2023 TESLA MODEL Y Steering Problems

While driving approximately 5–10 mph and making a right turn on a local street, the vehicle suddenly produced a metallic pulling sound followed by a loud impact. The vehicle abruptly stopped and became undrivable. Upon exiting the vehicle, the left front wheel was visibly displaced from normal alignment and appeared to have shifted rearward into the wheel well. No collision, curb strike, pothole, or road debris was involved. The vehicle had exhibited a wire-tugging or metallic noise during turning in the days prior. The failure occurred without warning and resulted in a sudden loss of vehicle control at low speed. The vehicle was towed to Tesla, where the left front control arm was found to be disconnected/broken. Tesla has not yet provided a determination and is attempting to route the vehicle to a collision center despite no evidence of impact. This appears to be a suspension component failure that could have resulted in a serious accident at higher speeds. Safety Impact: Loss of steering control, risk of crash, inability to drive vehicle.

While traveling at highway speeds, the vehicle suddenly veered to the right without driver input. The Autopilot/FSD system was not engaged. It all happened in a matter of seconds. There was no system failure message on the screen. The vehicle airborne and hit a tree. All side airbag were deployed. Was able to open the door and walk away without any major injuries. Software update : 2025.44.25.5

All in the same day: 1) Odd sound from behind the pedal area of driver side front quarter (sounded like a styrofoam cooler top rubbing against the cooler is the best way to describe - faint though). 2)BANG when in a parking garage turning full right but still able to control without difficulty. Made it home without incident. 3)Later that day, just after getting off of I4 in Orlando I pulled into grocery parking lot and parked. When I returned to my car I again turned right and a loud BANG and the car jerked to a sudden halt. I was able to back into a parking spot but there were 2 large screws in the driving land and the left wheel was toed slightly to the left. Ultimately it was detached when we tried to tow it we had to remove tire and put on a device to allow us to move it. Per Tesla “I have updated that estimate! The vehicle has very heavy damage, and this is the start. Once we replace these components their (sic) could be more damage, and it also could potentially need to go to a body shop!” Thankfully this didn’t happen at speed with my daughter in the car on I4! This is unsafe and a simple internet search revealed it is not an uncommon parts failure at this mileage! This is dangerous. All of this at just 54,000 miles. (4k out of warranty)

I was driving on the highway at around 70mph, switched lanes and the steering wheel randomly locked up. Gladly, I was aware of the situation and avoided a HUGE car crash but the steering started to work a few seconds later. I am very nervous to drive the car now.

I am writing to file a complaint regarding a safety issue with my 2023 Model Y Performance Tesla vehicle. The steering wheel's faux leather covering is peeling and bubbling, causing the material to come off while driving. This poses a significant hazard as it compromises my grip and creates a distraction, potentially leading to loss of control. Additionally, Tesla does NOT want to repair this, even though I’m still under warranty.

My Model Y experienced a sudden steering assist failure while driving. The wheel became extremely stiff/locked even though Autosteer was off. Multiple thermal system faults appeared: VCRIGHT_a271_THSSensorFault, VCRIGHT_a257_THSMIA, GTW_w043_THSVersionMismatch, and HVACSystemNotNominal This was very scary as I was driving and had no control of steering wheel because it locked.

Currently on the newest Tesla Full Self Driving software v14.1.4, it is phantom breaking as well as phantom swearing out of nowhere. It is swerving and using the breaks so hard it actually affects the steering wheel and self disengages it's self (without the big-loud safety alert to immediately take over control), it just does the soft disengage audio notification, like if you wanted to cancel FSD yourself. The serious problem is that the car does not stop like it should, instead it just continues it seems like it just neutrally rolls on its own drive and twice in the last week it would swerve directly into oncoming traffic. It is not supposed to be doing this at all, especially now that the "hands off" approval is enacted. I drive about 450 miles a week and this has happened about twice a week for the last two weeks. Thank god i was paying attention all four times, but I am so worried this is going to kill someone. I have tried to call TESLA but they purposely don't staff their phones and no one answers.

While driving home from a shop, my Tesla Model Y suddenly stopped in middle of busy road and became unable to move forward. I had to press the accelerator hard, which caused a loud noise before the car moved slightly and I was able to pull over to side of road. I narrowly avoided being hit by another car. Upon inspection, it was found that front tire connecting rod and suspension had failed, causing rod to drop off. The tow truck who assisted me mentioned that this is common issue with Tesla vehicle. This was a terrifying experience and I feel extremely fortunate to have escape an accident. My vehicle is less than 24 months old and I am deeply concerned about the safety and reliability of this component . I strongly urge Tesla to issue a recall and investigate this defect. There is no assurance that this failure won’t happen again. And this is scary

The bolt that holds the front lateral link portion the the lower control arm to the subframe fell out while driving. I lost the ability to steer the car and had to stop immediately and have the car towed. In searching the internet this is a know issue by Tesla but has not been recalled.

During normal driving on Sat Sep 27 2025, unusual noises started to come from the front left wheel. There were no warning lamps or messages, and no indication of issues prior to onset of the noise. I had the vehicle towed to a Tesla Service Center the following day. Tesla's technicians found that the front lateral link bolt on the left hand side had backed out and fallen out of the subframe. They determined that the cause was related to improper torque specification or application of the original bolt. They reached this conclusion in part because the passenger side lateral link to subframe bolts were also under-torqued. Rear bolts were not affected. Tesla has replaced the front lateral links on both sides with new bolts. There was no vehicle accident or damage, so there has been no involvement or inspection by police or insurance. It is fortunate that this issue began when the vehicle was traveling at low speed, and that I chose to have the vehicle towed to the service center rather than driving it. The bolt has loosened when the noise started, and finally fell out at the service center. Had I been driving at highway speeds when the bolt fell out, I could have lost control of the car and injured myself and others. Online research suggests this is not an isolated incident for this model of car.

I picked up my son from school and got home at about 3:30 PM on Sunday 9/21/2025. My son got out of the car and I heard a “clicking” sound when turning my steering wheel to the left to prepare for backing into my garage. There were no warning lights or messages for this issue. I did get out of my car and checked, but did not see anything that hit my car underneath. I got back in my car and continued backing my car into the garage. The nightmare started happening - The bolts connecting the front control arm and steering knuckle fell off that caused the left “arm” disconnected from the steering knuckle. This had resulted a sudden total loss of steering control. Please see attached photos. I could not imagine if this would have happened on the freeway.

Two days ago a warning popped up on the Tesla screen saying to schedule service for something the car had detected. It said the car could still be driven. I submitted a service request in the app, and in the meantime researched the error. Per Google, it said this was a potential issue with suspension / steering components that needed to be looked at. The next day, a Tesla technician called and asked what my appointment was for. I told him about the error and that I had found it said it was for a suspension or steering issue. He told me I was wrong, and that it was only for low tire pressure. The car did not have low tire pressure. He said the appointment wasn't needed, cancelled the appointment, and told me to drive 30-40 miles to clear the error. Literally 5 hours later, after my wife driving my kids down the freeway, when parking on the street in front go my house the car made a giant pop and the front left sank. We looked under the car and the front drivers side control arm had completely disconnected, popping straight down towards the road. More concerning, two bolts popped out, not broken, but just clearly loose and had finally unscrewed. You will see them on the ground in the pictures. If this had happened 5 minutes earlier while on the freeway I don't want to even think about what might have happened. These cars should be recalled, this is super dangerous. Not to mention the fact that Tesla explicitly canceled my appointment for this and told me not to bring the car in.

Incident Details: • Date/Time: [XXX]. • Location: [XXX] • Event: While driving, the front left wheel partially detached without warning, causing an immediate loss of steering control. Findings (third-party technician at the scene): • The wheel/control arm/linkage had come loose/detached. • Two major suspension bolts were extremely loose or had detached. • A rotor screw detached easily during inspection. • Photos, videos, and witness statements are available upon request. Current status: Tesla has not provided a failure analysis or demonstrated that the issue is resolved. Similar failures have been reported on social media, and recalls between 2021–2023 addressed front suspension lateral link fasteners that could loosen or detach. “A 2021 recall (NHTSA Recall #21V835) affected Model 3s from January 2019-April 2021 and Model Ys from March 2020-June 2021. A 2022 recall (NHTSA #22V895) was for certain 2023 Model Ys with issues on the left-hand lateral link. “ My vehicle has not been included in any such recall, and I received no prior notification. Supporting documentation (emails, service records, publications) is available upon request. Risk Level: Extremely high. This defect creates a severe danger to drivers, passengers, and the public. Tesla’s lack of corrective action leaves many customers at risk. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

According to TESLA service, my two "lateral links" for the front wheels need to be replaced. They sent us photos of the issue and it looks like one of the fasteners for one of the lateral links was missing (1 of two fasteners) If the other fastener failed/fell out the car could easily steer out of control. The problem of the lateral links was confirmed by Tesla servicing. They are repairing it under warranty. It was only been inspected by the manufacturer, Tesla. There were no warning lamps. The only indication was the thumping sound during turns.

I am writing to report severe safety concerns involving my Tesla Model Y. Without any accident or impact, my vehicle experienced a mechanical failure on [XXX}, when the front left tire detached, making the car immobile. The vehicle had approximately 31,500 miles and no prior damage or accident history. Tesla towed the car for repairs. However, during the repair process, I discovered that the vehicle was transferred to a body shop in Chantilly, VA, without my prior knowledge or consent. When I visited the shop to retrieve personal belongings, I was shocked to see that the condition of my vehicle had significantly worsened. The technician informed me that the car now had serious structural damage, including a twisted frame and extensive paint damage. This damage did not exist before and was not caused by an impact. The technician indicated that repairs would take at least a week if only bodywork was addressed. Most concerning, the vehicle was transferred with no visible damage, yet now has severe structural issues. Tesla has suggested replacing the damaged body parts later, which makes no sense given that the car was in a safe condition prior to the transfer. Additionally, the front wheel, which detached earlier, was reassembled without impact, but the vehicle remains unsafe. It has taken over 30 days to attempt repairs, and the vehicle still is not fully fixed. I do not feel safe driving it under these conditions. Furthermore, communication regarding the damage has been poor. I was not informed of any body or structural damage before the transfer. Tesla’s recent message asked me to pick up the vehicle, stating they will order parts later, which is confusing and concerning. Given the extensive damage, delays, and safety risks, I request the NHTSA investigate these issues. I also urge Tesla to buy back my vehicle so I can use the credit toward purchasing a new Tesla, ensuring my safety and confidence. Thank you for your attention to this urgent matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

The contact owns a 2023 Tesla Model Y. The contact stated while driving at an undisclosed speed, there was an abnormal sound coming from the steering wheel, and the electronic power steering was not functioning properly, requiring an increased effort to maneuver the vehicle. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 20,000.

