2009 TOYOTA COROLLA MATRIX Engine Problems

Subject: Request to Consider Recall for 2009 Toyota Matrix Excessive Oil Consumption Dear Toyota Motor Corporation/NHTSA, I am writing to bring to your attention a persistent issue with my 2009 Toyota Matrix, which has been experiencing excessive oil consumption. Despite regular maintenance and oil changes, the vehicle continues to burn through oil at an alarming rate, posing potential environmental and safety hazards. After researching this issue, I found that numerous 2009 Toyota Matrix owners have reported similar problems, suggesting a possible design or manufacturing flaw. I believe it is essential for Toyota to acknowledge this issue and take corrective action to ensure the safety and well-being of drivers and the environment. I respectfully request that you consider adding excessive oil consumption to the list of recalls for the 2009 Toyota Matrix. I would appreciate it if you could look into this matter and take necessary steps to address this issue. Please find below the details of my vehicle: - Year: 2009 - Make: Toyota - Model: Matrix - Mileage: 92000 - Engine: 2.4L 2AZ-FE Thank you for your attention to this matter. I look forward to hearing from you soon.

WHILE DRIVING HOME MY CAR STARTED BURNING. I PULLED OVER WITH SMOKE POURING OUT OF THE ENGINE AREA AND THE CAR JUST STOPPED. I OPENED THE HOOD AND THERE WERE FLAMES COMING UP FROM BEHIND THE ENGINE. THE FIRE GREW UNTIL IT ENGULFED THE FRONT OF THE CAR. THE FIRE DEPARTMENT CAME AND PUT OUT THE FIRE. THE 2009 MATRIX WAS TOTALLY DESTROYED. I NOTICED NO PRIOR WARNING SIGNS OR SYMPTOMS.

Mileage: 160,000

MY VEHICLE IS GOING THROUGH SEVERAL QUARTS OF OIL WITHIN THE 3,000 MILE RANGE. EXCESSIVE OIL CONSUMPTION.

Mileage: 110,000

VEHICLE HAS STALLED SEVERAL TIMES. ALL INSTANCES THE VEHICLE STALLS WHILE DRIVING. PROBLEM IS RANDOM AND NON-REPEATABLE. I HAVE HAD THE VEHICLE STALL WHILE AT VARIOUS SPEEDS RANGING FROM 15 MPH TO 55+ MPH (ON HIGHWAYS OR EVEN LOCAL ROADS). MOST RECENT STALL WAS 09/17/2018. MAKING A RIGHT HAND TURN, VEHICLE STALLED. TURNED THE IGNITION OFF, WENT TO TURN BACK ON, STALLED AGAIN. TURNED OFF, WAITED FOR A MOMENT, STARTED THE MOTOR AND VEHICLE RAN WITHOUT ANY FURTHER ISSUES FOR THE REMAINDER OF THE DAY. IN DOING READING, I SEE THE ENGINE CONTROL MODAL HAS BEEN RECALLED FOR THE TOYOTA MATRIX UP TO AND INCLUDING 2008 MODELS. I BELIEVE THE RECALL SHOULD BE EXTENDED TO 2009 MODELS. I HAVE ALSO DONE SOME READING THAT THERE WAS OVERLAP BETWEEN PRODUCTION YEARS OF 2008/2009 WHERE PARTS WERE USED FROM THE 2008 MODELS IN THE 2009 MODELS WHICH FURTHERS MY EMPHASIS TO EXPAND THE RECALL.

Mileage: 114,000

I AM THE ORIGINAL OWNER AND THE CAR HAS BEEN USING OIL LIKE CRAZY. I REPLACE ALL 5 QTS OF OIL AT LEAST 1.5 TIMES BETWEEN OIL CHANGES. I HAVE BEEN TOLD THAT OTHER THAN AN ENGINE REBUILD I AM PRETTY MUCH OUT OF LUCK. THE CAR NOW HAS APPOX 185K MILES. THE USE OF OIL HAS BEEN AN ISSUE SINCE AROUND 75K. I HAVE DONE A LITTLE RESEARCH AND SAW A SERVICE BULLETIN, BUT BY THE TIME IT WAS ISSUED MY CAR WAS OUTSIDE OF THE MILEAGE RANGE IT COVERED.

