOULD PROTECT THE WINDSHIELD FROM A ROCK ETC. THE CRACK EXTENDS VERTICALLY DOWN UNDER THE PLASTIC TRIM AND UP ALMOST TO THE WIPER BLADE SWEEP LIMIT. THIS IS THE SECOND WINDSHIELD IN MY VEHICLE. IN 2017 I THOUGHT I GET HIT BY A ROCK. A LARGE CHIP APPEARED ON THE DRIVERS SIDE AND A CRACK IMMEDIATELY APPEARED. I PAID FOR A REPAIR BY THE DEALER. IT WAS NOT COVERED BY WARRANTY OR INSURANCE. I AM NOW WONDERING IF THE FIRST WINDSHIELD WAS HIT BY A ROCK OR NOT. REGARDLESS, I CANT BELIEVE I WILL BE ON THIRD WINDSHIELD IN A VEHICLE I HAVE NOT YET HAD TO REPLACE THE BRAKE PADS.

Mileage: 61,100

I'VE ONLY RECENTLY LEARNED OF THE SPONTANEOUS WINDSHIELD CRACKING ISSUE THAT IS IN LITIGATION. THIS HAPPENED TO ME. I WAS STOPPED, WAITING AT A LIGHT NEAR THE INTERSECTION OF WASHINGTON AND THE ENTRANCE TO I-70 IN DENVER. SUDDENLY, THE WINDSHIELD LOUDLY POPPED AND A LARGE CRACK APPEARED ON THE PASSENGER SIDE WHICH HAS SINCE PROGRESSED IN MANY DIFFERENT DIRECTIONS. I SPOKE TO THE DEALERSHIP AND THEY OFFERED NO ASSISTANCE. I'VE NOT YET HAD IT REPLACED AS I'D LEARNED OF THIS LAWSUIT, BUT NO DEFINITIVE PROGRESS HAS BEEN MADE, I'M REPORTING IT HERE. I DO NOT HAVE A PICTURE, BUT WILL UPDATE THIS POST LATER, IF POSSIBLE.

Mileage: 49,000

A CRACK ON THE WINDSHIELD SUDDENLY APPEARED WHILE DRIVING ON HIGHWAY WITH NO OTHER VEHICLES AROUND. THE CRACK WAS 8" LONG AND STARTED NEAR THE BOTTOM CORNER ON THE DRIVER'S SIDE. AFTER PARKING IT OVERNIGHT, THE CRACK SPREAD ACROSS HALF THE WINDSHIELD. WHEN WE HAD THE WINDSHIELD REPLACED, SAFELITE COULD NOT FIND ANY EVIDENCE OF A CAUSE, NO CHIPS OR EVIDENCE OF A ROCK HITTING IT. EVEN WITH THE EXTENDED "GOLD" WARRANTY, SUBARU WOULD NOT COVER THE REPLACEMENT.

Mileage: 65,000

CAR WAS STATIONARY AND HAD NOT BEEN DRIVEN IN SEVERAL HOURS AND THE WINDSHIELD CRACKED FROM THE TOP CENTER DOWN ABOUT SIX INCHES ACROSS BOTH THE DRIVER AND PASSENGER FIELD OF VIEW. THERE WAS NO PREVIOUS DAMAGE, MAJOR OR MINOR, FROM THE POINT WHERE THE CRACK APPEARED TO START FROM.