Mileage: 20,000

While driving on the freeway, I heard an unusual noise coming from beneath the battery of my car. Concerned, I drove to a nearby friend's house and parked there, carefully checking my dashboard for any warning signals but finding none. I decided to resume my journey, but as I backed out of the driveway, I heard a sudden noise indicating something had come loose, followed by a crackling sound. Upon inspecting the car, I discovered that the control arm had become detached, the axle had popped out, and two bolts had come off. During the towing process, I noticed that the steering had become extremely tight. To my surprise, I had never received any recall notice from Tesla addressing this issue. Considering that my car is less than two years old, I was deeply disturbed by the situation. This incident has significantly undermined my confidence in the safety of the vehicle, as it highlights a potential manufacturing defect involving defective parts. I regularly use this car to drive my children to their activities, and knowing that this could have led to a catastrophic failure such as tire separation, loss of steering control, or compromised braking capabilities especially on the freeway, is worrying. The car was towed to a dealer and currently in the queue for evaluation by tesla technicians. I requested detailed service report from Irvine service center. There were no warning indicators in the dashboard while I was driving or after the bolts came loose.

Making a right turn and heard a pop sound. Pulled into a parking lot immediately found the steering arm dropped and shortly after a large bolt fell out. There is supposed to be 2 bolts holding up each side, one bolt was already missing. Event occurred without incident. Normal street driving at a low speed turn.

The contact owns a 2023 Tesla Model Y. The contact stated while driving at an undisclosed speed and attempting to complete a left turn, the contact briefly heard an abnormal clicking sound coming from the front end of the vehicle, after which the steering wheel jerked abnormally. The vehicle quickly returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the front-end suspension bushings. The contact was also informed that a bolt on the driver’s side control arm had loosened. The vehicle was repaired. The manufacturer was not notified of the failure. The failure mileage was 54,000.

Mileage: 54,000

The contact owned a 2023 Tesla Model Y. The contact stated that while driving approximately 45 - 50 MPH, the contact lost control of the vehicle. The contact stated that while attempting to regain control of the vehicle and attempting to correct the steering wheel, the vehicle kept going to the right and to the left independently. The contact was unable to regain control of the vehicle. The contact stated that the vehicle struck a railing and a concrete divider with the passenger’s side front bumper and then the rear passenger’s side quarter panel, and the vehicle spun around on the highway and came to a stop. The contact pressed the emergency latch to exit the vehicle out of fear that the vehicle might catch on fire. The contact stated that the rear passenger’s side tire was pushed back due to the impact. There were no warning lights illuminated. The contact stated that all the air bags deployed as designed. The vehicle was towed to a local Collision Center. A Police report was filed. The contact stated that the vehicle was deemed destroyed by the Insurance Provider. The contact sustained injuries to the upper back, left shoulder, right elbow, and neck; however, there were no broken bones reported. The contact received medical attention for the injuries sustained. The local dealer was not contacted, and the vehicle was not diagnosed or repaired. The manufacturer was not yet notified of the failure. The approximate failure mileage was 40,000.

Mileage: 40,000

A suspension rod/bolt fell off my car. When I was making a right hand turn my car began screeching and shaking, I lost control for a second and almost hit another vehicle, luckily I was able to stop my car. I had my car towed to a Tesla service station for repair.

We experienced an extremely dangerous and life threatening situation with Tesla Y model on [XXX] around [XXX] and would like to report to NHTSA. We were driving on [XXX] going towards Nashua and my TESLA-Y car when the steering wheel froze and I got message that front camera was not working. When I tried to steer the car in the lane, the car suddenly braked and took two 360 degree spins (turns) on the highway with cars streaming at high speed around us. We went from the left lane to the right most lane after two 360 degree spins and ended in the right lane. Luckily, no other autos hit us and I was able to take control of the car and pull over in the right lane. The incident is recorded int the Tesla's harddrive which we can make this available to you. the car started working normally so we drove back home. We have had minor control incidents with the lane assist and auto pilot systems of this car in 2023 and 2024. We have complained and showed the problem to Tesla dealer in Watertown, MA. However they said there is nothing wrong with the car. We request you to investigate this incident with Tesla and find out the cause for the car to take this dangerous breaking and spinning incident on a highway. Thanks, [XXX] and [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have had Supervised Full Self Driving in the vehicle for well over a year. I have used the Smart Parking feature Monday-Thursday to park the vehicle at work and it has worked flawlessly. On [XXX] around [XXX], I went to [XXX] . After entering the gate to parking on [XXX], I drove slowly. I was able to select a parking spot and tapped on it on the screen for the selection and then started the automatic parking. There were no other cars around as we were all just starting to enter the gate and park. The car began to move in reverse. It then paused turned the wheel a bit, turned it back, tried to decide what it was going to do and started to move forward. The car then drove up the curb on to the walkway and almost drove into the building. I was able to hit the brake quickly to stop the process. There was no damage to the building or the car. I had never had an issue with the Smart Parking until this time. I then backed the car off the sidewalk and parked it myself. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

UNKNOWN I was driving with no Advanced Driver Assistance Systems (ADAS). My vehicle took control of the steering wheel, swerving uncontrollably, almost hitting approaching cars, and a wooden electricity post. It was diffucult to keep the steering wheel steady. I struggled to pull the vehicle to the side of the road until I made a complete stop. A witness checked on me and was concerned that I had almost crashed.

Knocking noise coming from front left tire when turning, accelerating, and reversing. Investigated noise and found a bolt hanging (unscrewed) from control arm/tie rod and another bolt loose and working it's way loose. If this bolt unscrew, I'm positive steering would be lost. See pictures.

Vehicle was performing normally until I stopped and put vehicle into reverse to back into a supercharger stall. Heard a clunk when starting to back up. Car started to resist moving and front started to lift in the air a few inches. Stopped and went forward to go around and try again. Vehicle would not turn to left when going forward. Got out and noticed front passenger wheel was not aligned with other front wheel. Then noticed tie rod was ripped out of socket.

The driving wheel locked during a turn on back road and ran right into a electricity pole. All air bags deployed and the electricity pole broke. The driver was slightly injured on her forearm.

1. Front Passenger side wheel and auto steering system malfunctioned. Yes it is available for inspection. 2. My car was not drivable and I was stuck on the leftmost lane of highway with fast traffic passing by. Had to call 911 to move myself to safety. 3. Not yet 4. Vehicle has been inspected by the police 5. No warning lamps or message prior to failure

Power steering occasionally cuts out during low speed manoeuvres, such as parallel parking, parking, and turning while stopped. When trying to forcibly replicate the issue (by moving steering wheel lock to lock while doing parking manoeuvres) computer showed codes EPAS3P_a122_olpActive and EPAS3P_a074_overHeatProtect. Tesla says this is "working as designed" and will not fix. I have asked the car to be serviced for this issue twice now. Safety is a concern as the issue is unpredictable and I believe the steering could become difficult suddenly in a situation where it is necessary to move out of the way quickly. (Ie. Stopped in traffic with emergency vehicles incoming)

Two weeks I had my model Y serviced for shaking of the car and steering wheel. They deemed the cause of the shaking due to unalignment of the wheels and they claimed to have fixed the issue. After receiving the car for the week after it began to make a sound of something hitting every time I made a U turn or any time I turned the wheel. While driving 3/8 with my family in the car I made a U turn in a parking lot and heard the same loud sound of hitting. When I went to check two large approximately 3 inch bolts were on the ground but no nuts in sight and my control arm broke the bottom plate and was completely unattached from the car. Thankfully the bolts came off while in a parking lot and not 20 minutes prior when I was driving on a windy road. Within 24hours Tesla contacted me saying my car was ready for pickup without any explanation of why the bolts came off, No full inspection completed for other issues and no alignment of the tires. Under the Tesla mechanic notes they only reinstalled the bolts and tightened the front wheels and not the back. Upon further research online I have found numerous other people complaining of the same issue of the bolts for the control arm falling off on Model Y and 3 Teslas due to forgetting to weld the bolt nuts to the sub frame.

3/5/2024. Upon startup, car does not have power steering. Error code UI_a020 on screen and steering wheel very difficult to move as car reverses. Put car back into park and arranged for alternate transportation. Manufacturer advises "monitoring and reporting back when/if alert re-occurs"

While driving heard a noise from front end. As I turned right the steering wheel turned left in opposite direction. I heard something fall and found a bolt that fell off the car control arm. I managed to get the car back to my garage and called Tesla service. They say it needs an alignment and are going to charge me for this repair. A bolt should not be falling off the vehicle.

Subject: Urgent Safety Concern – Steering Component Failure in 2023 Tesla Model Y Dear Tesla Customer Support / NHTSA Safety Division, I am writing to formally report a serious safety issue involving a critical steering component failure in my 2023 Tesla Model Y (VIN: [XXX] 38,917 miles). The failure led to a loss of control and resulted in a collision. On [XXX], my wife, [XXX] , was driving the vehicle on our residential street, shortly after leaving our driveway. At a low speed of approximately 8-10 mph, she suddenly lost steering control as the car rapidly veered to the right. Despite attempts to steer, the vehicle was unresponsive, leading to a collision with a parked car. Damage Summary: •Our Tesla Model Y: Damage to front bumper, headlights, right wheel cover and right fender. •Parked Vehicle: Deep scratches and dents on the rear driver-side bumper and passenger door. Upon inspecting the vehicle after the incident, it became apparent that a suspension or steering component (likely the lower control arm) had failed (broken). After researching online, I discovered that multiple Tesla Model Y owners have reported similar sudden failures of the same part, indicating a potential manufacturing defect. Request for Immediate Action: 1.Tesla Inspection & Full Repair at No Cost – Since my vehicle is under warranty and this appears to be a manufacturing defect, I request a full investigation and repair at Tesla’s expense. 2.NHTSA Investigation into a Potential Recall – Given that similar failures have been reported by other Tesla owners, I urge NHTSA to review this issue for a potential recall before more accidents occur. 3.Tesla’s Official Response – I would like Tesla to confirm whether this component has been investigated for defects in other vehicles and what steps are being taken to prevent other accidents. This incident could have been far worse had my wife been driving at higher speeds. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA)

As I entered the parking lot I disengaged FSD by taking over the steering wheel. When it can to navigating into the parking spot I gently push the accelerator and the pedal disappeared from under neath my foot as the car accelerated forward hitting the car to my right. My calls to Tesla went unanswered so I could not report the incident. The incident happened May 2nd 2024.