I'M VERY DISAPPOINTED WITH TOYOTA. MY VEHICLE RUNS OUT OF OIL. PERIOD BEFORE 3,000 MILES. NO "RED" OIL LIGHT. IT JUST RUNS OUT OF OIL. I TOOK IT FOR TOYOTA OIL CONSUMPTION TEST AND IT PASSED. SO I GO FOR A SECOND TEST. NO. THE 10 YEAR 150,000 EXTENDED WARRANTY IS EXPIRED. SO I AM NOW STUCK PUTTING OIL IN THIS VEHICLE WEEKLY UNTIL IT ULTIMATELY FAILS. IT RUNS ROUGH AND I EXPECT IT TO FAIL. SHAME ON NTSB AND TOYOTA FOR NOT RECALLING THIS MOTOR. I GET A 10 YEAR WARRANTY THAT STARTS WHEN THE VEHICLE IS FIRST USED - NOT WHEN I'M NOTIFIED. VERY SHADY AND UNETHICAL. I ALSO HAVE RESERVATIONS THAT THE TEST WAS PROPERLY IMPLEMENTED.

I STARTED NOTICING A KNOCKING IN MY ENGINE. I REPORTED IT TO THE TOYOTA SERVICE DEPARTMENT ON 9-9-14. I WAS TOLD BY THE TOYOTA SERVICE DEPARTMENT( THE ONE THAT HAS DONE ALL OF MY SCHEDULED MAINTENANCE) " NO ABNORMAL SOUNDS HEARD AT THIS TIME." IN HIND SIGHT MAYBE THEY DIDN'T HEAR THE NOISE BECAUSE SHE WAS LOW ON OIL AND ONLY LISTEND FOR THE NOISE AFTER THE OIL CHANGE. I WAS NEVER TOLD THAT I SHOULD CHECK MY OIL FOR LEAKAGE IN BETWEEN MY SCHEDULED MAINTENANCE! I CHECKED MY OIL ONE DAY AT RANDOM AFTER I HEARD KNOCKING AGAIN AND SHE WAS VERY LOW ON OIL. I TOOK HER TO TOYOTA AND TOLD THEM SHE WAS CONSUMING OIL. THEY SUGGESTED A FUEL INDUCTION SERVICE FOR WHICH THEY DID ON 1-12-17, WHICH DIDN'T FIX THE PROBLEM. ON 9-12-17 AT HER NEXT APPOINTMENT I REPORTED AGAIN THE OIL USAGE.OUTCOME; " PERFORMED INSPECTION, FOUND SLIGHT OIL SEEPAGE AT ENGINE OIL PAN. PCV SYSTEM IS WORKING. ENGINE MUST BE BURNING OIL. PISTONS AND RINGS WOULD NEED TO BE REPLACED." BIG SURPRISE THERE. I WAS SO NAIVE BUT I DID TAKE HER TO DIFFERENT TOYOTA SERVICE PLACE FOR A SECOND OPINION. AND YES YOU GUESSED IT ANOTHER ENGINE OIL CLEANER SERVICE. AND SUGGESTED PISTON AND RINGS REPLACED. IT WAS A MECHANIC FRIEND THAT WE TOOK HER TO THAT KINDLY DID SOME SEARCHING AND FOUND THAT TOYOTA HAD ISSUED A TSB ON AUGUST 11, 2011[1](# FN:1) TO DEALERSHIPS WHICH SAYS: " SOME 2006-2011 MODEL YEAR VEHICLES EQUIPPED WITH THE 2AZ-FE ENGINE MAY EXHIBIT ENGINE OIL CONSUMPTION. THE PISTON ASSEMBLY HAS BEEN CHANGED TO MINIMIZE OIL CONSUMPTION." AND THAT PO3O# (CYLINDER # MISFIRE DETECTED) DTC MAY ALSO BE SET AS A RESULT OF OIL CONSUPTION" OBVIOUSLY THERE WAS THERE IS A DESIGN ERROR OF THE PISTONS.

