2004 TOYOTA 4RUNNER Problems & Recalls

What component or system failed or malfunctioned, and is it available for inspection upon request? Response: Frame, Suspension, Airbags / Yes it is available for inspection. How was your safety or the safety of others put at risk? Response: Safety was put at risk due to frame & suspension failur...

What component or system failed or malfunctioned, and is it available for inspection upon request? Response: Frame, Suspension, Airbags / Yes it is available for inspection. How was your safety or the safety of others put at risk? Response: Safety was put at risk due to frame & suspension failur...

What component or system failed or malfunctioned, and is it available for inspection upon request? Response: Frame, Suspension, Airbags / Yes it is available for inspection. How was your safety or the safety of others put at risk? Response: Safety was put at risk due to frame & suspension failur...

The body frame on this vehicle is almost completely rushed out. I don’t know what to do. If I should have the frame replaced I know there’s been a couple recalls on similar Toyota models.

The contact owns a 2004 Toyota 4Runner. The contact stated that while the vehicle was in for service, the independent mechanic discovered rust on the front driver's side subframe. Additionally, the subframe had developed holes due to rust. The cause of the failures was not yet determined, and the ve...

Mileage: 120,000

The contact owns a 2004 Toyota 4-Runner. The contact stated that the frame was severely rusted. The vehicle was not diagnosed or repaired by an independent mechanic or a dealer. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mil...

Mileage: 108,000

2004 Toyota 4Runner SR5 - Frame rust: currently not drivable due to complete breakage from the rust. Driving 2 hours home on the highway I almost lost control, pressing/releasing the brake and/or gas pulls the steering side to side and sways the truck (fish tail) due to damage from the frame rust/br...

2004 Toyota 4Runner SR5 - Frame rust: currently not drivable due to complete breakage from the rust. Driving 2 hours home on the highway I almost lost control, pressing/releasing the brake and/or gas pulls the steering side to side and sways the truck (fish tail) due to damage from the frame rust/br...

Rusting frame, no specific incident date. Used today’s date.

Frame rust. Huge problems on the 4th gen 4runners. Can't believe there's not a recall on this issue.

Excessive frame and suspension corrosion that could lead to serious accidents if not repaired at a very high cost for myself

The undercarriage is full of rust that the repair shop will not test drive or fix due to the issue. No warnings.

Extensive frame rust to the point of structural failure. Cannot support weight or force.

Rusty frame undercarriage. It’s not going to get any better due to the fact I have to drive on hwy 80 with all the construction, that’s a hazard itself, potholes everywhere that puts stress on your frame and the salt every winter.

Rusty frame undercarriage. It’s not going to get any better due to the fact I have to drive on hwy 80 with all the construction, that’s a hazard itself, potholes everywhere that puts stress on your frame and the salt every winter.

Rusty frame undercarriage. It’s not going to get any better due to the fact I have to drive on hwy 80 with all the construction, that’s a hazard itself, potholes everywhere that puts stress on your frame and the salt every winter.

Underbody of vehicle is rusting away from vehicle body, I was made aware of situation at a service appointment in April of 2022, no vehicle collision or wreck has happened because of it yet,

UNKNOWN: Excessive frame rust. frame is excessively rusting to the point where the brakes and suspensions is connected to the frame has been compromised. brake lines rusted to the point of failure, thus almost causing a wreck. Vehicle is now parked due to safety concerns involving the excessive rust...

UNKNOWN: Excessive frame rust. frame is excessively rusting to the point where the brakes and suspensions is connected to the frame has been compromised. brake lines rusted to the point of failure, thus almost causing a wreck. Vehicle is now parked due to safety concerns involving the excessive rust...

UNKNOWN: Excessive frame rust. frame is excessively rusting to the point where the brakes and suspensions is connected to the frame has been compromised. brake lines rusted to the point of failure, thus almost causing a wreck. Vehicle is now parked due to safety concerns involving the excessive rust...

Undercarriage frame rusted to the point where structural rust was formed in various places This rust has made a whole and cracks to the frame causing my vehicle to become a safety hazard on the road

I recently bought a 2004 Toyota 4 Runner and the frame of the vehicle has significant corrosion to the extent of holes, weld failures and more. I've never seen frame rust so bad on a vehicle like this. I'm a little uneasy about the safety of this situation. I think Toyota should replace the frame or...

Cars frame is rotting out to the point it is not safe to drive. I was told being in a collision could cause catastrophic failure and the car is just turning 20 years old with 125,000 miles. Can’t get my money back and the car is otherwise is excellent condition.

Cars frame is rotting out to the point it is not safe to drive. I was told being in a collision could cause catastrophic failure and the car is just turning 20 years old with 125,000 miles. Can’t get my money back and the car is otherwise is excellent condition.

Frame is severely rusted and has holes started at 40k miles

Frame is severely rusted and has holes started at 40k miles

Something is causing the straps to fray I was informed this is a a problem, checked my seat and sure enough my straps are fraying. Evenflo says it’s my fault.

Something is causing the straps to fray I was informed this is a a problem, checked my seat and sure enough my straps are fraying. Evenflo says it’s my fault.

Took 2004 Toyota 4Runner SR5 to Toyota dealership to be serviced. Dealership called me to explain unable to do alignment, due to rear back frame excessive rusted through. Dealership advised waste of money to align new tires just purchased, unable to even do alignment and it was dangerous. Now what i...

Took 2004 Toyota 4Runner SR5 to Toyota dealership to be serviced. Dealership called me to explain unable to do alignment, due to rear back frame excessive rusted through. Dealership advised waste of money to align new tires just purchased, unable to even do alignment and it was dangerous. Now what i...

Took 2004 Toyota 4Runner SR5 to Toyota dealership to be serviced. Dealership called me to explain unable to do alignment, due to rear back frame excessive rusted through. Dealership advised waste of money to align new tires just purchased, unable to even do alignment and it was dangerous. Now what i...

The rear tailgate window shattered while vehicle was in driveway as soon as it was turned off. Before it shattered there was an odor of something like plastic burning. Fortunately no one was hurt by the exploding bits of glass. The sound the breaking glass make was loud and startled the passengers. ...

The rear tailgate window shattered while vehicle was in driveway as soon as it was turned off. Before it shattered there was an odor of something like plastic burning. Fortunately no one was hurt by the exploding bits of glass. The sound the breaking glass make was loud and startled the passengers. ...

2004 4Runner rear hatch glass imploded with rear defroster on while driving and glass shattered all inside the vehicle in the back behind rear passenger seat. The loud sound when it imploded sounded like we had got shot at and scared all four of us in the vehicle thinking we were shot at. We pulled ...

2004 4Runner rear hatch glass imploded with rear defroster on while driving and glass shattered all inside the vehicle in the back behind rear passenger seat. The loud sound when it imploded sounded like we had got shot at and scared all four of us in the vehicle thinking we were shot at. We pulled ...

Excessive frame rusting. There are holes in the frame from rusting. At this point in time there isn’t anything I can do about the issues. Frame is unrepairable.

Unknown: we were on [XXX] when the car went out of control. It first spun one way and then the other way and then we hit the concrete abutment where the guardrail connects to it. We hit it head on. It was as if we were on ice or oil, unable to gain control or brake. We checked the road and it was d...

Unknown: we were on [XXX] when the car went out of control. It first spun one way and then the other way and then we hit the concrete abutment where the guardrail connects to it. We hit it head on. It was as if we were on ice or oil, unable to gain control or brake. We checked the road and it was d...

Unknown: we were on [XXX] when the car went out of control. It first spun one way and then the other way and then we hit the concrete abutment where the guardrail connects to it. We hit it head on. It was as if we were on ice or oil, unable to gain control or brake. We checked the road and it was d...

I have taken my car to Mountain states Toyota as well as corwin toyota for a tripped light it has to do with vehicle stability system it trips leaving the vehicle stability option not usable. I have told both dealers not to just reset the code however this is what’s happening and they don’t seem...

I have taken my car to Mountain states Toyota as well as corwin toyota for a tripped light it has to do with vehicle stability system it trips leaving the vehicle stability option not usable. I have told both dealers not to just reset the code however this is what’s happening and they don’t seem...

I own a 2004 Toyota 4runner Sport Edition that suffers from frame rust issues. Mine isn't as bad as I've seen in person while working at a Toyota dealership as a tech or on the forums but from my experience in assisting in replacing frames at the dealership I know that my frame won't last very long....

Entire frame of the vehicle is rotten with rust and holes. This vehicle has been inspected by McDaniel Toyota, Marion, OH 43302 and the damage was confirmed. I have been and must continue to drive this vehicle even though the dealership did not recommend it. No evidence of the extent of the rus...

Entire frame of the vehicle is rotten with rust and holes. This vehicle has been inspected by McDaniel Toyota, Marion, OH 43302 and the damage was confirmed. I have been and must continue to drive this vehicle even though the dealership did not recommend it. No evidence of the extent of the rus...

Rusted frame

Frame of this vehicle completely rusted through. Holes on passenger side right where the front door ends. Hole is approx 12" long. Frame also has a hole in the left front core support. Advised that the vehicle is no longer safe to drive by my Toyota Dealer and personal mechanic. . There were no ind...

Frame of this vehicle completely rusted through. Holes on passenger side right where the front door ends. Hole is approx 12" long. Frame also has a hole in the left front core support. Advised that the vehicle is no longer safe to drive by my Toyota Dealer and personal mechanic. . There were no ind...

The contact owns a 2004 Toyota 4Runner. The contact stated while driving 55 MPH, the ABS and the brake warning lights illuminated. Additionally, there was an abnormal humming sound coming from the dash. The contact stated while approaching another vehicle, he depressed the brake pedal, but the vehic...

Mileage: 350,325

The contact owns a 2004 Toyota 4Runner. The contact stated while driving 55 MPH, the ABS and the brake warning lights illuminated. Additionally, there was an abnormal humming sound coming from the dash. The contact stated while approaching another vehicle, he depressed the brake pedal, but the vehic...

Mileage: 350,325

Purchased 4 runner from a Toyota dealer in 2018 with 130k miles. During routine maintenance in 2021 with 160k. The frame was found to have several holes and wide spread corrosion. It is absurd that Toyotas was let off the hook for frame replacements. I bought this truck from the dealer and it ha...

Purchased 4 runner from a Toyota dealer in 2018 with 130k miles. During routine maintenance in 2021 with 160k. The frame was found to have several holes and wide spread corrosion. It is absurd that Toyotas was let off the hook for frame replacements. I bought this truck from the dealer and it ha...

The frame of the vehicle rust just as same as the 03-09 Tacoma and there is nothing I can do the fix it and if I get new parts it ruins my Parts after a short period of time

The contact owns a 2004 Toyota 4Runner. The contact stated while driving 30 MPH over a bump in the road, she heard an abnormally loud sound and the windshield shattered without impact and the sunroof panel loosened. The contact also stated that the vehicle was shaking uncontrollably. The contact sta...

Mileage: 160,000

The contact owns a 2004 Toyota 4Runner. The contact stated while driving 30 MPH over a bump in the road, she heard an abnormally loud sound and the windshield shattered without impact and the sunroof panel loosened. The contact also stated that the vehicle was shaking uncontrollably. The contact sta...

Mileage: 160,000

I have. Toyota 4Runner the frame is very rusty I ask the. Dealer few times for recall and he said no. Recall. It is very dangerous to drive. The buddy is very nice just the frame is very rusty. Want ca I do need help

The frame of my Toyota 4-Runner has developed holes making it dangerous to drive.

The contact's mother owns a 2004 Toyota 4-Runner. The contact stated that after the vehicle was taken to an independent mechanic for a routine oil change, his mother was made aware that the subframe had excessive corrosion, and that the subframe needed to be replaced. The mechanic informed the conta...

Mileage: 180,330

Frame rusted through on left rear of vehicle were suspension parts are attached.

The contact owns a 2004 Toyota 4Runner. The contact stated that while the vehicle was in for routine service, it was discovered that the subframe had sustained severe rusting and corrosion. The contact indicate that there was a hole going through the subframe while the vehicle was being lifted at th...

Mileage: 146,000

Frame and body prematurely and aggressively rusted despite constant care and upkeep. Toyota recalled the exact frame on their Tacoma of the same years and did not recall the 4runner frames. It’s criminal and dangerous to the user and other vehicles on the road.

Frame is falling apart rusted right out unsafe to drive a truck I'm making payments on.

-The frame is rotted out - If the frame were to break, which my mechanic i saying is very possible, a massive incident could occur - It has been confirmed by an independent service center - It has not been inspected by the manufacturer but is an astonishingly common issue Toyota is very aware of tha...

-The frame is rotted out - If the frame were to break, which my mechanic i saying is very possible, a massive incident could occur - It has been confirmed by an independent service center - It has not been inspected by the manufacturer but is an astonishingly common issue Toyota is very aware of tha...

The frame is damaged from excessive corrosion. The rear cross member that supports the trailer hitch and rear bumper is almost non-existent, which could result in the loss of the trailer being towed, and it will reduce the truck's rear impact resistance. The front right lower control arm has a 2'" x...

The frame is damaged from excessive corrosion. The rear cross member that supports the trailer hitch and rear bumper is almost non-existent, which could result in the loss of the trailer being towed, and it will reduce the truck's rear impact resistance. The front right lower control arm has a 2'" x...

The contact owns a 2004 Toyota 4Runner. The contact stated that he noticed that the tow hitch had separated from the frame and was laying on the ground. The contact stated upon inspecting the subframe of the vehicle, he noticed that the subframe to which the radiator mount was attached was severely ...

Mileage: 224,000

The frame is showing significant rust damage throughout the frame. A hole was punctured in the passenger side while using the factory bottle jack. This could have ended badly if someone was underneath when this happened. Furthermore there is deterioration on the front and rear sections that are ques...

The truck frame is rusting and making the vehicle unsafe prematurely. My vehicle only has 78 thousand miles and likely needs the frame replaced like many other toyota vehicle because of the lack of corrosion protection.

The truck frame is rusting and making the vehicle unsafe prematurely. My vehicle only has 78 thousand miles and likely needs the frame replaced like many other toyota vehicle because of the lack of corrosion protection.

We took our 2004 4Runner for annual vehicle inspection and the service provider told us the vehicle would not pass safety inspection due to the excessive rusting on the steel frame and the suspension of the vehicle. Welding and patchwork will not fix this issue. My husband depends on this vehicle ...

We took our 2004 4Runner for annual vehicle inspection and the service provider told us the vehicle would not pass safety inspection due to the excessive rusting on the steel frame and the suspension of the vehicle. Welding and patchwork will not fix this issue. My husband depends on this vehicle ...

The body frame is the problem, it has rust all around, the radiator supports are all rusted out almost hanging, front side of the frame and rear side are clearly rusted. Radiator could fall any time. The problem was confirmed by auto shop and inspection shop (independent service center). Vehicle has...

The frame of my 2004 Toyota 4Runner, which is manufactured by Dana Holding Corporation, is the primary support structure of my vehicle, to which every piece is attached. It is the main protection against injury in a car accident. The excessive rust corrosion of the frame on my Toyota 4Runner great...

Complete frame rust-out. Suspension at rear axle disintegrated. Vehicle undriveable. My son had just taken the vehicle (moving his belongings) from Minnesota to the East Coast and back. No problems or issues. After returning, while driving the vehicle I had a hard braking event which is when I notic...

The body is excessively rusted through. Other vehicles this age or older do not have any where near the amount of excessive rust and holes. Parts have fallen off. Anytime the shop has to work on the truck, there is a pile of rust under it. Broken off rust poses a hazard to owner and others on the r...

Extreme Rusting on the frame undercarriage of the vehicle. Our mechanic found it today - said it must have been rusting for years & that this is a common problem with 03 - 05 Toyota 4Runners.

The chassis is completely rusted/rotten, 1" Holes throughout the chassis and was told that it won't pass inspection.

The chassis is completely rusted/rotten, 1" Holes throughout the chassis and was told that it won't pass inspection.

Unaware of frame rusting issues to vehicle.. Observed rust through carpet on driver side. Upon research safety is a concern. Due to high volume of this type of issuing occurring a safety recall should be issued. It was not verbalized at time of purchase the make and model of vehicle have these type ...

I bought my 2004 Toyota 4runner Sport edition as a new car, and have been the sole owner of the vehicle. I have taken good care of it the entire time. Regular car washes, service maintenance and necessary repairs over time. I recently had my 4runner in for repairs and spent a considerable amount...

I bought my 2004 Toyota 4runner Sport edition as a new car, and have been the sole owner of the vehicle. I have taken good care of it the entire time. Regular car washes, service maintenance and necessary repairs over time. I recently had my 4runner in for repairs and spent a considerable amount...

I bought my 2004 Toyota 4runner Sport edition as a new car, and have been the sole owner of the vehicle. I have taken good care of it the entire time. Regular car washes, service maintenance and necessary repairs over time. I recently had my 4runner in for repairs and spent a considerable amount...

The right rear control arm mount completely rusted away from the frame. Causing it to start fish-tailing out of control. Also there are other mounts that have rusted through. Like for instance, the gas tank strap mounted to the frame. There are also more areas of the frame that are rusting through. ...

2004 Toyota 4 runner frame is corroded so bad and dealer mechanic thinks it is a default of manufacturer and suggested I file a complaint with you. He said many Toyota 4 runners having same issue and it is a safety hazzard.

The frame is rusted through on this 4Runner. Same frame as the tacomas that were recalled and I’m wondering why Toyota wouldn’t recall THE SAME EXACT FRAME WITH MAJOR RUST ISSUES on a different platform. This truck is not abused so it’s very frustrating to see it falling apart at the frame whe...

vehicle failed inspection due to hole in frame-- 08/14/20-- had to cover repairs--under body has severe frame damage from rust--toyota recalled and replaced truck frames from bad steel on 2004 tacomas but not to the 2004 4runners

My Car was inspected by a Virginia Inspection Station and was cited for significant rust holes in the frame which have to be repaired. The frame should not have such significant rust that it needs to be fixed or it will be a hazard on the road. Based on other litigation around Toyota fames from this...

The entire frame is rusted. It's been welded back together on 2 different occasions. The last time it happened I was pulling out of driveway and the vehicle cannot be steered at all. I live in east TN and should not have a rusted frame. This is not an isolated problem. This is a problem with the 4ru...

My 4 runner only has 147,000 miles and is a great running vehicle but my frame is rotted badly. I have large holes throughout, the front crossmember under radiator with tow hooks has completely rusted off, and now I found where my rear lower drag link bolts to frame is about to come off. I have had ...

My 4 runner only has 147,000 miles and is a great running vehicle but my frame is rotted badly. I have large holes throughout, the front crossmember under radiator with tow hooks has completely rusted off, and now I found where my rear lower drag link bolts to frame is about to come off. I have had ...

My 4 runner only has 147,000 miles and is a great running vehicle but my frame is rotted badly. I have large holes throughout, the front crossmember under radiator with tow hooks has completely rusted off, and now I found where my rear lower drag link bolts to frame is about to come off. I have had ...

2004 Toyota 4Runner, original owner with roughly 210K miles. We took the vehicle to the mechanic concerning a sway bar issue. He informed us that the frame of the vehicle was nearly rusted into and that it's serious safety issue to continue to drive it. It is my understanding the Toyota recalled sev...

Under body has severe frame damage from rust.

The frame of the vehicle has rusted so badly the Toyota Dealer I have taken to for diagnosis and repairs refuses to put the vehicle on their lift to inspect or work on the underside of the car for fear of the safety of their workers. This is not a new problem for Toyota because they have lost a civi...

The frame is rusted completely throughout. VERY DANGEROUS!

The frame is rusted completely throughout. VERY DANGEROUS!

The frame is rusted completely throughout. VERY DANGEROUS!

Vehicle has a rust frame which causes a dangerous

Vehicle has a rust frame which causes a dangerous

Rear section of the frame snapped in half during normal driving. Barely driveable extremely hazardous and will remained parked.

Rear section of the frame snapped in half during normal driving. Barely driveable extremely hazardous and will remained parked.

Seized front right brake caliper caused vehicle to slide off road during sudden stop to avoid debris in roadway. Took vehicle to a brake shop and they found that right front wheel was locked. This is the third time I have had the EXACT same problem with the brake system. The previous times, the p...

The frame rusted and at least two parts of the frame rusted through. Informed by the mechanic upon state inspection. On or around October 18, 2021

Took vehicle for service a couple of days ago. Mechanic would not work on the vehicle due to extensive frame rust and corrosion. Mechanic said he could push his finger through some of the rusted frame members. Extensive frame rust/corrosion on at least 3 sides of the vehicle and sagging frame in ...

Frame rust discovered by state inspection mechanic, vehicle fails for frame members rusted through. May not be repairable.

Side curtain shield airbags.

My steering became very loose with a lot of movement in the steering wheel. The universal joint in the steering column shaft was bad. Upon further investigation, both lower control arms on the front wheels were rusted through, (from the inside out), with one of them bent because of the lack of met...

My steering became very loose with a lot of movement in the steering wheel. The universal joint in the steering column shaft was bad. Upon further investigation, both lower control arms on the front wheels were rusted through, (from the inside out), with one of them bent because of the lack of met...

My steering became very loose with a lot of movement in the steering wheel. The universal joint in the steering column shaft was bad. Upon further investigation, both lower control arms on the front wheels were rusted through, (from the inside out), with one of them bent because of the lack of met...

Extensive rust on frame and suspension parts. Areas completely rusted through, presenting safety hazard.

I took my car in for repair. Check engine light and VSC track lights on with horrible sound beneath the car. The auto repair shop called me and said the frame and underbody of the car is so rusted it will break apart if I drive over a pothole. So rusted that there is nothing to be able to attach to ...

I took my car in for repair. Check engine light and VSC track lights on with horrible sound beneath the car. The auto repair shop called me and said the frame and underbody of the car is so rusted it will break apart if I drive over a pothole. So rusted that there is nothing to be able to attach to ...

The contact owned a 2004 Toyota 4 Runner. The contact stated that the driver’s and front passenger air bags failed. The contact stated that when at complete a stop at the red traffic light, the vehicle in the rear failed to stop and crashed into the contact's vehicle rear-end, pushing the vehicle ...

Mileage: 238,000

The control arms rusted completely off the frame. The whole frame has rust holes!

Frame started excessive rusting before 2011 when the vehicle had very low miles on it. I reported it to Toyota National headquarters in 2016. They knew about it but since they didn't have to replace the frames they didn't care. They offered me $1000 towards a new car. I could not afford a new car. ...

Frame started excessive rusting before 2011 when the vehicle had very low miles on it. I reported it to Toyota National headquarters in 2016. They knew about it but since they didn't have to replace the frames they didn't care. They offered me $1000 towards a new car. I could not afford a new car. ...

Original owner of 2004 Toyota 4Runner SR5 (purchased February 23, 2004). Garage kept and approximately 125,000 miles. Vehicle was taken to mechanic for exhaust issues and reported the flange had rusted and disintegrated providing $2300 quote to repair. Taken to a second shop that indicated rust on f...

My Frame is a rusted mess. The entire frame is experiencing rust issues. My rear sway bar rusted off and broke into pieces (1/15/21). Now my exhaust pipe has fell off the muffler due to rust (7/21/21). My brake calipers have been very badly rusted as well as the pieces that hold my shocks and su...

My 2004 Toyota 4Runner has holes multiple inches in diameter rusted completely through the frame in multiple locations including where frame rails meet and are welded. This 4Runner is very clean and well kept in a climate controlled garage. The 4Runner was somehow not captured in the class-action ...

My 2004 Toyota 4Runner has holes multiple inches in diameter rusted completely through the frame in multiple locations including where frame rails meet and are welded. This 4Runner is very clean and well kept in a climate controlled garage. The 4Runner was somehow not captured in the class-action ...

The frame on my 4Runner is severely rusted out; it is available to be inspected if requested. When I'm driving, the vehicle is potentially unstable due to frame rot which could cause potentially life threating injuries to myself, my passengers, and others on the road. The problem has been confirme...

Last year the frame showed rust and holes and was rejected by the inspector. We were able to get the worst hole patched and it passed inspection. I am afraid the car might be unsafe.

Last year the frame showed rust and holes and was rejected by the inspector. We were able to get the worst hole patched and it passed inspection. I am afraid the car might be unsafe.

The contact owns a 2004 Toyota 4Runner. The contact stated while driving at various speeds, there was a loud sound coming from underneath the vehicle. The contact looked under the vehicle and saw several holes throughout the subframe of the vehicle due to rust. The vehicle was taken to an independen...

Mileage: 130,000

On April 14, 2019, I was informed by an auto repair shop that my 2004 Toyota 4Runner showed signs of excessive rusting on the front end of the frame at the bumper and radiator support. The repair shop owner/mechanic indicated the bumper may eventually fall off. At the time, the odometer reading was ...

On April 17, 2019, I was informed by P.R. Auto Repair that my 2004 Toyota 4Runner showed signs of excessive rusting on the front end of the frame at the bumper support and radiator support. This observation was noted by the auto repair shop's owner. It is important to point out that my truck had on...

Severe rusting of body frame

The frame is rusted very badly and may need to be salvaged. Many of the other Toyota vehicles in this same year which have the same frame have already been recalled. Why not the 4runners? I've owned many other early 2000's vehicles and none have had this bad of rust. Simple not acceptable and not sa...

OUR 2004 TOYOTA FORERUNNER WITH V6 ENGINE WAS PURCHASED AS A USED VEHICLE IN 2019 WITH 106,000 MILES ON IT. SINCE THEN, IT HAS DEVELOPED MORE AND MORE AREAS OF RUST ON THE FRAME DESPITE OUR EFFORTS TO MITIGATE THIS ISSUE. WE HAVE HAD TO REPAIR THE FRAME, SUSPENSION, BRAKES, AND WHEEL BEARINGS. WE CO...

Mileage: 143,000

OUR 2004 TOYOTA FORERUNNER WITH V6 ENGINE WAS PURCHASED AS A USED VEHICLE IN 2019 WITH 106,000 MILES ON IT. SINCE THEN, IT HAS DEVELOPED MORE AND MORE AREAS OF RUST ON THE FRAME DESPITE OUR EFFORTS TO MITIGATE THIS ISSUE. WE HAVE HAD TO REPAIR THE FRAME, SUSPENSION, BRAKES, AND WHEEL BEARINGS. WE CO...

Mileage: 143,000

OUR 2004 TOYOTA FORERUNNER WITH V6 ENGINE WAS PURCHASED AS A USED VEHICLE IN 2019 WITH 106,000 MILES ON IT. SINCE THEN, IT HAS DEVELOPED MORE AND MORE AREAS OF RUST ON THE FRAME DESPITE OUR EFFORTS TO MITIGATE THIS ISSUE. WE HAVE HAD TO REPAIR THE FRAME, SUSPENSION, BRAKES, AND WHEEL BEARINGS. WE CO...

Mileage: 143,000

THE ORIGINAL FRAME ON OUR CAR IS ALMOST COMPLETELY RUSTED. THERE ARE HOLES IN THE FRAME AND COMPLETE CORROSION ALONG THE SIDE BEAMS. THIS IS A HUGE SAFETY HAZARD WHILE DRIVING. THERE IS SO MUCH RUST ON THE UNDERBODY. ALL PARTS ARE COMPLETELY STOCK AND ORIGINAL. THIS SHOULD NOT BE A PROCESS WE HAVE T...

TOYOTA MADE GARBAGE BOXED IN FRAMES AND NOW MY TRUCK WON'T PASS INSPECTION

Mileage: 226,000

EXCESSIVE FRAME RUST CAUSING FRONT RIGHT FRONT BODY MOUNT TO DETACH FROM THE FRAME, PASSENGER FRAME RAIL HAS DISINTEGRATED BETWEEN CROSSMEMBERS. THE 4RUNNER HAS 170000 MILES ON IT WITH NO BODY RUST.

Mileage: 169,000

I HAVE ANOTHER 4 RUNNER WITH A HEAVILY RUSTED FRAME. I AM VERY CONCERNED THAT A UNSEEN FAILURE CAN OCCUR WHILE TOWING A 4300 POUND CAMER OR WHILE DRIVING ON ROUGH ROADS. I'M NOT ONLY CONCERNED FOR MY WIFE AND I BUT ALSO FOR OUR GRANDKIDS THAT VISIT US MONTHLY. HERE IS THE ACTUAL FAILURE. MY WIFE CAM...

Mileage: 207,800

I HAVE ANOTHER 4 RUNNER WITH A HEAVILY RUSTED FRAME. I AM VERY CONCERNED THAT A UNSEEN FAILURE CAN OCCUR WHILE TOWING A 4300 POUND CAMER OR WHILE DRIVING ON ROUGH ROADS. I'M NOT ONLY CONCERNED FOR MY WIFE AND I BUT ALSO FOR OUR GRANDKIDS THAT VISIT US MONTHLY. HERE IS THE ACTUAL FAILURE. MY WIFE CAM...

Mileage: 207,800

EXCESSIVE RUST/ROT ON THE FRAME, WHICH IS LEADING TO EXPENSIVE REPAIRS AND FEARS OF UNSAFE OPERATION.

Mileage: 170,000

I PURCHASED THIS VEHICLE IN 2015 WITH 111K MILES ON IT. JUST FOUND OUT TODAY MARCH 2 THAT THE FRAME IS SHOT AND THE CONTROL ARMS FOR THE REAR AXLE HAVE LET GO ON BOTH SIDES DO TO FRAME ROT, THERE ARE ALSO OTHER QUESTIONABLE PARTS OF THE FRAME. SO VERY DISAPPOINTED IN THIS TOYOTA VEHICLE. THIS CAR CO...

MANY SIGNS OF PREMATURE RUST ON THE FRAME WITH SEVERAL HOLES. THE TRUCK ONLY HAS 124K MILES AND SHOULD NOT BE IN THIS STATE. TOYOTA HAS TO RECALL THESE FRAMES JUST LIKE THEY DO FROM OTHER TRUCKS MANUFACTURED DURING THE VERY SAME YEARS.

MANY SIGNS OF PREMATURE RUST ON THE FRAME WITH SEVERAL HOLES. THE TRUCK ONLY HAS 124K MILES AND SHOULD NOT BE IN THIS STATE. TOYOTA HAS TO RECALL THESE FRAMES JUST LIKE THEY DO FROM OTHER TRUCKS MANUFACTURED DURING THE VERY SAME YEARS.

MY VEHICLE HAS SEVERE FRAME ROT, ALL OF WHICH COMING FROM THE FACTORY WELDS TO THE SURFACE POINTS ALONG WITH IT'S ROTTING FROM THE INSIDE OUT ESPECIALLY AROUND THE FRONT LOWER CONTROL ARM AREAS OF THE DRIVER AND PASSENGER SIDES OF THE VEHICLE. THIS ALSO REACHING THE BACK OF THE VEHICLES FRAME TOO.

VEHICLE FRAME HAS RUSTED COMPLETELY THROUGH IN CERTAIN AREAS - STRUCTURE AND SAFETY IS COMPROMISED .... NORMAL DRIVING & CARE ENVIRONMENT BUT APPEARS FRAME HAS ACCELERATED DETERIORATION, WHILE ALL OTHER AREAS (BODY PANELS, ALL OTHER COMPONENTS) ARE IN EXCELLENT CONDITION - SEEING THIS IS A KNOWN TOY...

Mileage: 150,000

VEHICLE FRAME HAS RUSTED COMPLETELY THROUGH IN CERTAIN AREAS - STRUCTURE AND SAFETY IS COMPROMISED .... NORMAL DRIVING & CARE ENVIRONMENT BUT APPEARS FRAME HAS ACCELERATED DETERIORATION, WHILE ALL OTHER AREAS (BODY PANELS, ALL OTHER COMPONENTS) ARE IN EXCELLENT CONDITION - SEEING THIS IS A KNOWN TOY...

Mileage: 150,000

VEHICLE FRAME HAS RUSTED COMPLETELY THROUGH IN CERTAIN AREAS - STRUCTURE AND SAFETY IS COMPROMISED .... NORMAL DRIVING & CARE ENVIRONMENT BUT APPEARS FRAME HAS ACCELERATED DETERIORATION, WHILE ALL OTHER AREAS (BODY PANELS, ALL OTHER COMPONENTS) ARE IN EXCELLENT CONDITION - SEEING THIS IS A KNOWN TOY...

Mileage: 150,000

PREMATURE AND EXCESSIVE FRAME CORROSION. SIMILAR MODELS WERE COVERED BY EARLIER FRAME RECALL, WHY NOT THE 4RUNNER?

Mileage: 138,000

PREMATURE AND EXCESSIVE FRAME CORROSION. SIMILAR MODELS WERE COVERED BY EARLIER FRAME RECALL, WHY NOT THE 4RUNNER?

Mileage: 138,000

MY 2004 4RUNNER LIMITED V6 HAS SIGNIFICANT RUST BUILD UP ON THE FRAME, CONTROL ARMS, DRIVESHAFT, ETC. I AM THE SECOND OWNER WITH JUST OVER 21K MILES DRIVEN IN THE PAST THREE YEAR AND RIGHT AT 160K TOTAL. I'VE MADE SURE TO GET REGULAR WASHES TO PROTECT THE UNDERCARRIAGE AFTER INCLEMENT WEATHER SI...

Mileage: 159,000

MY 2004 4RUNNER LIMITED V6 HAS SIGNIFICANT RUST BUILD UP ON THE FRAME, CONTROL ARMS, DRIVESHAFT, ETC. I AM THE SECOND OWNER WITH JUST OVER 21K MILES DRIVEN IN THE PAST THREE YEAR AND RIGHT AT 160K TOTAL. I'VE MADE SURE TO GET REGULAR WASHES TO PROTECT THE UNDERCARRIAGE AFTER INCLEMENT WEATHER SI...

Mileage: 159,000

EXCESSIVE FRAME RUST. OUR 4RUNNER HAS JUST PASSED THE 200K MILE MARK, BUT THE FRAME HAS BEEN RUSTING AT AN ALARMING RATE FOR YEARS NOW. LIVING IN AN AREA WITH SALTED WINTER ROADS, I HAVE BEEN SOMEWHAT MINDFUL OF THIS (NOT PERFECT), BUT THE AMOUNT OF CORROSION SEEMS EXCESSIVE, EVEN IN THIS ENVIRONM...

Mileage: 200,100

EXCESSIVE FRAME RUST. OUR 4RUNNER HAS JUST PASSED THE 200K MILE MARK, BUT THE FRAME HAS BEEN RUSTING AT AN ALARMING RATE FOR YEARS NOW. LIVING IN AN AREA WITH SALTED WINTER ROADS, I HAVE BEEN SOMEWHAT MINDFUL OF THIS (NOT PERFECT), BUT THE AMOUNT OF CORROSION SEEMS EXCESSIVE, EVEN IN THIS ENVIRONM...

Mileage: 200,100

TODAY I FAILED VEHICLE INSPECTION BECAUSE OF RUST AND DETERIORATION OF MY CHASSIS FRAME. THE VEHICLE WAS BOUGHT NEW, SELDOM DRIVEN IN ANY AREAS OF SALTED OR SANDED ROADS. IT WAS ALSO MOSTLY GARAGED EITHER AT WORK AND/OR AT HOME. THE VEHICLE ONLY HAS 175000 WHICH IS LOW CONSIDERING THE AGE OF THE ...

Mileage: 175,000

FRAME IS ROTTED 115K MILES ON THE CAR, IT SEEMS TO BE ROTTING AT THE WELDS ONLY.

Mileage: 100,000

FRAME RUSTS TOO EASILY. COATING WAS NOT GOOD ENOUGH FROM FACTORY. TACOMA'S WITH SAME FRAME WERE RECALLED.

Mileage: 170,000

I WAS INFORMED THAT WHEN I WENT TO GET MY OIL CHANGED THIS MORNING THAT I HAD MAJOR RUSH ON MY FRAME IT WAS CRACKED AND HAD BIG HOLES IN IT AND THEY WERE AFRAID TO PUT IT UP ON THE LIFT. ADVISED ME TO CHECK WITH MY DEALER TO SEE IF THERE WAS A RECALL. ACCORDING TO KBB THERE IS NOT WITH MY CORRESPOND...

I WAS INFORMED THAT WHEN I WENT TO GET MY OIL CHANGED THIS MORNING THAT I HAD MAJOR RUSH ON MY FRAME IT WAS CRACKED AND HAD BIG HOLES IN IT AND THEY WERE AFRAID TO PUT IT UP ON THE LIFT. ADVISED ME TO CHECK WITH MY DEALER TO SEE IF THERE WAS A RECALL. ACCORDING TO KBB THERE IS NOT WITH MY CORRESPOND...

THE FRAME HAS RUST AND HAS A HOLE. IT IS UNSAFE TO DRIVE AND WILL NEED TO BE ADDRESSED VERY SOON. THERE WAS NO SPECIFIC INCIDENT. I RECENTLY BOUGHT THIS CAR. I DON'T KNOW WHEN IT HAPPENED.

Mileage: 100,000

TL* THE CONTACT'S SON OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE HIS SON WAS DRIVING 15 MPH, HIS SON HEARD A LOUD POPPING SOUND AS THE REAR AXLE TRAILING ARM FELL OFF THE VEHICLE WITHOUT WARNING. DUE TO THE FAILURE, THE CONTACT HAD THE VEHICLE TOWED TO AN INDEPENDENT MECHANIC. THE MEC...

Mileage: 104,000

WHILE DRIVING THE VEHICLE AND AFTER TURNING ONTO A STATE HIGHWAY IT SUDDENLY SWERVED BADLY AND THE REAR END BEGAN SWAYING BACK AND FORTH MAKING IT UNCONTROLLABLE. I STOPPED THE CAR IMMEDIATELY. IT WAS DISCOVERED THAT THE FRAME HAD RUSTED SO BADLY IT BECAME SEPARATED FROM THE REAR AXLE. I HAD TO TOW ...

Mileage: 78,000

THE FRAME HAS COMPLETELY RUSTED

THIS 2004 4RUNNER WAS PURCHASED FROM A LOCAL DEALER IN SOUTH FLORIDA. THE CARFAX REPORT STATES THAT IT WAS PREVIOUSLY TITLED IN TEXAS AND THEN LATER IN NEW YORK. IT DID PASS THE NEW YORK STATE SAFETY INSPECTION IN 2020. HOWEVER, AFTER OWNING THE VEHICLE FOR A SHORT PERIOD I TOOK IT TO A MECHANIC FOR...

Mileage: 115,000

THE STRUCTURAL FRAME OF THE VEHICLE IS RUSTED OUT. HOLES, LARGE AREAS OF THE FRAME HAS RUSTED OUT. THE FRAME IS STRUCTURALLY COMPROMISED. JUST NOTED ON 10/19/20. VEHICLE WAS IN LESS THAN A YEAR EARLIER WITH NO SIGN OF THE DAMAGE.

Mileage: 165,000

I RECENTLY BOUGHT A USED 2004 4RUNNER AND WHEN I INSPECTED THE FRAME THERE WAS RUST EVERYWHERE. NOT ONLY SURFACE RUST BUT ACTUAL HOLES IN THE FRAME FROM IT. ALSO THE STEERING ASSEMBLY IS COMPLETELY RUSTED OUT. I'M NOT THE ONLY 4RUNNER OWNER WHO HAS EXPERIENCED THESE ISSUES. IF YOU DO A QUICK ONLINE ...

FRAME HAS SEVER RUST-THROUGH AND CORROSION ON THE PASSENGER SIDE IN FRONT OF THE REAR TRAILING LINK MOUNT AND BEHIND THE FRONT CONTROL ARM MOUNT. VEHICLE IS DRIVEN IN AN ENVIRONMENT WHERE ROAD SALT IS USED IN THE WINTER, BUT THIS IS EXCESSIVE COMPARED TO OTHER OLDER VEHICLES. VEHICLE IS WASHED REG...