Mileage: 66,000

PLEASE FORWARD THIS MESSAGE ONTO WHOM IT MAY CONCERN AT SUBARU OF AMERICA CUSTOMER SERVICE. 2016 OUTBACK 3.6R BULLETIN NUMBER: 12-192-15R; NHTSA ID:10093903; REVISED: 11/19/15 UPDATE BULLETIN NUMBER: 12-192-15R; NHTSA ID:10093903; REVISED: 03/06/17 ISSUE: SPONTANEOUS CRACKED WINDSHIELD HELLO, I AM THE ORIGINAL OWNER OF MENTIONED VEHICLE, 2016 OUTBACK 3.6R EQUIPPED WITH THE ALL-WEATHER PACKAGE AND EYESIGHT. ON FEBRUARY 28, 2019 A SMALL VISIBLE RUNNING CRACK ONE INCH IN LENGTH APPEARED JUST IN FRONT OF THE DRIVER SIDE FRONT WINDSHIELD. WITH INSPECTION THE CRACK ACTUALLY STARTED AT THE LOWER PORTION OF THE FRONT WINDSHIELD IN THE DEICER/DEFROSTER AREA. SINCE THEN THE CRACKS HAVE INCREASED DAILY IN LENGTH AND IN NUMBER. ONE RUNNING CRACK HAS NOW SPREAD ACROSS THE ENTIRE LOWER HALF OF THE FRONT WINDSHIELD TOWARDS THE PASSENGER SIDE. ANOTHER VISIBLE RUNNING CRACK ONE INCH IN LENGTH NOW HEADING IN THE OPPOSITE DIRECTION ON THE DRIVERS SIDE OF FRONT WINDSHIELD. IT TOO ORIGINATES FROM THE LOWER PORTION OF THE FRONT WINDSHIELD IN THE DEICER/DEFROSTER AREA. UNDER VERY CLOSE PHOTO INSPECTION AT THE JUNCTIONS OF THESE MERGING CRACKS CHIPPING IS OCCURRING CAUSING ADDITIONAL SPIDERING CRACKS. I DID CONTACT MY SUBARU DEALERSHIP SERVICE DEPARTMENT ON MARCH 5, 2019.A SALESPERSON FILLED OUT AND I SIGNED AN INFORMATION FORM FOR REPORTING THIS ISSUE TO SUBARU AMERICA. I WAS NOT OFFERED AND DID NOT RECEIVE A COPY. HAVE NOT HEARD BACK FROM THEM YET. THIS ISSUE AND REPAIR MENTIONED IN TSB ID: 12-192-15R NEEDS TO BE ADDRESSED AS SOON AS POSSIBLE. I HAVE ATTACHED DETAILED PHOTOS AND MC-10093903-2280.PDF DOCUMENT. THIS SHOULD EXPEDITE THE REPLACEMENT PROCESS.

Mileage: 35,000

OUR WINDSHIELD HAS HAD 3 CHIPS/CRACKS IN IT SINCE NEW. THE FIRST ONE WAS A CHIP THAT WAS REPAIRED BY SAFELIGHT. THE SECOND WAS A CRACK/CHIP WHERE THE ENTIRE WINDSHIELD WAS REPLACED BY SAFELIGHT. BOTH OF THESE HAPPENED WHILE THE VEHICLE WAS ON-HIGHWAY. BOTH WERE IN DIFFERENT SPOTS, BUT WERE LOCATED ON THE DRIVERS SIDE. THE THIRD ONE WAS A LARGE CRACK ON THE DRIVER SIDE WE NOTICED YESTERDAY (12/26/18) WITH NO APPARENT CHIP ASSOCIATED. WE'RE NOT SURE IF THIS HAPPENED WHILE VEHICLE WAS MOVING OR STATIONARY. DATES FOR THE INITIAL CRACKS ARE ESTIMATES, BUT FIRST ONE WE ESTIMATE TO BE 8/2017. THE SECOND ONE WHERE THE WINDSHIELD WAS REPLACED IS ESTIMATED MAY 2018. WE NOTICED OTHERS WERE HAVING SIMILAR ISSUES AFTER DOING A SEARCH 12/26/18. IT ALSO APPEARS THAT SUBARU HAD ACKNOWLEDGED THERE WAS A PROBLEM WITH SOME 2015 AND 2016 MODELS, BUT OUR VEHICLE VIN DID NOT SHOW UP WHEN DOING A SEARCH.