On [XXX] at [XXX] on [XXX] I experienced a sudden malfunction of steering control of my Tesla Model Y, followed by a rightward movement initiated by vehicle automation and potentially amplified due to the steering malfunction. The vehicle then collided with an 18-wheeler truck on the right lane and came to a stop on the middle lane. I was driving past Tracy CA on [XXX] towards Modesto on a personal trip to Merced with my daughter, [XXX] , in the front passenger seat to drop her off. Fortunately, there was no casualty or injury from this incident. We are fortunate enough to have survived physically unscathed. A difference of few seconds could have led to significant injuries or impairment. Pictures attached show the steering wheel position turned to the left at about 160 degrees, while the front wheels turned to the right at about 20-30 degrees. For a right turn it’s about a 220-degree position, which is not possible by a single swipe of the steering wheel. Please note, the front wheel position in below picture cannot be justified either way. The steering wheel and front wheel remained frozen in this position when high voltage battery supply got disconnected at crash. This proves the turn of the wheel, thereby the movement of my vehicle to the right was not caused by my steering wheel control. Vehicle Automation Engaged related to this safety incident- Advanced Driver Assistance Systems such as Autopilot, Lane Assist, Collision Avoidance Assist and other safety features were active during this incident. There were no audio or visual warnings related to lane departure, forward collision or blind spot on the vehicle dashboard. The vehicle was declared a total loss by the insurance carrier, Tesla Insurance and currently in possession of their salvage vendor Copart, Title Express. Tesla Service refused to do any inspection of the components involved in this failure while the vehicle was at the body shop, Carstar Chilton Autobody, San Carlos, CA. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT

Vehicle control arms need to be replaced as suggested by the service department. They are currently clicking because they are not secure. I truly believe this is a safety hazard. Arms cannot be replaced for another month. Seems to be a widespread issue from my research. If arm fails, driver would lose control of the vehicle.

While driving, I experienced abnormal steering control. I am not sure if it’s a mechanical or electronic issue. The vehicle was towed to a local towing facility. I have reported the issue to Tesla but have not received a response regarding an inspection or next steps. This could be a potential safety issue.

There is a steering malfunction, with my Tesla Model Y it completely locks up and the steering is disabled. The steering doesn’t move at all the following warning and codes appeared on the dashboard. DI a223 Traction control disabled Drive with caution DL a222 Stability control disabled Drive with caution GTW_w074 Steering assist reduced Steering may require increased effort Ul_a020 Steering assist reduced Steering may require increased effort. Now this is the second time it has happened within few months. It was taken to the dealership with the same complaint this was their diagnoses Concern: Customer states: Feature Availability & Settings - Steering is disabled, park assist disabled , stability control disabled, traction control disabled, vehicle hold disabled Repair Notes: Confirmed customer concern. Removed and replaced steering rack, after replacement all systems operating as designed Correction: General Diagnosis Correction: Steering Rack (Dual Motor) (Remove & Replace) - Remove and Replace Parts Replaced or Added Part Quantity STEERING GEAR - LEFT 1.00 HAND DRIVE(1188832-00- A) NUT&WSHR[SW],M14X1.5, 2.00 [10],ZNFL,PTP(1109263- 00-B). There is a serious and unsafe issue with this car. A potential disaster waiting to happen.

Model Y s/w version 12.5.4.1 The model Y can be made to oscillate in the travel lane at highway speeds I think I experienced this at 70-75, it would seem to apply at any capable speed. Proper behavior: 1) driving on the highway in FSD 2) trigger the left or right turn signal to initiate a lane change by automation. What actually occurs: 1) driving on the highway in FSD 2) hold the turn signal in the desired up or down position to initiate a lane change. 3) the Tesla begins to switch lanes, and will continue to further its lane change provided you continue to hold the turn signal (up/down). 4) If you release the turn signal input "early", that is prior to the Tesla determining that the new lane is the current lane, it will immediately begin reverting to the original lane that you attempted to leave. 5) It begins to over correct, requiring maybe 5 damped oscillations. Its very uncomfortable, and exposes a vehicle on the edge of control - the vehicle is not traveling neutrally on its suspension. To be clear, it is damped, but I don't see how it could be described as stable at highway speeds.

The Tire losing with steering shaft . The bolt come off , my vehicle can’t make hard turn make it unsafe to able to drive.

I noticed a clicking sound when turning my steering wheel at low speeds such as when parking around September 2024. The sound got louder with time. A few months later after getting new tires installed (October 22, 2024)I had very bad vibration at high speeds that was not resolved with multiple tire balances at different tire shops. Requested service with the dealer. My initial first available service appointment was December 20th 2024. I messaged the service center expressing concern that my car was unsafe to drive. They allowed me to bring my car in to drive with a technician and they ended up replacing the front lateral links on November 7, 2024. My car was purchased new in June 2024 and is at 22,000 miles. The parts were replaced under warranty. There were no warning lamps or other symptoms.

My front right suspension linkage under the vehicle has come loose and drags on the tarmac. The problem is the suspension linkage is held on by what appears to be two bolts. The two bolts have backed out, causing this linkage to fail.

Two days ago, as I was turning left into my neighborhood, I suddenly lost control of my car's steering. Just as I started the turn, the steering wheel unexpectedly pulled to the right, causing my car to veer off course and head straight toward the curb. Despite trying to correct it, the steering wouldn't respond, and the car collided with the curb. The impact was substantial, and the vehicle continued dragging along the curb until I was able to bring it to a complete stop. Upon inspection, I found that the passenger-side front wheel had been severely damaged, appearing crushed and warped from the impact. When I looked under the car, I noticed that the control arm was visibly damaged. It seemed bent or possibly broken, which I suspect contributed to my sudden loss of control over the steering. This experience has been unsettling, especially since the control arm is a critical part of the steering and suspension system. Afterward, I started researching similar incidents and found many posts and articles discussing similar cases. It seems that control arm damage or failure is not uncommon, particularly in situations involving rough terrain, curbs, or sudden impacts. Some articles also discuss the importance of regular inspections and the potential risks of worn-out control arms. I came across one particular article that sheds more light on these types of steering and suspension failures. [XXX] [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

At approximately, 14,300 miles and while still under full manufacturer's warranty coverage, the front end of my vehicle started vibrating excessively at speeds of over 65 MPH while driving on smooth road surface (highway driving). I took the car to the local TESLA dealership to have the problem diagnosed. They determined that the "foam lining" on the inside of the tire separated and caused the wheel to become unbalanced. Their fix was to remove the foam lining and reinstall the tire on the wheel without the foam lining. I now have 1 tire out of 4 that does not meet the original OEM spec and condition. Below are the notes from the invoice for $256.10 that I had to pay to correct the problem. Repair Notes: Verified customer concern. Found RH front tire to have foam separation. Removed foam rebelanced tires. Test drove vehicle to verify vibration no longer present. Verified repairs.Correction: Tire - Front - RH (Remove & Install) - Remove and Install This seems to be a common problem with these foam lined tires manufactured by GOODYEAR according to TESLA owner blogs. It seems that either TESLA and or GOODYEAR are not claiming responsibility for a potential design and or manufacturing problem which is why I am filing a formal complaint. I will also be filing a complaint specific to the GOODYEAR tire.

Front right side wheel disengaged from the steering wheel. It was very scary situation to deal with and luckily it happened while I was on alley. I was not sure what was going as suddenly car was not under my control and acting weirdly. I hit a parked car and came out of the car safely. When parked the car then realized right wheel was disengaged. Called the Tesla insurance and they are not responding for over a month now since the incident happened. Tesla is saying I need to facilitate all this with the tesla authorized facility. Bottom-line, car is with tesla insurance and nothing is happened for over a month.

I found that two bolts that connect the front right suspension assembly to the body of the car were loose (actually one had completely come off). On 9/12 I heard a rather loud clanging sound when I accelerated. When I arrived home I looked under the car, saw those loose bolts, and took the two pictures that I attached, which were taken from in front of the behind the front right wheel. We bought this car new from Tesla, and received it in late August 2023. We would expect that those bolts were not properly tightened when the car was assembled at the factory, since servicing done afterwards should not have affected them. This is the list of servicing that was done after we received the car, and before 9/12: - Tesla service fixed some rattling sounds that we heard inside the car by adjusting the interior trim, and by fixing something in the brake pedal that was making some rattling sound sometime (replaced the brake pin, insulate the braked pedal and lubricated the brake pin) - A body shop replaced the side mirror on the left side (i.e. opposite side of the bolts that had come off), which had been hit by another car - A tire shop fixed a hole in a tire and rotated the tires

Date of incident 9/9/24 11:15 AM 2023 Tesla Model Y traveling north bound I-15 using Tesla Autopilot intending soon to exit Pioneer Crossing / American Fork UT in the far right lane — vehicle made sudden move to right glancing off wall causing scraping damage to right front quarter panel, and hub cap. Although I stepped on the brake in attempt to take control of the vehicle I immediately experienced uncontrolled acceleration and difficulting in steering. I chose not to exit and fought to keep the vehicle in varying freeway lanes attempting to brake to which the vehicle continued to attempt to accelerate against the braking, I also simultaneously and frantically continued to push the right stalk upwards in attempt to disengage Autopilot assuming that was causing the unintended acceleration. I was fighting to keep the car in a lane with faulty steering at time awakwardly steering to avoid slower moving vehicles. I eventually ended up coming to a complete stop in the middle lane of I-15 north bound 9/10ths (nine tenths) of mile north of my intended exit (mile post #278 Pioneer Crossing). Because of faulty controls I was afraid to try to move the vehicle to the side — I immediately put on emergency flashing lights and called 911 on my cell phone. While nervously waiting for emergency services approaching vehicles slowed and made their way around me — per instruction I stayed in my vehicle with seatbelt on. One large pickup truck struck my vehicle driverside rear as he passed by and failed to stop. Utah Highway Patrol and Fire Department Ambulance arrived within approximatley ten minutes. Two highway patrol officers stopped traffic and assisted in me slowing driving my vehicle to the center emergency lane. One office stayed with me until tow. He commented the right rear wheel appeared not aligned correctly suggested the rear axle was possibly broken. I was not injured beyond being extremely frightened. No passengers.

First time when it happened, i was able to control and It went to back to normal. I did not pay attention after. Second time I took right turn and the car drove in left lane but this time I felt steering was rigid and was unable to control the Steering and hit a tree. Driver seat air bag was deployed and all doors were locked. Gel from air bag burned my right hand wrist.

The control arm of my 2023 Model Y front wheel just came completely off without any incident. On August 31st at 9 pm, I was driving home from a park when I just pulled the car into my driveway, I heard a strange squeaky noise from the front wheel area, followed by a huge "BAM ''. I started to turn my steering wheel, and by then, the vehicle felt "stuck'' as if something was preventing the car from moving. I came out of the vehicle and noticed the control arm had just fallen off and was dragging on the ground, I also saw two bolts on the ground so I scheduled a Tesla roadside assistance. The Tesla service told me to call a lift-wheel tow truck to tow my vehicle to a collision for repairs. The control arm defect is a known issue for Tesla.