Mileage: 155,000

FRAME HAS SEVER RUST-THROUGH AND CORROSION ON THE PASSENGER SIDE IN FRONT OF THE REAR TRAILING LINK MOUNT AND BEHIND THE FRONT CONTROL ARM MOUNT. VEHICLE IS DRIVEN IN AN ENVIRONMENT WHERE ROAD SALT IS USED IN THE WINTER, BUT THIS IS EXCESSIVE COMPARED TO OTHER OLDER VEHICLES. VEHICLE IS WASHED REG...

Mileage: 155,000

SEVERE FRAME RUST ON 2004 4RUNNER SR5 SPORT. SUSPENSION RUST, STEERING COMPONENTS RUST. HOLES IN VEHICLE FRAME DUE TO RUST. I WENT TO TWO MECHANICS THAT TOLD ME THAT THIS RUST WAS BEYOND REASONABLE FOR NORMAL RUST ON FRAME, THEY BOTH STATED IT MAY BECOME DANGEROUS AND TO CONTACT TOYOTA DIRECTLY. THE...

SEVERE FRAME RUST ON 2004 4RUNNER SR5 SPORT. SUSPENSION RUST, STEERING COMPONENTS RUST. HOLES IN VEHICLE FRAME DUE TO RUST. I WENT TO TWO MECHANICS THAT TOLD ME THAT THIS RUST WAS BEYOND REASONABLE FOR NORMAL RUST ON FRAME, THEY BOTH STATED IT MAY BECOME DANGEROUS AND TO CONTACT TOYOTA DIRECTLY. THE...

SEVERE FRAME RUST ON 2004 4RUNNER SR5 SPORT. SUSPENSION RUST, STEERING COMPONENTS RUST. HOLES IN VEHICLE FRAME DUE TO RUST. I WENT TO TWO MECHANICS THAT TOLD ME THAT THIS RUST WAS BEYOND REASONABLE FOR NORMAL RUST ON FRAME, THEY BOTH STATED IT MAY BECOME DANGEROUS AND TO CONTACT TOYOTA DIRECTLY. THE...

CORROSION WAS FOUND ON PASSENGER SIDE OF FRAME DURING 2020 STATE SAFETY INSPECTION CAUSING FAILURE OF SAID STATE INSPECTION. CORROSION WAS PREVIOUSLY FOUND ON DRIVER SIDE FRAME DURING 2018 STATE SAFETY INSPECTION AND WAS RECTIFIED BY BODY SHOP WELDER. VEHICLE IS GARAGED WHEN NOT IN USE.

Mileage: 181,000

MY 2004 TOYOTA 4RUNNER HAS DANGEROUS FRAME RUST PERFORATION. TOYOTA SOMEHOW WAS ALLOWED TO EXCLUDE 4RUNNERS, WHEN THEY WERE MADE TO REPLACE FRAMES ON SEQUOIA, TUNDRA, TACOMA, AND TACOMA TRUCKS OF SIMILAR VINTAGE. THERE IS NO REASON THAT IS FAIR NOR EQUITABLE TO 4RUNNER OWNERS BE DENIED FRAME REPLACE...

2004 TOYOTA 4RUNNER, THE FRAME IS RUSTED REALLY BAD. CAN'T LIFT IT WITH A HOIST AND PARTS THAT CONNECT TO IT FOR SUSPENSION ARE RUSTED AS WELL. NOT GOOD IF YOU HIT A BUMP AND IT BREAKS, COULD CAUSE A SERIOUS ACCIDENT.

SEVERE RUST ON THE FRAME.

FRAME RUST TO AN UNSAFE LEVEL AT LOW MILES AND FAR BEFORE ANY OTHER OXIDATION FORMED. BY 120,000 MILES, FRAME HAD SEVERE RUST, CORRODED COMPLETELY THROUGH FRONT AND REAR TOW HOOK SECTIONS, LOWER RADIATOR SUPPORT, AND LARGE SECTIONS OF MAIN FRAME RAILS (WORSE TOWARDS REAR NEAR SUSPENSION MOUNTING). ...

Mileage: 120,000

FRAME RUST TO AN UNSAFE LEVEL AT LOW MILES AND FAR BEFORE ANY OTHER OXIDATION FORMED. BY 120,000 MILES, FRAME HAD SEVERE RUST, CORRODED COMPLETELY THROUGH FRONT AND REAR TOW HOOK SECTIONS, LOWER RADIATOR SUPPORT, AND LARGE SECTIONS OF MAIN FRAME RAILS (WORSE TOWARDS REAR NEAR SUSPENSION MOUNTING). ...

Mileage: 120,000

TOYOTA 4 RUNNER HAS DEVELOPED SEVERE CORROSION OF THE FRAME AND HAS BEEN DEEMED UNSAFE TO OPERATE. VEHICLE HAS BEEN REGULARLY WASHED AND MAINTAINED BY SINGLE OWNER. VEHICLE HAS NOT BEEN USED FOR OFF-ROAD DRIVING. VEHICLE HAS NOT BEEN IN A COLLISION. STATE SAFETY INSPECTOR ADVISED OWNER THAT THERE...

Mileage: 2,020

TOYOTA 4 RUNNER HAS DEVELOPED SEVERE CORROSION OF THE FRAME AND HAS BEEN DEEMED UNSAFE TO OPERATE. VEHICLE HAS BEEN REGULARLY WASHED AND MAINTAINED BY SINGLE OWNER. VEHICLE HAS NOT BEEN USED FOR OFF-ROAD DRIVING. VEHICLE HAS NOT BEEN IN A COLLISION. STATE SAFETY INSPECTOR ADVISED OWNER THAT THERE...

Mileage: 2,020

RE: NHSTA ACTION # DP18002. I OWN A 2004 TOYOTA 4RUNNER AND HAVE HAD PROBLEMS SIMILAR TO THOSE NOTED IN THE REFERENCED CASE. UPON READING THE CASE DETAILS I INVESTIGATED MY 4RUNNER AND FOUND SIMILAR SERIOUS STRUCTURAL CORROSION PROBLEMS. I CONSULTED WITH A LOCAL VIRGINIA MOTOR VEHICLE STATE INSPE...

Mileage: 100,000

VEHICLE FRAME IS SEVERELY CORRODED AND IS UNSAFE TO DRIVE.

Mileage: 241,000

OUR 2004 4RUNNER WAS INSPECTED YESTERDAY (VIRGINIA REQUIRES ANNUAL INSPECTIONS), AND FAILED DUE TO RUST HOLES IN THE FRAME. WE HAVE A PHOTO OF THE HOLES. THIS SEEMS ODD TO US, BECAUSE THE BODY IS RUST FREE AND WE LIVE IN A SOUTHERN STATE WHERE THERE IS NOT A LOT OF ROAD SALT. VIRGINIA DOES NOT ALLOW...

Mileage: 160,000

VEHICLE HAS DEVELOPED SEVERE RUST HOLES IN THE FRAME, SUFFICIENT TO FAIL NY STATE INSPECTION. HOLES HAVE APPEARED, AND THE METAL AROUND THE HOLES IS ALSO SOFT DUE TO RUST. THIS WAS BROUGHT TO OUR ATTENTION WHEN WE BOUGHT THE CAR OUT OF STATE, REGISTERED IT IN NY, AND THE VEHICLE FAILED ON UNS...

Mileage: 187,500

RUST. I WAS TOLD I MAY NOT PASS INSPECTION NEXT TIME BECAUSE OF THE BADLY RUSTED FRAME. ALONG WITH THAT ISSUE, THE REAR HATCH IS RUSTING OFF THE VEHICLE. IT CAN NO LONGER OPEN AND CLOSE BECAUSE THE LATCHING MECHANISM HAS RUSTED OFF. THE REST OF THE VEHICLE IS PRETTY MUCH RUST FREE. WHY HAS IT R...

RUST. I WAS TOLD I MAY NOT PASS INSPECTION NEXT TIME BECAUSE OF THE BADLY RUSTED FRAME. ALONG WITH THAT ISSUE, THE REAR HATCH IS RUSTING OFF THE VEHICLE. IT CAN NO LONGER OPEN AND CLOSE BECAUSE THE LATCHING MECHANISM HAS RUSTED OFF. THE REST OF THE VEHICLE IS PRETTY MUCH RUST FREE. WHY HAS IT R...

MY 4RUNNER'S FRAME BROKE WHILE DRIVING DUE TO RUST. THERE'S A RECALL FOR TACOMA'S BUT NOT 4 RUNNERS. I THANKFULLY WAS NOT INJURED BUT NOW I'M WITHOUT A VEHICLE. WHEN I BOUGHT MY 4 RUNNER I WAS UNDER THE IMPRESSION TOYOTA WAS #1 WHEN IT CAME TO SAFETY FOR THEIR CUSTOMERS. PLEASE HELP ME

Mileage: 190,000

THIS WELL MAINTAINED VEHICLE HAD BEEN FUNCTIONING FLAWLESSLY UP TO THIS POINT. OUR SON WAS ON HIS WAY HOME AND VEHICLE FELT UNSTABLE AND STARTED TO VEER IN BOTH DIRECTIONS. HE MAINTAINED CONTROL OF THE VEHICLE AND WAS ABLE TO GET HOME. I PERSONALLY DROVE THE VEHICLE UPON HIS DESCRIPTION AND SURE ENO...

Mileage: 220,000

THIS WELL MAINTAINED VEHICLE HAD BEEN FUNCTIONING FLAWLESSLY UP TO THIS POINT. OUR SON WAS ON HIS WAY HOME AND VEHICLE FELT UNSTABLE AND STARTED TO VEER IN BOTH DIRECTIONS. HE MAINTAINED CONTROL OF THE VEHICLE AND WAS ABLE TO GET HOME. I PERSONALLY DROVE THE VEHICLE UPON HIS DESCRIPTION AND SURE ENO...

Mileage: 220,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS EXTREMELY CORRODED WHICH CAUSED THE TOW BAR TO FRACTURE AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE SEVERITY OF THE CORROSION. THE CONTACT WA...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE UNDERCARRIAGE OF THE VEHICLE WAS EXTREMELY CORRODED WHICH CAUSED THE TOW BAR TO FRACTURE AND DETACHED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE SEVERITY OF THE CORROSION. THE CONTACT WA...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN FOR INSPECTION, IT WAS DISCOVERED THAT THE FRONT AND REAR SECTIONS OF THE SUBFRAME WAS RUSTED. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE MANUFACTURER WAS NO...

Mileage: 163,000

MY 4RUNNER HAS EXCESSIVE FRAME RUST ON THE ENTIRE UNDERSIDE OF THE VEHICLE. THE RUST IS FAR MORE PERVASIVE THAN ON ANY OTHER VEHICLE I HAVE SEEN AND WILL BECOME DANGEROUS IF NOT FIXED. I BELIEVE THIS IS A PROBLEM WITH ALL 4RUNNERS FROM THIS TIME PERIOD (2002-2006). *TR

Mileage: 148,250

FRAME IS COMPLETELY RUSTED OUT. THE ENGINE AND TRANSMISSION ARE STRONG BUT THE FRAME IS THE WEAK LINK TO THIS TOYOTA. THIS VEHICLE WILL NOT PASS INSPECTION AND WILL NEED TO BE SCRAPPED. *TR

TRUCK HAS BEEN WELL CARED FOR AND HAS 330K MILES ON IT. ALWAYS CLEAN AND MAINTAINED PROPERLY BY MYSELF AND PREVIOUS OWNERS. FRAME IS SHOWING SIGNS OF EXCESSIVE RUST IN THE FRONT BETWEEN THE WHEELS AND AT ALMOST ALL OF THE WELDED AREAS. SOME AREAS OF FRAME ARE COMING OFF IN CHUNKS AS IT APPEARS TO BE...

TRUCK HAS BEEN WELL CARED FOR AND HAS 330K MILES ON IT. ALWAYS CLEAN AND MAINTAINED PROPERLY BY MYSELF AND PREVIOUS OWNERS. FRAME IS SHOWING SIGNS OF EXCESSIVE RUST IN THE FRONT BETWEEN THE WHEELS AND AT ALMOST ALL OF THE WELDED AREAS. SOME AREAS OF FRAME ARE COMING OFF IN CHUNKS AS IT APPEARS TO BE...

TRUCK HAS BEEN WELL CARED FOR AND HAS 330K MILES ON IT. ALWAYS CLEAN AND MAINTAINED PROPERLY BY MYSELF AND PREVIOUS OWNERS. FRAME IS SHOWING SIGNS OF EXCESSIVE RUST IN THE FRONT BETWEEN THE WHEELS AND AT ALMOST ALL OF THE WELDED AREAS. SOME AREAS OF FRAME ARE COMING OFF IN CHUNKS AS IT APPEARS TO BE...

EXCESSIVE RUST THROUGHOUT THE ENTIRE FRAME OF THE VEHICLE THAT COULD POTENTIALLY BE DANGEROUS. MANY RUSTED PARTS ARE CONNECTED TO OTHER PARTS OF THE VEHICLE SUCH AS THE AUXILIARY CROSSMEMBER, FUEL TANK STRAP AND FRAME ITSELF. VEHICLE HAS A CLEAN CARFAX HISTORY. *TR

FRAME IS RUSTING. THERE ARE 2 BIG HOLES. *TR

Mileage: 145,000

WE HAVE A 2004 4RUNNER WITH EXTREME BODY RUST A CORROSION WHICH HAS CAUSED THE FAILURE OF NUMEROUS COMPONENTS, BRAKES, GAS TANK, TRANSMISSION LINES, WHEELS AND OTHER SUSPENSION AND EXHAUST ITEMS. WE ORIGINALLY NOTICED THIS FAILURE AND BEGAN TAKING STEPS TO CORRECT AREAS OF CONCERN, BUT THE EXCESSIVE...

Mileage: 75,000

TRANSMISSION WOULD NOT SHIFT IN MOTION LEAVING FROM A STOP SIGN. I LATER FOUND OUT MY TRANSMISSION LINES HAD CORRODED AWAY LEAKING A LARGE AMOUNT OF TRANSMISSION FLUID. AFTER REPLACING BRAKES AND ADDING BRAKE FLUID I NOTICED THE BRAKE FLUID HAD LEAKED FROM BOTTOM. I HAD TO REPLACE ALL BRAKE LINES AN...

Mileage: 190,000

TRANSMISSION WOULD NOT SHIFT IN MOTION LEAVING FROM A STOP SIGN. I LATER FOUND OUT MY TRANSMISSION LINES HAD CORRODED AWAY LEAKING A LARGE AMOUNT OF TRANSMISSION FLUID. AFTER REPLACING BRAKES AND ADDING BRAKE FLUID I NOTICED THE BRAKE FLUID HAD LEAKED FROM BOTTOM. I HAD TO REPLACE ALL BRAKE LINES AN...

Mileage: 190,000

TRANSMISSION WOULD NOT SHIFT IN MOTION LEAVING FROM A STOP SIGN. I LATER FOUND OUT MY TRANSMISSION LINES HAD CORRODED AWAY LEAKING A LARGE AMOUNT OF TRANSMISSION FLUID. AFTER REPLACING BRAKES AND ADDING BRAKE FLUID I NOTICED THE BRAKE FLUID HAD LEAKED FROM BOTTOM. I HAD TO REPLACE ALL BRAKE LINES AN...

Mileage: 190,000

HAD VEHICLE ALMOST TWO YEARS. HAD THE FRAME AND UNDER CARRIAGE RUST PROOFED BY KROWN IN LATE 2018. RECENTLY WHILE HAVING THE FRAME AND UNDER CARRIAGE RUST PROOFED BY RUST CHECK THEY POINTED OUT THAT THERE WAS A BIG HOLE IN THE FRAME. WE WERE GOING TO HAVE IT REPAIRED BUT WHEN THEY DROPPED THE GAS...

AFTER CHECKING UNDER MY 2004 4RUNNER FOR A FAULTY FOG LIGHT CONNECTION I NOTICED A LOT OF RUST ON THE FRONT FRAME. AFTER FURTHER INVESTIGATION I FOUND IT TO BE COMPLETELY RUSTED THROUGH. THERE ISN'T MUCH HOLDING THE BUMPER ON THERE

Mileage: 149,000

MY FRAME IS ROTTED OUT FROM THE INSIDE OUT. FRONT RADIATOR SUPPORT IS COMPLETELY RUSTED OUT. VEHICLE ONLY HAS 105,000 MILES. TOYOTA SHOULD BE RESPONSIBLE FOR REPLACING THE FRAME. ACCORDING TO THE PETITION TO INVESTIGATE, 4RUNNER OWNERS CLAIM THE FRAMES EXPERIENCE EXCESSIVE CORROSION AND THE SAME TYP...

Mileage: 105,000

MY FRAME IS ROTTED OUT FROM THE INSIDE OUT. FRONT RADIATOR SUPPORT IS COMPLETELY RUSTED OUT. VEHICLE ONLY HAS 105,000 MILES. TOYOTA SHOULD BE RESPONSIBLE FOR REPLACING THE FRAME. ACCORDING TO THE PETITION TO INVESTIGATE, 4RUNNER OWNERS CLAIM THE FRAMES EXPERIENCE EXCESSIVE CORROSION AND THE SAME TYP...

Mileage: 105,000

CRACKED DASHBOARD RISK OF AIRBAGS DEPLOYING

CRACKED DASHBOARD RISK OF AIRBAGS DEPLOYING

TL* THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN FOR ROUTINE SERVICE AT AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THE MUFFLER AND CHASSIS WERE FRACTURED AROUND THE SEAL. THE TECHNICIAN INFORMED THE CONTACT TO TAKE THE VEHICLE TO A TOYOTA DEALER. THE...

Mileage: 137,000

TOYOTA 4 RUNNER. CONSUMER WRITES IN REGARDS TO FRAME RUSTING. *LD CONSUMER STATES THAT THEY NOTICED THAT THE FRAME OF THE VEHICLE WAS RUSTING FROM THE INSIDE. THE MANUFACTURER WAS NOTIFIED. *DL

CAR FRAME IS COMPLETELY RUSTED. NOTHING IS REPAIRABLE ANYMORE. REAR SUSPENSION AND BREAK LINES EFFECTED BY RUST AND BROKEN! REAR SUSPENSION CAN'T BE FIXED DUE TO RUST BROKE CONNECTION TO FRAME. THIS IS NOT ACCEPTABLE , SPECIALLY SINCE THERE IS A RECALL FOR THE SAME FRAME MODEL ON TUNDRA, TACOMA AND ...

Mileage: 166,000

MY 2004 4RUNNER FRAME HAS A MAJOR RUST PROBLEM. IT HAS HOLES ALL OVER AND SOME PARTS ARE BREAKING DOWN DUE TO RUST. I TOOK IT TO A TOYOTA DEALER. THEY TOLD ME THAT THEY CANNOT DO ANYTHING. THEY DIDN'T ADVICE FOR REPLACEMENT AS THE COST, THEY SAY, COULD BE AROUND $15,000. I DIDN'T WANT TO GET RID OF ...

Mileage: 74,000

THE FRAME OF MY FAMILY'S 2004 TOYOTA 4RUNNER IS BADLY CORRODED, WITH ONLY 120K MILES ON IT. IT DID NOT PASS A RECENT INSPECTION AND IS UNSAFE TO DRIVE. TWO DIFFERENT MECHANICS TOLD ME THAT IF WE HIT A HARD BUMP, THE FRAME COULD SPLIT. THERE IS AN INVESTIGATION, BUT TOYOTA NEEDS TO RECALL THESE CAR...

Mileage: 120,000

FRAME IS SEVERELY RUSTING. HOLES PRESENT WHICH HAD TO BE PATCHED NUMEROUS TIMES FOR IT TO PASS INSPECTION. IF SOMETHING IS NOT DONE SOON, I WILL BE FORCED TO GET RID OF THE VEHICLE BECAUSE OF SAFETY CONCERNS AND IT NOT BEING ABLE TO PASS PA INSPECTION. THIS HAS TO BE ADDRESSED NOW. FOR YEARS, TO...

Mileage: 210,000

FRAME HAS RUST PROBLEMS. I SPENT THOUSANDS OF DOLLARS TO KEEP THE 4 RUNNER FUNCTIONING SAFELY AND NOW IT IS ALL TO WASTE BECAUSE THE FRAME THAT THE TRUCK SITS ON IS RUSTING OUT AND IS NO LONGER SAFE TO DRIVE. TOYOTA MUST TAKE ACCOUNTABILITY AND INCLUDE THE '04 4RUNNER ON THE FRAME RECALL. MY 4RUNN...

Mileage: 160,000

DASHBOARD SINGLE LINE CRACK FROM DRIVER'S SIDE CONTINUOUS THROUGH HALFWAY INTO THE PASSENGER'S SIDE.

Mileage: 138,000

WHILE HAVING THE TIRES REPLACED, THE MECHANICS WERE UNABLE TO LOWER THE SPARE TIRE. AFTER CALLING FOR BACKUP THE MECHANICS WERE ABLE TO CUT THE TIRE FROM THE VEHICLE. THIS WAS BEFORE A TRIP TO ATLANTIC CITY, SO I HAD TOYOTA REPLACE THE HOIST AT MY COST TO REPAIR (UNWARE OF THE RUST AND FRAME ISSUE...

Mileage: 126,000

I WAS DRIVING AT A SPEED OF 50 MPH ON POOLER PARKWAY IN HEAVY TRAFFIC AND A BUZZER WENT OFF. ALL OF A SUDDEN MY DASHBOARD GIVES OFF MULTIPLE WARNING SIGNALS: VASC TRAC, TRAC OFF, ABS (I) BRAKE. I DO NOT KNOW WHAT THE PROBLEM IS SO I PULL OFF THE ROAD AND TRY TO STOP THE CAR, BUT THE BRAKES FAIL. I ...

Mileage: 155,000

I WAS DRIVING AT A SPEED OF 50 MPH ON POOLER PARKWAY IN HEAVY TRAFFIC AND A BUZZER WENT OFF. ALL OF A SUDDEN MY DASHBOARD GIVES OFF MULTIPLE WARNING SIGNALS: VASC TRAC, TRAC OFF, ABS (I) BRAKE. I DO NOT KNOW WHAT THE PROBLEM IS SO I PULL OFF THE ROAD AND TRY TO STOP THE CAR, BUT THE BRAKES FAIL. I ...

Mileage: 155,000

I WAS DRIVING MY CAR ON POOLER PARKWAY IN POOLER, GA ON A CITY STREET IN HEAVY TRAFFIC WHEN ALL OF A SUDDEN A BUZZER GOES OFF AND MY DASHBOARD IMMEDIATELY GIVES OFF MULTIPLE WARNING SIGNALS. VASC TRAC, TRAC OFF, ABS (I) BRAKE. I IMMEDIATELY PULL OFF TO THE SIDE OF THE ROAD AND TRY TO STOP THE CAR, ...

Mileage: 155,000

I WAS DRIVING MY CAR ON POOLER PARKWAY IN POOLER, GA ON A CITY STREET IN HEAVY TRAFFIC WHEN ALL OF A SUDDEN A BUZZER GOES OFF AND MY DASHBOARD IMMEDIATELY GIVES OFF MULTIPLE WARNING SIGNALS. VASC TRAC, TRAC OFF, ABS (I) BRAKE. I IMMEDIATELY PULL OFF TO THE SIDE OF THE ROAD AND TRY TO STOP THE CAR, ...

Mileage: 155,000

THE FRAME OF THE 2004 4RUNNER IS RUSTING OUT AND THERE ARE VISIBLE HOLES IN THE FRAME THAT SUPPORT THE VEHICLE. THIS APPEARS TO BE A VERY COMMON PROBLEM ACCORDING TO THE DEALERSHIP WITH SEVERAL OF THE 4RUNNER AND TACOMA MODELS BEING AFFECTED.

SEVERE RUST ON FRAME AND SUSPENSION ATTACHMENT POINTS. RUST IS NOT SUPERFICIAL BUT RUSTING FROM INSIDE OF FRAME TUBES.

SEVERE RUST ON FRAME AND SUSPENSION ATTACHMENT POINTS. RUST IS NOT SUPERFICIAL BUT RUSTING FROM INSIDE OF FRAME TUBES.

2004 TOYOTA 4RUNNER WITH 110K MILES WITH RUSTED FRAME. THE CAR IS OTHERWISE IN PERFECT SHAPE AND WELL MAINTAINED. THE FRAME RUST MAKES THE VEHICLE UNSAFE TO DRIVE ALL OTHER TOYOTA MODELS WITH THE SAME ISSUE WITH FRAMES FROM THE SAME FACTORY WERE RECALLED. THE 4 RUNNER WAS NOT ADDRESSED

Mileage: 110,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT TOOK THE VEHICLE TO A TIRE SHOP FOR SCHEDULED MAINTENANCE. THE MECHANIC FOUND THAT THE FRAME WAS SEVERELY CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIIFIED OF THE FAILURE. THE VEHICLE WAS N...

Mileage: 122,000

PICTURES SHOW SIGNIFICANT RUST DAMAGE ON THE RIGHT BACK FRAME NEAR THE MUFFLER. DEALERSHIP STATED IT WOULD COST $14,000 TO REPLACE THE FRAME OF THE VEHICLE. CURRENTLY THE CAR HAS 125,000 MILES. VIN UNKNOWN *LN*JB

Mileage: 125,000

CHASSIS, BRAKES AND ALL UNDER CARRIAGE OF 2004 TOYOTA 4 RUNNER IS RUSTED. SOON THE CAR WILL NOT PASS INSPECTION. I DO NOT LIVE IN A SALT WATER ZONE. MY CAR HAS NEVER DRIVEN THROUGH SALT WATER. I HAVE 71,000 MILES ON THE CAR. THE BRAKES WERE SO RUSTED THAT I HAD TO REPLACE THEM. THE CAR WILL BE TOO D...

CHASSIS, BRAKES AND ALL UNDER CARRIAGE OF 2004 TOYOTA 4 RUNNER IS RUSTED. SOON THE CAR WILL NOT PASS INSPECTION. I DO NOT LIVE IN A SALT WATER ZONE. MY CAR HAS NEVER DRIVEN THROUGH SALT WATER. I HAVE 71,000 MILES ON THE CAR. THE BRAKES WERE SO RUSTED THAT I HAD TO REPLACE THEM. THE CAR WILL BE TOO D...

CHASSIS, BRAKES AND ALL UNDER CARRIAGE OF 2004 TOYOTA 4 RUNNER IS RUSTED. SOON THE CAR WILL NOT PASS INSPECTION. I DO NOT LIVE IN A SALT WATER ZONE. MY CAR HAS NEVER DRIVEN THROUGH SALT WATER. I HAVE 71,000 MILES ON THE CAR. THE BRAKES WERE SO RUSTED THAT I HAD TO REPLACE THEM. THE CAR WILL BE TOO D...

TL* THE CONTACT OWNS A 2014 TOYOTA 4RUNNER. WHILE DRIVING IN REVERSE OVER A SMALL BUMP, BOTH FRONTAL AIR BAGS DEPLOYED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO LARRY H MILLER TOYOTA MURRAY (5650 S STATE ST, MURRAY, UT 84107, (801) 590-0640) AND NUMEROUS FAILURE CODES WERE LOCATED. THE VEHICLE WAS N...

Mileage: 180,000

FRAME HAS RUSTED THROUGH IN AT LEAST THREE AREAS. IN ADDITION, PARTS OF THE FRAME I CAN PULL OFF BY HAND. THE FRONT CROSSMEMBER IS 80% WHAT IT USED TO BE DUE TO PARTS FALLING OFF CAUSED BY RUST.

Mileage: 134,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT TOOK THE VEHICLE TO TEMECULA VALLEY TOYOTA (LOCATED AT 26631 YNEZ RD, TEMECULA, CA 92591, 951-319-7911) FOR INSPECTION. THE DEALER INFORMED THE CONTACT THAT THE UNDERCARRIAGE WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER...

Mileage: 166,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE CONTACT WAS INFORMED THAT THE FRONT PASSENGER SIDE TO THE REAR SUBFRAME SHOWED EXTENSIVE CORROSION. THE CONTACT WAS INFORMED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT R...

Mileage: 115,800

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT TOOK THE VEHICLE TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME HAD EXCESSIVE CORROSION. THE VEHICLE WAS TAKEN TO RIVERA TOYOTA OF MT. KISCO (LOCATED AT 325 N BEDFORD RD, MT KISCO, NY 10549, (914) 666-5181), BUT WAS NOT DIAGNO...

Mileage: 50,720

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING A ROUTINE ALIGNMENT BY AN INDEPENDENT MECHANIC, IT WAS NOTICED THAT THE FRAME WAS CORRODED ALL THE WAY THROUGH. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FRAME FAILURE BECAME WORSE. THE CONTACT REFERENCED A NHTSA ...

Mileage: 137,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE OPERATING THE VEHICLE, A SQUEAKING NOISE WAS HEARD COMING FROM THE REAR PASSENGER SIDE BRAKING MECHANISM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THE SUBFRAME EXPERIENCED SEVERE RUSTING AND CORROSION. ALSO, THE REAR PASSENGER ...

Mileage: 34,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE OPERATING THE VEHICLE, A SQUEAKING NOISE WAS HEARD COMING FROM THE REAR PASSENGER SIDE BRAKING MECHANISM. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DISCOVERED THE SUBFRAME EXPERIENCED SEVERE RUSTING AND CORROSION. ALSO, THE REAR PASSENGER ...

Mileage: 34,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE DEALER (STEPHEN WADE TOYOTA, 150 HILTON DR, ST. GEORGE, UT 84770, (435) 634-6500) NOTICED CORROSION AROUND THE FRAME. THE DEALER INFORMED THE CONTACT THAT THE FRAME HAD TOO MUCH CORROSION TO REPAIR. THE V...

Mileage: 132,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STARTED TO SWAY BACK AND FORTH. THE CONTACT WAS CONCERNED THAT THERE MAY BE AN ISSUE WITH THE TIRES, ALIGNMENT, OR TIRE BALANCE. THE VEHICLE WAS TAKEN TO A TIRE AND WHEEL COMPANY WHERE THE TIRES WERE BALANCED,...

Mileage: 198,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING STATE INSPECTION, SHE WAS INFORMED THAT THE SUBFRAME WAS SEVERELY CORRODED AND THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APP...

Mileage: 188,711

I BOUGHT THIS VEHICLE AT DEALERSHIP MAY 2018, FRAME COMPONENTS COMPLETELY ROTTED THROUGH I WILL INCLUDE PHOTOS VECHICLE UNSAFE TO DRIVE TRANSMISSION LINES ROTTED WHEN I LOOKED CLOSELY I SAW FRAME ROTTED. *TR

Mileage: 142,814

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT DISCOVERED THAT THE ENTIRE UNDERCARRIAGE OF THE VEHICLE WAS RUSTED. DUE TO THE RUST, THE BRAKE LINES STARTED TO RUST AND CAUSED THE VEHICLE TO HAVE COMPLETE BRAKE FAILURE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO A...

Mileage: 180,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT DISCOVERED THAT THE ENTIRE UNDERCARRIAGE OF THE VEHICLE WAS RUSTED. DUE TO THE RUST, THE BRAKE LINES STARTED TO RUST AND CAUSED THE VEHICLE TO HAVE COMPLETE BRAKE FAILURE. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO A...

Mileage: 180,000

FRAME RUST. THE FRAME ON MY 2004 TOYOTA 4R 4D 4X4 SR5/SPT HAS COMPLETELY RUSTED UNDER THE RADIATOR CROSS MEMBER. UPON FURTHER INSPECTION THE ENTIRE INSIDE OF THE FRAME IS RUSTING TO THE OUTSIDE IN VARIOUS LOCATIONS. THIS WILL QUICKLY BECOME A SAFETY CONCERN SINCE EVERYTHING IS BOLTED TO THE FRAME...

Mileage: 95,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE, THE CONTACT WAS INFORMED THAT THE PASSENGER SIDE SUBFRAME HAD EXCESSIVE RUST AND THERE WERE HOLES IN THE SUBFRAME. PRESTIGE TOYOTA OF RAMSEY (LOCATED AT 1096 NJ-17, RAMSEY, NJ 07446, (844) 838-7075) INF...

Mileage: 140,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING ROUTINE MAINTENANCE BY AN INDEPENDENT MECHANIC, IT WAS DISCOVERED THAT THE SUBFRAME WAS RUSTED AND CORRODED. THE MECHANIC STATED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTU...

Mileage: 160,095

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE SUBFRAME OF THE VEHICLE HAD SEVERE RUST AND CORROSION. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. TOYOTA OF MERRILLVILLE (4450 E. LINCOLN HWY, MERRILLVILLE, IN) WAS NOTIFIED OF THE FAILURE. THE MANUFACTURER ...

Mileage: 213,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE ENTIRE UNDERCARRIAGE OF THE VEHICLE WAS RUSTED. THE CONTACT DISCOVERED THAT PART OF THE FRAME THAT HELD UP THE FUEL TANK WAS DRAGGING ON THE GROUND WHILE THE VEHICLE WAS IN MOTION. THE MANUFACTURER WAS CONTACTED AND STATED THAT ...

Mileage: 120,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE WAS EXTENSIVELY RUSTED AND CORRODED. SUBURBAN TOYOTA OF FARMINGTON HILLS (35200 GRAND RIVER AVE, FARMINGTON HILLS, MI 48335, (248) 699-7100) WAS NOTIFIED AND INDICATED THAT THE MANUFACTURER WAS AWARE OF THE ...

Mileage: 120,000

FRAME HAS RUSTED THROUGH, LEAVING SEVERAL HOLES, SOME VERY LARGE, PRESENTING A SIGNIFICANT SAFETY HAZARD.

Mileage: 128,500

THERE IS AN UNREASONABLE AMOUNT OF RUST ON 4TH GENERATION 4 RUNNER. SEEMS TO BE A COMMON PROBLEM AND MAKES THE CAR UNSAFE.

FRAME RAIL ROTTING AND I'VE ALWAYS PARKED IN A GARAGE!

Mileage: 142,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. DURING ROUTINE MAINTENANCE, THE CONTACT NOTICED THAT THE FRAME WAS RUSTED OUT. THE VEHICLE WAS TAKEN TO TOYOTA OF BELLINGHAM (360-676-0600, LOCATED AT 1100 IOWA ST, BELLINGHAM, WA 98229) AND THE CONTACT WAS INFORMED THAT THERE WAS NO RECALL. THE MANUFACTUR...

Mileage: 87,000

FRAME FOUND TO BE RUSTING AWAY AND CAN NOT BE SAFELY INSPECTED. WAS TOLD BY SAFETY MECHANIC AREAS ARE VERY BAD AND PARTS MAY START FALLING OFF.

Mileage: 115,978

TAKATA RECALL, THE RADIATOR MOUNT AND FRAME SUPPORTS ARE RUSTED OUT, ALSO THE REAR SHOCK AND AIR SUSPENSION MOUNTS ARE RUSTED OUT. VEHICLE WAS IN MOTION WHEN SHOCK MOUNT BROKE.

Mileage: 190,000

TAKATA RECALL, THE RADIATOR MOUNT AND FRAME SUPPORTS ARE RUSTED OUT, ALSO THE REAR SHOCK AND AIR SUSPENSION MOUNTS ARE RUSTED OUT. VEHICLE WAS IN MOTION WHEN SHOCK MOUNT BROKE.

Mileage: 190,000

TAKATA RECALL, THE RADIATOR MOUNT AND FRAME SUPPORTS ARE RUSTED OUT, ALSO THE REAR SHOCK AND AIR SUSPENSION MOUNTS ARE RUSTED OUT. VEHICLE WAS IN MOTION WHEN SHOCK MOUNT BROKE.

Mileage: 190,000

LOCAL TOYOTA DEALER INSPECTED FRAME FOUND MULTIPLE HOLES IN THE FRAME , ESTIMATE GIVEN OF $17,793.54 FOR NEW FRAME ALL PARTS NEEDED WITH THE FRAME PARTS AND LABOR. CONTACTED TOYOTA AND THEY WILL DO NOTHING TO CORRECT THE FAULTY FRAME ISSUE

FRAME IS RUSTED SO BAD IT IS ABOUT TO BREAK IN HALF. MECHANIC SAID HE HAS NEVER SEEN ANYTHING LIKE THIS BEFORE. FRAME SHOULD HOLD UP BETTER THAN THIS. AFRAID TO PUT FRAME UP ON LIFT TO ROTATE TIRES BECAUSE THOUGHT IT WOULD BREAK IN HALF. FRAME IS ROTTING BEFORE OUR EYES. VEHICLE STILL RUNS GOOD....

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. DURING A STATE INSPECTION, THE INSPECTOR DIAGNOSED THAT THE FRAME ON THE FRONT DRIVER'S SIDE, JUST BEFORE THE REAR WHEEL, WAS RUSTED AND HAD HOLES. THE CONTACT WAS INFORMED THAT THE FAILURE NEEDED TO BE REMEDIED. THE MANUFACTURER WAS MADE AWARE OF THE FAIL...

Mileage: 333,000

I OWN A 2004 TOYOTA 4RUNNER WITH SIGNIFICANT RUST ON THE FRAME THAT HAS NEARLY RUSTED THROUGH IN SOME AREAS. THROUGH MY RESEARCH I DETERMINED THAT THIS HAS BEEN AN ONGOING ISSUE FOR MANY TOYOTA VEHICLES CLOSE TO THE 2004 MODEL YEAR. APPARENTLY THE FRAME WAS NOT PROPERLY COATED AND RUST HAS GROWN ON ...

Mileage: 179,000

I OWN A 2004 TOYOTA 4RUNNER WITH SIGNIFICANT RUST ON THE FRAME THAT HAS NEARLY RUSTED THROUGH IN SOME AREAS. THROUGH MY RESEARCH I DETERMINED THAT THIS HAS BEEN AN ONGOING ISSUE FOR MANY TOYOTA VEHICLES CLOSE TO THE 2004 MODEL YEAR. APPARENTLY THE FRAME WAS NOT PROPERLY COATED AND RUST HAS GROWN ON ...

Mileage: 179,000

I OWN A 2004 TOYOTA 4RUNNER WITH SIGNIFICANT RUST ON THE FRAME THAT HAS NEARLY RUSTED THROUGH IN SOME AREAS. THROUGH MY RESEARCH I DETERMINED THAT THIS HAS BEEN AN ONGOING ISSUE FOR MANY TOYOTA VEHICLES CLOSE TO THE 2004 MODEL YEAR. APPARENTLY THE FRAME WAS NOT PROPERLY COATED AND RUST HAS GROWN ON ...

Mileage: 179,000

THE VSC AND TRAC OFF WARNING LIGHTS STAY ON AL THE TIME THE ENGINE IS ON. THE VSC BUTTON DOES NOTHING.

Mileage: 150,000

FRAME RUST IN 2 AREAS; MECHANIC DEEMED UNSAFE TO DRIVE

Mileage: 290,000

'FRAME RUST' FRAME RUSTED IN 2 AREAS AND MECHANIC DEEMED UNSAFE TO DRIVE.

Mileage: 290,000

THE BODY/FRAME OF THE CAR IS SUFFERING FROM SEVERE CORROSION/RUST. THE RUST HAS STARTED EATING THROUGH THE FRAME. THIS APPEARS TO BE A COMMON PROBLEM IN TOYOTA 4RUNNERS FROM 2003-2007 MODEL YEAR. IN MY CASE MY VEHICLE IS A 2004 MODEL YEAR. THIS IS A SERIOUS RISK AND HAZARD.

