2022 TESLA MODEL X Electrical System Problems

The vehicle presents a compounded safety defect creating a risk of passenger entrapment and high-voltage fire. 1. High Voltage Manufacturing Defect: On September 3, 2024, authorized Tesla Service technicians diagnosed a critical safety fault. The service record states technicians 'found A/C compressor HV harness was incorrectly routed, rubbing against the steering column' and 'found sand inside the connector'. Tesla repaired this defects under the 'Basic Vehicle Limited Warranty,' confirming it was a factory assembly error. This defect created an imminent risk of a high-voltage short to the steering column, which could result in driver electrocution or total vehicle power loss at speed. 2. Passenger Entrapment: The vehicle has a documented history of Rear Falcon Wing Door failure (7 repair attempts from April 2023 to May 2025). The doors frequently fail to latch or open. On July 8, 2025, the Left Rear Door failed to open due to a sensor fault. 3. Combined Hazard: If the incorrectly routed High Voltage harness causes a vehicle power failure, the rear doors' electronic latches will fail. Because the doors have a history of mechanical jamming, passengers in the rear seats would be trapped in a vehicle with a compromised High Voltage system.

I had my two Teslas parked in the garage. The model X was charging at about 1:30 AM. We heard explosions coming out of the garage. Went to check only to see my model X in flames. We evacuated and called 911 eventually a fire investigation report was made Showing the fire started within the vehicle outward. The battery pack was on fire. We had lithium contamination all over the house and this fire endangered five lives. This incident has been two years ago and until now Tesla refuses to acknowledge the faulty battery and is refusing to do anything about it

" PASSANGER SAFETY RESTRAINT SYSTEM FAULT" IS THE WARNING MESSAGE POPPING UP ON THE DISPLAY WE NOTICED THAT THE WARNING LIGHT SOMETIMES GOES AWAY WHEN MOVING THE PASSANGER SEAT, WE FIRST TOUGHT THAT THIS WAS JUST A PROBLEM THAT WE MAY HAVE CAUSED BUT ONCE DOING REASERACH WE NOTICED THAT THERE ARE MANY ONLINE SCENERIOUS THAT HAVE THE SAME ISSUE "PASSANGER SAFETY REISTRAINT FAULT" WE DISSMISSED THE ISSUE WE TOOK IT TO TESLA SERVICE IN JACKSONVILLE FLORIDA THEY MENTIONED THAT SOME WIRE PIN HAD CAME LOOSE WHICH WE THOUGHT WAS ODD SINCE WE HAVE OWNED OVER 20 VEHILES AND WE HAVE NEVER HAD THIS ISSUE WITH ANY OTHER MANUFACTURE. WE WERE CHARGED 300+ DOLLARS FOR THEM TO FIND THEB EXCAT PIN/ WIRE THAT CAME LOOSE. WE ALSO HAVE A 2020 TESLA MODEL 3 STANDER RANGE, WE RECENTLY HAD THE SAME ISSUE AND THE WARNING LIGHT IS CURRENTLY ON AND GOES AWAY IF WE MOVE THE PASSANGER SEAT. I HAVE COME TO CONCLUDE THAT THIS IS A MANUFACTURE DEFECT THAT CAN BE A SERIOUS ISSUE IF AIR BAGS ARE NOT PROPERLY WORKING CAUSING SERIOUS INJURY TO PASSANGERS IN THE VEHICLE I WILL ATTACH THE VIN OF OUR 2020 TESLA MODEL 3 STANDER RANGE [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Tesla stopped in the middle of a 4 way intersection without notice. As I was turning left, the car started to shake for about 2 seconds and then stopped. No warning or anything. The notification stated "electrical system unable to support functions." My safety was put at risk and others. I was traveling with my 11 month old and other cars could have hit my car if they were not paying attention when coming through the intersection. The car was towed to the Tesla dealership. No warnings prior to the failure. Warnings appeared after the car stopped.

This vehicle has massive and unbearable static electrical shock when the car stopped and trying to close the door as metal body of the car. and I have several Videos showing the electric shocks The auto pilot stop the vehicle on the highway for no reason that’s put the passenger in serious rear collision

The horn is a small button on the steering wheel instead of the larger pad in the center of the steering wheel. When making turns or complex maneuvers the horn is not easily found since the steering device is turning. This is a safety issue that needs to be addressed.

Bran new Tesla Model X 2022 model went up in flames in my garage on it is own, burning my garage, and destroying my other tesla. the car melted completely and Tesla Warranty is no where to be found, they are not even talking to me after 8 weeks of the incident and as of this date filing this complaint. The Car was purchased directly from Tesla, Brand New, owned it less than 14 months and had less than 30,000 miles on it.