Mileage: 105,801

ENGINE BURNS OIL AT A RATE OF 1 QUART EVERY 500 MILES. MILEAGE IS ONLY 105,000

ENGIN USED 2 1/2 QUATS OF OIL BETWEEN OIL CHANGES.ENGIN ONLY HAS 71000 MILE ON IT

Mileage: 71,000

HAD A OIL CONSUMPTION RECALL THAT THE DEALER SAID IT PASSED THE TEST BECAUSE IT DID'T LOSE 1 QT OF OIL DURING A 1200 MILE TIME. WAS TOLD IT IS NORMAL FOR OIL TO DISSAPPEAR

EXCESSIVE OIL CONSUMPTION. RED OIL LIGHT COMES ON WHEN YOU TURN AND STOP VEHICLE BEFORE MANUFACTURER CHANGE INTERVAL. TOOK TO TOYOTA DEALERSHIP FOR OIL CONSUMPTION TEST AND THE VEHICLE PASSED. TOYOTA FAILS TO PROVIDE ANY TECHNICAL INFORMATION ABOUT THE TEST SUCH AS WHAT OIL TYPE USED, AMOUNTED ADDED, AMOUNT BURNED. THIS IS THE SECOND TSB REFUSED BY TOYOTA FOR THIS VEHICLE TO GET OUT OF SAFETY RECALL AND LAWSUITS. MY FIRST SAFETY COMPLAINT WAS TO GET TBS FOR LOOSE COMPUTER ASSISTED STEERING. TOYTOTA REFUSED BASED ON TIME PASSED AND MILEAGE OF VEHICLE.

MULTIPLE EPISODES OF ENGINE STALL WITHOUT WARNING. INSTRUMENT PANEL GOES BLACK AND COMPLETE LOSS OF POWER. A FEW TIMES IT SPUTTERED AND BUCKED BEFORE IT STALLED. HAVE HAD IT IN TO TOYOTA TWICE NOW. THE FIRST TIME THEY WERE ABLE TO REPLICATE THE MALFUNCTION AND SAID IT WAS A LOOSE FUSE. I PICKED UP THE CAR AND IT STALLED AGAIN WHILE DRIVING ANOTHER 4 TIMES. IN THE MIDDLE OF A BUSY INTERSECTION WITH MY TODDLER GRANDSON IN THE BACK SEAT. ANOTHER TIME I WAS COMING OUT OF A DARK TUNNEL WITH A BLIND TURN DOING APPROX 55MPH AND ONLY BY THE GRACE OF GOD DID SOMEBODY NOT PLOW INTO THE BACK OF ME. IT COULD HAVE BEEN DEADLY. THE CAR IS BACK IN THE TOYOTA DEALERSHIP AND HAS BEEN THERE FOR 4 WEEKS. THE SERVICE DEPARTMENT SAYS THEY CAN'T PERFORM ANY REPAIRS IF THEY ARE UNABLE TO REPLICATE THE MALFUNCTION. I AM LEFT WONDERING IF THE 2005-2008 RECALLS FOR THIS VERY ISSUES SHOULD INDEED BE EXPANDED TO INCLUDE THE 2009 AS WELL. *JS

Mileage: 65,000

ON HUMID MORNINGS, ENGINE OCCASIONALLY MISSES ON START UP THEN CLEARS. ENGINE STALLED WITH NO WARNING AND ALMOST CAUSED A REAR END COLLISION WHEN IT SUDDENLY LOST POWER ON ACCELERATION ONTO BUSY ROAD. NEXT MORNING ENGINE WOULD NOT START UNTIL LATER IN DAY AFTER WARMING UP. IT STARTED WITH EXTREME MISS THEN CLEARED. THE 08 MATRIX HAS AN ECM RECALL FOR SAME REASON HOWEVER NO NOTICE WAS RECEIVED FOR THE 09 MODEL MANUFACTURED ON 5/08. *TR

Mileage: 131,500