Mileage: 125,000

MY FRAME HAS 10 PLUS HOLES IN IT ALL OVER THE VEHICLE, IT'S SITTING IN MY DRIVEWAY AS IT WILL SPLIT IN TWO ANY SECOND BY THE TRANSMISSION CROSS MEMBER, TOYOTA IT'S TIME TO START RECALLING THESE FRAMES AS THERE ARE MILLIONS OF COMPLAINTS

Mileage: 165,000

TOYOTA 4 RUNNER IN MOTION, DRIVING THE HIGHWAY AND LOCAL WHEN NOTICED NOISE COMING FROM THE BACK OF THE VEHICLE. IT WAS MOVING UNSTABLE LIKE WIGGLING AND SLOWED DOWN. MY HUSBAND CHECKED UNDER THE CAR. HE FOUND OUT THE CHASSIS WAS BROKEN.

Mileage: 244,000

THE FRAME ON MY 4RUNNER IS ROTTING. IT HAS A FEW HOLES IN IT AND THE RUST IS EVERYWHERE. I DO NOT UNDERSTAND HOW IT COULD BE SO ROTTEN SO QUICKLY, ESPECIALLY WHERE I LIVE. THERE ARE A LOT OF OTHER 4RUNNERS CLOSE IN AGE THAT ARE EXPERIENCING THE SAME ISSUE. TOYOTA NEEDS TO REPLACE THE FRAMES ON THE 4...

FRAME HAS ROTTED AND HAS BEEN DECLARED UNSAFE TO DRIVE.

EXCESSIVE RUST HAS APPEARED IN A NUMBER OF STRUCTURAL AREAS IN THE FRAME OF MY 4RUNNER. COMPLETE RUST THROUGH HAS OCCURRED IN MANY AREAS OF THE FRAME AND IN KEY STRESS POINTS. THE RUST APPEARS TO BE COMING FROM THE INSIDE OUT SO IT IS TOUGH TO IDENTIFY ADDITIONAL AREAS THAT RUST IS AFFECTING AND FUR...

Mileage: 244,000

PREMATURE RUSTING IF THE FRAME AND OTHER COMPONENTS OF THE VEHICLE. DRIVING COULD BE OR TURN INTO A SAFETY HAZARD.

PREMATURE RUSTING IF THE FRAME AND OTHER COMPONENTS OF THE VEHICLE. DRIVING COULD BE OR TURN INTO A SAFETY HAZARD.

COMPLETE FRAME IS RUSTED OUT

UPON BRINGING MY CAR TO TOYOTA FOR SERVICE, THEY HAVE BEEN NOTICING MORE AND MORE RUST PERFORATION ON MY CHASSIS, LAST YEAR TRYING TO FIX A FLAT THE JACK WENT RIGHT THRU THE CHASSIE RAIL DUE TO BEING ALL RUSTED OUT AND FLAKY. TODAY I WENT FOR AN OIL CHANGE AND MULTI POINT INSPECTION FOUND REAR SHOCK...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED WHEN THE VEHICLE WAS STARTED AND REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO BIG ISLAND TOYOTA KAILUA-KONA (808-329-8517, LOCATED AT 74-5504 KAIWI ST, KAILUA, HI 96740) TO BE DIAGNOSED, BUT ...

Mileage: 120,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR ILLUMINATED WHEN THE VEHICLE WAS STARTED AND REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO BIG ISLAND TOYOTA KAILUA-KONA (808-329-8517, LOCATED AT 74-5504 KAIWI ST, KAILUA, HI 96740) TO BE DIAGNOSED, BUT ...

Mileage: 120,000

THE FRAME ON MY 2004 TOYOTA IS VERY RUSTY. IT IS COMPLETELY CRACKED THROUGH NEAR THE FRONT PASSENGER SUSPENSION. MY MECHANIC HAS WARNED ME NOT TO DRIVE THE VEHICLE ANYMORE. SEE PICS

Mileage: 175,000

THE FRAME ON MY 2004 TOYOTA IS VERY RUSTY. IT IS COMPLETELY CRACKED THROUGH NEAR THE FRONT PASSENGER SUSPENSION. MY MECHANIC HAS WARNED ME NOT TO DRIVE THE VEHICLE ANYMORE. SEE PICS

Mileage: 175,000

EXCESSIVE FRAME RUST. REPLACED COMPLETE REAR END IN 2013. TOLD BY HYANNIS TOYOTA THAT IT WAS UNSAFE TO DRIVE BECAUSE OF EXCESSIVE RUST. THE REAR END IS NOW RUSTED OUT AGAIN IN 2019 AND NEEDS REPLACING. IN APRIL 2019 COULD NOT HAVE SUSPENSION REPLACED UNTIL FRAME WELDING WAS COMPLETED. ADDITIONAL WO...

Mileage: 150,000

EXCESSIVE FRAME RUST. REPLACED COMPLETE REAR END IN 2013. TOLD BY HYANNIS TOYOTA THAT IT WAS UNSAFE TO DRIVE BECAUSE OF EXCESSIVE RUST. THE REAR END IS NOW RUSTED OUT AGAIN IN 2019 AND NEEDS REPLACING. IN APRIL 2019 COULD NOT HAVE SUSPENSION REPLACED UNTIL FRAME WELDING WAS COMPLETED. ADDITIONAL WO...

Mileage: 150,000

THE TAILGATE OF THE SUV OPENS IT WHILE DRIVING. THE TAILGATE CLOTHING LATCH SOUNDS AS IF IT HAS CLOSED, BUT HAS NOT. THIS RESULTS IN THE TAIL GATE OPENING UP WHILE DRIVING. THIS BEGAN AFTER HAVING A REPAIR ON THE BACK WINDOW SYSTEM, THAT WAS A RECALL FROM TOYOTA. ALSO, THERE'S NO PROTECTION FROM T...

Mileage: 140,000

I STARTED HEARING A NOISE LIKE FRICTION COMING FROM UNDER THE CAR AND FEELING IT THROUGH THE STEERING WHILE DRIVING. IT WOULD COME AND GO AND WITHIN A WEEK THE CAR WAS UNDRIVABLE. JUST AFTER EXITING THE INTERSTATE AND ON A SIDE ROAD, MY BRAKES WENT OUT AND THERE WAS AN INCREDIBLY LOUD METAL ON META...

Mileage: 142,679

I HAVE A 2004 4RUNNER WHICH IS METICULOUSLY KEPT. THE ENTIRE FRONT FRAME WHICH SUPPORTS THE RADIATOR HAD TO BE CUT OUT AND REPLACED. THERE WHERE ALSO MULTIPLE SPOTS ON THE FRAME RAIL WHERE STEEL PLATES HAD TO BE WELDED ON FOR IT TO PASS INSPECTION. I'VE BEEN TOLD THAT THERE ARE NOT ENOUGH COMPLAI...

Mileage: 180,000

FRAME AND SUSPENSION RUST HAS WEAKENED THE PARTS TO THE POINT OF FAILURE. REAR UPPER CONTROL ARM MOUNTING BRACKET ON REAR AXLE BROKE WHILE DRIVING ON HIGHWAY WHILE GOING AROUND A TURN. VEHICLE'S REAR WOBBLED BACK AND FORTH VIOLENTLY. I ALMOST LOST CONTROL OF THE VEHICLE. THERE ARE OTHER PIECES THAT ...

Mileage: 150,000

TOYOTA FRAME RUSTING. THE FRAME ON MY 4RUNNER IS RUSTED TO THE POINT WHERE I FEEL IT IS UNSAFE. THE WELDS THAT HOLD THE REAR CONTROL ARMS ARE RUSTED COMPLETELY THROUGH. WHEN LOOKING AT THE FRAME RAIL YOU CAN SEE DAYLIGHT THROUGH THE WELDS. THERE ARE OTHER SPOTS ON THE FRAME RAILS THAT ARE RUSTED JUS...

Mileage: 175,000

FRAME AND UNDERNEATH OF VEHICLE EXCESSIVELY RUSTING WITH HOLES COMPLETELY THROUGH ENTIRE FRAME LIKE SWISS CHEESE. WILL NOT PASS INSPECTION BECAUSE OF THIS PROBLEM. DEEMED UNSAFE TO USE VEHICLE ANY MORE.

Mileage: 250,000

RUMBLE WHEN OVER 20 MPH AND TURNING SLIGHTLY RIGHT ON ANY SURFACE.

Mileage: 94,500

RUMBLE WHEN OVER 20 MPH AND TURNING SLIGHTLY RIGHT ON ANY SURFACE.

Mileage: 94,500

VEHICLE DID NOT PASS VA STATE SAFETY INSPECTION DUE TO A CORRODED HOLE IN THE FRAME. SIMILAR TO RECALL IN PLACE FOR TOYOTA TACOMA

I BROUGHT MY 4RUNNER IN TO HAVE THE BRAKES LOOKED AT AND THE MECHANIC WAS NOT ABLE TO PUT IT UP ON A LIFT BECAUSE OF THE EXTENSIVE AMOUNT OF RUST ON MY VEHICLE, THEY WERE CONCERNED THAT IT WOULDN'T HOLD. I NEED THIS VEHICLE TO GET AROUND FOR WORK AND MY COMPANY, AND I AM NOW TERRIFIED IT IS NOT SAFE...

Mileage: 180,000

FRAME LEFT SIDE - DRIVERS FRONT CLOSE TO WHEEL WELL AREA IS RUSTED THROUGH APPROX SIZE OF 8" X 5" DURING INSPECTION NOTIFIED THIS WILL BE A HAZARD TO DRIVING IF NOT ADDRESSED SINCE THIS IS PART OF THE FRAME AND CAN CAUSE SERIOUS DAMAGE IF NOT ADDRESSED. VEHICLE IS INSPECTED YEARLY AND THIS IS THE F...

Mileage: 204,000

FRAME RUST

I BROUGHT TOYOTA 4RUNNER 2004 IN FOR A RECALL AND THE DEALER TOLD ME THERE WAS MAJOR RUST ON FRAME . HE SHOWED ME PICTURES OF THE FRAME RUSTED THROUGH IN MANY AREAS. HE TOLD ME IT WAS DANGEROUS TO DRIVE . I HAVE A TOYOTA TUNDRA WHICH HAD SIMILAR RUST ON FRAME AND TOYOTA PUT ON A NEW FRAME . THIS CA...

Mileage: 200,000

THE FRAME IS ROTTING ..AND I CAN NOT STOP OR PREVENT IT ..EVENTUALLY THE ENTIRE FRAME WILL FALL APART..CAUSING A SAFETY CONCERN FOR ME AND MY FAMILY ..I BOUGHT A TOYOTA FOR ITS DEPENDABILITY..NOT HOW FAST IT WOULD KILL ME

THE FRAME OF MY TRUCK IS COMPLETE MUSH! I'VE TAKEN EXCELLENT CARE OF MY 4RUNNER AS IT HAS BEEN MY MOST FAVORITE VEHICLE. I'M BEING WARNED TO GET THIS FIXED DUE TO IT BEING A DANGEROUS SITUATION & WOULDN'T YOU KNOW I'M DRIVING HOME & I LOOSE ALL CONTROL OVER MY VEHICLE ON HELLACIOUS MOUNTAIN ROADS, B...

Mileage: 194,000

THE FRAME OF MY TRUCK IS COMPLETE MUSH! I'VE TAKEN EXCELLENT CARE OF MY 4RUNNER AS IT HAS BEEN MY MOST FAVORITE VEHICLE. I'M BEING WARNED TO GET THIS FIXED DUE TO IT BEING A DANGEROUS SITUATION & WOULDN'T YOU KNOW I'M DRIVING HOME & I LOOSE ALL CONTROL OVER MY VEHICLE ON HELLACIOUS MOUNTAIN ROADS, B...

Mileage: 194,000

THE FRAME OF MY TRUCK IS COMPLETE MUSH! I'VE TAKEN EXCELLENT CARE OF MY 4RUNNER AS IT HAS BEEN MY MOST FAVORITE VEHICLE. I'M BEING WARNED TO GET THIS FIXED DUE TO IT BEING A DANGEROUS SITUATION & WOULDN'T YOU KNOW I'M DRIVING HOME & I LOOSE ALL CONTROL OVER MY VEHICLE ON HELLACIOUS MOUNTAIN ROADS, B...

Mileage: 194,000

THE FRAME IS COMPLETELY ROTTED OUT SINCE 2017

Mileage: 180,000

I HAVE 2004 TOYOTA 4RUNNER V6 4.0 SR5. MILAGE 130.000. THE FRAME HAS A LOT OF RUST. ESPECIALLY THE PASSENGER SIDE THRU WHOLE THAT SIDE. THE FRONT RADIATOR MOUNTS ARE ALSO CORRODED. BACK SIDE OF THE VEHICLE FRAME IS ALSO CORRODED. BASICALLY WHOLE FRAME IS VERY RUSTY. IF I TOUCH THE FRAME THE PIECES ...

TRUCK FRAME RUSTED THROUGH

Mileage: 145,000

FRAME IS SEVERELY RUSTED WITH LARGE HOLES THROUGHOUT. THESE VEHICLES ARE NO LONGER SAFE TO DRIVE. TOYOTA HAS HAD ISSUES WITH RUSTED FRAMES WITH MANY TRUCKS AND APPARENTLY THE 4RUNNERS IS NO EXCEPTION.

MY 2004 TOYOTA 4RUNNER WILL NOT PASS IT'S NEXT INSPECTION DUE TO A HOLE FROM CORROSION IN THE FRAME. THE HOLE IS IN THE PASSENGER SIDE FRAME. THE CAR IS ALWAYS KEPT IN THE GARAGE, IS WASHED REGULARLY AND ALL MAINTENANCE WORK HAS BEEN DONE BY A TOYOTA DEALER

FRAME RUST. WILL NOT PASS INSPECTION.

Mileage: 126,465

FRAME IS RUSTING ,TOYOTA DEALER SAID DANGERASE TO DRIVE,DEALER SAID THEY ARE THUOSANDS OF THESE OUT THERE BUT NO RECALLS!!!! WHEY DO PEOPLE NEED TO DIE BEFORE TOYOTA DOES SOMETHING? I ,M LOSING THOUSANDS OF DOLLARS FOR THERE MISTAKES,THIS SUV HAS LESS THAN 100,000 ON IT!!! SAD!!!!

Mileage: 50,000

EXCESSIVE FRAME ROT/RUST

Mileage: 150,000

WRITING A COMPLAINT DUE TO EXCESSIVE CORROSION OF THE FRAME OF TOYOTA 4 RUNNER. GOT VEHICLE INSPECTED LAST YEAR, NO RECOMMENDATION OF THE FRAME NEEDING REPAIRED. NOW, WONT PASS INSPECTION THIS YEAR DUE TO A CRACK IN THE WELDING PLATE ABOVE DRIVERS SIDE REAR AND SEVERE CORROSION. DRIVERS SIDE FRA...

WAS DRIVING TO WORK GOING 50 MPH BRAKED TO COME TO A STOP AND THE BACK END STARTED TO TURN ALMOST HAD AN ACCIDENT. FRAME IS COMPLETELY RUSTED OUT. TOO DANGEROUS TO DRIVE.

Mileage: 190

EXCESSIVE AMOUNTS OF CORROSION AND RUST ON THE VEHICLE'S FRAME. FRAME WELDS ARE RUSTING THROUGH IN VARIOUS SPOTS. I ONLY HAVE 112K MILES ON THIS VEHICLE. THIS AMOUNT OF RUST AND CORROSION IS UNACCEPTABLE.

THERE IS A CRACK IN FRAME ON PASSENGER SIDE NEVER IN ACCIDENT . THE RUST CORROSION IS HORRIBLE ALMOST CRACKED ALL THE WAY ON DRIVERS SIDE ,FRONT HOOKS GONE FROM RUST.

Mileage: 155,789

TAKATA RECALL, PERFORMING ROUTINE MAINTENANCE ON MY 04 4RUNNER, THERE IS SO MUCH FRAME RUST THAT I HAVEN'T BEEN ABLE TO DO ANY WORK WITHOUT EVERY BOLT/SCREW/NUT BREAKING OFF. THE FRAME IS SO RUSTED I'M SCARED TO DRIVE IT FAR IF ANYWHERE. I'VE TAKEN IT FOR SERVICE AND HAVE BEEN TOLD BEFORE THAT IT'S ...

Mileage: 114,000

A THIN METAL SUPPORT PLATE WELDED TO REAR AXLE CONNECTS UPPER CONTROL ARMS TO REAR AXLE. BOTH SUPPORT PLATES TOTALLY DISINTEGRATED FROM RUST. THESE PLATES ARE A STRUCTURAL COMPONENT OF VEHICLE SUSPENSION SYSTEM. WHEN THE UPPER CONTROL ARMS FAILED FROM FAILED SUPPORT PLATES, THE BRAKE WARNING LIGHT ...

Mileage: 140,000

TOOK MY 2004 TOYOTA 4RUNNER IN FOR A BRAKE JOB AND THE MECHANIC ASKED IF THEIR WAS ANY RECALLS ON OUR VEHICLE FOR RUSTED FRAME .HE SAID THAT WE WERE GOING TO HAVE TROUBLE WITH IT SOON DO TO FRAME RUSTING SO BAD

Mileage: 55,000

TAKATA RECALL FRAME IS COMPLETELY RUSTED. CAUSING ALL THE UNDERCARRIAGE TO RUST OUT AND MAKE THE VEHICLE VERY DANGEROUS TO DRIVE. EVEN THE BODY IS STARTING TO RUST AWAY. ONLY HAS 116,000 MILES ON IT WHICH IS CRAZY.

Mileage: 116,000

TAKATA RECALL FRAME IS COMPLETELY RUSTED. CAUSING ALL THE UNDERCARRIAGE TO RUST OUT AND MAKE THE VEHICLE VERY DANGEROUS TO DRIVE. EVEN THE BODY IS STARTING TO RUST AWAY. ONLY HAS 116,000 MILES ON IT WHICH IS CRAZY.

Mileage: 116,000

TAKATA RECALL FRAME IS COMPLETELY RUSTED. CAUSING ALL THE UNDERCARRIAGE TO RUST OUT AND MAKE THE VEHICLE VERY DANGEROUS TO DRIVE. EVEN THE BODY IS STARTING TO RUST AWAY. ONLY HAS 116,000 MILES ON IT WHICH IS CRAZY.

Mileage: 116,000

MY 2004 TOYOTA 4RUNNER WILL NOT PASS IT'S NEXT INSPECTION DUE TO HOLES FROM CORROSION IN THE FRAME.

Mileage: 150,000

UPON PRE-INSPECTION OF MY PERSONAL VEHICLE FOR PURCHASE I FOUND THAT BOTH REAR CORNERS OF THE FRAME WERE TOTALLY ROTTED OUT. UPON FURTHER INSPECTION, AFTER REMOVAL OF THE REAR BUMPER, IT TURNED OUT THAT THE RUST EXTENDED ALMOST ENTIRELY THROUGH THE CORNERS OF THE FRAME. THERE WAS ALSO A MAJOR HOLE ...

Mileage: 160,000

UPON PRE-INSPECTION OF MY PERSONAL VEHICLE FOR PURCHASE I FOUND THAT BOTH REAR CORNERS OF THE FRAME WERE TOTALLY ROTTED OUT. UPON FURTHER INSPECTION, AFTER REMOVAL OF THE REAR BUMPER, IT TURNED OUT THAT THE RUST EXTENDED ALMOST ENTIRELY THROUGH THE CORNERS OF THE FRAME. THERE WAS ALSO A MAJOR HOLE ...

Mileage: 160,000

WAS THERE A RECALL OR WARRANTY ENHANCEMENT ON 4RUNNERS WITH CRACKED DASHBOARDS??? MY MOTHER OWNS A 2004 4RUNNER (VIN #[XXX]) AND WE JUST LEARNED THAT THERE WAS A WARRANTY ENHANCEMENT/RECALL THAT COVERED THE REPLACEMENT OF THIS ITEM HOWEVER, SHE NEVER RECEIVED ANY NOTIFICATION IN THE MAIL ADVISING ...

MY 2004 TOYOTA 4RUNNER FRAME HAS HOLES AND HAVE SEEN DOZENS OF OTHERS WITH THE SAME OR WORSE FRAMES. I WORK AT A TOYOTA DEALERSHIP AND ALL THE TRUCE THAT HAVE FRAMES EXCEPT THE 4RUNNERS HAVE RECALLS FOR THE FRAMES. WHEN I ASKED TOYOTA WHY THAT IS THE CASE THEY SAID IT WAS BECAUSE THE TRUCKS WERE BUI...

Mileage: 192,507

FRAME HAS MULTIBLE HOLES IN FRAME AND MANY AREAS FRAME WEEK GAS TANK STRAPS RUSTED OUT WILL NOT PASS INSPECTION

FRONT RIGHT AND LEFT FRAME EXTENSION BRACKETS RUSTED OUT AND ROTTING. THIS IS HAPPENING WITH MANY OTHER OWNERS AND NEEDS TO BE ADDRESSED.

RUST CRACK IN FRAME RIGHT FRONT AT CORE SUPPORT. CRACKS IN DASHBOARD.

Mileage: 165,000

RUST CRACK IN FRAME RIGHT FRONT AT CORE SUPPORT. CRACKS IN DASHBOARD.

Mileage: 165,000

RUST CRACK IN FRAME RIGHT FRONT AT CORE SUPPORT. CRACKS IN DASHBOARD.

Mileage: 165,000

FRAME RUST ISSUE..... VERY BAD FRAME RUST BEHIND THE FRONT BUMPER, BELOW THE RADIATOR SUPPORT. RUSTING SO BAD THAT RADIATOR SUPPORT WILL NEED TO BE REINFORCED.

Mileage: 160,000

SINCE BUYING MY FORERUNNER USED IN 2015 I HAVE ONLY BROUGHT IT TO THE DEALERSHIP FOR MAINTENANCE BED INSPECTIONS WITH TOYOTA PROFESSIONAL MECHANICS. UPON BRINGING MY VEHICLE IN FOR A ROUTINE OIL CHANGE AND INSPECTION I WAS TOLD THAT THE FRAME IS RUSTED OUT AND UNSAFE TO DRIVE. I WAS SHOCKED AND UPS...

Mileage: 215,117

SINCE BUYING MY FORERUNNER USED IN 2015 I HAVE ONLY BROUGHT IT TO THE DEALERSHIP FOR MAINTENANCE BED INSPECTIONS WITH TOYOTA PROFESSIONAL MECHANICS. UPON BRINGING MY VEHICLE IN FOR A ROUTINE OIL CHANGE AND INSPECTION I WAS TOLD THAT THE FRAME IS RUSTED OUT AND UNSAFE TO DRIVE. I WAS SHOCKED AND UPS...

Mileage: 215,117

SINCE BUYING MY FORERUNNER USED IN 2015 I HAVE ONLY BROUGHT IT TO THE DEALERSHIP FOR MAINTENANCE BED INSPECTIONS WITH TOYOTA PROFESSIONAL MECHANICS. UPON BRINGING MY VEHICLE IN FOR A ROUTINE OIL CHANGE AND INSPECTION I WAS TOLD THAT THE FRAME IS RUSTED OUT AND UNSAFE TO DRIVE. I WAS SHOCKED AND UPS...

Mileage: 215,117

THIS IS AN ADDENDUM TO MY ORIGINAL COMPLAINT SUBMITTED ON 12/5/2018. AFTER A MORE THOROUGH INSPECTION OF MY VEHICLE'S FRAME, TOYOTA WESTBOROUGH (MA), HAS IDENTIFIED AN AREA THAT IS SIGNIFICANTLY COMPROMISED. THE SIZE OF THIS HOLE EXCEEDS THE THRESHOLD USED IN THE RELATED TOYOTA TACOMA FRAME RECALL S...

Mileage: 125,000

AFTER WASHING THE CAR ONE DAY, AND SPRAYING OFF THE UNDERSIDE OF THE VEHICLE. I NOTICED A QUARTER SIZED HOLE IN THE PASSENGER SIDE FRAME. IT LOOKS TO BE RUSTED. I FURTHER EXAMINED THE CAR AND FOUND FURTHER PREMATURE RUST THROUGHOUT THE VEHICLE.

TOOK VEHICLE IN FOR A REPAIR RECENTLY AT A TOYOTA DEALER UPON TEAR DOWN THEY TOLD ME THAT MY 2004 4RUNNER'S FRAME AND MANY OTHER STRUCTURAL SUPPORTS FOR THE ENGINE AND MOUNTS ARE NOT STRUCTURALLY SOUND DUE TO SEVERE CORROSION. THEY FOUND HOLES IN THE FRAME AT ENGINE CROSS MEMBER ON THE PASSENGER SID...

Mileage: 178,000

FRAME RUST

Mileage: 70,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS BEING SERVICED BY AN INDEPENDENT MECHANIC, THE TECHNICIAN NOTICED THAT THE FRAME WAS CORRODED THROUGH. THE CONTACT CALLED BUCHANAN'S AUTO SALES AT (423) 282-5515 (LOCATED AT N ROAN ST, JOHNSON CITY, TN 37601), BUT WAS NOT ASSISTED. TH...

Mileage: 143,000

TRANSMISSION FAILED DUE TO RUSTED TRANSMISSION LINES. LEADS UP TO FINDING OUT THAT FRAME IS COMPLETELY RUSTED OUT. UNABLE TO FIX IT DUE TO FRAME RUST. SUSPENSION ARE OF FRAME RUSTED AS WELL...BARELY HOLDING ON. TRAVELING FROM TN TO PA WHEN ALL THIS HAPPENED.

Mileage: 120,000

TRANSMISSION FAILED DUE TO RUSTED TRANSMISSION LINES. LEADS UP TO FINDING OUT THAT FRAME IS COMPLETELY RUSTED OUT. UNABLE TO FIX IT DUE TO FRAME RUST. SUSPENSION ARE OF FRAME RUSTED AS WELL...BARELY HOLDING ON. TRAVELING FROM TN TO PA WHEN ALL THIS HAPPENED.

Mileage: 120,000

TRANSMISSION FAILED DUE TO RUSTED TRANSMISSION LINES. LEADS UP TO FINDING OUT THAT FRAME IS COMPLETELY RUSTED OUT. UNABLE TO FIX IT DUE TO FRAME RUST. SUSPENSION ARE OF FRAME RUSTED AS WELL...BARELY HOLDING ON. TRAVELING FROM TN TO PA WHEN ALL THIS HAPPENED.

Mileage: 120,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS UNDERGOING A STATE INSPECTION, IT WAS DISCOVERED THAT THE SUBFRAME WAS SEVERELY RUSTED AND CORRODED. THE MANUFACTURER AND DEALER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 186,000. THE VIN WA...

Mileage: 186,000

REAR FRAME RUSTED THROUGH. I WAS DRIVING AND A PIECE HOLDING THE SUSPENSION TOGETHER RUSTED OFF THE FRAME. THE VEHICLE WAS IN MOTION AND IT FELT LIKE IT WAS GOING TO TIP OVER. IT ALSO FELT LIKE THE FRONT AND BACK WHEELS WERE GOING IN DIFFERENT DIRECTIONS. APPARENTLY A VERY COMMON ISSUE.

REAR FRAME RUSTED THROUGH. I WAS DRIVING AND A PIECE HOLDING THE SUSPENSION TOGETHER RUSTED OFF THE FRAME. THE VEHICLE WAS IN MOTION AND IT FELT LIKE IT WAS GOING TO TIP OVER. IT ALSO FELT LIKE THE FRONT AND BACK WHEELS WERE GOING IN DIFFERENT DIRECTIONS. APPARENTLY A VERY COMMON ISSUE.

THE FRAME OF THE VEHICLE IS DEVELOPING A HOLE ON THE BOTTOM RIGHT SIDE FRAME RAIL AROUND WHERE THE TRANS MISSION CROSS-MEMBER MOUNTS TO THE FRAME

Mileage: 201,401

THE FRAME ON MY 2004 4RUNNER IS BADLY RUSTED. THERE ARE RUST HOLES WHERE THE CROSS MEMBER IS WELDED TO THE FRAME THEREFORE WEAKENING THE STRUCTURE. THIS IS A SAFETY ISSUE SINCE THERE IS NO TELLING WHEN THAT CRITICAL JUNCTION WILL BREAK. ANOTHER AREA OF RUST THAT CAUSES GREAT CONCERN IS ON THE FR...

Mileage: 119,000

I JUST TOOK THE CAR FOR ANNUAL STATE SAFETY INSPECTION. IT FAILED AND THE INSPECTOR SAID IT IS UNSAFE TO DRIVE. THE PART OF THE FRAME THAT CONNECTS THE RIGHT FRONT AND RIGHT REAR SUSPENSION IS SO RUSTED THAT THE CAR IS UNSAFE TO DRIVE. WE HAVE BEEN DRIVING THIS VEHICLE WITH NO KNOWLEDGE OF THIS HAZA...

Mileage: 100,000

I JUST TOOK THE CAR FOR ANNUAL STATE SAFETY INSPECTION. IT FAILED AND THE INSPECTOR SAID IT IS UNSAFE TO DRIVE. THE PART OF THE FRAME THAT CONNECTS THE RIGHT FRONT AND RIGHT REAR SUSPENSION IS SO RUSTED THAT THE CAR IS UNSAFE TO DRIVE. WE HAVE BEEN DRIVING THIS VEHICLE WITH NO KNOWLEDGE OF THIS HAZA...

Mileage: 100,000

EXCESSIVE FRAME RUST I HAVE A 2004 4RUNNER THAT HAS SO MUCH LIFE LEFT EXCEPT FOR THE FRAME. THE VEHICLE RUNS IMPECCABLY, BUT THE FRAME, THE VERY FOUNDATILN ON WHICH IT SITS, IS CRUMBLING. THE FRAME OF MY 4RUNNER HAS RUSTED TO THE POINT WHERE MY MECHANIC RECOMMENDED I REPLACE THE FRAME BEFORE TOWI...

EXCESSIVE RUST IS COMPROMISING STEERING CONTROL.

Mileage: 250,000

EXCESSIVE RUST IS COMPROMISING STEERING CONTROL.

Mileage: 250,000

EXCESSIVE RUST IS COMPROMISING STEERING CONTROL.

Mileage: 250,000

MY 16 YEAR OLD DAUGHTER WAS DRIVING ON A CITY STREET AND WAS TURNING INTO A DRIVEWAY AND THE LOWER CONTROL ARM ON PASSENGER SIDE BROKE AND I WAS TOLD IT WAS BECAUSE THE FRAME IS ROTTED. NOT SURE IF I AM ABLE TO FIX DUE TO THE FRAME. I AM NEW TO THE NORTHEAST AND WAS NOT AWARE OF ROTTED FRAMES OUT ...

Mileage: 145,000

MY 16 YEAR OLD DAUGHTER WAS DRIVING ON A CITY STREET AND WAS TURNING INTO A DRIVEWAY AND THE LOWER CONTROL ARM ON PASSENGER SIDE BROKE AND I WAS TOLD IT WAS BECAUSE THE FRAME IS ROTTED. NOT SURE IF I AM ABLE TO FIX DUE TO THE FRAME. I AM NEW TO THE NORTHEAST AND WAS NOT AWARE OF ROTTED FRAMES OUT ...

Mileage: 145,000

THE FRAME IS EXTREMELY RUSTED RESULTING IN NEAR SEPARATION OF DIFFERENT PARTS OF THE FRAME. THE CAR HAS BEEN TO THE TOYOTA DEALER MANY TIMES BUT THIS WAS NOT POINTED OUT. A LOCAL CAR REPAIR SHOP POINTED IT OUT.

Mileage: 80,000

I TOOK VEHICLE IN FOR BRAKE REPAIR, THE MECHANIC NOTED EXCESSIVE FRAME RUST AND CAUTIONED THAT IT MAY BE UNSAFE TO CONTINUE TO OPERATE THE VEHICLE WITH OUT REMEDY. RECOMMENDED THOUSANDS OF DOLLARS WORTH OF REPAIR WORK. I AM THE SECOND OWNER OF THE 4RUNNER, BUT THE SUV SPENT MOST OF ITS LIFE IN ARI...

Mileage: 183,000

I TOOK VEHICLE IN FOR BRAKE REPAIR, THE MECHANIC NOTED EXCESSIVE FRAME RUST AND CAUTIONED THAT IT MAY BE UNSAFE TO CONTINUE TO OPERATE THE VEHICLE WITH OUT REMEDY. RECOMMENDED THOUSANDS OF DOLLARS WORTH OF REPAIR WORK. I AM THE SECOND OWNER OF THE 4RUNNER, BUT THE SUV SPENT MOST OF ITS LIFE IN ARI...

Mileage: 183,000

THE FRAME HAS SO MUCH RUST ON IT AND OTHER AREAS OF THE UNDERCARGO THAT IT HAS CAUSED MY SPEED AND ABS SENSORS TO WORK IMPROPERLY. SPEEDOMETER WILL JUST QUIT WORKING AND ABS LIGHTS WILL COME ON WITH THE VCS TRAC, VCS OFF, AND ABS LIGHTS ALL COMING ON, THEN THE ENGINE LIGHT WILL ALSO COME ON FROM TIM...

Mileage: 137,000

THE FRAME HAS SO MUCH RUST ON IT AND OTHER AREAS OF THE UNDERCARGO THAT IT HAS CAUSED MY SPEED AND ABS SENSORS TO WORK IMPROPERLY. SPEEDOMETER WILL JUST QUIT WORKING AND ABS LIGHTS WILL COME ON WITH THE VCS TRAC, VCS OFF, AND ABS LIGHTS ALL COMING ON, THEN THE ENGINE LIGHT WILL ALSO COME ON FROM TIM...

Mileage: 137,000

THE RUST ON THE FRAME OF MY 2004 4RUNNER IS EXCESSIVE AND VERY CONCERNING TO ME AS I'VE HAD THE LOCAL TOYOTA DEALERSHIP AND MY PERSONAL MECHANIC TELL ME NOT TO DRIVE IT AT ALL AND IF SO KEEP IT TO A MINIMUM. NOT SURE WHAT TO DO BECAUSE THAT BASICALLY MEANS THE SUV IS NO GOOD... I WAS TOLD THERE IS A...

HAD A MISFIRE IN #6 CYLINDER AT 155K MILES. I TOOK IT TO A DEALER AND THEY TOLD ME THAT I HAD A HEAD GASKET STARTING TO GO BAD THAT LET COOLANT INTO THAT CYLINDER AFTER I SHUT THE ENGINE OFF RESULTING IN A ROUGH COLD START. THE TECH SPECIALIST GAVE ME SOME NICE INFORMATION AND AFTER RESEARCH I LEARN...

Mileage: 155,000

FRAME IS ROTTING IN SEVERAL SPOTS. TOYOTA HAS ISSUED RECALLS ON TACOMAS, BUT NOT THE 4RUNNER WHICH HAS THE SAME FRAME.

Mileage: 130,000

FRAME RUST - VEHICLE FAILED INSPECTION DUE TO EXCESSIVE RUST ON FRAME WHICH RENDERED UNSAFE TO OPERATE BY THE INSPECTION STATION. THIS WAS PREVIOUSLY REPORTED HOWEVER THE VIN WAS NOT CORRECT.

Mileage: 117,439

EXCESSIVE RUST AND CORROSION ON FRAME AND SUSPENSION COMPONENTS. MY MECHANIC, WHO SEES PLENTY OF LATE MODEL VEHICLES ACROSS NUMEROUS MAKES, WAS AGHAST WHEN HE SAW HOW MUCH RUST AND CORROSION THERE WAS HERE DURING A RECENT TRANSMISSION REPAIR JOB. HE SAID IT'S TO THE POINT THAT HE'D RECOMMEND TAKING ...

Mileage: 125,000

EXCESS RUST ON FRAME. IT WAS CONCLUDED BY REPAIR SHOP NOT ABLE TO PASS INSPECTION DUE TO SAFETY.

Mileage: 117,439

MY VEHICLE HAS EXCESSIVE FRAME RUST ON THE PASSENGER SIDE MIDDLE OF FRAME AND HAS A HOLE. I'M CONCERNED THE FRAME MAY SPLIT IN HALF WHILE DRIVING.

FRAME IS RUSTING IN KEY AREAS MAKING THE VEHICLE UNSAFE TO DRIVE UNTILL REPAIRS ARE MADE TO THE FRAME. THERE ARE RUST HOLES NEAR THE CROSS ARM AND ABOVE THE REAR CONTROL ARM AND THE SPARE TIRE DETACHED WHILE DRIVING DUE TO RUST.

Mileage: 223,000

EXCESSIVE RUST ON FRAME CREATING ABNORMAL HANDLING CONDITION WHEN IN MOTION, SAFETY IS BECOMING A CONCERN.

Mileage: 180,000

SIGNIFICANT RUST THROUGHOUT FRAME, AS WELL AS MANY COMPONENTS AROUND THE ENGINE.

Mileage: 110,000

EXCESSIVE RUST ON FRAME. DETERIORATED STRUCTURE NEAR RADIATOR AND SKID PLATE.

FRAME RUST PREVALENT. THERE APPEARS TO BE A FEW POORLY DESIGNED AREAS ON THE FRAME THAT ACCUMULATE WATER AND RUST AT AN ACCELERATED RATE COMPARED TO OTHER SECTIONS, NAMELY: FRONT RADIATOR AUXILLARY BRACKET THAT SUPPORTS THE FRONT SKID PLATE AND TRANS COOLER LINES, AND THE SECTIONS OF FRAME DIRECTLY ...

Mileage: 125,000

FRAME RUSTING BADLY, ESPECIALLY THE LOWER FRONT RADIATOR SUPPORTS. PAINT CLEAR COAT HAS FAILED. RUST AROUND THE FRONT WINDSHIELD AREA. THE COATING ON THE ALLOY WHEELS STARTED FALLING OFF WITHIN ONE YEAR OF PURCHASE. THE VEHICLE HAS 125000 MILES I AM THE ORIGINAL OWNER AND LIVED IN THE NEW ENGLAND AR...

FRAME RUSTING BADLY, ESPECIALLY THE LOWER FRONT RADIATOR SUPPORTS. PAINT CLEAR COAT HAS FAILED. RUST AROUND THE FRONT WINDSHIELD AREA. THE COATING ON THE ALLOY WHEELS STARTED FALLING OFF WITHIN ONE YEAR OF PURCHASE. THE VEHICLE HAS 125000 MILES I AM THE ORIGINAL OWNER AND LIVED IN THE NEW ENGLAND AR...

FRAME RUSTING BADLY, ESPECIALLY THE LOWER FRONT RADIATOR SUPPORTS. PAINT CLEAR COAT HAS FAILED. RUST AROUND THE FRONT WINDSHIELD AREA. THE COATING ON THE ALLOY WHEELS STARTED FALLING OFF WITHIN ONE YEAR OF PURCHASE. THE VEHICLE HAS 125000 MILES I AM THE ORIGINAL OWNER AND LIVED IN THE NEW ENGLAND AR...

PARTS OF THE VEHICLES EXTERIOR AND INCLUDING FRAME AND SUBFRAME COMPONENTS ARE EXCESSIVELY RUSTED. PARTS ARE OF THE SUSPENSION AND OTHER HARD PARTS ARE HAVING TO BE REPLACED DUE TO CORROSION.

Mileage: 120,000

PARTS OF THE VEHICLES EXTERIOR AND INCLUDING FRAME AND SUBFRAME COMPONENTS ARE EXCESSIVELY RUSTED. PARTS ARE OF THE SUSPENSION AND OTHER HARD PARTS ARE HAVING TO BE REPLACED DUE TO CORROSION.