As I was trying to make a turn into the parking lot of a convenient store, my Tesla Model X started accelerating suddenly and unintendedly without my foot being on the accelerator. I kept pressing on the brake to stop the car, but it would not stop. I had no control and while it accelerated for 15-20 yards eventually it hit two other cars that were parked there. This happened so quickly. We all were terrified and shocked as I could not stop it from accelerating. I kept yelling "it is not stopping" to the person seating on the passenger side. I am confident that I did NOT press the accelerator pedal. The car was not on autopilot. My initial speed was probably 5 miles/hour, but it accelerated so suddenly that four airbags deployed, and the car is not drivable. Insurance company is evaluating whether the car is repairable, but I am afraid of driving with this car again until the problem is found and fixed. This could have turned to a major tragedy.

The contact owns a 2022 Tesla Model X. The contact received notification of NHTSA Campaign Number: 23V085000 (Steering, Electrical System) however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

In all late 2021 and 2022 Model S and X cars from Tesla, the manufacturer removed the left and right stalks for a) directional signals b) wiper controls c) forward/reverse/park controls and also made it nearly impossible to use the horn, with only a tiny button to sound the horn. The driver is forced to remove their eyes from the road to a) turn on left or right directional signals b) choose forward or reverse c) turn on window washers d) turn on wipers when they fail to turn on automatically and e) press the horn. AT NO TIME SHOULD A DRIVER HAVE TO REMOVE THEIR EYES FROM THE ROAD TO DO THESE FUNCTIONS. Traditionally, any driver could use a left or right hand without removing eyes from the road and use any such control. This is not possible.

The 2021-2022 model X “yoke” steering wheel is poorly conceived and a safety hazard. 1) horn location is tiny, and moves as wheel turns, impossible to quickly activate horn in emergency situations 2) high Beam lights are on a tiny button which also moves and cannot be activated when wheel turns or in an emergency situation, or even when choosing to cross an intersection during a yellow light because a car behind you is tailgating. 3) wheel shape: when used at lower speeds in autopilot Beta mode, the electronics literally rip the wheel out of your hands when turning right on residential streets. It is impossible to maintain hands on the wheel without risk of personal injury during some autopilot beta turns. Safety of the vehicle would be returned if the prior 2017-2020 round wheel with turn signal, wiper control, and gear selector stalks returned. The inability for the driver to control following distance in the ADAS (cruise control) systems without dropping 3 levels down into on screen menus is also unsafe.

Malfunctioned components and systems: 1) Outdated feed from the backup camera. No signal from the side cameras. Reproduced multiple times. 2) False input from physical controls. Reproduced multiple times for the left wheel button on the yoke (scroll up and press) and the honk button on the yoke. 3) False signal from proximity sensors. 4) False signal from open door sensors. 5) Spontaneous activation of autonomous parking (when disabled in the settings). 6) Spontaneous activation of the service mode. The vehicle shows: "Do not drive. Improper use may cause damage or injury." 7) Brake fault. Reproduced multiple times. 8) Parking brake fault. Reproduced multiple times. 9) Steering assist fault. 10) High-voltage system fault. 11) Spontaneous computer restart. Available for inspection before 5/5/2022. Safety concerns: 1) The outdated feed from the backup camera almost led to an accident on 03/26/2022 at ~3:09 pm when another vehicle was shown at a distance, but it was actually right behind the vehicle. 2) False signal from proximity sensors on 04/17/2022 at 10:35 pm likely caused a false accident avoidance maneuver toward leaving the drivable surface at a high speed with no vehicles in proximity (video is available by request). 3) Spontaneously increased volume on 04/17/2022 at 12:00 pm distracted the driver and could damage the ears. It couldn't be counteracted by the driver's input due to the fast false input and the persistence of the problem (the volume increased and the playback resumed). 4) False input from physical controls may potentially lead to an uncontrollable vehicle. 5) Spontaneous activation of autonomous parking may potentially lead to an uncontrollable vehicle. The problem was reported to Tesla on 3/26/2022 (two days after the delivery of the vehicle). The vehicle was inspected and the problem was confirmed by Tesla Service on 4/5/2022. They recommended installing a software update that didn't resolve any of the reported issues. Tesla has issued a safety recall with NHTSA Recall No. 22V-296 and M

While driving the electronic systems that monitor the brakes as well as traction control malfunction. It happened multiple times. At one point, the steering wheel was not operable. The brakes became inoperable. I had it towed to the Tesla service center where they said they corrected it. However, upon getting the car back it happened again. Car is very unsafe to drive when all systems shut down.