We were driving on a 2 lane highway, when we came to an intersection with a center turn lane the car panicked and swerved left and then braked and disengaged the autosteer/cruise control. This was not with autopilot, just autosteer.

The power steering stopped working while I was pulling out of a parallel parking space. It started working again when my speed went above 5 mph. The risk was that I was briefly in traffic, and it was very difficult to steer the car. The dealer has not seen the vehicle yet, and I didn’t notice any warning messages, but I also wasn’t looking at the screen at the time.

On Sunday [XXX] I was driving to work, there was a moment where I felt the steering wheel was very stiff to the point where it felt weird and hard to control. I felt the two front wheels a bit odd, but then it went back to normal. I paid no attention to it after. As I was driving on [XXX] , my car started to automatically move to the left and I tried steering my wheel to get back in lane, but the steering wheel got so stiff that even using all my might I could not steer it. Eventually the car slammed against the cement wall three times as it spins. At the end, the police came on site and saw that the two front wheels were pulled inward. I believe it was a software/technology malfunction. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reaching out on behalf of my wife who met with accident on 3/24/2024.She was driving Tesla Y model and this accident occurred due to System failure of Vehicle , brakes and Steering wheel get locked and she was not able to do anything and car hit the couple of trees on other side of parking lot . She was not using Autopilot feature and it vehicle didn't stop after applying the brake instead of stopping , its get accelerated and steering was also locked.

You have no doubt heard the news that Tesla has deployed Full Self Driving to all its vehicles as a "free trial." My Tesla received this update in the past few days. Last night I was driving on an expressway and engaged what has up until now been traffic-aware cruise control by pressing down one time on the right stalk. I expected regular cruise control but the car started steering for me. Tesla has changed the default behavior of the cruise control activation (one single downward press on the stalk) to instead activate Autopilot. My attempt to regain control caused me to jerk the wheel side to side in a way that could have led to an accident had I been in heavier traffic. This was unexpected behavior from the vehicle and I find it unacceptable that Tesla has changed a default function in this manner. I had to hunt around on the screen to find the setting to change the behavior back to regular Traffic Aware Cruise Control from one downward press. Furthermore, on the same 20 mile trip I had three phantom braking incidents while the car was on Traffic Aware Cruise Control mode. This is more than typical and these events can be dangerous if they happen in traffic. Tesla should not be allowed to deploy changes, especially without notice, that modify basic functionality of a car in motion from what the driver has become accustomed to.

I am receiving codes, GTW_w074 Steering Assist reduced, and UL_a020 Steering Assist reduced. In reality, steering is unavailable without extreme effort. This makes the car undrivable. I had the same problem in early February. The car was towed to Tesla for service and repaired. Now one month later the problem has returned.

My vehicle beeps liberally when parking in tight spots, anywhere near a line of any sort, etc. A few weeks after getting my vehicle in late November (I don’t remember the exact date), I was driving through construction at night and without warning, the steering “corrected” itself and I hit a cone causing 2 scuffs on my new vehicle. The steering locked, but thankfully I was able to get the vehicle back into the lane. When I called Tesla a few weeks later they asked for a specific date and time which I didn’t have. They said they were unable to help without that. Thankfully there was nothing more serious, but I would like my scuffs and steering fixed.

The Facts of the Incident: On [XXX], at approximately [XXX] PM, [XXX] , was driving our 2023 Tesla Model Y on Arizona State Route [XXX] ), a two-lane highway, enroute from Orange, California, to the Grand Canyon South Rim. The vehicle carried a total of four passengers, including my wife, myself, and another couple from San Diego. During our journey, an alarming and life-threatening situation unfolded. Without warning, our 2023 Tesla Model Y abruptly veered to the left, dangerously encroaching into oncoming traffic. Despite my immediate attempts to regain control by steering the vehicle away from the oncoming traffic, the steering wheel became unresponsive, effectively locking in place. This mechanical or software malfunction prevented me from correcting the perilous situation, resulting in a head-on collision with a large Ford 350 Truck, which was also traveling at a high speed, estimated to be more than 60 miles per hour. Fortunately, while there were injuries, there didn’t appear to be any life threating injuries. Because of the resources required to further investigate and do an analysis of the vehicle, as well as the challenge of dealing with Tesla Inc., law firms have declined to pursue further investigations. Morgan and Morgan initially started an investigation with Knott, LLC, Arizona, but then dropped the pursuit due to costs. The vehicle is still on-hold by my insurance company, USAA, but they may not hold it much longer before placing it on auction. However, it is urgent that NHTSA take possession and complete further analysis of this vehicle. Your assistance and consideration are appreciated, and I look forward to assisting with this investigation. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Vehicle is not up to date. Needs “over the air” update for auto steering.

As I was trying to make a turn on a street which I have used for months, the vehicle started accelerating on its own. So much so that it laterally flew over a median curb and hit another vehicle. I could not steer the vehicle nor stop it despite the fact that I hit the breaks several times. It truly was a very scary experience, and I am not sure what caused it. I have read of similar issues in the past, but I never thought that this truly happens. As a result of the acceleration, I got into an accident that damaged four vehicles. I am a very good and confident driver with clean driving record, and I have no explanation as to what happened, other than that the vehicle took control on its own. There were no warning lamps before, the vehicle has not been inspected yet, but I assume it will be after I have reported this very issue to the insurance company. While I am fine, my safety and the safety of those who were involved in the accident could have been extremely in danger.

After making a right turn, the car accelerated automatically and drove onto the sidewalk. The driver was hitting the brakes and attempting to redirect the vehicle with the steering wheel but both components of the vehicle were locked, causing the vehicle to lose control and crash into several things on the sidewalk (flower pot, parked cars, building pillars). The Tesla is completely dead so we are unable to retrieve any data within the vehicle. The safety of civilians on the street as well has the driver and passenger of the vehicle were at risk due to the lack of control of the vehicle. Two weeks after the accident, Tesla sent out a recall notice in regards to autosteer which can increase risk of collision, but prior to this no notice/warning was in place. The police were involved and at the scene at the time of the event and a police report has been made. No messages were seen on the screen or on the Tesla app in regards to any car mode (autopilot, cruise control, etc.) the vehicle could've been on, nor any warnings about risk of collision due to the recall.

Vechile started skidding and didn't respond to steering wheel control, ultimately failed to a make a turn and fell off road into a ditch. Also emergency braking wasn't triggered to prevent vechile from falling off road and furthermore upon impact airbags weren't deployed. The driver sustained grevious injuries and was transported away by EMS.

Autopilot feature disengaged with a single, 3 second warning.

I was driving in the left lane of the highway. Just up ahead I saw something sitting on the guardrail to my left which was jutting into my lane, right about eye level. It looked like a long wood 2x4. I swerved to my right to avoid hitting the piece (scared it would shatter my windshield) and the steer correct safety feature (probably wrong term) quickly threw me back to the left and into the guardrail. I turned my steering wheel to the right to get away from the guardrail and it threw me back into the guardrail. It did this a few times. I didn’t understand what was going on. It felt like I had no control over the car. It just kept slamming back into the guardrail. I finally took my foot off the gas and it slowed down and stopped throwing me around. Luckily, there was no one next to me and no one else in the car with me. No one got hurt. If it wasn’t for that “safety” feature, my car wouldn’t have been damaged. I did call the police to let them know about the wood piece that was sitting on the guardrail so hopefully it gets removed and no one gets hurt.

As I attempted to make a left turn, I wasn't able to make a complete turn when the steering wheels partially locked on me, resulting the car hitting a utility pole, I could only drive forward or reverse, difficulty making a turn. I was able to make it home but the next day, it had to be towed to a Tesla authorized collision center for damage assessment. I'm hoping Tesla can remedy the problem because usually my kids are in the car with me. Reached out to Tesla regarding the incident, they took my information as to what happened exactly during the accident and that there would an investigation on their end which should take about 1 week.

While I was trying to pull up my vehicle at about 10mph from the street to my driveway after driving around 35 miles from work, the vehicle suddenly accelerated (Unintended Acceleration) to 40+ mph (based on logs) and hit the property. This put my life and others at home at risk. The vehicle was inspected by insurance representative. No warnings lights prior to incident. However, the message 'Corrective steering applied for your safety' appeared periodically while driving back home even though the vehicle was very much within the lanes.

The vehicle's steering wheel vibrates regardles driving on highways/freeways and/or city streets. It happens since day 1 of ownership and has been owning for 4 months now. The vehicle's screen got blacked out twice when it was moving; thus, i couldn't read speed and perfom other functions such as turn on AC and/or heat. The regenerative braking/one pedal driving sometimes does not work. It sometimes accelerates itself after slowing down after accelarator was not depressed. Autopilot was not used at the times of unintended acceleration. Had submitted questions and service requests to Tesla. Unfortunately, Tesla did not provide any feedback or perform any service related to these issues.

We bought a 2023 Model Y from the Mesa Tesla on 12/17/23. The staff rushed orientation (we are first-time EV owners) saying they were so busy that we could only get 15-30 minutes max for a complex vehicle. They told us calibration is normal and to reboot the Y if anything happens and showed us how. Once we drove off the lot the A/C went out and we got calibration prompts saying Pull Over. We pulled over less than 0.5 miles out and the A/C came on. Because of the bullying at the dealer we we afraid to go back and decided to go home. Again the calibration prompts came on and Pull Over. My wife was driving with my daughter and my in-law's and I was behind her in another car with our son. She suddenly started slowing down on the road because the vehicle would not let her accelerate. I pulled over to the side but she could not. I went to her and rebooted the Y, per Tesla's directions, and the car went dark and locked me and my in-law's inside in moving traffic (my wife had exited with my daughter). We had to call Gilbert police to direct traffic around us (had many angry drivers until Gilbert police came not understanding why a Y with a paper license tag was stopped in the road) and a tow truck for help. Two other drivers did stop to help too. I found the manual release but my in-law's could not. The tow truck driver had to climb (we had previouly rolled the windows down with the A/C issue) from the front seats to the back to get my in-law's out and paid $140.00 to have our new Y towed back to the dealer. For one week the story keeps changing - there is a coolant leak, no coolant leak but bad sensor, now the PCS is bad. I do not understand how the government can sanction such vehicles. We saved for a long time to purchase what was a dream vehicle for my wife and our famil'ys life was endangered within minutes. We are terrified of this vehicle and being around others like it on the road.