Mileage: 120,000

PARTS OF THE VEHICLES EXTERIOR AND INCLUDING FRAME AND SUBFRAME COMPONENTS ARE EXCESSIVELY RUSTED. PARTS ARE OF THE SUSPENSION AND OTHER HARD PARTS ARE HAVING TO BE REPLACED DUE TO CORROSION.

Mileage: 120,000

UNDER CARRIAGE , FRAME RUST THROUGH VERY SIMILAR TO THE TOYOTA TACOMA FRAME RUST THROUGH.

Mileage: 156,900

WHILE DRIVING MY LOWER CONTROL ARM SNAPPED OFF ON THE REAR RIGHT SIDE OF MY VEHICLE. I ALMOST CRASHED MY VEHICLE AND COLLIDED WITH ANOTHER VEHICLE BECAUSE I COULDN'T CONTROL THE STEERING WHEN THIS SNAPPED OFF. MY MECHANIC SAID IT CANNOT BE REPAIRED BECAUSE THE FRAME IS HOLLOW IN THAT AREA AN THE F...

Mileage: 198,000

FRAME IS EXTREMELY RUSTED, IT JUST FLAKES OFF AND AFTER INSPECTING THE JOINTS AM AFRAID THAT IT WILL SOON BECOME A SAFETY HAZARD ALSO THE BRAKE CALIPERS BECOME IN-OP (FROZEN) HAVE REPLACED THE 2 FRONT CALIPERS 3 TIMES AND THE 2 REAR CALIPERS TWICE

Mileage: 117,000

FRAME IS EXTREMELY RUSTED, IT JUST FLAKES OFF AND AFTER INSPECTING THE JOINTS AM AFRAID THAT IT WILL SOON BECOME A SAFETY HAZARD ALSO THE BRAKE CALIPERS BECOME IN-OP (FROZEN) HAVE REPLACED THE 2 FRONT CALIPERS 3 TIMES AND THE 2 REAR CALIPERS TWICE

Mileage: 117,000

2004 4RUNNER SPORT V8 WITH 135MI. VEHICLE FRAME HAS RUSTED TO THE POINT THAT IT WILL NO LONGER PASS PENNSYLVANIA VEHICLE INSPECTION. VEHICLE HAS BEEN DEEMED UNSAFE DUE TO EXCESSIVE FRAME RUST. THE EXTENT OF THE RUST IS NOT COMMENSURATE WITH THE AGE, MILEAGE, OR ELEMENT EXPOSURE OF THE VEHICLE. T...

Mileage: 135,000

KINGS TOYOTA DEALERSHIP INFORMED ME THAT THE FRAME IS RUSTED SO SEVERELY THAT IT IS UNSAFE TO DRIVE THE VEHICLE. SERVICE TECHNICIAN SAYS RUST IS SO BAD THEY CANNOT PUT IT ON A LIFT..

Mileage: 138,000

KINGS TOYOTA DEALERSHIP INFORMED ME THAT THE FRAME IS RUSTED SO SEVERELY THAT IT IS UNSAFE TO DRIVE THE VEHICLE. SERVICE TECHNICIAN SAYS RUST IS SO BAD THEY CANNOT PUT IT ON A LIFT..

Mileage: 138,000

KINGS TOYOTA DEALERSHIP INFORMED ME THAT THE FRAME IS RUSTED SO SEVERELY THAT IT IS UNSAFE TO DRIVE THE VEHICLE. SERVICE TECHNICIAN SAYS RUST IS SO BAD THEY CANNOT PUT IT ON A LIFT..

Mileage: 138,000

THE SUN VISOR KEEP DROPPING AND IT IS HARD TO SEE AND IT IS OBSTRUCTING THE VISION WHILE DRIVING

FRAME EXCESS RUST

I OWN A 2004 TOYOTA 4 RUNNER THAT HAS A REALLY BAD RUST PROBLEM AROUND THE LOWER RADIATOR SUPPORT. IT HAS 145000 MILES AND IT'S BEEN GARAGE KEPT MOST OF IT LIFE ..

Mileage: 145,000

THE VEHICLE FRAME HAS RUSTED THROUGH FROM THE INSIDE OUT. THIS APPEARS TO BE A COMMON PROBLEM WITH TOYOTA FRAMES OF THIS VINTAGE. TOYOTA HAS RECALLED AND TAKEN CORRECTIVE ACTION INCLUDING FRAME REPLACEMENT FOR US BUILT TRUCKS - TACOMAS AND TUNDRAS, BUT HAS NOT TAKEN ACTION WITH 4RUNNERS, WHICH A...

Mileage: 160,000

SINCE VEHICLE WAS 5YRS OLD THE FRAME HAS RUSTED TERRIBLY. THE RUST IS SO SIGNIFICANT THERE ARE HOLES AND PIECES OF IT HAVE JUST FALLEN OFF. CURRENTLY, THE STEERING JOINT IS SO RUSTED THAT IT CANNOT BE DRIVEN SAFELY BECAUSE IT FEELS LIKE IT MAY LOSE CONTROL ON THE ROAD. ENTIRE UNDERCARRIAGE APPEAR...

Mileage: 131,000

SINCE VEHICLE WAS 5YRS OLD THE FRAME HAS RUSTED TERRIBLY. THE RUST IS SO SIGNIFICANT THERE ARE HOLES AND PIECES OF IT HAVE JUST FALLEN OFF. CURRENTLY, THE STEERING JOINT IS SO RUSTED THAT IT CANNOT BE DRIVEN SAFELY BECAUSE IT FEELS LIKE IT MAY LOSE CONTROL ON THE ROAD. ENTIRE UNDERCARRIAGE APPEAR...

Mileage: 131,000

SINCE VEHICLE WAS 5YRS OLD THE FRAME HAS RUSTED TERRIBLY. THE RUST IS SO SIGNIFICANT THERE ARE HOLES AND PIECES OF IT HAVE JUST FALLEN OFF. CURRENTLY, THE STEERING JOINT IS SO RUSTED THAT IT CANNOT BE DRIVEN SAFELY BECAUSE IT FEELS LIKE IT MAY LOSE CONTROL ON THE ROAD. ENTIRE UNDERCARRIAGE APPEAR...

Mileage: 131,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 167,000.

Mileage: 167,000

EXTENSIVE RUST AND CORROSION ON FRAME AND SUSPENSION PARTS. I AM THE ORIGINAL OWNER AND THE VEHICLE HAS 134,000 MILE. ADVISED BY TECHNICIAN THAT THIS IS NOT NORMAL WEAR.

Mileage: 134,000

EXTENSIVE RUST AND CORROSION ON FRAME AND SUSPENSION PARTS. I AM THE ORIGINAL OWNER AND THE VEHICLE HAS 134,000 MILE. ADVISED BY TECHNICIAN THAT THIS IS NOT NORMAL WEAR.

Mileage: 134,000

FRAME HAS RUST HOLES ALMOST BROKE ON RIGHT SIDE AND RUNNING THREW ON LEFT

MADE A LEFT TURN AT APPROXIMATELY 10 MPH, HEARD LOUD THUNK, STOPPED VEHICLE, INSPECT ED UNDERSIDE LEFT FRONT, WHEEL "ARM" TOTALLY DETACHED FROM FRAME. INSPECTED AT GARAGE, FRAME RUSTED CAUSING SEPARATION. GRATEFUL THIS HAPPENED AFTER TURNING OFF OF 55 MPH ROAD. RESEARCH INDICATES THIS TO BE A PROBLE...

Mileage: 198,000

FRAME IS RUSTED BADLY POOR BREAKING SYSTEM I HAD TO REPLACE THE LINES THAT KEEPS MY TOYOTA STABILIZED. I PUT SO MUCH MONEY INTO MY 2004 TOYOTA 4 RUNNER LIMITED. NOW THE RUST HAS TAKEN OVER ON SIDES AND UNDER RADIATOR. TRANSMISSION LINES NOW LEAKING BADLY RUST HAS BEEN AN ON GOING PROBLEM BUT WHEN I...

Mileage: 94,000

FRAME IS RUSTED BADLY POOR BREAKING SYSTEM I HAD TO REPLACE THE LINES THAT KEEPS MY TOYOTA STABILIZED. I PUT SO MUCH MONEY INTO MY 2004 TOYOTA 4 RUNNER LIMITED. NOW THE RUST HAS TAKEN OVER ON SIDES AND UNDER RADIATOR. TRANSMISSION LINES NOW LEAKING BADLY RUST HAS BEEN AN ON GOING PROBLEM BUT WHEN I...

Mileage: 94,000

FRAME IS RUSTED BADLY POOR BREAKING SYSTEM I HAD TO REPLACE THE LINES THAT KEEPS MY TOYOTA STABILIZED. I PUT SO MUCH MONEY INTO MY 2004 TOYOTA 4 RUNNER LIMITED. NOW THE RUST HAS TAKEN OVER ON SIDES AND UNDER RADIATOR. TRANSMISSION LINES NOW LEAKING BADLY RUST HAS BEEN AN ON GOING PROBLEM BUT WHEN I...

Mileage: 94,000

TAKATA RECALL THIS YEAR THE EXACT SAME FRAMES WERE REPLACED ON THE TOYOTA TACOMA. MY FRAME AND CROSS MEMBERS ARE RUSTED OUT ON THE FRONT END AND THIS HAS BEEN GARAGE KEPT AND ONLY HAS 92K MILES. MY 4RUNNER SHOULD NOT HSVE THIS MUCH RUST ON THE FRAME, AFTER IT HAS BEEN METICULOUSLY TAKEN CARE OF.

WE HAVE A 2004 TOYOTA 4RUNNER WITH 121,510 AND WE'RE INFORMED THAT THE WHOLE FRAME IS RUSTED. WE LEARNED THAT TOYOTA HAD A SIMILAR ISSUE WITH FRAMES IN OTHER VEHICLES FOR THE SAME REASON AND IT WAS RECALLED FOR THOSE VEHICLES BUT THERE IS NO RECALL ON THE 4RUNNER. MY VEHICLE RUNS WELL AND HAS NO ISS...

Mileage: 121,510

HI, I RECENTLY PURCHASED A TOYOTA 4RUNNER 2004 FROM A PREVIOUS OWNER. I DON'T KNOW MUCH ABOUT CARS AND HOW THE PROCESS WORKS. BUT WHEN THE CHECK ENGINE LIGHT CAME ON. I WENT TO GO TAKE IT TO GET IT FIXED AS WELL AS PREPARING THE CAR FOR THE SMOG TEST. WHICH IT FAILED, TOYOTA THE COMPANY WAS UNABLE ...

Mileage: 128,000

HI, I RECENTLY PURCHASED A TOYOTA 4RUNNER 2004 FROM A PREVIOUS OWNER. I DON'T KNOW MUCH ABOUT CARS AND HOW THE PROCESS WORKS. BUT WHEN THE CHECK ENGINE LIGHT CAME ON. I WENT TO GO TAKE IT TO GET IT FIXED AS WELL AS PREPARING THE CAR FOR THE SMOG TEST. WHICH IT FAILED, TOYOTA THE COMPANY WAS UNABLE ...

Mileage: 128,000

FRAME IS RUSTED AND WARNED WILL LIKELY NOT PASS STATE INSPECTION WHEN RENEWAL IS REQUIRED IN JUNE 2019 BY SEVERAL MECHANICS

Mileage: 254,000

TOYOTA TRUCK FRAME CORROSION UPON INSTALLATION OF FAILED SUSPENSION COMPONENTS ON MY 2004 TOYOTA 4RUNNER, MY INDEPENDENT MECHANIC INFORMED ME OF SUBSTANTIAL FRAME CORROSION. I CONTACTED LYNCH TOYOTA WITH MY CONCERNS, LYNCH TOYOTA INSPECTED MY 4RUNNER AND FOUND SUBSTANTIAL FRAME CORROSION, VEHICLE ...

Mileage: 128,672

TOYOTA TRUCK FRAME CORROSION UPON INSTALLATION OF FAILED SUSPENSION COMPONENTS ON MY 2004 TOYOTA 4RUNNER, MY INDEPENDENT MECHANIC INFORMED ME OF SUBSTANTIAL FRAME CORROSION. I CONTACTED LYNCH TOYOTA WITH MY CONCERNS, LYNCH TOYOTA INSPECTED MY 4RUNNER AND FOUND SUBSTANTIAL FRAME CORROSION, VEHICLE ...

Mileage: 128,672

TOYOTA TRUCK FRAME CORROSION UPON INSTALLATION OF FAILED SUSPENSION COMPONENTS ON MY 2004 TOYOTA 4RUNNER, MY INDEPENDENT MECHANIC INFORMED ME OF SUBSTANTIAL FRAME CORROSION. I CONTACTED LYNCH TOYOTA WITH MY CONCERNS, LYNCH TOYOTA INSPECTED MY 4RUNNER AND FOUND SUBSTANTIAL FRAME CORROSION, VEHICLE ...

Mileage: 128,672

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THERE WAS EXTENSIVE RUST ON THE FRAME OF THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED BY A DEALER. AN INDEPENDENT MECHANIC DIAGNOSED THAT THERE WERE MASSIVE HOLES AND CRACKS IN THE FRONT AND REAR OF THE FRAME, AND THE REAR WHEEL WELL ...

Mileage: 194,000

BRAKE CALIPERS KEEP SEIZING & NEED TO BE REPLACED. 09/10/2018 07/24/2014 04/17/2013 04/13/2013 06/18/2012

Mileage: 270,000

MY 2004 TOYOTA 4 RUNNER IS IN THE DEALER FOR ROUTINE MAINTENANCE. MOST OF THE CAR MAINTENANCE HAVE BEEN AT THIS LOCAL TOYOTA DEALERSHIP. I JUST HAD THE CV BOOTS AND SWAY BAR BUSHINGS REPLACED THIS PAST SPRING AND SUMMER. I HAVE THE RECORDS FOR THESE PARTICULAR MAINTENANCE AND REPAIR. MY SERVICE...

Mileage: 102,000

MY 2004 TOYOTA 4 RUNNER IS IN THE DEALER FOR ROUTINE MAINTENANCE. MOST OF THE CAR MAINTENANCE HAVE BEEN AT THIS LOCAL TOYOTA DEALERSHIP. I JUST HAD THE CV BOOTS AND SWAY BAR BUSHINGS REPLACED THIS PAST SPRING AND SUMMER. I HAVE THE RECORDS FOR THESE PARTICULAR MAINTENANCE AND REPAIR. MY SERVICE...

Mileage: 102,000

MY 2004 TOYOTA 4 RUNNER IS IN THE DEALER FOR ROUTINE MAINTENANCE. MOST OF THE CAR MAINTENANCE HAVE BEEN AT THIS LOCAL TOYOTA DEALERSHIP. I JUST HAD THE CV BOOTS AND SWAY BAR BUSHINGS REPLACED THIS PAST SPRING AND SUMMER. I HAVE THE RECORDS FOR THESE PARTICULAR MAINTENANCE AND REPAIR. MY SERVICE...

Mileage: 102,000

MY 2004 TOYOTA 4 RUNNER IS IN THE DEALER FOR ROUTINE MAINTENANCE. MOST OF THE CAR MAINTENANCE HAVE BEEN AT THIS LOCAL TOYOTA DEALERSHIP. I JUST HAD THE CV BOOTS AND SWAY BAR BUSHINGS REPLACED THIS PAST SPRING AND SUMMER. I HAVE THE RECORDS FOR THESE PARTICULAR MAINTENANCE AND REPAIR. MY SERVICE...

Mileage: 102,000

WHILE DRIVING ON THE HIGHWAY MY CAR WENT OUT OF ALIGNMENT DUE TO A ROTTEN TORSION BAR MOUNT. THE ENTIRE FRAME ALSO HAS LOTS OF ROT

Mileage: 151,000

WHILE DRIVING ON THE HIGHWAY MY CAR WENT OUT OF ALIGNMENT DUE TO A ROTTEN TORSION BAR MOUNT. THE ENTIRE FRAME ALSO HAS LOTS OF ROT

Mileage: 151,000

WHILE DRIVING ON THE HIGHWAY MY CAR WENT OUT OF ALIGNMENT DUE TO A ROTTEN TORSION BAR MOUNT. THE ENTIRE FRAME ALSO HAS LOTS OF ROT

Mileage: 151,000

FRAME IS PREMATURELY FAILING. THERE ARE HOLES RUSTED IN THE FRAME. THIS HAS BEEN A KNOWN PROBLEM WITH OTHER TOYOTA MODELS WHICH UTILIZE THE SAME FRAME. TOYOTA DID A RANDOM "INSPECTION" WHERE THEY IDENTIFIED AND FIXED ON PIECE OF THE FRAME BUT HAVE FAILED TO PROVIDE SUPPORT FOR THE ENTIRE FRAME. ...

Mileage: 95,000

THE FRAM IS EXCESSIVELY RUSTED FROM YEARS IN 'COLD WEATHER STATES.

Mileage: 165,000

THE FRAM IS EXCESSIVELY RUSTED FROM YEARS IN 'COLD WEATHER STATES.

Mileage: 165,000

THE FRAM IS EXCESSIVELY RUSTED FROM YEARS IN 'COLD WEATHER STATES.

Mileage: 165,000

EXCESSIVE FRAME RUST, INCLUDING HOLES, AND GENERAL RUST ALL AROUND THE FRAME. SPECIFICALLY IN THE FRONT AND REAR.

Mileage: 160,000

EXCESSIVE FRAME RUST, INCLUDING HOLES, AND GENERAL RUST ALL AROUND THE FRAME. SPECIFICALLY IN THE FRONT AND REAR.

Mileage: 160,000

THE AIRBAGS FAILED TO DEPLOY UPOND IMPACT FROM A TRACTOR TRAILER. CAR COMPLETELY TOTALED.

Mileage: 45

WE PURCHASED A 2004 TOYOTA 4 RUNNER IN MAY OF 2017. THE DEALER INFORMED US THAT HIS MECHANIC HAD CHECKED THE VEHICLE OVER AND WAS IN GOOD SHAPE AND SHOULD LAST US A LONG TIME. ON AUGUST 14, 2018 I DRIVE THE VEHICLE TO A TOYOTA DEALERSHIP APPROXIMATELY 70 MILES AWAY TO HAVE DIAGNOSTICS RUN ON IT FOR ...

Mileage: 155,950

THE OUTSIDE OF MY 4RUNNER IS RUST FREE. THE FRAME HOWEVER HAS EXTENSIVE RUST ISSUES. I HAVE HAD TO HAVE SECTIONS CUT OUT AND REWELDED BECAUSE IT WOULD NOT PASS INSPECTION. THE STEERING COLUMN RUSTED OUT AND HAD TO BE REPLACED BECAUSE THE STEERING STOPPED RESPONDING.

THE FRAME IS RUSTED REALLY BAD. THE BRACKET THAT HOLDS THE REAR PASSENGER SIDE LOWER CONTROL ARE HAS RUSTED OFF MAKING ME TIE IT UP AND MAKING IT USELESS. THE FRAME HAS SEVERAL PLACES THAT THE RUST HAS ATE LARGE HOLES IN IT. IF YOU NEED ME TO I CAN MAIL PICTURES TO YOU. I BOUGHT THIS 4RUNNER BRAND N...

RUST ON THE FRAME INCLUDING THE REAR BUMPER, CRACK IN THE DASHBOARD FROM DRIVERS SIDE OVER TO THE CENTER OF CAR. DRIVERS SEAT EXCESSIVE MOVEMENT AT ATTACHMENT BETWEEN SEAT BACK AND BASE ON EXTERNAL PORTION OF SEAT. THE VEHICLE WAS PARKED AT VARIOUS TIMES WHEN INSPECTED. REPAINTED RIMS THAT PAINT HA...

Mileage: 145,000

RUST ON THE FRAME INCLUDING THE REAR BUMPER, CRACK IN THE DASHBOARD FROM DRIVERS SIDE OVER TO THE CENTER OF CAR. DRIVERS SEAT EXCESSIVE MOVEMENT AT ATTACHMENT BETWEEN SEAT BACK AND BASE ON EXTERNAL PORTION OF SEAT. THE VEHICLE WAS PARKED AT VARIOUS TIMES WHEN INSPECTED. REPAINTED RIMS THAT PAINT HA...

Mileage: 145,000

RUST ON THE FRAME INCLUDING THE REAR BUMPER, CRACK IN THE DASHBOARD FROM DRIVERS SIDE OVER TO THE CENTER OF CAR. DRIVERS SEAT EXCESSIVE MOVEMENT AT ATTACHMENT BETWEEN SEAT BACK AND BASE ON EXTERNAL PORTION OF SEAT. THE VEHICLE WAS PARKED AT VARIOUS TIMES WHEN INSPECTED. REPAINTED RIMS THAT PAINT HA...

Mileage: 145,000

MY FRAME FOR MY 2004 4RUNNER ARE ROTTING AND RUSTING AWAY MAKING IT UNSAFE FOR ME TO DRIVE.

Mileage: 128,000

2004 TOYOTA 4RUNNER FRAME RUST RECALL

MY NAME IS [XXX], I AM HERE BECAUSE OF RUSTED FRAMES I WAS JUST TOLD TODAY BY AAA MECHANIC CENTER IN SKOKI ILLINOIS THAT I CAN NOT DRIVE MY 4RUNNER HOME BECAUSE ISN'T SAFE FOR DRIVE, AND THEY SHOW ME THE FRAMES BOTH SIDES ARE RUSTED AND I TOOK THE CAR TO 6042 N WESTERN AVE CHICAGO IL 60659 (773-728-...

SEVERE FRAME RUSTING, WITH HOLES, SOME AS LONG AS 6", AND WOULD NOT PASS PENNSYLVANIA INSPECTION. HAD TO HAVE WELDED IN 6 DIFFERENT SECTIONS.CENTER FRONT TOE, LEFT AND RIGHT FRONT HARNESS, LEFT AND RIGHT FRAME CENTER, AND LEFT REAR FRAME END. THE GARAGE AND AUTOBODY SHOP SAID TOYOTA SHOULD BE RECA...

Mileage: 188,000

I JUST DISCOVERED THAT THE FRAME ON MY 4RUNNER IS SEVERELY RUSTED DUE TO LOW QUALITY STEEL. SEVERAL MECHANICS HAVE OBSERVED THE FRAME AND ALL OF THEM HAVE TOLD ME IT IS UNSAFE TO DRIVE. I HAVE A 2003 TOYOTA LAND CRUISER AND ITS FRAME IS IN GREAT CONDITION. BOTH CARS HAVE BEEN GARAGED AND OPERATED...

Mileage: 185,000

MY 2004 TOYOTA 4RUNNER WAS NOT ABLE TO GET A BRAKE JOB BECAUSE THE FRAME WAS RUSTED, REAR TRAILING ARM BRACKETS BROKEN OFF, DIFFERENTIAL HOUSING ON BOTH SIDES BROKEN, HOLES IN FRAME RIGHT SIDE. TOTALLY RUSTED AND UNSAFE TO DRIVE.

Mileage: 106,500

THE FRAME AND STRUCTURE HAVE RUSTED FROM THE INSIDE OUT TO AN ALARMING DEGREE. SPECIFICALLY AT THE FRAME WELD POINTS IN MIDSECTION AND THE REAR ATTACHMENTS TO AXLE. IT IS A SAFETY HAZARD AND IT HAS RUSTED FAR MORE QUICKLY AND DRAMATICALLY THAN ANY OF THE OTHER COMPONENTS. NONE OF MY OTHER VEHICLES H...

Mileage: 140,000

THE FRAME AND STRUCTURE HAVE RUSTED FROM THE INSIDE OUT TO AN ALARMING DEGREE. SPECIFICALLY AT THE FRAME WELD POINTS IN MIDSECTION AND THE REAR ATTACHMENTS TO AXLE. IT IS A SAFETY HAZARD AND IT HAS RUSTED FAR MORE QUICKLY AND DRAMATICALLY THAN ANY OF THE OTHER COMPONENTS. NONE OF MY OTHER VEHICLES H...

Mileage: 140,000

THE FRAME AND STRUCTURE HAVE RUSTED FROM THE INSIDE OUT TO AN ALARMING DEGREE. SPECIFICALLY AT THE FRAME WELD POINTS IN MIDSECTION AND THE REAR ATTACHMENTS TO AXLE. IT IS A SAFETY HAZARD AND IT HAS RUSTED FAR MORE QUICKLY AND DRAMATICALLY THAN ANY OF THE OTHER COMPONENTS. NONE OF MY OTHER VEHICLES H...

Mileage: 140,000

FLAKING RUSTY FRAME. ANY UNDERCARRIAGE SCRATCH IMMEDIATELY RUSTS

Mileage: 117,000

THE 4RUNNER WAS WELL CARED FOR AND THE FRAME HAS ROTTED TO NOTHING IN UNDER 15 YEARS. IT IS EXTREMELY UNSAFE AND IS THE SAME ISSUE PRESENT IN THE TACOMA'S AND OTHER TOYOTA FULL FRAME VEHICLES. THE RUST DEVELOPS EARLY AND IN THE SAME SPOTS ON ALL MODELS. IT SPREADS RAPIDLY AND COMPROMISES THE ENTIRE...

Mileage: 167,000

2004 TOYOTA 4RUNNER WITH SIGNIFICANT RUST ON THE UNDERBODY INCLUDING FRAME. THE VEHICLE IS STATIONARY BUT WAS DEEMED UNSAFE TO DRIVE DUE TO FRAME DAMAGE. IT HAS BEEN WELL MAINTAINED AND THERE ARE NO OTHER ISSUES ASIDE FROM SIGNIFICANT RUST DAMAGE.

Mileage: 149,000

MY 2004 TOYOTA 4 RUNNER HAS SERIOUS SAFETY ISSUES WITH THE FRAME RUSTING. I HAVE ROUTINELY MAINTAINED THE VEHICLE, INCLUDING ROUTINE WASHING UNDERNEATH ON THE FRAME. I TOOK MY VEHICLE INTO THE TOYOTA DEALER FOR SERVICE AND THEY DECLARED THE VEHICLE IS UNSAFE TO DRIVE DUE TO RUST ON THE FRAME. T...

Mileage: 242,000

I AM THE ORIGINAL OWNER OF 04 V8 4RUNNER SPORT AND IT JUST PASSED THE 200,000 MILE MARK. THE SUV RUNS GREAT STILL, BUT THE FRAME IS RUSTING OUT SO BAD THAT IT IS BECOMING DANGEROUS TO DRIVE. WE HAD TO WELD A PATCH FOR THE RADIATOR SUPPORT AND THE FRONT TOW/TIE DOWN HOOK BROKE OFF, THE ENTIRE FRAME I...

THE FRAME HAS RUSTED ON THE PASSENGER SIDE WHERE THE FRAME IS WELDED TOGETHER. THE CHICAGO NORTHSIDE TOYOTA DEALER FOUND IT WHILE DOING WORK ON MY VEHICLE. IT IS ABOUT A 3 INCH HOLE ON THE OUTSIDE OF THE FRAME AND THERE IS ALSO A RUSTED HOLE ON THE OPPOSITE SIDE NEAR THE BRACKETS. PLEASE SEE PICT...

Mileage: 95,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V065000 (AIR BAGS); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN TOYOTA DEA...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS PARKED, CRACKS WERE SEEN IN THE DASHBOARD. THE DEALER (ZT MOTORS OF FORT WALTON BEACH, 1000 N BEAL PKWY NW, FORT WALTON BEACH, FL 32547, (850) 863-2167) WAS CONTACTED, BUT THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WA...

Mileage: 22,000

2004 V8 4 RUNNER WITH ONLY 62,000 MI.,FRAME FRACTURE RIGHT REAR @ LOWER CONTROL ARM ATTACHMENT POINT. LEFT REAR OF FRAME MISSING TWO SIDES @ WHEEL WELL AND LARGE HOLE AT LOWER CONTROL ARM ATTACHMENT. ADVISED BY MECHANIC NOT TO DRIVE THE TRUCK. THIS IS THE SAME ISSUE TOYOTA HAD WITH THE TACOMA AND TU...

I'VE HAD THIS 2004 TOYOTA 4RUNNER SINCE 2004 I BOUGHT IT NEW AND HAVE TAKEN GOOD CARE OF IT. THE BODY STILL LOOKS GREAT, NO RUST ON BODY JUST HAS 94000 MILES ON IT. BUT THE UNDER SIDE IS AWFUL THE FRAME HAS HOLES RUSTED THROUGH AT HIGH PRESSURE POINTS LIKE SUSPENSION POINTS, CROSS MEMBERS FOR TRANSM...

Mileage: 85,000

ON FEBRUARY 10, 2018, I WAS DRIVING MY 2004 4RUNNER IN A SNOWSTORM IN 4WD HIGH WHEN THE CHECK ENGINE LIGHT SUDDENLY CAME ON AND THE STABILITY CONTROL AND TRACTION CONTROL SYSTEMS IMMEDIATELY SHUT DOWN, CAUSING THE REAR OF THE VEHICLE TO START SLIDING AND PUTTING ME ON A COLLISION COURSE WITH ONCOMIN...

Mileage: 179,500

TOTAL VEHICLE FRAME IS RUSTED THROUGH. NOT SAFE TO DRIVE

Mileage: 134,000

FRAME IS RUSTING OUT CREATING A DRIVING HAZARD WHICH COULD RESULT IN INJURY TO DRIVER AND OR PASSENGERS

Mileage: 140,000

FRAME IS RUSTING OUT CREATING A DRIVING HAZARD WHICH COULD RESULT IN INJURY TO DRIVER AND OR PASSENGERS

Mileage: 140,000

DASHBOARD CRACKING NEXT STAGE IS MELTING WHICH WILL CAUSE GLARE ON WINDSHIELD REDUCING VISIBILITY.

Mileage: 130,000

TOYOTA DASHBOARD CRACKING / MELTING AFTER TOYOTA EXTENDED WARRANTY ZE6 CLOSED OUT. THIS NEEDS TO BE A RECALL I HAVE SEEN DASHBOARDS THAT HAVE MELTED AND CAUSE WINDOW GLARE. WHICH AFFECTS DRIVES ABILITY TO SEE.

Mileage: 130,000

TOYOTA DASHBOARD CRACKING / MELTING AFTER TOYOTA EXTENDED WARRANTY ZE6 CLOSED OUT. THIS NEEDS TO BE A RECALL I HAVE SEEN DASHBOARDS THAT HAVE MELTED AND CAUSE WINDOW GLARE. WHICH AFFECTS DRIVES ABILITY TO SEE.

Mileage: 130,000

TOYOTA DASHBOARD CRACKING / MELTING AFTER TOYOTA EXTENDED WARRANTY ZE6 CLOSED OUT. THIS NEEDS TO BE A RECALL I HAVE SEEN DASHBOARDS THAT HAVE MELTED AND CAUSE WINDOW GLARE. WHICH AFFECTS DRIVES ABILITY TO SEE.

Mileage: 130,000

I'VE PUT A DOWN PAYMENT OF 1200 AT PREMIER AUTO SALES . IN VICTORIA TX I LEFT FEEL POSITIVE ABOUT THE VEHICLE . THE SALES MAN TOLD ME AS SOON AS THEY GET A MECHANIC TO LOOK AT IT . IT DIDN'T HAVE AN INSPECTION EITHER . SO I TOOK IT TO P&H ALL THEY DID WAS RIGHT IN A PAPER AN SENT IT BACK WITH ME TO ...

I'VE PUT A DOWN PAYMENT OF 1200 AT PREMIER AUTO SALES . IN VICTORIA TX I LEFT FEEL POSITIVE ABOUT THE VEHICLE . THE SALES MAN TOLD ME AS SOON AS THEY GET A MECHANIC TO LOOK AT IT . IT DIDN'T HAVE AN INSPECTION EITHER . SO I TOOK IT TO P&H ALL THEY DID WAS RIGHT IN A PAPER AN SENT IT BACK WITH ME TO ...

I'VE PUT A DOWN PAYMENT OF 1200 AT PREMIER AUTO SALES . IN VICTORIA TX I LEFT FEEL POSITIVE ABOUT THE VEHICLE . THE SALES MAN TOLD ME AS SOON AS THEY GET A MECHANIC TO LOOK AT IT . IT DIDN'T HAVE AN INSPECTION EITHER . SO I TOOK IT TO P&H ALL THEY DID WAS RIGHT IN A PAPER AN SENT IT BACK WITH ME TO ...

MY 2004 WELL-MAINTAINED TOYOTA 4RUNNER'S, WITH 170,000 MILES, FRAME RUSTED SO BADLY THAT IT WOULDN'T PASS THE NYS INSPECTION. THE FRAME ON THIS SUV IS THE SAME FRAME AS THE RECALLED 2004 TOYOTA TACOMA'S, WHICH WERE ABLE TO HAVE THERE FRAMES REPLACED DUE TO RUSTING ISSUES.

Mileage: 17,000

MICHELIN GREEN X TIRES, SIZE 265/65/17. WITH LESS THAN 35,000 MILES, THE TIRES ARE SPLITTING ON THE SIDE WALLS AS WELL AS BETWEEN THE TREADS. I'VE BEEN USING MICHELIN TIRES SINCE THE EARLY 90'S AND THESE ARE THE WORST TIRES I HAVE EVER USED. MAKES ME THINK TWICE BEFORE I BUY ANOTHER SET. THE TIR...

Mileage: 164,000

MY 2004 TOYOTA 4RUNNER FRAME/CHASIS IS RUSTED THROUGHOUT. EVERYTHING THAT IS NOT PLASTIC OR RUBBER ON THE CHASIS IS RUSTED OUT. THE SKID PLATE IS RUSTED THROUGH IN SEVERAL PLACES AND NEEDS TO BE REMOVED OR REPLACED BEFORE IT FALLS OFF. TOYOTA HAS RECALLED VEHICLES IN THE PAST AS WELL AS REPLACED ...

Mileage: 164,000

I HAVE A 2004 TOYOTA 4RUNNER THAT I BELIEVE IS TOO DANGEROUS TO DRIVE DUE TO THE SEVERELY RUSTED FRAME. I HAVE ATTACHED SOME PHOTOS TO SEE FOR YOURSELF. I CONTACTED TOYOTA TWICE TO SEE IF THERE'S ANYTHING THEY COULD DO AND THERE WAS NOTHING. THEY TOLD ME TO FILE A COMPLAINT WITH NHTSA. ALSO I HAVE H...

Mileage: 100,000

VEHICLE FRAME HAS HOLES AROUND HIGH STRESS AREAS FROM SEVERE RUST AND CORROSION.

VEHICLE FRAME HAS HOLES AROUND HIGH STRESS AREAS FROM SEVERE RUST AND CORROSION.

MY 2004 TOYOTA 4RUNNER HAS EXTREME AMOUNTS OF RUST ON THE FRAME TO THE POINT WHERE THERE ARE ACTUAL HOLES FORMING. THIS IS A MAJOR STRUCTURAL ISSUE FOR THE VEHICLE AND INCREDIBLY UNSAFE. I WORRY THAT THIS MAY CAUSE AN ACCIDENT OR RENDER MY VEHICLE INOPERABLE IN THE FUTURE.

Mileage: 156,000

MY 2004 TOYOTA 4RUNNER HAS EXTREME AMOUNTS OF RUST ON THE FRAME TO THE POINT WHERE THERE ARE ACTUAL HOLES FORMING. THIS IS A MAJOR STRUCTURAL ISSUE FOR THE VEHICLE AND INCREDIBLY UNSAFE. I WORRY THAT THIS MAY CAUSE AN ACCIDENT OR RENDER MY VEHICLE INOPERABLE IN THE FUTURE.

Mileage: 156,000

UPON VISUAL INSPECTION FRAME FOUND RUSTED THROUGH ON RIGHT SIDE JUST FORWARD OF REAR AXLE AND APPEARS TO HAVE RUSTED FROM INSIDE. SUSPECT LOW QUALITY STEEL WAS USED. EXCESSIVE RUST ON ENTIRE FRAME. BODY AND MECHANICAL SYSTEMS ARE IN EXCELLENT SHAPE WITH 120,000 MILES. TOYOTA SHOULD BE RESPONSIBLE FO...

Mileage: 120,000

THE UNDER CARRIAGE OF THE TOYOTA 4 RUNNER IS EXTREMELY RUSTED, INCLUDING FRAME, FRAME BRACES UNDER RADIATOR AND SEVERAL OTHER AREAS. I DO NEED HELP FROM TOYOTA TO CORRECT THIS PROBLEM.

RECENTLY BECAME THE OWNER OF 04 4RUNNER WITH WHAT WE THOUGHT AT FIRST GLANCE WERE NEW TIRES. AFTER POOR DRIVING CONDITIONS AND CHECKING THE TIRES WE FOUND BOTH FRONT TIRES WITH TREAD CHUNKING OFF IN MEDIUM PIECES AND ARE UNSAFE. BOTH REAR TIRES ARE FINE. WE LIVE ON A PRETTY SMALL ISLAND WHERE DAI...

ABS, VSB TRAC ON/OFF, AND BRAKE LIGHTS COME ON SUDDENLY ALONG WITH CONTINUOUS HIGH-PITCHED ALERT. BRAKES EVENTUALLY BECOME DIFFICULT TO WORK. HAD TOWED TO DEALER, BY THE TIME DEALER LOOKED AT, IT WASN'T HAPPENING AND THEY COULD FIND NOTHING WRONG. PICKED UP CAR, HAPPENED AGAIN ON WAY HOME (BOTH T...

Mileage: 158,000

ABS, VSB TRAC ON/OFF, AND BRAKE LIGHTS COME ON SUDDENLY ALONG WITH CONTINUOUS HIGH-PITCHED ALERT. BRAKES EVENTUALLY BECOME DIFFICULT TO WORK. HAD TOWED TO DEALER, BY THE TIME DEALER LOOKED AT, IT WASN'T HAPPENING AND THEY COULD FIND NOTHING WRONG. PICKED UP CAR, HAPPENED AGAIN ON WAY HOME (BOTH T...

Mileage: 158,000

ABS, VSB TRAC ON/OFF, AND BRAKE LIGHTS COME ON SUDDENLY ALONG WITH CONTINUOUS HIGH-PITCHED ALERT. BRAKES EVENTUALLY BECOME DIFFICULT TO WORK. HAD TOWED TO DEALER, BY THE TIME DEALER LOOKED AT, IT WASN'T HAPPENING AND THEY COULD FIND NOTHING WRONG. PICKED UP CAR, HAPPENED AGAIN ON WAY HOME (BOTH T...

Mileage: 158,000

TAMARA RECALL (AIRBAGS)

EXTREME FRAME RUST ON MY 2004 TOYOTA 4RUNNER. HAS ONLY 82,000 MILES AND WELL MAINTAINED. BODY IN GOOD CONDITION, NO RUST AT ALL. HAS A LOT OF RUST IN THE ENGINE COMPARTMENT ALSO, TABS, LINES ETC. I KNOW THERE WAS A RECALL ON THE TACOMA FOR FRAME RUST AND I AM AWARE THAT THIS VEHICLE IS ON A TACOMA F...

Mileage: 50,000

EXTREME FRAME RUST ON MY 2004 TOYOTA 4RUNNER. HAS ONLY 82,000 MILES AND WELL MAINTAINED. BODY IN GOOD CONDITION, NO RUST AT ALL. HAS A LOT OF RUST IN THE ENGINE COMPARTMENT ALSO, TABS, LINES ETC. I KNOW THERE WAS A RECALL ON THE TACOMA FOR FRAME RUST AND I AM AWARE THAT THIS VEHICLE IS ON A TACOMA F...

Mileage: 50,000

FRAME RUSTING BADLY. FRONT CROSS MEMBER ALREADY COMPLETELY RUSTED THROUGH.