Mileage: 5,000

3 MONTHS AFTER GETTING MY OUTBACK THE WINDSHIELD CRACKED AT THE BASE AND WENT UP AND OVER. I REPLACED THE WINDSHIELD AT A COST OF $500. MY WINDSHIELD RECENTLY CRACKED AGAIN AND WHEN I TAKE TO THEM AT THE SERVICE COUNTER THEY SAID IT IS NOT COVERED UNDER WARRANTY. I SHOULD NOT HAVE TO BUY A WINDSHIELD EVERY YEAR FOR A BRAND NEW CAR. FOR A CAR THAT IS SUPPOSED TO BE 5+ STAR SAFETY RATED I SHOULD HAVE AN INTACT WINDSHIELD. THE CRACKS ALSO APPEARED OVERNIGHT. THEY WERE NOT THERE WHEN I PARKED THE CAR, BUT WHEN I GOT IN IT THE NEXT MORNING. ALSO - NO CHIPPING OR STARING WAS FOUND WHERE THE CRACK STARED ON THE BOTTOM OF THE WINDSHIELD.

SPONTANEOUS CRACKS ON WINDSHIELD AND THEIR EXTENSION DURING HOT, SUNNY DAY. FOR THE SAFETY ISSUE, IT HAD TO BE REPLACED.

Mileage: 36,000

DRIVING ON A 4 LANE HIGHWAY IN A RURAL AREA AT 7:30 IN THE MORNING, NO OTHER TRAFFIC AROUND. I HEARD A SOUND LIKE A SMALL STICK BEING BROKEN. IT GOT MY ATTENTION AND I WONDERED WHAT IN THE WORLD WAS THAT. ABOUT 10 MILES LATER I NOTICED A CRACK COMING UP FROM THE BOTTOM OF THE WINDSHIELD RIGHT IN FRONT OF MY FACE. IT DEVELOPED INTO 2 CIRCLE CRACKS IN MY VIEWING AREA. DEALER SAID IT WAS A OLD CHIPPED PLACE OR A NEW CHIP THAT CAUSES IT. NEVER NOTICE A CHIP BEFORE OR AFTER I HEARD THE SNAP.

Mileage: 33,200

WINDSHIELD HAS CRACKED TWICE IN 16 MONTHS. THE 1ST CRACK HAPPENED WHILE DRIVING ON HIGHWAY WITH NO ONE AROUND ME- HEARD A POP AND HAD AN L SHAPED CRACK APPEARED ON MY WINDHIELD. THE WINDSHIELD WAS NOT STRUCK BY ANYTHING. AFTER MUCH NEGOTIATION WITH THE DEALER (THE CAR WAS UNDER WARRANTY WITH ABOUT 10,000 MILES), SUBURU REPLACED THE WINDSHIELD. THE SECOND CRACK APPEARED WHILE STATIONARY IN MY DRIVEWAY AFTER TURNING ON THE VEHICLE. I LITERALLY WATCHED AS AN L SHAPED CRACK APPEARED ON THE WINDSHIELD. I HAVE NOT REPAIRED THAT YET. I DID NOT REPAIR IT BECAUSE IT WILL HAPPEN AGAIN IN A FEW MONTHS. THE CRACK HAS SINCE SPIDERED THROUGHOUT THE ENTIRE WINDSHIELD. TO DATE, I HAVE RECEIVED NO NOTIFICATION FROM SUBURU. I AM NOT LOOKING FORWARD TO ANOTHER FIGHT WITH SUBURU.

Mileage: 45,000

WINDSHIELD SPONTANEOUSLY CRACKED. I HAVE DASHCAM FOOTAGE SHOWING BEFORE AND AFTER THE FORMATION OF THE CRACK. THERE WAS NO IMPACT OF ANY OBJECT TO CAUSE THE CRACK OVER ANY PERIOD OF TIME.