UNKWOWN: ASSESSMENT: Date of Event 19 December 2022 Upon taking delivery from Tesla for 2023 Model Y vehicle with the above or contained VIN, driver experiences a series of events that result from a autosteer activation. Approximately seven (7) calendar days after receiving the vehicle a FDU (Front Drive Unit) was replaced. At approximately another twenty-one (21) calendar days after the FDU was replaced while activating active cruise control and or autosteer the vehicle unexpectedly aggressively accelerated (UAA) to unknown speed that was not observed by the driver. It was later found out by the drive through scheduling a service appointment that a series of settings and unknown factors may have caused the incident. This incident was video recorded as a result of a traffic stop conducted by a local sheriff's office. This event contained several other incidents before vehicle was stopped including UAA, collision avoidance (oncoming traffic), vehicle brake lockup, and unresponsive controls.

Steering got locked while driving. Couldn’t perform left turn in the middle of drive

Steering system malfunction and failure: I have a brand new Tesla Model Y for less than 3 months. Two months after I have the vehicle, the steering rack had an internal fault. The steering rack was replaced at the Tesla authorized repair shop. Eighteen days after that repair. I was involved in a car accident. The reason was because my car had veered to the right on its own while driving on a city street. I then turned the steering wheel to the left, but the car did not turn to the left. My car then hit another vehicle that was parked on the right side of the street. The front of my vehicle was totally damaged on the right side. The entire left side of the other parked vehicle was also totally damaged. I was NOT on cruise control. I was NOT on self- driving mode.

Steering assist reduced. The steering wheel completely stopped working in the middle of a drive.

The process of the car losing control around 10:50am to 11:55am: We were driving on Woodgate Road and were making a U-turn. The car lost control just after the U-turn. The steering wheel spun and failed. The car sped up and the brakes did not work. The car hit the curb and the left tire burst. It went straight over. It was about 3 meters from the sidewalk to the hillside covered with weeds, and it was impossible to stop because the hillside was too steep.

The car lost steering while driving. The wheel was super difficult to turn. The problem was confirmed by Tesla Service via phone call, the Tesla Service Center in Rochester and alerts on the screen. The car was towed to the service center.

Power steering was not able to control. Can't control the handle. It was locked. My car got towed to service center on same day. I received a call and they said rat or squirrel bite electric line. And charged me over $800 for it. I just figured out there is lot of cases like me.

1. What component or system failed or malfunctioned, and is it available for inspection upon request? My 2023 Tesla Model Y's steering wheel was totally locked up. I was not able to control the vehicle at all. 2. How was your safety or the safety of others put at risk? It happened when I parked, but I believe this could happen anytime, anywhere while I am driving. That could happen on the freeway which I do not even want to imagine. I am now scared of driving it. 3. Has the problem been reproduced or confirmed by a dealer or independent service center? I have a service appointment tomorrow, so I am not sure this could be addressed by the service center, but I can easily find articles talking about the same issue. 4. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not yet. 5.Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No waring or alert popped up. I have a videoclip that I took when the incident took place, but I cannot upload it here because of its size.

I took my wife to a doctors appointment and upon going back into the car to drive off the steering wheel became VERY stiff. I had to use a considerable amount of force to move the wheel. My wife couldn't move the steering wheel at all. Some errors appeared on the screen 'Power steering reduced', and UI_a020 Steering assist is disabled. Ultimately had to call Tesla and they had to tow it away to a Service center.

Autosteer mode, while generally helpful and which I use daily, abruptly brakes hard and/or pulls hard to the right when its computer program misinterprets a mere shadow as a threat. While I am sure your organization already knows this well. I believe this has strong potential to cause a driver to over-react and lose control of the vehicle. Addition of a radar sensor as an input to the existing algorithm similar to the Chevy Bolt for separately assessing/confirming this perceived threat could resolve the problem in milliseconds and preclude this risk. Understandably, Tesla management as judged this acceptable since adding this capability would raise its cost and reduce its market share in the increasingly competitive EV market. But as a former systems engineer and general manager manufacturing aviation autopilot computers, I strongly disagree and remain concerned about its potential to cause a serious/fatal crash. Thus, I offer another voice pressing for reconsideration by your public safety organization.

Steering Assist is reduced shows up in the screen. The steering then becomes hard to manouver and you lose parts of the control of the car.

We were turning onto a crowded street, and halfway through turning the power steering suddenly failed. We couldn't get the steering wheel to move. We were facing perpendicular to the street and several cars were within inches of hitting us. We got out of the car (in the middle of the crowded street) and back in, at which point the steering worked again. We thought this was a one-time issue, but as we got to the parking lot at our apartment complex, we experienced the same power steering failure. We can't drive this car under the assumption that we'll be safe.

During the week of October 09 2023, I started receiving two failure alerts on my 2023 Model Y. The first is that lane keeping assist was unavailable. In spite of this alert, the system continued to function properly. The second warning was a Steering Assist Reduced warning. At first, this also seemed to not corollate to a noticeable issue with the vehicle. On the evening October 15, when leaving a supercharger station, I noticed a momentary stutter in the steering wheel that accompanied the above mentioned alert. No other issue was observed. On the afternoon of October 16, when leaving from work, after putting the vehicle in gear, I had no steering ability at all, it was a similar feeling to the steering wheel lock on older vehicles. The wheel would move approximately 1" in either direction. I immediately shut the vehicle down and performed a reset by holding in both scroll wheels on the steering wheel. This did not clear the code, but did return steering ability. Since I could not predict when the steering might go out again, I contacted Tesla and had the vehicle towed to the nearest service center.

Steering wheel locks frequently, especially when driving on busy road. Very dangerous.

Power steering randomly goes out while driving. Most often happens after reversing, but also happens consistently while in drive. I was essentially unable to turn the car, so I was stuck in one spot and had to get out of the car so that the car could reset. This happened in several low traffic areas but also happened while I was at a red light at an intersection. The system did say “steering assist degraded” and that the cameras were blocked, but not sure if that has to do with the same issue. Never has been inspected, but I did see reports that this has happened to other 2023 Model Y and 3 owners. We have a service appointment with Tesla coming up to address it.

Upon starting the vehicle, the center console displayed a fault code "UI_a020" and a message that steering assistance was disabled. There had been no earlier indication of faults or degraded operation - only minutes earlier, the car was driving fine. The vehicle was now very difficult to maneuver. Rebooting the car did not clear the fault code. I was able to navigate the short distance back home, though it was not a pleasant experience. Upon returning home, I scheduled an appointment for a repair with the local service center. Later, I checked my vehicle again, and found the fault code had cleared and it was operating normally. I still kept the service appointment, and the tech I spoke with mentioned they have had recent reports of faulty steering racks. They replaced the entire steering rack. (I do not have the faulty unit available for inspection.) This vehicle was only a few weeks old at the time of the incident.

While driving, the car suddenly lost power steering. We had to struggle to get the car to the side of the road. Had to do a reboot to get the power steering back.

I was driving my car, and the steering wheel locked while driving and pushed me into the oncoming lane. We were lucky there were no other cars coming the other direction. I had to reboot the car to get it to drive again. The steering locked up again while getting the car home and also in the driveway. Tesla towed the car and replaced the entire steering rack of the car. I then saw an article about this exact issue and wanted to add my car to the other complaints. My car is only six months old.

Steering felt odd and was pulling to the extreme right, which caused contact with a curb. After driving about a mile after contact, car lost steering and both front wheels were turned inward. Tesla claimed contact with curb caused the steering gear and rack to break-they did not take into consideration that car steering was not workin correctly before impact. Component is not available for inspection. Safety was a factor since I couldn't steer. Has not been reproduced or confirmed by an independent service center. Component not inspected by anyone other than Tesla service center in San Francisco, Ca. No warnings re:steering or any other issues.

The contact owns a 2023 Tesla Model Y. The contact stated that while driving at an undisclosed speed, the steering wheel became stiff and difficult to maneuver. The steering assist warning light illuminated. The contact veered off the roadway. The contact notified a tow truck company, and the vehicle was towed to the dealer where it was diagnosed that the steering rack had failed and needed to be replaced. The vehicle was repaired; however, the contact was concerned for her safety while driving the vehicle. The manufacturer was not notified of the failure. The failure mileage was approximately 1,400.

Mileage: 1,400

I lost all power in my steering and was completely unable to steer. I contacted Tesla who advised me to conduct a soft reboot and the issue was resolved only to return about an hour later. I contacted Tesla again for roadside assistance. I was advised to complete a soft reboot and drive the vehicle to the nearest service station. I refused to drive the vehicle, as I did not feel safe to do so. Tesla sent a tow truck to pickup the vehicle and drop off at a Tesla service station. After 3 days, I was informed there was a malfunction in the vehicles steering rack and the entire part will be replaced. I conducted research and found a lot of owners are experiencing the same issue with 2023 Tesla Y, some even having crashes as a result. This is very unsafe and needs to be addressed.

It’s just been 2 weeks in I bought my Tesla Y 2023 model. Was exploring entertainment options in in park mode and then when I had to leave, I see this steering assist reduced and wasn’t able to move my steering at all, I was like what.. a brand new car having such safety issues, thank god didnt happen while I was on road, would have definitely killed me. Tried rebooting or reset but still the same. After multiple attempts, power steering came back on and I was able to get home. After reaching home immediately requested a service through my Tesla app. This is very frustrating to see issues in a brand new car.

The steering wheel locked and stiff, wasn't able to turn. The was very dangerous as my wife and kids could have gotten into a serious accident. We are no longer comfortable with driving this vehicle even if Tesla repairs so we would like a refund

Steering assist reduced error message. All of a sudden I was unable to steer the steering wheel. This was scary and dangerous.

I was driving and the steering wheel completely locked up, I could barely turn the wheel even when using all my strength. The car would only go forward and backward. I was fortunately pointed slightly towards the curb so was able to glide the car to a stop on the side of the road. There were no warnings prior to failure and I immediately lost all steering capability. The car was towed by Tesla to the service center.

Power steering went out twice, both from changing gears once was mid drive second time was going from park to reverse.

While Driving the car the steering became unresponsive, this almost created like a death situation for me. Tesla should be held accountable.

I was driving through a busy nyc street very slowly. Probably 10 mph or less. I was on a red light. then i moved forward when the light turned green, my handle felt weird and the car was moving side ways. I first thought it was the tire that blew off. So I immediately stopped the car and had my husband look at the tires. No holes, no pressure was lost. I thought it was so odd, so I started moving forward a little bit, again. Something felt very off. We stopped again and looked throughly and realized the right rear wheel was twisted while the other three remained straight. This is our brand new car that was just picked up 7 days ago. We just simply couldn’t believe our eyes. My whole family including my husband, my two kids (7,10), our dog and myself were in the car and I can’t imagine ourself being in the same situation if we were on a highway at a faster speed. We’d probably dead by now. I didn’t hit anything, i was going 10 mph, there was nothing on the street. And the wheel getting twisted like that just doesn’t justify anything but a defect.