Mileage: 97,000

AFTER TRAVELING AT SPEEDS CLOSE TO 75 MILES AN HOUR. I EXITED HIGHWAY TO PARKING LOT. BACKED OUT AND WAS UNABLE TO STOP CAR FROM ROLLING. MOVED CAR TO NEW PARKING AREA AND HAD TO USE PARKING BRAKE TO SLOW DOWN. SHUT DOWN CAR CHECK FUILDS. RESTARTED CAR TO LOUD BUZZER AND ABS LIGHTS. VERY CONCERNED I...

2004 4RUNNER. FRAME IS EXTREMELY RUSTED AND TRUCK WILL BECOME DANGEROUS TO OPERATE IN THE VERY NEAR FUTURE. TRUCK IS GARAGE KEPT AND WELL MAINTAINED. NO BODY RUST OR OTHER ISSUES. 100,500 MILES.

Mileage: 100,500

I HAD TO SCHEDULE APPOINTMENTS TO TAKE THE CAR TO TOYOTA BECAUSE OF THE AIRBAG DEFECT.THIS HAPPENED TWICE ONCE IN 2013 AND THEY SAID THAT THERE WAS NO CHARGE AND THAN THEY CHARGED ME $346 AND SAID IT WAS TO REPLACE FLUIDS...THE SECOND RECALL WAS IN 2016 THIS TIME THERE WAS NO CHARGE.

SEVERE CHASSIS RUST, POSSIBLY AFFECTING VEHICLE AND PERSONAL SAFETY

Mileage: 80,000

THE FRAME OF THE 4RUNNER IS RUSTING THROUGH AND HAS CRACKS, AND HOLES. IT IS BECOMING UNSAFE. THIS IS NOT SURFACE RUST, BUT THE FRAMES ARE LITERALLY RUSTING AWAY. TOYOTA NEEDS TO REPLACE THESE FRAMES AS THEY DID THE TACOMA'S FROM THE SAME YEAR THAT WERE A SIMILAR, IF NOT IDENTICAL FRAME.

FRAME AND REAR AXLE HOUSING RUST - CAUSED THE UPPER CONTROL ARMS, WHICH PREVENT ROTATION OF THE REAR AXEL, TO DISCONNECT FROM THE HOUSING/FRAME. ALSO, STEERING HAS BECOME STIFF AND BUMPY AS YOU TURN THE WHEEL. THIS MAY BE DUE TO FRONT CROSSMEMBER RUST OR RUST ON THE STEERING UNIVERSAL JOINT.

FRAME AND REAR AXLE HOUSING RUST - CAUSED THE UPPER CONTROL ARMS, WHICH PREVENT ROTATION OF THE REAR AXEL, TO DISCONNECT FROM THE HOUSING/FRAME. ALSO, STEERING HAS BECOME STIFF AND BUMPY AS YOU TURN THE WHEEL. THIS MAY BE DUE TO FRONT CROSSMEMBER RUST OR RUST ON THE STEERING UNIVERSAL JOINT.

FRAME AND REAR AXLE HOUSING RUST - CAUSED THE UPPER CONTROL ARMS, WHICH PREVENT ROTATION OF THE REAR AXEL, TO DISCONNECT FROM THE HOUSING/FRAME. ALSO, STEERING HAS BECOME STIFF AND BUMPY AS YOU TURN THE WHEEL. THIS MAY BE DUE TO FRONT CROSSMEMBER RUST OR RUST ON THE STEERING UNIVERSAL JOINT.

WHILE DRIVING, AN ALARM BEGAN SOUNDING AND THE BRAKE LIGHT, ASB LIGHT AND VSC LIGHTS ALL CAME ON, WE STOPPED AND CHECKED THE BRAKE FLUID AND FOUND IT WAS FULL. WE THEN CONTINUED TO DRIVE HOME. WITHIN 2 MILES THE BRAKES WENT OUT. THERE HAD BEEN ABSOLUTELY NO INDICATION OF ANYTHING WRONG UP TO THAT ...

Mileage: 168,000

POWER STEERING IS HARD WHEN YOU ARE MAKING TURNS

Mileage: 162,000

WHILE DRIVING ON RESIDENTIAL STREET AT 30 MPH, VSC, ABS AND TRAC DASH LIGHTS CAME ON AND CABIN ALARM SOUNDED. THE BRAKES WERE NOT FUNCTIONING. I HAD TO USE THE EMERGENCY BRAKE AND EVASIVE DRIVING TO AVOID REAR ENDING A SCHOOL BUS. AFTER BRINGING TO MY MECHANIC I LEARNED THAT THE MASTER BRAKE CYLI...

Mileage: 137,000

THE DASHBOARD HAS BEEN MELTING AND CRACKING. ITS GETS STICKY, EXTREMELY SHINY AND GOOY DURING HOT WEATHER AND CAUSED A REFLECTION OF THE SHINY DASHBOARD ON THE WINDSHIELD WHILE DRIVING, IN ATLANTA GEORGIA

Mileage: 150,000

FRAME AND REAR AXLE HOUSING RUST - CAUSED THE UPPER CONTROL ARMS, WHICH PREVENT ROTATION OF THE REAR AXEL, TO DISCONNECT FROM THE HOUSING/FRAME. ALSO, STEERING HAS BECOME STIFF AND BUMPY AS YOU TURN THE WHEEL. THIS MAY BE DUE TO FRONT CROSSMEMBER RUST OR RUST ON THE STEERING UNIVERSAL JOINT. I LIVE...

Mileage: 101,000

FRAME RECALL NEEDED. I HAVE BAD RUST IN MY FRAME DESPITE REGULAR WASHINGS AND CARE TAKEN. IS IT A WIDESPREAD PROBLEM AND IT IS UNSAFE TO DRIVE. PLEASE HELP!

Mileage: 82,500

EXCESSIVE RUSTING OF THE FRAME. HOLES DEVELOPING IN MAIN FRAME MEMBERS.

Mileage: 91,000

THE U-JOINT IN MY YEAR, AND MANY OTHER YEARS CLOSE TO THE SAME PERIOD, RUSTS OUT IN THE BEARINGS AND REQUIRES REPLACEMENT. THIS MAKES THE STEERING SIGNIFICANTLY DIFFICULT. HERE IS JUST ONE, OF MANY, WEBSITES DEDICATED TO THIS PROBLEM. I AM HAVING MINE FIXED NEXT WEEK BUT THE GENERAL CONSENSUS IS ...

Mileage: 175,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE VIEWING THE UNDERCARRIAGE OF THE VEHICLE, THE CONTACT OBSERVED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE CONTACT WAS INFORMED THAT THE VEHICLE'S WARRANTY HAD EXPIRED. THE F...

Mileage: 202,000

EXTENSIVE RUST ALL OVER THE UNDER-BODY AND FRAME OF THE VEHICLE, DESPITE REGULAR CAR WASHES TO RINSE OFF ANY SALT.

Mileage: 45,000

VEHICLE HAS SEVERE RUST ON FRAME AND PERFORATION OF AT LEAST ONE CROSSMEMBER. OTHER TOYOTA MODELS THAT SHARE THIS FRAME HAVE BEEN RECALLED (TACOMA, SEQUOIA).

Mileage: 103,500

THE ENTIRE FRAME AND UNDERNEATH THE VEHICLE IS RUSTED FROM FRONT TO BACK.

MY 2004 TOYOTA 4RUNNER IS EXPERIENCING MORE-THAN-NORMAL FRAME RUST. IT APPEARS IT SHOULD HAVE BEEN INVOLVED IN THE TACOMA, SEQUOIA, TUNDRA RECALL. PARTS ARE RUSTING THROUGH AND THE ENTIRE FRAME IS COVERED IN RUST.

Mileage: 124,000

TL* TAKATA RECALL. THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHEN THE CONTACT STARTED THE VEHICLE, THE FOUR SIDE CURTAIN AIR BAGS DEPLOYED IN THE VEHICLE. THE CONTACT SUSTAINED NECK INJURIES AND THE PASSENGER SUSTAINED BURNS AND CUTS ON THE LEFT SIDE OF HIS ARM. THE OCCUPANTS DID NOT REQUIRE MEDICAL A...

Mileage: 136,000

UNBELIEVABLE FRAME RUST TO THE POINT IT IS NOT SAFE. SEEMS TO BE A COMMON PROBLEM THAT TOYOTA WILL NOT ADDRESS AND CORRECT..

I TOOK THE VEHICLE IN FOR INSPECTION AND WAS TOLD THE VEHICLE HAS FRAME RUST IN SEVERAL PLACES AND WOULD NOT PASS INSPECTION. I WAS INFORMED OF THE TACOMA, SEQUOIAS AND TUNDRA RECALL AND SINCE THE 4RUNNER IS THE SAME FRAME NOT SURE WHY THE 4RUNNER WAS NOT INCLUDED.

Mileage: 147,000

BRAKES FAILED WHILE DRIVING WITH 3 YEAR OLD IN BACK SEAT. HAD TO HAVE VEHICLE TOWED TO DEALER TO REPLACE FAULTY ABS ACTUATOR PUMP. LUCKILY NOT ON THE HIGHWAY WHEN BRAKES WENT OUT. OVER $2,000 TO REPLACE PART. *TR

Mileage: 82,000

PREMATURE HEAVY RUSTING ON FRAME RAILS AND CROSSMEMBERS

MY 2004 4RUNNER, WITH LESS THAN 80,000 MILES, HAS SIGNIFICANT AND OVERWHELMING UNDER CARRIAGE RUST. THERE IS A FRAME ROT HOLE. ONE OF THE TRAILING ARM BRACKETS ON THE AXLE HAS RUSTED TO THE POINT WHERE THE TRAILING ARM WAS NO LONGER CONNECTED. THIS IS ONE OF THE POINTS WHERE THE AXEL IS CONNECTED...

MY 2004 4RUNNER, WITH LESS THAN 80,000 MILES, HAS SIGNIFICANT AND OVERWHELMING UNDER CARRIAGE RUST. THERE IS A FRAME ROT HOLE. ONE OF THE TRAILING ARM BRACKETS ON THE AXLE HAS RUSTED TO THE POINT WHERE THE TRAILING ARM WAS NO LONGER CONNECTED. THIS IS ONE OF THE POINTS WHERE THE AXEL IS CONNECTED...

HEAVY FRAME RUST AND CORROSION OCCURRING IN A GARAGED 4RUNNER WITH ONLY 65,000 MILES TO DATE. VERY ADVANCED FOR MILEAGE, AND SOON TO BE A STRUCTURAL AND SAFETY CONCERN. CROSSMEMBERS, FRAME, AND SUSPENSION ATTACHMENTS. TWO EXHAUST SHIELDS HAVE HAD TO BE REATTACHED. ALSO, MY DASHBOARD IS CRACKING...

Mileage: 65,000

THE TOYOTA DEALERSHIP DOES NOT WANT TO REPAIR THE SAFETY RECALL THEY DID ON 2004 4RUNNERS TOYOTA. I CALLED OVER A YEAR AGO AND NO ACTION HAS TAKEN PLACE. THE RECALL WAS OVER THE GAS PEDAL AND DASHBOARD, I ALSO HAVE A CASE NUMBER AND HAVE CALLED MANY TIMES AND THEY ONLY TELL ME TO WAIT. THEY DIDN'T E...

THE TOYOTA DEALERSHIP DOES NOT WANT TO REPAIR THE SAFETY RECALL THEY DID ON 2004 4RUNNERS TOYOTA. I CALLED OVER A YEAR AGO AND NO ACTION HAS TAKEN PLACE. THE RECALL WAS OVER THE GAS PEDAL AND DASHBOARD, I ALSO HAVE A CASE NUMBER AND HAVE CALLED MANY TIMES AND THEY ONLY TELL ME TO WAIT. THEY DIDN'T E...

FRAME HAS WAY TOO MUCH RUST FOR A VEHICLE OF THIS AGE. EXHAUST MANIFOLD TICKING NOISE. BOTH ARE WELL DOCUMENTED ISSUES WITH THIS MODEL YEAR....

Mileage: 160,000

FRAME HAS WAY TOO MUCH RUST FOR A VEHICLE OF THIS AGE. EXHAUST MANIFOLD TICKING NOISE. BOTH ARE WELL DOCUMENTED ISSUES WITH THIS MODEL YEAR....

Mileage: 160,000

THE REAR SWAY BAR HAS RUSTED COMPLETELY AWAY FROM THE FRAME. WHILE I WAS DRIVING AND ON THE FREEWAY. RUSTED HEAVY ON FRAME AND UNDERBELLY

Mileage: 150,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT PART OF THE VEHICLE'S FRAME WAS RUSTY. THE FRONT CROSS MEMBER THAT SUPPORTED THE SKID PLATE WAS MISSING AND NEEDED TO BE REPLACED, NOT REPAIRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DETERMINED THAT THE VEHIC...

Mileage: 74,500

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED MULTIPLE FRACTURES ACROSS THE DASHBOARD. IN ADDITION, THE CONTACT STATED THAT THE DASHBOARD APPEARED TO BE MELTING, WHICH CAUSED A GLARE THAT HINDERED THE CONTACT'S VISIBILITY. THE VEHICLE WAS TAKEN TO A D...

Mileage: 50,000

THERE IS LOT OF RUST ON FRAME, UNDER CARRIAGE AND ITS ALSO IN THE SUSPENSION. ITS ALSO CAUSING FLUIDS TO LEAK AND I HAD TO REPLACE THE MUFFLER ASSEMBLY DUE TO RUST. I PURCHASED THIS CAR AS CERTIFIED USED FROM PRESTIGE TOYOTA OF NJ WITH ONLY 5000 MILES IN AUGUST OF 2005, I PURCHASED THIS TOYOTA BECA...

Mileage: 95,000

THERE IS LOT OF RUST ON FRAME, UNDER CARRIAGE AND ITS ALSO IN THE SUSPENSION. ITS ALSO CAUSING FLUIDS TO LEAK AND I HAD TO REPLACE THE MUFFLER ASSEMBLY DUE TO RUST. I PURCHASED THIS CAR AS CERTIFIED USED FROM PRESTIGE TOYOTA OF NJ WITH ONLY 5000 MILES IN AUGUST OF 2005, I PURCHASED THIS TOYOTA BECA...

Mileage: 95,000

THERE IS LOT OF RUST ON FRAME, UNDER CARRIAGE AND ITS ALSO IN THE SUSPENSION. ITS ALSO CAUSING FLUIDS TO LEAK AND I HAD TO REPLACE THE MUFFLER ASSEMBLY DUE TO RUST. I PURCHASED THIS CAR AS CERTIFIED USED FROM PRESTIGE TOYOTA OF NJ WITH ONLY 5000 MILES IN AUGUST OF 2005, I PURCHASED THIS TOYOTA BECA...

Mileage: 95,000

BLOWN HEAD GASKET AT 150K MILES. POTENTIAL TO OVERHEAT TO OVERHEAT WHILE IN OPERATION LEAVING THE PASSENGERS STRANDED OR START AN ENGINE FIRE. EVERY LOCAL MECHANIC SHOP I RECEIVED ESTIMATES FROM IN KNOXVILLE WAS VERY FAMILIAR WITH THIS ISSUE FOR THIS MODEL YEAR AND THE INTERNET FORUM SEARCHES HAVE H...

Mileage: 155,000

THE FRAME OF MY 2004 4RUNNER HAS HOLES PERFORATED THROUGH THE FRAME. I PURCHASED THIS VEHICLE NEW AND HAVE ALWAYS SERVICED IT THROUGH THE TOYOTA DEALER. IT ONLY HAS 86,000 MILES ON IT, HAS BEEN GARAGE KEPT, AND SHOULDN'T BE AT THE END OF IT'S LIFE AS SUGGESTED BY THE TOYOTA SERVICE ADVISOR. I AM ...

Mileage: 85,735

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT TOOK THE VEHICLE TO BE INSPECTED AND WAS ADVISED THAT THE FRAME WAS RUSTED AND NEEDED REPLACEMENT. THERE WERE NO RECALLS FOR THE VEHICLE. THE FAILURE MILEAGE WAS UNKNOWN.

FRAME BADLY RUSTED, DURING TIRE CHANGE LIFTED CAR WITH TOYOTA JACK AND IT WENT INSIDE FRAME, FRONT TOW HOOKS RUSTED OFF AND FELL OFF, HALF OF BAR SUPPORTING OIL HOSES RUSTED OFF.

Mileage: 160,000

I WAS NOTIFIED IN APRIL 2016 THAT MY CURTAIN AIRBAGS MAY NEED A NEW MODULE DUE TO THE UNINTENTIONAL OPERATION OF THESE AIR BAGS. SINCE THEN, I HAVE HEARD NOTHING FROM THE DEALER. I THINK TOYOTA IS DRAGGING THEIR FEET IN SUPPLYING THE DEALERS WITH THE REPLACEMENT MODULE.

Mileage: 40,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V065000 (AIR BAGS); HOWEVER, THE PARTS FOR THE RECALL REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HA...

OIL LEAKING FROM TRANSFER CASE ACTUATOR MOTOR ASSEMBLY POWERTRAIN TRANSFER CASE. VEHICLE IS STATIONARY

Mileage: 170,450

THE ENTIRE FRAME AND UNDERNEATH THE VEHICLE IS RUSTED FROM FRONT TO BACK.

THE ENTIRE FRAME AND UNDERNEATH THE VEHICLE IS RUSTED FROM FRONT TO BACK.

RUST EROSION OF THE FRAME RESULTING IN DANGER IN DRIVING THE VEHICLE. VEHICLE HAS BEEN GARAGED KEPT FOR IT'S ENTIRE LIFE AND MAINTAINED ON A REGULAR BASIS. FRAME IS NOW NEAR DETERIORATION.

Mileage: 209,000

FRAME VERY BADLY RUSTED. SEEMS TO BE A COMMON COMPLAINT. WHY IS NOTHING BEING DONE?

Mileage: 180,000

I TOOK MY VEHICLE TO FREEDOM TOYOTA IN HAMBURG, PA TO GET SERVICED AND THEY TOLD ME MY FRAME WAS RUSTED THAT BAD THAT IT WOULD NOT PASS INSPECTION, AND COULD NOT BE REPAIRED. THIS IS VERY UPSETTING, BECAUSE IT'S ONLY 12 YEARS OLD. I HAVE A 1998 TOYOTA 4RUNNER PREVIOUSLY AND THAT WAS 14 YEARS OLD B...

Mileage: 199,000

I TOOK MY VEHICLE TO FREEDOM TOYOTA IN HAMBURG, PA TO GET SERVICED AND THEY TOLD ME MY FRAME WAS RUSTED THAT BAD THAT IT WOULD NOT PASS INSPECTION, AND COULD NOT BE REPAIRED. THIS IS VERY UPSETTING, BECAUSE IT'S ONLY 12 YEARS OLD. I HAVE A 1998 TOYOTA 4RUNNER PREVIOUSLY AND THAT WAS 14 YEARS OLD B...

Mileage: 199,000

WE HAVE JUST DISCOVERED THE UNDERSIDE AND FRAME OF THE VEHICLE IS COMPLETELY RUSTING OUT, WITH ONLY 80,000 MILES ON IT. WE LIVE YEAR-ROUND IN NC WHERE WE GET VERY FEW SNOWFALLS WITH SUBSEQUENT SALT USED ON THE HIGHWAY. HOWEVER, THE RUST IS PREVALENT AND COMPREHENSIVE. WE ARE TAKING IT TO DETERMIN...

Mileage: 80,000

VA STATE SAFETY INSPECTOR TODAY POINTED OUT EXCESSIVE RUST ON FRAME, PARTICULARLY PASSENGER SIDE RAIL WITH MOST SERIOUS SAFETY CONCERN RIGHT IN FRONT OF REAR PASSENGER SIDE WHEEL. RUST IS FAR BEYOND WHAT SHOULD BE NORMAL GIVEN LIFE OF THE TRUCK AND MILEAGE ONLY AT 117K. RESEARCHING AND THIS APPEAR...

Mileage: 117,000

DRIVING (SLOWLY), EVERY LIGHT ON THE CONSOLE LIT UP DEALING WITH, ABS, TRACTION ETC...ACCOMPANIED WITH A HIGH PITCH WARNING TONE, DEPRESSED ON THE BRAKES TO STOP...ONLY NO BRAKES, USED THE EMERGENCY BRAKE TO SUCCESSFULLY STOP, NO INCIDENT. CALLED A TOW TRUCK TO TAKE TO DEALERSHIP.TOYOTA DEALER SAID ...

Mileage: 146,000

CROSS MEMBER UNDER RADIATOR THAT THE TOW HITCHES CONNECT TO ARE COMPLETELY RUSTING OUT AND FALLING APART AS WELL AS THE SKID PLATE NOTICED THIS HOOKING UP ROPES TO SECURE MY KAYAKS. THE PAINT ON THE TIRE RIMS ARE PEALING AND CORRODING

CROSS MEMBER UNDER RADIATOR THAT THE TOW HITCHES CONNECT TO ARE COMPLETELY RUSTING OUT AND FALLING APART AS WELL AS THE SKID PLATE NOTICED THIS HOOKING UP ROPES TO SECURE MY KAYAKS. THE PAINT ON THE TIRE RIMS ARE PEALING AND CORRODING

RUST ROT ON FRAME OF BODY, WILL PROBABLY NOT PASS NEXT IN INSPECTION NOTED BY THOMPSON DEALERSHIP. TOYOTA FIXED OTHER MODELS, BUT AM IGNORING MY MODEL.

Mileage: 119,000

RUST ROT ON FRAME OF BODY, WILL PROBABLY NOT PASS NEXT IN INSPECTION NOTED BY THOMPSON DEALERSHIP. TOYOTA FIXED OTHER MODELS, BUT AM IGNORING MY MODEL.

Mileage: 119,000

LETTER FROM CONGRESSMAN FITZPATRICK ON BEHALF OF CONSTITUENT RE RUST ON HER 2004 TOYOTA 4-RUNNER. SHE IS LOOKING FOR A SOLUTION TO THIS PREDICAMENT IN ORDER THAT HER CAR MAY PASS INSPECTION. *SMD THE CONSUMER WAS INFORMED BY HER MECHANIC, RUST WAS FOUND ON THE VEHICLE. *JB

WELL MAINTAINED VEHICLE FAILED NH STATE SAFETY INSPECTION BASED ON SIGNIFICANT FRAME RUST. RUST POINTS AROUND RADIATOR SUPPORT MOUNTS, AND PASSENGER SIDE RAIL, NEAR MUFFLER MOUNT, AND REAR SUSPENSION MOUNT POINT. WITH DAMAGE, CAR IS UNSAFE TO DRIVE. TOYOTA STATES NO RESOLUTION OPTION EXISTS. SIMIL...

Mileage: 188,700

FRAME RUST - FRAME REAR UPPER CONTROL ARM HAS FULLY RUSTED THROUGH, CREATING A VERY DANGEROUS CONDITION WHERE VEHICLE CONTROL CAN BE LOST AND CAUSE AN ACCIDENT OR FATALITY. TOYOTA DEALER WOULD NOT REPLACE OR REPAIR FRAME DUE TO VEHICLE OUT OF WARRANTY. FOUND OUT RUST AFTER REPLACING SHOCKS. WELDED ...

Mileage: 120,000

DRIVING DOWN ROAD @40 MPH, ALL OF A SUDDEN FELT LIKE DRIVING ICE. IMMEDIATELY LET OFF GAS PEDAL TO REMAIN IN CONTROL OF VEHICLE. ABOVE 35 MPH, CAN BARELY STAY IN CONTROL. THANKFULLY CLOSE TO HOME, CRAWLED HOME UNDER 25 MPH. THANK GOD I WASN'T DRIVING ON THE HIGHWAY @ 70MPH. AT HIGHWAY SPEEDS I CERTA...

Mileage: 104,000

I RECEIVED A LETTER FROM TOYOTA IN MAY OF 2015 IN REFERENCE OF A WARRANTY ENHANCEMENT NOTIFICATION. WE HAVE GONE TO THE TOYOTA DEALERSHIP MANY TIMES TO ASK WHEN OUR REPAIR WOULD PROCESS THOUGH AND COMMENCE. THEY KEEP ON SAYING THAT WE WERE FOURTH IN LINE. IT HAS BEEN MORA THAT ONE YEAR AND WE STILL...

THE ENTIRE FRONT FRAME ON MY 2004 TOYOTA 4RUNNER ROTTED WITHIN THE LAST YEAR. IT WAS DEEMED UNSAFE TO DRIVE AFTER GOING IN FOR A ROUTINE INSPECTION. SHAMEFUL SINCE THE BODY WAS IN GOOD CONDITION AND THE CAR RAN GREAT. TOYOTA SHOULD BE HELD RESPONSIBLE FOR FIXING THESE FRAMES. I HAD NO CHOICE BUT...

Mileage: 118,500

I HAVE ALREADY RECEIVED INFORMATION ON THE INTERIM G1C. THIS IS ALSO ABOUT THE FRAME ON MY VEHICLE WHICH IS RUSTED VERY BAD. THE REAR PASSENGER ARM MOUNT HAS ALREADY BROKEN. THERE ARE ALSO HOLES IN THE TRAVE AND THE LONG PIECES OF METAL ON THE FRAME. THE SKID PLATES ARE ALSO RUSTED. ALSO THE TOW...

Mileage: 149,000

I HAVE ALREADY RECEIVED INFORMATION ON THE INTERIM G1C. THIS IS ALSO ABOUT THE FRAME ON MY VEHICLE WHICH IS RUSTED VERY BAD. THE REAR PASSENGER ARM MOUNT HAS ALREADY BROKEN. THERE ARE ALSO HOLES IN THE TRAVE AND THE LONG PIECES OF METAL ON THE FRAME. THE SKID PLATES ARE ALSO RUSTED. ALSO THE TOW...

Mileage: 149,000

2004 4 RUNNER SPORT, FRAME RUSTING OUT EVERYWHERE, N OW FRONT CROSS MEMBER UNDER THE RADIATOR IS COMPLETLY RUSTED THRU. THIS CAR HAS BEEN WELL MAINTAINED, TOYOTA SHOULD BE STANDING BEHIND THIS PROBLEM. I HAD HOPED THIS WOULD BE MY LAST CAR TO BUY, NOW AT 75 I MUST LOOK FOR ANOTHER VEHICLE. THIS CA...

Mileage: 124,600

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER TO GET AN INSPECTION STICKER. THE MECHANIC OBSERVED RUST AND HOLES ON THE FRAME OF THE VEHICLE. THE VEHICLE FAILED INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FA...

Mileage: 98,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE DASHBOARD WAS FRACTURED NEAR THE PASSENGER SIDE AIR BAG. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIR...

Mileage: 75,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT RECEIVED A RECALL NOTIFICATION FOR NHTSA CAMPAIGN NUMBER: 16V065000 (AIR BAGS) AND STATED THAT THE PART NEEDED WAS UNAVAILABLE TO PERFORM THE RECALL REPAIR. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. ...

HAVE SEEN EXTREME RUST ON MY FRAME, SO BAD I CAN PICK OFF CHUNKS WITH MY HAND. I KNOW TOYOTA IS IN DENIAL BUT WHAT IS REALLY BEING DONE OVER THIS ISSUE.

Mileage: 140,000

THE FRAME OF THE VEHICLE IS COMPLETELY RUSTED TO THE POINT WHERE IT WILL NOT PASS INSPECTION.

Mileage: 125,000

RUST EAT MY FRAME INTO

Mileage: 220,000

RUST EAT MY FRAME INTO

Mileage: 220,000

RUST EAT MY FRAME INTO

Mileage: 220,000

LOOKS LIKE THE FRAN AROUND AND IN FRONT OF THE FRONT SUSPENSION IS RUSTING IN TWO

DASH BOARD CRACK RECALL 2 YEARS ALL DEALER SAYS IS THEY DON'T HAVE THE PARTS

Mileage: 12,000

BLOWN HEAD GASKET WITH 130,000 MILES. BLOWN NEAR THE NUMBER 6 CYLINDER (LIKE EVERYONE ELSE). COST $3700 FOR REPAIRS.

Mileage: 130,000

REAR BREAKS - LEFT AND RIGHT (BOTH) SIDES CEASED UP.

LOSS OF COOLANT WITH NO VISIBLE SIGNS OF LEAKING. REPLACED SO MANY THINGS AND KEEP GETTING MISFIRES AND VSC LIGHTS ON CONSTANTLY. ROUGH START UP FOR ABOUT 30 SECONDS EVERY TIME STARTED. SLIGHT OVER HEATING IF IDLING ... ALL POINTS NOW LEAD TO BLOWN HEAD GASKET IN WHICH I READ MORE AND MORE AND COMMO...

LOSS OF COOLANT WITH NO VISIBLE SIGNS OF LEAKING. REPLACED SO MANY THINGS AND KEEP GETTING MISFIRES AND VSC LIGHTS ON CONSTANTLY. ROUGH START UP FOR ABOUT 30 SECONDS EVERY TIME STARTED. SLIGHT OVER HEATING IF IDLING ... ALL POINTS NOW LEAD TO BLOWN HEAD GASKET IN WHICH I READ MORE AND MORE AND COMMO...

LOSS OF COOLANT WITH NO VISIBLE SIGNS OF LEAKING. REPLACED SO MANY THINGS AND KEEP GETTING MISFIRES AND VSC LIGHTS ON CONSTANTLY. ROUGH START UP FOR ABOUT 30 SECONDS EVERY TIME STARTED. SLIGHT OVER HEATING IF IDLING ... ALL POINTS NOW LEAD TO BLOWN HEAD GASKET IN WHICH I READ MORE AND MORE AND COMMO...

I HAVE AN ONGOING PROBLEM WITH OUR 2004 TOYOTA 4RUNNER. IT STARTED ABOUT 4 YEARS AGO WHEN THE MARYLAND STATE EMMISSION TEST FACILITY PLUGGED INTO MY ODBI2 PORT. ALL THE DASH LIGHTS WERE ON AND I WENT IN TO THE OFFICE AND COMPLAINED. I FILED A FORM WITH EMISSIONS. I WORK OUT OF TOWN, MY WIFE IS A...

Mileage: 79,000

I HAVE AN ONGOING PROBLEM WITH OUR 2004 TOYOTA 4RUNNER. IT STARTED ABOUT 4 YEARS AGO WHEN THE MARYLAND STATE EMMISSION TEST FACILITY PLUGGED INTO MY ODBI2 PORT. ALL THE DASH LIGHTS WERE ON AND I WENT IN TO THE OFFICE AND COMPLAINED. I FILED A FORM WITH EMISSIONS. I WORK OUT OF TOWN, MY WIFE IS A...

Mileage: 79,000

I HAVE AN ONGOING PROBLEM WITH OUR 2004 TOYOTA 4RUNNER. IT STARTED ABOUT 4 YEARS AGO WHEN THE MARYLAND STATE EMMISSION TEST FACILITY PLUGGED INTO MY ODBI2 PORT. ALL THE DASH LIGHTS WERE ON AND I WENT IN TO THE OFFICE AND COMPLAINED. I FILED A FORM WITH EMISSIONS. I WORK OUT OF TOWN, MY WIFE IS A...

Mileage: 79,000

WHEN VEHICLE IS DRIVEN OVER A ROUGH ROAD THERE IS A RATTLE SOUND COMING FROM STEERING COLUMN..NO RATTLE ON SMOOTH ROADS LIKE HIGHWAYS.......ITS BEEN DOING THIS FOR A LONG TIME,YRS....SEEMS LIKE SOMETHING IS LOOSE IN STEERING COLUMN

Mileage: 195,435

BOUGHT 4TH GENERATION 4RUNNER IN 1-15 FROM DEALER AFTER OWNING 4 PRIOR 3RD GENERATION ONES AND THIS ONE IS PLAGUED WITH EXCESSIVE RUST BEYOND NORMAL WEAR IN FRAME (SOME HOLES), SUSPENSION, STEERING RACK AND SHAFT, BRAKE COMPONENTS, VIRTUALLY EVERYTHING STEEL UNDER THE BODY HAS RUSTED EXCESSIVELY WHI...

Mileage: 152,000

BOUGHT 4TH GENERATION 4RUNNER IN 1-15 FROM DEALER AFTER OWNING 4 PRIOR 3RD GENERATION ONES AND THIS ONE IS PLAGUED WITH EXCESSIVE RUST BEYOND NORMAL WEAR IN FRAME (SOME HOLES), SUSPENSION, STEERING RACK AND SHAFT, BRAKE COMPONENTS, VIRTUALLY EVERYTHING STEEL UNDER THE BODY HAS RUSTED EXCESSIVELY WHI...

Mileage: 152,000

BOUGHT 4TH GENERATION 4RUNNER IN 1-15 FROM DEALER AFTER OWNING 4 PRIOR 3RD GENERATION ONES AND THIS ONE IS PLAGUED WITH EXCESSIVE RUST BEYOND NORMAL WEAR IN FRAME (SOME HOLES), SUSPENSION, STEERING RACK AND SHAFT, BRAKE COMPONENTS, VIRTUALLY EVERYTHING STEEL UNDER THE BODY HAS RUSTED EXCESSIVELY WHI...

Mileage: 152,000

THESE VEHICLES ARE PLAGUED BY RUST ON THE FRAME AND COMPONENTS ATTACHED TO THE FRAMES. THERE IS THE POTENTIAL THAT THIS CAN CAUSE A HAZARD DUE TO FAILURE OF CRITICAL COMPONENTS OF THE VEHICLE. THIS ISSUE EFFECTS MULTIPLE VEHICLES AND IS NOT AN ISOLATED INCIDENT. FRAMES DEGRADE JUST LIKE THE ONES ON ...

Mileage: 173,000

THESE VEHICLES ARE PLAGUED BY RUST ON THE FRAME AND COMPONENTS ATTACHED TO THE FRAMES. THERE IS THE POTENTIAL THAT THIS CAN CAUSE A HAZARD DUE TO FAILURE OF CRITICAL COMPONENTS OF THE VEHICLE. THIS ISSUE EFFECTS MULTIPLE VEHICLES AND IS NOT AN ISOLATED INCIDENT. FRAMES DEGRADE JUST LIKE THE ONES ON ...

Mileage: 173,000

THE BRAKE GET HARD AND ABS, BRAKE VSC AND TRAC SIGN CAME ON WITH ALERT WHISTLE WHILE I WAS DRIVING IN THE NEIGHBOTHOOD LUCKILY.. MECHANIC SAID IT IS RARE TO GO BAD BUT IT IS BRAKE BOOSTER ASSEMBLY GOES BAD. IS THIS THE SAME ISSUE AS PRIUS?

Mileage: 160,000

THERE IS EXCESSIVE RUST/CORROSION ON THE FRAME OF THE TRUCK. THE SKID PLATES COMPLETELY RUSTED OFF THE TRUCK IN 2010. THE TRANSMISSION LINES HAVE CORRODED TO THE POINT THEY HAVE TO BE REPLACED. THE ENGINE OIL COOLER AND RADIATOR SUPPORTS HAVE RUSTED THROUGH. THE EXHAUST RUSTED OFF THE TRUCK IN 2...

Mileage: 70,000

THERE IS EXCESSIVE RUST/CORROSION ON THE FRAME OF THE TRUCK. THE SKID PLATES COMPLETELY RUSTED OFF THE TRUCK IN 2010. THE TRANSMISSION LINES HAVE CORRODED TO THE POINT THEY HAVE TO BE REPLACED. THE ENGINE OIL COOLER AND RADIATOR SUPPORTS HAVE RUSTED THROUGH. THE EXHAUST RUSTED OFF THE TRUCK IN 2...

Mileage: 70,000

THERE IS EXCESSIVE RUST/CORROSION ON THE FRAME OF THE TRUCK. THE SKID PLATES COMPLETELY RUSTED OFF THE TRUCK IN 2010. THE TRANSMISSION LINES HAVE CORRODED TO THE POINT THEY HAVE TO BE REPLACED. THE ENGINE OIL COOLER AND RADIATOR SUPPORTS HAVE RUSTED THROUGH. THE EXHAUST RUSTED OFF THE TRUCK IN 2...

Mileage: 70,000

THIS 2004 TOYOTA 4RUNNER HAD 145000 MILES ON IT WHEN THE CHECK ENGINE LIGHT CAME ON, ALONG WITH VSC AND VSC TRAC LIGHTS. ENGINE RAN ROUGH/RUMBLED FOR FEW SECONDS AFTER EACH START, THEN THE RUMBLING WOULD STOP. AT AUTOZONE THEY DIAGNOSED A P0306 ERROR CODE. TOOK IT TO THE DEALER WHO SCANNED CODE # 03...

Mileage: 145,000

CALIPER.

VEHICLE HAS 129,881 MILES. SEVERE RUST THROUGH OF FRAME UNDERSIDE. HAD PLATED & WELDED. NEW RUST THROUGH HOLES APPEARED WITHIN 6 MONTHS OF PREVIOUS WELD ON SAME FRAME STRUCTURE BUT IN DIFFERENT LOCATIONS POSING IMMINENT RUST THROUGH FAILURE IN CENTER OF VEHICLE. CANNOT PASS SAFETY INSPECTION.

Mileage: 129,881

WHILE DRIVING AT APPROXIMATELY 30 MPH ON A CITY STREET, WITH CHILDREN IN VEHICLE, BREAKS FAILED AND LOUD CABIN ALARM SOUND AND ABS, VSC AND TRAC DASH LIGHTS CAME ON. I HAD TO PULL INTO A GRASSY SWALE, APPLY EMERGENCY BREAK AND DOWN SHIFT IN ORDER TO STOP AND AVOID CRASHING INTO TRAFFIC. HAD VEHICL...

Mileage: 194,000

FRAME HAS RUST HOLES IN FRONT CROSS MEMBER THAT RUNS UNDER RADIATOR. TOW HOOK IS UNUSABLE. PROFESSIONAL INSPECTION OF ENTIRE FRAME INDICATED THAT FRAME HAS NUMEROUS RUST SPOTS THAT ARE UNSAFE. ALL FRAME ATTACHED UNDERCARRIAGE COMPONENTS ARE SO RUSTED THAT REMOVAL OF PARTS IS IS IMPOSSIBLE. CANNOT F...

Mileage: 197,000

EVENT OCCURRED AT START UP. WARNING LIGHTS >>> CHECK ENGINE, VSC TRAC, AND TRAC OFF. PER TOYOTA DEALERSHIP >>> FOUND HEAD GASKET ALLOWING ANTIFREEZE TO LEAK INTO CYLINDER 6 CAUSING P0306 REPLACED BOTH HEAD GASKETS COST $2644.91

Mileage: 210,350

VEHICLE ENGINE LIGHT AND OTHER LIGHTS CAME ON, TOOK TO DEALER AND TOLD ME CODE WAS PO306 CODE WAS DIAGNOSED STATING THERE IS A MISFIRE IN CYLINDER #6 RESULTING IN A HEAD GASKET PROBLEM OF COOLANT ENTERING THE CYLINDER & IT WOULD COST ME 3000 TO 5000 DOLLARS TO FIX. EVERY TIME I START CAR IN MORNING ...

Mileage: 135,000

EXCESSIVE RUST AND CORROSION TO THE POINT WHERE MY SKID PLATE CAME OFF AND TRANSMISSION FLUID LINES BROKE APART, LEADING TO MAJOR LEAK AND FIX - LUCKILY IT CAME OFF IN DRIVEWAY AND NOT ON HIGHWAY WHERE SOMEONE COULD HAVE BEEN SIGNIFICANTLY INJURED. SHOCKS HAVE HOLES IN THEM FROM RUST AND CORROSION, ...