Mileage: 30,850

SUDDEN 6" CRACK IN WINDSHIELD ORIGINATING ON THE LOWER EDGE UNDER THE WIPERS. I HAD DRIVEN THE CAR HOME FOR LUNCH AND BACK TO WORK AT 1:15PM AND THE CRACK WAS NOT THERE. WHEN I GOT OFF WORK AT 4PM THE CRACK WAS THERE. DROVE CAR HOME AND PUT IT IN THE GARAGE. THE NEXT MORNING AT 7AM THE CRACK WAS APPROXIMATELY 12" LONG RUNNING AT A DIAGONAL TOWARDS THE OUTER EDGE OF THE WINDSHIELD.

Mileage: 19,500

ON NOVEMBER 18 WE WERE DRIVING ALONG INTERSTATE 10 WHEN A CRACK APPEARED IN THE WINDSHIELD. THERE IS NO EVIDENCE OF A ROCK HITTING ALTHOUGH WE CAN'T SAY DEFINITELY WHETHER IT DID OR DID NOT

Mileage: 24,400

DRIVING ON THE HIGHWAY EARLY IN THE MORNING, NO OTHER CARS AROUND, HEARD A LOUD POP FOLLOWED BY A LARGE UPSIDE DOWN "L" CRACK COMING FROM THE BOTTOM.

Mileage: 22,000

I HAD DIFFICULTY SEVERAL TIMES REMOVING THE KEY FROM THE IGNITION. THE LAST TIME THIS HAPPENED, I WAS ABLE TO REMOVE THE KEY, BUT THE CAR DIED. I CALLED THE DEALER AND THEY GAVE ME THE LOCAL TOWING COMPANY. NAPLETON SUBARU KEPT THE CAR FOR TWO DAYS AND COULD NOT FIND ANYTHING WRONG WITH IT. I HAVE BEEN AFRAID TO DRIVE THE CAR ON THE HIGHWAY, OR GO TOO FAR FROM HOME.

THE WINDSHIELD DEVELOPED A CRACK WHILE THE VEHICLE WAS PARKED. THERE WAS NO DAMAGE FROM THE ROAD OR OTHER SOURCES. THIS PROBLEM HAS BEEN REPORTED BY DOZENS OF OWNERS OF SUBARU OUTBACKS, ESPECIALLY ONES WITH THE SUBARU EYESIGHT SAFETY SYSTEM, WHICH MY VEHICLE HAS.

Mileage: 7,500

THE WINDSHIELD DEVELOPED A FISSURE OVER 2 FEET LONG WITH NO KNOWN (VISIBLE OR AUDIBLE IMPACT) I SIMPLY NOTICED IT AS I WAS DRIVING HOME AND IT WAS NOT THERE WHEN I LEFT HOME. IT STARTS IN THE LOWER PASSENGER SIDE UNDER THE BLACK PORTION AND RUNS HALF WAY ACROSS THE WINDSHIELD.

Mileage: 28,000

FRONT WINDSHIELD SPONTANEOUSLY CRACKED FROM TOP OF DRIVER SIDE DOWN BOTH SIDES WHILE SITTING IN HOME DRIVEWAY FOR ABOUT TWO HOURS ON CLEAR, 90 DEGREE DAY. NO IMPACTS NOTED WHILE DRIVING ABOUT 25 MILES EARLIER IN THE DAY, AND NO CHIP IN WINDSHIELD AT APPARENT IMPACT POINT. NOTHING FELL ON THE VEHICLE IN THE DRIVEWAY OR EXERTED PRESSURE ON THE GLASS.