- Failed system: Steering wheel was locked up in the middle of driving. Driver was making a right turn at an intersection. Suddenly a "Steering Assist Reduced" UI_a020 warning appeared on screen, and driver was unable to turn the wheel. No autopilot in any level whatsoever was turned on. - Safety risk: Driver hit another car due to the loss of control of the vehicle. Thankfully it happened in a city intersection. If it happened on a highway, much more damages and casualties might have been incurred. - Reproducing the problem: Right after the accident, driver was ordered to pull the car over to the side. But even after a few restarting of the car, the UI_a020 warning reappeared sporadically. From that time we completely stopped driving the car and drove it only occasionally to load/unload it to tow trucks. So we did not have much chance to reproduce the problem. We have some photos and video clips of the UI_a020 warning taken on the date of the accident. - Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?: Not yet. Currently the vehicle is at a Tesla Approved body shop (collision center) for repair. - Any warning lamps, messages or other symptoms of the problem prior to the failure: There was no UI_a020 warning that we recall prior to the time of the accident. This could be unrelated to the UI_a020 issue, but one day before the accident, I was trying to unlock the car using my cell phone, but the car did not recognize it. Only after turning off and on the Bluetooth several times was I able to unlock the car. This had never happened before and after.

Steering wheel locked up while driving and making a turn

lost all power steering today on model Y 2023 tesla.

During driving this vehicle on road, this steering wheel wheel was suddenly locked, and cannot be turned. This caused the vehicle stopped making any turns. There was no any warning/messages/symptom before this incident happened. I had to go straight and stopped/parked the vehicle on roadside. After several power off and restarting, the steering wheel was still locked. Called Tesla tech support, the problem cannot be solved. Then had the vehicle been towed to Tesla service center. Tesla technician confirmed seeing error log info. It is under investigation now.

I got the dreaded ul_a020 error - "Steering assist reduced" today while driving our model Y - barely 3 months old with 2K miles. The steering became very stiff and I could barely move it, had to use all my forrce to rotate the steering wheel and move the car to the side. it very scary, I parked, got out and then drove again, it happened again. Thankfully I was not too far away from home, so somehow got back. The steering is not smooth anymore now.

Steering wheel locked after only 9k miles on the car. Won’t turn so cannot drive the car. Brand new car. God forbid this happens while driving the car on road.

Power steering appeared to be off when trying to drive car. Could not turn wheel at all. Car was towed to tesla service and told the power steering rack has an internal issue and needs to be replaced.

Please note that I am not the owner of the vehicle and I am making this report in the public interest to try and save lives. The defect affects all 2023 Tesla Model Y cars and I have used the VIN of a junkyard Model Y to be able to complete the form. I have also used a fictitious USA address to satisfy your website requirements. My genuine contact details are available I understand that it is perfectly lawful for a non USA resident and a non owner to file a complaint. A Tesla Forum in Germany has a report from an owner detailing severe corrosion on the Ground terminal on his [XXX] car. This looks like galvanic corrosion between dissimilar metals. I think a bad ground connection might be the reason for the spate of power steering complaints on this model and possibly also causing brake booster failure. Tesla has been blaming the steering rack and replacing it. I think it is highly unlikely that the steering rack is faulty and it is much more likely that bad ground connections are the cause. The 2023 Model Y has some changes from the 2022 model including the use of so large aluminum castings. I think this may increase the risk of Galvanic corrosion and be the cause of the alarming increase in failures. Fatal crashes into oncoming vehicles may have been caused by this. Here is the thread: [XXX] Quote: Premature corrosion MY? Tesla Model Y Model Y Issues/Errors 19 March locobmw 19 March A bit frightening - after 3 months the contacts are already badly corroded. I'm going to report this to the SEC INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

While driving I lost the ability to steer. The steering wheel completely locked almost. This was a huge safety risk, as I was in the middle of a busy road in Los Angeles. I went to the Tesla service center today and they were closed. No warning lights came on. The same thing happened again today.

On September 3/2023 at around 9am I was driving my Tesla Y. I stopped on a traffic light on an intersection and on my green light started to turn left. However my steering wheel was not turning, it has stuck. It was very scary because of the intense incoming traffic. I turned my car on parking and then started again but nothing has changed. Tried this a few times without any success. My car only moved straight forward and backward. Then two drivers stopped and started to help me. They stopped incoming traffic and one of them helped me to turn the steering wheel left to move my car from the middle of the intersection. Two of us barely did this together and moved the car to the side of the road.

Power steering failed repeatedly. Car was extremely difficult to steer. This only happened at low speeds, so there was no immediate danger. The car displayed various error messages. Took the car to the dealer, they confirmed it was an issue and replaced the Steering Rack.

I had an error message that power steering was not available and I was unable to steer.

Steering system completely failed during driving. Thankfully I was in a parking lot at the time. The car had to be towed to my home from over 100 miles away. I’m towing it back to Tesla service this morning, August 28, 2023.

While driving the steering locked up and driver was unable to turn in either direction

Power steering failed for unknown reason. Operating the vehicle without functional steering made turning through traffic dangerous. The vehicle is now at the Tesla service center for diagnosis.

When placing foot on brake to shift into gear, vehicle goes into multiple faults and disables all safety features. Also mid drive vehicle loses power steering and cause unsafe driving conditions. Brakes also start to behave erratically when this occurs.

Had my vehicle for under 1 month. I was driving on a busy highway and the steering wheel completely seized up. It was unable to respond to turns or even curves in the road. Luckily, I was eventually able to pull over gradually, stop the car and contact roadside assistance. However, this was a very dangerous condition that could have cause multiple fatalities, including my own. Tesla replaced the steering column and sent me away without explaining the cause of the condition.

The contact owns a 2023 Tesla Model Y. The contact stated while attempting to make a left turn, she became aware that electric power steering (EPS) system had failed. The EPS warning light was illuminated. The vehicle was taken to the dealer but was not yet diagnosed. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 18V204000 (Steering) however, the VIN was not included. The failure mileage was 2,000.

Mileage: 2,000

While I was driving my car earlier today, my Tesla Model Y experienced an unexpected steering freeze right in the middle of the freeway. This incident occurred while I was accompanied by my 2-year-old son. Initially, I was quite alarmed and attempted to exert force to guide the car towards the slower lane, but unfortunately, the steering remained unresponsive. After trying the brakes a few times and executing forceful maneuvers, I was fortunate that the steering finally began to respond. Thanks to these actions, both my son and I are safe and well today. It's worth considering the safety implications of Tesla vehicles on the road, and some individuals believe that the NHTSA should intervene by imposing fines and addressing the use of the autopilot feature promptly. Thanks Dr. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Steering assist reduced. Notification on screen alerted me. Could not turn steering wheel to make turn while in a Chick-fil-A drive thru. Needed to park car and shift to drive a couple of times before I could eventually make the turn.

Last night the steering totally failed right after starting the car. An alert popped up saying “steering assist reduced”. Total loss of power steering and the car is inoperable.

While driving in the city on under construction road, the car started showing notifications that the steering power will be reduced. 30 sec. later the steering wheel froze and the car was drivable only forward and backwards. This safety system malfunction put me and my family at risk while in active driving mode, luckily there was no much traffic and i was able to reset the car in order to be able to drive it again. Bumpy road shouldn’t cause the system to malfunction and limit the driving capability, especially not while active driving. I wasnt using any cruise control or auto pilot features.

I have had the car 5 months and have had no problems. This week while driving there was a jerk of the steering wheel to the right and a second later I lost all power steering. I could not turn the wheel without using great force. Luckily I was in the far right lane and could pull over. Car behind me almost rear ended me. The warning on the Tesla screen said "steering assist reduced". I called Tesla and they sent a tow truck to get the car. I did try restarting the car and the steering came back for 10 seconds, but again there was a jerk the right of the wheel and then NO power steering again. Was very upsetting to say the least. I have a home in the mountains and had I been driving down a winding mountain road I could see myself having driven into a tree or off the road! The car is in the shop and they are saying they will likely replace the steering column. I see that others have experienced this and wanted to make sure my voice was heard. I will not be surprised if there are MANY more similar incidents with this car. I hope that it does not lead to deaths.

While driving my Tesla model Y, an error message "Power assist reduced" popped up on the computer's screen. I couldn't turn the steering wheel in either direction in a parking lot. This incident happened on 8/11/2023. I reset the car's computer and walked away for 5 minutes and returned. The problem went away. I drove to another place and encountered the same error message while backing up a car into a parking space. I reset the computer system and got out of a car for a few minutes. The error message disappeared and I drove home within 2 mile radius. I have scheduled an appointment on Tuesday 8/15/2023 with Tesla Service Center.

Steering wheel locked up while driving under normal conditions at 45 MPH. I was exiting the highway at this time and was luckily able to come to a complete stop. The car had to be towed to the Tesla service center. This is a brand new 2023 Tesla Y purchased a month ago. The steering wheel has been locking up from time to time; and the steering of the vehicle sometimes feels unwieldy, uncontrollable, and simply undrivable. The issue is very dangerous. I Googled the issue and came across Reddit posts and other Tesla forums where other Tesla drivers have reported the same issue. There are also YouTube videos that discuss the same issue. This seems to be a common enough problem that warrants a total recall. The Tesla service agent acknowledged that the problem seems routine and pervasive, but downplayed the issue. There have been tragic accidents involving Teslas in the news recently (including a mother/daughter who crashed into a tree and both died en route to a doctor’s appointment—and this crash is still under investigation in California). But having experienced this steering issue with my own car, it makes me wonder whether the cause of these accidents is this steering issue. And I wonder if Tesla is covering up some of their data regarding these fatal accidents. This is an urgent issue and should be addressed and investigated thoroughly.

Having issue with steering getting stuck and not allowing to rotate. Happened 2 times today and I am ending up powering off and starting the car. I am worried about getting stuck while driving. This is a safety concern for me.

Steering locking up. Based on what I am reading it is the same as others have experienced.

I was driving on the street and all of a sudden steering lost control. The screen shows "steering assist reduced" but the steering got really really heavy to the point it couldn't be turned. It was a dangerous situation where we were in the middle of the street, and there were oncoming traffic on both ways. I called Tesla Road emergency assistant but in the first call was told they couldn't help me unless i move to a safe spot. They asked me to call 911 and get a towing service and could only help after doing so. So we called 911 and asked them again. This time they asked us to reboot the system and it worked for 2 minutes. Afterwards it failed again. It is a very threatening and dangerous situation, as we lost control of the car! I would not want to imagine what would happen if this was on a highway. What's more frustrating is Tesla's emergency road assistant denying help in a timely manner. Now my Tesla is towed to a service center, and I've inquired what my options are. The service center person did not apology at all about the situation and said can only change the steering rack. They also mentioned there is no guarantee that this wouldn't happen again in the future. This is becoming such a common issue and Tesla should take responsibility to recall.