EXCESSIVE RUST AND CORROSION TO THE POINT WHERE MY SKID PLATE CAME OFF AND TRANSMISSION FLUID LINES BROKE APART, LEADING TO MAJOR LEAK AND FIX - LUCKILY IT CAME OFF IN DRIVEWAY AND NOT ON HIGHWAY WHERE SOMEONE COULD HAVE BEEN SIGNIFICANTLY INJURED. SHOCKS HAVE HOLES IN THEM FROM RUST AND CORROSION, ...

EXCESSIVE RUST AND CORROSION TO THE POINT WHERE MY SKID PLATE CAME OFF AND TRANSMISSION FLUID LINES BROKE APART, LEADING TO MAJOR LEAK AND FIX - LUCKILY IT CAME OFF IN DRIVEWAY AND NOT ON HIGHWAY WHERE SOMEONE COULD HAVE BEEN SIGNIFICANTLY INJURED. SHOCKS HAVE HOLES IN THEM FROM RUST AND CORROSION, ...

ROTTEN EGG SMELL FROM REAR OF TRUCK. WORSE WITH REAR WINDOW OPEN.

Mileage: 98,007

SUV IS UNSAFE TO DRIVE DUE TO EXCESSIVE RUSTING OF FRAME AND ALL OTHER UNDERCARRIAGE METAL PARTS. FRAME INTEGRITY IS SERIOUSLY COMPROMISED. RUST IS EXPONENTIATING OVER TIME. RUST LEACHING TO OTHER MAJORS PARTS LIKE THE EXHAUST. TRANSMISSION, RADIATOR, AC, WHEELS, BRAKES, EXHAUST, STEERING, ETC AL...

Mileage: 98,007

SUV IS UNSAFE TO DRIVE DUE TO EXCESSIVE RUSTING OF FRAME AND ALL OTHER UNDERCARRIAGE METAL PARTS. FRAME INTEGRITY IS SERIOUSLY COMPROMISED. RUST IS EXPONENTIATING OVER TIME. RUST LEACHING TO OTHER MAJORS PARTS LIKE THE EXHAUST. TRANSMISSION, RADIATOR, AC, WHEELS, BRAKES, EXHAUST, STEERING, ETC AL...

Mileage: 98,007

SUV IS UNSAFE TO DRIVE DUE TO EXCESSIVE RUSTING OF FRAME AND ALL OTHER UNDERCARRIAGE METAL PARTS. FRAME INTEGRITY IS SERIOUSLY COMPROMISED. RUST IS EXPONENTIATING OVER TIME. RUST LEACHING TO OTHER MAJORS PARTS LIKE THE EXHAUST. TRANSMISSION, RADIATOR, AC, WHEELS, BRAKES, EXHAUST, STEERING, ETC AL...

Mileage: 98,007

MY 2004 4RUNNER WITH $144K MILES WAS RECENTLY DISCOVERED TO HAVE A SIX INCH HOLE IN THE FRAME DUE TO RUST, AND BASED ON MD SAFETY INSPECTION REQUIREMENTS, THIS VEHICLE PRESENTS A SIGNIFICANT SAFETY HAZARD AND CAN NOT BE REGISTERED. THE DEALERSHIP INFORMED ME THE REPAIR WOULD BE A COMPLETE FRAME REP...

Mileage: 144,000

MY 2004 4RUNNER WITH $144K MILES WAS RECENTLY DISCOVERED TO HAVE A SIX INCH HOLE IN THE FRAME DUE TO RUST, AND BASED ON MD SAFETY INSPECTION REQUIREMENTS, THIS VEHICLE PRESENTS A SIGNIFICANT SAFETY HAZARD AND CAN NOT BE REGISTERED. THE DEALERSHIP INFORMED ME THE REPAIR WOULD BE A COMPLETE FRAME REP...

Mileage: 144,000

THE FRAME OF MY 2004 TOYOTA 4RUNNER HAS CONSIDERABLE RUST THAT EXCEEDS NORMAL WEAR AND AGE. CONSIDERING THE RECALL ASSOCIATED WITH THE TACOMA OF THE SAME YEAR IT SEEMS PRUDENT AND RESPONSIBLE FOR TOYOTA TO STAND BY THEIR RELIABILITY SLOGAN AND REMEDY THIS SITUATION, AS THERE ARE MANY OTHERS IN THE ...

Mileage: 127,640

WHEN I RETURNED TO MY HOME AND PULLED INTO MY GARAGE, AN ALARM SOUND WENT OFF IN THE DASHBOARD AND ALL OF THE DASHBOARD WARNING LIGHTS CAME ON. THE CAR WAS DRIVING FINE JUST PRIOR. THE NEXT MORNING I WENT TO TRY TO DRIVE IT TO DRIVE IT TO THE DEALER AND NOTICED THAT MY BRAKE PEDAL WAS VERY HARD TO...

Mileage: 174,000

2004 TOYOTA 4RUNNER LIMITED, HAS EXCESSIVE CHASSIS RUST AND ROTTED OUT AT SOME POINT ON THE SUB FRAME, CONTACTED THE DEALER AND THERE IS NO RECALL AVAILABLE ALSO CALLED TOYOTA AND RECALL IS NOT AVAILABLE.I AM AFRAID THAT THE CHASSIS WILL BREAK AND CAUSE AN ACCIDENT.

Mileage: 86,000

2004 TOYOTA 4RUNNER LIMITED, HAS EXCESSIVE CHASSIS RUST AND ROTTED OUT AT SOME POINT ON THE SUB FRAME, CONTACTED THE DEALER AND THERE IS NO RECALL AVAILABLE ALSO CALLED TOYOTA AND RECALL IS NOT AVAILABLE.I AM AFRAID THAT THE CHASSIS WILL BREAK AND CAUSE AN ACCIDENT.

Mileage: 86,000

2004 TOYOTA 4RUNNER LIMITED, HAS EXCESSIVE CHASSIS RUST AND ROTTED OUT AT SOME POINT ON THE SUB FRAME, CONTACTED THE DEALER AND THERE IS NO RECALL AVAILABLE ALSO CALLED TOYOTA AND RECALL IS NOT AVAILABLE.I AM AFRAID THAT THE CHASSIS WILL BREAK AND CAUSE AN ACCIDENT.

Mileage: 86,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER EQUIPPED WITH BF GOODRICH TIRES, TIRE LINE: 105S RUGGED TRAIL, AND TIRE SIZE: P265/65R/17 (NA). THE CONTACT NOTICED EXCESSIVE CRACKING AROUND THE TREAD AND SIDEWALL OF ALL FOUR TIRES. THE TIRES WERE NOT INSPECTED OR REPLACED. THE TIRES WERE NOT ORIGINAL EQU...

I WAS DRIVING HOME AT AROUND 50 MPH AND HAD TO BRAKE AND SUDDENLY THE VSC/ABS BRAKE DASH INDICATOR LIGHTS CAME ON AND A LOUD ALARM STARTED TO SOUND. I DID NOT HIT ANYTHING, I JUST PRESSED THE BRAKE PEDAL AND WHOLE SYSTEM WENT OFF. I WAS VERY CLOSE TO THE EXIT TO A TOYOTA SERVICE CENTER, A COUPLE B...

Mileage: 60,285

I WAS DRIVING HOME AT AROUND 50 MPH AND HAD TO BRAKE AND SUDDENLY THE VSC/ABS BRAKE DASH INDICATOR LIGHTS CAME ON AND A LOUD ALARM STARTED TO SOUND. I DID NOT HIT ANYTHING, I JUST PRESSED THE BRAKE PEDAL AND WHOLE SYSTEM WENT OFF. I WAS VERY CLOSE TO THE EXIT TO A TOYOTA SERVICE CENTER, A COUPLE B...

Mileage: 60,285

FRAME HAS STARTED RUSTING NEAR WELDS AND HOLES. VERY POOR PREVENTION OF RUST BY TOYOTA. SKID PLATES TOTALLY RUSTED OUT AND FUZED BOLTS. REAR DIFF HOUSING IS ALSO RUSTY. CAR WILL PROBABLY FALL APART IN A YEAR OR TWO.

Mileage: 140,000

FRAME HAS STARTED RUSTING NEAR WELDS AND HOLES. VERY POOR PREVENTION OF RUST BY TOYOTA. SKID PLATES TOTALLY RUSTED OUT AND FUZED BOLTS. REAR DIFF HOUSING IS ALSO RUSTY. CAR WILL PROBABLY FALL APART IN A YEAR OR TWO.

Mileage: 140,000

TOOK MY 2004 TOYOTA 4RUNNER SR5 TO LOCAL TOYOTA DEALER FOR INPSECTION AND MAINTENANCE. LEFT DEALER THINKING TRUCK WAS IN GREAT SHAPE. WHEN CHANGING BRAKES, NOTICED AN CV JOINT BOOT WAS TORN SO TOOK THE TRUCK TO A MECHANIC TO HAVE THE AXLE REPLACED (SINCE THEY DON'T JUST REPLACE THE BOOT ANYMORE). ...

Mileage: 148,000

TOOK MY 2004 TOYOTA 4RUNNER SR5 TO LOCAL TOYOTA DEALER FOR INPSECTION AND MAINTENANCE. LEFT DEALER THINKING TRUCK WAS IN GREAT SHAPE. WHEN CHANGING BRAKES, NOTICED AN CV JOINT BOOT WAS TORN SO TOOK THE TRUCK TO A MECHANIC TO HAVE THE AXLE REPLACED (SINCE THEY DON'T JUST REPLACE THE BOOT ANYMORE). ...

Mileage: 148,000

I WAS GOING 5 MPH AND HIT MY BRAKES. THE CONTROL ARM WAS RIPPED FROM THE FRAME DUE TO ROT/RUST. TOYOTA IS AWARE OF THIS PROBLEM FOR 4RUNNERS, BUT HAS ONLY OFFERED ASSISTANCE ON THE TACOMA AND TUNDRAS. THE BODY OF MY VEHICLE HAS NO RUST ANYWHERE, AND THE MILEAGE IS EXTREMELY LOW. I CANNOT EVEN FIND A...

Mileage: 72,000

I WAS GOING 5 MPH AND HIT MY BRAKES. THE CONTROL ARM WAS RIPPED FROM THE FRAME DUE TO ROT/RUST. TOYOTA IS AWARE OF THIS PROBLEM FOR 4RUNNERS, BUT HAS ONLY OFFERED ASSISTANCE ON THE TACOMA AND TUNDRAS. THE BODY OF MY VEHICLE HAS NO RUST ANYWHERE, AND THE MILEAGE IS EXTREMELY LOW. I CANNOT EVEN FIND A...

Mileage: 72,000

I WAS GOING 5 MPH AND HIT MY BRAKES. THE CONTROL ARM WAS RIPPED FROM THE FRAME DUE TO ROT/RUST. TOYOTA IS AWARE OF THIS PROBLEM FOR 4RUNNERS, BUT HAS ONLY OFFERED ASSISTANCE ON THE TACOMA AND TUNDRAS. THE BODY OF MY VEHICLE HAS NO RUST ANYWHERE, AND THE MILEAGE IS EXTREMELY LOW. I CANNOT EVEN FIND A...

Mileage: 72,000

MY 4RUNNER CHECK ENGINE LIGHT CAME ON AND THE VSC TRAK OFF LIGHTS CAME ON WITH IT. THE TROUBLE CODE INDICATED #6 CYLINDER MISFIRE. AFTER CHECKING ALL THE SENSORS IT BECAME OBVIOUS THAT THERE WAS A SLIGHT LOSS OF COOLANT. CHECKED THE ENGINE AND FOUND THAT THE HEAD GASKET FOR #6 HAD FAILED. LOOKING...

Mileage: 125,000

FRONT CALIPER SEIZE UP L/F AND R/F 3 INCIDENTS 11/2012 02/2015 06/2015

Mileage: 84,000

FRONT CALIPER SEIZE UP L/F AND R/F 3 INCIDENTS 11/2012 02/2015 06/2015

Mileage: 84,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRAME SUPPORT MEMBER WAS CORRODED. THE VEHICLE WAS TAKEN TO A DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 88,540. MA 10/2 UPDATED 10/18/2017*CN

Mileage: 88,540

EXTENSIVE FRAME RUST. UNSAFE BODY STRUCTURE. MULTIPLE HOLES IN THE FRAME DUE TO RUST ISSUE.

WE HAVE A MELTING DASH IN OUR 4 RUNNER. IT CAN BURN TO THE TOUCH AND HAS PROGRESSIVELY GOTTEN WORSE OVER PAST YEAR. IT IS STICKY TO TOUCH ALSO AND HAS A BAD ODOR ALSO. WE MADE COMPLAINT TO TOYOTA BUT NO OFFER TO REPAIR. I CALLED DEALERSHIPS AND THEY SAID THEY HAVE BEEN NOTIFIED OF THE PROBLEM BUT TO...

Mileage: 80,000

WE HAVE A MELTING DASH IN OUR 4 RUNNER. IT CAN BURN TO THE TOUCH AND HAS PROGRESSIVELY GOTTEN WORSE OVER PAST YEAR. IT IS STICKY TO TOUCH ALSO AND HAS A BAD ODOR ALSO. WE MADE COMPLAINT TO TOYOTA BUT NO OFFER TO REPAIR. I CALLED DEALERSHIPS AND THEY SAID THEY HAVE BEEN NOTIFIED OF THE PROBLEM BUT TO...

Mileage: 80,000

2004 TOYOTA 4-RUNNER. CONSUMER WRITES IN REGARDS TO ACCELERATOR PEDAL RECALL. *SMD THE DEALER INFORMED THE CONSUMER THAT SINCE HE HAD INTERIOR PACKAGE, INCLUDING A SPORT ACCELERATOR PEDAL, THE PEDAL COULD NOT BE MODIFIED. THE CONSUMER WAS INFORMED THE SILVER WOULD HAVE TO BE STRIPPED OFF THE PEDA...

TOOK MY 2004 TOYOTA 4RUNNER FOR A OIL CHANGE AND FREE 28 POINT VEHICLE INSPECTION. WAS TOLD BY THE AUTHORIZED TOYOTA DEALER THAT THE FRAME WAS RUSTED BROKEN AND HAD HOLES SIMILAR TO THE TACOMA RECALL. CALLED TOYOTA CALIFORNIA AND ALL THE WOULD DO IS OFFER A $500 SERVICE ALLOWANCE TO ONE OF MY OTHER ...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 10 MPH, THE DRIVER AND PASSENGER SIDE CURTAIN AIR BAGS DEPLOYED INDEPENDENTLY. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

Mileage: 200,000

DASHBOARD COVER DEVELOPED HAIRLINE SURFACE CRACKS. DASHBOARD COVER WAS STILL SOFT TO TOUCH AND RETAINED A SPONGE TYPE FEEL. THE THIN SKIN OF OVER THE SPONGE-LIKE CORE IS WHAT CRACKED. OTHER COMPLAINTS FOR THIS SAME ISSUE ARE REPORTED ON TOYOTA OWNERS FORUM WEB PAGES. THE DASHBOARD COVER IS DEFEC...

Mileage: 125,000

THE DASH BOARD OF THE VEHICLE HAS CRACKED FROM ONE SIDE TO THE OTHER WITH MULTIPLE CRACKS IN THE COVER OVER THE PASSENGER AIR BAG. I AM CONCERNED WHETHER THIS WILL AFFECT THE PERFORMANCE OF THE PASSENGER AIR BAG IF IT SHOULD NEED TO DEPLOY. *TR

Mileage: 140,000

WENT IN FOR A OIL CHANGE AND WAS OFFERED A 28 POINT INSPECTION. AT DEALERSHIP, IRA TOYOTA, MILFORD, MA 28 POINT INSPECTION TELLS US THERE IS HOLES AND RUST IN THE FRAME AND THE VEHICLE WOULD NOT PASS INSPECTION. THIS 4RUNNER HAS BEEN KEPT IN MINT CONDITION WITH RECEIPTS TO PROVE. DID SOME RESEARCH...

Mileage: 213,109

WENT IN FOR A OIL CHANGE AND WAS OFFERED A 28 POINT INSPECTION. AT DEALERSHIP, IRA TOYOTA, MILFORD, MA 28 POINT INSPECTION TELLS US THERE IS HOLES AND RUST IN THE FRAME AND THE VEHICLE WOULD NOT PASS INSPECTION. THIS 4RUNNER HAS BEEN KEPT IN MINT CONDITION WITH RECEIPTS TO PROVE. DID SOME RESEARCH...

Mileage: 213,109

CYLINDER 6 MISFIRES CAUSED BY OIL LEAKING INTO CYLINDER 6 COMBUSTION CHAMBER AROUND SPARK PLUG. THE ISSUE IS TRACED BACK TO A HEAD GASKET FAILURE ON THE 2004 4RUNNER V6 ENGINE. CYLINDER 6 IS THE WEAK POINT WHERE SUCH FAILURES OCCUR ESPECIALLY AT START UP AND WHEN THE ENGINE IS COLD. THERE IS...

DRIVING HOME AND MY BRAKES STOPPED WORKING. I HAD MY MECHANIC LOOK AT IT AND HE SAID THE ABS MODULE HAD FAILED. HE SAID THAT ONLY MY FRONT BRAKES ARE WORKING. I FEEL VERY UNSAFE DRIVING MY CAR. *TR

Mileage: 198,000

SEVERE CRACKS ON DASH PANEL ON PASSENGER AIRBAG AND WHOLE DASH. *TR

SEVERE CRACKS ON DASH PANEL ON PASSENGER AIRBAG AND WHOLE DASH. *TR

DRIVING DOWN THE LOCAL HIGHWAY, SMELLED TRANSMISSION FLUID BURNING. PULLED OVER TO FIND TRANSMISSION FLUID LEAKING FROM UNDER THE RADIATOR AREA. I WAS NEAR THE GARAGE THAT WORKS ON THE VEHICLE AND WAS ABLE TO DRIVE THERE. SKID PLATE WAS REMOVED AND THE TRANSMISSION LINES THAT RUN ALONG THE RADIATOR ...

Mileage: 85,400

FRONT SUPPORT FRAME UNDER RADIATOR RUSTED THROUGH. THE LOCAL TOYOTA DEALER TOLD ME THIS IS A COMMON PROBLEM AND THERE IS NO FIX. THE VEHICLE IS UNSAFE TO DRIVE AND THE QUESTION IS HOW WOULD THIS HOLD UP IN A FRONTAL CRASH. THE VEHICLE HAS A LITTLE OVER 85,000 MILES AND THIS HAPPENS. IT IS IN A AREA ...

Mileage: 85,400

FRONT SUPPORT FRAME UNDER RADIATOR RUSTED THROUGH. THE LOCAL TOYOTA DEALER TOLD ME THIS IS A COMMON PROBLEM AND THERE IS NO FIX. THE VEHICLE IS UNSAFE TO DRIVE AND THE QUESTION IS HOW WOULD THIS HOLD UP IN A FRONTAL CRASH. THE VEHICLE HAS A LITTLE OVER 85,000 MILES AND THIS HAPPENS. IT IS IN A AREA ...

Mileage: 85,400

THE DASHBOARD ON MY TOYOTA IS CRACKING REAL BAD. IT GETS WORSE EACH YEAR. I HAVE TALKED TO SEVERAL PEOPLE WITH 4 RUNNERS AND THEY ARE HAVING THE SAME PROBLEM AS WELL. I AM VERY CONCERNED ABOUT THE SAFETY OF MY AIRBAGS. *TR

VEHICLE HAS ABNORMAL AMOUNT OF RUST ON FRAME METAL PARTS WITH EXCESSIVE CHIPPING AN CORROSION. ALSO, OF ALMOST MORE CONCERN IS THAT THE AIRBAG SENSORS ARE COMPLETELY ROTTED THROUGH, AS IF THEY WERE SACRIFICIAL ANODES. FRAME FAILURE DUE TO ABNORMAL RUST COULD CAUSE A CATASTROPHIC ACCIDENT. SENSOR ...

Mileage: 146,000

VEHICLE HAS ABNORMAL AMOUNT OF RUST ON FRAME METAL PARTS WITH EXCESSIVE CHIPPING AN CORROSION. ALSO, OF ALMOST MORE CONCERN IS THAT THE AIRBAG SENSORS ARE COMPLETELY ROTTED THROUGH, AS IF THEY WERE SACRIFICIAL ANODES. FRAME FAILURE DUE TO ABNORMAL RUST COULD CAUSE A CATASTROPHIC ACCIDENT. SENSOR ...

Mileage: 146,000

VEHICLE HAS ABNORMAL AMOUNT OF RUST ON FRAME METAL PARTS WITH EXCESSIVE CHIPPING AN CORROSION. ALSO, OF ALMOST MORE CONCERN IS THAT THE AIRBAG SENSORS ARE COMPLETELY ROTTED THROUGH, AS IF THEY WERE SACRIFICIAL ANODES. FRAME FAILURE DUE TO ABNORMAL RUST COULD CAUSE A CATASTROPHIC ACCIDENT. SENSOR ...

Mileage: 146,000

DASHBOARD HAS STARTED CRACKING ON PASSENGER SIDE. NOW IT HAS SPREAD ALL ACROSS THE DASH TO THE DRIVER SIDE. I'M WORRIED THE AIRBAGS MAY DEPLOY. THIS TRUCK IS IN PRISTINE CONDITION AND KEPT IN A GARAGE WHEN HOME AND UNDER COVERED PARKING AT WORK. I ALSO HAVE A 2003 TUNDRA WITH MORE MILES AND DASH...

Mileage: 125,000

I HAVE A TOYOTA TACOMA 4 DOOR 4 CLY PICK UP..I WAS ON THE INTERNET AND JUST NOTICE A RECALL ABOUT BRAKES,,IS MY TRUCK INCLUDED IN THIS RECALL? AND ANOTHER I HAVE NEVER GOT ANY LETTER OR ANYTHING TELLING ME ABOUT ANY RECALLS ON MY TRUCK AND I SEE HERE THERE HAS BEEN RECALL FOR FRONT BALL JOINTS ...

I HAVE A TOYOTA TACOMA 4 DOOR 4 CLY PICK UP..I WAS ON THE INTERNET AND JUST NOTICE A RECALL ABOUT BRAKES,,IS MY TRUCK INCLUDED IN THIS RECALL? AND ANOTHER I HAVE NEVER GOT ANY LETTER OR ANYTHING TELLING ME ABOUT ANY RECALLS ON MY TRUCK AND I SEE HERE THERE HAS BEEN RECALL FOR FRONT BALL JOINTS ...

I HAVE A TOYOTA TACOMA 4 DOOR 4 CLY PICK UP..I WAS ON THE INTERNET AND JUST NOTICE A RECALL ABOUT BRAKES,,IS MY TRUCK INCLUDED IN THIS RECALL? AND ANOTHER I HAVE NEVER GOT ANY LETTER OR ANYTHING TELLING ME ABOUT ANY RECALLS ON MY TRUCK AND I SEE HERE THERE HAS BEEN RECALL FOR FRONT BALL JOINTS ...

I HAVE A TOYOTA TACOMA 4 DOOR 4 CLY PICK UP..I WAS ON THE INTERNET AND JUST NOTICE A RECALL ABOUT BRAKES,,IS MY TRUCK INCLUDED IN THIS RECALL? AND ANOTHER I HAVE NEVER GOT ANY LETTER OR ANYTHING TELLING ME ABOUT ANY RECALLS ON MY TRUCK AND I SEE HERE THERE HAS BEEN RECALL FOR FRONT BALL JOINTS ...

I STARTED MY VEHICLE @ 3PM WHEN I GOT OFF WORK AS SOON AS IT STARTED THE VSC, ABS AND BRAKE LIGHT CAME ON AS WELL AS A ALARM IN THE DASH. I ALSO NOTICED THE CLOCK IN THE DASH SAID 1:00 INSTEAD OF 3:00. WHEN I DEPRESSED THE BRAKE I HAD VIRTUALLY NO BRAKES. I HAVE READ UP ON THIS AND FOUND THAT A BA...

Mileage: 235,000

VEHICLE FRAME IS ROTTED AND UNSAFE HAD IT LOOKED AT , MY AUTO SHOP SAID IT IS UNSAFE CANNOT SELL THE CAR IN THE CONDITION OF THE FRAME I HAVE OWNED IT FOR 4 YEARS AND IT HAS ALWAYS BEEN IN A HEATED GARAGE THROUGH THE WINTERS, HAVE TAKEN GOOD CARE OF THE VEHICLE THE ONLY WAY I FOUND OUT THE FRAME WA...

THE FRAME HAS RUSTED THRU MAKING HOLES AND IF NOT REPAIRED WILL BE UNSAFE TO DRIVE. TOYOTA HAS NOT OFFERED A RECALL WHICH IS CRIMINAL BECAUSE THERE ARE SO MANY THAT HAVE THIS PROBLEM. ALL OF THEIR OTHER SIMILAR VEHICLES OF ALL AGES HAVE "RECALLS" BUT THEY REFUSE TO DO SO AS "YET" ON THE 04. DEALE...

Mileage: 95,153

TL* THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. THE CONTACT STATED THE ENTIRE FRAME WAS CORRODED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN VERIFIED THE FAILURE AND STATED THAT IT COULD NOT BE REPAIRED. THE MANUFACTURER WAS UNAWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE ...

Mileage: 73,000

MY DASHBOARD IS MELTING AND CRACKING. *TR

Mileage: 89,000

CRACK IN THE VINYL DASH STARTING AT THE DRIVERS SIDE A-PILLAR AND CONTINUING OVER THE GAUGE CLUSTER ON THE LEADING EDGE AND ENDING ABOUT THE MID POINT OVER THE RADIO. TOYOTA NEEDS TO TAKE RESPONSABLITY AND RECALL THIS ITEM FOR SAFETY REASONS.

Mileage: 121,000

WHILE I WAS DRIVING MY TOYOTA 4RUNNERAND I STEPPED ON THE BRAKESAND LET OFF OF THE BRAKES I KEPT ON MAKING A THUD SOUND AS THE FASTER I DRIVE THE LOUDER IT WOULD MAKE THAT SOUND AND IT HAD A BURNING SMELL TO IT SO WHEN I TOOK IT TO THE REPAIR SHOP THEY TOLD ME THAT MY BRAKE PADS WHERE COMPLETELY GON...

Mileage: 40,000

DRIVING ON THE INTERSTATE IN NORTH CAROLINA VSC LIGHT TURNED ON, TSC LIGHT TURNED ON, ABS LIGHT TURNED ON, BRAKE LIGHT TURNED ON. CAR WAS DRIVABLE FOR A SHORT PERIOD OF TIME THEN BRAKING BECAME EXTREMELY DIFFICULT. LIMPED HOME WITH MY 3 YEAR OLD IN HER CAR SEAT AND LUCKILY WAS ABLE TO DO SO WITHOUT ...

Mileage: 187,529

DRIVING ON THE INTERSTATE IN NORTH CAROLINA VSC LIGHT TURNED ON, TSC LIGHT TURNED ON, ABS LIGHT TURNED ON, BRAKE LIGHT TURNED ON. CAR WAS DRIVABLE FOR A SHORT PERIOD OF TIME THEN BRAKING BECAME EXTREMELY DIFFICULT. LIMPED HOME WITH MY 3 YEAR OLD IN HER CAR SEAT AND LUCKILY WAS ABLE TO DO SO WITHOUT ...

Mileage: 187,529

DRIVING ON THE INTERSTATE IN NORTH CAROLINA VSC LIGHT TURNED ON, TSC LIGHT TURNED ON, ABS LIGHT TURNED ON, BRAKE LIGHT TURNED ON. CAR WAS DRIVABLE FOR A SHORT PERIOD OF TIME THEN BRAKING BECAME EXTREMELY DIFFICULT. LIMPED HOME WITH MY 3 YEAR OLD IN HER CAR SEAT AND LUCKILY WAS ABLE TO DO SO WITHOUT ...

Mileage: 187,529

8/6/14-STARTED MY 2004 4-RUNNER TO LEAVE WORK AND A HIGH-PITCHED ALARM SOUND STARTED AND THE VSC, ABS, AND OTHER DASH LIGHT SYMBOLS CAME ON. I REVERSED OUT OF MY PARKING SPOT, AND BRAKE, AND NOTHING OTHER THAN THOSE THINGS WAS OUT OF THE ORDINARY. I PULLED FORWARD AND PULLED INTO ANOTHER SPOT AND...

Mileage: 121,000

8/6/14-STARTED MY 2004 4-RUNNER TO LEAVE WORK AND A HIGH-PITCHED ALARM SOUND STARTED AND THE VSC, ABS, AND OTHER DASH LIGHT SYMBOLS CAME ON. I REVERSED OUT OF MY PARKING SPOT, AND BRAKE, AND NOTHING OTHER THAN THOSE THINGS WAS OUT OF THE ORDINARY. I PULLED FORWARD AND PULLED INTO ANOTHER SPOT AND...

Mileage: 121,000

8/6/14-STARTED MY 2004 4-RUNNER TO LEAVE WORK AND A HIGH-PITCHED ALARM SOUND STARTED AND THE VSC, ABS, AND OTHER DASH LIGHT SYMBOLS CAME ON. I REVERSED OUT OF MY PARKING SPOT, AND BRAKE, AND NOTHING OTHER THAN THOSE THINGS WAS OUT OF THE ORDINARY. I PULLED FORWARD AND PULLED INTO ANOTHER SPOT AND...

Mileage: 121,000

I HAVE HAD TWO INCIDENTS OF BRAKE CALIPERS FAILURE. UNDER 50K I HAD A FRONT DRIVER SIDE CALIPER FAIL. THEN AGAIN AT 99K THE REAR PASSENGER SIDE CALIPER FAILURE. TOYOTA HAS A MAJOR ISSUE WITH THEIR BRAKE CALIPER DESIGN ON 4-RUNNERS. TOYOTA SHOULD EXTEND THEIR WARRANTY, I ALWAYS BOUGHT TOYOTA'S,...

Mileage: 99,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT NOTICED A LARGE AMOUNT OF RUST ON THE FRAME NEAR THE RADIATOR. THE DEALER STATED THAT THE BOOTS ON THE FRONT AXLES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 110,0...

Mileage: 110,000

FRAME HAS EXCESSIVE RUST. THE VEHICLE HAS SPENT MOST OF ITS LIFE IN NH/ME. IT IS NOW REGISTERED IN FL. IT HAS BEEN IN FLORIDA FOR ABOUT 16 MONTHS. I HAVE FILED SEVERAL COMPLAINTS WITH TOYOTA AND THEY KEEP TELLING ME MY VEHICLE IS OUT OF WARRANTY SO THEY WILL NOT DO ANYTHING. THE RUST IS BAD ENOUGH ...

Mileage: 145,000

THIS COMPLAINT IS NOT ABOUT THE VEHICLE BUT RATHER ABOUT A REPLACEMENT PARTS MADE/SOLD BY THE FOLLOWING OUTFIT: PH: (954) 970-8820 FAX: (954) 970-8819 [email protected] WWW.FINESTAUTOPARTS.COM THE CALIPER (NEW) I PURCHASED FROM THEM WAS NOT ONLY IMPORTED FROM CHINA CONTRARY TO THE COMP...

Mileage: 137,000

SUFFERED SUDDEN, CATASTROPHIC FAILURE OF VSC/ABS BRAKE SYSTEM WHILE DRIVING. VSC, ABS, BRAKE DASH INDICATOR LIGHTS ILLUMINATED WITH AN AUDIBLE ALARM. VEHICLE OPERATED NORMALLY FOR ABOUT 1 MILE, THEN LOST MOST BRAKING CONTROL. NARROWLY AVOIDED COLLISION WITH ANOTHER VEHICLE DUE TO HAVING MINIMAL B...

Mileage: 99,000

SUFFERED SUDDEN, CATASTROPHIC FAILURE OF VSC/ABS BRAKE SYSTEM WHILE DRIVING. VSC, ABS, BRAKE DASH INDICATOR LIGHTS ILLUMINATED WITH AN AUDIBLE ALARM. VEHICLE OPERATED NORMALLY FOR ABOUT 1 MILE, THEN LOST MOST BRAKING CONTROL. NARROWLY AVOIDED COLLISION WITH ANOTHER VEHICLE DUE TO HAVING MINIMAL B...

Mileage: 99,000

SUFFERED SUDDEN, CATASTROPHIC FAILURE OF VSC/ABS BRAKE SYSTEM WHILE DRIVING. VSC, ABS, BRAKE DASH INDICATOR LIGHTS ILLUMINATED WITH AN AUDIBLE ALARM. VEHICLE OPERATED NORMALLY FOR ABOUT 1 MILE, THEN LOST MOST BRAKING CONTROL. NARROWLY AVOIDED COLLISION WITH ANOTHER VEHICLE DUE TO HAVING MINIMAL B...

Mileage: 99,000

SUFFERED SUDDEN, CATASTROPHIC FAILURE OF VSC/ABS BRAKE SYSTEM WHILE DRIVING. VSC, ABS, BRAKE DASH INDICATOR LIGHTS ILLUMINATED WITH AN AUDIBLE ALARM. VEHICLE OPERATED NORMALLY FOR ABOUT 1 MILE, THEN LOST MOST BRAKING CONTROL. NARROWLY AVOIDED COLLISION WITH ANOTHER VEHICLE DUE TO HAVING MINIMAL B...

Mileage: 99,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE CONTACT CRASHED INTO A POLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A IMPOUND LOT. THE MANUFACTURER WAS NOTIFIED OF THE FAILU...

Mileage: 90,444

WHEN I WENT TO CHANGE MY BRAKE PADS, I NOTICED THAT THE FRONT HAD HARDLY BEEN WORN DOWN. I HAD PREVIOUSLY NOTICED THAT I NEEDED MORE ROOM TO STOP, AND MY RATE OF DECELERATION HAD LESSENED. I DISCOVERED THAT MY INNER LOWER PISTONS ON MY FRONT CALIPERS HAD RUSTED AND FROZEN. A QUICK SEARCH ONLINE A...

Mileage: 70,000

WHILE APPROACHING A RED STOP LIGHT, THE ABS, BRAKE! VSC OFF, VSC TRAC LIGHTS ALL CAME ON ALONG WITH A LOUD BUZZER. I HAD NO IDEA WHAT WAS HAPPENING. 1 BLOCK LATER I PULLED INTO A PARKING LOT THAT WAS LUCKILY EMPTY, BECAUSE WHEN I WENT TO BRAKE TO STOP THE TRUCK, I HAD NO BRAKES...ZERO!!! I HAD THE ...

Mileage: 111,000

WHILE APPROACHING A RED STOP LIGHT, THE ABS, BRAKE! VSC OFF, VSC TRAC LIGHTS ALL CAME ON ALONG WITH A LOUD BUZZER. I HAD NO IDEA WHAT WAS HAPPENING. 1 BLOCK LATER I PULLED INTO A PARKING LOT THAT WAS LUCKILY EMPTY, BECAUSE WHEN I WENT TO BRAKE TO STOP THE TRUCK, I HAD NO BRAKES...ZERO!!! I HAD THE ...

Mileage: 111,000

DASHBOARD IS RIDDLED WITH CRACKS ALL OVER. MANY OF THE CRACKS FOLLOW ALONG THE SAME LINES AS OTHER OWNERS WHO HAVE POSTED PICS OF THEIR DASHBOARD ONLINE. MY OTHER CAR FROM A SIMILAR YEAR, HAD THE SAME ISSUE AND THAT MANUFACTURER REPLACED IT WITH A GOODWILL REPAIR, PROBABLY TO AVOID A FULL RECALL. IT...

1.) 4RUNNER SAT FOR 10-15 MINUTES WITH RADIO ON (NOT RUNNING) (BATTERY TESTED GOOD/700, 701, 691 OUR OF 75 CA) 2.) 4RUNNER WOULD NOT START, BATTERY ISSUE, AND WAS SUBSEQUENTLY JUMPED. 3.) DROVE 4RUNNER 10 MINUTES, PARKED, TUNED OFF AND STARTED BACK UP JUST FINE. 4.) 4RUNNER SAT FOR 3 HOURS...

Mileage: 123,000

1.) 4RUNNER SAT FOR 10-15 MINUTES WITH RADIO ON (NOT RUNNING) (BATTERY TESTED GOOD/700, 701, 691 OUR OF 75 CA) 2.) 4RUNNER WOULD NOT START, BATTERY ISSUE, AND WAS SUBSEQUENTLY JUMPED. 3.) DROVE 4RUNNER 10 MINUTES, PARKED, TUNED OFF AND STARTED BACK UP JUST FINE. 4.) 4RUNNER SAT FOR 3 HOURS...

Mileage: 123,000

INSPECTION OF UNDERSIDE OF VEHICLE REVEALED EXTENSIVE FRAME RUST AND PERFORATION THROUGH THE SIDES OF THE FRAME. LOWER RADIATOR SUPPORT RUSTED THROUGH, CONTROL ARM SUPPORT RUSTED THROUGH. DEALER INSPECTED AND VERIFIED, NO PROGRAM AVAILABLE FOR REPAIR. DEALER STATED COMMON PROBLEM IN NORTHEAST VEHICL...

Mileage: 93,475

MY DASHBOARD HAS SEVERAL CRACKS FORM ONE SIDE TO THE OTHER ALL ACROSS THE AIRBAG WHICH CONCERNS ME A WHOLE LOT, I ALSO HAVE A 2002 4RUNNER WHICH DOES NOT HAVE THIS PROBLEM, THE MATERIAL IS PRETTY DIFFERENT TO THE 2004, THE 2004 LOOKS AND FEEL VERY POOR, NOT SURE IF TOYOTA WILL STEP UP TO THE PLATE T...

Mileage: 87,000

MY DASHBOARD HAS SEVERAL CRACKS FORM ONE SIDE TO THE OTHER ALL ACROSS THE AIRBAG WHICH CONCERNS ME A WHOLE LOT, I ALSO HAVE A 2002 4RUNNER WHICH DOES NOT HAVE THIS PROBLEM, THE MATERIAL IS PRETTY DIFFERENT TO THE 2004, THE 2004 LOOKS AND FEEL VERY POOR, NOT SURE IF TOYOTA WILL STEP UP TO THE PLATE T...

Mileage: 87,000

FRAME IS RUSTING OUT. *TR

Mileage: 132,000

FRAME IS RUSTING OUT. *TR

Mileage: 132,000

DRIVING VEHICLE IN FRIGID WEATHER AND ENGINE SERVICE LIGHT WENT ON, FOLLOWED BY VSC TRAC LIGHT AND VSC OFF LIGHT GOING ON. WENT TO SERVICE STATION THEY CHECKED CAR AND WERE ABLE TO TURN OFF ENGINE LIGHT. TOOK VEHICLE TO EMPIRE TOYOTA IN ONEONTA NY 1/18 AND WAS TOLD LOW BATTERY CAUSED PROBLEM. DIAGNO...

Mileage: 118,000

DRIVING VEHICLE IN FRIGID WEATHER AND ENGINE SERVICE LIGHT WENT ON, FOLLOWED BY VSC TRAC LIGHT AND VSC OFF LIGHT GOING ON. WENT TO SERVICE STATION THEY CHECKED CAR AND WERE ABLE TO TURN OFF ENGINE LIGHT. TOOK VEHICLE TO EMPIRE TOYOTA IN ONEONTA NY 1/18 AND WAS TOLD LOW BATTERY CAUSED PROBLEM. DIAGNO...

Mileage: 118,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING 15 MPH, THE VEHICLE SUDDENLY ACCELERATED TO 25 MPH AND CAUSED THE CONTACT TO CRASH INTO A POLE. THE CONTACT WAS NOT INJURED AND A POLICE REPORT WAS NOT FILED. THE CONTACT DID NOT CALL THE MANUFACTURER REGARDING THE INC...