Mileage: 26,200

WHILE DRIVING DOWN AN OPEN ROAD GOING ABOUT 45MPH WITH NO TREES AND NO OTHER VEHICLES AROUND US, OUR SUNROOF EXPLODED. I SAY EXPLODED BECAUSE WE THOUGHT WE HAD BEEN SHOT. IT WAS A VERY LOUD POP AND THEN WE WERE INSTANTLY COVERED IN GLASS. LIKE ALMOST THE ENTIRE SUNROOF WAS NOW IN PIECES AND INSIDE THE CAR. I ACTUALLY GOOGLED "EXPLODING SUNROOF" BECAUSE WE KNEW WE DIDN'T HIT ANYTHING. THERE ARE LITERALLY PAGES OF ACCOUNTS OF THIS HAPPENING AND THERE ARE NUMEROUS MANUFACTURERS LISTED AS HAVING THIS PROBLEM. ANYWAY, SUBARU DID REPLACE IT AND WE DID NOT HAVE TO FILE A CLAIM WITH OUR INSURANCE BUT WE COULD HAVE BEEN SERIOUSLY INJURED IF WE WERE GOING ANY FASTER. THE PREVAILING THEORY IS THAT IN ORDER THE SAVE WEIGHT ON THE AFFECTED VEHICLES, THE FRAME OF THE SUNROOF ISN'T RIGID ENOUGH ALLOWING THE GLASS TO MOVE TOO MUCH WHICH CAUSES THE SPONTANEOUS EXPLOSION.

Mileage: 20,000

WINDSHIELD CRACK APPEARED SUDDENLY ORIGINATING NEAR THE HEATING ELEMENT AT THE BOTTOM .DO NOT SEE ANY VISIBLE ROCK HIT MARKS . DEALERSHIP DOES NOT ACKNOWLEDGE ANY MANUFACTURING DEFECTS AND I HAVE TO GET IT REPAIRED USING MY INSURANCE .

Mileage: 10,500

WINDSHIELD CRACKED WHILE DRIVING ON I-684. THERE WAS NO OBJECT THAT HIT THE GLASS OR SOUND OF ANYTHING HITTING. JUST A CRACK ORIGINATING FROM THE DEICER AREA OF THE WINDSHIELD TOWARDS THE DRIVER'S SIDE AND UP AND TO THE RIGHT THAT APPEARED SUDDENLY. THERE WAS NO ADVERSE WEATHER AND THE CAR WAS OPERATING AS NORMAL. THE DEFROSTER WAS ON AT THE TIME.

REAR VIEW MIRROR BROKE LOOSE FROM WINDSHIELD WHILE BEING ADJUSTED. VEHICLE STATIONARY, VEHICLE OFF, PREPARING TO DRIVE AFTER BEING PARKED DURING THE WORK DAY. A CHUNK OF GLASS REMAINED ATTACHED TO THE BASE OF THE MIRROR. VEHICLE HAS LESS THAN 600 MILES ON IT AND THE MIRROR HAD NOT BEEN SUBJECTED TO ANY ABNORMAL FORCES. BALL SOCKETS ON MIRROR SUPPORT SEEM VERY TIGHT.

Mileage: 600

WINDSHIELD CRACK ON A 2016 SUBARU OUTBACK LIMITED WITH EYESIGHT, PURCHASED NEW IN APRIL 2016 AND CURRENTLY HAS 2,200 MILES ON IT. WENT TO RUN A QUICK ERRAND, DID NOT NOTICE ANYTHING UNUSUAL. ON THE WAY HOME WHILE DRIVING IN A RAINSTORM, I NOTICED A 6" CRACK ON THE DRIVER'S SIDE WINDSHIELD. THE CRACK RUNS FROM THE EDGE OF THE DRIVER'S SIDE, ABOUT 1/3 UP FROM THE BOTTOM AND ABOUT 4' IN TOWARD THE CENTER. THE CRACK HAS GROWN TO ABOUT 18 INCHES OVERNIGHT. THERE IS EVIDENCE OF A SMALL CHIP IN THE GLASS, BUT NOTHING I WOULD EXPECT TO CAUSE A CRACK AND I DON'T RECALL ANYTHING IMPACTING THE WINDSHIELD. THIS CRACK ONLY AFFECTS THE OUTER GLASS AND DOES NOT PROPAGATE THROUGH THE LAMINATION INTO THE INNER GLASS. THERE IS EVIDENCE OF DELAMINATION OF THE GLASS IN THE AREA ADJACENT TO THE CRACK. THIS IS A WIDE CRACK. I MEASURED 0.009" IMMEDIATELY ADJACENT TO THE CHIP DAMAGE ALL THE WAY TO THE EDGE OF THE GLASS WITH A STARRETT MODEL 66 THICKNESS GAGE. IT SEEMS THE OUTER GLASS MAY BE SUBJECT TO TENSION IN THE "AS INSTALLED" CONDITION AS EVIDENCED BY THE OPENING OF THIS CRACK. THIS MAY CONTRIBUTE TO THE APPARENT DAMAGE INTOLERANCE OF THE WINDSHIELD. PICTURES OF THE DAMAGE AND MEASUREMENT ARE ATTACHED.