The contact owns a 2023 Tesla Model Y. The contact stated that while driving at an undisclosed speed, the power steering failed and with three error messages displayed on the instrument panel. The contact was able to safely drive the vehicle to the residence. The contact stated that after the vehicle had sat for several minutes, the power steering functionality returned. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 1,170. The contact stated that Tesla replaced the steering rack under warranty.

Mileage: 1,170

While driving the steering wheel got locked. It occurred 2-3 times consecutively. I call the tesla center and they arranged a tow. When the tow arrived the steering wheel started to make weird noises (it initially worked again) and it got locked again. When the steering wheel was locked there were warnings appearing on the screen (photo attached). The car is now at the tesla service center but it has not been processed yet as they are not open on Sunday. I have video recording of when the second wheel lock happen and can send it if needed

As I was exiting my parking space I notice the steering wheel was stiff as I tried to navigate a left turn. I could not pull the wheel for a successful turn and to not block traffic I reverse slowly back into the parking spot. I rebooted the vehicle and was successful with no issues. Sent a message to Tesla service regarding incident. Mechanic says to have it towed the next time it happens again. Today for the second time (5 days later) as I try to leave for work the same problem appears. This time a reboot to the vehicle did not solve the issue. Rebooted 2 times and steering wheel was still frozen. Called for roadside assistance. Prior to this, there were warning signs that stated power steering reduced and lane departure off. With those warning signals I have a tesla service appointment scheduled.

This was a brand new vehicle delivered in March 2023. Soon after delivery, we noticed difficulty with the steering - more resistance than expected and a feeling that the wheel was turning through notches as you turned the wheel. Please note, we have owned other Teslas and are familiar with the normal steering effort required and software adjustments available. The problem continued to get worse, until one day in May while out, my wife got into the vehicle to drive and the screen displayed an error "Steering Assist Reduced" and the steering wheel would not turn at all, regardless of effort. She reset the vehicle a few times and got out, then re-entered and after a few minutes the problem went away on its own. She drove it home immediately, and then we had it towed to a service center. The service center determined that the vehicle had a steering rack failure and replaced the steering rack. We asked a service manager for compensation for the issues and Tesla then decided to purchase back the vehicle at the full purchase price.

Vehicle was parked on the street. Put car in Drive, loud noise came from steering column, and warning message shows steering assist reduced and lane departure avoidance features unavailable and at that point the car had no power steering. Car was reset 4 times. Every time the vehicle was reset, loud noise came from steering column, both warning messages appeared, and no power steering. On 4th reset, power steering came back, but both warning messages still appeared.

I bought the vehicle and after one day the cars power steering went off while driving and I couldn’t steer. As Tesla has an autopilot function it did not come with the car and no adaptive cruise control and I had to take it to service and leave the car for two days to resolve it.

After a software update I lost all power steering and could not drive the car. It had to be towed and the power steering motor replaced

Loss of power steering making vehicle very hard to steer. The day before power steering was lost, steering became step like - not turning smoothly but in incremental steps. The problem was confirmed by Tesla service and repair has been performed.

All of a sudden, steering wheel control was lost. Steering wheel was so hard to rotate that it was even difficult to park the car. Also, I was getting lots of pop up messages from tesla vehicle operating system.

Steering is locking up while driving. This happened 5 times in the past three weeks. Vehicle is scheduled for service.

Steering got locked and stiffened in middle of the road in traffic.had to call 911 to help me to move my car.this was scary as it could have lead to crash or accident.some time front wiper is automatically wiping in dry summer days which is sometimes blocks the view while driving. Had to switch off the auto mode for wiper.

Summary: Loss of power steering/inability to steer the vehicle occurred twice (7/16/23 & 7/29/23). Issue appears consistent with Investigation PE 23-014. Other functionality was also lost on each occurrence. Details: 7/16/23 - Driver entered the car and immediately received several alerts including Steering assist reduced, stability controlled disabled, traction control disabled, Lane departure avoidance features unavailable, and Vehicle hold disabled. Steering wheel could not be turned and regenerative braking was not functioning. A video of the issue was created and is available upon request as it could not be loaded in its current format. Tesla was contacted on 7/17/23. They stated that a firmware update failed on the evening of 7/15/23. The vehicle was towed to service center and firmware was updated. the invoice from the service center as also attached. 7/29/23 - Driver entered the car and immediately received several alerts including Steering assist reduced and Lane departure avoidance features unavailable. The steering wheel could not be turned, but only with extreme force. There was no firmware update at this time. I was able to drive the car 3 miles to my home at very slow speeds. 2 videos of the issue were created and are available upon request as they could not be loaded in their current format. Tesla was contacted on 7/30/23. The vehicle was towed to service center where they determined that the steering rack needs to be replaced. The vehicle remains at the service center for repair. Background: Car was just received on 6/30/2023. I have had other issues as well. Upon receipt, the electronic seat mechanism was not working and my cameras do not appear to be measuring distances properly.

What component or system failed or malfunctioned, and is it available for inspection upon request?: I got delivery of my new Model Y and odometer was reading 3 miles, i took the delivery and drove 10 miles and it stuck the steering wheel , "rear motor got disabled alert" and vehicle went to slow speed on freeway all of sudden, i had truck behind me it would ended up very bad for me and family, i had to immediately put emergency signal and stop on road side, i tried to call tesla road safety helpline and they were totally busy and did not receive call. How was your safety or the safety of others put at risk? ; this car "rear motor disabled " twice in middle of freeway , Has the problem been reproduced or confirmed by a dealer or independent service center?: Yes they confirmed but unable to give me more details . Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? : No they kept it secret with less info. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?: No warnings, just stopped over in middle of freeway . so scary specially to new car. I would like NHTSA to inspect all new model Y car which have problems reported please check online and see the percentage of people received this kind of risky issues.

I received delivery of my new 2023 Model Y at the end of June. About 2 weeks ago, I was driving with my child in the car and at a left turn light. When the light turned green, I attempted to turn and the steering wheel almost completely stopped working. It felt like it was totally locked and with all my force, I was able to turn the car about 10% to avoid running into oncoming traffic. There was an alert for steering assist reduced. However, this was basically a locked steering wheel. The vehicle was towed to the nearest Tesla service center and per their notes, they replaced the steering rack and after test driving, they found an HVIL alert. Per their following notes, vehicle kept HVIL faulting and they had to pull logs and check signals and found that OSC kit was needed at VCFront. Installed OCS kit and alert stopped popping up. When I picked up the vehicle, I emphasized my great concern and how scary the incident was. They told me that if the issue continues, it's a hardware issue.

Vehicle completely lost the ability to steer. Warning message appeared that said power steering assist had been reduced. In fact, the steering was "locked" and a tremendous amount of force was required to simply steer the vehicle slightly to the side of the road. I could have been killed if this had happened on anything but a very straight low speed section of road. The vehicle was taken away on a flat bed truck to Tesla.

Within two weeks of taking delivery of the car, the power steering locked up when I was driving on the highway. Luckily I was on the right lane and was able to pull over. Once I got out, locked the car and came back in, it started working. It happened twice after that on my drive home from Wilmington NC. I had to take it to Tesla and they replaced the steering rack to fix this but this seems to be a common problem.

The cruise control for keeping the car in the lane never worked correctly . The car had to be towed to 1805 N Pepper Ln, Liberty Lake, WA 99019. Tesla had our new Tesla for two days and fixed the problem. When the car steering when out I was in restaurant parking lot and only drove less than a mile to our Spokane hotel . Waiting two extra days in Spokane was a major pain and loss of two days of work .

While on the highway i lost all power steering and acceleration and breaking power. no blinkers or access to my cars screen would not put car in park while on the side of the highway. i had to cross 4 lanes with no power, blinkers, minimal breaking. The control computer completely broke and stopped working. this was a week after delivery. Telsa towed my car for free and fixed the issue. But did not give anything for almost killing me on the highway. what repair notes say they fixed/replaced. Steering Colum control module bolt Rc Airbag harness Faulty SCCM,CAN

Had car less than a month. After a Tesla software upgrade, error message that power steering assist was disabled. Unable to turn steering wheel. Reset software twice with no change. Left the car for awhile. When I came back, steering worked. No issues since.

Loose power steering control while driving. Mostly happens when car is backing but also has happened while driving. Twice, we narrowly avoided accident. We called Tesla and they said to reset the software upon which it did not show for a day and again started showing up. We are taking the car to be looked up by Tesla service center. This is extremely dangerous situation as loosing power steering makes car really hard to steer!!

Steering wheel locked up one morning and immediately reported it to Tesla and they corrected it, but it seems like they just did a flush of the system. Not sure if there is still some fundamental flow. Charging port also kept on not responding either which basically makes the vehicle unable to move if it can't be charged.

The steering wheel on my 2023 Tesla Model Y, brand new with only 800 miles on it, kept on locking up out of nowhere, in the middle of the drive, and even on the highway, posing a major safety concern for me and everyone driving around me. My safety was put at risk since I could not steer my vehicle off the road and into a safe area, posing a risk-prone of a severe accident through rear-ending. The problem was notified to Tesla Service, which responded super late to this incident where I had to call them and wait on hold for 1 hour to speak to a representative who then followed up and told me to drive it to the closest service center, which I declined since the steering wheel locking up at random is a major safety. Tesla stated that I would need a new steering rack installed on my brand new 2023 Model Y. I don't understand how these vehicles are inspected and pass quality control on such a major issue. This issue is not just about a broken part but a LIFE or DEATH SITUATION and should be dealt which severely. I got multiple lights and messages when the failure occurred while driving, with steering assist required being the last notification which I have attached in the pictures.

Service pushed a software update intended to fix a parking assist issue, and after that the power steering failed with a "steering assist reduced" message. I did a full power off and waited a few minutes, and since then it has worked fine. Also of note I mentioned this in my service ticket and they didn't respond at all. I attached a screenshot of the conversation from the Tesla app.

While backing the vehicle out of my driveway the steering wheel completely froze and would not turn in either direction. The vehicle reported a fault, so I turned the vehicle off then back in and it returned to normal. There was an error reported in the app under the service section however it has now disappeared.

Unable to steer. Received the power steering error mentioned in reports, I don’t remember the error code. Happened in my driveway, so no issues with respect to time or place. Rebooted the car and the error went away, but still scheduled service due to error code. It resulted in bringing the car to a service center where the steering rack was replaced.