Mileage: 164,000

I PURCHASED FOUR (4) NEW BF GOODRICH RADIAL LONG TRAIL T/A SIZE P265/65R17 110T M&S FOR MY 2004 TOYOTA 4RUNNER IN 08/2011. I HAD APPROX 10,000 MILES ON THE NEW TIRES. TIRES ARE NOW DRY ROTTED/CRACKED ON THE SIZE WALL, ALL AROUND THE WHEEL/FRAME (ON ALL 4 TIRES). *TR

MY WIFE WAS AT THE SCHOOL ZONE TAKING OUR CHILDREN TO SCHOOL, WHEN SHE HEARD A NOISE AND AN ALARM START TO SOUND, THE ABS AND TRACK OFF LIGHTS CAME ON AND THE BRAKE PEDAL WENT TO THE FLOOR, SHE WAS NOT ABLE TO STOP THE VEHICLE, FORTUNATELY SHE WAS ON SCHOOL SPEED ZONE AND NOTHING WAS IN FRONT OF HER...

Mileage: 77,860

AFTER READING ONLINE THERE ARE HUNDREDS OF REPORTS OF CYLINDER #6 FAILING WITH A HEAD GASKET ISSUE WHICH RESULTS IN A 2500-4000 $$ REPAIR BILL. TOYOTA HAD A MAJOR RECALL FOR THE 2ND GENERATION 4RUNNER BECAUSE OF HEAD GASKET ISSUES. THEY REALLY NEED TO ADDRESS THIS ISSUE B/C THERE IS OBVIOUSLY A MA...

Mileage: 148,000

UNDERBODY FRAME RUSTED OUT IN SEVERAL PLACES. *TR

Mileage: 77,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4-RUNNER. THE CONTACT STATED THAT THE VEHICLE STABILITY CONTROL AND THE CHECK ENGINE WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE COMPUTER NEEDED TO BE CALIBRATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE....

Mileage: 112,000

ROUGH IDLE AT MORNING START UP. VSC, TRAC OFF INDICATORS ILLUMINATE. OBD II CODE OF P0306, MISFIRE CYLINDER #6. HAVING TO REFILL ENGINE COOLANT ON A WEEKLY BASIS. PREMATURE HEAD GASKET FAILURE. TOYOTA SUPER LONG LIFE ENGINE COOLANT IS SLOWLY LEAKING INTO CYLINDER #6. ROUGH IDLE NOTICEABLE AT MOR...

Mileage: 89,000

ROUGH IDLE AT MORNING START UP. VSC, TRAC OFF INDICATORS ILLUMINATE. OBD II CODE OF P0306, MISFIRE CYLINDER #6. HAVING TO REFILL ENGINE COOLANT ON A WEEKLY BASIS. PREMATURE HEAD GASKET FAILURE. TOYOTA SUPER LONG LIFE ENGINE COOLANT IS SLOWLY LEAKING INTO CYLINDER #6. ROUGH IDLE NOTICEABLE AT MOR...

Mileage: 89,000

DRIVING TO CORAL GABLES AT AROUND 20 MPH, ALL OF SUDDEN FOUR LIGHTS COMES ON AND LOUD BEEPING NOISE. VSC, TRAC OFF, ABS & BRAKE LIGHTS ON AT THE SAME TIME, BRAKE PEDDLE IS HARD AND NO BRAKES AT ALL. I HAD TO GO INTO NEUTRAL TRY THE EMERGENCY BRAKE TO TRY AND STOP AND PULL OVER, I HAD TO TOW MY ...

Mileage: 144,094

DRIVING TO CORAL GABLES AT AROUND 20 MPH, ALL OF SUDDEN FOUR LIGHTS COMES ON AND LOUD BEEPING NOISE. VSC, TRAC OFF, ABS & BRAKE LIGHTS ON AT THE SAME TIME, BRAKE PEDDLE IS HARD AND NO BRAKES AT ALL. I HAD TO GO INTO NEUTRAL TRY THE EMERGENCY BRAKE TO TRY AND STOP AND PULL OVER, I HAD TO TOW MY ...

Mileage: 144,094

DRIVING TO CORAL GABLES AT AROUND 20 MPH, ALL OF SUDDEN FOUR LIGHTS COMES ON AND LOUD BEEPING NOISE. VSC, TRAC OFF, ABS & BRAKE LIGHTS ON AT THE SAME TIME, BRAKE PEDDLE IS HARD AND NO BRAKES AT ALL. I HAD TO GO INTO NEUTRAL TRY THE EMERGENCY BRAKE TO TRY AND STOP AND PULL OVER, I HAD TO TOW MY ...

Mileage: 144,094

DRIVERS SEAT ON TOYOTA 4 RUNNER, WHEN ADJUSTED AND LOCKED IN PLACE, HAS WAY TOO MUCH LATERAL MOVEMENT. THE SEAT "ROCKS" FROM SIDE TO SIDE APPROXIMATELY 1-2 INCHES. IT IS MOST NOTICEABLE WHEN YOU ARE STRAPPED INTO THE SEAT, WITH THE SEAT BELT ON AND SEAT LOCKED IN PLACE. I HAD MY INDEPEND...

Mileage: 120,000

IN 2006 OF SEPT, I NOTICED A LITTLE HAIRLINE ON MY DASHBOARD AND AS YEARS GO BY UP TO THIS YEAR 1 SEPT 2013 THAT HAIRLINE DEVELOP TO A CRACK. THIS CAR IS GARAGE KEEP, WINDOWS ARE CRACK OPEN FOR AIR CIRCULATION AND A SUN VISOR COVER FOR WINDSHIELD AND NOT MUCH DRIVEN, ACTUAL MILEAGE IS 50600 AS OF TO...

ON JUNE 20, 2013 APPROX. 10:30-11:00 AM, WALKED IN GARAGE ATTACHED TO HOUSE NOTICE SMELL OF BURN, OPENED DRIVER DOOR AND DISCOVERED THAT THE FRONT PASSENGER DOOR COMPLETELY BURN, FRONT PASSENGER SEAT BURN, PASSENGER SUNVISOR BURNED, CARPET BURNED. NO PREVIOUS PROBLEMS OR TECHNICAL ISSUES, AUTO CHEC...

Mileage: 7,200,000

ON JUNE 20, 2013 APPROX. 10:30-11:00 AM, WALKED IN GARAGE ATTACHED TO HOUSE NOTICE SMELL OF BURN, OPENED DRIVER DOOR AND DISCOVERED THAT THE FRONT PASSENGER DOOR COMPLETELY BURN, FRONT PASSENGER SEAT BURN, PASSENGER SUNVISOR BURNED, CARPET BURNED. NO PREVIOUS PROBLEMS OR TECHNICAL ISSUES, AUTO CHEC...

Mileage: 7,200,000

ON JUNE 20, 2013 APPROX. 10:30-11:00 AM, WALKED IN GARAGE ATTACHED TO HOUSE NOTICE SMELL OF BURN, OPENED DRIVER DOOR AND DISCOVERED THAT THE FRONT PASSENGER DOOR COMPLETELY BURN, FRONT PASSENGER SEAT BURN, PASSENGER SUNVISOR BURNED, CARPET BURNED. NO PREVIOUS PROBLEMS OR TECHNICAL ISSUES, AUTO CHEC...

Mileage: 7,200,000

MY DRIVER'S SIDE VISOR NO LONGER STAYS UP. IT SAGS AND I WAS USING VELCRO TO KEEP IT AS CLOSE TO THE ROOF OF MY CAR AS POSSIBLE SINCE IT WOULD SAG INTO MY LINE OF VISION. *TR

Mileage: 80,000

DRIVERS DOOR LATCH MECHANISM WOULD NOT PERMIT DRIVER TO EXIT THE VEHICLE. DOOR WOULD NOT UNLOCK, THOUGH ALL ELECTRIC AND MANUAL ACTIONS TO UNLOCK THE DOOR APPEAR TO WORK, LATCH HANDLE WOULD NOT MOVE. THIS CONDITION WAS NORMAL FOR THE VEHICLE WHEN NEW IF THE DOOR WAS LOCKED. ALL OTHER DOORS IN THE...

Mileage: 93,077

DRIVERS DOOR LATCH MECHANISM WOULD NOT PERMIT DRIVER TO EXIT THE VEHICLE. DOOR WOULD NOT UNLOCK, THOUGH ALL ELECTRIC AND MANUAL ACTIONS TO UNLOCK THE DOOR APPEAR TO WORK, LATCH HANDLE WOULD NOT MOVE. THIS CONDITION WAS NORMAL FOR THE VEHICLE WHEN NEW IF THE DOOR WAS LOCKED. ALL OTHER DOORS IN THE...

Mileage: 93,077

AIR BAGS FAILED TO DEPLOY. I HAD SENT IN A COMPLAINT AFTER THE INCIDENT. CAR WAS TOTALED AND DRIVER WAS INJURED WITH A FRONT END COLLISION. TOYOTA REFUSED TO LOOK AT CAR FOR AIRBAG DEFECTS. I CAN SEND IMAGES IF NEEDED. RECALLED FOR TOO MUCH FORCE? HOW ABOUT JUST DEFECTIVE? THIS IS AT LEAST A...

Mileage: 45,000

I WAS BACKING INTO MY DRIVEWAY. I STOPPED THE VEHICLE. I THEN SHIFTED INTO FORWARD FOR ABOUT 1 FOOT AND THEN SHIFTED INTO REVERSE (I WAS MANEUVERING MY CAR). WHEN I SHIFTED INTO REVERSE THE ENGINE WENT TO MAXIMUM POWER (INSTANTLY). I JAMMED ON THE BRAKE AND THE REAR TIRES STARTED TO SPIN AND THE...

Mileage: 47,000

I EXPERIENCED A TERRIFYING "ACCELERATION PROBLEM" THIS PAST WEEK AS I WAS PARKING MY CAR AT A LOCAL STORE. I'D ALREADY SLOWED DOWN TO ALMOST A HALT, BUT AS I PUT MY FOOT ON THE BRAKE TO COME TO A COMPLETE STOP, IT SUDDENLY LURCHED FORWARD WITH SHOCKING SPEED. I INSTINCTIVELY THREW THE GEAR INTO PARK...

Mileage: 50,850

I EXPERIENCED A TERRIFYING "ACCELERATION PROBLEM" THIS PAST WEEK AS I WAS PARKING MY CAR AT A LOCAL STORE. I'D ALREADY SLOWED DOWN TO ALMOST A HALT, BUT AS I PUT MY FOOT ON THE BRAKE TO COME TO A COMPLETE STOP, IT SUDDENLY LURCHED FORWARD WITH SHOCKING SPEED. I INSTINCTIVELY THREW THE GEAR INTO PARK...

Mileage: 50,850

MAJOR RUST ON FRAME AND OTHER MECHANICAL PARTS. NOT EXPOSED TO SALT DOES NOT OCCUR WITH MY OTHER VEHICLES. *TR

Mileage: 80,000

MAJOR RUST ON FRAME AND OTHER MECHANICAL PARTS. NOT EXPOSED TO SALT DOES NOT OCCUR WITH MY OTHER VEHICLES. *TR

Mileage: 80,000

MAJOR RUST ON FRAME AND OTHER MECHANICAL PARTS. NOT EXPOSED TO SALT DOES NOT OCCUR WITH MY OTHER VEHICLES. *TR

Mileage: 80,000

I OPENED THE PASSENGER SIDE DOOR TO PLACE MY BAG DOWN. THE CAR ROLLED OUT OF GEAR DOWN MY DRIVEWAY WITH MY DAUGHTER IN THE FRONT SEAT. THEN I HAD TO JUMP INTO THE ROLLING CAR TO PUT IT BACK INTO PARK AND THE KEYS WERE NOT IN THE IGNITION. *TR

I OPENED THE PASSENGER SIDE DOOR TO PLACE MY BAG DOWN. THE CAR ROLLED OUT OF GEAR DOWN MY DRIVEWAY WITH MY DAUGHTER IN THE FRONT SEAT. THEN I HAD TO JUMP INTO THE ROLLING CAR TO PUT IT BACK INTO PARK AND THE KEYS WERE NOT IN THE IGNITION. *TR

ON 8/22/2011, PHIL BACHMAN TOYOTA IN JOHNSON CITY, TN REPLACED A LEAKING LEFT FRONT CALIPER ON MY TOYOTA 4RUNNER. THE LEAK WAS SO BAD THAT THE FRONT BRAKE PADS WERE SATURATED AND HAD TO BE REPLACED. BRAKE FLUID COVERED MY TIRE AND WHEEL, AND THE WHEEL HAD SEVERAL KNICKS FROM SOMETHING THAT OCCURRE...

Mileage: 137,000

2004 4RUNNER LIMITED, FRAME RUSTED OUT. *TR

Mileage: 182,000

2004 4RUNNER LIMITED, FRAME RUSTED OUT. *TR

Mileage: 182,000

VEHICLE WAS BEING PARKED ALONGSIDE THE CURB WHEN IT SUDDENLY JUMPED THE CURB, THE SIDEWALK ONTO THE UPHILL GRASSY LANDSCAPE, HIT AND SEVERED A TREE, AND ALMOST CRASHED THE HOUSE INCHES AWAY, THEN BOUNCED BACK TO THE STREET- ALL IN ABOUT 3 SECONDS. THE TIRES SPUN VIOLENTLY AND LEFT A THICK RESIDUE O...

Mileage: 40,000

VEHICLE WAS BEING PARKED ALONGSIDE THE CURB WHEN IT SUDDENLY JUMPED THE CURB, THE SIDEWALK ONTO THE UPHILL GRASSY LANDSCAPE, HIT AND SEVERED A TREE, AND ALMOST CRASHED THE HOUSE INCHES AWAY, THEN BOUNCED BACK TO THE STREET- ALL IN ABOUT 3 SECONDS. THE TIRES SPUN VIOLENTLY AND LEFT A THICK RESIDUE O...

Mileage: 40,000

VEHICLE WAS BEING PARKED ALONGSIDE THE CURB WHEN IT SUDDENLY JUMPED THE CURB, THE SIDEWALK ONTO THE UPHILL GRASSY LANDSCAPE, HIT AND SEVERED A TREE, AND ALMOST CRASHED THE HOUSE INCHES AWAY, THEN BOUNCED BACK TO THE STREET- ALL IN ABOUT 3 SECONDS. THE TIRES SPUN VIOLENTLY AND LEFT A THICK RESIDUE O...

Mileage: 40,000

WHILE DRIVING AT APPROXIMATELY 50 MPH AND PRESSING THE BRAKES FOR A SUDDEN STOP, THE 4-RUNNER LURCHES TO THE LEFT, AND THEN, WHEN THE BRAKE IS RELEASED, BACK TO THE RIGHT. I WAS ON A TRIP AND WAS LUCKY ENOUGH TO GET IN TO A TOYOTA DEALER ON SATURDAY. THE SERVICE DEPARTMENT TOLD ME I HAD TWO FROZEN...

Mileage: 140,000

DRIVING ON THE HIGHWAY GOING STRAIGHT AT 55 MPH, WITH MY FOOT ON THE ACCELERATOR ONLY (WITH NO LOSS OF STABILITY OR CONTROL AND NO WET CONDITIONS), SUDDENLY AND SIMULTANEOUSLY A BEEPING NOISE FROM THE DASHBOARD OCCURS ALONG WITH THE 4RUNNER PULLING REAL HARD TO THE LEFT. (ALMOST AS IF I PULLED THE S...

Mileage: 105,000

DRIVING ON THE HIGHWAY GOING STRAIGHT AT 55 MPH, WITH MY FOOT ON THE ACCELERATOR ONLY (WITH NO LOSS OF STABILITY OR CONTROL AND NO WET CONDITIONS), SUDDENLY AND SIMULTANEOUSLY A BEEPING NOISE FROM THE DASHBOARD OCCURS ALONG WITH THE 4RUNNER PULLING REAL HARD TO THE LEFT. (ALMOST AS IF I PULLED THE S...

Mileage: 105,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT NOTICED THAT THE ENTIRE LENGTH OF THE DASHBOARD EXHIBITED CRACKS WHICH ORIGINATED FROM THE DRIVER'S SIDE AIR BAG HOUSING. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 97,...

Mileage: 97,377

I BEGAN TO NOTICE THAT MY DASH HAS STARTED TO CRACK AND IT IS IN THE AREA OF THE AIR BAG. I DID SOME RESEARCH AND FOUND OUT THAT MANY 2004 TOYOTA 4RUNNER OWNERS ARE HAVING THE SAME PROBLEM. I CALLED TOYOTA TO ASK FOR INFO AND THEY REFUSED TO ASSIST IN THE MATTER OR EVEN HELP PAY FOR IT TO BE REPLACE...

Mileage: 87,000

I BEGAN TO NOTICE THAT MY DASH HAS STARTED TO CRACK AND IT IS IN THE AREA OF THE AIR BAG. I DID SOME RESEARCH AND FOUND OUT THAT MANY 2004 TOYOTA 4RUNNER OWNERS ARE HAVING THE SAME PROBLEM. I CALLED TOYOTA TO ASK FOR INFO AND THEY REFUSED TO ASSIST IN THE MATTER OR EVEN HELP PAY FOR IT TO BE REPLACE...

Mileage: 87,000

ENGINE IS LEAKING COOLANT INTO THE #6 CYLINDER CAUSING MISFIRE, ROUGH IDLE, AND CHECK ENGINE LIGHT TO ILLUMINATE - APPARENTLY A VERY COMMON PROBLEM WITH THIS V6, 4.0L ENGINE LEAKING AT THE #6 CYLINDER - OBVIOUSLY A MANUFACTURING DEFECT TO HAVE HEAD GASKETS FAILING AT THE SAME LOCATION. *TR

Mileage: 105,000

ON OR ABOUT JULY 16, 2012 OWNER NOTICED THAT THE VEHICLE DASHBOARD HAD VERTICAL CRACKS NEAR THE DRIVER SIDE AND PASSENGER SIDE AIR VENTS. ON OR ABOUT 9/21/12, OWNER NOTICED A HORIZONTAL CRACK IN THE PASSENGER SIDE DASHBOARD ABOVE THE GLOVE BOX. VEHICLE HAS NOT BEEN IN ANY ACCIDENTS AND HAS BEEN HOU...

Mileage: 148,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE DASHBOARD DEVELOPED MULTIPLE CRACKS AND HE WAS CONCERNED THAT THE AIR BAGS WOULD BECOME EXPOSED. THE VEHICLE WAS TAKEN TO THE DEALER WHO STATED THAT THE DASHBOARD NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FA...

Mileage: 42,000

APPROX 3 YEARS AGO, I NOTICED A SMALL CRACK IN THE DASH ON THE PASSENGER SIDE, I THOUGHT MAYBE SOMEONE DID SOMETHING AND DID NOT TELL ME. SINCE THAT TIME, MY DASH HAS INCREASED IN THE AMOUNT AND LENGTH OF THE CRACKS. ONE CRACK IS ABOUT 24-28 INCHES LONG AND OTHERS ARE ABOUT 2 INCHES AND LONGER. I LO...

APPROX 3 YEARS AGO, I NOTICED A SMALL CRACK IN THE DASH ON THE PASSENGER SIDE, I THOUGHT MAYBE SOMEONE DID SOMETHING AND DID NOT TELL ME. SINCE THAT TIME, MY DASH HAS INCREASED IN THE AMOUNT AND LENGTH OF THE CRACKS. ONE CRACK IS ABOUT 24-28 INCHES LONG AND OTHERS ARE ABOUT 2 INCHES AND LONGER. I LO...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRONT SEAT PASSENGER ATTEMPTED TO REMOVE THE SEAT BELT AND NOTICED THE LOCK WOULD NOT RELEASE. THE PASSENGER WAS ABLE TO PULL THE SEAT BELT UNDER HERSELF AND MANEUVER HERSELF OUT OF THE SEAT. THE DEALER WAS MADE AWARE OF THE FAI...

Mileage: 80,000

THERE IS A DESIGN FLAW IN THE 04 4RUNNER. THE BRAKE CALIPERS RUST OUT, AND FREEZE, SIEZE, AND NEED TO BE REPLACED ANY TIME THE BRAKE PADS NEED TO REPLACED. THIS ALSO DAMAGES THE ROTORS. TODAY, I HAD TO OVERHAUL THE ENTIRE FRONT END BRAKING SYSTEM, INCLUDING PADS, ROTORS AND CALIPERS. THIS IS THE...

Mileage: 56,977

THE PASSENGER SEATBELT IN THE TOYOTA 4RUNNER TEARS. THE 3RD SEATBELT IN THE 4RUNNER I OWN IS TEARING AND WILL HAVE TO BE REPLACED FOR THE 4TH TIME. EACH TIME THE DEALERSHIP CHARGES FOR A NEW SEATBELT AND INSTALLATION. THE PASSENGER SEATBELT IS NOT USED DAILY. THIS IS A SEVERE SAFETY CONCERN! YE...

Mileage: 76,500

DRIVE SHAFT IS CLANGING, BANGING, CAUSING SLAMMING WITH THE BRAKING ACTION SURGING FORWARD SEVERAL FEET BEFORE STOPPING. *TR

Mileage: 56,000

DRIVE SHAFT IS CLANGING, BANGING, CAUSING SLAMMING WITH THE BRAKING ACTION SURGING FORWARD SEVERAL FEET BEFORE STOPPING. *TR

Mileage: 56,000

I HAVE BEEN READING ONLINE WHERE MANY OWNERS OF TOYOTA 4RUNNERS IN THE 2003-2004 YEAR RANGE ARE HAVING A CRACKED DASH ON THE PASSENGER SIDE ABOVE THE AIRBAG. IN AN ACCIDENT, THE PLASTIC COULD CUT YOU IF THE AIR BAG GOES OFF AND WATER COULD GO DOWN CRACK AND GET INTO AIRBAG SYSTEM. TO MY KNOWLEDGE,...

Mileage: 150,000

LINEAR CRACKS APPEARED SEEMINGLY OVERNIGHT ACROSS THE ENTIRE DASH (TOYOTA CALLS IT THE SAFETY PAD). CAR IS IN PRISTINE CONDITION, AND A SUNSHADE WAS USED DAILY. THIS MUST BE A DEFECT IN MATERIALS. *TR

Mileage: 45,000

I HAVE A 2004 4RUNNER LIMITED. THE DASH HAS A LONG CRACK ALL THE WAY ACROSS THE FRONT. THE DASH ON THE PASSENGER SIDE RIGHT ABOVE THE GLOVE BOX IS COVERED WITH CRACKS. I BELIEVE THAT THIS IS A DEFECT IN MATERIALS USED BY TOYOTA AND THAT IT CAN POTENTIALLY CAUSE THE AIRBAG TO NOT DEPLOY CORRECTLY....

I HAVE A 2004 4RUNNER LIMITED. THE DASH HAS A LONG CRACK ALL THE WAY ACROSS THE FRONT. THE DASH ON THE PASSENGER SIDE RIGHT ABOVE THE GLOVE BOX IS COVERED WITH CRACKS. I BELIEVE THAT THIS IS A DEFECT IN MATERIALS USED BY TOYOTA AND THAT IT CAN POTENTIALLY CAUSE THE AIRBAG TO NOT DEPLOY CORRECTLY....

I HAVE A TOYOTA 4RUNNER 2004 W/ 62000 THAT HAS BEEN KEPT IN THE GARAGE AND IS IN IMMACULATE CONDITION EXCEPT FOR CRACKS ON THE DASHBOARD AROUND INSTRUMENT PANEL AND ABOVE GLOVE BOX . I BROUGHT TO THE DEALERSHIP AND THEY SAID I HAVE TO REPLACE IT AND WOULD COST AROUND $1500. THE SAME DEALERSHIP REPLA...

Mileage: 32,000

WHILE DRIVING, THE CEL (CHECK ENGINE LIGHT) CAME ON AND THE VSC TRAC AND VSC OFF LIGHTS CAME ON AS WELL. APPARENTLY TOYOTA DISABLES VSC WHEN THE CEL IS TRIGGERED. IN MY CASE, THE 2 TIMES IT HAS OCCURRED HAS BEEN DUE TO EMISSIONS RELATED FAILURES (1ST TIME THE CAT FAILED, 2ND TIME ONE OF THE O2 SENS...

Mileage: 131,000

WHILE DRIVING, THE CEL (CHECK ENGINE LIGHT) CAME ON AND THE VSC TRAC AND VSC OFF LIGHTS CAME ON AS WELL. APPARENTLY TOYOTA DISABLES VSC WHEN THE CEL IS TRIGGERED. IN MY CASE, THE 2 TIMES IT HAS OCCURRED HAS BEEN DUE TO EMISSIONS RELATED FAILURES (1ST TIME THE CAT FAILED, 2ND TIME ONE OF THE O2 SENS...

Mileage: 131,000

WHILE DRIVING, THE CEL (CHECK ENGINE LIGHT) CAME ON AND THE VSC TRAC AND VSC OFF LIGHTS CAME ON AS WELL. APPARENTLY TOYOTA DISABLES VSC WHEN THE CEL IS TRIGGERED. IN MY CASE, THE 2 TIMES IT HAS OCCURRED HAS BEEN DUE TO EMISSIONS RELATED FAILURES (1ST TIME THE CAT FAILED, 2ND TIME ONE OF THE O2 SENS...

Mileage: 131,000

WHILE DRIVING, THE CEL (CHECK ENGINE LIGHT) CAME ON AND THE VSC TRAC AND VSC OFF LIGHTS CAME ON AS WELL. APPARENTLY TOYOTA DISABLES VSC WHEN THE CEL IS TRIGGERED. IN MY CASE, THE 2 TIMES IT HAS OCCURRED HAS BEEN DUE TO EMISSIONS RELATED FAILURES (1ST TIME THE CAT FAILED, 2ND TIME ONE OF THE O2 SENS...

Mileage: 131,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. THE CONTACT STATED THAT WHILE PARKED, THE DEFROSTER WAS ACTIVATED WHEN THE REAR WINDOW EXPLODED. THE VEHICLE WAS THEN TAKEN TO AN AUTHORIZED DEALER WHERE THEY ADVISED THE CONTACT THAT THE FAILURE WAS CAUSED BY AN ELECTRICAL MALFUNCTION IN THE DEFROSTER. ...

Mileage: 97,000

AROUND THE END OF 2010, I NOTICED A CRACK ON THE DASHBOARD OVER THE PASSENGER SIDE AIRBAG AND TOOK THE VEHICLE TO MY LOCAL DEALER TO SEE IF THE FACTORY REPRESENTATIVE COULD LOOK AT IT AT HIS NEXT VISIT. INSTEAD OF THE REP LOOKING AT IT AT A LATER DATE THE SERVICE MANAGER HAD ME BRING THE VEHICLE BA...

Mileage: 39,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30-35 MPH, THE ACCELERATOR PEDAL BECAME JAMMED AND CAUSED THE VEHICLE TO ACCELERATE TO 65 MPH. THE CONTACT WAS ABLE TO RELEASE THE PEDAL AS THE VEHICLE RESUMED NORMAL OPERATION. THE VEHICLE WAS TOWED TO ...

Mileage: 67,200

MY 2004 TOYOTA 4/RUNNER DASH BOARD HAS CRACKS ALL IN THE FRONT OF THE RIGHT SIDE AIR BAG (PASSENGER SIDE) THEY CONTINUE TO GROW BECOMING DEEP. THEY APPEARED AT ONE TIME, THIS VERY UNUSUAL, I HAVE OWNED A 1993 TOYOTA 4/RUNNER AND THE DASH BOARD NEVER HAS CRACKS AND IT WAS ALWAYS PARKED OUT SIDE. MY...

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FLOOR MAT BECAME TRAPPED UNDER THE ACCELERATOR PEDAL AND CAUSED THE VEHICLE TO UNINTENTIONALLY ACCELERATE. THE VEHICLE WAS TAKEN TO THE DEALER FOR REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 11V113000 (VEHICLE SPEED CONTROL: ACCELER...

Mileage: 170,000

I HAD A NEW BRAKE PADS AND ROTOR'S INSTALLED AT 50,000 MILES,AT 70,000 MILES I DISCOVERED THAT THE FRONT LOWER BRAKE CALIPER PISTON HAD FROZEN. IT WAS THE SAME FOR BOTH SIDES. TOOK IT INTO THE SHOP, AND THEY SAID THE SAME THING. HAD TO HAVE THE CALIPER, BRAKE PADS, AND ROTORS, REPLACED ON BOTH SIDES...

Mileage: 70,000

BOTH FRONT (LEFT AND RIGHT) CALIPER SEIZED. LOWER INSIDE PISTON SEIZED AND WOULD NOT RETRACT. REPLACED BOTH CALIPERS WITH RE-MANUFACTURED PARTS FROM A1 CARDONE AND LESS THAN 1 YEAR AND 5000 MILES LATER BOTH CALIPERS HAVE SEIZED AGAIN CREATING WHEEL SHAKE WHEN BRAKING ABOVE 40 MPH. I AM NOT THE FIRS...

Mileage: 54,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING 30 MPH, THE CONTACT STATED SHE APPLIED PRESSURE TO THE ACCELERATOR PEDAL WHEN IT EXTENDED TO THE FLOOR AND REMAINED STUCK. SHE APPLIED PRESSURE TO THE BRAKES; HOWEVER, THE VEHICLE DID NOT STOP. SHE ACTIVATED THE EMERGENCY BRAKE AND SHIFTED I...

Mileage: 67,262

DRIVER SIDE AND PASSENGER SIDE AIR BAGS DEPLOYED WHEN IGNITION SWITCH WAS TURNED TO FIRST POSITION. ENGINE WAS NOT RUNNING AND CAR WAS IN PARK. MY CAR WAS PARKED IN MY GARAGE AT THE TIME AIR BAGS EXPLODED AND HAS NOT BEEN IN ANY ACCIDENTS.

Mileage: 68,000

THE EVENING OF 8/10/11 AS I WAS LEAVING WORK, I TURNED THE VEHICLE ON AND A HIGH PITCHED ALARM-TYPE SOUND STARTED; VSC LIGHT, BRAKE LIGHTS CAME ON. AT THIS POINT, I ASKED A NEAR BY SUPERVISOR TO TAKE A LOOK AT THE VEHICLE; UPON INSPECTION HE DID NOT FIND ANYTHING OUT OF PLACE. HE TEST DROVE THE VEHI...

Mileage: 165,931

THE EVENING OF 8/10/11 AS I WAS LEAVING WORK, I TURNED THE VEHICLE ON AND A HIGH PITCHED ALARM-TYPE SOUND STARTED; VSC LIGHT, BRAKE LIGHTS CAME ON. AT THIS POINT, I ASKED A NEAR BY SUPERVISOR TO TAKE A LOOK AT THE VEHICLE; UPON INSPECTION HE DID NOT FIND ANYTHING OUT OF PLACE. HE TEST DROVE THE VEHI...

Mileage: 165,931

THE EVENING OF 8/10/11 AS I WAS LEAVING WORK, I TURNED THE VEHICLE ON AND A HIGH PITCHED ALARM-TYPE SOUND STARTED; VSC LIGHT, BRAKE LIGHTS CAME ON. AT THIS POINT, I ASKED A NEAR BY SUPERVISOR TO TAKE A LOOK AT THE VEHICLE; UPON INSPECTION HE DID NOT FIND ANYTHING OUT OF PLACE. HE TEST DROVE THE VEHI...

Mileage: 165,931

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRONT DRIVER SEAT WOULD NOT ATTACH TO THE MECHANICAL RAIL PROPERLY AND AS A RESULT, PIECES OF FOAM FROM THE BOTTOM OF THE SEAT CUSHION WERE BECOMING STUCK WITHIN THE FRAME RAIL TRACKS. THE DEALER WAS NOTIFIED OF THE FAILURE YET ...

Mileage: 40,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. THE CONTACT WAS DRIVING 20 MPH WHEN THE STEERING WHEEL FAILED AND BECAME STIFF WITHOUT WARNING. THE CONTACT MENTIONED THAT THE DRIVER WAS ABLE TO REGAIN CONTROL OF THE VEHICLE AND BRING IT TO A STOP. THE VEHICLE WAS TOWED TO A LOCAL REPAIR SHOP WHERE IT W...

Mileage: 65,000

FROZEN FRONT BRAKE CALIPER RESULTING IN BRAKE PART FAILURE AND BRAKE PEDAL PULSATING. OCCURRED AGAIN MAY 2010. THIS PROBLEM OCCURS WITH MANY TOYOTA TRUCKS. *TR

Mileage: 70,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE FRAME WAS SEVERELY RUSTED AND CORRODED. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000 AND THE CURRENT MILEAGE WAS 67,000.

Mileage: 60,000

2004 TOYOTA 4 RUNNER. CONSUMER WRITES IN REGARDS TO NATIONAL SAFETY RECALL COMPLAINT *TGW THE CONSUMER STATED THE DEALER WANTED HIM TO SIGN AN ARBITRATION AGREEMENT AS A CONDITION TO ADDRESS THE RECALL. THE CONSUMER STATED HE SIGNED THE AGREEMENT, BUT HE ALSO WROTE IT WAS UNDER PROTEST/DURESS. *JB

TL* THE CONTACT OWNS A 2004 TOYOTA 4-RUNNER. THE CONTACT WAS DRIVING 2 MPH UPHILL WHEN THE VEHICLE SUDDENLY ACCELERATED AND CRASHED INTO A TREE. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. THE CONTACT WAS INJURED BUT THERE WAS NO POLICE REPORT FILED. THE VEHICLE WAS INSPECTED BUT NO TECHNICIAN WAS ...

Mileage: 87,643

TOYOTA 4RUNNER, 2004, V6-SPORT EDITION DURING WARRANTY PERIOD 2009 (PURCHASED EXTENDED WARRANTY), LOW TIRE PRESSURE SENSOR LIGHT CAME ON, REPAIRED BY TOYOTA DEALERSHIP, AFTER A YEAR LIGHT RETURNED. CHECK ALL TIRES AT RECOMMENDED PRESSURE, LIGHT REMAINS ON. HAD VEHICLE SERVICED FOR RECALL ON F...

Mileage: 40,000

I WAS DRIVING MY CHILDREN TO SCHOOL AND A CAR COMING IN THE OPPOSITE DIRECTION TRIED TO MAKE A LEFT HAND TURN IN FRONT OF ME, SHE DID NOT HAVE TIME TO MAKE THE TURN( I DIDN'T EVEN HAVE TIME TO PUT ON BRAKES) WHICH ENDED UP IN A HEAD ON COLLISION. I WAS GOING AROUND 45MPH AND MY AIRBAG DID NOT DEPLOY...

Mileage: 168,000

2004 TOYOTA 4 RUNNER. CONSUMER STATES PROBLEM WITH THE TIRE PRESSURE SENSOR *TGW THE CONSUMER STATED AFTER HE LEFT THE DEALER, THE TAC LIGHT AND ANOTHER TROUBLE LIGHT ILLUMINATED ON THE DASHBOARD.

2004 TOYOTA 4 RUNNER. CONSUMER STATES PROBLEM WITH THE TIRE PRESSURE SENSOR *TGW THE CONSUMER STATED AFTER HE LEFT THE DEALER, THE TAC LIGHT AND ANOTHER TROUBLE LIGHT ILLUMINATED ON THE DASHBOARD.

I LEASED A 2004 TOYOTA 4 RUNNER IN 2004 FOR FIVE YEARS AND TURNED THE VEHICLE BACK INTO TOYOTA IN 2009. DURING THE TIME I HAD THE VEHICLE, THE ACCELERATOR BECAME STUCK ON THE FREEWAY WHICH RESULTED IN MY ENTIRE FAMILY ALMOST BEING KILLED. FORTUNATELY, WE WERE NOT HURT, BUT OUR BRAKES WERE RUINED DUR...

Mileage: 50,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THE AIR BAG LIGHT REMAINED ILLUMINATED. THE CONTACT TOOK THE VEHICLE TO THE DEALER FOR DIAGNOSTIC TESTING AND WAS TOLD THAT THE FAILURE WAS CAUSED BY THE FRONTAL DRIVER SIDE AIR BAG SENSOR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEA...

Mileage: 67,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 40 MPH, THE CONTACT HEARD A LOUD RUMBLING NOISE. THE VEHICLE WAS PULLED OVER AND THE CONTACT NOTICED THE CALIPER ON THE FRONT DRIVER SIDE WAS LOCKED AND EXTREMELY HOT. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE TH...

Mileage: 29,000

HAD TO REPLACE RIGHT FRONT CALIPER AT 55,000 MILES AFTER IT FROZE UP AFTER NEW PADS WERE INSTALLED--IT WAS DONE BY A LOCAL GARAGE BY A FORMER TOYOTA TECH.--HAD IT CHECKED BY A TOYOTA DEALERSHIP AT 57,000 MILES AND THEY SAID IT WAS ALL GOOD--STILL DID NOT FEEL RIGHT--HAD IT CHECKED AGAIN BY TOYOTA D...

Mileage: 105,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4-RUNNER. WHILE DRIVING APPROXIMATELY 15 MPH, THE CONTACT ATTEMPTED TO ENGAGE THE 4-WHEEL DRIVE BUT IT WOULD NOT ENGAGE. THE VEHICLE WAS BROUGHT TO A STOP AND SHE THEN ATTEMPTED TO ENGAGE THE 4-WHEEL DRIVE AGAIN BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO AN AUTHORIZ...

Mileage: 112,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4-RUNNER. WHILE DRIVING APPROXIMATELY 15 MPH, THE CONTACT ATTEMPTED TO ENGAGE THE 4-WHEEL DRIVE BUT IT WOULD NOT ENGAGE. THE VEHICLE WAS BROUGHT TO A STOP AND SHE THEN ATTEMPTED TO ENGAGE THE 4-WHEEL DRIVE AGAIN BUT TO NO AVAIL. THE VEHICLE WAS TAKEN TO AN AUTHORIZ...

Mileage: 112,000

TL*THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. WHILE DRIVING APPROXIMATELY 35 MPH, THE DRIVER AND PASSENGER SIDE CURTAIN AIR BAGS SUDDENLY DEPLOYED. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACUTER WAS CONTACTED AND INFORMED THE CONTACT AN INSPECTOR WOULD INSPECT THE VEHICLE FOR THE FAILURE. THE IN...

Mileage: 75,000

WHILE DRIVING I NOTICED THAT MY FRONT ABS WOULD NOT ACTIVATE IN AN EMERGENCY SITUATION. BRAKING DISTANCES BECAME A LOT LONGER. WHEN I WENT TO REPLACE MY FRONT BRAKES, I DISCOVERED THAT THE FRONT LOWER BRAKE PISTON HAD FROZEN. IT WAS THE SAME FOR BOTH SIDES. TOOK IT INTO THE SHOP, AND THEY SAID T...

Mileage: 85,000

2004 TOYOTA 4RUNNER. CONSUMER STATES THERE WAS A CLICKING NOISE COMING FROM THE STEERING WHEEL WHILE TURNING RIGHT OR LEFT *TGW THE NOISE WAS A FAINT CLICKING, INCREASING ONLY SLIGHTLY IN VOLUME OVER TIME. THE VEHICLE WAS TAKEN TO THE DEALER AND AN INSPECTION REVEALED THE INNER SHAFT SHOWED GROOVE...

THIS MORNING I STOPPED AT THE END OF MY DRIVEWAY TO WAIT FOR THE GARAGE DOOR TO GO UP. I STEPPED ON THE BRAKE AND STOPPED. AFTER I WAS STOPPED MY 4RUNNER ACCELERATED HARD AND I HAD TO USE BOTH FEET ON THE BRAKE TO HOLD IT. I SHIFTED IN TO NEUTRAL AND THE ENGINE CONTINUED TO RACE. IT EVENTUALLY STOPP...