Mileage: 2,200

CAR HAD 2578 MILES ON IT. WHILE PARKED OVERNIGHT WINDSHIELD CRACKED STARTING AT PASSENGER SIDE AND EXTENDING APPROXIMATELY 12 INCHES TOWARD DRIVER SIDE. WENT IMMEDIATELY TO THE LOCAL SUBARU SERVICE DEPT AND THEY DETERMINED THAT IT WOULD BE COVERED UNDER WARRANTY DUE TO NO EVIDENCE OF A STRIKE CAUSING IT. WINDSHIELD WAS REPLACED WITH SUBARU BRANDED PART 6 DAYS LATER THROUGH SUBARU BUT BY THEN THE CRACK HAD GROWN TO APPROX. 18INCHS.

Mileage: 2,578

SECOND WINDSHIELD CRACK IN 10 DAYS. WHILE DRIVING ON INTERSTATE IN THE RAIN, I TURNED ON THE FRONT DE-FOGGER. APPROX 20 SECONDS LATER THE WINDSHIELD CRACKED FROM THE CENTER BOTTOM UP AND TOWARD THE DRIVERS SIDE. CRACK CURRENTLY EXTENDS UP ABOUT 8 INCHES. AS BEFORE, THERE WAS NO STRIKE THAT CAUSED THIS AND PAVEMENT WAS CLEAN AND SMOOTH. THIS WAS A NEW SUBARU BRANDED WINDSHIELD THAT WAS INSTALLED LITERALLY 4 DAYS AGO. GOING BACK IN TO THE SERVICE DEPT FOR REPAIR AS SOON AS POSSIBLE.

Mileage: 2,750

VEHICLE PURCHASED NEW 2/25/2016. 1990 MILEAGE. CRACKS DEVELOPED WHILE DRIVING AT 70MPH. NO SOUNDS OF STONES HITTING GLASS AT ANY TIME DURING DRIVE. STOPPED TO WASH WINDSHIELD AT GAS STOP. DID NOT NOTICE CRACKS UNTIL LATER IN DRIVE. AC WAS TURNED ON & OFF DURING DRIVE, IF THAT MADE A DIFFERENCE. DRIVEN 500 MILES IN MODESTLY WARM SUNNY WEATHER IN 8 HRS THAT DAY,4/24/2016. CRACK PROGRESSED TO DRIVERS LINE OF SITE WITHIN ONE HOURS TIME. WAS INFORMED BY SUBARU DEALER NOT COVERED BY WARRANTY. REPAIR IS MY EXPENSE.

Mileage: 1,973

WINDSHIELD CRACKED WHILE SITTING IN A PARKING AREA. THERE WAS A SMALL CHIP IN THE DEICER AREA WHERE THE CRACK BEGAN. HOWEVER, IT APPEARS THE STRIKE WAS MINOR AND WOULD HAVE BEEN EASILY REPAIRED BEFORE SPREADING. ALREADY HAD ONE CHIP REPAIRED FOR ANOTHER MINOR STRIKE. WINDSHIELD APPEARS TO BE EXCESSIVELY FRAGILE WHICH COULD RESULT IN A MAJOR SAFETY PROBLEM. DEALER IS WILLING TO REPAIR, BUT I AM CONCERNED ABOUT THE QUALITY OF GLASS BEING USED IN THE SUBARU.

