2003 SUZUKI SV1000 Problems & Recalls

FLYWHEEL MAGNETS SHIFTED AND CRACKED. PIECES OF THE MAGNET ARE ALL OVER THE INSIDE OF THE ENGINE. STATOR IS SCRATCHED. FOUND OUT BECAUSE OF VIBRATION AT LOW RPM AND BIKE NOT HOLDING A CHARGE. *TR

Mileage: 23,000

THE CHARGING SYSTEM MAGNETS DETACHED FROM THE FLYWHEEL/ROTOR (INTERNAL TO THE MOTOR), CAUSING AN ISSUE WHERE THE CHARGING SYSTEM WAS NOT FUNCTIONING PROPERLY. THIS IS A SAFETY ISSUE BECAUSE THE MAGNETS COULD HAVE BECOME DISLODGED ENOUGH TO CAUSE A CATASTROPHIC AND IMMEDIATE ENGINE SEIZURE/FAILURE...

Mileage: 22,023

THE CHARGING SYSTEM MAGNETS DETACHED FROM THE FLYWHEEL/ROTOR (INTERNAL TO THE MOTOR), CAUSING AN ISSUE WHERE THE CHARGING SYSTEM WAS NOT FUNCTIONING PROPERLY. THIS IS A SAFETY ISSUE BECAUSE THE MAGNETS COULD HAVE BECOME DISLODGED ENOUGH TO CAUSE A CATASTROPHIC AND IMMEDIATE ENGINE SEIZURE/FAILURE...

Mileage: 22,023

MY SV1000 HAS EXPERIENCED PROBLEMS WITH ITS CHARGING SYSTEM THAT AFFECTS THE ENTIRE ENGINE. I CAME TO FIND IT WAS A HEAVILY DOCUMENTED ON PUBLIC ONLINE FORUMS SUCH AS SV-PORTAL.COM AND HAS AFFECTED ALMOST ALL SV1000 OWNERS. THE MAGNETS, WHICH ARE GLUED TO THE INTERIOR OF THE STATOR ROTOR, BREAK ...

Mileage: 25,000

MY SV1000 HAS EXPERIENCED PROBLEMS WITH ITS CHARGING SYSTEM THAT AFFECTS THE ENTIRE ENGINE. I CAME TO FIND IT WAS A HEAVILY DOCUMENTED ON PUBLIC ONLINE FORUMS SUCH AS SV-PORTAL.COM AND HAS AFFECTED ALMOST ALL SV1000 OWNERS. THE MAGNETS, WHICH ARE GLUED TO THE INTERIOR OF THE STATOR ROTOR, BREAK ...

Mileage: 25,000

MY SV1000 HAS EXPERIENCED PROBLEMS WITH ITS CHARGING SYSTEM THAT AFFECTS THE ENTIRE ENGINE. I CAME TO FIND IT WAS A HEAVILY DOCUMENTED ON PUBLIC ONLINE FORUMS SUCH AS SV-PORTAL.COM AND HAS AFFECTED ALMOST ALL SV1000 OWNERS. THE MAGNETS, WHICH ARE GLUED TO THE INTERIOR OF THE STATOR ROTOR, BREAK ...

Mileage: 25,000

1. BIKE WOULD COMPLETELY GO DEAD WHILE RIDING, GAUGES GO BLACK AND BIKE WILL NOT CRANK. IT HAPPENED ON MULTIPLE OCCURRENCES 2. PROBLEM WAS A TOTAL LOSS OF ELECTRICAL POWER, THIS MEANS NO LIGHTS, NO IGNITION, NO GAUGES, LIKE IF SOMEONE HAD TURNED OFF THE IGNITION SWITCH. 3. I TROUBLE SHOT THE PRO...

Mileage: 12,000

DT: THE CONTACT S OWNS A 2003 SUZUKI SV-1000S MOTORCYCLE. WHILE ATTEMPTING TO START THE MOTORCYCLE THE INDICATOR LIGHTS CAME ON, AND THEN THE MOTORCYCLE LOST POWER. THE MOTORCYCLE WAS TOWED TO A DEALER, AND THEY REPLACED THE WIRE FROM THE HARNESS TO THE IGNITION SWITCH. THIS SEEMED TO REMEDY TH...

Mileage: 6,300

MY 2003 SUZUKI SV1000S STARTED RUNNING POORLY AFTER I FILLED UP THE GAS TANK ON 9/10/2005. INITIALLY I THOUGHT I HAD BAD GAS. I TOOK THE BIKE TO THE DEALER AND THEY CHECKED IT AND FOUND THERE IS A CRACK IN THE TANK. THE DEALER SAID THE CRACK IS NEAR THE FUEL VAPOR SEPARATOR. THIS PART IS ONLY INS...

Mileage: 10,900

MY 2003 SUZUKI SV1000S STARTED RUNNING POORLY AFTER I FILLED UP THE GAS TANK ON 9/10/2005. INITIALLY I THOUGHT I HAD BAD GAS. I TOOK THE BIKE TO THE DEALER AND THEY CHECKED IT AND FOUND THERE IS A CRACK IN THE TANK. THE DEALER SAID THE CRACK IS NEAR THE FUEL VAPOR SEPARATOR. THIS PART IS ONLY INS...

Mileage: 10,900

THIS COMPLAINT IS IN REFERENCE TO MY 2003 SUZUKI SV100S,CALIFORNIA MODEL[XXX]. I AM THE ORIGINAL OWNER AND THE BIKE HAS 23,000 MILES ON IT NOW. THE PROBLEM IS WITH FUEL LEAKING FROM A SPOT WELD ON THE BOTTOM OF THE FUEL TANK. I HAD THE ORIGINAL TANK REPLACED LAST YEAR UNDER THE EMISSIONS WARRANTY...

Mileage: 15,000

WHILE RIDING THE MOTORCYCLE THE ELECTRONICS AND ENGINE BEGAN TO CUT-OUT INTERMITTENTLY. UPON INSPECTION, IT WAS FOUND THAT THE CONNECTOR BETWEEN THE IGNITION SWITCH AND THE IGNITION RELAY HAD MELTED AND WAS SHORTING OUT. THE FUSE ON THE CONNECTION DID NOT BLOW. THERE WAS NO MOISTURE PRESENT OR OTHER...

Mileage: 10,900

MY 2003 SUZUKI SV1000S MOTORCYCLE HAD AN INTERMITANT TOTAL POWER(ELECTRICAL) FAILURE THAT WOULD RESULT IN THE BIKE COMPLETELY SHUTTING OFF. BIKE WAS BROUGHT TO A LOCAL DEALER AND THEY COULD NOT DUPLICATE THE PROBLEM. THE DEALER REPLACED THE BATTERY UNDER WARRENTY AND ADVISED ME THAT SOMETIMES THE BA...

Mileage: 5,500