Mileage: 72,564

TL*THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE THE VEHICLE WAS PARKED HE NOTICED THAT 85% OF THE FRONT PASSENGER SEAT BELT WAS TORN. HE ORDERED A SEAT BELT FROM A COMPANY OTHER THAN THE DEALER AND IT WAS INSTALLED BY A CERTIFIED TOYOTA TECHNICIAN. FOUR DAYS LATER, 90% OF THAT SEAT BELT WAS TORN. ...

Mileage: 71,800

TOOK MY 4RUNNER TO BE SERVICED AND I WAS TOLD THAT BOTH FRONT BRAKE CALIPERS HAD FROZEN PISTONS. BECAUSE ONLY ONE PISTON WORKED, THEY DAMAGED THE ROTORS AND WORN OUT THE PADS UNEVENLY. THIS IS A CAR THAT ALWAYS SERVICED BY DEALER ACCORDING TO TOYOTA SPECIFICATIONS WITH 67K MILES. THE JOB REPAIR COST...

Mileage: 67,000

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT WHILE DRIVING 25 MPH AND ATTEMPTING A LEFT TURN, THE VEHICLE CRASHED HEAD ON INTO ANOTHER VEHICLE. THE AIR BAGS DID NOT DEPLOY. THE CONTACT SUSTAINED INJURIES TO THE CHEST AND KNEE. A PASSENGER WAS ALSO REPORTED INJURED. THE VEHICL...

Mileage: 62,000

I HAVE A 2004 TOYOTA 4RUNNER SPORTS EDITION. I ALWAYS HEAR RATTLING NOISE WHEN I AM DRIVING 40 MPH. RECENTLY, I TOOK MY CAR TO TOYOTA TO HAVE THIS ISSUE SERVICED. THEY SAID IT WAS THE TRANSFER CASE. I WAS GOING DRIVE IT OUT OF STATE WITH MY WIFE FOR OUR ANNIVERSARY, BUT THEY RECOMMENDED I NOT TO DRI...

Mileage: 83,600

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT WAS DRIVING 30 MPH WHEN THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY WHERE THE VEHICLE WAS DIAGNOSED AND THE MECHANIC LOCATED THE FAILURE AT THE FUEL PUMP. THE FUEL PUMP WAS FRACTURED AND HAD METAL PIECE...

Mileage: 62,000

TL * THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. SHE TOOK THE VEHICLE IN FOR INSPECTION ON HER BRAKES AND THE DEALER FOUND THAT THE FRONT CALIPERS WERE RUSTED.THE DEALER REPLACED BOTH FRONT CALIPERS, WHICH COST THE CONTACT $1116. THE MANUFACTURER WAS CONTACTED BUT THEY DID NOT OFFER ANY ASSISTANCE.THE ...

Mileage: 42,364

2004 TOYOTA 4-RUNNER DASH CRACKING ABOVE GLOVE BOX/ AIR BAG IN TWO PLACES. GETTING LARGER DAILY. *TR

Mileage: 84,000

2004 TOYOTA 4RUNNER BRAKE CALIPERS SEEM TO SEIZE AT 10K MILES. THE BOOTS ON THE PISTONS HOLD WATER, AND DURING WINTER GATHER SIGNIFICANT CORROSION FROM ROAD SALT. TOYOTA REPLACES WITH THE SAME PART, BUT THESE FAIL IN THE SAME MANNER. *TR

Mileage: 10,000

BOTH SUNVISORS HAVE FAILED, THEY DO NOT STAY UP OR ALL THE WAY DOWN ,THEY MUST BE HELD UP WITH VELCRO STRAPS. *TR

Mileage: 75,000

2004 TOY 4RUNNER. DRIVERS SIDE SUN VISOR IS LOOSE AND "DROPS" INTO THE DRIVERS FILED OF VIEW, ESPECIALLY FOR A TALL DRIVER LIKE ME... LEANING FORWARD WILL ALLOW THE DRIVER TO HIT HEAD AGAINST IT. THIS STARTED A LITTLE WHILE AGO, AND IS NOW JUST ONGOING. *TR

BRAKE PEDAL SPONGY, NOT STOPPING LIKE IT SHOULD ( EXTENDED STOPPING RANGE) UNEVEN BRAKE PAD WEAR SMELL OF HOT BRAKES WHEN USED HARD. *TR

Mileage: 79,664

2004 TOYOTA 4RUNNER SR5, WITH JUST UNDER 74K MILES ON IT, HAS A FRAME WITH SEVERE CORROSION, AND MORE IMPORTANTLY THE FRONT CALIPERS HAD TO BE REPLACED DUE A CEASED LOWER PISTON. I'VE TALKED TO THE DEALER ABOUT ALL OF THESE ISSUES, BUT THEY CAN'T DO ANYTHING FOR ME. I GOT THE SAME STORY FROM THE T...

Mileage: 73,989

I WAS DRIVING ON THE FREEWAY AT 60 MPH AND TAPPED ON THE GAS PEDAL AND IT BECAME STUCK AND RAPIDLY ACCELERATED THE CAR. I HAD TO SHIFT THE CAR TO NEUTRAL AND TAP THE BRAKES IN ORDER TO GET THE GAS PEDAL UNSTUCK. THE CAR HAD BEEN ON CRUISE CONTROL EARLIER BUT AT THE TIME THAT THE GAS PEDAL WAS STUCK ...

Mileage: 107,000

TL*THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING AT APPROXIMATELY 50 MPH, THE CONTACT APPLIED THE BRAKES BUT THE VEHICLE SURGED FORWARD. THE CONTACT DEPRESSED THE BRAKE PEDAL AGAIN BUT THE VEHICLE WOULD NOT STOP. HE WAS ABLE TO PULL OVER AND TURN THE VEHICLE OFF. UPON RESTART, THE ENGINE REV...

Mileage: 78,500

TOYOTA 4RUNNER 2004 DASH CRACKED. *TR

Mileage: 70,000

FROZEN PISTONS ON INSIDE FRONT BRAKE CALIPERS. *TR

Mileage: 32,000

I HAVE A 2004 TOYOTA 4RUNNER SR5 V6. I HAVE A CONSTANT ISSUE WITH PISTONS ON THE FRONT BRAKE CALIPER SEIZING. THIS LOWERS THE EFFECTIVENESS OF THE BRAKE SYSTEM, AND CAUSES UNEVEN WEAR ON THE BRAKE PADS. I HAVE BEEN ABLE TO DISLODGE THE PISTON USING A C-CLAMP AND FIND THAT I HAVE TO REPLACE THE B...

I HAVE A 2004 TOYOTA 4 RUNNER AND I TOOK IT IN WHEN IT WAS NEW FOR THE FRONT DRIVER SEAT. WHERE THE SEAT CONNECTS TO THE BACK WHEN YOU STOP OR START THE HINGE OR TRACK HAS CONSIDERABLE PLAY IN IT AND YOU FEEL A CLUNK EVERY TIME. THEY REPLACED THE SEAT BUT THE PROBLEM CAME BACK. I REPEATEDLY ASK TOY...

Mileage: 5,000

DRIVING INTO A PARKING GARAGE IN MY TOYOTA 4RUNNER I WAS PRESSING ON THE THE BRAKE AS I WAS PULLING INTO A SPACE WHEN ALL OF A SUDDEN MY CAR LURCHED FORWARD AND SLAMMED INTO THE WALL. I THOUGHT I HAD BEEN HIT FROM BEHIND, BUT THAT WAS NOT THE CASE. WITHIN THE WEEK I WAS PULLING INTO MY SISTER'S DRI...

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I AM AN ORIGINAL OWNER OF A 2004 TOYOTA 4RUNNER, SPORT EDITION. TWO SAFETY ISSUES: 1) DURING THE FALL OF 2009 ON THE WAY BACK FROM FRANKLIN VA, I EXPERIENCE A CONTINUOUS ACCELERATION AFTER MY FOOT WAS R...

INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6) I AM AN ORIGINAL OWNER OF A 2004 TOYOTA 4RUNNER, SPORT EDITION. TWO SAFETY ISSUES: 1) DURING THE FALL OF 2009 ON THE WAY BACK FROM FRANKLIN VA, I EXPERIENCE A CONTINUOUS ACCELERATION AFTER MY FOOT WAS R...

I HAVE A 2004 TOYOTA 4 RUNNER, WHICH I BELIEVE IS NOT SUBJECT TO A RECALL, AND ON THREE OCCASIONS THE ACCELERATOR HAS BECOME STUCK. EACH TIME IT OCCURRED WHEN I ACCELERATED MORE THAN NORMAL, AND EACH TIME ONCE MY FOOT WENT OFF THE PEDAL THE CAR KEPT ACCELERATING. EACH TIME I WAS ABLE TO STOP IT BY...

Mileage: 65,000

TL*THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING 55 MPH ON A HIGHWAY WITHOUT HIS FOOT ON THE ACCELERATOR PEDAL, AND MAKING A RIGHT TURN BUT THE VEHICLE KEEPS GOING AT ABOUT THE SAME SPEED. CONTACT STATES THAT HE HAS TO BRAKE VERY HARD TO GET THE CAR TO SLOW DOWN TO MAKE THE TURN. FAILURE MI...

Mileage: 71,000

I HAVE PURCHASED IT. I HAVE BEEN TOLD THAT THERE ARE NOT ANY RECALLS OR TBS'S ON THE 4RUNNER FOR THAT PROBLEM. TODAY(2/24/10) I FIND ONLINE A TBS FOR THE PROBLEM THAT I HAVE. I CALLED A DEALER AND HE SAID THAT SINCE I HAVE OVER 80K ON THE TRUCK, THAT I WOULD HAVE TO PAY FOR IT. THIS IS NOT FAIR AND ...

Mileage: 28,000

WHEN COMING TO A STOP MY 4RUNNER WILL MAKE A CLUNK NOISE AS IF I WAS REAR ENDED. IT HAS DONE THIS SINCE I HAVE OWNED THE TRUNK. TAKING IT TO DEALER, THEY SAID THAT IT IS NORMAL, JUST THE TRANSMISSION IS DOWNSHIFTING. *TR

Mileage: 28,000

I HAVE A 2004 TOYOTA 4-RUNNER. ABOUT 2 YEARS AGO AS I WAS DRIVING DOWN A LOCAL HIGHWAY AT ABOUT 45 MPH, MY 4-RUNNER SUDDENLY TOOK OFF AS IF THE CRUISE CONTROL ENGAGED. HOWEVER, THE CRUISE CONTROL WAS NOT ON. THIS IS THE ONE & ONLY TIME THIS HAPPENED. I FEEL LIKE THIS INCIDENT SHOULD BE NOTED SI...

Mileage: 600,000

MY 2004 TOYOTA 4 RUNNER SKIDDED IN STOP LIGHT WHEN THERE WAS LITTLE ICE ON STREET. WHEN I TRIED TO ACCELERATE THE CAR AFTER STOPPING A STOP LIGHT, THE VEHICLE MAKES HUMMING NOISE AND SKID MAKING IT OUT OF CONTROL. IN WINTER 2009, SIMILAR INCIDENT HAPPENED ON I-69 (20 MILES EAST OF FLINT, MI), WH...

Mileage: 52,360

SUDDEN ACCELERATION , WHERE THE BRAKES HAVE TO BE APPLIED TO STOP VEHICLE. THIS HAS HAPPENED NUMEROUS TIMES SINCE VEHICLE WAS PURCHASED NEW IN 2004. *TR

Mileage: 20,000

SUDDEN ACCELERATION , WHERE THE BRAKES HAVE TO BE APPLIED TO STOP VEHICLE. THIS HAS HAPPENED NUMEROUS TIMES SINCE VEHICLE WAS PURCHASED NEW IN 2004. *TR

Mileage: 20,000

FOUR MONTHS AGO I PURCHASED A 2004 TOYOTA 4RUNNER LIMITED WITH APPROX. 82,000 MILES. A MONTH OR SO LATER, I APPROACHED A STOP SIGN AND AS I BRAKED, THE VEHICLE SUDDENLY ACCELERATED. I STEPPED AS HARD AS I COULD ON THE BRAKE AND FORTUNATELY, THE VEHICLE STOPPED. AT THE TIME, I WAS SCARED BUT THOUG...

Mileage: 83,000

FRONT DRIVER SIDE DOOR WILL NOT UNLOCK WITH REMOTE, KEY, INSIDE LATCH, ETC. DOOR WILL MAKE SOUNDS WHEN ELECTRICAL LOCKS ARE PUSHED, SO IT IS NOT LIKELY THE ACTUATOR (WHICH HAS ALSO BEEN A PROBLEM IN THIS MAKE AND MODEL). INTERNET RESEARCH HAS SHOWN THAT THERE IS A COMPONENT WITHIN THE LATCH, A SPRIN...

I HAVE A 2004 TOYOTA 4 RUNNER LIMITED. GAS PEDAL WENT TO THE FLOOR, 0800 HRS, 1/26/2010. WITH ENGINE ROARING, I HAD TO FIRMLY PUT ON BRAKE AND HIT THE PEDAL SEVERAL TIMES, BEFORE IT RELEASED. I ALMOST WENT THRU AN INTERSECTION. TOOK TO TOYOTA DEALER SAME WEEK. THEY SAID IT HAS AN ELECTRONIC GAS P...

Mileage: 40,649

TL* THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING APPROXIMATELY 5 MPH INTO A PARKING SPACE WITH HER FOOT ON THE BRAKE PEDAL, THE VEHICLE ACCELERATED ON ITS OWN WITHOUT WARNING. SHE APPLIED EXTREME PRESSURE TO THE BRAKE PEDAL; HOWEVER, THE VEHICLE FAILED TO STOP AND CRASHED INTO ANOTHER VEHIC...

Mileage: 40,400

I OWN A 2004 TOYOTA 4RUNNER. DUE TO POOR DESIGN DRIVERS SEAT FRAME HAS COLLAPSED. THIS IS A VERY COMMON PROBLEM FOR 2003-2005 4RUNNERS ACCORDING TO MY LOCAL TOYOTA DEALER. SO MUCH SO THAT TOYOTA HAS SEVERAL SERVICE BULLETINS ISSUED REGARDING THE MATTER. I HAD BEEN DRIVING WITH IT BROKEN FOR SEVERAL...

Mileage: 63,000

WHILE DRIVING IN CRUISE CONTROL, AND FOOT COMPLETELY OFF OF THE GAS PEDAL. THE CAR WILL SUDDENLY SURGE AHEAD IN WHAT FEELS LIKE GOING INTO PASSING GEAR. IT DOES THIS AT VARIOUS TIMES. AND WITHOUT ANY WARNING. SLAMMING ON THE BRAKE SEEMS TO STOP IT. *TR

Mileage: 45,000

TL*THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. WHILE DRIVING APPROXIMATELY 15 MPH ON NORMAL ROAD CONDITIONS; PROCEEDING TO A STOP SIGNAL PRESSURE WAS APPLIED TO THE BRAKE PEDAL, FOLLOWED BY AN UNINTENDED AND FORCEFUL ACCELERATION. THE DRIVER WAS ABLE TO COME TO A COMPLETE STOP. THE FAILURE OCCURRED I...

Mileage: 50,000

THIS INCIDENT WAS 1ST NOTICED 12/9/2009. I STARTED MY CAR IN THE MORNING AND LET IT WARM UP, WHEN I WENT TO GET IN IT A FEW MINUTES LATER, THE HEATER FAN WOULD NOT WORK. SINCE THEN, I FIND THAT THE HEATER FAN WILL WORK OFF AND ON, SEEMS TO BE AFTER VEHICLE HAS WARMED UP A BIT -MAYBE (NOT SURE OF ...

Mileage: 48,000

I HAVE A 2004 4 RUNNER I RECENTLY HAVE HAD A STEERING VIBRATION THAT IS MAKING ME CRAZY IT FLUTTERS AROUND 55 TO 65 I HAVE GONE TO DIFFERENT DEALERS AND INDEPENDENT SHOPS PLUS I HAVE DONE LOTS OF TESTING WITH NO LUCK ON A PERMANENT FIX I HAVE RESEARCHED THE INTERNET FOR 6 MONTHS SINCE THE PROBLEM RE...

Mileage: 65,237

I HAVE A 2004 TOY 4-RUNNER, V-8 ALL WHEEL DRIVE THAT I AM GENERALLY SATISFIED WITH, BUT THERE IS ONE ISSUE THAT IS FRIGHTENING. WHEN I COME TO AN ABRUPT STOP THERE IS A FORWARD LUNGE THAT FEELS LIKE I HAVE BEEN HIT FROM BEHIND. THE VEHICLE LUNGES FORWARD THE BRAKES DO NOT ALWAYS CONTAIN THIS FORWARD...

Mileage: 35,000

WARNING LIGHTS BEGAN COMING ON AROUND 60,000 MILES OR SO. STARTED WITH THE LOW TIRE PRESSURE LIGHT & NOW HAS PROGRESSED TO THE VSC ON, VSC OFF, ABS WARNING LIGHTS BEING ON ALL THE TIME AND THE LOW TIRE PRESSURE LIGHT IS STILL ON. I HAVE TAKEN THIS VEHICLE INTO 2 DIFFERENT DEALERS TO BE FIXED FOR 4...

Mileage: 60,000

WARNING LIGHTS BEGAN COMING ON AROUND 60,000 MILES OR SO. STARTED WITH THE LOW TIRE PRESSURE LIGHT & NOW HAS PROGRESSED TO THE VSC ON, VSC OFF, ABS WARNING LIGHTS BEING ON ALL THE TIME AND THE LOW TIRE PRESSURE LIGHT IS STILL ON. I HAVE TAKEN THIS VEHICLE INTO 2 DIFFERENT DEALERS TO BE FIXED FOR 4...

Mileage: 60,000

WARNING LIGHTS BEGAN COMING ON AROUND 60,000 MILES OR SO. STARTED WITH THE LOW TIRE PRESSURE LIGHT & NOW HAS PROGRESSED TO THE VSC ON, VSC OFF, ABS WARNING LIGHTS BEING ON ALL THE TIME AND THE LOW TIRE PRESSURE LIGHT IS STILL ON. I HAVE TAKEN THIS VEHICLE INTO 2 DIFFERENT DEALERS TO BE FIXED FOR 4...

Mileage: 60,000

VEHICLE CRASH AND AIRBAGS FAILED TO DEPLOY. *TR

Mileage: 73,000

I HAVE A 2004 TOYOTA 4RUNNER AND A FEW MONTHS AGO THE ACCELERATOR PEDAL GOT STUCK UNDER THE RUBBER FLOOR MAT. I PURCHASED THE RUBBER FLOOR MAT FROM A TOYOTA DEALER AND IT WAS MADE SPECIFICALLY FOR THE 4 RUNNER. WHEN THE PEDAL GOT STUCK, THE ENGINE WAS RUNNING WIDE OPEN. I MANAGED TO GET THE VEHI...

Mileage: 78,000

I HAVE A 2004 TOYOTA 4RUNNER AND A FEW MONTHS AGO THE ACCELERATOR PEDAL GOT STUCK UNDER THE RUBBER FLOOR MAT. I PURCHASED THE RUBBER FLOOR MAT FROM A TOYOTA DEALER AND IT WAS MADE SPECIFICALLY FOR THE 4 RUNNER. WHEN THE PEDAL GOT STUCK, THE ENGINE WAS RUNNING WIDE OPEN. I MANAGED TO GET THE VEHI...

Mileage: 78,000

I WAS DRIVING AT ABOUT 35MPH AND HAD TO START BRAKING FOR A VEHICLE THAT WAS SIGNALING A LEFT TURN. I NOTICE THE BRAKES DID NOT FEEL NORMAL AND THAT THE PADS WERE NOT CATCHING ON THE ROTORS. SO I JAMMED ON THE BRAKES AS HARD AND AS FAR AS THEY COULD GO AND AVOIDED HITTING THE OTHER VEHICLE BY INCH...

Mileage: 66,000

I HAVE A 2004 TOYOTA 4 RUNNER THAT HAS A PROBLEM WITH ITS REAR WIPER BLADE NOT WORKING AND REAR DEFROST. I HAD TO BRING IT IN FOR THEM TO RESET IT AFTER THE RESET IT WORKED FOR ABOUT A WEEK THEN STOPPED WORKING AGAIN. I WAS TOLD THAT THERE'S A GLITCH IN THE WIPER AND REAR DEFROST COMPUTER THAT NEEDS...

Mileage: 75,000

I HAVE A 2004 TOYOTA 4 RUNNER THAT HAS A PROBLEM WITH ITS REAR WIPER BLADE NOT WORKING AND REAR DEFROST. I HAD TO BRING IT IN FOR THEM TO RESET IT AFTER THE RESET IT WORKED FOR ABOUT A WEEK THEN STOPPED WORKING AGAIN. I WAS TOLD THAT THERE'S A GLITCH IN THE WIPER AND REAR DEFROST COMPUTER THAT NEEDS...

Mileage: 75,000

I HAVE A PROBLEM WITH A DASH OF 4RUNNER 2004 IS CRACKED SLOWLY UNTIL YOU ARE FULL. TOYOTA TO REPORT ON THE PROBLEM THAT SAID NO RECALL. AND VALE $ 840.00. ALL THE BUS DYED THE SAME PROBLEM. *TR

Mileage: 48,000

TL*THE CONTACT OWNS A 2004 TOYOTA 4 RUNNER. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A STATE INSPECTION. THE TECHNICIAN OBSERVED FRAME PERFORATION DUE TO SEVERE RUST CORROSION. AS A RESULT, THE VEHICLE FAILED INSPECTION BECAUSE OF THE FRAME. THERE WERE NO WARNINGS PRIOR TO THE FAILURE. ...

Mileage: 61,980

AFTER ABOUT 12MONTHS OF NORMAL/ TYPICAL USE, THE SUN VISOR (ON THE DRIVER SIDE) WILL NO LONGER STAY UP; IT CONSTANTLY DROPS. THIS IS A HUGE DISTRACTION AND OBSTRUCTS THE FIELD OF VIEW. *TR

Mileage: 15,000

FRONT END COLLISION WITH SEMI WHERE AIR BAGS FAILED TO DEPLOY. HE SAID/SHE SAID SITUATION. TRUCKER STATED HE WAS BROADSIDED BY DRIVER WHO RAN RED LIGHT. TOYOTA DRIVER STATES TRUCK "JACK KNIFED" OR SWERVED INTO HER CAR AS HE WAS CHANGING LANES IN INTERSECTION. TRUCK HAS A FLAT REAR TIRE ON SECON...

Mileage: 51,000

THE MOON ROOF WOULD NOT RETURN TO ORIGINAL POSITION, HAD TO BUY A REPAIR KIT FROM TOYOTA, THEY KNOW OF THIS PROBLEM BUT WOULD NOT FIX IT. HAD TO BRING REPAIR KIT TO A LOCAL BODY SHOP. TOYOTA KNOWS OF THIS PROBLEM, BUT DOES NOT THINK IT DANGEROUS ENOUGH TO FIX AT THEIR COST. LAID OUT 225.00 TO FIX...

Mileage: 89,500

TL*THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING 35 MPH, THE CONTACT LOST CONSCIOUSNESS AND CRASHED INTO A FENCE. THE FRONTAL AIR BAGS FAILED TO DEPLOY. THE CONTACT WAS INJURED AND SUSTAINED A BROKEN NECK. A POLICE REPORT WAS FILED. THE VEHICLE WAS INSPECTED BY THE INSURANCE ADJUSTER, W...

Mileage: 66,000

TL*THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE BLOWER MOTOR THAT PRODUCES THE HEAT IS FROZEN. WHILE DRIVING VARIOUS SPEEDS, HE CANNOT DEFROST THE WINDOW. THE DEALER STATED THAT THERE WAS A SAFETY BULLETIN FOR THIS FAILURE, BUT THE CONTACT WOULD HAVE TO PAY $600 FOR THE REP...

Mileage: 45,000

DIRT ROAD, MODERATE BRAKING, SLIGHT SKID, ABS/TRAC/VSC LIGHTS ILLUMINATED, SECOND TIME HAPPENED. RESET THE FIRST TIME MANUALLY BY TRICKING COMPUTER TO RESET. SECOND TIME, NO GO. VSC/ABS/TRAC COMPUTER MAY BE BAD. *TR

Mileage: 47,000

DIRT ROAD, MODERATE BRAKING, SLIGHT SKID, ABS/TRAC/VSC LIGHTS ILLUMINATED, SECOND TIME HAPPENED. RESET THE FIRST TIME MANUALLY BY TRICKING COMPUTER TO RESET. SECOND TIME, NO GO. VSC/ABS/TRAC COMPUTER MAY BE BAD. *TR

Mileage: 47,000

SEAT BELTS IN REAR OF TWO TOYOTA VEHICLES FAILED TO ENGAGE LATCH. THIS OCCURRED IN BOTH THE 2004 TOYOTA COROLLA AND THE 2004 TOYOTA 4-RUNNER. THIS IS A SAFETY CONCERN AS THE PASSENGER IS FORCED TO RIDE UNSECURED IN THE VEHICLE. THIS ALSO FACE THE DRIVER TO VIOLATE STATE LAW. I FIND IT IRONIC THA...

Mileage: 63,000

CHK ENGINE LIGHT,VSCTRAC LIGHT,TRAC OFF LIGHT ALL CAME ON WHILE DRIVING DOWN THE ROAD. TOOK TO DEALER,FOUND GAS CAP OFF,CHK LIGHT THEN WENT OUT BUT OTHERS DID NOT. DEALER SAID ALL IS OK VSC TRAC AND TRAC OFF WILL GO OUT AFTER A FEW DRIVING CYCLES. THEY HAVE NOT YET. THIS IS11/19/2008. WHILE LIGHTS A...

Mileage: 5,740

WHILE DRIVING, NOTICED THAT THE VEHICLE DECELERATED QUICKLY WHEN LETTING OFF THE ACCELERATOR. RETURNED HOME AND AFTER EXITING THE VEHICLE FOUND FLAMES IN THE AREA OF THE LEFT, FRONT WHEEL. THE BRAKE ROTORS ON BOTH LEFT AND RIGHT FRONT WERE GLOWING RED HOT. ROOT CAUSE WAS FOUND TO BE A YAW RATE SE...

Mileage: 85,000

WHILE DRIVING, NOTICED THAT THE VEHICLE DECELERATED QUICKLY WHEN LETTING OFF THE ACCELERATOR. RETURNED HOME AND AFTER EXITING THE VEHICLE FOUND FLAMES IN THE AREA OF THE LEFT, FRONT WHEEL. THE BRAKE ROTORS ON BOTH LEFT AND RIGHT FRONT WERE GLOWING RED HOT. ROOT CAUSE WAS FOUND TO BE A YAW RATE SE...

Mileage: 85,000

MALFUNCTION IN THE CENTER AIRBAG SENSOR ASSEMBLY IN MY VEHICLE HAS RENDERED THE AIRBAGS INOPERABLE. SENSOR LIGHT CAME ON TWO WEEKS AGO. TOYOTA SERVICE GARAGE SAID IT WOULD COST $545 TO REPAIR. NO REPAIR TO DATE. TOYOTA INDICATED THAT IT WAS ONLY COVERED BY 3-YEAR WARRANTY. *TR

Mileage: 118,500

-HATCHBACK ELECTRONIC CLOSURE FAILS FOR THE SECOND TIME WITHIN A ONE YEAR PERIOD -REPLACED MOTOR ONCE BECAUSE VEHICLE DOES NOT OPERATE WITHOUT--EXHAUST FUMES COME THROUGH THE HATCHBACK, UNABLE TO LOCK VEHICLE, LIGHTS DON'T AUTOMATICALLY SHUT OFF, WATER DURING RAIN OR SNOW GETS INSIDE VEHICLE, ETC ...

-HATCHBACK ELECTRONIC CLOSURE FAILS FOR THE SECOND TIME WITHIN A ONE YEAR PERIOD -REPLACED MOTOR ONCE BECAUSE VEHICLE DOES NOT OPERATE WITHOUT--EXHAUST FUMES COME THROUGH THE HATCHBACK, UNABLE TO LOCK VEHICLE, LIGHTS DON'T AUTOMATICALLY SHUT OFF, WATER DURING RAIN OR SNOW GETS INSIDE VEHICLE, ETC ...

DRIVERS SEAT MOVES WHILE DRIVING, WHEN SLOWING DOWN OR TURNING. IT SOUNDS LIKE A CLICKING NOISE AND FEELS LIKE A SHIFT FORWARD OR BACK. THIS HAS BEEN THERE SINCE PURCHASE AND DEALER HAS NO FIX. *TR

SEAT BELT HOUSING IS BROKEN, CAN'T USE BELT. DOOR LOCKS DO NOT WORK, PERSON MAY GET LOCKED IN VEHICLE IF INVOLVED IN ACCIDENT. *TR

SEAT BELT HOUSING IS BROKEN, CAN'T USE BELT. DOOR LOCKS DO NOT WORK, PERSON MAY GET LOCKED IN VEHICLE IF INVOLVED IN ACCIDENT. *TR

1. THERE IS A SERIOUS "CLUNK" NOISE WHEN TAKING MY FOOT OFF THE BRAKE FROM A STOP. 2. MY VEHICLE MAKES A LOUD NOISE WHEN STOPPED AT AN INTERSECTION COMBINED WITH A SURGING FORWARD AS IF BEING REAR ENDED. 3. WHEN APPLYING THE BRAKES, AFTER IT HAS BEEN SITTING FOR A NUMBER OF HOURS, IT SHAKES AND BA...

Mileage: 2,000

VIBRATION IS FELT IN STEERING WHEEL AT HIGHWAY SPEEDS (55 MPH OR HIGHER). THIS IS ESPECIALLY PRESENT WHEN STEERING WHEEL IS TURNED SLIGHTLY TO THE RIGHT. HAVE HAD TIRES REBALANCED WITH NO CHANGE IN VIBRATION. PROBLEM HAS BEEN WITH VEHICLE SINCE PURCHASE. TIRE REPLACEMENT AND ROTATION DOES NOT CO...

Mileage: 1,500

VIBRATION IS FELT IN STEERING WHEEL AT HIGHWAY SPEEDS (55 MPH OR HIGHER). THIS IS ESPECIALLY PRESENT WHEN STEERING WHEEL IS TURNED SLIGHTLY TO THE RIGHT. HAVE HAD TIRES REBALANCED WITH NO CHANGE IN VIBRATION. PROBLEM HAS BEEN WITH VEHICLE SINCE PURCHASE. TIRE REPLACEMENT AND ROTATION DOES NOT CO...

Mileage: 1,500

VIBRATION IS FELT IN STEERING WHEEL AT HIGHWAY SPEEDS (55 MPH OR HIGHER). THIS IS ESPECIALLY PRESENT WHEN STEERING WHEEL IS TURNED SLIGHTLY TO THE RIGHT. HAVE HAD TIRES REBALANCED WITH NO CHANGE IN VIBRATION. PROBLEM HAS BEEN WITH VEHICLE SINCE PURCHASE. TIRE REPLACEMENT AND ROTATION DOES NOT CO...

Mileage: 1,500

1.) THERE IS A SERIOUS "CLUNK" NOISE WHEN BRAKING AND ALSO THE SAME NOISE WHEN STARTING FROM A COMPLETE STOP WHEN YOU TAKE FOOT OFF BRAKE. 2.) THERE IS "SULFUR SMELL " IN CABIN FROM CATALYTIC CONVERTER. *TR

Mileage: 55,000

1.) THERE IS A SERIOUS "CLUNK" NOISE WHEN BRAKING AND ALSO THE SAME NOISE WHEN STARTING FROM A COMPLETE STOP WHEN YOU TAKE FOOT OFF BRAKE. 2.) THERE IS "SULFUR SMELL " IN CABIN FROM CATALYTIC CONVERTER. *TR

Mileage: 55,000

1.) THERE IS A SERIOUS "CLUNK" NOISE WHEN BRAKING AND ALSO THE SAME NOISE WHEN STARTING FROM A COMPLETE STOP WHEN YOU TAKE FOOT OFF BRAKE. 2.) THERE IS "SULFUR SMELL " IN CABIN FROM CATALYTIC CONVERTER. *TR

Mileage: 55,000

I HAVE A 2004 LIMITED 4RUNNER TOYOTA, ALL WHEEL DRIVE, WITH V8. AFTER ABOUT 20 THOUSAND MILES, MY VEHICLE BEGAN MAKING A VERY LOUD NOISE WHEN COMING TO A STOP, WHILE SIMULTANEOUSLY SURGING FORWARD LIKE I WAS REAR ENDED. THIS NOISE ALSO HAS A DISTINCT METALLIC SOUND AND JARRING VIBRATION EACH AND E...

Mileage: 13,000

I HAVE A 2004 LIMITED 4RUNNER TOYOTA, ALL WHEEL DRIVE, WITH V8. AFTER ABOUT 20 THOUSAND MILES, MY VEHICLE BEGAN MAKING A VERY LOUD NOISE WHEN COMING TO A STOP, WHILE SIMULTANEOUSLY SURGING FORWARD LIKE I WAS REAR ENDED. THIS NOISE ALSO HAS A DISTINCT METALLIC SOUND AND JARRING VIBRATION EACH AND E...

Mileage: 13,000

I HAVE A 2004 LIMITED 4RUNNER TOYOTA, ALL WHEEL DRIVE, WITH V8. AFTER ABOUT 20 THOUSAND MILES, MY VEHICLE BEGAN MAKING A VERY LOUD NOISE WHEN COMING TO A STOP, WHILE SIMULTANEOUSLY SURGING FORWARD LIKE I WAS REAR ENDED. THIS NOISE ALSO HAS A DISTINCT METALLIC SOUND AND JARRING VIBRATION EACH AND E...

Mileage: 13,000

THE SPEEDOMETER NEEDLE STOP WORKING RIGHT AFTER 36,000 MILES ON 2004 TOYOTA 4RUNNER LIMITED EDITION 4 WD. THE NEEDLE WILL WORK AFTER IDLE FOR 2 DAYS UNTIL ENGINE OFF. *TR

EXCESSIVE SULFUR SMELL WHEN ACCELERATING. OCCUPANTS OF THE CAR CAN SMELL THE SULFUR, AND ALL WINDOWS MUST BE ROLLED UP IN WARMER WEATHER TO BLOCK OUT SMELL. I HAVE TAKEN THE VEHICLE TO THE TOYOTA DEALERSHIP, BUT THEY WILL NOT FIX THE PROBLEM BECAUSE THERE IS NO TSB FOR THE V8 (BUT THERE IS FOR THE ...

THERE IS A DELAY AND THEN A SUDDEN AND ABRUPT ACCELERATION IN THE VEHICLE A 2004 TOYOTA SUV, VIRTUALLY EVERY TIME DURING SLOW DOWNS IN TRAFFIC AND WHEN MAKING TURNS. THIS CAUSES THE VEHICLE TO JERK AND HAS CAUSED A HOT BEVERAGE TO SPILL ON THE DRIVER, NEARLY CONTRIBUTED TO AN ACCIDENT WHEN THE VEHI...

TL*THE CONTACT OWNS A 2004 TOYOTA 4RUNNER. WHILE DRIVING ANY SPEED, THE BRAKE PEDAL AND THE VEHICLE VIBRATE AND PULSATE WHEN THE BRAKE PEDAL IS DEPRESSED. THE DEALER HAS NOT INSPECTED THE VEHICLE. THE CONTACT REPLACED THE BRAKE PADS, HOWEVER, THE PROBLEM CONTINUES TO PERSIST. THE CURRENT MILEAGE...

Mileage: 50,000

HEAD-ON COLLISION WHILE STOPPED AT LIGHT BY PANEL VAN TRAVELING AT 25 MPH, POLICE ESTIMATE, FRONT AIR BAGS FAILED TO DEPLOY. *AK

Mileage: 52,000

I EXPERIENCED A SIGNIFICANT OIL LEAK AT THE TRANSFER CASE. IT WAS DETERMINED THE "O" RING ON THE TRANSFER CASE ACTUATOR MOTOR ASSEMBLY WAS DEFECTIVE AND CAUSED THE LEAK. THE NEW "O" RING COST $10, BUT LABOR WAS $900. *JB

Mileage: 80,000

AFTER 2.5 YEARS AND ABOUT 25000 MILES, MY 4 RUNNER SPORT DEVELOPS A STRONG SULFUR ODOR INSIDE THE CABIN WHEN DRIVING. BROUGHT THE CAR TO THE DEALER (CALDWELL TOYOTA) IN WEST CALDWELL, NJ WHO INFORMED ME THE PROBLEM WAS NORMAL AND CAUSED BY THE TYPE OF FUEL USED. CALDWELL TOYOTA HAD NO ANSWER TO MY Q...

Mileage: 24,500

TL* - THE CONTACT STATED THAT ALL OF THE DOOR LOCK MODULES FAILED AND HE WAS UNABLE TO OPEN OR LOCK THE DOOR LATCH. THE DRIVER'S FRONT MODULE FAILED AT 38,000 MILES, AND THE PASSENGER'S FRONTAND REAR MODULE FAILED AT 48,000. THE CONTACT HAD THE DRIVER'S DOOR LOCK MODULE REPAIRED. THE DEALER DI...

Mileage: 39,000

DT*: THE CONTACT STATED WHILE DRIVING 20 MPH UNDER NORMAL ROAD CONDITIONS, THE FRONT RIGHT LOWER BALL JOINT SEPARATED. THERE WERE NO WARNINGS PRIOR TO THE INCIDENT. THE VEHICLE WAS TAKEN TO THE SERVICE DEALER, WHO DETERMINED THE FRONT RIGHT LOWER BALL JOINT HAD FRACTURED.

Mileage: 13,000

DT*: THE CONTACT STATED WHILE DRIVING 50 MPH, THE VEHICLE WAS INVOLVED IN A COLLISION WITH A GUARDRAIL. THERE WAS A 5 SECOND DELAY IN THE DEPLOYMENT OF THE AIR BAG, CAUSING THE CONTACT AND A PASSENGER TO HIT THE WINDSHIELD. BOTH OCCUPANTS INCURRED HEAD INJURIES, LACERATIONS, MUSCULAR INJURIES, AND...

Mileage: 78,000

TRAVELING 55 MPH ON CA INTERSTATE WHEN CAR DIRECTLY IN FRONT OF ME ABRUPTLY STOPPED. THERE WAS NOT ENOUGH TIME FOR ME TO STOP, SO I IMPACTED THE REAR OF THE VEHICLE HEAD ON AT APPROXIMATELY 45 MPH. NOT ONE OF THE AIRBAGS IN MY VEHICLE DEPLOYED. CONTACTED TOYOTA ABOUT THIS AND THEY SAID IT IS THEIR "...

Mileage: 54,000

DT*: THE CONTACT STATED WHILE DRIVING AT ANY SPEED OR EVEN PARKED WITH THE ENGINE RUNNING, THERE WAS STRONG GAS ODOR INSIDE THE CABIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT CERTIFIED MECHANIC WHO DISCOVERED RUST IN THE INJECTION SYSTEM AND A CATALYTIC CONVERTER FAILURE.

Mileage: 30,000

DT*: THE CONTACT STATED WHILE DRIVING AT ANY SPEED OR EVEN PARKED WITH THE ENGINE RUNNING, THERE WAS STRONG GAS ODOR INSIDE THE CABIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT CERTIFIED MECHANIC WHO DISCOVERED RUST IN THE INJECTION SYSTEM AND A CATALYTIC CONVERTER FAILURE.

Mileage: 30,000