Mileage: 6,000

WINDSHIELD CRACKED WITHIN FIRST 150 MILES/48 HOURS OF OWNERSHIP OF THE NEW CAR. A VERY SMALL PIECE OF GRAVEL HIT THE WINDSHIELD NEAR THE PASSENGER SIDE WIPER BLADE. IT BARELY MADE ANY NOISE. ON ANY OTHER CAR I'VE OWNED, IT LIKELY WOULD NOT HAVE DAMAGED THE WINDSHIELD AT ALL. IT LEFT A STAR ON THE OUTBACK, WHICH TURNED INTO A FOOT LONG CRACK WITHIN 30 SECONDS. SITTING OVERNIGHT THE CRACK DOUBLED IN SIZE. A WINDSHIELD WHICH FAILS UNDER TYPICAL DAY-TO-DAY CONDITIONS IS NOT ACCEPTABLE.

Mileage: 150

I BOUGHT A 2016 SUBARU OUTBACK ON MARCH 5TH, 2016. AFTER TWO WEEKS I TOOK A TRIP DOWN TO ATLANTA AND BACK TO KNOXVILLE, TN. I WAS DRIVING ON I-75 AND GOING 70MPH. I HEARD NO SOUND NOR DID I SEE A ROCK OR DEBRIS HIT MY WINDSHIELD, BUT ALL OF A SUDDEN I SAW A CRACK APPEAR. WITHIN AN HOUR OF HOME THIS CRACK GREW FROM ABOUT 3 INCHES TO 5 INCHES. I CALLED SUBARU OF AMERICA AND ALL THEY TOLD ME WAS 'CRACKS HAPPEN.'

Mileage: 1,000

THE DAY AFTER DRIVING THE NEW CAR HOME FROM THE DEALERSHIP, A CRACK APPROXIMATELY 12 INCHES IN LENGTH APPEARED IN THE WINDSHIELD. THE CRACK WAS NOT NOTICED UNTIL THE VEHICLE WAS STATIONARY AND HAD NOT MOVED FOR ABOUT 24 HOURS. THE CRACK STARTED AT THE EXTREME EDGE OF THE WINDSHIELD ON THE PASSENGER SIDE TOWARD THE TOP AND CURVED DOWN.

Mileage: 125

WHEN DRIVING ABOUT 60MPH ON A SMOOTH FLAT HIGHWAY, A SMALL CLICK WAS HEARD. DIDN'T THINK ANYTHING OF IT AT FIRST. AFTER ABOUT 10 MORE MINUTES OF DRIVING I HEARD A LOUD POP. A 8 INCH VERTICAL CRACK STARTED ON THE WINDSHIELD. IT STARTED LOW, BY THE WIPERS, AROUND THE MID-LINE OF THE WINDSHIELD. THE CRACK HAS CONTINUALLY GROWN AND IS NOW RUNNING HORIZONTALLY ACROSS THE DRIVER-SIDE.

Mileage: 11,000

WHILE THE CAR WAS GARAGED WITH THE GARAGE DOOR CLOSED, IT DEVELOPED AT ROUGHLY 12" CRACK RUNNING FROM THE RIGHT (PASSENGER SIDE) PILLAR. THERE IS NO ROCK STRIKE OR OTHER IMPACT, NOR HAD THERE BEEN ONE PRIOR TO IT BEING GARAGED. IT DEVELOPED OVERNIGHT.