I was in Tesla charging station when I noticed this steering issue happened. I wasn’t be able to turn the steering as usual and had to make call to Tesla and had it towed to their repair shope. It took four days to replace the rack and pinion. I am not happy having just three month and this happened. Shape on Tesla. Thank God I was not in the free way.

While driving my 2023 Model Y, the electronic power steering suddenly stopped working. Luckily there wasn’t a vehicle behind me, which avoided any accident. I had to use immense manual power on the steering to make the vehicle move to the side. Upon resetting, the steering was back to normal again. However, this seems to be a serious safety hazard and I cannot fathom the fact if it had happened on a busy freeway.

My model y was park in our garage and when we decided to go out to get some food around 7pm and when I started backing out the steering wheel seems “locked” that like 5 seconds after the car start moving… I move it forward so it won’t be in the street or side wall and I tried to walk away and lock it and it happened again. I did for 5 times and I even ask people who we know that have Tesla and I even turn the power off and waited two minutes and still the steering wheel locks up. I made an appointment and for this Thursday and I added that the car is undriveable because it seems like their help service in the app says “bring all the keys”… I have been reading online about and how to troubleshoot but it seems like it’s a defective “electrical component” and it’s been happening to other people as well and some was driving in the freeway. We love our Tesla but why and how these things pass their quality checks? Please check their products as in cars for the safety of everyone. I have my fiancée and two kids in their car seat when this thing happened and I’m glad we weren’t in the freeway.

About 24 hours after the car was delivered I performed the first routine OTA software update. Upon putting the car into drive for the first time after finishing the software update, the power steering failed with a "power steering reduced" warning before the car could move. The steering wheel would not move without great effort. A power cycle cleared the issue. After remotely viewing the vehicle logs, Tesla service inspected the car about two weeks later at a service center. The service center determined the issue was resolved by a firmware update. The issue has not come back since the initial occurrence. The service center was aware of the problem and was initially prepared to replace the steering rack.

We purchased the vehicle new approximately 2 weeks ago. After about a week, the steering wheel would lock up randomly. This occurred 6 times on different dates before we were able to get it to the Tesla service department. The vehicle currently remains at Tesla for the next 3 weeks while we await a new steering rack/motor. The vehicle would lock while in the park position but we were still able to move forward and backward. I’ve read other instances where this has occurred in other Tesla vehicles. The safety concern is this could have occurred while driving which would have ended in unfavorable circumstances. This should not be happening in a brand new vehicle and the fact that this has occurred in other Tesla vehicles is very concerning. I’ve uploaded photos of the errors that showed on the screen when the problem occurred.

2 weeks old car. 350 miles. Coming out of the shopping center, suddenly steering wheel did not steer. It was hard and saw the alert. Went to very close to opposite side of traffic and some how made it to across the road inside the shopping center

Over the past few weeks, I have been experiencing significant problems with the steering wheel of my car. Upon starting the vehicle, the steering wheel frequently locks or becomes exceedingly stiff, requiring significant physical effort to turn. Rebooting the system, exist then re-entering the car can sometimes fix the issue temporarily to make it drivable for the current trip. This issue not only causes inconvenience but also poses a serious threat to safety as it sometimes persists even while driving. Yesterday it happened again when I drove the car to the dealer for diagnosis and repair. Luckily, it didn't happen when I was on highway, it happened when I existed the highway and stopped at the first traffic light when the steering wheel became extremely difficult to turn again. The car is in the service center since 6/3/23. Operating a vehicle under such conditions is challenging and risky, creating potential hazards for both myself and other road users. This defect could lead to an inability to navigate or respond effectively to traffic situations, thereby greatly increasing the risk of an accident.

Hi Team, I bought a new car Model Y- [XXX] from Tesla on 27 Dec 2022 and after driving 50 miles itself with in 3 days, I reported so many manufacturing issues to Tesla in my new Car. All the issues that I have reported at that time either all of them are still open or while fixing any of those issues it caused even more issues in my car. As of now I have given my car 5-6 times to them for service so they may fix them but still all those issues either still exists or not fixed well. I am fed up giving my new car back to them for servicing and booking appointments & visiting them. Initially one of their employee gave me a confirmation that he is working with Tesla to buy back my car but then after 30 days I got to understand that Tesla employee is no more working with Tesla and have been fooling around me. I am not sure what kind of customer service, assurance does Tesla provides to its customer and how they working towards resolving those issues. I have paid $68000 to buy this car- and I feel like I am driving a car which got lot of design issues and I feel like I paid for new car and I am driving a 2nd hand car. It so much noise and rattle in my car and that also started to come after they tried to fix issues in my car. So, I am no more interested to get the issues fixed in a factory fitted car rather should have a new car or should get a full refund of the car. I am attaching a PDF of email thread that is going on from last 2-3 months with Tesla service employee and still they just want me to keep coming and giving my car to them. I don't have any more trust on them. Attach PDF shows all the issues and how they are just wanting me to spend time and keep explaining the same issues to them. All the issues details can also be referred from the email attached. Also from the email you may see- I was supposed to get one of issue fixed today but they have pushed again my appointment again after 10 days and not addressing my email. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(

I was trying to make my way into a parking lot yesterday and my car was in a complete stop and I was making sure that the spot is a right one since I was in downtown Norfolk with its parking issue. I noticed a sudden acceleration of my vehicle and I obviously became terrified and just waiting for what will happen next. Fortunately, the parking lot of empty with no passenger or vehicle to run into. I pressed the brake and the car came into a complete stop. I can only imagine what could have happened if the parking lot was not empty. I parked my car and went for my appointment. After my appointment and I drove the same car home with no issues, I am curious to understand what has happened so I started researching online whether this is a one of issue or there are others who have had similar experience. I found that there are cases describing something similar to what I had experience but the investigation blamed it on user misuse or misapplication of acceleration. I STRONGLY believe that there is more to this issue than what your previous investigation has unravelled and my concern is more about the public safety danger that this represents. What could have happened if there are people at the parking? What if this had happened in a public square? I am one of the cases that did not result in an accident but I do have responsibility to report this and ensure that this case is properly investigated. Looking forward to your update on this matter.

April 22, 2023, at 7:00 pm: I stepped into the car at a local store parking lot and pushed my foot on the brake to unlock the vehicle. The wheel jerked hard right and made a thud. The screen warned that “Steering Assist Reduced” with an error code ui_a020. Power steering was disabled. I restarted the Tesla with dual buttons and left it alone for two minutes, but power steering did not return. The vehicle drove but was difficult to steer without power steering. We were less than a mile away and made it home with steering difficulties. I made a service request online to Tesla immediately. At home, I restarted using the dual buttons again and left the vehicle alone for longer. This time power steering felt like it partially returned, but when turning the wheel, it was clunky: every 1/8”, a bump in the steering was felt. I’ve now discovered other Model Ys in online forums with the same issue, and they describe a similar experience that the steering feels ‘notchy.’ The vehicle is available for inspection. I have attempted to drive it a little on my block, and it feels unsafe to steer. Tesla has moved my service visit from May 2 to May 25 due to a backlog of parts. They confirmed this is a recently known issue and noted the steering rack might be replaced entirely. No one has yet inspected the vehicle; it is sitting untouched in my driveway. Aside from the screen warnings of “Steering Assist Reduced” with an error code ui_a020, no other warnings were received. The error happened on a vehicle less than 30 days old: * Model Y * Dual Motor * Plant of Manufacture: Fremont, CA * Software Version: 2023.6.11 * Delivery: March 23, 2023 * Mileage: 800

Upon receiving the car the steering wheel never matched the way the wheels pointed. The steering wheel needed to be around 10-15 degrees to the right to go straight. After 3 wheel alignment's, the steering wheel still isn't straight to get the car to travel straight, but having to keep the wheel 3 degrees to the right is better than 10 degrees.

While driving down the road in traffic, several errors started appearing on the Tesla screen, and the vehicle lost power brakes and steering, rendering it impossible to drive safely. The complete set of car systems that were disabled all at once was: stability control disabled traction control disabled automatic vehicle hold disabled lane departure avoidance unavailable ABS disabled steering assist reduced (no power steering) regenerative braking features temporarily limited automatic emergency braking disabled The car is only weeks old. We had the car towed to a Tesla repair center, and they said due to a wiring issue, the wheel weight on the right rear wheel was rubbing against the wire connecting the wheel speed sensor, which led to this cascading series of errors. I'm concerned this is a systemic issue with newer Model Ys. There's a QA or manufacturing defect, and Tesla, along with the NHTSA, needs to investigate this dangerous safety issue.

I lost the ability to steer the Tesla Model Y. After exiting the vehicle, I found a bolt on the pavement beside the vehicle (see photo) that fell out of the steering mechanism. Had this happened at high speed, a fatal accident could have occurred. We called Tesla Roadside Assistance; they responded within an hour, towed the vehicle to the repair facility, and replaced the parts and aligned the front end.

Automatic emergency braking occurs without cause at high speeds on flat divided Hwy. Happened on multiple trips 5 or more times in a 3 hour drive on 3 different highways in NM. Tesla service has addressed the issue twice. said everything is working properly. Happens when Cruse control + auto steering are active.

Tesla autopilot made a turn into oncoming traffic without warning and caused a collision.

Vehicle steering lost power steering and the steering is stuck in straight position only while driving. Vehicle can travel only straight line forward or backward and cannot turn. Powering off and on did not help resolve the issue. Had to get the car towed to Tesla service.

Took delivery of new Tesla Model Y on Friday, March 24th. While driving it to my residence (205 miles away) noticed that the alignment was off and vehicle pulled to the left at highway speeds on flat, level sections of roadway. I was not informed of the 100 miles or 7 days to report issues with vehicle. I scheduled service with Tesla with odometer reading of 348. Tesla service verified the issue and corrected it but charged me $275 for an issue that was present from factory.

We leased the brand new Model Y on Tuesday January 24th at Tesla, Rockville, MD. On Friday January 27th at approximately 4:30pm we were driving on RT773 Riverside Parkway in the right hand lane and the steering wheel came totally out of the column with wires and electronic exposed. I was able to slow the car down and the car went up on the curb. I kept trying to put the steering wheel back in the column and somehow managed to get it in enough to drive home which was 5 miles away. All of the electronics did not work. Tesla came and towed the car the same evening. There was no working warning. Tesla towed the car and the next day on Saturday said the bolt to the steering column was loose and became dislodged.

Intermittent shaking from the two front wheels while driving.

I bought this car on January 24, 2023, I was driving with my family on Route 1 South in Woodbridge, NJ and all the sudden steering wheel fall January 29, 2023 . Was lucky there was no car behind and able to pull on divider. https://twitter.com/preneh24/status/1619889507133976580?s=48&t=-diw7ET9CNnRr31mHffyfw