Mileage: 2,100

DURING A RECENT TRIP TO FLORIDA, THE FRONT WINDSHIELD ON MY NEW 2016 SUBARU OUTBACK DEVELOPED OVER HALF A DOZEN SMALL PITS IN THE EXTERIOR GLASS SURFACE FROM CONTACT WITH VERY TINY PEBBLES. THE TINY PEBBLE STRIKES SHOULD NOT HAVE CAUSED SUCH PITS BASED ON MY EXTENSIVE DRIVING EXPERIENCE. I BELIEVE THERE TO BE A DEFECT IN THE GLASS ITSELF, MAKING IT UNUSUALLY BRITTLE. THE PEBBLE STRIKES OCCURRED WHILE DRIVING AT LOW SPEEDS ON HIGHWAY OFF RAMPS. THE TEMPERATURE OUTSIDE DURING THE PEBBLE STRIKES, WHICH TOOK PLACE OVER SEVERAL DAYS OF DRIVING, RANGED FROM 60 TO 85 DEGREES F. THE DEALER EXAMINED THE WINDSHIELD AND SAID THERE WAS NOTHING INFERIOR ABOUT IT.

Mileage: 2,000

I WAS DRIVING ON THE HIGHWAY AND HEARD THE WINDOW CRACK (POSSIBLY A SMALL PEBBLE, BUT NOT A ROCK SOUND) AND SAW A CRACK ON THE DRIVERS SIDE WINDOW THAT EXTENDED TO NEAR THE LANE DEPARTURE SYSTEM. I DISABLE THE LANE DEPARTURE SYSTEM OUT OF CAUTION. WHEN I STOPPED I FOUND A TINY PIT LIKELY FROM A SMALL ROCK/PEBBLE NEAR THE EDGE OF THE WINDSHIELD. IT SEEMS LIKE IT FORMED A CRACK VERY EASILY WITH NO NOTICEABLE IMPACT..

Mileage: 5,200

NON COLLISION OR OTHER VEHICLE DAMAGE CRACK IN WINDSHIELD. A CRACK APPEARED ON THE PASSENGER SIDE OF THE WINDSHIELD. ACCORDING TO OWNER WEBSITE THIS IS AN ONGOING PROBLEM OF WHICH SUBARU IS AWARE FOR THE 2015 AND 2016 MODEL YEARS. THEY OCCASIONALLY COVER THE REPAIR UNDER WARRANTY CLAIMING THEY DO SO AS A "COURTESY" CAR WAS STATIONARY, PARKED IN GARAGE ENGINE OFF. WINDSHIELD JUST CRACKED

Mileage: 2,800

I JUST PURCHASED A 2016 OB 2.5I PREMIUM. I HAVE HAD THE CAR FOR A WEEK AND A HALF. ON FRIDAY I DECIDED TO WASH MY CAR FOR THE FIRST TIME. I STARTED ON THE DRIVERS SIDE, RAISED THE DRIVERS SIDE WIPER, WENT AROUND THE FRONT OF THE CAR AND RAISED THE PASSENGER SIDE WIPER. I THEN WASHED AROUND THE CAR. WHEN I WENT TO PUT THE DRIVERS SIDE WIPER DOWN IT HIT THE PASSENGER SIDE WIPER AND SLAPPED IT DOWN ONTO THE WINDSHIELD. AN HOUR LATER I NOTICED A CRACK COMING FROM THE PASSENGER SIDE. I DID THE "PEN TEST" AND FOUND A SMALL DEPRESSION UNDER THE WIPER. NO ROCK HIT MY WINDSHIELD, IT WOULD HAVE HAD TO PASS THROUGH THE WIPER. THATS IMPOSSIBLE. BECAUSE I WAS JUST FREAKING AMAZED THAT IT COULD OF HAPPENED I RAISED THE PASSENGER WIPER AND LET IT COME DOWN ON THE WINDSHIELD TO SEE WHAT WOULD HAPPEN. IT PUT A SECOND CRACK IN THE WINDSHIELD, NOT ONE EMANATING FROM THE FIRST BUT A WHOLE NEW CRACK. IM TAKING IT TO MY DEALER TOMORROW.

Mileage: 225